| Fuel/Propulsion System | 00.0%No examples available for this selection. | 1129.7%ODI 10485807 · 75,000 miFUEL STARTED LEAKING FROM TOP OF GAS TANK , LEAKING FROM CRACKS IN FLANGE CONNECTION VERY UNSAFE FIRE HAZARD. *TR Look up ODI 10485807 at NHTSA ↗ | 375.0%ODI 10474390 · 5,500 miFUEL PUMP FLANGE IS CRACKED, ALLOWING 40PSI OF FUEL PRESSURE TO STREAM OUT OF TANK. GREAT RISK OF FIRE AS FUEL LANDS DIRECTLY ON EXHAUST. THERE WAS ONLY NO FIRE BECAUSE I NOTICED THE LEAD AND SUBSEQUENT PUDDLE OF FUEL BEFORE BIKE/PIPES GOT HOT. *TR Look up ODI 10474390 at NHTSA ↗ | 1557.7%ODI 10459207 · 39,500 miFAILURE FOUND DURING SCHEDULED SERVICE WORK. FAILURE OF THE FUEL PUMP HOUSING HIGH-PRESSURE FUEL QUICK DISCONNECT REINFORCEMENT FLANGE CRACKS UNDER HIGH PRESSURE.WITH RISK OF LEAKING FUEL, IS EXHAUSTED ON THE RIDERS LEFT LEG, CREATING SIGNIFICANT RISK FOR THE RIDER EVEN AFTER DISMOUNTING THE VEHICLE. CONSEQUENCES OF FAILURE THE COMBINATION OF HIGH FUEL PRESSURE AND NEGLIGENT DESIGN CREATE SUBSTANTIAL RISK FOR RIDERS OF THE IMPACTED VEHICLES. THERE ARE MULTIPLE NEGATIVE CONSEQUENCES OF THIS FAILURE.1. RIDERS BECOME FUEL SOAKED AS FUEL LEAKS ON … Look up ODI 10459207 at NHTSA ↗ | 844.4%ODI 10467136 · 61,500 miWHILE RIDING MY MOTORCYCLE, I NOTICED FUEL LEAKING FROM THE FRONT BOTTOM LEFT SIDE OF THE FUEL TANK. FUEL WAS SPRAYING ON TO MY LEFT LEG SOAKING IT IN FUEL. THE LOCATION OF THE SPRAY WAS DIRECTLY ON TOP OF THE FRONT LEFT CYLINDER AND EXHAUST PIPE. THE POTENTIAL FOR A FIRE WAS REAL. AFTER TAKING IT TO THE DEALER ( GULF COAST BMW IN HOUSTON ), THEY TOLD ME THAT THIS WAS A COMMON FAILURE AND SHOWED ME A SAMPLE OF THE FAILED PART. I WAS THEN FORCED TO BUY A COMPLETE FUEL PUMP ASSEMBLY AS BMW DID NOT SELL THE FUEL PUMP FLANGE THAT FAILED. THE FLANGE… Look up ODI 10467136 at NHTSA ↗ | 1266.7%ODI 10461180 · 19,404 miBMW MOTORCYCLES FUEL GAUGE WITH "ELECTRONIC FUEL STRIP" FAIL RESULTING IN SAME CONDITION AS THEIR CAR RECALL SHOWN BELOW! DANGEROUS CONDITION RESULTS. (POST 2010 MODELS CHANGED TO FLOAT TYPE SYSTEM). SUMMARY: BMW IS RECALLING CERTAIN 2010 AND 2011 5-SERIES AND 5-SERIES GRAN TURISMO PASSENGER VEHICLES MANUFACTURED FROM JANUARY 12 THROUGH JULY 1, 2010. THE VEHICLE'S FUEL LEVEL SENSOR WITHIN THE FUEL TANK CAN BECOME WEDGED AGAINST THE TANK. CONSEQUENCE: IF THIS OCCURS, THE FUEL GAUGE IN THE INSTRUMENT CLUSTER WOULD DISPLAY A LARGER AMOUNT OF… Look up ODI 10461180 at NHTSA ↗ | 466.7%ODI 10499336 · 750 miFUEL STRIP FAILED. REPLACED AGAIN IN 6/2012. FAILURE RESULTS IN FALSE GAUGE READING WHICH CAN LEAD TO RUNNING OUT OF FUEL AT SPEED IN TRAFFIC. *TR Look up ODI 10499336 at NHTSA ↗ | 00.0%No examples available for this selection. | 360.0%ODI 10555171 · 14 miAFTER ABOUT 20-30 MINUTES OF RIDING THE BIKE AT HIGHWAY SPEEDS, THIS MOTORCYCLE'S FUEL SYSTEM STARTS TO HAVE TROUBLE IDLING. FOR EXAMPLE, AFTER THE ENGINE IS HOT THE BIKE SEEMS HAVE PROBLEMS IDLING PROPERLY. FOR EXAMPLE, WHILE SLOWING FOR LIGHTS AND TRAFFIC CONTROL SYSTEMS, THE BIKE HAS A TENANCY TO STALL. THIS MOTORCYCLE INTERMITTENTLY STALLS WHEN THE MOTOR IS WARM AND THE WHILE BREAKING AFTER DOWN-SHIFTING QUICKLY. IT HAPPENED OVER 20 TIMES IN THE LAST YEAR. THE BIKE STALLS IN BOTH COLD WEATHER AND IN HOT WEATHER. HOWEVER, IT APPEARS TO STA… Look up