U.S. public vehicle records

Ford AEROSTAR fuel problems

152 complaint narratives mention fuel terms.

Key facts

2,311 owner complaints analyzed

23 distinct recall campaigns

128,850 mi median reported failure mileage

Scope: 1986 to 2000 model years. Data updated: 2026-09-30 (September 30, 2026). 107 complaints include usable failure mileage. View data status.

Fuel system concerns evidence

152 of 2,311 complaints match this topic (6.6%). The keyword filter can include complaints that mention a transmission without reporting its failure. View matching rules.

Owner report 10980287 · 2017-04-24 (April 24, 2017)

THE GROMMET IN THE FUEL TANK IS LEAKING. FUEL IS ESCAPING FROM THE TANK AND MAY CAUSE A FIRE. THERE IS A CONSTANT ESCAPE OF FUEL MOVING OR STATIONARY. THEREFORE THIS SYSTEM WILL NOT PASS SMOG BECAUSE WHEN PRESSURIZED, IT WILL NOT HOLD AIR. THIS IS A CALIFORNIA REQUIREMENT. IT IS ALSO MOST DANGEROUS. FORD MOTOR CO. WILL NOT CORRECT THIS PROBLEM. THE 9 RECALLS FOR THIS MODEL IS ON YOUR SYSTEM.

Owner-reported narrative. 300,000 miles reported. Look up ODI 10980287 at NHTSA ↗

Owner report 504972 · 1996-05-24 (May 24, 1996)

FAILED FUEL INJECTOR CAUSED ENGINE FIRE. *DH

Owner-reported narrative. Look up ODI 504972 at NHTSA ↗

Owner report 967310 · 1995-06-20 (June 20, 1995)

FUEL TANK FILLER PIPE FAILURE, INSUFFICIENT INTERFERENCE FIT BETWEEN FUEL TANK FILLER PIPE AND GROMMET COULD RESULT IN AN INADEQUATE SEAL ALLOWING FUEL TO SEEP.

Owner-reported narrative. Look up ODI 967310 at NHTSA ↗

Owner report 700970 · 1999-01-19 (January 19, 1999)

ORIGINAL FILLER NECK GROMMET AND SEAL REPLACED AT OUR EXPENSE IN 4/89- REIMBURSED BY DEALER IN 1990. SECOND FAILURE OCCURRED 6/97, AND PARTS REPLACED AT OUR EXPENSE WITH NO REIMBURSEMENT. THIRD FAILURE OCCURRED 11/26/98-HAVE NOT YET NOTIFIED DEALER. NOTICEABLE WHEN FUEL TANK IS FILLED AT 15GALLONS OR MORE, GAS RUNS DOWN OVER BOTTOM OF TANK ONTO GROUND. SAME SITUATION AS HAPPENED IN 1989 AND 1997. FEEL THIS IS A SAFETY ISSUE AND WE SHOULD NOT BE EXPECTED TO CONTINUALLY PAY FOR FORD'S NEGLIGENCE IN PRODUCING DEFECTIVE PARTS. ALSO REPLACED …

Owner-reported narrative. Look up ODI 700970 at NHTSA ↗

Owner report 809503 · 1997-02-28 (February 28, 1997)

CANNOT FILL GAS TANK MORE THAN HALF-WAY FULL WITHOUT LEAKING. *AK

Owner-reported narrative. Look up ODI 809503 at NHTSA ↗

Explore the data

Vehicle analysis explorer

Inspect model-year patterns, reported mileage, monthly activity and the evidence behind each signal.

Data completeness

2,311 unique complaints in this selection. Analysis snapshot: 2026-09-30.

4.6%Usable mileage107 / 2,311 records

79.4%Valid incident date1,835 / 2,311 records

100.0%Valid filing date2,311 / 2,311 records

79.4%Ordered incident and filing dates1,835 / 2,311 records

Missing, zero and invalid mileage is excluded. Dates after the snapshot are excluded. Examples are limited selections, not a representative sample.

Problems by model year

Model-wide comparison of the eight most reported components across the model. Cells show counts and shares within each model year. Open a cell for source examples.

