| Service Brakes | 430.8%ODI 10492330 · 200 miVIOLENT SHAKING WHILE APPLYING BRAKES. *TR Look up ODI 10492330 at NHTSA ↗ | 627.3%ODI 10521646 · 2,500 miTL* THE CONTACT OWNS A 2013 CHEVROLET EXPRESS. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE FRONT PASSENGER SIDE BRAKE ENGAGED AND THE ELECTRONIC STABILITY CONTROL LIGHT ILLUMINATED. THE CONTACT STATED THAT HE SLOWED THE VEHICLE DOWN AND THE LIGHT TURNED OFF AND THE VEHICLE FUNCTIONED PROPERLY. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION AND THEY STATED THAT THEY COULD NOT DIAGNOSE THE CAUSE OF FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 2,500. Look up ODI 10521646 at NHTSA ↗ | 17.1%ODI 11122692 · 36,000 miTL* THE CONTACT OWNS A 2014 CHEVROLET EXPRESS. WHILE SLOWING THE VEHICLE DOWN TO STOP, THE BRAKES SEIZED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO BLAISE ALEXANDER CHEVROLET (405 ALEXANDER DR, MUNCY, PA 17756, [phone removed]) WHERE IT WAS DIAGNOSED THAT AN UNKNOWN SENSOR NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT ASSIST. THE FAILURE RECURRED AND WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 36,000. Look up ODI 11122692 at NHTSA ↗ | 225.0%ODI 10853911 · 16,494 miBRAKES FAILED WHILE DRIVING DOWN A HILL IN 2ND GEAR. Look up ODI 10853911 at NHTSA ↗ | 320.0%ODI 11452869I'd be driving down the street and the brakes would start applying themselves by themselves . I took the van to Ganly Chevrolet the first time and they did a brake job and said it was fixed . I drove it about a half mile and was doing about 35MPH when the brakes locked , if I wasn't buckled in I probably would have gone through the window . I immediately took it back by putting the gas pedal to the floor . you could smell and see the brakes burning . later Ganly said I needed a Brake Module and kept the car After about 6months of having my Va… Look up ODI 11452869 at NHTSA ↗ | 1152.4%ODI 11031985 · 16 miMY COMPANY JUST RECENTLY PURCHASED DOZENS OF 2017 CHEVY EXPRESS VANS. ONE OF THESE NEW VANS (16 MILES ON ODOMETER) EXPERIENCED A FAULTY BRAKE BOOSTER MECHANICAL ISSUE WHICH CAUSED THE BRAKES TO ENGAGE WHILE TURNING THE STEERING WHEEL. THE DESIGN OF THE BRAKE BOOSTER INTEGRATION WITH THE POWER STEERING PUMP WAS PART OF THE PROBLEM. THIS IS POTENTIALLY FATAL DESIGN FLAW IF YOU MANUFACTURE A VEHICLE THAT WOULD ENGAGE THE BRAKES JUST BY TURNING THE STEERING WHEEL. Look up ODI 11031985 at NHTSA ↗ | 218.2%ODI 11244426 · 7,283 miTL* THE CONTACT OWNS A 2018 CHEVROLET EXPRESS. WHILE DRIVING APPROXIMATELY 35 MPH, THE BRAKES APPLIED AUTOMATICALLY. TO KEEP THE VEHICLE FROM STOPPING ABRUPTLY, THE CONTACT DEPRESSED THE ACCELERATOR PEDAL TO CONTINUE DRIVING. IN ADDITION, THE BRAKE INDICATOR ILLUMINATED DURING THE FAILURE. THE FAILURE RECURRED AND THE VEHICLE WAS TAKEN TO THREE DIFFERENT DEALERS, INCLUDING EMICH CHEVROLET [phone removed], LOCATED AT 2033 S WADSWORTH BLVD, LAKEWOOD, CO 80227) TO BE DIAGNOSED, BUT THE FAILURE COULD NOT BE DUPLICATED. THE CONTACT WAS INFORMED BY T… Look up ODI 11244426 at NHTSA ↗ | 00.0%No examples available for this selection. | 211.8%ODI 11454725Bought this van new & when traveling down a hill, brake assist helps slow up the van. Once the van is on level ground, it will NOT shift back out of the brake assist & it takes effort or time to return to normal D. I was told I must set up & find a hill. I had major water leaks in the van & once corrected, there started a whistling of air now. The passenger door was 1/4" off, nowhere near flush. How does that get missed? Lastly, the right