ODI 10555171 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 18.3%ODI 11092238 · 490 miWHILE RIDING THE MOTORCYCLE AT HIGHWAY SPEEDS, THE ENGINE GOES INTO A FAULTED STATE SPONTANEOUSLY WITH NO WARNING PRIOR, THE ECU IS FAULTING AND PUTTING THE ENGINE INTO "LIMP MODE" WHICH IS ALMOST EQUIVALENT OF COMPLETELY KILLING THE ENGINE THE WAY IT IS CURRENTLY DONE, AND YOU ARE LEFT TO NAVIGATE OFF THE HIGHWAY IN A SEVERELY DEBILITATED STATE OF OPERATION. THE ENGINE IS PROGRAMMED WITH A "LIMP MODE" FAULT I ASSUME TO SAVE THE ENGINE? BUT MY COMPLAINT IS , THE WAY IT CURRENTLY OPERATES ON THE MOTORCYCLE,IT IS PATENTLY "UNSAFE" AND PUTS THE R… Look up ODI 11092238 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
|---|
| Power Train | 125.0%ODI 10167228 · 29,500 miFINAL DRIVE SEAL BLEW OUT AFTER ONLY 30K MILES. *JB Look up ODI 10167228 at NHTSA ↗ | 821.6%ODI 102426092005 BMW 1200 GS MOTORCYCLE HAD A DEFECTIVE PART. CONSUMER STATES THAT THE REAR WHEEL FINAL DRIVE WAS DEFECTIVE AND WANTS TO BE REIMBURSED FOR THE DEFECTIVE PART. *NJ THE CONSUMER STATED WHILE RIDING THE BIKE, IT SLID/HOPPED A COUPLE OF TIMES ON FAST CURVES. THE DEALER REPLACED THE REAR FLANGE IN THE FINAL DRIVE BECAUSE IT WAS DAMAGED. *JB Look up ODI 10242609 at NHTSA ↗ | 00.0%No examples available for this selection. | 27.7%ODI 10483540 · 7,800 miTL* THE CONTACT OWNS A 2007 BMW R1200 GS MOTORCYCLE. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE FINAL DRIVE STARTED LEAKING BEFORE FAILING. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 7,800 AND THE CURRENT MILEAGE WAS 7,845. UPDATED 12/21/12*LJ UPDATED 1/4/2013*JS Look up ODI 10483540 at NHTSA ↗ | 422.2%ODI 10535147 · 51,063 miWHILE RIDING DOWN THE FREEWAY AN ODD VIBRATION IN THE BIKE OCCURRED WHEN THE SUSPENSION UNLOADED. ABOUT A HALF MILE LATER THE REAR WHEEL SUDDENLY LOCKED UP, CAUSING THE BIKE TO JERK VIOLENTLY. IMMEDIATELY PULLING IN THE CLUTCH ALLOWED ME TO COAST TO THE SIDE. SMOKE WAS COMING OUT THROUGH THE TWO SWING ARM JOINT BOOTS. THE LOWER U-JOINT OF THE DRIVE SHAFT SEIZED AND BROKE DUE TO THE FAILURE OF A NON-MAINTAINABLE SEALED BEARING. THE DRIVESHAFT IS LOCATED IN THE SWINGARM AND THE FLAILING DRIVESHAFT CAUSED SIGNIFICANT DAMAGE TO THAT PART AS WELL. … Look up ODI 10535147 at NHTSA ↗ | 422.2%ODI 10446587 · 10,000 miAT THE INDICATED TIME, I NOTICED ROUGHNESS WHILE DRIVING. I STOPPED, EXAMINED THE DRIVETRAIN, AND FOUND ROUGHNESS WHEN TURNING THE REAR WHEEL BY HAND. I DRAINED THE DRIVETRAIN OIL AND FOUND METALLIC PARTICLES THE TEXTURE OF COARSE SAND ADHERING TO THE MAGNETIC DRAIN PLUG. THE LOCAL AUTHORIZED BMW DEALER EXAMINED THE MOTORCYCLE AND FOUND THAT A BEARING IN THE FINAL DRIVE HAD FAILED. BMW REPLACED THE BEARING AT NO COST UNDER WARRANTY. THIS IS THE SAME FAILURE AS DESCRIBED IN ODI NO. 10439549, AND CURRENTLY BEING INVESTIGATED UNDER CAMPAIGN DP1200… Look up ODI 10446587 at NHTSA ↗ | 233.3%ODI 10668281 · 5,000 miTHE DROP DOWN MENU ABOVE FOR AFFECTED PARTS WAS NOT WORKING WITH MY COMPUTER. THE AFFECTED PART IS THE TRANSMISSION/SHIFTING. THE VEHICLE MENU DID NOT SHOW MY YEAR OF MOTORCYCLE, WHICH IS 2011. I SELECTED 2010 AS THE NEXT CLOSEST OPTION. SINCE I PURCHASED THE BIKE IT WILL ON OCCASION POP OUT OF 6TH GEAR ON THE HIGHWAY. THERE IS A FALSE NEUTRAL