Beaver Coach PATRIOT recalls by model year

Reported: 2007-09-06 (September 6, 2007) · Model years: 1998, 1999, 2000, 2001, 2002

ON CERTAIN MOTOR HOMES, FIFTH WHEEL AND TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION, THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Consequence: RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.

Remedy: MONACO WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR MONACO AT 1-877-466-6226.

Reported: 2008-06-05 (June 5, 2008) · Model years: 1999, 2000, 2001, 2002

MONACO IS RECALLING CERTAIN MOTOR HOMES EQUIPPED WITH NORCOLD REFRIGERATORS. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK.

Consequence: EXTENDED OPERATION OF A LEAKING COOLING UNIT COULD LEAD TO A FIRE FROM GAS WHICH MIGHT ESCAPE.

Remedy: MONACO IS WORKING WITH NORCOLD TO REPAIR THESE REFRIGERATORS. NORCOLD WILL PROVIDE THERMAL SWITCH KITS TO OWNERS ALONG WITH THE NECESSARY FORMS AND INSTRUCTIONS. THE RECALL BEGAN ON AUGUST 29, 2008. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR MONACO AT 1-800-685-6545.

Reported: 2004-07-06 (July 6, 2004) · Model years: 2003

CERTAIN MOTORHOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 104, 'WINDSHIELD WIPING AND WASHING SYSTEMS.' THE WINDSHIELD WIPER ASSEMBLY WAS INSTALLED WITHOUT PROPER SUPPORT ALLOWING THE WIPER ASSEMBLY TO BIND AND/OR BREAK.

Consequence: THIS FAILURE COULD RESULT IN INADEQUATE VISIBILITY IN ADVERSE WEATHER CONDITIONS, WHICH COULD LEAD TO INJURY OR A CRASH COULD OCCUR WITHOUT WARNING.

Remedy: DEALERS WILL INSTALL A NEW STYLE OF WIPER ASSEMBLY AND ADD SUPPORT FOR THE NEW WIPER ASSEMBLY. THE RECALL BEGAN ON JULY 23, 2004. OWNERS SHOULD CONTACT MONACO AT 1-800-685-6545.

Reported: 2004-08-10 (August 10, 2004) · Model years: 2004

CERTAIN MOTOR HOMES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, 'TIRE SELECTION AND RIMS.' THE FEDERAL IDENTIFICATION LABELS CONTAINS INCORRECT INFORMATION REGARDING THE RIM SIZE AND TIRE INFLATION RATING AS WELL AS AN INCORRECT RATING FOR THE GROSS VEHICLE WEIGHT RATING (GVWR) AND FRONT GROSS AXLE WEIGHT RATING (GAWR).

Consequence: THIS MISPRINT COULD LEAD TO AN INCORRECT RIM BEING PLACED ON THE UNIT THAT WOULD NOT BE RATED FOR THE GAWR, IN ADDITION TO OVERLOADING THE UNIT AND OVER-INFLATING THE TIRES. DRIVING WITH OVER-INFLATED TIRES CAN CAUSE OR CONTRIBUTE TO PREMATURE TIRE FAILURE THAT COULD RESULT IN A LOSS OF CONTROL OF THE VEHICLE, INCREASING THE RISK OF A CRASH.

Remedy: OWNERS WILL BE PROVIDED WITH A CORRECTED FEDERAL IDENTIFICATION LABEL AND INSTALLATION INSTRUCTIONS. IF AN OWNER WISHES, A DEALER CAN PLACE THE LABEL ON FOR THEM. THE RECALL BEGAN ON AUGUST 30, 2004. OWNERS SHOULD CONTACT MONACO AT 1-800-685-6545.

Reported: 2006-11-08 (November 8, 2006) · Model years: 2006

ON CERTAIN MOTOR HOMES, AN IMPROPER NUT AND BOLT COMBINATION WAS USED TO CLAMP THE INTERMEDIATE SHAFT ONTO THE STEERING SHAFT. WITHOUT THE PROPER NUT AND BOLT COMBINATION, THE NUT CAN LOOSEN PREMATURELY AND ALLOW THE BOLT TO COME OUT WHICH COULD ALLOW THE INTERMEDIATE SHAFT TO BECOME DISCONNECTED FROM THE STEERING COLUMN SHAFT.

Consequence: LOSS OF STEERING CONTROL COULD OCCUR, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT THE NUT AND BOLT COMBINATION. IF THE IMPROPER COMBINATION IS INSTALLED, DEALERS WILL REPLACE IT WITH A NEW NUT AND BOLT. IF THE COMBINATION IS CORRECT, DEALERS WILL RE-TORQUE THE EXISTING COMBINATION. THE RECALL BEGAN ON NOVEMBER 21, 2006. OWNERS MAY CONTACT MONACO AT 1-800--685-6545.

Reported: 2006-11-29 (November 29, 2006) · Model years: 2007

ON CERTAIN CLASS A MOTOR HOMES, THE WINDSHIELD WIPER MOTORS ARE UNDER-FUSED AND THE FUSE MAY FAIL.

Consequence: IF THE FUSE FAILS, THE WINDSHIELD WIPERS WILL STOP FUNCTIONING WHICH WOULD RESULT IN A DECREASE OF THE VISIBILITY OF THE OPERATOR AND COULD RESULT IN A CRASH.

Remedy: DEALERS WILL INSTALL A NEW 15 AMP AUTO RESETTING CIRCUIT BREAKER FUSE ON THE VEHICLE. THE RECALL BEGAN ON DECEMBER 15, 2006. OWNERS MAY CONTACT MONACO AT 1-800-685-6545.