read brake cylinder went out with less then 12,000 miles on it. Many many problems with this "new" va… Look up ODI 11454725 at NHTSA ↗ | 323.1%ODI 11634050This is a Forest River Sunseeker Motorhome on a 2021 Chevrolet Express chasis. On Friday, [XXX], after being in stop and go traffic for 10-15 minutes on [XXX] driving at 65 mph, a smell of burning brakes started filling up the motorhome. Then the vehicle started to wobble and the ABS light came on. Pulled over to the side and while applying brakes the vehicle shook/wobbled. Drove to a NTB tire store and the manager indicated it was not the tires but smelled like the brakes burning and advised not to drive it. Had it towed to Monument Chevr… Look up ODI 11634050 at NHTSA ↗ | 150.0%ODI 11671263The car always turns on the slippery road warning light when I drive over 60 miles per hour and the wheels lock up. Sometimes, the ABS warning light also comes on, along with error messages saying 'Service Traction Control' and 'Service StabiliTrak'. Look up ODI 11671263 at NHTSA ↗ | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. |
|---|
| Electrical System | 323.1%ODI 10725751 · 47,000 miTL* THE CONTACT OWNS A 2012 CHEVROLET EXPRESS. WHEN THE BRAKES WERE DEPRESSED AND RELEASED, THE VEHICLE BEGAN TO SHAKE VIOLENTLY. THE CONTACT MENTIONED THAT THE STABILITRAK ACTIVATED INDEPENDENTLY AFTER BEING TURNED OFF WITHOUT WARNING. THE VEHICLE WAS TAKEN TO DEALER. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 47,000. Look up ODI 10725751 at NHTSA ↗ | 522.7%ODI 10889389 · 2,000 miTL* THE CONTACT OWNS A 2013 CHEVROLET EXPRESS. THE CONTACT STATED THAT THERE WAS A WARNING LIGHT THAT RANDOMLY FLASHED, INDICATING A LOSS OF ENGINE POWER. IN ADDITION, THE VEHICLE RANDOMLY STALLED MORE THAN ONCE. THE FAILURE WAS REPORTED TO A DEALER, BUT THEY DID NOT HAVE THE TOOLS TO PROVIDE DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 2,000. Look up ODI 10889389 at NHTSA ↗ | 321.4%ODI 10809792 · 25,900 miVEHICLE WILL SHUT OFF WHILE DRIVING. NO WARNING SIGNS. WILL LOSE ALL POWER STEERING AND UNSTABLE CONTROL. WILL NOT START AFTER IT SHUTS DOWN FOR UP TO 24HRS. THIS VEHICLE ALSO HAS A HISTORY OF HARD/TROUBLE STARTING. WHEN IT TURNS OVER IS WILL GO INTO PROTECTION MODE "LOSS OF POWER". THIS PROBLEM STARTED AT 3,178 MILES AND HAS CONTINUED REGULARLY UP TO THE CURRENT 26, 050 MILES. JACK WILSON CHEVROLET OF SAINT AUGUSTINE HAS ATTEMPTED TO REPAIR THIS VEHICLE ELEVEN (11) TIMES SINCE THE 2ND DAY AFTER PURCHASE. AFTER OBTAINING ALL SERVICE RECORD… Look up ODI 10809792 at NHTSA ↗ | 112.5%ODI 10864330 · 45 miTL- Look up ODI 10864330 at NHTSA ↗ | 320.0%ODI 11120207TL* THE CONTACT OWNS A 2016 CHEVROLET EXPRESS. UPON STARTING THE VEHICLE, THE SERVICE THEFT DETERRENT SYSTEM WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO HAYWARD MITSUBISHI (25601 MISSION BLVD, HAYWARD, CA 94544, [phone removed]) AND THE CONTACT WAS INFORMED THAT THE IGNITION KEY COULD BE THE CAUSE OF THE FAILURE. THE VEHICLE WAS REPAIRED, BUT THE CONTACT WAS UNAWARE OF THE REPAIRS THAT WERE COMPLETED. THE CONTACT STATED THAT THE FAILURE RECURRED SEVERAL DAYS LATER. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHO AGAIN STATED THAT THE F… Look up ODI 11120207 at NHTSA ↗ | 29.5%ODI 11268920 · 18,029 miTL- THE CONTACT SENT THE COMPLAINT VIA EMAIL TO BE USED: ON 5/08/19 AFTER SEVERAL COMPLAINTS FROM OUR DRIVER THAT THE ELECTRICAL SYSTEM IN OUR 2017 EXPRESS CHEVY SHUTDOWN WHEN HITTING A BUMP OR SLAMMING THE DRIVER DOOR WE DECIDED IT WAS TIME TO GET IT CHECKED OUT VAN WAS NOT PURCHASED FROM AUTO NATION CHEVY IN LAKE WORTH FL,THIS DEALER WAS NOT ABLE TO LOCATE A PROBLEM THE SAME DESCRIBED PROBLEM CONTINUED TO PERSIST,WE DECIDED TO BRING THE VAN TO THE DEALER FROM WHOM IT WAS PURCHASED SCHUMACHER CHEVY IN NORTH PALM BEACH 05/13/19,UPON KEEPING THE… Look up ODI 11268920 at NHTSA ↗ | 327.3%ODI 11418581Unknown, electrical fire from inside passenger door, no external heat source, and heat source seems to be from inside the door. Vehicle was parked while fire occurred. Look up ODI 11418581 at NHTSA ↗ | 112.5%ODI 11221488 · 2,540 miTL* THE CONTACT RENTED A 2019 CHEVROLET EXPRESS VAN. THE CONTACT RENTED THE VEHICLE FROM BUDGET CAR RENTAL (1919 5TH AVE, SEATTLE, WA 98101). WHILE THE VEHICLE WAS PARKED ON A HILL, THE CONTACT'S MOTHER WAS EXITING FROM THE REAR PASSENGER SLIDING DOOR AND WITHOUT WARNING, THE SLIDING DOOR CLOSED ON THE CONTACT'S MOTHER'S RIGHT FOREARM AND CAUSED MINOR BRUISING. NO POLICE REPORT WAS FILED. THERE WAS MEDICAL ATTENTION AT THE SCENE WHEN THE CONTACT INJURED HER RIGHT FOREARM. NO DEALER WAS CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER W… Look up ODI 11221488 at NHTSA ↗ | 317.6%ODI 11433832 · 1,000 miThe contact owns a 2021 Jayco Redhawk. The contact stated that while inspecting underneath the RV the plumbing hoses and lines as well electrical wires, fuel line from the propane tank, and fuel line from the generator was just lying on the frame. The hoses and lines were not insulated or secured underneath the RV. The contact stated that he was concerned that a fire could have been started. The contact stated that he wire-tied all the wires, so they were not laying on the frame. The vehicle was taken to the dealer who only secured the wires wi… Look up ODI 11433832 at NHTSA ↗ | 00.0%No examples available for this selection. | 150.0%ODI 11671263The car always turns on the slippery road warning light when I drive over 60 miles per hour and the wheels lock up. Sometimes, the ABS warning light also comes on, along with error messages saying 'Service Traction Control' and 'Service StabiliTrak'. Look up ODI 11671263 at NHTSA ↗ | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. |
|---|
| Power Train | 17.7%ODI 10778557 · 100,000 miTHE ENGINE WILL GO TO LOW POWER AND NOT GO MORE THAN 30 MPH WITHOUT WARNING. THIS IS AN AMBULANCE CHASSIS AND IS A KNOW PROBLEM GM HAS NOT ADDRESSED YET IN THE 2012 AND 2013 CHASSIS. IT CAN DO THIS ON HWYS WITH SPEED LIMITS OF 55, 65, 70 MPH SUDDENLY WHICH COULD CAUSE AN ACCIDENT AS NO STOP LIGHTS GIVE ANY WARNING AND YOU CAN'T SPEED UP ANYTIME IN POOR VISIBILITY OR AT ANYTIME. NOT ONLY IS IT BAD FOR THE INJURED OR ILL PATIENT IT COULD CAUSE AN ACCIDENT AND INJURY OTHERS. GM HAS FIXED THIS ON THE 2014 AND NEWER MODELS BUT NOT 12 &13. THIS IS NO… Look up ODI 10778557 at NHTSA ↗ | 14.5%ODI 11057100THE TRANSMISSION IS SLIPPING AND I ONLY HAVE 77,000 MILES. IS THIS NORMAL? THE VAN IS ONLY A 2013 MODEL. Look up ODI 11057100 at NHTSA ↗ | 17.1%ODI 10970911 · 7,000 miDRIVING DOWN A HILL AT 30 MPH ON A ONE LANE CURVE THE VEHICLE COMPLETELY QUIT. I STRUGGLED TO TURN THE WHEEL TO THE SIDE OF THE ROAD. IT HAD 3/4 TANK OF FUEL AND ONLY 7,000 MILES ON IT. IT WOULD NOT START. CALLED AND GOT A TOW TO CHEVY DEALER WHERE IT WAS BOUGHT. THEY COULD NOT DUPLICATE IT. HAVE RECEIPT AND INFO FROM THEM. Look up ODI 10970911 at NHTSA ↗ | 00.0%No examples available for this selection. | 16.7%ODI 11634601 · 88,000 miThe contact owns a 2016 Chevrolet Express. The contact stated while driving 65 MPH, the “Service Engine” warning