From model yearThrough model year

Component complaint heatmap
Component	1986	1987	1988	1989	1990	1991	1992	1993	1994	1995	1996	1997	1998	1999	2000
Electrical System:Ignition:Switch	713.2% ODI 504169 IGNITION SWITCH CAUGHT FIRE. *SD Look up ODI 504169 at NHTSA ↗	119.6% ODI 503169 IGNITION SWITCH SHORTED, CAUSING WIRING TO MELT. *DH Look up ODI 503169 at NHTSA ↗	158.5% ODI 10033973 · 386,118 mi THE ELECTRICAL SYSTEM FAILED AND CAUSED THE IGNITION SWITCH TO BE INOPERATIVE. THE DEALER WAS NOTIFIED. AK SCC *NLM Look up ODI 10033973 at NHTSA ↗	3814.6% ODI 10140845 · 208,000 mi DT: THE CONTACT RECEIVED NHTSA RECALL 96V071000 CONCERNING THE IGNITION SWITCH. WHEN HE CONTACTED FORD, THEY COULD NOT FIND THE VIN. THIS STARTED A COUPLE OF MONTHS AGO. THE SWITCH STARTED TO COME APART, CAUSING THE VEHICLE NOT TO START. HE REPAIRED IT HIMSELF, AND IT IS CURRENTLY WORKING.AK UPDATED 12/27/2005. NM Look up ODI 10140845 at NHTSA ↗	2110.8% ODI 10076051 · 12,000 mi THE VEHICLE IS EXPERIENCING THE FAILURES DESCRIBED IN THE MASTER CYLINDER PISTONS RECALL 89V223000. IN ADDITION, THE ABS LIGHT COMES ON. ALSO, THE VEHICLE IS EXPERIENCING THE FAILURE DESCRIBED IN THE IGNITION SWITCH RECALL 96V071000 BUT THIS VEHICLE NOT INCLUDED IN RECALL DUE TO VIN. *AK Look up ODI 10076051 at NHTSA ↗	2913.0% ODI 10120979 I OWNED A 1991 FORD AEROSTAR WHICH BURST INTO FLAMES AND WAS DESTROYED. I HAVE BEEN BOUNCED AROUND TRYING TO GET SATISFACTIONS BUT SINCE THERE WAS AN ONGOING CLASS ACTION LAW SUIT HAVE NOT RECEIVED ANY COMPENSATION. THE CONSUMERS WIFE NOTICED SMOKE COMING FROM THE STEERING COLUMN. THE CONSUMER PULLED OVER, RAN TO CALL THE FIRE DEPARTMENT, BUT BY THE TIME HE RETURNED THE VEHICLE WAS FULLY ENGULFED IN FLAMES. UPDATED 04/14/10.*JB Look up ODI 10120979 at NHTSA ↗	3310.4% ODI 504420 IGNITION SWITCH FAILS TO RETURN TO RUN POSITION AFTER STARTING VEHICLE, CAUSING FAILURE OF TURN SIGNALS/BLOWER MOTOR. *SD Look up ODI 504420 at NHTSA ↗	4612.3% ODI 10087331 · 130,000 mi WHILE DRIVING ON THE HIGHWAY VEHICLE CAUGHT ON FIRE BECAUSE OF THE DEFECT DESCRIBED IN IGNITION SWITCH ELECTRICAL SHORT 99V029000 RECALL. MANUFACTURER PROVIDED CONFLICTING INFORMATION. THEY TOLD CONSUMER BY PHONE THAT THE VIN NUMBER WAS INCLUDED IN THE RECALL ,AND THEN SENT A LETTER INDICATING THAT THE VIN NUMBER WASN'T INCLUDED. *AK Look up ODI 10087331 at NHTSA ↗	228.6% ODI 10008035 THE WIRING HARNESS IN MY STEERING COLUME IS DEFECTIVE. THIS WILL BE THE SECOND TIME IN 6 YRS THAT THIS HAS HAD TO BE REPLACED. THE HARNESS CONTROLLS THE AIRBAGE, HORN AND CRUISE CONTROLL. ALSO THE IGITION SWITCH IS FAULTY, THE KEY CAN BE REMOVED WHILE THE VEHICLE IS RUNNING Look up ODI 10008035 at NHTSA ↗	1811.5% ODI 10071645 · 151,000 mi CONSUMER ATTEMPTED TO GET THE VEHICLE RECALL 99V029000 REPAIRED. HOWEVER, THE DEALER KEPT GIVING THE CONSUMER EXCUSES WHY THEY COULD NOT FIX THE IGNITION SWITCH. AK SC *JB Look up ODI 10071645 at NHTSA ↗	43.8% ODI 10175900 · 115,000 mi DT: THE CONTACT STATED WHILE THE VEHICLE WAS BEING DRIVEN 30 MPH, ALL POWER FAILED AND THE ENGINE STALLED. THE STALLING HAS ALSO OCCURRED AT HIGHER SPEEDS AND WHILE THE VEHICLE WAS IMMOBILE. A FUSE CONNECTED TO THE BATTERY CABLES BLEW. WHEN THE FUSE WAS REPLACED, THE ENGINE WOULD RESTART. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER. THE CONTACT WAS INFORMED THE VEHICLE WAS NOT INCLUDED IN RECALL # 99V029000, FOR THE ELECTRICAL IGNITION SWITCH DUE THE VIN EVEN THOUGHT VEHICLE HAD THE SAME PROBLEMS. THE MANUFACTURER WAS NOT NOTIFIED.AK Look up ODI 10175900 at NHTSA ↗	711.1% ODI 10129732 MY 1997 FORD AERO STAR VAN PRODUCED A PUFF OF SMOKE FROM THE STEERING COLUMN NEAR THE IGNITION SWITCH. I TOOK IT TO MY MECHANIC WHOM CHECKED THE RECALL NOTICES AND FOUND ONE RESULTING IN AN ELECTRICAL OVERLOAD SHORT CIRCUIT AND OVERHEATING IN THE STEERING COLUMN ELECTRICAL COMPONENTS. WHEN THE KEY WAS TURNED OFF IT SUBSIDES. SINCE THIS OCCURRENCE THE INSTRUMENT PANEL HAS NOT WORKED AND BLEW ALL FUSES, THE FUEL PUMP DOES NOT TURN ON WITH THE KEY AFTER MULTIPLE ATTEMPTS IT ENGAGES SOME TIMES. THE FORD DEALER DID THE RECALL WORK BUT DID NOT FIX OR… Look up ODI 10129732 at NHTSA ↗	00.0% No examples available for this selection.	00.0% No examples available for this selection.	00.0% No examples available for this selection.
