ON CERTAIN MOTOR HOMES, THE BRAKE ASSEMBLIES EXHIBIT ELEVATED TEMPERATURES THAT CAN LEAD TO CATASTROPHIC DETERIORATION OF THE WHEEL END COMPONENTS SUCH AS BEARINGS, RACES, SPINDLES, KNUCKLES, SEALS, HUBS, ROTORS, PATCH BOLTS, CALIPERS, BRAKE PADS, AND ABS SENSORS.
Consequence: THIS COULD RESULT IN LOSS OF CONTROL, AND/OR THE POTENTIAL FOR A FIRE.
Remedy: DEALERS WILL INSPECT THE FRONT AND REAR BRAKE CALIPERS FOR CORROSION AND REPLACE OR REBUILD THE CALIPERS AS NECESSARY. THE RECALL BEGAN ON AUGUST 18, 2004. OWNERS SHOULD CONTACT MONACO AT 1-800-685-6545.
Reported: 2003-05-08 (May 8, 2003) · Model years: 1998, 1999
ON CERTAIN MOTORHOMES, FIFTH WHEELS AND TRAVEL TRAILERS EQUIPPED WITH NORCOLD REFRIGERATOR COOLING UNITS MODEL NUMBERS 1200LR AND 1200RIM, THESE REFRIGERATORS CAN EXPERIENCE LOW CYCLE FATIGUE FAILURE WHICH CAN LEAD TO THE LIQUID SOLUTION SLOWLY LEAKING FROM THE SEALED, PRESSURIZED COOLING UNIT THROUGH A SMALL CRACK.
Consequence: IF A LEAK OCCURS AND THE UNIT IS CONTINUALLY OPERATED, HYDROGEN GAS MAY BE EXPELLED AND CAN BE IGNITED, RESULTING IN A FIRE, POSSIBLY CAUSING SERIOUS INJURY OR DEATH.
Remedy: NORCOLD WILL NOTIFY ITS CUSTOMERS AND PROVIDE A REPLACEMENT COOLING UNIT FREE OF CHARGE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NORCOLD SERVICE CENTER AT 1-800-667-3005 OR MONACO AT 574-862-7211.
ON CERTAIN MOTOR HOMES, FIFTH WHEEL AND TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION, THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
Consequence: RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.
Remedy: MONACO WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR MONACO AT 1-877-466-6226.
MONACO IS RECALLING CERTAIN MOTOR HOMES EQUIPPED WITH NORCOLD REFRIGERATORS. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK.
Consequence: EXTENDED OPERATION OF A LEAKING COOLING UNIT COULD LEAD TO A FIRE FROM GAS WHICH MIGHT ESCAPE.
Remedy: MONACO IS WORKING WITH NORCOLD TO REPAIR THESE REFRIGERATORS. NORCOLD WILL PROVIDE THERMAL SWITCH KITS TO OWNERS ALONG WITH THE NECESSARY FORMS AND INSTRUCTIONS. THE RECALL BEGAN ON AUGUST 29, 2008. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR MONACO AT 1-800-685-6545.
Reported: 2002-04-09 (April 9, 2002) · Model years: 2002
ON CERTAIN MOTOR HOMES EQUIPPED WITH ELECTRONIC THROTTLE CONTROL/ACCELERATOR PEDALS SUPPLIED BY WILLIAMS CONTROLS INDUSTRIES, THE WELD ATTACHING THE CLEVIS TO THE PLATE HAS INSUFFICIENT PENETRATION AND COULD ALLOW THE CLEVIS TO SEPARATE FROM THE PLATE.
Consequence: IF THE CLEVIS SEPARATED FROM THE PLATE WHILE THE VEHICLE WAS IN USE, THE VEHICLE WOULD RETURN TO IDLE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THESE PEDALS. OWNER NOTIFICATION BEGAN SEPTEMBER 9, 2002. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MONACO AT 1-800-344-6332 OR WILLIAMS CONTROL AT 1-503-684-8600.
