Chevrolet EXPRESS 1500 brakes problems

THE PASSENGER SIDE AIRBAG EMPLOYED WHEN THE VEHICLE WAS PARKED INSIDE THE SHOP. THE VEHICLE IS AVAILABLE FOR INSPECTION AT STANLEY CHEVROLET CELINA TX [phone removed] CONTACT GARY WERNER SERVICE MANAGER. THE VEHICLE OWNER IS RICK DIETEL OF AMERSOL INC. [phone removed]. *TR

Look up ODI 10262412 at NHTSA ↗

THE AIRBAGS IN MY EXPRESS 1500 DID NOT DEPLOY AFTER I SKIDDED OUT ON A HIGHWAY TO AVOID A 18 WHEELER. THE VAN WAS TOTALED SO NOTHING WAS DONE TO CORRECT IT BUT WITH NO AIRBAGS IT LED TO A BROKEN SHOULDER AND SOME RIBS FROM THE STEERING WHEEL. I HIT THE JERSEY BARRIER GOING DIRECTLY STRAIGHT AT IT AT ABOUT 50-60MPH. *TR

Look up ODI 10371015 at NHTSA ↗

TL*THE CONTACT OWNS A 2007 CHEVROLET EXPRESS 1500. THE CONTACT STATED THAT THE AIR BAGS WERE DEFECTIVE. HIS VEHICLE WAS STRUCK FROM THE REAR WHILE IT WAS PARKED AND THE AIR BAGS FAILED TO DEPLOY. THE DRIVER WHO CRASHED INTO HIM WAS KILLED. FOUR PEOPLE WERE INJURED IN THE CONTACT'S VEHICLE AND FOUR PEOPLE WERE INJURED IN THE OTHER VEHICLE. THE VEHICLE WAS DESTROYED. A POLICE REPORT WAS FILED. THE MANUFACTURER ISSUED THE CONTACT A CASE NUMBER, HOWEVER, THEY DID NOT EXPLAIN WHY THE AIR BAGS DID NOT DEPLOY AND IF THE VEHICLE WAS INCLUDED IN …

Look up ODI 10197813 at NHTSA ↗

VEHICLE HAD AN ELECTRONICALLY FAILED FRONTAL CRASH SENSOR.I PURCHASED A NEW PART FROM GM.THE PART WAS INSTALLED AND THE CONNECTOR WOULD NOT FIT IN.I CHECKED THE ALIGHNMENT OF SLOTS AND THE CONFIGURATION MATCHED THE OLD ONE. UPON FURTHER INVESTIGATION I NOTICED THE MOLD OF THE PLASTIC WAS DISTORTED.CHECKING THE ORIGIN OF THIS PART (MADE IN SINGAPORE).MY THOUGHTS ARE THAT IF THERE NOT TESTING THE FIT,HOW CAN WE BE SURE THAT IN THE EVENT OF A CRASH IT WOULD EVEN SEND THE SIGNAL TO DEPLOY THE AIR BAG.EVEN THOUGH THE SDM UNIT CHECKS THE RESISTANCE V…

Look up ODI 10850343 at NHTSA ↗

I'M FROM AN INDEPENDENT REPAIR SHOP. I HAVE RECENTLY HAD PROBLEMS WITH THIS 2009 EXPRESS VAN. IT HAS FOR NO REASON THAT I CAN TELL. DEPLOYED THE SIDE AIR BAGS WHILE BACKING THE VEHICLE UP A DRIVEWAY @ LESS THAN 5 MPH. TO GIVE YOU A LITTLE HISTORY ABOUT THE VEHICLE. THE CUSTOMER PURCHASED THE VEHICLE FROM A USED CAR DEALER APPROXIMATELY 6 MONTH AGO. THE FIRST PROBLEM WITH THE VEHICLE WAS WITH THE STABI-TRAC & REDUCED POWER LIGHT CAME ON . WE HOOKED UP ARE TECH-2 SCAN TOOL AN RETRIEVED THE CODES AN DIAGNOSED THE PROBLEM WITH THE STEERING WHE…

Look up ODI 10588195 at NHTSA ↗

STARTED VEHICLE AND "SERVICE AIR BAGS" WARNING CAME ON. IT HAS COME ON AT EVERY START SINCE. ON 3/20/14 CHEVROLET DEALER REPAIR DEPARTMENT DIAGNOSED A FAULTY FRONT SENSOR. REPLACEMENT WILL BE AVAILABLE NEXT WEEK. *TR