Power Train:Automatic Transmission	611.3% ODI 484729 TRANSMISSION FAILED. *DH Look up ODI 484729 at NHTSA ↗	1412.3% ODI 10038500 TRANSMISSION PROBLEMS. THE TRANSMISSION CONTINUED TO FAIL. THE CONSUMER HAS REPLACED THREE TRANSMISSION. *NLM Look up ODI 10038500 at NHTSA ↗	84.5% ODI 482463 HEATER CORE FAILED. Look up ODI 482463 at NHTSA ↗	145.4% ODI 481635 VEHICLE ROLLED BACKWARDS TWICE WHILE IN PARK GEAR, ONCE CAUSING INJURIES. *AW Look up ODI 481635 at NHTSA ↗	189.2% ODI 10029226 VEHICLE TRANSMISSION FAILURE. *AK Look up ODI 10029226 at NHTSA ↗	219.4% ODI 10073700 WHILE DRIVING 65 MPH ANOTHER MOTORIST YELLED AT THE CONSUMER THAT THE VAN WAS ON FIRE. THE FIRE APPEARED TO BE COMING FORM THE MIDDLE TO THE REAR. CONSUMER PULLED OVER, AND NOTICED TRANSMISSION FLUID ON THE UNDERSIDE OF THE VAN. CONSUMER SHUT THE ENGINE OFF, AND FIRE WENT OUT. A TECHNICIAN EXAMINED THE VAN AND STATED THAT THE TRANSFER CASE NEEDED TO BE REPLACED. NHTSA RECALL CAMPAIGN 99V094000 WAS ISSUED. *AK Look up ODI 10073700 at NHTSA ↗	278.5% ODI 483932 SHIFT CABLE RESTING ON MUFFLER, MELTING PLASTIC COVERING, ALLOWING CABLE TO RUST. *TW Look up ODI 483932 at NHTSA ↗	174.5% ODI 10000660 · 243,150 mi THEY SAY "WHERE THERE'S SMOKE THERE'S FIRE" SO THAT'S WHY I CHECKED THE FIRE BUTTON ON THE FORM. JUST TO THE RIGHT OF THE ACCELERATOR THE CARPET STARTED SMOKING. WE STILL DON'T KNOW THE CAUSE. BUT, EVERYTIME WE RUN THE CAR AN AWFUL SMELL RESULTS. WE NO LONGER DRIVE LONG DISTANCES. IT'S OUR ONLY CAR BUT I WE'LL HAVE TO TAKE IT TO THE GARAGE SOON. WITH HOLIDAY BILLS THIS COULDN'T HAVE COME AT A WORSE TIME. Look up ODI 10000660 at NHTSA ↗	155.8% ODI 10017023 AUTOMATIC TRANSMISSION FAILURE - TRANSMISSION FALLS OUT OF GEAR. *JB Look up ODI 10017023 at NHTSA ↗	85.1% ODI 705043 VERY DISAPPOINTING VEHICLE! NP SAFETY DEFECT MENTIONED IN SUMMARY. *AK Look up ODI 705043 at NHTSA ↗	32.9% ODI 602648 DRIVESHAFT DEFECTIVE. Look up ODI 602648 at NHTSA ↗	23.2% ODI 609433 TRANSMISSION. Look up ODI 609433 at NHTSA ↗	00.0% No examples available for this selection.	114.3% ODI 10172783 THE MOTOR WOULD DIE AND THEN ACCELERATE SUDDENLY, SOMETIMES MAKING A CRANKING NOISE. THE SERVICE REPORT STATED THAT THERE NO PROBLEM. IN ADDITION, WHEN THE VEHICLE WAS PARKED AND WANTED TO CHANGE FROM PARKING TO DRIVE, IT WOULD BE STUCK, MAKING IT DIFFICULT TO CHANGE THE TRANSMISSION, USUALLY PRODUCING A LOUD CRANKING NOISE AS IF THE TRANSMISSION WAS TO EXPLODE. EVENTUALLY, IN FEBRUARY 2005 THE MOTOR BROKE DOWN AND BOTH THE MOTOR AND TRANSMISSION HAD TO BE REPLACED. THE DEALER (BAYAMON FORD) REPLACED THE MOTOR IN MARCH 2005 AND WHEN THE TRA… Look up ODI 10172783 at NHTSA ↗	116.7% ODI 898114 THIS WAS SECOND TIME THAT VEHICLE TOOK OFF FORWARD WHILE SHIFT LEVER WAS IN REVERSE. ONCE VEHICLE TOOK OFF, CONSUMER LOST CONTROL AND WENT THROUGH SOME BUSHES, AND ALMOST WENT INTO A BUILDING. CONSUMER FELT SOMEONE COULD HAVE BEEN KILLED.*AK Look up ODI 898114 at NHTSA ↗
Fuel System, Gasoline:Storage:Tank Assembly	11.9% ODI 833818 HAD FILLED VEHICLE WITH GASOLINE. NOTICED THAT THE TANK HAD STARTED TO LEAK AFTERWARDS. TOOK VEHICLE TO DEALER & HAD IT CHECKED. THE MECHANIC NOTICED THE FUEL WAS LEAKING FROM THE TOP OF THE TANK IN & AROUND THE SEAM AREA.*AK Look up ODI 833818 at NHTSA ↗	21.8% ODI 809503 CANNOT FILL GAS TANK MORE THAN HALF-WAY FULL WITHOUT LEAKING. *AK Look up ODI 809503 at NHTSA ↗	3821.5% ODI 10044531 · 117,814 mi GAS TANK DEFECT STATED IN RECALL 98V190000 OCCURRED AFTER THE RECALL REPAIRS WERE PERFORMED.*AK Look up ODI 10044531 at NHTSA ↗	4617.7% ODI 10046209 · 160,000 mi THE MANUFACTURER WAS REFUSING TO HONOR RECALL 98V190000 FOR FUEL TANK CRACKS BECAUSE THE WARRANTY PERIOD ENDED. *AK Look up ODI 10046209 at NHTSA ↗	189.2% ODI 10004422 NHTSARECALL 98-V-190-000 CONCERNING UPPER PORTION OF FUEL TANK THAT CAN DEVELOP SMALL CRACKS DUE TO EXTENDED EXPOSURE TO VERY HIGH AMBIENT TEMPERATURES. FUEL VAPOR OR LEAKAGE COULD OCCUR AT THESE CRACKS. CONSUMER HADTHE RECALL LETTER, BUT MANUFACTURER DIDN'T HONOR IT. PLEASE PROVIDE FURTHER INFORMATION.TS. *AK Look up ODI 10004422 at NHTSA ↗	10.4% ODI 528331 DEFECTIVE FUEL TANK CAUSING LEAKAGE OF FUEL. Look up ODI 528331 at NHTSA ↗	10.3% ODI 547856 FUEL TANK AROUND STRAPS DEVELOPED HAIRLINE CRACKS FROM CHAFFING CAUSING SEAPAGES. MJS Look up ODI 547856 at NHTSA ↗	30.8% ODI 564167 CONSUMER STATED THAT VEHICLE IS EXPERIENCING PROBLEMS WITH A FAULTY GAS TANK AND IS REQUESTING REMIBURSEMENT, CONSUMER STATED THAT HIS 1990 FORD AEROSTAR WAS RECALLED FOR A FAULTY GAS TANK, AND EXPECTS TO HAVE HIS 1993 RECALLED AS WELL SINCE BOTH VEHICLES EXPERIENCED THE SAME PROBLEM. *YD Look up ODI 564167 at NHTSA ↗	41.6% ODI 488852 ENGINE LIGHT LUMINATES. *SD Look up ODI 488852 at NHTSA ↗	21.3% ODI 8016902 PLASTIC FUEL TANK IS CRACKING AT THE TOP WHICH IS CAUSING A MASSIVE FUEL LEAK, AND POSSIBLE HAZARD. FUEL TANK MUST BE KEPT AT HALF LEVEL, BUT IT DOES NOT STOP FUMES FROM ENTERING COMPARTMENT. AK YH Look up ODI 8016902 at NHTSA ↗	00.0% No examples available for this selection.	00.0% No examples available for this selection.	00.0% No examples available for this selection.	00.0% No examples available for this selection.	00.0% No examples available for this selection.
