0 distinct campaigns affect this selection. Announcement dates below are different from vehicle model years. A campaign may cover multiple years.
No recall campaigns are recorded in this snapshot.
Explore the data
Vehicle analysis explorer
Inspect model-year patterns, reported mileage, monthly activity and the evidence behind each signal.
Data completeness
15 unique complaints in this selection. Analysis snapshot: 2026-10-01.
73.3%Usable mileage11 / 15 records
100.0%Valid incident date15 / 15 records
100.0%Valid filing date15 / 15 records
100.0%Ordered incident and filing dates15 / 15 records
Missing, zero and invalid mileage is excluded. Dates after the snapshot are excluded. Examples are limited selections, not a representative sample.
Problems by model year
Model-wide comparison of the eight most reported components across the model. Cells show counts and shares within each model year. Open a cell for source examples.
Component complaint heatmap
Component
1997
1998
Power Train:Driveline:Differential Unit
111.1%ODI 10005333 · 75,000 mi
I HAVE A AWD WITH APPX 75,000/MI AND THE ENTIRE DIFFERENTIAL WENT OUT ON THE VEHICLE. REPLACEMENT COST $4,700.00. I DO NOT OR HAVE BEEN ROUGH WITH THIS VEHICLE. NORMAL HIGHWAY DRIVING ONLY... AND MY GAS GAUGE WENT OUT ON MY VEHICLE ALSO.
THERE IS A PROBLEM WITH THE DOOR BLEND ON MY VEHICLE. FORD STATES THAT THEY NEVER HEARD OF THIS PROBLEM, HOWEVER, ANY WEBSITE YOU GO TO THAT HAS FORD OWNERS ON IT HAVE MULTIPLE COMPLAINTS. I HAVE CHANGED THE THERMOSTAT, TRACED ALL VACUUM LINES, CHECKED THE HEATER COR ETC. THE BLOWER THROWS OUT COLD AIR ONLY. FORD WANTS IN EXCESS OF $1,100 TO REPAIR THE PROBLEM. I WILL NOT PAY THIS AMOUNT. I PLAN ON CONSULTED WITH MY FAMILY ATTORNEY, AND POSSIBLY SEE IF A CLASS ACTION LAWSUIT CAN BE FILED. THEY REFUSE TO ACCEPT RESPONSIBILITY FOR THE PROB…
I HAD TO REPLACE THE CENTER ARMREST ON 9-9-99 UNDER WARANTY AND A SECOND TIME AT MY EXPENSE. THE TRANSMISSION MOUNT BOLT WAS MISSING. RAZZARI FORD IN MERCED, CA, CANNOT FIX UNDER WARRANTY. *JB FORD MOTOR COMPANY CLAIMS MISSING BOLT AND DEFECTIVE ARMREST IS NOT UNDER WARRANTY. I REMINDED THEM I WILL NOT BUY NEW FORDS AGAIN.
1997 FORD EXPLORER, BOUGHT AS A PROGRAM VEHICLE (RETURNED) WITH 40,000 MILES.EHICLE NOW HAS 103,000 EASY MILES. MOSTLY SITS IN CARPORT. NOT DRIVEN DAILY. VECHICLE HAS HAD THE FOLLOWING PROBLEMS 1. CHECK ENGINE LIGHT HAS BEEN ON SINCE WE BOUGHT THE VEHICLE, HAVE REPLACED )2 SENSOR TWICE. CAME BACK ON SHORTLY AFTER. RUNS ROUGH IN THE MORNING. 2. BLEND DOOR FAILED (THIS CAUSES EITHER WARM OR COOL AIR TO BLOWN INTO THE VEHICLE), RENDERING EITHER AC OR HEATER INOPERABLE. THIS IS A POTENTIALLY DANGEROUS CONDITION, WHEN DEFROSTER IS NEEDED QUICK…