Inspect model-year patterns, reported mileage, monthly activity and the evidence behind each signal.
Data completeness
14 unique complaints in this selection. Analysis snapshot: 2026-10-01.
64.3%Usable mileage9 / 14 records
100.0%Valid incident date14 / 14 records
100.0%Valid filing date14 / 14 records
100.0%Ordered incident and filing dates14 / 14 records
Missing, zero and invalid mileage is excluded. Dates after the snapshot are excluded. Examples are limited selections, not a representative sample.
Problems by model year
Model-wide comparison of the eight most reported components across the model. Cells show counts and shares within each model year. Open a cell for source examples.
Component complaint heatmap
Component
1998
1999
2000
2001
2002
Equipment
0Unavailable
No examples available for this selection.
120.0%ODI 10247974 · 82,383 mi
WHILE HAVING A MODIFICATION DONE TO THE REFRIGERATOR ON A NORCOLD RECALL, I LOOKED INSIDE THE COMPARTMENT WHERE THE REFRIGERATOR RESIDES. ON THE CEILING, NEAR THE VENT OPENING, I NOTICED A CHARRED AREA IN THE CEILING MATERIAL, A WOOD PANELING. THE CHARRED AREA WAS ACTUALLY BURNED THROUGH THE WOOD PANELING AND INTO THE STYRENE INSULATION ABOVE. I DISCOVERED THE CHARRED AREA WAS ROUND, ABOUT 2" IN DIAMETER, AND DIRECTLY ABOVE WHERE THE FLUE PIPE FOR THE PROPANE COMBUSTION IN THE REFRIGERATOR ENDED. THE FLUE PIPE ENDS ABOUT 3" BELOW THE CEILING MA…
DT*: THE CONTACT STATED THAT THE REAR JACK ON DRIVER SIDE DETACHED DURING AUTOMATIC LEVELING OF THE VEHICLE AND COLLIDED WITH THE DRIVE SHAFT. INSPECTORS FROM THE DEPARTMENT OF TRANSPORTATION INSPECTED THE VEHICLE, AND DETERMINED THAT THE FAILURE WAS A RESULT OF THE SEPARATION OF THE MOUNTING BRACKET DUE TO SUPERFICIAL AND SPOTTY WELDING. THE MOUNTING BRACKET WAS OBSERVED TO HAVE ROUGH EDGES RESULTING IN POOR CONTACT WITH THE CHASSIS. THE REMAINING JACKS WERE OBSERVED TO BE IN THE SAME CONDITION DUE TO THE IDENTICAL WELDING OF THE DEFECTIVE…
I HAVE 2002 BEAVER CONTESSA MOTORHOME WITH A 330 CATAPILLAR ENGINE. RECENTLY I EXPERIENCED A PROBLEM WITH MY ALTERNATOR WHICH TURNED OUT TO BE A BURNED WIRE IN THE WIRE HARNESS. THE WIRE CONNECTED FROM THE ALTERNATOR I TERMINAL TO THE STARTER RELAY. THE FIRE BURNED SEVERAL OTHER WIRES IN THE HARNESS AND SHORTED THE RADIO AND TWO GAUGES. THE WIRE COMPLETELY BURNED THROUGH BEFORE ADDITIONAL DAMAGE WAS DONE. *JB
I HAVE 2002 BEAVER CONTESSA MOTORHOME WITH A 330 CATAPILLAR ENGINE. RECENTLY I EXPERIENCED A PROBLEM WITH MY ALTERNATOR WHICH TURNED OUT TO BE A BURNED WIRE IN THE WIRE HARNESS. THE WIRE CONNECTED FROM THE ALTERNATOR I TERMINAL TO THE STARTER RELAY. THE FIRE BURNED SEVERAL OTHER WIRES IN THE HARNESS AND SHORTED THE RADIO AND TWO GAUGES. THE WIRE COMPLETELY BURNED THROUGH BEFORE ADDITIONAL DAMAGE WAS DONE. *JB