BETWEEN 5TH AND 6TH GEAR. WHEN I BROUGHT IT TO THE DEALER UNDER WARRANTY ON SEVERAL OCCASIONS, THEY INDICATED THE PROBLEM COULD NOT BE REPLICATED SO THEY WOULD NOT FIX IT. THIS ISSUE IS DOCUMEN… Look up ODI 10668281 at NHTSA ↗ | 1100.0%ODI 10916708 · 14,000 miAFTER FEW KM (16.700) A LOT OF NOISE COMES FROM GEAR BOX. I SEARCH ON THE WEB IF SOMEBODY ELSE HAD THE SAME PROBLEM AND I FOUND A LOT. MANY CUSTOMER CLAIMS THAT OUT OF WARRANTY THE GEAR FAULT CAUSING SERIOUS NOISE AND IN SOME CASE CRASH AND INJURIES. THE PROBLEM CONSIST IN A FAULT OF THE OF THE SHAFT IN THE GEARBOX THAT CAN CAUSE THE REAR WHEEL LOCKING. IN FACT, THIS MOTORCYCLE HAD A RIGID TRANSMISSION MADE WITH A SHAFT. WHEN THE SHAFT OF THE GEARBOX CRACK, SOME SMALL METAL PARTS CAN SIMPLY LOCK THE TRANSMISSION. BMW WELL KNOW THE PROBLEM DUE T… Look up ODI 10916708 at NHTSA ↗ | 00.0%No examples available for this selection. | 120.0%ODI 10899352 · 30,000 miENGINE CUTS OUT, WHILE TRAVELING, STALLS COMPLETELY, AS IF THE KILL SWITCH HAS BEEN DEPRESSED/ENGAGED. THIS HAS HAPPENED TO ME ON 4 SEPARATE OCCASIONS IN THE LAST 2500MILES. THE TWO MOST RECENT TIMES THIS HAS HAPPENED PRESENTED A HAZARD TO MYSELF AND TO OTHER ROAD USERS. I HAVE TAKEN THE BIKE TO MY LOCAL BMW DEALER, THEY OPENED A PUMA CASE AS THEY WERE UNABLE TO DUPLICATE THE PROBLEM, NOR WERE THEY ABLE TO FIND A SOLUTION. I DID CONTACT BMW DIRECTLY WHO TOLD ME THERE WAS NOTHING THEY COULD DO AND THAT THEY WERE SORRY BUT HAD NO IDEA WHAT THE PR… Look up ODI 10899352 at NHTSA ↗ | 00.0%No examples available for this selection. | 18.3%ODI 11092238 · 490 miWHILE RIDING THE MOTORCYCLE AT HIGHWAY SPEEDS, THE ENGINE GOES INTO A FAULTED STATE SPONTANEOUSLY WITH NO WARNING PRIOR, THE ECU IS FAULTING AND PUTTING THE ENGINE INTO "LIMP MODE" WHICH IS ALMOST EQUIVALENT OF COMPLETELY KILLING THE ENGINE THE WAY IT IS CURRENTLY DONE, AND YOU ARE LEFT TO NAVIGATE OFF THE HIGHWAY IN A SEVERELY DEBILITATED STATE OF OPERATION. THE ENGINE IS PROGRAMMED WITH A "LIMP MODE" FAULT I ASSUME TO SAVE THE ENGINE? BUT MY COMPLAINT IS , THE WAY IT CURRENTLY OPERATES ON THE MOTORCYCLE,IT IS PATENTLY "UNSAFE" AND PUTS THE R… Look up ODI 11092238 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
|---|
| Service Brakes | 00.0%No examples available for this selection. | 410.8%ODI 10596090 · 32,390 miI WAS REPLACING MY REAR BRAKE ROTOR. THE ROTOR IS BOLTED TO A PIECE CALLED A FLANGE (PART NUMBER 33117722831) USING 5 BOLTS. I FOUND THAT EACH OF THE 5 BOLT HOLES IN THE FLANGE ARE CRACKED. IF THIS PART WERE TO COME APART WHILE RIDING I THINK IT WOULD CAUSE THE REAR WHEEL TO LOCK UP AND SKID OR POSSIBLY WORSE. THE FLANGE (PART NUMBER 33117722831) IS ALSO PART OF THE POWER TRAIN AND REAR WHEEL DRIVE SYSTEM (ALSO KNOWN AS THE FINAL DRIVE SYSTEM) FOR THE BMW R1200GS MOTORCYCLE. THE BMW MUST KNOW THAT THIS IS A DANGEROUS PROBLEM BECAUSE THEY H… Look up ODI 10596090 at NHTSA ↗ | 00.0%No examples available for this selection. | 623.1%ODI 10535215 · 22,715 miTHE FUEL PUMP OUTLET QUICK CONNECTOR CRACKED, CAUSING GASOLINE TO LEAK OUT AND SPILL ALL OVER THE MOTORCYCLE CREATING A FIRE HAZARD AND POTENTIAL BRAKE FAILURE. ALSO THE GASOLINE SOAKED MY PANTS LEG CREATING ANOTHER FIRE HAZARD AND SKIN RASH. *TR Look up ODI 10535215 at NHTSA ↗ | 15.6%ODI 10605939 · 2,000 miTL* THE CONTACT OWNS A 2008 BMW R1200 GS MOTORCYCLE. THE CONTACT STATED THAT THE ANTI- LOCK BRAKING SYSTEM ENGAGED AND TURNED OFF INDEPENDENTLY WITHOUT ANY WARNINGS. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE ANTI-LOCK BRAKE SYSTEM CONTROL UNIT NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN RECALL NHTSA CAMPAIGN NUMBER: 09V129000 (ELECTRICAL SYSTEM). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 2,000 AND THE CURRENT… Look up ODI 10605939 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 440.0%ODI 11110571 · 7,000 miREAR BRAKE REQUIRES MORE AND MORE TRAVEL UNTILL IT HIT THE STOP..NO REAR BRAKE. BLEEDING BRAKE SOLVES FOR A MONTH OR TWO, THEN CYCLE BEGINS AGAIN. BMW SAYS BLEED BRAKES EVERY 2 YEARS, I HAVE TO DO IT AT LEAST EVERY OIL CHANGE (6000 MILES). DEALER IS AWARE OF PROBLEM, HAS NO SOLUTION Look up ODI 11110571 at NHTSA ↗ | 216.7%ODI 11245377 · 12,000 miTHE REAR BRAKE BECOMES INEFFECTIVE. DEALER SAYS THAT AIR INVADES THE REAR BRAKE SYSTEM. BLEEDING THE OLD BRAKE FLUID AND REPLACING IT WITH NEW BRAKE FLUID SOLVES THE PROBLEM FOR A FEW MONTHS. THEN IT HAPPENS AGAIN AND THE BLEEDING MUST BE DONE AGAIN. FRONT BRAKE CONTINUES TO BE EFFECTIVE AT ALL TIMES. Look up ODI 11245377 at NHTSA ↗ | 133.3%ODI 11374290 · 14,200 miTL* THE CONTACT OWNS A 2017 BMW R1200 GS. THE CONTACT STATED THAT WHILE RIDING 50 MPH AND DEPRESSING THE REAR BRAKE PEDAL, THE MOTORCYCLE FAILED TO STOP. THE CONTACT DEPRESSED THE FRONT BRAKE TO BRING THE MOTORCYCLE TO A STOP. THE CONTACT CALLED TYTLERS CYCLE (2246 MID VALLEY DR, DE PERE, WI 54115, [phone removed]) AND INFORMED THE DEALER OF THE FAILURE. THE CONTACT WAS INFORMED THAT THE MOTORCYCLE WAS NOT UNDER RECALL AND WAS NOT UNDER WARRANTY. THE CONTACT WAS INFORMED TO SCHEDULE AN APPOINTMENT FOR A DIAGNOSTIC TEST. THE VEHICLE WAS NOT TAK… Look up ODI 11374290 at NHTSA ↗ | 00.0%No examples available for this selection. |
|---|
| Suspension | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 15.6%ODI 10644654 · 17,732 miI PURCHASED THE MOTORCYCLE NEW FROM VALLEY CYCLE & MOTORSPORTS IN BAKERSFIELD, CA ON 6/23/08. DURING THE 18,000 MILE SERVICE ON 04/06/11 (ODO: 17,732) , BMW OF SANTA CRUZ, CA SERVICE TECHNICIAN NOTICED REAR SHOCK STRUT WAS LEAKING OIL AND ORDERED A REPLACEMENT. ON 06/28/11 (ODO: 21,500) VALLEY CYCLE & MOTORSPORTS, CA INSTALLED THE REPLACEMENT SHOCK STRUT UNDER WARRANTY. ON 9/12/14 (ODO: 38,768) WHILST ON AN EXTENDED MOTORCYCLE VACATION THE REPLACEMENT REAR SHOCK STRUT STARTED LEAKING, SPEWING OIL ON THE BACK TIRE CREATING A DANGEROUS CONDITI… Look up ODI 10644654 at NHTSA ↗ | 15.6%ODI 10550394 · 42,182 miTL* THE CONTACT OWNS A 2009 BMW 1200 GS MOTORCYCLE. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE REAR FINAL DRIVE BEARING BECAME SEPARATED. THE CONTACT WAS ABLE TO STOP THE MOTORCYCLE WITH THE FRONT BRAKE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE REAR FINAL BEARING WAS REPLACED. THE FAILURE AND CURRENT MILEAGE WAS 42,182. UPDATED 01/07/014*LJ UPDATED 1/17/2014 *JS Look up ODI 10550394 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 360.0%ODI 10983725WHILE RIDING FORK OIL BEGIN TO LEAK OUT OF THE TOP OF THE LEFT FORK. ONCE REMOVING THE RUBBER COVER I NOTICED THAT