Engine And Engine Cooling:Exhaust System:Emission Control:Catalytic Convertor
111.1%ODI 10047380 · 83,000 mi
IT HAS BEEN BROUGHT TO MY ATTENTION AFTER 5 TRIPS TO THE SERVICE DEPT. THAT MY 1997 FORD EXPLORER NEEDS A CATALYTIC CONVERTER. THIS WAS AFTER SENSORS WERE REPLACED THE FIRST 4 TIMES. THE CHECK ENGINE LIGHT HAS BEEN ON ALMOST CONSTANTLY SINCE THE PURCHASE IN JUNE. I WAS TOLD THAT THIS WAS AN ONGOING PROBLEM WITH THE EXPLORER AND FORD WOULD NOT RECALL THEM FOR THIS MAJOR DEFECT. I DID NOT PURCHASE THIS VEHICLE TO CONSTANTLY MAKE REPAIRS TO A DEFECTIVE PART OR PARTS. FORD SHOULD MAKE THIS RIGHT. PLEASE CONTACT ME IMMEDIATELY. [XXX]. *LA INFO…
EDDIE BAUER FORD EXPLORER BRIGHT LIGHT SWITCH ON STEERING COLUMN FAILED WHEN RETURNING FROM BRIGHT HEADLIGHTS TO REGULAR LIGHTING. THE HEADLIGHTS WENT OUT DUE TO THE SWITCH, HAD TO WIGGLE SWITCH TO GET LIGHTS BACK ON. I DISCOVERED BY HOLDING THE SWITCH TOWARDS MY DIRECTION (THE FLASH BRIGHTS MODE), I COULD GET HOME. THIS OCCURRED WHILE DRIVING IN PITCH DARK . LIGHTS UNEXPECTEDLY WENT OUT DURING THIS ACTION. IT WAS RATHER SHOCKING TO HAVE THE HEADLIGHTS TO TURN OFF UNEXPECTEDLY. *AK
I HAVE A AWD WITH APPX 75,000/MI AND THE ENTIRE DIFFERENTIAL WENT OUT ON THE VEHICLE. REPLACEMENT COST $4,700.00. I DO NOT OR HAVE BEEN ROUGH WITH THIS VEHICLE. NORMAL HIGHWAY DRIVING ONLY... AND MY GAS GAUGE WENT OUT ON MY VEHICLE ALSO.
I HAD TO REPLACE THE CENTER ARMREST ON 9-9-99 UNDER WARANTY AND A SECOND TIME AT MY EXPENSE. THE TRANSMISSION MOUNT BOLT WAS MISSING. RAZZARI FORD IN MERCED, CA, CANNOT FIX UNDER WARRANTY. *JB FORD MOTOR COMPANY CLAIMS MISSING BOLT AND DEFECTIVE ARMREST IS NOT UNDER WARRANTY. I REMINDED THEM I WILL NOT BUY NEW FORDS AGAIN.
4WD LOW AND HIGH LIGHT ILLUMINATED / SIX TIMES FLASHING EVERY THREE MINUTES. WHILE IN REVERSE THE CAR WOULD SHUTTER/BANG. FOLLOWED BY THE VEHICLE NOT ENGAGING INTO DRIVE.
Darker cells indicate a larger share of submitted complaints. Components overlap. This measures complaint composition, not failure probability.
Failure mileage by component
Median and middle 50% of usable owner-reported mileages. Ranges require at least five records.
Component failure mileage distribution
Component
Mileage range (25th–75th percentile)
Median
Usable records
Examples
Power Train:Driveline:Differential Unit
Too few reports for a range
76,500 mi
2 (sparse)
ODI 10005333 · 75,000 mi
I HAVE A AWD WITH APPX 75,000/MI AND THE ENTIRE DIFFERENTIAL WENT OUT ON THE VEHICLE. REPLACEMENT COST $4,700.00. I DO NOT OR HAVE BEEN ROUGH WITH THIS VEHICLE. NORMAL HIGHWAY DRIVING ONLY... AND MY GAS GAUGE WENT OUT ON MY VEHICLE ALSO.
