5 distinct campaigns affect this selection. Announcement dates below are different from vehicle model years. A campaign may cover multiple years.
08V692000 · Engine And Engine Cooling:Engine:Gasoline
Reported: 2008-12-29 (December 29, 2008) · Model years: 2008
BMW IS RECALLING 509 MY 2008 F650 GS AND F800 GS MOTORCYCLES. THE TIGHTENING OF THE CHAIN SPROCKET FASTENERS MAY HAVE RESULTED IN VARIOUS LEVELS OF TORQUE BEING APPLIED.
Consequence: IT IS POSSIBLE FOR THE FASTENERS TO WORK LOOSE FROM THE SPROCKET, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL LOOSEN AND INSPECT THE CHAIN SPROCKET FASTENERS. THOSE THAT HAVE BEEN DAMAGED WILL BE REPLACED. IN ALL CASES, THE FASTENERS WILL BE RETIGHTENED. THE RECALL IS EXPECTED TO BEGIN DURING JANUARY 2009. OWNERS MAY CONTACT BMW AT 1-800-831-1117.
BMW IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2010 F650 GS AND F800 GS MOTORCYCLES MANUFACTURED BETWEEN JANUARY 2008 AND DECEMBER 2009. DURING ENGINE OPERATION, A VACUUM IS CREATED IN ORDER TO DRAW FRESH AIR INTO THE CANISTER. THIS AIR THEN MIXES WITH THE FUEL VAPORS CAPTURED BY THE CANISTER, AND IS SUBSEQUENTLY COMBUSTED. DUE TO THE ROUTING OF THE VENTILATION HOSE, WATER NEAR THE END OF THE HOSE COULD BE DRAWN INTO THE CHARCOAL CANISTER.
Consequence: WATER COULD FLOW INTO THE CANISTER CAUSING A STALLING CONDITION INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND ADD AN ADDITIONAL HOSE AND ROUTE IT SUCH THAT THE PRESENT DEFECT IS PREVENTED. THIS REMEDY WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 13, 2010. OWNERS MAY CONTACT BMW AT 1-800-831-1117.
Reported: 2010-06-16 (June 16, 2010) · Model years: 2008, 2009
BMW IS RECALLING CERTAIN MODEL YEAR 2008 AND 2009 F650 GS AND F 800 GS MOTORCYCLES MANUFACTURED FROM SEPTEMBER 27, 2007 THROUGH MARCH 30, 2009. THE DRIVE CHAINS MAY NOT HAVE BEEN PRODUCED TO SPECIFICATION. AS A RESULT, OVER TIME THE DRIVE CHAIN COULD BREAK.
Consequence: IF THE BROKEN CHAIN BECOMES TRAPPED BETWEEN THE REAR WHEEL AND THE FRAME, THE REAR WHEEL COULD LOCK UP, POSSIBLY RESULTING IN A CRASH.
Remedy: BMW WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE DRIVE CHAIN AND SPROCKETS ON THE AFFECTED MOTORCYCLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 30, 2010. OWNERS MAY CONTACT BMW AT 1-800-525-7417.
Reported: 2009-03-18 (March 18, 2009) · Model years: 2009
BMW IS RECALLING 754 MY 2009 F800 GS VEHICLES. THE AXLE SHAFT WALL THICKNESS MAY NOT HAVE BEEN MANUFACTURED ACCORDING TO SPECIFICATIONS.
Consequence: IF THE WALL THICKNESS WAS NOT SUFFICIENT, THE AXLE SHAFT COULD DEFORM AND COULD BREAK INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE FRONT WHEEL QUICK-RELEASE AXLE AND REPLACE IT WITH AN IMPROVED AXLE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JUNE 2009. OWNERS MAY CONTACT BMW AT 1-800-831-1117.
Reported: 2025-07-25 (July 25, 2025) · Model years: 2025
BMW of North America, LLC (BMW) is recalling certain 2025 F 900 GS, F 800 GS, R 1300 GS Adventure, R 1300 GS, S 1000 RR, S 1000 R, and K 1600 GT vehicles equipped with the optional emergency call system. The emergency call system (eCall) may have been deactivated due to a software programming error.
Consequence: In an emergency, first responders may not receive notification of the crash or emergency location, increasing the risk of injury to riders.
Remedy: The electronic control unit software will be updated over-the-air (OTA) or by a dealer, free of charge. Owner notification letters are scheduled to be mailed September 12, 2025. Owners may contact BMW customer service at 1-800-525-7417.
Inspect model-year patterns, reported mileage, monthly activity and the evidence behind each signal.