Vehicle Speed Control	23.8% ODI 510720 SUDDEN ACCELERATION, CAUSING ACCIDENT. Look up ODI 510720 at NHTSA ↗	54.4% ODI 731103 SEPTEMBER 11, 2000. NO SAFETY DEFECT MENTIONE DIN SUMMARY. *AK Look up ODI 731103 at NHTSA ↗	52.8% ODI 753198 VEHICLE WAS PARKED IN THE GARAGE, AND HAD BEEN BACKED INTO THE GARAGE, HEADING OUT. AFTER STARTING VEHICLE, PUTTING IT INTO GEAR, AND LIGHTLY TOUCHING THE THROTTLE, THE VEHICLE'S THROTTLE WAS SUDDENLY PULLED ALL THE WAY TO THE FLOORBOARD. THE VEHICLE SCREAMED OUT OF THE GARAGE UNCONTROLLABLY AND CRASHED INTO ANOTHER CAR IN THE DRIVEWAY.*AK Look up ODI 753198 at NHTSA ↗	114.2% ODI 10097085 · 102,371 mi THE CONSUMER STATED THAT BACK IN 1998 SHE HAD A ACCIDENT WITH HER FORD AEROSTAR. SHE STATED THAT WHEN SHE PULLED INTO A PARKING SPACE AND HIT THE BRAKES, THE VEHICLE SURGED FORWARD AND HIT A BUILDING. SHE SAID SHE HAD THE VEHICLE TOWED TO THE DEALER WHO STATED THAT THEY THOUGHT THE PROBLEM WAS A FAULTY IDLE AIR CONTROL. SHE SAID IT WAS REPAIRED AND SHE TOOK THE PART AND SENT IT TO THE MANUFACTURER. NOW THE PROBLEM HAS COME UP AGAIN AND SHE WAS ASKED TO BE A WITNESS, BECAUSE SOMEONE WAS KILLED, WHEN THEIR VEHICLE DID THE SAME THING. *JB … Look up ODI 10097085 at NHTSA ↗	147.2% ODI 10079452 · 60,000 mi UPON STARTING THE VEHICLE, IT ACCELERATED AT A HIGH SPEED AND CRASHED INTO A BUILDING. THE DRIVER'S FOOT WAS ON THE BRAKE PEDAL WHEN SUDDEN ACCELERATION OCCURRED. THE VEHICLE WAS TOTALED. THE INSURANCE COMPANY INDICATED THAT THE INCIDENT WAS INCONCLUSIVE. THERE WAS A TRANSMISSION RECALL 91V189000, BUT THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. AK SC *JB Look up ODI 10079452 at NHTSA ↗	188.1% ODI 500755 BRAKE CALIPERS STICK. *SD Look up ODI 500755 at NHTSA ↗	82.5% ODI 544561 CRUISE CONTROL REMAINED ACTIVE DESPITE ATTEMPTS TO DISABLE IT WITH CONTROL SWITCH, VEHICLE WAS STOPPED BY TURNING VEHICLE OFF. Look up ODI 544561 at NHTSA ↗	184.8% ODI 490876 INADEQUATE LUBE ON POWER WINDOWS. *SD Look up ODI 490876 at NHTSA ↗	93.5% ODI 10233257 · 120,000 mi ALL ELECTRONICS ON STEERING COLUMN DON'T WORK. AIR BAG SYSTEM FLASHES 3-2. NO AIRBAG (PRESUMABLY), CRUISE CONTROL OR HORN FUNCTION. *TR Look up ODI 10233257 at NHTSA ↗	42.5% ODI 542242 VEHICLE BUCKING/STALLING DUE TO FAILURE OF THE TP SENSOR AND EXHAUST OXYGEN SENSOR. Look up ODI 542242 at NHTSA ↗	21.9% ODI 704000 REQUIRES A SHIFT INTO 'NEUTRAL' TO DISENGAGE MAXIMUM THROTTLE DURING A PASSING MANUVER. SEEMS TO BE TORQUE RELATED. OCCURS INDEPENDENT OF 'CRUISE CONTROL' BEING ON OR OFF. APPLYING BRAKES OR TURNING CURISE TO OFF DOES NOT RELEASE THROTTLE. VEHICAL HAS BEEN BACK TO DEALER WHO SOLD VEHICLE AND ACCESSORY AT LEAST TWICE. CRUISE CONTROL HAS BEEN REPLACED BUT PROBLEM RECURS. Look up ODI 704000 at NHTSA ↗	69.5% ODI 10350538 · 48,000 mi NOTE: I WISH I HAD FOUND THIS SITE YEARS AGO. I COULD NOT GET PAST FORDS "BRICK WALL" TO SPEAK TO AN ENGINEER! 1. 1997 AEROSTAR - ACCELERATOR PEDAL WAS PRESSED DOWN QUICKLY TO PASS (2 LANE HIGHWAY). 2. NOW IN THE LEFT LANE, NOT FAR AHEAD OF PASSED THE CAR - I EXPERRIENCED A COMPLETE LOSS OF POWER - HARD RIGHT OVER TO SOFT SHOULDER - AVOIDED AN ONCOMING HEAD ON COLLISION - L JUST MISSED THE CAR BEING PASSED BY INCHES AND STOPPED. THE CRIMPED END OF CABLE TO THE CARBURATOR HAD RELEASED FROM THE ACCELERATOR PEDAL. 3. I CLAMPED THE CABLE… Look up ODI 10350538 at NHTSA ↗	00.0% No examples available for this selection.	114.3% ODI 10172783 THE MOTOR WOULD DIE AND THEN ACCELERATE SUDDENLY, SOMETIMES MAKING A CRANKING NOISE. THE SERVICE REPORT STATED THAT THERE NO PROBLEM. IN ADDITION, WHEN THE VEHICLE WAS PARKED AND WANTED TO CHANGE FROM PARKING TO DRIVE, IT WOULD BE STUCK, MAKING IT DIFFICULT TO CHANGE THE TRANSMISSION, USUALLY PRODUCING A LOUD CRANKING NOISE AS IF THE TRANSMISSION WAS TO EXPLODE. EVENTUALLY, IN FEBRUARY 2005 THE MOTOR BROKE DOWN AND BOTH THE MOTOR AND TRANSMISSION HAD TO BE REPLACED. THE DEALER (BAYAMON FORD) REPLACED THE MOTOR IN MARCH 2005 AND WHEN THE TRA… Look up ODI 10172783 at NHTSA ↗	00.0% No examples available for this selection.