THERE IS A PROBLEM WITH THE DOOR BLEND ON MY VEHICLE. FORD STATES THAT THEY NEVER HEARD OF THIS PROBLEM, HOWEVER, ANY WEBSITE YOU GO TO THAT HAS FORD OWNERS ON IT HAVE MULTIPLE COMPLAINTS. I HAVE CHANGED THE THERMOSTAT, TRACED ALL VACUUM LINES, CHECKED THE HEATER COR ETC. THE BLOWER THROWS OUT COLD AIR ONLY. FORD WANTS IN EXCESS OF $1,100 TO REPAIR THE PROBLEM. I WILL NOT PAY THIS AMOUNT. I PLAN ON CONSULTED WITH MY FAMILY ATTORNEY, AND POSSIBLY SEE IF A CLASS ACTION LAWSUIT CAN BE FILED. THEY REFUSE TO ACCEPT RESPONSIBILITY FOR THE PROB…
I HAD TO REPLACE THE CENTER ARMREST ON 9-9-99 UNDER WARANTY AND A SECOND TIME AT MY EXPENSE. THE TRANSMISSION MOUNT BOLT WAS MISSING. RAZZARI FORD IN MERCED, CA, CANNOT FIX UNDER WARRANTY. *JB FORD MOTOR COMPANY CLAIMS MISSING BOLT AND DEFECTIVE ARMREST IS NOT UNDER WARRANTY. I REMINDED THEM I WILL NOT BUY NEW FORDS AGAIN.
Engine And Engine Cooling:Exhaust System:Emission Control:Catalytic Convertor
Too few reports for a range
83,000 mi
1 (sparse)
ODI 10047380 · 83,000 mi
IT HAS BEEN BROUGHT TO MY ATTENTION AFTER 5 TRIPS TO THE SERVICE DEPT. THAT MY 1997 FORD EXPLORER NEEDS A CATALYTIC CONVERTER. THIS WAS AFTER SENSORS WERE REPLACED THE FIRST 4 TIMES. THE CHECK ENGINE LIGHT HAS BEEN ON ALMOST CONSTANTLY SINCE THE PURCHASE IN JUNE. I WAS TOLD THAT THIS WAS AN ONGOING PROBLEM WITH THE EXPLORER AND FORD WOULD NOT RECALL THEM FOR THIS MAJOR DEFECT. I DID NOT PURCHASE THIS VEHICLE TO CONSTANTLY MAKE REPAIRS TO A DEFECTIVE PART OR PARTS. FORD SHOULD MAKE THIS RIGHT. PLEASE CONTACT ME IMMEDIATELY. [XXX]. *LA INFO…
EDDIE BAUER FORD EXPLORER BRIGHT LIGHT SWITCH ON STEERING COLUMN FAILED WHEN RETURNING FROM BRIGHT HEADLIGHTS TO REGULAR LIGHTING. THE HEADLIGHTS WENT OUT DUE TO THE SWITCH, HAD TO WIGGLE SWITCH TO GET LIGHTS BACK ON. I DISCOVERED BY HOLDING THE SWITCH TOWARDS MY DIRECTION (THE FLASH BRIGHTS MODE), I COULD GET HOME. THIS OCCURRED WHILE DRIVING IN PITCH DARK . LIGHTS UNEXPECTEDLY WENT OUT DURING THIS ACTION. IT WAS RATHER SHOCKING TO HAVE THE HEADLIGHTS TO TURN OFF UNEXPECTEDLY. *AK
I HAVE A AWD WITH APPX 75,000/MI AND THE ENTIRE DIFFERENTIAL WENT OUT ON THE VEHICLE. REPLACEMENT COST $4,700.00. I DO NOT OR HAVE BEEN ROUGH WITH THIS VEHICLE. NORMAL HIGHWAY DRIVING ONLY... AND MY GAS GAUGE WENT OUT ON MY VEHICLE ALSO.
I HAD TO REPLACE THE CENTER ARMREST ON 9-9-99 UNDER WARANTY AND A SECOND TIME AT MY EXPENSE. THE TRANSMISSION MOUNT BOLT WAS MISSING. RAZZARI FORD IN MERCED, CA, CANNOT FIX UNDER WARRANTY. *JB FORD MOTOR COMPANY CLAIMS MISSING BOLT AND DEFECTIVE ARMREST IS NOT UNDER WARRANTY. I REMINDED THEM I WILL NOT BUY NEW FORDS AGAIN.
4WD LOW AND HIGH LIGHT ILLUMINATED / SIX TIMES FLASHING EVERY THREE MINUTES. WHILE IN REVERSE THE CAR WOULD SHUTTER/BANG. FOLLOWED BY THE VEHICLE NOT ENGAGING INTO DRIVE.
Explore monthly filing activity alongside recall announcements. Up to ten years of monthly history is available.