Data completeness
18 unique complaints in this selection. Analysis snapshot: 2026-10-01.
94.4%Usable mileage17 / 18 records
100.0%Valid incident date18 / 18 records
100.0%Valid filing date18 / 18 records
100.0%Ordered incident and filing dates18 / 18 records
Missing, zero and invalid mileage is excluded. Dates after the snapshot are excluded. Examples are limited selections, not a representative sample.
Problems by model year
Model-wide comparison of the eight most reported components across the model. Cells show counts and shares within each model year. Open a cell for source examples.
Darker cells indicate a larger share of submitted complaints. Components overlap. This measures complaint composition, not failure probability.
Failure mileage by component
Median and middle 50% of usable owner-reported mileages. Ranges require at least five records.
Component failure mileage distribution
Component
Mileage range (25th–75th percentile)
Median
Usable records
Examples
Fuel/Propulsion System
Too few reports for a range
5,056 mi
4 (sparse)
ODI 10596974 · 9,712 mi
I WAS TRAVELING ON THE FREEWAY AT APPROXIMATELY 75 MPH WHEN TRAFFIC STARTED TO SLOW DOWN. AS I ROLLED OFF THE THROTTLE TO SLOW DOWN THE ENGINE COMPLETELY DIED. I HAD TO COAST THROUGH MULTIPLE LANES OF HIGH SPEED FREEWAY TRAFFIC TO GET TO THE SHOULDER. I SAW THAT NO WARNING/ CHECK ENGINE LIGHTS HAD COME ON, THE FUEL GAUGE INDICATED THAT IT HAD APPROXIMATELY 3/4 OF A TANK, THE KILL SWITCH WAS IN THE RUN POSITION, AND THE KICK STAND WAS SECURELY UP. WHILE COASTING TO THE SHOULDER I NOTICED THAT THE TACHOMETER SHOWED ABOUT 1,000 RPM EVEN THOUGH THE…
THE PLASTIC FUEL TANK ON THIS MOTORCYCLE IS KNOWN TO HAVE A MATERIAL OR MANUFACTURING DEFECT IN THE FORM OF A LATERAL CRACK ALL THE WAY AROUND THE TANK. THE FUEL TANK IS POSITIONED DIRECTLY OVER THE EXHAUST SYSTEM UNDER THE SEAT. I DISCOVERED THIS DEFECT ON MY MACHINE AFTER SMELLING GAS DURING A CASUAL RIDE IN MY NEIGHBORHOOD. A QUICK SEARCH ONLINE FOR "F800GS FUEL TANK CRACK" IMMEDIATELY RETURNED SEVERAL DISCUSSIONS AND OWNERS' DOCUMENTATION OF THE EXACT SAME ISSUE, INCLUDING SOME DISCOVERED BIKES STILL ON THE SHOWROOM FLOOR. I AM CONCERNED…
LEFT REAR WHEEL BEARING FAILURE ON MY 2008 BMW F800GS MOTORBIKE AT 13,800KM. ON INVESTIGATION THERE APPEARS TO BE A CRUSHING FORCE BY THE HUB ON THE BEARING WHICH CAUSED FAILURE. THE RIGHT BEARING IS STILL FINE. *TR
REAR WHEEL BEARING DETERIORATION AT 12,000 MILES ON A BMW F800GS. RIDING UNDER NORMAL CIRCUMSTANCES. CHECK THE BEARING AFTER READING AN INTERNET POST ABOUT SEVERAL OTHER PEOPLE WITH THE SAME MAKE AND MODEL HAVING BEARING FAILURES. THE BEARING FELT PITTED AND GRITTY. I TOOK IT TO THE DEAL AND THEY REPLACED THEM UNDER WARRANTY WITH FACTORY PARTS. UNCHECKED THIS WOULD HAVE MOST LIKELY LEAD TO A CATASTROPHIC FAILURE WITH POSSIBLE INJURY OR DEATH. *TR
I HAD THE REAR WHEEL BEARINGS ON MY 2009 BMW F800GS MOTORCYCLE CHECKED DURING ITS ROUTINE 6,000 MILE SERVICE. THE BEARINGS ON MY BIKE SHOWED EVIDENCE OF ACCELERATED WEAR. THEY WERE REPLACED BY THE BMW SHOP, UNDER WARRANTY. ONE WOULD EXPECT SUCH BEARINGS TO LAST A _MINIMUM_ OF 50,000 MILES, AND SO FAILURE WITH SO LITTLE MILEAGE WAS UTTERLY UNEXPECTED. ON A MOTORCYCLE, REAR WHEEL BEARING FAILURE AT SPEED COULD LEAD TO LOSS OF CONTROL OF THE VEHICLE, RESULTING IN INJURY OR DEATH TO THE OPERATOR. *TR
THE STATOR OF THE ALTERNATOR FRIED, SO THE BATTERY STARTED DISCHARGING AND WHEN EMPTY THE COMPUTER AND THE ENGINE STALLED. I HAD THE STATOR REWINDED AND THE SAME PROBLEM REPEATED 5000 MILES LATER. I HAD IT REWINDED A SENCOND TIME AND IT HAPPENED AGAIN. I AM INTO MY 3RD REWIND AND JUST EXPECTING THE PROBLEM TO REAPPEAR...