Look up ODI 10573723 at NHTSA ↗

MY AIR BAG WARNING LIGHT CAME ON AND WHEN I INVESTIGATED I FOUND IT WAS PROBABLY RELATED TO THE FRONT AIR BAG SENSORS. WHEN I EXAMINED THE SENSORS I FOUND THAT THE ALUMINUM ALLOY BODY AND THE PLASTIC SHIELD SURROUNDING IT HAD SPLIT WIDE APART WHERE THE STEEL MOUNTING SCREW PASSED THROUGH THE SENSOR HOUSING. BOTH SENSORS HAVE FAILED IN EXACTLY THE SAME MANOR. THE VEHICLE HAS 83,000 MILES ON IT AND DOES NOT HAVE ANY OTHER OF ADVANCED CORROSION ANYWHERE ELSE. I CONTACTED GM AND THEY SEEMED TO HAVE NO INTEREST AND ADVISED ME TO TAKE IT TO A DEAL…

Look up ODI 11318814 at NHTSA ↗

TL* THE CONTACT OWNS A 2014 CHEVROLET EXPRESS 1500. THE CONTACT WAS DRIVING 40 MPH AND CRASHED INTO ANOTHER VEHICLE. THE AIR BAG WARNING LIGHT ILLUMINATED AND FAILED TO DEPLOY. THE CONTACT DID NOT NEED MEDICAL ATTENTION IMMEDIATELY, BUT DID RECEIVE MEDICAL ATTENTION TWO DAYS LATER DUE TO UNKNOWN INJURIES SUSTAINED IN THE CRASH. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A POLICE YARD AND WAS NEITHER INSPECTED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 40,000. THE VIN WAS NOT AVAILABLE.

Look up ODI 10672838 at NHTSA ↗

BRAKES FAILED WITH NO WARNING. UPON INSPECTION IT WAS DETERMINED THAT BRAKE LINES BURST DUE TO RUSTING.

Look up ODI 10544234 at NHTSA ↗

I WAS TRAVELING DOWN A HILL AT ABOUT 35-40 MPH. WHEN THE ABS SYSTEM KICKED IN FOR SOME REASON AND THE BRAKES WENT STIFF AND I COULD BARELY STOP. MECHANIC SAID WHEEL SENSOR, IT WAS CHANGED AND I HAVE THE SAME PROBLEM. THE ABS KICKS IN AT THE WORST TIMES WHEN YOU ARE SLOWING DOWN COMING TO AN INTERSECTION THE BRAKES GO STIFF. ALMOST GOT KILLED. *TR

Look up ODI 10521963 at NHTSA ↗

TL* THE CONTACT OWNS A 2007 CHEVROLET EXPRESS 1500. THE CONTACT STATED THAT WHILE DRIVING AT 40 MPH, THE BRAKE PEDAL WAS DEPRESSED AND TRAVELED TO THE FLOOR BOARD. AS A RESULT, THE CONTACT CRASHED INTO THE REAR OF ANOTHER VEHICLE. THE AIR BAGS DID NOT DEPLOY. THE CONTACT AND OTHER DRIVER SUSTAINED WHIP LASH. NO MEDICAL ATTENTION WAS REQUIRED. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE HYDRAULIC BRAKE LINE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE CONTACT ALSO…

Look up ODI 10809972 at NHTSA ↗

WE'VE COMPLAINED NUMEROUS TIMES ABOUT THE BRAKES. AFTER HAVING A COMPLETE BRAKE REHAB ON JULY 7TH, 2017, I EXPERIENCED A COMPLETE BRAKE FAILURE ON FEB. 2ND, 2018 LOSING ALL BRAKES INSTANTLY AS I APPROACHED A 6 LANE INTERSECTION. I CONTACTED THE OWNER OF THE DEALERSHIP BOTH BY PHONE AND EMAIL AND DID NOT RECEIVE ANY RESPONSE. I WAS TOLD THAT A HOSE OR TUBING WAS RUBBING AGAINST THE BRAKE LINES CAUSING AN ABRUPT LOSS OF FLUID? WHY THIS WAS NOT NOTICED DURING THE EARLIER BRAKE WORK SEEMS QUESTIONABLE. MOREOVER, I AM OUT HUNDREDS OF DOLLARS FOL…