light flashed on and off. The contact stated that after arriving to the residence and shifting into reverse(R), the vehicle failed to respond as needed. The vehicle was turned off and restarted and the contact was able to park the vehicle. The vehicle was later towed to the dealer to be diagnosed. The contact was informed that the Progressive Snapshot device had caused the failure. The vehicle was repaired, and the Snapshot device wa… Look up ODI 11634601 at NHTSA ↗ | 00.0%No examples available for this selection. | 327.3%ODI 11516209Since purchasing this vehicle in 2018 we have had an ongoing issue of the car randomly going into a violent shaking when exceeding speeds of about 60mph, it happens without warning, and other than coming to an almost standstill, it is impossible to recover the vehicle. This is extremely dangerous on the freeway. Have taken the vehicle to Chevrolet dealership multiple times without any resolution. They would charge us for an alignment and this never fixed the problem. This continues to be an ongoing issue, and now having researched it on the… Look up ODI 11516209 at NHTSA ↗ | 450.0%ODI 11535437 · 4,783 miThe contact owns a 2019 Chevrolet Express. The contact stated that while the vehicle was stopped with the transmission in reverse(R), the vehicle moved forward. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and informed the contact that there was no recall on the VIN. The failure mileage was approximately 4,783. Look up ODI 11535437 at NHTSA ↗ | 952.9%ODI 11571580Transmission needs to be replaced at 70k miles and I have had all scheduled service maintenance done. Vehicle jerks hard when shifting gears. Look up ODI 11571580 at NHTSA ↗ | 215.4%ODI 11587552When I come to stop in traffic the drivetrain suddenly jolts and pushes the vehicle forward potentially pushing me into the car or traffic in front of me unless I put it in neutral or press hard on the brakes approaching the stoplight. Happens everyday. Look up ODI 11587552 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. |
|---|
| Air Bags | 17.7%ODI 11704917About 6:45 in the morning on November 10th, the vehicle was in a high-speed. Front end collision with adult cow elk at 70 miles an hour on the freeway, and the airbags failed to deploy in the Van on both front seats and the vehicle was severely damaged. Injuries were sustained. Look up ODI 11704917 at NHTSA ↗ | 29.1%ODI 10915564 · 48,000 miTL* THE CONTACT OWNS A 2013 CHEVROLET EXPRESS. WHILE DRIVING 43 MPH, THE VEHICLE WAS INVOLVED IN A CRASH. THE AIR BAGS DID NOT DEPLOY. IN ADDITION, THE SHOULDER OF THE SEAT BELT DID NOT LOCK, WHICH CAUSED THE CONTACT'S BODY TO BE JERKED AROUND IN THE SEAT. THE REAR PASSENGER SEAT BELT FRACTURED. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED INJURIES TO THE HEAD, THUMB, LOWER TORSO, AND KNEES. THE CONTACT ALSO SUFFERED WHIPLASH. MEDICAL ATTENTION WAS REQUIRED. THE VEHICLE WAS TOWED TO A REPAIR SHOP. THE MANUFACTURER WAS MADE AWARE OF THE FAIL… Look up ODI 10915564 at NHTSA ↗ | 428.6%ODI 10615263I HAVE BEEN WAITING OVER 5 WEEKS FOR THE PARTS TO COME IN TO CHAMPION CHEVROLET IN JOHNSON CITY TN BUT EVERY TIME I CALL THEY SAY THAT GM HAS NOT SENT THE PARTS TO FIX THE AIRBAG THAT IS ON RECALL. WHY MUST I WAIT THIS LONG TO HAVE A SAFETY ISSUE CORRECTED. *TR Look up ODI 10615263 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 314.3%ODI 11325324AIR BAG SENSOR HAS GONE BAD IT'S IN THE LEFT DOOR. *TR Look up ODI 11325324 at NHTSA ↗ | 00.0%No examples available for this selection. | 