STATOR / FLYWHEEL NO LONGER CHARGING BATTERY. RAN ON BATTERY POWER UNTIL ENGINE QUIT ON FREEWAY AT 65 MPH. COASTED TO SHOULDER AND WAITED FOR TOW. 2ND TIME THIS HAPPENED. FIRST TIME AT 28,000 MILES. *TR
I HAVE A 2010 BMW F800GS WITH 40,000 MILES. THE ALTERNATOR DIED FAR AWAY FROM MY HOUSE, ABOUT 1000 MILES AND INCLUDED THE NEED TO CROSS THE BORDER. WHEN THE BATTERY EMPTIED THE ABS LIGHT WENT ON AND SOON AFTER THE DASHBOARD TURNED OFF COMPLETELY. SOON AFTER THE BIKE CAME TO A HALT. *TR
STATOR / FLYWHEEL NO LONGER CHARGING BATTERY. RAN ON BATTERY POWER UNTIL ENGINE QUIT ON FREEWAY AT 65 MPH. COASTED TO SHOULDER AND WAITED FOR TOW. 2ND TIME THIS HAPPENED. FIRST TIME AT 28,000 MILES. *TR
I WAS TRAVELING ON THE FREEWAY AT APPROXIMATELY 75 MPH WHEN TRAFFIC STARTED TO SLOW DOWN. AS I ROLLED OFF THE THROTTLE TO SLOW DOWN THE ENGINE COMPLETELY DIED. I HAD TO COAST THROUGH MULTIPLE LANES OF HIGH SPEED FREEWAY TRAFFIC TO GET TO THE SHOULDER. I SAW THAT NO WARNING/ CHECK ENGINE LIGHTS HAD COME ON, THE FUEL GAUGE INDICATED THAT IT HAD APPROXIMATELY 3/4 OF A TANK, THE KILL SWITCH WAS IN THE RUN POSITION, AND THE KICK STAND WAS SECURELY UP. WHILE COASTING TO THE SHOULDER I NOTICED THAT THE TACHOMETER SHOWED ABOUT 1,000 RPM EVEN THOUGH THE…
AFTER 9000 MILES THE CLUTCH ON MY 2009 F800GS SUDDENLY STARTED TO SLIP ON THE FREEWAY WHEN DOWNSHIFTING AND ACCELERATING. THERE WAS NO PREVIOUS SYMPTOMS OF ANY PROBLEMS IN THE DRIVE TRAIN/CLUTCH APART THAT THE ADJUSTMENT OF THE CLUTCH WAS TO THE LAST LIMIT (ALL SERVICE DONE BY BMW DEALER). SINCE THEN ANY ACCELERATION MAKES THE RPM JUMP 1000+ RPM BEFORE GRADUALLY COMING DOWN AND ACTUAL ACCELERATION OCCURRING. THIS CAN BE A SAFETY PROBLEM AS A LOSS OF ACCELERATION CAN LEAD TO AN ACCIDENT OR DEATH ON A MOTORCYCLE. *TR
TL* THE CONTACT OWNS A 2009 BMW F800 GS MOTORCYCLE. WHILE TRAVELING 75 MPH, THE CONTACT ATTEMPTED TO DOWNSHIFT FROM SIXTH TO FIFTH GEAR AND THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE COMPUTER WAS UPDATED. THE FAILURE RECURRED FOLLOWING REPAIRS. THE DEALER THEN PERFORMED A SECOND COMPUTER SOFTWARE UPDATE TO CORRECT THE FAILURE. THE FAILURE MILEAGE WAS 2,200 AND THE CURRENT MILEAGE WAS 4,200.