THE FORK TUBE HAD SEPARATED FROM THE HEAD ENOUGH TO CAUSE LEAKAGE AND LOSS OF OIL. I REMOVED THE RIGHT COVER AS WELL AND NOTICED THE FORKS WERE STARTING TO SEPARATE ALSO. THIS CAUSED PLAY IN MY STEERING AS WELL AS THE END OF MY TRIP. I RETURNED THE BIKE TO THE DEALERSHIP AND THEY REPLACED THE FORKS UNDER WARRANTY. THIS WAS AUGUST OF 2016. SINCE THAT TIME I HAVE HEARD OF NUMEROUS ACCOUNTS OF THIS INCIDENT HAPPENING. A FELLOW MOTORCY… Look up ODI 10983725 at NHTSA ↗ | 330.0%ODI 11021750TL* THE CONTACT OWNS A 2015 BMW R1200 GS. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V438000 (SUSPENSION) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. AN UNKNOWN BMW DEALER OF MANHATTAN, NEW YORK WAS MADE AWARE OF THE RECALL AND STATED THAT THE PARTS WERE UNAVAILABLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PART DISTRIBUTION DISCONNECT. THE VIN WAS NOT AVAILABLE. Look up ODI 11021750 at NHTSA ↗ | 541.7%ODI 10983838 · 11,000 miTHE LEFT STANCHION HAS COME LOOSE FROM THE CRIMPED CONNECTION AT THE TOP OF THE UPPER TUBE. I HAVE SEEN MANY OTHER PROBLEMS WITH THIS DESIGN ON OTHER BIKES ON THE SOCIAL MEDIA FORUM I TRACK. GS GIANTS ON FACEBOOK, AND ALSO ON ADVRIDER.COM. I TOOK IT TO THE BMW SHOP TODAY IN TULSA OK. I HAD TO SHOW THEM EXACTLY HOW IT WAS LOOSE. I HAVE NOT BEEN IN AN ACCIDENT WITH THIS BIKE. I DO RIDE IT ON ROUGH GRAVEL ROADS, BUT THE BIKE IS DESIGNED FOR THIS TYPE OF ENVIRONMENT. Look up ODI 10983838 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
|---|
| Engine | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 27.7%ODI 10459207 · 39,500 miFAILURE FOUND DURING SCHEDULED SERVICE WORK. FAILURE OF THE FUEL PUMP HOUSING HIGH-PRESSURE FUEL QUICK DISCONNECT REINFORCEMENT FLANGE CRACKS UNDER HIGH PRESSURE.WITH RISK OF LEAKING FUEL, IS EXHAUSTED ON THE RIDERS LEFT LEG, CREATING SIGNIFICANT RISK FOR THE RIDER EVEN AFTER DISMOUNTING THE VEHICLE. CONSEQUENCES OF FAILURE THE COMBINATION OF HIGH FUEL PRESSURE AND NEGLIGENT DESIGN CREATE SUBSTANTIAL RISK FOR RIDERS OF THE IMPACTED VEHICLES. THERE ARE MULTIPLE NEGATIVE CONSEQUENCES OF THIS FAILURE.1. RIDERS BECOME FUEL SOAKED AS FUEL LEAKS ON … Look up ODI 10459207 at NHTSA ↗ | 211.1%ODI 10630849 · 20,200 miON 17 AUGUST 2014 AT NEWCOMB'S RANCH IN THE ANGELES NATIONAL FOREST EAST OF LOS ANGELES AT APPROXIMATELY 10:15 AM I DISCOVERED THAT THE IGNITION SWITCH DETENT MECHANISM HAD FAILED ON MY 2008 BMW R1200GS MOTORCYCLE. I WAS ABLE TO FREELY ROTATE THE IGNITION KEY BETWEEN ON AND OFF, SO THAT THE SLIGHTEST TORQUE FROM A KEY FOB OR WIND COULD TURN THE KEY TO OFF, WHICH WOULD SHUT THE ENGINE AND ALL ELECTRICAL SYSTEMS OFF, PERHAPS UNEXPECTEDLY DURING OPERATION OF THE VEHICLE. THE FAILED IGNITION SWITCH DETENT CONDITION APPARENTLY OCCURRED DURING MY ONE… Look up ODI 10630849 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 110.0%ODI 10747595 · 500 miTL* THE CONTACT OWNS A 2015 BMW R1200 GS ADVENTURER. THE CONTACT STATED THAT THE MOTORCYCLE STALLED NUMEROUS TIMES WITHOUT WARNING. THE MOTORCYCLE WAS TAKEN TO THE DEALER EVERY THREE MONTHS. THE TECHNICIAN WAS UNABLE TO REPLICATE AND DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT ABLE TO PROVIDE A REMEDY TO PREVENT THE FAILURE FROM RECURRING. THE MOTORCYCLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 