Look up ODI 11153606 at NHTSA ↗

WE DEVELOPED A SIGNIFICANT LEAK IN A REAR BRAKE LINE OF OUR VAN. THE LEAK DID NOT LEAD TO A LOSS OF CONTROL, BUT THE BRAKE RESERVOIR WAS NEARLY EMPTY WHEN I DISCOVERED THE ISSUE. THE LEAK WAS DISCOVERED BASED ON A LARGE SPOT LEFT ON OUR DRIVEWAY UNDER THE VAN. THE VEHICLE WAS PROBABLY DRIVEN ABOUT 50-100 MILES (ONE TO TWO DAYS) AFTER THE LEAK DEVELOPED BUT BEFORE THE ISSUE WAS DISCOVERED AND ADDRESSED. WHILE FIXING THE PROBLEM, I FOUND THAT THE LEAK WAS DUE TO AN ASSEMBLY ERROR. THE VAN'S FUEL FILLER DOWN-PIPE HAS A WORM-GEAR CLAMP THAT WAS…

Look up ODI 11306239 at NHTSA ↗

WHEEL BEARINGS AND TIRES ARE BECAUSE OF RE-CALL ON THE TORG IS NOT ALIGN PUT BRAND NEW TIRES ON AND THE TIRES ARE ALREADY BALD IN THE FRONT.

Look up ODI 11055391 at NHTSA ↗

My spouse was driving our family south on Hwy 101 at about 50 mph near Arch Cape, Oregon on June 25, 2022 during 93 degree weather. Just before Falcon Cove state park as we were going up a hill and people were braking to turn into the park, my spouse yelled "we have no brakes". The brakes were hard as a wall and he was using both feet to get us to slow down. I could not feel us slowing. It was utterly terrifying. He did finally get us slowed down likely due to the weight we were carrying and the hill. But the brakes were so terrible we couldn't…

Look up ODI 11472033 at NHTSA ↗

ON A FEW OCCASIONS PRIOR TO LOCATING A LEAK, I NOTICED A GASOLINE SMELL. FINALLY WHEN FILLING EARLIER THIS MONTH, I SAW A LOT OF LEAKING COMING OUT OF THE FUEL FILLER TUBE, BETWEEN THE METAL TUBE AND THE PLASTIC COVER SURROUNDING THE TUBE. WHEN I GOT HOME, I CUT OFF THE PLASTIC TUBE ABOUT HALFWAY AND FOUND A STATIC WIRE RUNNING THE LENGTH OF THE TUBE. EVERYWHERE, WHERE THIS WIRE TOUCHED TO METAL PIPE, IT WAS CORRODED COMPLETELY THROUGH. THE STATIC WIRE IS OF A DIFFERENT MATERIAL AND WAS NOT CORRODED. PRESENTLY I HAVE WRAPPED THE TUBE WITH A…

Look up ODI 10459328 at NHTSA ↗

TL* THE CONTACT OWNS A 2004 CHEVROLET EXPRESS. THE CONTACT STATED THAT AFTER REFUELING, FUEL SPEW BACK OUT OF THE FILLER NECK. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 12V388000 (FUEL SYSTEM, GASOLINE: STORAGE: TANK ASSEMBLY: FILLER PIPE AND CAP). THE FAILURE AND CURRENT MILEAGE WAS 114,000. UPDATED 10/16/12*LJ THE CONSUMER STATED THE FUEL FILLER NECK CORRODED UPDATED 10/19/2012 *JS

Look up ODI 10471862 at NHTSA ↗

WE OWN BOTH A 1998 AND 2000 EXPRESS VAN AND WE HAVE A PROBLEM WITH BOTH OF THEM WITH REGARDS TO THE SIDE PASSENGER DOORS (THE 'DOUBLE' DOORS). WE HAVE HAD A DEALER DRILL HOLES IN THE HINGES TO LUBRICATE THEM AS THEY SEIZE UP AND BECOME VERY HARD TO OPEN AND CLOSE. THIS IS JUST A TEMPORARY AND EVENTUALLY AN INEFFECTIVE FIX. I BELIEVE THIS IS A SAFETY HAZARD AS WE HAVE 6 CHILDREN OF WHICH 3 HAVE TO SIT IN THE BACK SEAT AND IF THERE WERE TO BE AN EMERGENCY WE WOULDN'T BE ABLE TO GET THE LEFT DOOR OPEN TO GET THE KIDS OUT FASTER. *TR