THROTTLE RESPONSE IS TOO SHARP AND TAKES YOU BY SURPRISE WITHOUT WARNING DURING NORMAL OPERATION. THIS RESPONSE CAN BE RAPID ACCELERATION OR DECELERATION WHEN A DEFORMITY IN THE ROAD IS DRIVEN OVER. THE RAPID RESPONSE IS EVEN MORE EXACERBATED AT LOW SPEEDS WHEN TRYING TO MANEUVER RESIDENTIAL SURFACE ROADS. I HAVE TAKEN THE VEHICLE TO THE DEALER WITH NO KNOWN REPAIRS. I HAVE HAD A COMPUTER SOFTWARE UPGRADE TO NO AVAIL. I HAVE SEARCHED MANY ADVENTURE TYPE FORUMS WHERE MANY PEOPLE ARE HAVING THE SAME PROBLEMS WITH NO KNOWN REPAIR FROM THE FAC…
Explore monthly filing activity alongside recall announcements. Up to ten years of monthly history is available.
Solid line: filed complaints. Dashed amber lines: recall announcement dates for this vehicle selection; markers include all recall components. The latest month is partial. Temporal proximity does not establish causation.
Monthly counts, recall campaigns and complaint examples
Complete months in the latest six months with at least 10 complaints, at least twice the preceding 12-month average, and at least three square-root deviations above that average.
This is a descriptive screening rule, not a statistical defect finding. Publicity and reporting changes can increase submissions.
No complete months meet the spike thresholds for this selection.
Equal-age model-year comparison
Model-wide cumulative reports during the first three or five calendar years, starting with the model year (age 0). Only fully elapsed windows are compared.
2010: 1 complaints · 2013: 3 complaints
Equal observation windows
Model year
Through age 0
Through age 1
Through age 2
2010
0
1
1
2013
2
3
3
Date coverage across each selected cohort
Date basis for all complaints in selected model years
Year
Incident dates used
Filing date fallbacks
Excluded dates
2010
3
0
0
2013
4
0
0
Incident date is preferred when valid and no later than filing; otherwise filing date is used. Model year approximates age. Equal observation time does not adjust for sales, distance driven or reporting delays. One complaint linked to multiple model years can appear in each cohort.
Components reported together
Each cell counts unique complaints naming both components. Open a nonzero cell for examples.
Component co-occurrence matrix
Component
Fuel/Propulsion System
Wheels
Electrical System
Engine
Power Train:Manual Transmission
Engine And Engine Cooling:Engine
Exterior Lighting
Fuel System, Gasoline
Fuel/Propulsion System
—
0
0
1ODI 10596974 · 9,712 mi
I WAS TRAVELING ON THE FREEWAY AT APPROXIMATELY 75 MPH WHEN TRAFFIC STARTED TO SLOW DOWN. AS I ROLLED OFF THE THROTTLE TO SLOW DOWN THE ENGINE COMPLETELY DIED. I HAD TO COAST THROUGH MULTIPLE LANES OF HIGH SPEED FREEWAY TRAFFIC TO GET TO THE SHOULDER. I SAW THAT NO WARNING/ CHECK ENGINE LIGHTS HAD COME ON, THE FUEL GAUGE INDICATED THAT IT HAD APPROXIMATELY 3/4 OF A TANK, THE KILL SWITCH WAS IN THE RUN POSITION, AND THE KICK STAND WAS SECURELY UP. WHILE COASTING TO THE SHOULDER I NOTICED THAT THE TACHOMETER SHOWED ABOUT 1,000 RPM EVEN THOUGH THE…
STATOR / FLYWHEEL NO LONGER CHARGING BATTERY. RAN ON BATTERY POWER UNTIL ENGINE QUIT ON FREEWAY AT 65 MPH. COASTED TO SHOULDER AND WAITED FOR TOW. 2ND TIME THIS HAPPENED. FIRST TIME AT 28,000 MILES. *TR
I WAS TRAVELING ON THE FREEWAY AT APPROXIMATELY 75 MPH WHEN TRAFFIC STARTED TO SLOW DOWN. AS I ROLLED OFF THE THROTTLE TO SLOW DOWN THE ENGINE COMPLETELY DIED. I HAD TO COAST THROUGH MULTIPLE LANES OF HIGH SPEED FREEWAY TRAFFIC TO GET TO THE SHOULDER. I SAW THAT NO WARNING/ CHECK ENGINE LIGHTS HAD COME ON, THE FUEL GAUGE INDICATED THAT IT HAD APPROXIMATELY 3/4 OF A TANK, THE KILL SWITCH WAS IN THE RUN POSITION, AND THE KICK STAND WAS SECURELY UP. WHILE COASTING TO THE SHOULDER I NOTICED THAT THE TACHOMETER SHOWED ABOUT 1,000 RPM EVEN THOUGH THE…
STATOR / FLYWHEEL NO LONGER CHARGING BATTERY. RAN ON BATTERY POWER UNTIL ENGINE QUIT ON FREEWAY AT 65 MPH. COASTED TO SHOULDER AND WAITED FOR TOW. 2ND TIME THIS HAPPENED. FIRST TIME AT 28,000 MILES. *TR
Co-reporting does not establish that one component caused another concern.