500. THE VIN WAS NOT AVAILABLE. Look up ODI 10747595 at NHTSA ↗ | 325.0%ODI 10899372 · 700 miCRUISE CONTROL ENGAGED AT 75 MPH U.S. 59N. THE ENGINE BEHAVES AS IF IT SHUTS OFF. I ENGAGE THE CLUTCH AND COAST TO THE SHOULDER OF THE ROAD. I WAS SURPRISED THAT THE ENGINE WAS STILL RUNNING, WITH A SURGING IDLE FROM 1000-2000 RPMS. THE INSTRUMENT PANEL HAD TWO WARNINGS ILLUMINATED, YELLOW "WARNING" TRIANGLE AND AN ENGINE SYMBOL WHICH BMW DESCRIBES AS "ENGINE IN EMERGENCY-OPERATING MODE". I TURNED OFF THE ENGINE USING THE KEYLESS IGNITION BUTTON. I RESTARTED THE ENGINE AND OPERATION WAS NORMAL. NO WARNINGS WERE ILLUMINATED ON THE IN… Look up ODI 10899372 at NHTSA ↗ | 266.7%ODI 11142408 · 7,000 miWHILE THE MOTORCYCLE WAS DRIVEN AT A CONSTANT SPEED ON THE STREET, SUDDENLY AND WITHOUT WARNING THE ENGINE PROBLEM LIGHT COMES ON THE DASHBOARD. THE MOTORCYCLE THEN PROCEEDS INTO "EMERGENCY OPERATION MODE" WHERE THE RPMS IMMEDIATELY DROP TO 2000 RPMS OR LOWER CAUSING IMMEDIATE DECELERATION. ON A MOTORCYCLE THIS IS AN EXTREME HAZARD IN TRAFFIC, IN A TURN, OR PASSING. THIS HAS HAPPENED SEPARATE TIMES. EACH TIME THE MOTORCYCLE WAS BROUGHT INTO THE BMW SHOP FOR REPAIR OF THE PROBLEM. EACH TIME THE SHOP PERFORMED A SOFTWARE UPGRADE TO THE MOTOR… Look up ODI 11142408 at NHTSA ↗ | 250.0%ODI 11363484 · 12,100 miTHIS IS IN REFERENCE TO TICKET # 11363230. RELATED TO THIS SAME VEHICLE. I WENT FOR A RIDE TODAY AND THE SAME THING HAPPENED, WITH THE ENGINE SUDDENLY SHUTTING ALMOST COMPLETELY DOWN. LUCKILY, IT WAS ON A DESERTED COUNTRY ROAD AND NOT IN RUSH HOUR TRAFFIC. I AM ATTACHING A PDF OF THE OBD SCAN I TOOK UPON RETURNING HOME TODAY. ALSO, PLEASE NOTE THAT THIS DEFECT IS SHOWING UP ON A NUMBER OF THESE BIKES--THERE IS A THREAD DISCUSSING THE ISSUE AT: HTTPS://FORUMS.BMWMOA.ORG/SHOWTHREAD.PHP?98612-2018-R1200RT-WITH-INTERMITTENT-CHECK-ENGINE-LIGH… Look up ODI 11363484 at NHTSA ↗ |
|---|
| Electrical System | 00.0%No examples available for this selection. | 12.7%ODI 10488899 · 127,988 miAFTER FILLING UP ON FUEL AND DRIVING HOME (LESS THAN FIVE MILES), I PARKED THE MOTORCYCLE. LATER IN THE DAY, I NOTICED FUEL ON THE ASPHALT BENEATH THE BIKE AND LEAKING FROM THE FUEL PUMP, DOWN ONTO THE ENGINE, LEFT EXHAUST PIPE AND OTHER PARTS OF THE FRAME. FURTHER INSPECTING, I FOUND FUEL POOLED ATOP THE FUEL PUMP HOUSING. MOPPING UP THE FUEL, I IDENTIFIED A HAIRLINE CRACK IN THE UPPER PLASTIC HOUSING THAT HOLDS THE FUEL PUMP, FUEL PUMP ELECTRONICS AND FUEL LINE CONNECTION. THE FUEL PUMP ELECTRONICS UNIT WAS DAMAGED BY EXPOSURE TO THE FUEL,… Look up ODI 10488899 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 316.7%ODI 10605939 · 2,000 miTL* THE CONTACT OWNS A 2008 BMW R1200 GS MOTORCYCLE. THE CONTACT STATED THAT THE ANTI- LOCK BRAKING SYSTEM ENGAGED AND TURNED OFF INDEPENDENTLY WITHOUT ANY WARNINGS. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE ANTI-LOCK BRAKE SYSTEM CONTROL UNIT NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN RECALL NHTSA CAMPAIGN NUMBER: 09V129000 (ELECTRICAL SYSTEM). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 2,000 AND THE CURRENT… Look up ODI 10605939 at NHTSA ↗ | 422.2%ODI 10504958 · 12,000 miFUEL GAUGE FREQUENTLY INDICATES PLENTY OF FUEL IN TANK WHEN TANK RUNS EMPTY. GAUGE WILL ALSO OCCASIONALLY SHOW EMPTY WHEN SEVERAL GALLONS OF FUEL IN TANKS. *TR ## VIN FAILED ## Look up ODI 10504958 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 110.0%ODI 10747595 · 500 miTL* THE CONTACT OWNS A 2015 BMW R1200 GS ADVENTURER. THE CONTACT STATED THAT THE MOTORCYCLE STALLED NUMEROUS TIMES WITHOUT WARNING. THE MOTORCYCLE WAS TAKEN TO THE DEALER EVERY THREE MONTHS. THE TECHNICIAN WAS UNABLE TO REPLICATE AND DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT ABLE TO PROVIDE A REMEDY TO PREVENT THE FAILURE FROM RECURRING. THE MOTORCYCLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 500. THE VIN WAS NOT AVAILABLE. Look up ODI 10747595 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 125.0%ODI 11661315 · 11,500 miThe contact owns a 2018 BMW R 1200 GS. The contact stated while riding the motorcycle at an undisclosed speed, the RPM's decreased and the motorcycle lost motive power. In addition, the contact stated that the failure had occurred several times. The contact pulled over to the shoulder of the road. The motorcycle was taken to the dealer where it was diagnosed with corrosion on the Dynamic Motor Engine (DME) connector pins. The contact was informed that the DME connector pins needed to be cleaned. The motorcycle was repaired. The manufacturer was… Look up ODI 11661315 at NHTSA ↗ |
|---|
| Steering | 00.0%No examples available for this selection. | 12.7%ODI 10643951 · 62,000 miUPON REPLACING REAR TIRE AT THE BMW DEALERSHIP, NOTICED A CRACKED REAR WHEEL FLANGE. THESE CRACKS APPEARED ON 4 OF 5 ATTACHMENT POINTS WHERE THE FLANGE BOLTS ONTO THE REAR DRIVE. THIS IS A PART THAT HOLDS THE WHEEL TO THE MOTORCYCLE. SPOKE TO BMW NA AND THEY DO RECOGNIZE THE PROBLEM AS INHERENT DEFECT, AND HAVE NOT RECALLED DESPITE HAVING REDESIGNED THE REPLACEMENT PART SEVERAL TIMES OVER THE LAST FEW YEARS (IMPLIED ADMISSION BY BMW OF THE INHERENT DEFECT DUE TO REDESIGN). THIS IS SAFETY ISSUE RELATED TO AN INHERENT DEFECT OF SAFETY CRITICA… Look up ODI 10643951 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 15.6%ODI 10630849 · 20,200 miON 17 AUGUST 2014 AT NEWCOMB'S RANCH IN THE ANGELES NATIONAL FOREST EAST OF LOS ANGELES AT APPROXIMATELY 10:15 AM I DISCOVERED THAT THE IGNITION SWITCH DETENT MECHANISM HAD FAILED ON MY 2008 BMW R1200GS MOTORCYCLE. I WAS ABLE TO FREELY ROTATE THE IGNITION KEY BETWEEN ON AND OFF, SO THAT THE SLIGHTEST TORQUE FROM A KEY FOB OR WIND COULD TURN THE KEY TO OFF, WHICH WOULD SHUT THE ENGINE AND ALL ELECTRICAL SYSTEMS OFF, PERHAPS UNEXPECTEDLY DURING OPERATION OF THE VEHICLE. THE FAILED IGNITION SWITCH DETENT CONDITION APPARENTLY OCCURRED DURING MY ONE… Look up ODI 10630849 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 240.0%ODI 10983725WHILE RIDING FORK OIL BEGIN TO LEAK OUT OF THE TOP OF THE LEFT FORK. ONCE REMOVING THE RUBBER COVER I NOTICED THAT THE FORK TUBE HAD SEPARATED FROM THE HEAD ENOUGH TO CAUSE LEAKAGE AND LOSS OF OIL. I REMOVED THE RIGHT COVER AS WELL AND NOTICED THE FORKS WERE STARTING TO SEPARATE ALSO. THIS CAUSED PLAY IN MY STEERING AS WELL AS THE END OF MY TRIP. I RETURNED THE BIKE TO THE DEALERSHIP AND THEY REPLACED THE FORKS UNDER WARRANTY. THIS WAS AUGUST OF 2016. SINCE THAT TIME I HAVE HEARD OF NUMEROUS