2009 Aprilia SCARABEO 500 problems and owner complaints

VEHICLE HAD AN IRREGULAR, LOW IDLE, STUTTERING, LACK OF POWER AND WAS VERY DIFFICULT TO START. SOMETIMES THE VEHICLE'S ENGINE WOULD DIE AT INTERSECTIONS WHILE IDLING. THE ENGINE STOPPING AT INTERSECTIONS IS DANGEROUS AND COULD CAUSE AN ACCIDENT OR DEATH. UPON INVESTIGATION, I REALIZED THAT THE ELECTRIC FUEL PUMP HOSE INSIDE THE FUEL TANK WAS LEAKING THEREFORE NOT SUPPLYING THE APPROPRIATE PRESSURE TO THE INJECTOR. I PURCHASED A NEW SUBMERSIBLE FUEL LINE AND TWO HOSE CLAMPS AND REPLACED THE LEAKING OEM FUEL HOSE. *TR

Look up ODI 10235504 at NHTSA ↗

AFTER RUNNING FOR A COUPLE HOURS IN HEAT, THE BIKE WILL STALL ANYTIME RPM'S FALL TO IDLE SPEEDS. THERE SEEMS AT THESE TIMES TO BE A BUILDUP OF EXCESS PRESSURE IN THE FUEL TANK BECAUSE REMOVING THE CAP WILL CAUSE AN OUTWARD FLOW OF AIR FROM THE TANK. OCCASIONALLY THIS FLOW IS STRONG ENOUGH TO FLIP THE FUEL CAP OUT OF MY HAND AS I REMOVE IT. LEAVING THE CAP NOT FULLY SECURED SEEMS TO PREVENT BOTH THE FUEL STARVATION AND THE BUILDUP OF PRESSURE. *TR

Look up ODI 10235514 at NHTSA ↗

THE MATERIAL USED FOR AN IN-TANK FUEL LINE DETERIORATES AND CAUSES A SUDDEN LOSS OF POWER. THE MANUFACTURER IS AWARE OF THE PROBLEM BUT WILL ONLY MAKE REPAIRS IF FORCED TO DO SO. *TR

Look up ODI 10235535 at NHTSA ↗

BOUGHT VEHICLE NEW ON 2/9/2012 FROM BARNEY'S MOTORCYCLE SALES INC AT 10411 GANDY BLVD, ST PETERSBURG, FL 33702. TOOK VEHICLE BACK FOR INITIAL 625 MILE INSPECTION ON 2/27/12. AT THAT TIME NOTED A STRONG ODOR OF GASOLINE UNDER THE SEAT, WHICH I HAD NOT PREVIOUSLY NOTICED. I HAD NOT RECENTLY FUELED THE SCOOTER, AND THERE WAS NO REASON FOR AN OVERFLOW. I REPORTED THE PROBLEM TO THE SERVICE MANAGER, WHO TOOK NOTICE OF IT AND WROTE IT ON THE REPAIR ORDER. I PICKED UP THE SCOOTER ON 2/29/12 AND STILL NOTICED VERY STRONG GASOLINE FUMES UNDER THE SEAT.…

Look up ODI 10450281 at NHTSA ↗

TL*THE CONTACT OWNS A 2006 APRILIA SCARABEO 500. THE HIGHBEAMS WERE ACTIVATED; HOWEVER, THEY WERE DIMMER THAN THE REGULAR HEADLIGHTS. THE DEALER STATED THAT THE WIRES WERE MESSED UP WHEN THE ABS FEATURE WAS ADDED. THERE WAS NO REMEDY FOR THE FAILURE. THE FAILURE MILEAGE WAS 100 AND CURRENT MILEAGE WAS 2,850. UPDATED 01/11/08. *LJ

Look up ODI 10207748 at NHTSA ↗

TL*THE CONTACT OWNS A 2006 APRILIA SCARABEO 500 (NA). THE CONTACT STATED THAT THE HIGH BEAM LIGHTS WERE VERY DIM LIKE A FLASHLIGHT. TWO DAYS AFTER PURCHASING THE VEHICLE, HE RETURNED TO THE DEALER TO FIND OUT WHY THE HIGH BEAMS WERE SO DIM AND DENSE. AFTER EXAMINING THE HIGH BEAMS, THE DEALER STATED THAT THERE WAS NO WAY TO ADJUST THEM AND MAKE THEM BRIGHTER. THE CURRENT MILEAGE IS 7,012 AND FAILURE MILEAGE WAS LESS THAN 100. UPDATED 01/11/08. *LJ UPDATED *JB

Look up ODI 10207776 at NHTSA ↗

TL*THE CONTACT OWNS A 2006 APRILIA SCARABEO 500 ABS SCOOTER. THE CONTACT STATED THAT THE ENGINE STALLED AT LOW SPEEDS, WHILE IDLING, IN STOP-AND-GO TRAFFIC, AND WHEN MAKING A LEFT TURN. HE ALSO STATED THAT THE HIGH BEAMS WERE DIMMER THAN THE LOW BEAMS. THE PURCHASE DATE AND NUMBER OF CYLINDERS WERE UNKNOWN. THE CURRENT MILEAGE WAS APPROXIMATELY 2,500 AND FAILURE MILEAGE WAS APPROXIMATELY 1,500. UPDATED 02-14-08 *BF THE CONSUMER STATED THE DEALER REPLACED FUEL LINE AND CLAMPS WHICH CORRECTED ENGINE STALLING PROBLEM. UPDATED 02/14/08 *T…

Look up ODI 10215236 at NHTSA ↗

AN IN-TANK FUEL LINE BETWEEN THE FUEL PUMP AND FILTER IS MISSING HOSE CLAMPS CAUSING FUEL PRESSURE LOSS AND ERRATIC ENGINE PERFORMANCE. STALLING AND SPUTTERING DURING MANEUVERS IN TRAFFIC CAN BE BEING VERY DANGEROUS ON A MOTORCYCLE OR ANY TWO WHEEL VEHICLE. THIS PROBLEM EFFECTS 2007 THROUGH 2008 APRILIA SCARABEO 500IE AND EARLIER YEAR MODELS. THUS FAR SOME (NOT MINE) DEALERS HAVE CORRECTED THIS UNDER WARRANTY ON A BY COMPLAINT BASES. MOST OF THESE FAILURES HAVE OCCURRED IN THE FIRST 1000 MILES. AN OBVIOUS DESIGN FLAW. I FEEL THE MANUFACTURE S…

Look up ODI 10236324 at NHTSA ↗