Service Brakes, Hydraulic:Antilock/Traction Control/Electronic Limited Slip	00.0% No examples available for this selection.	10.9% ODI 533946 ABS BRAKE FAILURE. Look up ODI 533946 at NHTSA ↗	00.0% No examples available for this selection.	31.2% ODI 543498 ABS SYSTEM FAILED. Look up ODI 543498 at NHTSA ↗	147.2% ODI 10048473 · 190,000 mi THE REAR ANTI LOCK BRAKES HAVE MALFUNCTIONED, CAUSING THE BRAKES TO LOCK. AS A RESULT THE STEERING LOCK AND THE VEHICLE LOST CONTROL. NO REPORT OF AIRBAG DEPLOYMENT. PLEASE PROVIDE ADDITIONAL INFORMATION. *NLM Look up ODI 10048473 at NHTSA ↗	114.9% ODI 506542 ANTI LOCK BRAKES LOCKING UP, CAUSING VEHICLE TO VIBRATE. *DH Look up ODI 506542 at NHTSA ↗	196.0% ODI 523850 AIR CONDITIONING COMPRESSOR MALFUNCTIONED. IN ADDITION, NOISY ABS BRAKES/DEFECTIVE FRONT/REAR CV JOINTS/PREMATURE WEAR OF FRONT BRAKE PADS AND ROTORS/ELECTRIC DOOR LOCKS MALFUNCTIONED/LOWER BALL JOINT NOISE/ RADIATOR HOSE FAILURE AND PREMATURE DISTRIBUTOR/CAP/ROTOR WEAR. *AK Look up ODI 523850 at NHTSA ↗	174.5% ODI 10048270 WHILE DRIVING VEHICLE LOST CONTROL. TOOK VEHICLE TO INDEPENDENT REPAIR SHOP, AND MECHANIC INDICATED THAT THIS VEHICLE WAS ON RECALL CONCERNING TRANSFER CASE PROBLEM. ALSO, HAD BRAKE SYSTEM PROBLEM. *AK Look up ODI 10048270 at NHTSA ↗	124.7% ODI 518492 REAR ABS BRAKES FAILED THREE TIMES, ONCE RESULTING IN AN ACCIDENT. *AK Look up ODI 518492 at NHTSA ↗	74.5% ODI 522672 ABS BRAKE FAILURE. ALSO, PREMATURE WEAR OF FRONT BRAKE ROTORS, RESULTING IN SCORING AND VIBRATION. *AK Look up ODI 522672 at NHTSA ↗	54.8% ODI 706692 ON APRIL 19, 1999, QUALITY OF NAPA LOCATED AT 1823 SOSCOL AVE, NAPA, 94559, PERFORMED OUR 30,000 MILE SERVICE WHICH IN OUR FORD MAINTENANCE SCHEDULE BOOK INCLUDES INSPECTION OF DISC BRAKE SYSTEM AND DRUM BRAKE SYSTEM. ON APRIL 19TH, OUR MILEAGE WAS 34,712.5 AND QUALITY SIGNED OFF ON THE MAINTENANCE SCHEDULE FOR BOTH THE 30,000 & 35,000 MILE SERVICE. ON OR ABOUT MAY 17TH, 1999 OUR BRAKES FAILED AT 35,597 MILES, AND CAUSED US TO TAKE OUR VAN TO FORD FOR TROUBLESHOOTING. FORD CHARGED US OVER $500 TO REPLACE THE BRAKES. OUR COMPLAINT IS WITH QUA… Look up ODI 706692 at NHTSA ↗	34.8% ODI 818956 CONSUMER STARTED VEHICLE, PRESSED BRAKES, WENT TO REVERSE AND VEHICLE ACCELLERATED AT HIGH SPEED, RACING 100 FEET DOWN THE DRIVEWAY, ACROSS THE ROAD, JUMPED A CURVE AND TORE DOWN APPPROX. 70 FT. OF CHAINLINK FENCE. THE PIPE FROM FENCE BROKE BACK WINDOW OF VEHICLE ,PERTRUDING THROUGH HITTING CONSUMER ON HEAD, THEN BROKEN WINDSHIELD EXTENDED ABOUT 40 FT. OUTSIDE OF WINDSHIELD. THROUGH ALL OF THIS, CONSUMER STILL HAD FOOT ON THE BRAKES, THE VEHICLE DID NOT STOP UNTILL FENCE WAS CAUGHT UP UNDER VEHICLE. CONSUMER SUFFERS A SWOLLEN FOOT DUE TO PRES… Look up ODI 818956 at NHTSA ↗	00.0% No examples available for this selection.	00.0% No examples available for this selection.	00.0% No examples available for this selection.
Engine And Engine Cooling:Engine:Gasoline	917.0% ODI 503618 VEHICLE FIRE. *DH Look up ODI 503618 at NHTSA ↗	1513.2% ODI 504821 ENGINE COMPARTMENT FIRE. *SD Look up ODI 504821 at NHTSA ↗	105.6% ODI 482463 HEATER CORE FAILED. Look up ODI 482463 at NHTSA ↗	124.6% ODI 484796 VEHICLE FIRE. *AW Look up ODI 484796 at NHTSA ↗	115.6% ODI 504603 REPLACED WATER PUMP. Look up ODI 504603 at NHTSA ↗	83.6% ODI 480446 NOISY ENGINE/EXCESSIVE OIL CONSUMPTION/MAIN BEARING FAILURE. *TW Look up ODI 480446 at NHTSA ↗	82.5% ODI 511441 VEHICLE FIRE. Look up ODI 511441 at NHTSA ↗	102.7% ODI 512549 IGNITION KEY GETS HOT. Look up ODI 512549 at NHTSA ↗	51.9% ODI 558844 TRANSMISSION FAILED, VEHICLE WAS STUCK IN DRIVE, SHAVINGS WERE FOUND IN THE TRANSMISSION PAN, DEALER ALSO REPLACED THE SHIFTER CABLE. *SLC Look up ODI 558844 at NHTSA ↗	10.6% ODI 705043 VERY DISAPPOINTING VEHICLE! NP SAFETY DEFECT MENTIONED IN SUMMARY. *AK Look up ODI 705043 at NHTSA ↗	11.0% ODI 743038 MOTOR PINGS UNDER LOAD IN OVERDRIVE WHEN USING A/C AT 40-45 MPH. REQUIRES TAKING OUT OF OVERDRIVE MANUALLY. DEALER REPORTS NO CODES UPON COMPUTER CHECK. ENGINE ALSO PINGS IN WINTER ON LOAD GOING UP GRADE AT 40-45 MPH IN OVERDRIVE. DEALER REPORTED ENGINE COMPUTER INDICATES VERY LEAN CONDITION WHEN FORST PURCHASED....NO CORRECTION AVAILABLE. MILEAGE EXCELLENT 20-21 AROUND TOWN AND 27-30 ON HIGHWAY. THIS IS A GREAT VAN EXCEPT FOR THE PINGING. HAVE TRIED MID RANGE AND PREMIUM FUEL AND PREMIUM WITH NO BETTER RESULTS. MY RESEARCH SHOW A … Look up ODI 743038 at NHTSA ↗	11.6% ODI 744550 WHEN IT RAINS/UNABLE TO OPEN DOOR LOCK FROM PASSENGER SIDE; UNEXPLAINED STALL CHECK/ENGINE LIGHT CAME ON/STARTED WITH NO PROBLEM Look up ODI 744550 at NHTSA ↗	00.0% No examples available for this selection.	00.0% No examples available for this selection.	00.0% No examples available for this selection.