Solid line: filed complaints. Dashed amber lines: recall announcement dates for this vehicle selection; markers include all recall components. The latest month is partial. Temporal proximity does not establish causation.
Monthly counts, recall campaigns and complaint examples
Monthly complaint and recall timeline
Month
Complaints
Campaigns announced
Examples
2024-11
0
None
No examples available for this selection.
2024-12
0
None
No examples available for this selection.
2025-01
0
None
No examples available for this selection.
2025-02
0
None
No examples available for this selection.
2025-03
0
None
No examples available for this selection.
2025-04
0
None
No examples available for this selection.
2025-05
0
None
No examples available for this selection.
2025-06
0
None
No examples available for this selection.
2025-07
0
None
No examples available for this selection.
2025-08
0
None
No examples available for this selection.
2025-09
0
None
No examples available for this selection.
2025-10
0
None
No examples available for this selection.
2025-11
0
None
No examples available for this selection.
2025-12
0
None
No examples available for this selection.
2026-01
0
None
No examples available for this selection.
2026-02
0
None
No examples available for this selection.
2026-03
0
None
No examples available for this selection.
2026-04
0
None
No examples available for this selection.
2026-05
0
None
No examples available for this selection.
2026-06
0
None
No examples available for this selection.
2026-07
0
None
No examples available for this selection.
2026-08
0
None
No examples available for this selection.
2026-09
0
None
No examples available for this selection.
2026-10 (partial)
0
None
No examples available for this selection.
Emerging complaint spikes
Complete months in the latest six months with at least 10 complaints, at least twice the preceding 12-month average, and at least three square-root deviations above that average.
This is a descriptive screening rule, not a statistical defect finding. Publicity and reporting changes can increase submissions.
No complete months meet the spike thresholds for this selection.
Equal-age model-year comparison
Model-wide cumulative reports during the first three or five calendar years, starting with the model year (age 0). Only fully elapsed windows are compared.
1997: 0 complaints · 1998: 0 complaints
Equal observation windows
Model year
Through age 0
Through age 1
Through age 2
1997
0
0
0
1998
0
0
0
Date coverage across each selected cohort
Date basis for all complaints in selected model years
Year
Incident dates used
Filing date fallbacks
Excluded dates
1997
9
0
0
1998
6
0
0
Incident date is preferred when valid and no later than filing; otherwise filing date is used. Model year approximates age. Equal observation time does not adjust for sales, distance driven or reporting delays. One complaint linked to multiple model years can appear in each cohort.
Components reported together
Each cell counts unique complaints naming both components. Open a nonzero cell for examples.
Component co-occurrence matrix
Component
Power Train:Driveline:Differential Unit
Unknown Or Other
Engine And Engine Cooling
Engine And Engine Cooling:Exhaust System:Emission Control:Catalytic Convertor
Exterior Lighting:Headlights:Switch
Fuel System, Other
Power Train:Automatic Transmission
Power Train:Transfer Case (4-Wheel Drive)
Power Train:Driveline:Differential Unit
—
0
0
0
0
1ODI 10005333 · 75,000 mi
I HAVE A AWD WITH APPX 75,000/MI AND THE ENTIRE DIFFERENTIAL WENT OUT ON THE VEHICLE. REPLACEMENT COST $4,700.00. I DO NOT OR HAVE BEEN ROUGH WITH THIS VEHICLE. NORMAL HIGHWAY DRIVING ONLY... AND MY GAS GAUGE WENT OUT ON MY VEHICLE ALSO.
I HAD TO REPLACE THE CENTER ARMREST ON 9-9-99 UNDER WARANTY AND A SECOND TIME AT MY EXPENSE. THE TRANSMISSION MOUNT BOLT WAS MISSING. RAZZARI FORD IN MERCED, CA, CANNOT FIX UNDER WARRANTY. *JB FORD MOTOR COMPANY CLAIMS MISSING BOLT AND DEFECTIVE ARMREST IS NOT UNDER WARRANTY. I REMINDED THEM I WILL NOT BUY NEW FORDS AGAIN.