Look up ODI 10228933 at NHTSA ↗

THE PASSENGER SIDE SWING DOORS ARE VERY HARD TO OPEN AND SHUT AND THE DRIVERS SIDE SWING DOORS ARE IN THE INITIAL STAGE OF THIS. THE PASSENGER SWING DOOR THAT IS FIRST TO OPEN (RIGHT) DOES NOT WANT TO OPEN AND DOESN'T WANT TO SHUT. I HAVE TO FORCE IT. THE SECOND DOOR (LEFT) IS GETTING WORSE AS WELL. THIS IS CAUSING THE INTERIOR LIGHT PIN IN THE DOOR JAM TO NOT PUSH IN ALL THE WAY, THEREFORE; THE LIGHTS WILL NOT SHUT OFF.

Look up ODI 10748421 at NHTSA ↗

I WAS TRAVELING EAST THRO AN INTERSECTION WHEN A TRUCK ON THE MY RIGHT RAMMED ME IN THE FRONT RIGHT SIDE OF MY CAR.I FELT THE CAR SPIN AND THE TRUCK ENDED UP IN MY RIGHT REAR BUMPER AND WHEN I CAME TO A STOP BOTH AIRBAGS DEPLOYED AND I WAS INJURED AND THE AIRBAGS EXPLODED AND I HAVE EYE DAMAGE TO MY RIGHT EYE AND NECK INJURY AND BACK INJURY. STILL SEEING SPINE DR. AND EYE DR EVERY 6 MONTHS. *TR

Look up ODI 10722109 at NHTSA ↗

TL* THE CONTACT OWNS A 2008 CHEVROLET EXPRESS 1500. THE CONTACT STATED THAT BOTH REAR DOORS WERE EXTREMELY HARD TO OPEN AND CLOSE. THE CONTACT TOOK THE VEHICLE TO THE DEALER, WHO STATED THAT THE DOORS WERE MANUFACTURED TO OPERATE AS THEY WERE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURE WAS NOTIFIED ABOUT THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.

Look up ODI 10567413 at NHTSA ↗

NOT SURE I HAVE THIS UNDER THE RIGHT "AFFECTED PARTS", I PURCHASED A NEW VAN, HAD DRIVEN MY PREV VAN 238,000+ MILES SO I KNOW HOW TO USE MIRRORS, HOWEVER, THE SPLIT MIRRORS ON THESE NEW VANS DO NOT ALLOW YOU TO SEE PROPERLY BACKING UP & I FOUND THIS TO BE A DANGER. CONTACTED CHEVY AND THEY WERE NOT INTERESTED IN DOING ANYTHING ABOUT IT SO I PURCHASED SOLID MIRRORS AND REPLACED THEM AT MY OWN EXPENSE. WONDERED IF THERE WERE ANY OTHER COMPLAINTS???? *TR

Look up ODI 10632019 at NHTSA ↗

TL* THE CONTACT OWNS A 2000 CHEVROLET EXPRESS 1500. THE CONTACT STATED THAT THE IGNITION FAILED TO START WITH SEVERAL ATTEMPTS, HOWEVER AFTER WAITING FIFTEEN MINUTES THE VEHICLE BEGAN TO OPERATE NORMALLY. THE VEHICLE WOULD ALSO STALL UNEXPECTEDLY WHEN DRIVING AND THEN RESTART. THE FAILURE RECURRED NUMEROUS TIMES. A CERTIFIED MECHANIC REPLACED THE PASS-LOCK SECURITY SYSTEM. IN ADDITION, THE DEALER REPLACED THE IGNITION SWITCH. THE FAILURE NO LONGER PERSISTED AFTER BOTH REPAIRS WERE PERFORMED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE AP…

Look up ODI 10573032 at NHTSA ↗

AT 4:30 A.M. ON THE MORNING OF FEB 13 2008 WAS AWOKE TO FLAMES FLICKERING ON BEDROOM WALL IT WAS MY 2003 REGENCY CONVERSION VAN GOING UP IN SMOKE NO APPARENT REASON BUT IT DID START IN THE FUSE BOX AREA MAYBE THE SAME ISSUE AS THE HORN PROBLEM THE WEEK BEFORE HAD THE SAME PROBLEM OF HORN GOING OFF IN THE MIDDLE OF THE NIGHT BUT THERE WAS NO FIRE AT THAT TIME. *TR