Power Train:Automatic Transmission:Lever And Linkage:Column Shift	00.0% No examples available for this selection.	00.0% No examples available for this selection.	10.6% ODI 500038 ENGINE MISSES. *DSH Look up ODI 500038 at NHTSA ↗	10.4% ODI 543498 ABS SYSTEM FAILED. Look up ODI 543498 at NHTSA ↗	42.1% ODI 510728 TRANSFER CASE FIRE. Look up ODI 510728 at NHTSA ↗	62.7% ODI 505127 TRANSFER CASE BROKE. Look up ODI 505127 at NHTSA ↗	216.6% ODI 10038132 · 142,297 mi THE SHIFTING LEVER IN THE STEERING COLUMN MALFUNCTIONED, WHICH CAUSED THE VEHICLE NOT TO SHIFT. PART# 2F0DC-7215 53. AK THIS WAS DUE TO A MECHANICAL FAILURE AND MAY BE A MANUFACTURER DEFECT. THE PROBLEM WAS THE TRANSMISSION/SHIFT ACTUATING TUBE. SCC *JB Look up ODI 10038132 at NHTSA ↗	205.3% ODI 523219 VEHICLE MADE A LOT OF RACKET WHEN ATTEMPTING TO SHIFT GEARS. ALSO, WHILE DRIVING VEHICLE VIBRATED. *AK Look up ODI 523219 at NHTSA ↗	145.4% ODI 506930 EXTENSION HOUSING WERE BUSTED. Look up ODI 506930 at NHTSA ↗	74.5% ODI 52309 TRANSFER CASE FAILED DUE TO DRIVESHAFT VIBRATION. *AK Look up ODI 52309 at NHTSA ↗	32.9% ODI 534103 CONSUMER IS HAVING TROUBLE RECEIVING RECALL REPAIR WORK ON THE TRANSFER CASE BY DEALERSHIP. Look up ODI 534103 at NHTSA ↗	23.2% ODI 8016938 VEHICLE WILL NOT RUN PROPERLY DUE TO THE TRANSFER CASE BEING DEFECTIVE. THERE IS A LOUD NOISE WHEN DRIVING. CONTACTED DEALER, AND THE DEALER NOTED THAT VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. AK YH Look up ODI 8016938 at NHTSA ↗	00.0% No examples available for this selection.	00.0% No examples available for this selection.	00.0% No examples available for this selection.
Electrical System:Wiring:Front Underhood	713.2% ODI 549265 POSSIBLE WIRING HARNESS IN THE ENGINE FAILURE RESULTING IN FIRE. NLM Look up ODI 549265 at NHTSA ↗	108.8% ODI 741072 VAN CAUGHT FIRE AND WAS A TOTAL LOSS. *AK Look up ODI 741072 at NHTSA ↗	84.5% ODI 10046164 · 36,520 mi TRUCK EXPERIENCED ELECTRICAL SYSTEM FAILURE. AS A RESULT THE TRUCK CAUGHT ON FIRE WITHIN TWO HOURS AFTER BEING PARKED. THE FIRE ORIGINATED UNDER THE HOOD. ALL THE UNDER HOOD ELECTRICAL COMPONENTS WERE MELTED. THE HEAT ALSO CRACKED THE WINDSHIELD.*AK Look up ODI 10046164 at NHTSA ↗	83.1% ODI 10169816 · 155,000 mi MY FORD AEROSTAR CAUGHT FIRE LAST NIGHT FOR NO APPARENT REASON. MY DAUGHTER HAD RETURNED FROM SCHOOL AND PARKED IT IN THE DRIVEWAY. APPROXIMATELY 2 HOURS LATER, A NEIGHBOR RANG THE DOOR BELL AND FRANTICALLY SAID "YOUR VAN IS ON FIRE". WE CALLED 911 AND THE FIRE DEPARTMENT WAS THERE WITHIN 3 MINUTES TO PUT IT OUT. *JB Look up ODI 10169816 at NHTSA ↗	42.1% ODI 711623 PARKED FOR 12 HOURS PRIOR TO FIRE AT 3:50 AM. Look up ODI 711623 at NHTSA ↗	125.4% ODI 511270 ELECTRICAL SHORT IN WIRING HARNESS, CAUSING FIRE. Look up ODI 511270 at NHTSA ↗	72.2% ODI 704786 THIS INCIDENT CAUSED ME $1623 OUT OF POCKET EXPENSE. NO DEFECT MENTIONED IN THE SUMMARY. *AK Look up ODI 704786 at NHTSA ↗	41.1% ODI 704676 TO WHOM IT MAY CONCERN : I HAVE HAD MY VEHICLE REPAIRED BY JACK DEMMER FORD AT A COST OF $3600.00 DUE TO MULTIPLE ELECTRICAL PROBLEMS. ALL HARNESSES WERE REPLACED. I HAVE THE OLD ONES WHICH I CAN MAKE AVAILABLE TO YOU . THE BURN MARKS IN THE MIDDLE OF THE HARNESS AWAY FROM ANY CONNECTORS SUGGESTS A SERIOUS PROBLEM WHICH SEEMS LIKE THE SAME TYPE OF PROBLEM YOU JUST INVESTIGATED FORD ABOUT. *AK Look up ODI 704676 at NHTSA ↗	114.3% ODI 10132510 · 100,000 mi DT: THE CONTACT STATED 1994, FORD VAN CAUGHT ON FIRE ON THE FREEWAY ON 8-8-05. SHE WAS NOT HAVING PROBLEMS PRIOR TO THE FIRE. THE FIRE SEEMED TO BE ELECTRICAL AND ORIGINATED UNDER THE HOOD. AK JB UPDATED 2/7/2006 - THE CONSUMER RECEIVED RECALL 97V204000 ON NOV 13, 1997 FOR THE TRANSFER CASE/DRIVESHAFT BUT THE DEALER REFUSED TO MAKE THE REPAIRS. THIS FAILURE OF THIS COMPONENT COULD RESULT IN A FIRE. THE CONSUMER RECEIVED INFORMATION FROM NHTSA ON TWO RECALLS FOR THE VEHICLE. ONE WAS 99V028000 FOR THE ELECTRICAL WIRING UNDER THE HOOD AND T… Look up ODI 10132510 at NHTSA ↗	42.5% ODI 10206495 · 150,000 mi TL*THE CONTACT OWNS A 1995 FORD AEROSTAR. WHILE DRIVING 20 MPH, THE VEHICLE SHUT OFF WITHOUT WARNING. THE CONTACT OPENED THE HOOD AND NOTICED THAT THE FUEL LINES WERE EXTREMELY HOT BEFORE THEY BURST INTO FLAMES. THE CONTACT SUSTAINED A BURNED RIGHT HAND. THE FIRE DEPARTMENT STATED THAT THE FUEL PUMP CAUSED THE FIRE. A POLICE REPORT WAS FILED. THE MANUFACTURER STATED THAT HIS VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 99V028000 (ELECTRICAL SYSTEM: WIRING: FRONT UNDER HOOD). THE CURRENT AND FAILURE MILEAGES WERE 150,000. Look up ODI 10206495 at NHTSA ↗	00.0% No examples available for this selection.	11.6% ODI 543351 SPARK PLUGS FAILED TWO TIMES. Look up ODI 543351 at NHTSA ↗	125.0% ODI 827053 DRIVING TRUCK AND STOPPED AT RED LIGHT LOST POWER. HEARD A POPPING SOUND AND BEGAN SMELLING SOMETHING BURNING. DROVE VEHICLE HOME AND PULLED INTO THE DRIVEWAY, AND SAW BLACK SMOKE COMING FROM UNDERNEATH THE HOOD. THE ALTERNATOR HAD BURNED THE WIRING HARNESS. *AK Look up ODI 827053 at NHTSA ↗	00.0% No examples available for this selection.	00.0% No examples available for this selection.