DT: HAVE HAD FOUR RADIATOR FAILURES. WHERE THE CORE PIPES THAT JOINS THE MANIFOLD LEAKS. DEALERSHIP HAS REPLACED THE RADIATOR FOUR TIMES, THEY STILL CANNOT PINPOINT THE PROBLEM. JANUARY OF 2005 WAS THE LAST TIME IT WAS REPLACED. RADIATOR AS OF RIGHT NOW IS STILL WORKING BUT HAVE A DOCUMENT OF MY COMPLAINT. ITS A MOTOR HOME ITS A MONACO, KNIGHT 30J. *NM
WHILE HAVING A MODIFICATION DONE TO THE REFRIGERATOR ON A NORCOLD RECALL, I LOOKED INSIDE THE COMPARTMENT WHERE THE REFRIGERATOR RESIDES. ON THE CEILING, NEAR THE VENT OPENING, I NOTICED A CHARRED AREA IN THE CEILING MATERIAL, A WOOD PANELING. THE CHARRED AREA WAS ACTUALLY BURNED THROUGH THE WOOD PANELING AND INTO THE STYRENE INSULATION ABOVE. I DISCOVERED THE CHARRED AREA WAS ROUND, ABOUT 2" IN DIAMETER, AND DIRECTLY ABOVE WHERE THE FLUE PIPE FOR THE PROPANE COMBUSTION IN THE REFRIGERATOR ENDED. THE FLUE PIPE ENDS ABOUT 3" BELOW THE CEILING MA…
PARKING BRAKE ON BEAVER PATRIOT THUNDER MOTOR HOME BECAME DETACHED CAUSING INABILITY TO KEEP VEHICLE FROM MOVING WHEN STOPPED FOR EMERGENCY OR PARKING. *JB
MY BRAKES STARTED SMOKING WHILE MOVING. IFOUND OUT THEIR WAS A RECALL YEARS AGO ABOUT THIS PROBLEM. I CALLED MONACO AND THEY TOLD ME THAT THEY NO LONGER HONOR THIS RECALL, MONACO STATED TO ME THAT WHEN THEY BOUGHT THE BANKRUPT COMPANY BEAVER MOTOR COACHES THAT THEY MADE A DEAL THAT IF THEY BOUGHT THE COMPANY THE RECALL DID NOT COME WITH THE COMPANY, THE RECALL WAS ON CATASTROPHIC CALIPER PROBLEMS.
Service Brakes, Air:Supply:Hoses, Lines/Piping, And Fittings
0Unavailable
No examples available for this selection.
00.0%
No examples available for this selection.
00.0%
No examples available for this selection.
00.0%
No examples available for this selection.
125.0%ODI 10184227 · 34,000 mi
THE RIGHT FRONT BRAKE LINE WAS CUT BY THE HYDRAULIC JACK FOR THE LEVELING SYSTEM. ALL THE FLUID RAN OUT WHEN THE BRAKES WERE APPLIED. NO BRAKE WARNING LIGHTS CAME ON, SO DRIVER WAS NOT AWARE OF THE PROBLEM AND DROVE FOR SEVERAL DAYS UNTIL IT WAS FOUND BY INSPECTION. APPARENTLY, THE FRONT BRAKES ARE INDEPENDENT OF THE REAR BRAKES, SO THE PEDAL REMAINED NORMAL WHEN APPLIED. *JB
Darker cells indicate a larger share of submitted complaints. Components overlap. This measures complaint composition, not failure probability.
Failure mileage by component
Median and middle 50% of usable owner-reported mileages. Ranges require at least five records.
