2016 Blue Bird VISION problems and owner complaints

BRAKE LIGHTS MAY REMAIN ILLUMINATED AFTER BRAKE PEDAL HAS BEEN RELEASED. WHEN DRIVING, "MISSING BRAKE INPUT" FAULT CODE MAY BE DISPLAYED. HAS SIMILAR SYMPTOMS OF PREVIOUS RECALL R13WG.

Look up ODI 11046297 at NHTSA ↗

SCHOOL BUS DRIVER REPORTED AN OIL LEAK AT THE REAR OF THE LEFT SIDE VALVE COVER. I INSPECTED THE BUS AND SAW A LOT OF OIL ON THE FRAME AREA ON THE LEFT SIDE ENGINE AREA. CHECKED THE VALVE COVER BOLTS FOR TIGHTNESS AND FOUND THE BOLTS TO BE TIGHT. AT THE REAR OF THIS VALVE COVER THE AREA IS VERY TIGHT AND THERE ARE HOSES AND WIRES RAN BETWEEN THE VALVE COVER AND THE FIREWALL. I WAS ABLE TO PHYSICALLY MOVE THESE AND FEEL AROUND THE AREA AND DISCOVERED THAT A HOLE HAS BEEN RUBBED COMPLETELT THROUGH THE FIREWALL, THIS IS WHERE THE OIL IS COMING FR…

Look up ODI 11311782 at NHTSA ↗

VEHICLE FLIPS COMPRESSOR BELTS OFF FREQUENTLY BRAKE PEDDLE SWITCH FAILS AND BENDS MOUNTING BRACKETS CAUSING BRAKE LIGHT FAILURE AND VEHICLE TO GO INTO DERATE MODE IN MOTION FOR BOTH. */BF.. *DT *DT*JB *TR*JB *DT*JB *DT

Look up ODI 11163621 at NHTSA ↗

HEADLIGHTS HAVE A REFLECTOR OVER THE 9007 TYPE BULB THAT IS HELD ON BY AN UPPER AND LOWER SCREW. DURING INSPECTION, IT WAS NOTED THAT THE UPPER SCREWS OF BOTH LEFT AND RIGHT HEADLIGHTS CAME OUT. SHORTLY THEREAFTER, THE LOWER SCREW OF THE LEFT HEADLIGHT CAME OUT, LEAVING THE REFLECTOR LYING LOOSE INSIDE. THIS NECESSITATED PURCHASING A NEW HEADLIGHT. THIS EXACT SAME PROBLEM IS ALSO OCCURRING ON OUR OTHER BUS OF THIS TYPE, THAT IS VIN NUMBER PRIOR. THE NEW HEADLIGHT PURCHASED DOES NOT USE THE SCREWS, BUT INSTEAD HAS A REFLECTOR THAT LOOKS LIKE …

Look up ODI 11123880 at NHTSA ↗

A 2009 BLUEBIRD VISION SCHOOL BUS DEVELOPED A FUEL (DIESEL) LEAK AND CAUGHT FIRE. IT FULLY ENGULFED THE BUS BURNING IT TO A TOTAL LOSS. ONE SPECIAL NEEDS STUDENT, A TRANSPORTATION AIDE, AND THE DRIVER WERE ON BOARD. ALL EVACUATED SAFELY. WE RECENTLY RECEIVED 46 OF THESE BUSES (ALL CONFIGURED THE SAME) AND WE HAVE HAD 8 INCIDENTS OF FUEL LEAKS INVOLVING 6 OF THESE UNITS, NOT INCLUDING THE BUS WHICH CAUGHT FIRE. OUR DISTRICT HAS MET WITH BLUEBIRD AND CATERPILLAR (ENGINE SUPPLIER) AND LOOKED AT THE BURNED UNIT. WE ARE WAITING FOR THEIR COMMENTS …

Look up ODI 10269625 at NHTSA ↗

FAILURE OF THE PROPORTIONING VALVE WHICH IS CAUSING PREMATURE BRAKE PAD WEAR ON THE REAR. THE VEHICLE HAS AIR DISC BRAKES. WE HAVE SEVERAL IN OUR FLEET THAT HAS THIS ISSUE. WE BROUGHT THE BUS IN FOR SERVICE AND UPON INSPECTING THE BRAKES WE DISCOVERED THE ISSUE. WE HAVE CONTACTED THE COMPANY WE PURCHASED THE BUSES FROM AND I WAS TOLD THEY KNEW THERE WAS AN ISSUE AND THEY HAD A FIX BUT IT WOULD COST US $250. MY QUESTION IS WHO APPROVED THE FIX AND WHERE CAN I FIND IT IN WRITING. THEY ARE NOT REPLACING THE VALVE, THEY ARE PUTTING ON A QUICK REL…