112.5%ODI 11755530The OTA had the interstate lanes bottle necked down. Traffic was trying to merge. The van had already slowed down and moved into the thru lane closest to the median. The van was pushed off the road by a semi into the contrete barrier. The semi clipped the bumper on the front passenger's side. It was also hit on the driver's side rear bumper. All of this caused the van to hit the wall on the front driver's corner. The airbags did not deploy! The driver was slammed into the steering wheel hitting his face against it. He suffered several facial fr… Look up ODI 11755530 at NHTSA ↗ | 00.0%No examples available for this selection. | 323.1%ODI 11559558 · 65,000 miThe contact owns a 2021 Chevrolet Express. The contact stated while driving at approximately 55 MPH the contact was crashed into by a deer, the contact stated that the deer struck the driver's side front headlight and then the driver's door. The contact stated that the left headlight was fractured and the grill was damaged by the deer strike. The contact stated that both side curtain air bags had deployed. The contact stated that the impact of the side air bag caused his left arm to pull down on the steering wheel which caused the vehicle to ve… Look up ODI 11559558 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. |
|---|
| Engine | 17.7%ODI 10778557 · 100,000 miTHE ENGINE WILL GO TO LOW POWER AND NOT GO MORE THAN 30 MPH WITHOUT WARNING. THIS IS AN AMBULANCE CHASSIS AND IS A KNOW PROBLEM GM HAS NOT ADDRESSED YET IN THE 2012 AND 2013 CHASSIS. IT CAN DO THIS ON HWYS WITH SPEED LIMITS OF 55, 65, 70 MPH SUDDENLY WHICH COULD CAUSE AN ACCIDENT AS NO STOP LIGHTS GIVE ANY WARNING AND YOU CAN'T SPEED UP ANYTIME IN POOR VISIBILITY OR AT ANYTIME. NOT ONLY IS IT BAD FOR THE INJURED OR ILL PATIENT IT COULD CAUSE AN ACCIDENT AND INJURY OTHERS. GM HAS FIXED THIS ON THE 2014 AND NEWER MODELS BUT NOT 12 &13. THIS IS NO… Look up ODI 10778557 at NHTSA ↗ | 731.8%ODI 10672499 · 900 miTHE FIRST AND SECOND (OF THREE INCIDENTS) BOTH APPEARED MINOR, LASTING ONLY A FRACTION OF A SECOND. ABOUT HALF WAY THROUGH A 150-MILE DRIVE, THE ENGINE WENT DEAD BUT AS QUICKLY FIRED UP AGAIN SO AS NOT TO BE TAKEN SERIOUSLY BY ME. BUT A THIRD INCIDENT WAS WORRISOME. WHILE DRIVING ABOUT 50 MPH ON A STRAIGHT, FLAT-AND-LEVEL STRETCH OF A MACADEM FARM ROAD, THE VAN SUDDENLY, VERY ABRUPTLY, SHIFTED INTO WHAT MUST HAVE BEEN ITS LOWEST GEAR, AND DURING ABOUT 15 OR 20 SECONDS THEREAFTER IT JERKED BACK AND FORTH AS IF IT WERE STRUGGLING TO CLIMB … Look up ODI 10672499 at NHTSA ↗ | 17.1%ODI 10809792 · 25,900 miVEHICLE WILL SHUT OFF WHILE DRIVING. NO WARNING SIGNS. WILL LOSE ALL POWER STEERING AND UNSTABLE CONTROL. WILL NOT START AFTER IT SHUTS DOWN FOR UP TO 24HRS. THIS VEHICLE ALSO HAS A HISTORY OF HARD/TROUBLE STARTING. WHEN IT TURNS OVER IS WILL GO INTO PROTECTION MODE "LOSS OF POWER". THIS PROBLEM STARTED AT 3,178 MILES AND HAS CONTINUED REGULARLY UP TO THE CURRENT 26, 050 MILES. JACK WILSON CHEVROLET OF SAINT AUGUSTINE HAS ATTEMPTED TO REPAIR THIS VEHICLE ELEVEN (11) TIMES SINCE THE 2ND DAY AFTER PURCHASE. AFTER OBTAINING ALL SERVICE RECORD… Look up ODI 10809792 at NHTSA ↗ | 112.5%ODI 11209193 · 24,000 miTL* THE CONTACT OWNS A 2015 CHEVROLET EXPRESS. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED, RESTARTED, AND THE CHARGING SYSTEM INDICATOR ILLUMINATED. THE CONTACT CALLED WALKER CHEVROLET (3940 CAROTHERS PKWY, FRANKLIN, TN 37067, [phone removed]) AND WAS INFORMED TO SCHEDULE A SERVICE APPOINTMENT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 24,000. Look up ODI 11209193 at NHTSA ↗ | 213.3%ODI 11282142 · 35,000 miTL* THE CONTACT OWNS A 2016 CHEVROLET EXPRESS. WHILE TRAVELING UP A HILL AT APPROXIMATELY 45 MPH, THE VEHICLE STARTED MISFIRING AND HESITATING. AFTER DEPRESSING THE ACCELERATOR PEDAL SEVERAL TIMES, THE VEHICLE RESPONDED NORMALLY. THE CONTACT STATED THAT THE FAILURES OCCURRED SINCE MAY OF 2019. THE VEHICLE WAS TAKEN TO GEORGE KELL MOTORS INC (3808S VAN DYKE RD, NEWPORT, AR 72112) FOUR TIMES AND THEY REPLACED THE TIMING BELT, TORQUE CONVERTER, FUEL INJECTORS, CATALYTIC CONVERTER, AND MUFFLER; HOWEVER, THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURE… Look up ODI 11282142 at NHTSA ↗ | 14.8%ODI 11196596 · 19,400 miWE'VE HAD 4 INSTANCES OF "ENGINE POWER REDUCED" AND CHECK ENGINE LIGHT, WITH NO PRIOR WARNING OF ISSUE ON THE DASH DISPLAY. I BELIEVE THIS IS DUE TO AN ISSUE WITH THE DIESEL PARTICULATE FILTER SOOT LOAD TRACKING. THE FIRST 3 OCCURRED ON RURAL HIGHWAY AND THE 4TH ON A LOCAL HIGHWAY AT SPEED. THE POWER REDUCTION IS IMMEDIATE AND SEVERE ENOUGH THAT THE VEHICLE RAPIDLY LOSES SPEED AND CANNOT KEEP UP WITH TRAFFIC. HAD TRAFFIC BEEN CLOSE OR WITH A TRAILER, THERE WOULD BE RISK OF BEING REAR ENDED DUE TO THE SUDDEN LOSS OF SPEED. I FEEL THERE SHOULD … Look up ODI 11196596 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 317.6%ODI 11460154 · 26,000 miThe contact stated that the 2020 Chevrolet Express was used as a school bus. The contact stated while driving at various speeds, the vehicle suddenly stalled and would not restart. During the failure the check engine warning light was illuminated. The vehicle was towed to the local dealer but the failure could not be duplicated and no repair was performed. The manufacturer was notified of the failure. The failure mileage was 26,000. Look up ODI 11460154 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 1100.0%ODI 11709863 · 56,837 miThe contact owns a 2024 Chevrolet Express. The contact stated that while attempting to accelerate, the vehicle hesitated, jerked, and stopped unexpectedly. There were no warning lights illuminated. The vehicle was serviced by an independent mechanic who determined the failure was associated with DTC: P129F-00 (Fuel pump drive control module). The part was replaced. The contact stated that the vehicle was in a fleet of vehicles for the school district. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacture… Look up ODI 11709863 at NHTSA ↗ | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. |
|---|
| Service Brakes, Hydraulic:Antilock/Traction Control/Electronic Limited Slip | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. |
|---|
| Fuel/Propulsion System | 215.4%ODI 11649646Vehicle is upfitted as a school bus. Forward fuel tank strap failed in operation. Our company operates more than 100 of these vehicles and we experience a failure of fuel tank straps at a rate of about one vehicle per month. If the 2nd strap would also fail the gasoline tank would become dislodged and present a fire hazard. This is even more critical as these vehicles are carrying students as a school bus. We perform visual inspections of the straps at 6 month intervals (per Pennsylvania these vehicles are subject to Semi-Annual State Inspecti… Look up ODI 11649646 at NHTSA ↗ | 313.6%ODI 10511447 · 1,800 miTHIS IS A C CLASS RV BY THOR MOTOR COACH. THE COACH SERIAL NUMBER IS [XXX]. THE VEHICLE WOULD NOT TAKE FUEL. I BOUGHT IT TO TWO CHEVROLET DEALERS WHO WOULD NOT LOOK AT IT BECAUSE IT HAD A MOTORHOME BODY. ONE