Component failure mileage distribution
Component
Mileage range (25th–75th percentile)
Median
Usable records
Examples
Equipment
Too few reports for a range
60,192 mi
2 (sparse)
ODI 10247974 · 82,383 mi
WHILE HAVING A MODIFICATION DONE TO THE REFRIGERATOR ON A NORCOLD RECALL, I LOOKED INSIDE THE COMPARTMENT WHERE THE REFRIGERATOR RESIDES. ON THE CEILING, NEAR THE VENT OPENING, I NOTICED A CHARRED AREA IN THE CEILING MATERIAL, A WOOD PANELING. THE CHARRED AREA WAS ACTUALLY BURNED THROUGH THE WOOD PANELING AND INTO THE STYRENE INSULATION ABOVE. I DISCOVERED THE CHARRED AREA WAS ROUND, ABOUT 2" IN DIAMETER, AND DIRECTLY ABOVE WHERE THE FLUE PIPE FOR THE PROPANE COMBUSTION IN THE REFRIGERATOR ENDED. THE FLUE PIPE ENDS ABOUT 3" BELOW THE CEILING MA…
DT*: THE CONTACT STATED THAT THE REAR JACK ON DRIVER SIDE DETACHED DURING AUTOMATIC LEVELING OF THE VEHICLE AND COLLIDED WITH THE DRIVE SHAFT. INSPECTORS FROM THE DEPARTMENT OF TRANSPORTATION INSPECTED THE VEHICLE, AND DETERMINED THAT THE FAILURE WAS A RESULT OF THE SEPARATION OF THE MOUNTING BRACKET DUE TO SUPERFICIAL AND SPOTTY WELDING. THE MOUNTING BRACKET WAS OBSERVED TO HAVE ROUGH EDGES RESULTING IN POOR CONTACT WITH THE CHASSIS. THE REMAINING JACKS WERE OBSERVED TO BE IN THE SAME CONDITION DUE TO THE IDENTICAL WELDING OF THE DEFECTIVE…
WHILE HAVING A MODIFICATION DONE TO THE REFRIGERATOR ON A NORCOLD RECALL, I LOOKED INSIDE THE COMPARTMENT WHERE THE REFRIGERATOR RESIDES. ON THE CEILING, NEAR THE VENT OPENING, I NOTICED A CHARRED AREA IN THE CEILING MATERIAL, A WOOD PANELING. THE CHARRED AREA WAS ACTUALLY BURNED THROUGH THE WOOD PANELING AND INTO THE STYRENE INSULATION ABOVE. I DISCOVERED THE CHARRED AREA WAS ROUND, ABOUT 2" IN DIAMETER, AND DIRECTLY ABOVE WHERE THE FLUE PIPE FOR THE PROPANE COMBUSTION IN THE REFRIGERATOR ENDED. THE FLUE PIPE ENDS ABOUT 3" BELOW THE CEILING MA…
PARKING BRAKE ON BEAVER PATRIOT THUNDER MOTOR HOME BECAME DETACHED CAUSING INABILITY TO KEEP VEHICLE FROM MOVING WHEN STOPPED FOR EMERGENCY OR PARKING. *JB
MY BRAKES STARTED SMOKING WHILE MOVING. IFOUND OUT THEIR WAS A RECALL YEARS AGO ABOUT THIS PROBLEM. I CALLED MONACO AND THEY TOLD ME THAT THEY NO LONGER HONOR THIS RECALL, MONACO STATED TO ME THAT WHEN THEY BOUGHT THE BANKRUPT COMPANY BEAVER MOTOR COACHES THAT THEY MADE A DEAL THAT IF THEY BOUGHT THE COMPANY THE RECALL DID NOT COME WITH THE COMPANY, THE RECALL WAS ON CATASTROPHIC CALIPER PROBLEMS.