Look up ODI 10219006 at NHTSA ↗

TL* THE CONTACT OWNS A 2005 CHEVROLET EXPRESS 1500. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE VEHICLE STALLED WITHOUT WARNING. AN INDEPENDENT MECHANIC DIAGNOSED THAT THE IGNITION MODULE FAILED, AND MADE THE NECESSARY REPAIRS. THE MANUFACTURER WAS NOTIFIED AND ADVISED THAT THERE WERE NO OPEN RECALLS FOR THE VEHICLE. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.

Look up ODI 10586130 at NHTSA ↗

WE HAVE HAD 2 CHEVY EXPRESS 1500 VANS CATCH FIRE TO THE DRIVER DOOR FROM A FAULTY WINDOW SWITCH. SIMILIAR TO A PREVIOUS GM SUV RECALL: HTTP://WWW.AUTOBLOG.COM/2014/08/07/GM-SUV-WINDOW-SWITCH-RECALL-FIRE-HAZARD-PARK-OUTSIDE/ THIS HAS HAPPENED ONCE WHILE THE VEHICLE WAS IN MOTION AND ANOTHER TIME WHILE THE VEHICLE WAS STOPPED. CAN PROVIDE PICS IF NECESSARY

Look up ODI 10899697 at NHTSA ↗

FUEL LEAKING FROM FUEL TANK FILLER TUBE WHEN FILLING GAS TANK. *TR

Look up ODI 10353717 at NHTSA ↗

DRIVING ALONG THE HIGHWAY, MY WARNING LIGHT CAME ON STATING THERE WAS AN ENGINE PROBLEM. I WAITED TO GET IT CHECKED OUT. AS I WAS MAKING A DELIVERY THE 2006 EXPRESS CARGO STALLED ON THE HIGHWAY. HAD IT TOWED TO THE CHEVROLET DEALERSHIP AND THEY STATED IT WAS THE FUEL SENSOR IN THE GAS TANK THAT BURNT OUT. *TR

Look up ODI 10254660 at NHTSA ↗

TL*THE CONTACT OWNS A 2001 CHEVROLET EXPRESS 1500 EQUIPPED WITH TBC SIGMA SHADOW TIRES, SIZE P235/75/R15. WHILE DRIVING 60 MPH, THE LEFT REAR SIDE TIRE BEGAN MAKING NOISES AND THERE WAS A LOUD TUG. AFTER STOPPING, THE CONTACT NOTICED THAT ABOUT 95% OF THE TREAD WAS OFF THE TIRES. NEITHER THE DEALER NOR THE MANUFACTURER WERE NOTIFIED. THE FAILURE MILEAGE WAS 56,000.

Look up ODI 10378420 at NHTSA ↗

TL*THE CONTACT OWNS A 2002 CHEVROLET EXPRESS 1500. THE VEHICLE HAS COOPER COBRA RADIAL TIRES, SIZE P255\70R15 (NA). WHILE DRIVING APPROXIMATELY 70 MPH, THE TIRE TREAD SEPARATED WITHOUT WARNING ON THE REAR DRIVER'S SIDE OF THE VEHICLE. THE CONTACT PULLED TO THE SIDE OF THE ROAD AND CALLED ROADSIDE ASSISTANCE. THE TIRE WAS CHANGED AND THE CONTACT CONTINUED TO HIS DESTINATION. THE FAILURE RECURRED ON THE REAR PASSENGER SIDE OF THE VEHICLE. AN INDEPENDENT TIRE COMPANY REPLACED THE TIRE. THE CONTACT NOTICED THAT THE AIR PRESSURE IN THE FRONT …