DEALER HOOKED IT UP TO A FAULT FINDER AND FOUND THERE WAS A FUEL VENTING PROBLEM. THEY SAID IT LOOKED LIKE THE MOTOR COACH MANUFACTURER HAD CHANGED THE FUEL VENTING SYSTEM AND MOVED THE TANK. I FINALLY WAS SERVICED, UNDER WARRANTY, BY AN RV DEALER IN TULSA OKLAHOMA. THEY TOLD ME THE FUEL TANK HAD BEEN MOVED WHICH CAUSED A KINK IN THE… Look up ODI 10511447 at NHTSA ↗ | 321.4%ODI 10809792 · 25,900 miVEHICLE WILL SHUT OFF WHILE DRIVING. NO WARNING SIGNS. WILL LOSE ALL POWER STEERING AND UNSTABLE CONTROL. WILL NOT START AFTER IT SHUTS DOWN FOR UP TO 24HRS. THIS VEHICLE ALSO HAS A HISTORY OF HARD/TROUBLE STARTING. WHEN IT TURNS OVER IS WILL GO INTO PROTECTION MODE "LOSS OF POWER". THIS PROBLEM STARTED AT 3,178 MILES AND HAS CONTINUED REGULARLY UP TO THE CURRENT 26, 050 MILES. JACK WILSON CHEVROLET OF SAINT AUGUSTINE HAS ATTEMPTED TO REPAIR THIS VEHICLE ELEVEN (11) TIMES SINCE THE 2ND DAY AFTER PURCHASE. AFTER OBTAINING ALL SERVICE RECORD… Look up ODI 10809792 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 15.9%ODI 11766626The vehicle is experiencing an under-chassis manufacturing wiring harness restriction (Connector X185) that was installed too tightly from the factory, dropping the 5-volt reference power circuit down to 0 volts under load. This intermittent electrical failure completely starves the fuel pump, causing the fuel loop pressure to drop to a dangerous 43.5 PSI while driving (GM factory specification is 55–100 PSI). This electrical breakdown simultaneously chokes the fuel tank vapor loops, causing the fuel tank pressure to spike to an extreme -1100 v… Look up ODI 11766626 at NHTSA ↗ | 323.1%ODI 11519585While driving engine inexplicably shut off leaving us without power steering or brakes and unable to safely navigate off of the roadway. Fault: Fuel Pump Control Module GM representative stated they are seeing numerous failures of these components Look up ODI 11519585 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. |
|---|
| Service Brakes, Hydraulic | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 14.8%ODI 11581307 · 136,000 miThe contact owns a 2017 Chevrolet Express. The contact stated that while driving at approximately 35 MPH, the ABS inadvertently engaged, and the vehicle pulled to the left side. The vehicle was taken to an independent mechanic where it was diagnosed and determined that the electronic brake control module assembly needed to be repaired. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was 136,000. Look up ODI 11581307 at NHTSA ↗ | 00.0%No examples available for this selection. | 225.0%ODI 11649544The contact owns a 2019 Chevrolet Express. The contact received notification of NHTSA Campaign Number: 24V702000 (Service Brake, Hydraulic); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect. Look up ODI 11649544 at NHTSA ↗ | 00.0%No examples available for this selection. | 17.7%ODI 11646583 · 18,000 miThe contact owns a 2021 Chevrolet Express. The contact stated that while driving at an undisclosed speed, the vehicle started to pull to the left, prompting the contact to pull over to the shoulder off the roadway. After a visual inspection, the contact stated there was smoke coming from the driver's side front brakes. No warning lights were illuminated. The vehicle was taken to the dealer, who was unable to determine the cause of the failure. The contact was informed that the braking system needed to be replaced. The vehicle was not repaired. … Look up ODI 11646583 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. |
|---|