Engine And Engine Cooling:Exhaust System:Emission Control:Catalytic Convertor
0
0
0
—
0
0
0
0
Exterior Lighting:Headlights:Switch
0
0
0
0
—
0
0
0
Fuel System, Other
1ODI 10005333 · 75,000 mi
I HAVE A AWD WITH APPX 75,000/MI AND THE ENTIRE DIFFERENTIAL WENT OUT ON THE VEHICLE. REPLACEMENT COST $4,700.00. I DO NOT OR HAVE BEEN ROUGH WITH THIS VEHICLE. NORMAL HIGHWAY DRIVING ONLY... AND MY GAS GAUGE WENT OUT ON MY VEHICLE ALSO.
I HAD TO REPLACE THE CENTER ARMREST ON 9-9-99 UNDER WARANTY AND A SECOND TIME AT MY EXPENSE. THE TRANSMISSION MOUNT BOLT WAS MISSING. RAZZARI FORD IN MERCED, CA, CANNOT FIX UNDER WARRANTY. *JB FORD MOTOR COMPANY CLAIMS MISSING BOLT AND DEFECTIVE ARMREST IS NOT UNDER WARRANTY. I REMINDED THEM I WILL NOT BUY NEW FORDS AGAIN.
Co-reporting does not establish that one component caused another concern.
Recurring narrative patterns
Specific keyword mentions beyond broad component labels. Matching includes negations and comparisons and does not confirm a diagnosis.
2 patterns with matching reports.
Warning lights and dashboard alerts
2 mentions · 13.3% of complaints
Median mileage: 83,000 mi (1 usable records).
ODI 10047380 · 83,000 mi
IT HAS BEEN BROUGHT TO MY ATTENTION AFTER 5 TRIPS TO THE SERVICE DEPT. THAT MY 1997 FORD EXPLORER NEEDS A CATALYTIC CONVERTER. THIS WAS AFTER SENSORS WERE REPLACED THE FIRST 4 TIMES. THE CHECK ENGINE LIGHT HAS BEEN ON ALMOST CONSTANTLY SINCE THE PURCHASE IN JUNE. I WAS TOLD THAT THIS WAS AN ONGOING PROBLEM WITH THE EXPLORER AND FORD WOULD NOT RECALL THEM FOR THIS MAJOR DEFECT. I DID NOT PURCHASE THIS VEHICLE TO CONSTANTLY MAKE REPAIRS TO A DEFECTIVE PART OR PARTS. FORD SHOULD MAKE THIS RIGHT. PLEASE CONTACT ME IMMEDIATELY. [XXX]. *LA INFO…
1997 FORD EXPLORER, BOUGHT AS A PROGRAM VEHICLE (RETURNED) WITH 40,000 MILES.EHICLE NOW HAS 103,000 EASY MILES. MOSTLY SITS IN CARPORT. NOT DRIVEN DAILY. VECHICLE HAS HAD THE FOLLOWING PROBLEMS 1. CHECK ENGINE LIGHT HAS BEEN ON SINCE WE BOUGHT THE VEHICLE, HAVE REPLACED )2 SENSOR TWICE. CAME BACK ON SHORTLY AFTER. RUNS ROUGH IN THE MORNING. 2. BLEND DOOR FAILED (THIS CAUSES EITHER WARM OR COOL AIR TO BLOWN INTO THE VEHICLE), RENDERING EITHER AC OR HEATER INOPERABLE. THIS IS A POTENTIALLY DANGEROUS CONDITION, WHEN DEFROSTER IS NEEDED QUICK…
1997 FORD EXPLORER, BOUGHT AS A PROGRAM VEHICLE (RETURNED) WITH 40,000 MILES.EHICLE NOW HAS 103,000 EASY MILES. MOSTLY SITS IN CARPORT. NOT DRIVEN DAILY. VECHICLE HAS HAD THE FOLLOWING PROBLEMS 1. CHECK ENGINE LIGHT HAS BEEN ON SINCE WE BOUGHT THE VEHICLE, HAVE REPLACED )2 SENSOR TWICE. CAME BACK ON SHORTLY AFTER. RUNS ROUGH IN THE MORNING. 2. BLEND DOOR FAILED (THIS CAUSES EITHER WARM OR COOL AIR TO BLOWN INTO THE VEHICLE), RENDERING EITHER AC OR HEATER INOPERABLE. THIS IS A POTENTIALLY DANGEROUS CONDITION, WHEN DEFROSTER IS NEEDED QUICK…