Look up ODI 10244090 at NHTSA ↗

WE PURCHASED A COMPLETE SET OF GENERAL GRABBER HTS 235/75R16 FOR OUR CHEVY EXPRESS VAN AT DUNN TIRE ON 11/15/08. THEY WERE SUPPOSED TO HAVE A 60K WARRANTY. WE WENT IN FOR THE REQUIRED ROTATIONS AND NOTED THAT THE TREAD DIDN'T SEEM TO BE WEARING WELL. AT THE 20K MILE ROTATION IN JANUARY OF 2011, DUNN TIRE ACKNOWLEDGED THAT THE TIRES WERE NOT PERFORMING AS ADVERTISED AND TOLD US THAT THEY WOULD LIKELY NEED TO ADJUST THE TIRES ON A PRO-RATA BASIS AT THE NEXT ROTATION AT 25K MILES. IT IS OUR BELIEF THAT THE TIRES ARE DEFECTIVE IN SOME WAY. THE…

Look up ODI 10401305 at NHTSA ↗

TL* THE CONTACT OWNS A 2014 CHEVROLET EXPRESS 1500. WHILE DRIVING AT APPROXIMATELY 60 MPH, THE FRONT DRIVER SIDE TIRE BLEW OUT AND CAUSED THE CONTACT TO CRASH INTO A WALL FOUR TIMES. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT AND A PASSENGER SUSTAINED UNKNOWN INJURIES THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 50,000. THE VIN WAS UNAVAILABLE.

Look up ODI 10726064 at NHTSA ↗

REAR SEAT BELTS FAIL TO LOCK MY VEHICLE IS A CONVERSION VAN BUILT BY DEBUT IN SAGINAW MICHIGAN. RECENTLY MY GRANDCHILDREN NOTICED THAT THE REAR SEAT BELTS FAILED TO LOCK. THOSE BELTS ARE ON THE SEAT/BED UNIT. THE SEAT BELTS HAVE THE NAME ATWOOD MOBILE PRODUCTS ON THEM. I INSPECTED THE SEAT BELTS AND DETERMINED THAT THE PLASTIC COATING ON THE MALE END OF THE BELT PREVENTED THE MECHANISM FROM PROPERLY LOCKING IN PLACE. I CUT ENOUGH OF THE PLASTIC COATING OFF TO ALLOW THE ENDS TO PROPERLY LOCK IN PLACE. THEY WORK FINE NOW. MY CONCERN IS…

Look up ODI 10749683 at NHTSA ↗

(1)SEAT BELT WILL NOT LATCH. SEATBELT LATCH OPENS WITHOUT WARNING. (2)THE SIDE CARGO DOOR HINGES ARE FAULTY AND HARD TO OPEN. OPENS WITHOUT WARNING. *TR

Look up ODI 10233227 at NHTSA ↗

PURCHASED THIS VEHICLE IN ORDER TO TRAVEL WITH PASSENGERS BUT ON MY FIRST ATTEMPT THIS HOLIDAY DISCOVERED THE SEAT BELTS WILL NOT EXTEND ENOUGH TO ACCOMMODATE MOST PASSENGERS. I CAN NOT AFFORD TO REPLACE THEM NOR DO I WANT TO BE LEGALLY CHARGED WITH UNLAWFUL EQUIPMENT (OR RESPONSIBLE FOR HARM TO ANYONE IN MY VEHICLE). THIS IS MY FIRST TIME DEALING WITH SUCH A DILEMMA AND WOULD APPRECIATE ANY INPUT THAT THE COMPANY MAY ADVISE. IS THIS AN OVERSITE ON THE MANUFACTURER TO BUILD A VEHICLE THAT WILL NOT MEET REGULATIONS?

Look up ODI 11003312 at NHTSA ↗

I'M FROM AN INDEPENDENT REPAIR SHOP. I HAVE RECENTLY HAD PROBLEMS WITH THIS 2009 EXPRESS VAN. IT HAS FOR NO REASON THAT I CAN TELL. DEPLOYED THE SIDE AIR BAGS WHILE BACKING THE VEHICLE UP A DRIVEWAY @ LESS THAN 5 MPH. TO GIVE YOU A LITTLE HISTORY ABOUT THE VEHICLE. THE CUSTOMER PURCHASED THE VEHICLE FROM A USED CAR DEALER APPROXIMATELY 6 MONTH AGO. THE FIRST PROBLEM WITH THE VEHICLE WAS WITH THE STABI-TRAC & REDUCED POWER LIGHT CAME ON . WE HOOKED UP ARE TECH-2 SCAN TOOL AN RETRIEVED THE CODES AN DIAGNOSED THE PROBLEM WITH THE STEERING WHE…

Look up ODI 10588195 at NHTSA ↗