ACCOUNTS OF THIS INCIDENT HAPPENING. A FELLOW MOTORCY… Look up ODI 10983725 at NHTSA ↗ | 110.0%ODI 11000810WHILE TRAVELING AT APPROXIMATELY 25 MPH ON A NATIONAL FOREST ROAD THE FRONT SUSPENSION COLLAPSED CAUSING ME TO LOSE CONTROL AND CRASH AND CAUSING INJURY MANUFACTURE REPLACED EVERYTHING UNDER WARRANTY NO DEFINITION TOO WHY PART FAILED Look up ODI 11000810 at NHTSA ↗ | 18.3%ODI 10990628 · 5,500 miI WAS TRAVELING IN ON A STRAIGHT PORTION OF PACIFIC COAST HIGHWAY IN HUNTINGTON BEACH. THERE WAS NO TRAFFIC AROUND AND NO DEBRIS IN THE ROAD. I WAS TRAVELING APPROXIMATELY 40 MPH WHEN THE HANDLEBAR ON MY MOTORCYCLE VIOLENTLY JERKED TO THE LEFT FOR A SPLIT SECOND AND CORRECTED ITSELF. THIS WAS NOT NORMAL AND VERY DANGEROUS. I LOOKED AT THE HANDLEBAR AND NOTICED THAT IT WASN'T STRAIGHT OR SQUARE TO THE DIRECTION I WAS TRAVELING. A SECOND AFTER SEEING THE HANDLE BAR THE BIKE JERKED TO THE LEFT AGAIN, THIS TIME CAUSING ME TO LOSE CONTROL AND C… Look up ODI 10990628 at NHTSA ↗ | 00.0%No examples available for this selection. | 125.0%ODI 11373443 · 8,000 miWITHOUT WARNING THE MOTORCYCLE STEERING WENT INTO WHAT IS COMMONLY KNOW AS "DEATH WOBBLE" OR "TANK SLAPPING" WITH THE STEERING UNCONTROLLABLE RAPIDLY MOVING RIGHT TO LEFT AND IMMEDIATELY CRASHING CAUSING SEVERE INJURIES TO DRIVER. Look up ODI 11373443 at NHTSA ↗ |
|---|
| Service Brakes, Hydraulic | 125.0%ODI 10376817 · 45,000 miRIDING THE BIKE SLOWLY (ABOUT 40 KPH) AND BRAKED HEAVILY. DISINTEGRATION OF REAR WHEEL CARRIER (FLANGE) ON BMW GS1200 (2004) . THIS BILLET ALUMINUM FLANGE IS THE SINGLE COMPONENT CONNECTING THE REAR WHEEL WITH THE MOTORCYCLE. AND ALSO THE BRAKE DISK. THE PART BROKE APART UNDER HEAVY BRAKING AND THE BRAKE DISK DETACHED, RESULTING IN NO REAR WHEEL BRAKING AND DAMAGE TO THE ABS UNIT. CRITICAL FAILURE WILL CERTAINLY RESULT IN SERIOUS INJURY OR DEATH. BMW AUSTRALIA HAS BEEN ADVISED AND OFFERED NO RECOURSE TO CORRECT RO ADVISE OTHER OWNERS. ABS MODU… Look up ODI 10376817 at NHTSA ↗ | 25.4%ODI 10202317 · 6,000 miREAR BRAKE PADS WEAR OUT PREMATURELY, TYPICALLY IN 6000 MILES, AS OPPOSED TO TYPICAL PAD LIFE WHICH IS ~18-24000 MILES. NO SYMPTOMS WERE NOTED PREVIOUS TO THE BRAKE PADS WEARING OUT. WHEN REAR BRAKE PADS WEAR OUT, THERE IS LOSS OF REAR BRAKING ABILITY. THIS DID NOT CAUSE AN ACCIDENT FOR ME, BUT COULD EASILY CATCH A RIDER BY SURPRISE AND CAUSE A CRASH AS A RESULT OF LOSS OF REAR BRAKE. BMW CLAIMS THAT THIS IS NORMAL FOR THESE BIKES, AND THEREFORE NOTHING WAS DONE TO FIX THE ACTUAL PROBLEM, ASIDE FROM HAVING THE OWNER PAY AND HAVE NEW BRAKE P… Look up ODI 10202317 at NHTSA ↗ | 125.0%ODI 10276585 · 8,000 miHAND GUARD ROTATED INTO A POSITION THAT RESTRICTED THE BRAKE LEVER FROM FULLY DISENGAGING THE BRAKES. THIS CAUSED THE BRAKES TO OPERATE WHILE THE MOTORCYCLE WAS IN MOTION. THE OPERATOR NOTICED THAT THE BRAKES WERE SLIGHTLY ENGAGED (DUE TO THE NOISE OF THE BRAKE SERVOS) EVEN THOUGH THE BRAKE LEVER AND PEDAL WERE NOT BEING ENGAGED BY THE OPERATOR. THE PROBLEM WAS RECTIFIED BY TWISTING THE HAND GUARD BACK INTO POSITION. HAD THE PROBLEM NOT BEEN RECTIFIED IN A TIMELY MANNER, OVERHEATING OF THE BRAKE SYSTEM COULD HAVE OCCURRED LEADING TO THE BREAKS … Look up ODI 10276585 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
|---|