Service Brakes, Air:Supply:Hoses, Lines/Piping, And Fittings
Too few reports for a range
34,000 mi
1 (sparse)
ODI 10184227 · 34,000 mi
THE RIGHT FRONT BRAKE LINE WAS CUT BY THE HYDRAULIC JACK FOR THE LEVELING SYSTEM. ALL THE FLUID RAN OUT WHEN THE BRAKES WERE APPLIED. NO BRAKE WARNING LIGHTS CAME ON, SO DRIVER WAS NOT AWARE OF THE PROBLEM AND DROVE FOR SEVERAL DAYS UNTIL IT WAS FOUND BY INSPECTION. APPARENTLY, THE FRONT BRAKES ARE INDEPENDENT OF THE REAR BRAKES, SO THE PEDAL REMAINED NORMAL WHEN APPLIED. *JB
Explore monthly filing activity alongside recall announcements. Up to ten years of monthly history is available.
Solid line: filed complaints. Dashed amber lines: recall announcement dates for this vehicle selection; markers include all recall components. The latest month is partial. Temporal proximity does not establish causation.
Monthly counts, recall campaigns and complaint examples
Monthly complaint and recall timeline
Month
Complaints
Campaigns announced
Examples
2024-11
0
None
No examples available for this selection.
2024-12
0
None
No examples available for this selection.
2025-01
0
None
No examples available for this selection.
2025-02
0
None
No examples available for this selection.
2025-03
0
None
No examples available for this selection.
2025-04
0
None
No examples available for this selection.
2025-05
0
None
No examples available for this selection.
2025-06
0
None
No examples available for this selection.
2025-07
0
None
No examples available for this selection.
2025-08
0
None
No examples available for this selection.
2025-09
0
None
No examples available for this selection.
2025-10
0
None
No examples available for this selection.
2025-11
0
None
No examples available for this selection.
2025-12
0
None
No examples available for this selection.
2026-01
0
None
No examples available for this selection.
2026-02
0
None
No examples available for this selection.
2026-03
0
None
No examples available for this selection.
2026-04
0
None
No examples available for this selection.
2026-05
0
None
No examples available for this selection.
2026-06
0
None
No examples available for this selection.
2026-07
0
None
No examples available for this selection.
2026-08
0
None
No examples available for this selection.
2026-09
0
None
No examples available for this selection.
2026-10 (partial)
0
None
No examples available for this selection.
Emerging complaint spikes
Complete months in the latest six months with at least 10 complaints, at least twice the preceding 12-month average, and at least three square-root deviations above that average.
This is a descriptive screening rule, not a statistical defect finding. Publicity and reporting changes can increase submissions.
No complete months meet the spike thresholds for this selection.
Equal-age model-year comparison
Model-wide cumulative reports during the first three or five calendar years, starting with the model year (age 0). Only fully elapsed windows are compared.
2001: 0 complaints · 2002: 0 complaints
Equal observation windows
Model year
Through age 0
Through age 1
Through age 2
2001
0
0
0
2002
0
0
0
Date coverage across each selected cohort
Date basis for all complaints in selected model years
Year
Incident dates used
Filing date fallbacks
Excluded dates
2001
2
0
2
2002
4
0
0
Incident date is preferred when valid and no later than filing; otherwise filing date is used. Model year approximates age. Equal observation time does not adjust for sales, distance driven or reporting delays. One complaint linked to multiple model years can appear in each cohort.
Components reported together
Each cell counts unique complaints naming both components. Open a nonzero cell for examples.