Darker cells indicate a larger share of submitted complaints. Components overlap. This measures complaint composition, not failure probability.

Failure mileage by component

Median and middle 50% of usable owner-reported mileages. Ranges require at least five records.

Component failure mileage distribution
Component	Mileage range (25th–75th percentile)	Median	Usable records	Examples
Electrical System:Ignition:Switch	122,500–179,500 mi	144,670 mi	7	ODI 10033973 · 386,118 mi THE ELECTRICAL SYSTEM FAILED AND CAUSED THE IGNITION SWITCH TO BE INOPERATIVE. THE DEALER WAS NOTIFIED. AK SCC NLM Look up ODI 10033973 at NHTSA ↗ ODI 10140845 · 208,000 mi DT: THE CONTACT RECEIVED NHTSA RECALL 96V071000 CONCERNING THE IGNITION SWITCH. WHEN HE CONTACTED FORD, THEY COULD NOT FIND THE VIN. THIS STARTED A COUPLE OF MONTHS AGO. THE SWITCH STARTED TO COME APART, CAUSING THE VEHICLE NOT TO START. HE REPAIRED IT HIMSELF, AND IT IS CURRENTLY WORKING.AK UPDATED 12/27/2005. NM Look up ODI 10140845 at NHTSA ↗ ODI 10076051 · 12,000 mi THE VEHICLE IS EXPERIENCING THE FAILURES DESCRIBED IN THE MASTER CYLINDER PISTONS RECALL 89V223000. IN ADDITION, THE ABS LIGHT COMES ON. ALSO, THE VEHICLE IS EXPERIENCING THE FAILURE DESCRIBED IN THE IGNITION SWITCH RECALL 96V071000 BUT THIS VEHICLE NOT INCLUDED IN RECALL DUE TO VIN. AK Look up ODI 10076051 at NHTSA ↗
Power Train:Automatic Transmission	Too few reports for a range	151,575 mi	2 (sparse)	ODI 10079452 · 60,000 mi UPON STARTING THE VEHICLE, IT ACCELERATED AT A HIGH SPEED AND CRASHED INTO A BUILDING. THE DRIVER'S FOOT WAS ON THE BRAKE PEDAL WHEN SUDDEN ACCELERATION OCCURRED. THE VEHICLE WAS TOTALED. THE INSURANCE COMPANY INDICATED THAT THE INCIDENT WAS INCONCLUSIVE. THERE WAS A TRANSMISSION RECALL 91V189000, BUT THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. AK SC *JB Look up ODI 10079452 at NHTSA ↗ ODI 10000660 · 243,150 mi THEY SAY "WHERE THERE'S SMOKE THERE'S FIRE" SO THAT'S WHY I CHECKED THE FIRE BUTTON ON THE FORM. JUST TO THE RIGHT OF THE ACCELERATOR THE CARPET STARTED SMOKING. WE STILL DON'T KNOW THE CAUSE. BUT, EVERYTIME WE RUN THE CAR AN AWFUL SMELL RESULTS. WE NO LONGER DRIVE LONG DISTANCES. IT'S OUR ONLY CAR BUT I WE'LL HAVE TO TAKE IT TO THE GARAGE SOON. WITH HOLIDAY BILLS THIS COULDN'T HAVE COME AT A WORSE TIME. Look up ODI 10000660 at NHTSA ↗
Fuel System, Gasoline:Storage:Tank Assembly	131,072–167,500 mi	144,000 mi	7	ODI 10044531 · 117,814 mi GAS TANK DEFECT STATED IN RECALL 98V190000 OCCURRED AFTER THE RECALL REPAIRS WERE PERFORMED.AK Look up ODI 10044531 at NHTSA ↗ ODI 10046079 · 144,000 mi CONSUMER IS STILL HAVING PROBLEMS WITH FUEL TANK LEAKING AFTER RECALL 98V190000 REPAIRS WERE DONE. CONSUMER SMELLS GAS FUMES INSIDE VEHICLE . AK NM Look up ODI 10046079 at NHTSA ↗ ODI 10048534 · 120,000 mi THE VAN WAS UNABLE TO PASS STATE INSPECTION DUE TO A GAS LEAK FROM THE TOP OF THE FUEL TANK. THERE WAS A FUEL TANK CRACK RECALL, BUT THE VEHICLE IDENTIFICATION NUMBER WAS OUTSIDE THE REMEDY SCOPE. JB MR NM Look up ODI 10048534 at NHTSA ↗
Vehicle Speed Control	Too few reports for a range	81,186 mi	4 (sparse)	ODI 10097085 · 102,371 mi THE CONSUMER STATED THAT BACK IN 1998 SHE HAD A ACCIDENT WITH HER FORD AEROSTAR. SHE STATED THAT WHEN SHE PULLED INTO A PARKING SPACE AND HIT THE BRAKES, THE VEHICLE SURGED FORWARD AND HIT A BUILDING. SHE SAID SHE HAD THE VEHICLE TOWED TO THE DEALER WHO STATED THAT THEY THOUGHT THE PROBLEM WAS A FAULTY IDLE AIR CONTROL. SHE SAID IT WAS REPAIRED AND SHE TOOK THE PART AND SENT IT TO THE MANUFACTURER. NOW THE PROBLEM HAS COME UP AGAIN AND SHE WAS ASKED TO BE A WITNESS, BECAUSE SOMEONE WAS KILLED, WHEN THEIR VEHICLE DID THE SAME THING. JB … Look up ODI 10097085 at NHTSA ↗ ODI 10079452 · 60,000 mi UPON STARTING THE VEHICLE, IT ACCELERATED AT A HIGH SPEED AND CRASHED INTO A BUILDING. THE DRIVER'S FOOT WAS ON THE BRAKE PEDAL WHEN SUDDEN ACCELERATION OCCURRED. THE VEHICLE WAS TOTALED. THE INSURANCE COMPANY INDICATED THAT THE INCIDENT WAS INCONCLUSIVE. THERE WAS A TRANSMISSION RECALL 91V189000, BUT THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. AK SC JB Look up ODI 10079452 at NHTSA ↗ ODI 10233257 · 120,000 mi ALL ELECTRONICS ON STEERING COLUMN DON'T WORK. AIR BAG SYSTEM FLASHES 3-2. NO AIRBAG (PRESUMABLY), CRUISE CONTROL OR HORN FUNCTION. *TR Look up ODI 10233257 at NHTSA ↗
Service Brakes, Hydraulic:Antilock/Traction Control/Electronic Limited Slip	Too few reports for a range	190,000 mi	1 (sparse)	ODI 10048473 · 190,000 mi THE REAR ANTI LOCK BRAKES HAVE MALFUNCTIONED, CAUSING THE BRAKES TO LOCK. AS A RESULT THE STEERING LOCK AND THE VEHICLE LOST CONTROL. NO REPORT OF AIRBAG DEPLOYMENT. PLEASE PROVIDE ADDITIONAL INFORMATION. *NLM Look up ODI 10048473 at NHTSA ↗
Power Train:Automatic Transmission:Lever And Linkage:Column Shift	Too few reports for a range	142,297 mi	1 (sparse)	ODI 10038132 · 142,297 mi THE SHIFTING LEVER IN THE STEERING COLUMN MALFUNCTIONED, WHICH CAUSED THE VEHICLE NOT TO SHIFT. PART# 2F0DC-7215 53. AK THIS WAS DUE TO A MECHANICAL FAILURE AND MAY BE A MANUFACTURER DEFECT. THE PROBLEM WAS THE TRANSMISSION/SHIFT ACTUATING TUBE. SCC *JB Look up ODI 10038132 at NHTSA ↗
Electrical System:Wiring:Front Underhood	Too few reports for a range	125,000 mi	4 (sparse)	ODI 10046164 · 36,520 mi TRUCK EXPERIENCED ELECTRICAL SYSTEM FAILURE. AS A RESULT THE TRUCK CAUGHT ON FIRE WITHIN TWO HOURS AFTER BEING PARKED. THE FIRE ORIGINATED UNDER THE HOOD. ALL THE UNDER HOOD ELECTRICAL COMPONENTS WERE MELTED. THE HEAT ALSO CRACKED THE WINDSHIELD.AK Look up ODI 10046164 at NHTSA ↗ ODI 10169816 · 155,000 mi MY FORD AEROSTAR CAUGHT FIRE LAST NIGHT FOR NO APPARENT REASON. MY DAUGHTER HAD RETURNED FROM SCHOOL AND PARKED IT IN THE DRIVEWAY. APPROXIMATELY 2 HOURS LATER, A NEIGHBOR RANG THE DOOR BELL AND FRANTICALLY SAID "YOUR VAN IS ON FIRE". WE CALLED 911 AND THE FIRE DEPARTMENT WAS THERE WITHIN 3 MINUTES TO PUT IT OUT. JB Look up ODI 10169816 at NHTSA ↗ ODI 10132510 · 100,000 mi DT: THE CONTACT STATED 1994, FORD VAN CAUGHT ON FIRE ON THE FREEWAY ON 8-8-05. SHE WAS NOT HAVING PROBLEMS PRIOR TO THE FIRE. THE FIRE SEEMED TO BE ELECTRICAL AND ORIGINATED UNDER THE HOOD. AK JB UPDATED 2/7/2006 - THE CONSUMER RECEIVED RECALL 97V204000 ON NOV 13, 1997 FOR THE TRANSFER CASE/DRIVESHAFT BUT THE DEALER REFUSED TO MAKE THE REPAIRS. THIS FAILURE OF THIS COMPONENT COULD RESULT IN A FIRE. THE CONSUMER RECEIVED INFORMATION FROM NHTSA ON TWO RECALLS FOR THE VEHICLE. ONE WAS 99V028000 FOR THE ELECTRICAL WIRING UNDER THE HOOD AND T… Look up ODI 10132510 at NHTSA ↗