Recurring narrative patterns
Specific keyword mentions beyond broad component labels. Matching includes negations and comparisons and does not confirm a diagnosis.
3 patterns with matching reports.
Fuel smell or leak mentions
2 mentions · 11.1% of complaints
Median mileage: 15,965 mi (2 usable records).
ODI 11377487 · 31,920 mi
THE PLASTIC FUEL TANK ON THIS MOTORCYCLE IS KNOWN TO HAVE A MATERIAL OR MANUFACTURING DEFECT IN THE FORM OF A LATERAL CRACK ALL THE WAY AROUND THE TANK. THE FUEL TANK IS POSITIONED DIRECTLY OVER THE EXHAUST SYSTEM UNDER THE SEAT. I DISCOVERED THIS DEFECT ON MY MACHINE AFTER SMELLING GAS DURING A CASUAL RIDE IN MY NEIGHBORHOOD. A QUICK SEARCH ONLINE FOR "F800GS FUEL TANK CRACK" IMMEDIATELY RETURNED SEVERAL DISCUSSIONS AND OWNERS' DOCUMENTATION OF THE EXACT SAME ISSUE, INCLUDING SOME DISCOVERED BIKES STILL ON THE SHOWROOM FLOOR. I AM CONCERNED…
MOTORCYCLE WAS BOUGHT NEW FROM A DEALERSHIP WITH A CRACK IN THE GAS TANK. IT WAS REPLACED AFTER PURCHASE UNDER WARRANTY. THE TANK IS BEGINNING TO CRACK ONCE AGAIN FOR THE SECOND TIME ABOUT A YEAR LATER. CRACKING FUEL TANKS POSES A RISK OF NOT ONLY GETTING STRANDED BUT POTENTIAL FUEL LEAKS AND SUBSEQUENT ASSOCIATED FIRES. THE CRACK OCCURS ALONG THE SEAM BY THE SEAT ALONG THE RIM OF THE FUEL TANK.
TL* THE CONTACT OWNS A 2009 BMW F800 GS MOTORCYCLE. WHILE TRAVELING 75 MPH, THE CONTACT ATTEMPTED TO DOWNSHIFT FROM SIXTH TO FIFTH GEAR AND THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE COMPUTER WAS UPDATED. THE FAILURE RECURRED FOLLOWING REPAIRS. THE DEALER THEN PERFORMED A SECOND COMPUTER SOFTWARE UPDATE TO CORRECT THE FAILURE. THE FAILURE MILEAGE WAS 2,200 AND THE CURRENT MILEAGE WAS 4,200.
THE STATOR OF THE ALTERNATOR FRIED, SO THE BATTERY STARTED DISCHARGING AND WHEN EMPTY THE COMPUTER AND THE ENGINE STALLED. I HAD THE STATOR REWINDED AND THE SAME PROBLEM REPEATED 5000 MILES LATER. I HAD IT REWINDED A SENCOND TIME AND IT HAPPENED AGAIN. I AM INTO MY 3RD REWIND AND JUST EXPECTING THE PROBLEM TO REAPPEAR...
Matching rule\b(stall\w*|loss of power|lost power|engine shut\w* off)\b
Warning lights and dashboard alerts
1 mentions · 5.6% of complaints
Median mileage: 9,712 mi (1 usable records).
ODI 10596974 · 9,712 mi
I WAS TRAVELING ON THE FREEWAY AT APPROXIMATELY 75 MPH WHEN TRAFFIC STARTED TO SLOW DOWN. AS I ROLLED OFF THE THROTTLE TO SLOW DOWN THE ENGINE COMPLETELY DIED. I HAD TO COAST THROUGH MULTIPLE LANES OF HIGH SPEED FREEWAY TRAFFIC TO GET TO THE SHOULDER. I SAW THAT NO WARNING/ CHECK ENGINE LIGHTS HAD COME ON, THE FUEL GAUGE INDICATED THAT IT HAD APPROXIMATELY 3/4 OF A TANK, THE KILL SWITCH WAS IN THE RUN POSITION, AND THE KICK STAND WAS SECURELY UP. WHILE COASTING TO THE SHOULDER I NOTICED THAT THE TACHOMETER SHOWED ABOUT 1,000 RPM EVEN THOUGH THE…