Component co-occurrence matrix
Component
Equipment
Electrical System:Alternator/Generator/Regulator
Electrical System:Wiring:Front Underhood
Engine And Engine Cooling:Cooling System
Equipment:Recreational Vehicle/Trailer
Parking Brake:Conventional:Air
Service Brakes
Service Brakes, Air:Supply:Hoses, Lines/Piping, And Fittings
Equipment
—
0
0
0
1ODI 10247974 · 82,383 mi
WHILE HAVING A MODIFICATION DONE TO THE REFRIGERATOR ON A NORCOLD RECALL, I LOOKED INSIDE THE COMPARTMENT WHERE THE REFRIGERATOR RESIDES. ON THE CEILING, NEAR THE VENT OPENING, I NOTICED A CHARRED AREA IN THE CEILING MATERIAL, A WOOD PANELING. THE CHARRED AREA WAS ACTUALLY BURNED THROUGH THE WOOD PANELING AND INTO THE STYRENE INSULATION ABOVE. I DISCOVERED THE CHARRED AREA WAS ROUND, ABOUT 2" IN DIAMETER, AND DIRECTLY ABOVE WHERE THE FLUE PIPE FOR THE PROPANE COMBUSTION IN THE REFRIGERATOR ENDED. THE FLUE PIPE ENDS ABOUT 3" BELOW THE CEILING MA…
I HAVE 2002 BEAVER CONTESSA MOTORHOME WITH A 330 CATAPILLAR ENGINE. RECENTLY I EXPERIENCED A PROBLEM WITH MY ALTERNATOR WHICH TURNED OUT TO BE A BURNED WIRE IN THE WIRE HARNESS. THE WIRE CONNECTED FROM THE ALTERNATOR I TERMINAL TO THE STARTER RELAY. THE FIRE BURNED SEVERAL OTHER WIRES IN THE HARNESS AND SHORTED THE RADIO AND TWO GAUGES. THE WIRE COMPLETELY BURNED THROUGH BEFORE ADDITIONAL DAMAGE WAS DONE. *JB
I HAVE 2002 BEAVER CONTESSA MOTORHOME WITH A 330 CATAPILLAR ENGINE. RECENTLY I EXPERIENCED A PROBLEM WITH MY ALTERNATOR WHICH TURNED OUT TO BE A BURNED WIRE IN THE WIRE HARNESS. THE WIRE CONNECTED FROM THE ALTERNATOR I TERMINAL TO THE STARTER RELAY. THE FIRE BURNED SEVERAL OTHER WIRES IN THE HARNESS AND SHORTED THE RADIO AND TWO GAUGES. THE WIRE COMPLETELY BURNED THROUGH BEFORE ADDITIONAL DAMAGE WAS DONE. *JB
WHILE HAVING A MODIFICATION DONE TO THE REFRIGERATOR ON A NORCOLD RECALL, I LOOKED INSIDE THE COMPARTMENT WHERE THE REFRIGERATOR RESIDES. ON THE CEILING, NEAR THE VENT OPENING, I NOTICED A CHARRED AREA IN THE CEILING MATERIAL, A WOOD PANELING. THE CHARRED AREA WAS ACTUALLY BURNED THROUGH THE WOOD PANELING AND INTO THE STYRENE INSULATION ABOVE. I DISCOVERED THE CHARRED AREA WAS ROUND, ABOUT 2" IN DIAMETER, AND DIRECTLY ABOVE WHERE THE FLUE PIPE FOR THE PROPANE COMBUSTION IN THE REFRIGERATOR ENDED. THE FLUE PIPE ENDS ABOUT 3" BELOW THE CEILING MA…
Service Brakes, Air:Supply:Hoses, Lines/Piping, And Fittings
0
0
0
0
0
0
0
—
Co-reporting does not establish that one component caused another concern.
Recurring narrative patterns
Specific keyword mentions beyond broad component labels. Matching includes negations and comparisons and does not confirm a diagnosis.
1 patterns with matching reports.
Warning lights and dashboard alerts
1 mentions · 7.1% of complaints
Median mileage: 34,000 mi (1 usable records).
ODI 10184227 · 34,000 mi
THE RIGHT FRONT BRAKE LINE WAS CUT BY THE HYDRAULIC JACK FOR THE LEVELING SYSTEM. ALL THE FLUID RAN OUT WHEN THE BRAKES WERE APPLIED. NO BRAKE WARNING LIGHTS CAME ON, SO DRIVER WAS NOT AWARE OF THE PROBLEM AND DROVE FOR SEVERAL DAYS UNTIL IT WAS FOUND BY INSPECTION. APPARENTLY, THE FRONT BRAKES ARE INDEPENDENT OF THE REAR BRAKES, SO THE PEDAL REMAINED NORMAL WHEN APPLIED. *JB