Reported: 2007-12-20 (December 20, 2007) · Model years: 2008

ON CERTAIN CLASS A MOTOR HOMES EQUIPPED WITH TRW STEERING GEARS, MODELS TAS85 AND RCS85, THESE STEERING GEARS CONTAIN POTENTIALLY DEFECTIVE SECTOR SHAFTS WITH AN INCORRECT GEAR TOOTH WHICH MAY INTERFERE WITH THE RACK-PISTON TEETH, RESULTING IN A STICK OR BIND CONDITION.

Consequence: THIS CONDITION HAS THE POTENTIAL TO CAUSE THE STEERING GEAR TO STALL AND RESTRICT THE STEERING TURNING ANGLE OF THE VEHICLE WHICH COULD RESULT IN A VEHICLE CRASH.

Remedy: MONACO IS WORKING WITH TRW TO REPLACE THE DEFECTIVE STEERING GEAR (PLEASE SEE 07E101). THE RECALL BEGAN ON JANUARY 24, 2008. OWNERS MAY CONTACT MONACO AT 1-800-685-6545 OR TRW AT 1-765-429-1768.

Reported: 2010-06-25 (June 25, 2010) · Model years: 2008, 2009, 2010

KONGSBERG POWER PRODUCTS SYSTEMS I, INC., (KPPS) IS RECALLING ON BEHALF OF MONACO COACH CERTAIN MODEL YEAR 2008-2010 MOTOR HOMES MANUFACTURED AFTER APRIL 2007 AND EQUIPPED WITH PNEUMATIC AND HYDRAULIC ADJUSTABLE BRAKE PEDAL ASSEMBLIES SUPPLIED BY KPPS. THE DRIVE PIN WHICH SECURES THE BRAKE PEDAL ARM TO THE BALANCE OF THE ASSEMBLY MAY BECOME DISENGAGED, THIS MAY CAUSE A REDUCTION IN VEHICLE BRAKING AND/OR CAUSE THE BRAKE PEDAL TO MOVE OUT OF POSITION AND INTERFERE WITH THROTTLE PEDAL FUNCTION.

Consequence: A REDUCTION IN BRAKING OR INTERFERENCE WITH THE THROTTLE PEDAL COULD RESULT IN A CRASH.

Remedy: KPPS WILL PROVIDE A CLAMP ASSEMBLY KIT ALONG WITH INSTALLATION INSTRUCTIONS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 16, 2010. OWNERS MAY CONTACT KPPS AT 1-877-485-6647.

Reported: 2010-01-20 (January 20, 2010) · Model years: 2009

NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2008-2009 BEAVER CONTESSA, MODEL YEAR 2009 BEAVER MARQUIS, PATRIOT, MONTEREY, MODEL YEAR 2009-2010 HOLIDAY RAMBLER AMBASSADOR, MODEL YEAR 2010-2011 HOLIDAY RAMBLER ENDEAVOR, MODEL YEAR 2009-2010 HOLIDAY RAMBLER IMPERIAL, MODEL YEAR 2010 HOLIDAY RAMBLER NAVIGATOR, AND SCEPTOR, MODEL YEAR 2010 MONACO CAMELOT MODEL YEAR 2010-2011 MONACO DIPLOMAT, MODEL YEAR 2010 MONACO DYNASTY, MODEL YEAR 2009-2010 MONACO KNIGHT AND MODEL YEAR 2010 MONACO SIGNATURE MANUFACTURED FROM JANUARY 22, 2008 THROUGH OCTOBER 27, 2009 ON BEHALF OF MONACO RV WITH KONGSBERG POWER PRODUCTS SYSTEMS ADJUSTABLE BRAKE PEDALS. THE DRIVE PIN WHICH SECURES THE BRAKE PEDAL ARM TO THE BALANCE OF THE ASSEMBLY MAY BECOME DISENGAGED, THIS MAY CAUSE A REDUCTION IN VEHICLE BRAKING AND/OR CAUSE THE BRAKE PEDAL TO MOVE OUT OF POSITION AND INTERFERE WITH THROTTLE PEDAL FUNCTION.

Consequence: A REDUCTION IN BRAKING OR INTERFERENCE WITH THE THROTTLE PEDAL COULD RESULT IN A VEHICLE CRASH.

Remedy: NAVISTAR IS WORKING WITH KONGSBERG PLEASE SEE KONGSBERG DEFECT REPORT 09E-064. NAVISTAR WILL RECEIVE KITS AND WILL INSPECT AND INSTALL A C-CLAMP ON THE ADJUSTABLE BRAKE PEDAL. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 4, 2010. OWNERS MAY CONTACT NAVISTAR AT 1-800-685-6545.

Reported: 2011-11-17 (November 17, 2011) · Model years: 2009

NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2009-2011 BEAVER, HOLIDAY RAMBLER AND MONACO COACH BRAND RECREATIONAL VEHICLES MANUFACTURED FROM JANUARY 11, 2008, THROUGH APRIL 15, 2011. SEE THE ABOVE LIST FOR MODELS. THE FRONT WINDSHIELD SHADE MAY SEPARATE FROM THE CABIN BODY WITHOUT WARNING, POSSIBLY IMPAIRING THE DRIVER'S ABILITY TO SEE THE ROADWAY.

Consequence: AN IMPAIRMENT TO A DRIVER'S ABILITY TO SEE THE ROADWAY COULD CAUSE A VEHICLE CRASH POTENTIALLY RESULTING IN PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH.

Remedy: NAVISTAR WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT THE SHADE MOUNTING CLIPS AND REPAIR THE VEHICLES AS NECESSARY FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DECEMBER 10, 2011.OWNERS MAY CONTACT NAVISTAR AT 1-877-466-6226.