Complaint and recall timeline

Explore monthly filing activity alongside recall announcements. Up to ten years of monthly history is available.

ComponentPeriod

Solid line: filed complaints. Dashed amber lines: recall announcement dates for this vehicle selection; markers include all recall components. The latest month is partial. Temporal proximity does not establish causation.

Monthly counts, recall campaigns and complaint examples

Monthly complaint and recall timeline
Month	Campaigns announced	Examples
2024-10	None	No examples available for this selection.
2024-11	None	No examples available for this selection.
2024-12	None	No examples available for this selection.
2025-01	None	No examples available for this selection.
2025-02	None	No examples available for this selection.
2025-03	None	No examples available for this selection.
2025-04	None	No examples available for this selection.
2025-05	None	No examples available for this selection.
2025-06	None	No examples available for this selection.
2025-07	None	No examples available for this selection.
2025-08	None	No examples available for this selection.
2025-09	None	No examples available for this selection.
2025-10	None	No examples available for this selection.
2025-11	None	No examples available for this selection.
2025-12	None	No examples available for this selection.
2026-01	None	No examples available for this selection.
2026-02	None	No examples available for this selection.
2026-03	None	No examples available for this selection.
2026-04	None	No examples available for this selection.
2026-05	None	No examples available for this selection.
2026-06	None	No examples available for this selection.
2026-07	None	No examples available for this selection.
2026-08	None	No examples available for this selection.
2026-09 (partial)	None	No examples available for this selection.

Emerging complaint spikes

Complete months in the latest six months with at least 10 complaints, at least twice the preceding 12-month average, and at least three square-root deviations above that average.

This is a descriptive screening rule, not a statistical defect finding. Publicity and reporting changes can increase submissions.

No complete months meet the spike thresholds for this selection.

Equal-age model-year comparison

Model-wide cumulative reports during the first three or five calendar years, starting with the model year (age 0). Only fully elapsed windows are compared.

Observation windowFirst model yearSecond model year

1999: 3 complaints · 2000: 2 complaints

Equal observation windows
Model year	Through age 0	Through age 1	Through age 2
1999	1	3	3
2000	1	2	2

Date coverage across each selected cohort

Date basis for all complaints in selected model years
Year	Incident dates used	Filing date fallbacks	Excluded dates
1999	4	3	0
2000	6	0	0

Incident date is preferred when valid and no later than filing; otherwise filing date is used. Model year approximates age. Equal observation time does not adjust for sales, distance driven or reporting delays. One complaint linked to multiple model years can appear in each cohort.

Components reported together

Each cell counts unique complaints naming both components. Open a nonzero cell for examples.

Component co-occurrence matrix
Component	Electrical System:Ignition:Switch	Power Train:Automatic Transmission	Fuel System, Gasoline:Storage:Tank Assembly	Vehicle Speed Control	Service Brakes, Hydraulic:Antilock/Traction Control/Electronic Limited Slip	Engine And Engine Cooling:Engine:Gasoline	Power Train:Automatic Transmission:Lever And Linkage:Column Shift	Electrical System:Wiring:Front Underhood
Electrical System:