Chevrolet T-SERIES recalls by model year

Reported: 2006-07-13 (July 13, 2006) · Model years: 2006

CERTAIN MEDIUM DUTY TRUCKS EQUIPPED SR-7 BENDIX BRAKE VALVES, THE CHECK VALVE INSIDE THE VALVE CAVITY MAY NOT PROPERLY SET, CAUSING INTERNAL AIR LEAKAGE. IF THE CHECK VALVE DOES NOT PROPERLY SEAT, THE RESULTING LEAKAGE CAN CAUSE A DELAY IN THE APPLICATION OF THE SPRING BRAKES TO PARK THE VEHICLE AFTER OPERATOR PULLS THE DASH VALVE BUTTON.

Consequence: THE DELAYED PARKING BRAKE APPLICATION CAN OCCUR WITHOUT WARNING, LEADING TO UNINTENDED VEHICLE ROLLAWAY INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT THE VALVES AND REPLACE IT FREE OF CHARGE. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR ISUZU AT 1-800-255-6727.

Reported: 2006-08-16 (August 16, 2006) · Model years: 2006

CERTAIN TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, "AIR BRAKE SYSTEMS." AN INTERNAL CONTROL AND CHECK VALVE WITHIN THE AIR BRAKE APPLICATION VALVE ASSEMBLY WAS CONFIGURED IMPROPERLY, PREVENTING AIR FROM FLOWING THROUGH THE BRAKE SYSTEM AS DESIGNED. IN THE EVENT OF AN EMERGENCY STOP, THE VEHICLE'S STOPPING DISTANCE WOULD BE INCREASED.

Consequence: IF STOPPING DISTANCE WAS LIMITED, A VEHICLE CRASH COULD RESULT.

Remedy: DEALERS WILL REPLACE THE AIR BRAKE APPLICATION VALVE ASSEMBLY ON C-SERIES OR REROUTE THE AIR BRAKE LINES ON T-SERIES FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 20, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463 AND ISUZU AT 1-800-255-6727.

Reported: 2007-05-02 (May 2, 2007) · Model years: 2007

ON CERTAIN MEDIUM DUTY CONVENTIONAL AND TILT CAB TRUCKS EQUIPPED WITH 7.8L DIESEL ENGINES AND AIR BRAKES, THE AIR COMPRESSOR MAY NOT BUILD ENOUGH AIR PRESSURE TO SUPPORT THE AIR BRAKE SYSTEM.

Consequence: IF THIS CONDITION WERE TO OCCUR WHILE THE VEHICLE WAS STATIONARY (BRAKES APPLIED) THE AIR BRAKES WOULD REMAIN APPLIED AND PREVENT THE VEHICLE FROM MOVING. IF THIS CONDITION WERE TO OCCUR WHILE THE VEHICLE WAS IN MOTION, THE DUAL SYSTEM AIR PRESSURE GAUGES WOULD REGISTER THE DROP IN PRESSURE. IF THE PRESSURE CONTINUED TO DROP, THE LOW AIR PRESSURE WARNING BUZZER AND WARNING LAMP WOULD ACTIVATE AS DESIGNED, WARNING THE DRIVER TO MOVE THE VEHICLE TO A SAFETY LOCATION. IF THE DRIVER IGNORES THESE WARNINGS AND CONTINUES TO DRIVE THE VEHICLE, AND IF THERE WAS A CONTINUED LOSS OF PRESSURE, THE REAR SPRING PARKING BRAKES WOULD AUTOMATICALLY APPLY, PREVENTING THE TRUCK FROM BEING DRIVEN.

Remedy: DEALERS WILL REPLACE THE AIR COMPRESSOR HEAD. THE RECALL BEGAN ON MAY 23, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR ISUZU AT 1-800-255-6727.

Reported: 2009-07-29 (July 29, 2009) · Model years: 2007

GM IS RECALLING 1,880 MODEL YEAR 2007 CHEVROLET KODIAK AND T-SERIES, GMC TOPKICK AND T-SERIES, AND ISUZU F-SERIES AND H-SERIES PASSENGER VEHICLES EQUIPPED WITH 7.8L DIESEL ENGINE. THE AIR COMPRESSOR IN SOME OF THESE VEHICLES MAY NOT BUILD ENOUGH AIR PRESSURE TO SUPPORT THE AIR BRAKE SYSTEM. IF THIS CONDITION WERE TO OCCUR WHILE THE VEHICLES WAS STATIONARY (BRAKES APPLIED), THE AIR BRAKES WOULD REMAIN APPLIED AND PREVENT THE VEHICLE FROM MOVING.

Consequence: IF THE DRIVER IGNORES THESE WARNINGS AND CONTINUES TO DRIVE THE VEHICLE, AND IF THERE WAS A CONTINUED LOSS OF PRESSURE, THE REAR SPRING PARKING BRAKES WOULD AUTOMATICALLY APPLY, PREVENTING THE TRUCK FROM BEING DRIVEN.

Remedy: DEALERS WILL INSPECT THE AIR COMPRESSOR FOR ITS ABILITY TO BUILD AIR PRESSURE, AND EITHER MODIFY THE AIR COMPRESSOR BY ELIMINATION OF THE SUPPRESSION VALVE OR REPLACE THE AIR COMPRESSOR ASSEMBLY FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING AUGUST 2009. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727 OR AT WWW.GMOWNERCENTER.COM.