Look up ODI 11110684 at NHTSA ↗

VEHICLE FLIPS COMPRESSOR BELTS OFF FREQUENTLY BRAKE PEDDLE SWITCH FAILS AND BENDS MOUNTING BRACKETS CAUSING BRAKE LIGHT FAILURE AND VEHICLE TO GO INTO DERATE MODE IN MOTION FOR BOTH. */BF.. *DT *DT*JB *TR*JB *DT*JB *DT

Look up ODI 11163621 at NHTSA ↗

TL*THE SCHOOL OWNS A 2008 BLUE BIRD VISION SCHOOL BUS. THE SCHOOL BUS WAS INSPECTED BY THE DEALER BECAUSE IT WAS VIBRATING. WHILE DRIVING GREATER THAN 60 MPH, ONE OF THE FRONT WHEELS WOULD RUB AGAINST AND RUPTURE THE BRAKE LINE. THE CURRENT AND FAILURE MILEAGES WERE 3,422.

Look up ODI 10239186 at NHTSA ↗

OUR BUS OPERATOR REPORTED THAT WHEN SHE WAS STOPPING FOR A TRAFFIC SIGNAL THE BRAKE PEDAL SUDDENLY WENT TO THE FLOOR, SHE PUT THE EMERGENCY BRAKE ON TO STOP THE BUS. THE BUS WAS TAKEN TO OUR MAINTENANCE SHOP, OUR MAINTENANCE SUPERVISOR TESTED THE BRAKES, HE ALSO REPORTED THAT WITH THE BUS IN REVERSE HE STEPPED ON THE BRAKE AND IT DID NOT APPLY THE BRAKES, HE HAD TO PULL THE EMERGENCY BRAKE. WE TRIED TO DUPLICATE THE PROBLEM AGAIN AND WERE NOT ABLE TO. WE CONTACTED OUR BLUE BIRD BUS DEALER AND SENT THE BUS TO THEM. *TR

Look up ODI 10325049 at NHTSA ↗

BODY STRUCTURE BROKEN OR CRACKED AT A-PILLAR AND SEVERAL OTHER LOCATIONS ON LEFT SIDE. ROOF BOW CRACKED AT SIDE EMERGENCY EXIT AT LEFT SIDE. REAR ROOF CAP CRACKED AND PULLING AWAY FROM BODY AT RIVETS. BODY SEEMS TO FLEX AND TWIST CAUSING BREAKAGE ALONG THE BOTTOM OF WINDOWS ALONG LEFT SIDE. WE HAVE 2 VEHICLE OF THE SAME YEAR, MAKE AND MODEL AND BOTH HAVE DONE THE SAME THING AT ABOUT THE SAME MILEAGE. BOTH VEHICLES HAVE BEEN REPAIRED AT DEALER, WAS VERY EXPENSIVE ($21,000.00) FOR REPAIRS. COULD POSSIBLY CAUSE SERIOUS INJURY IN A ROLLOVER TYPE A…

Look up ODI 10593162 at NHTSA ↗

CRACKS IN STRUCTURE BEAM UNDER DASH ALSO CAUSING THE BODY OUTER SKIN TO CRACK ON A 2013 BLUE BIRD VISION

Look up ODI 10568434 at NHTSA ↗

VOQ ENTERED BY MHDVD ON 8/22/2011 THE DRIVER NOTICED SMOKE COMING FROM THE STEERING COLUMN AREA OF THE DASH OF THE SCHOOL BUS WHICH RAPIDLY DEVELOPED AND ENGULFED THE LEFT SIDE OF THE ENGINE COMPARTMENT. CAUSE OF FIRE WAS UNDETERMINED AFTER INSPECTION. ELECTIRCAL HEATING WAS NOTED AT THE SOLENOID BUT DID NOT APPEAR TO BE SUFFICIENT TO ACT AS AN IGNITION SOURCE AND LACK OF FUEL IN THE AREA DOES NOT DEMONSTRATE A MEANS FOR A FIRE TO DEVELOP.

Look up ODI 10450994 at NHTSA ↗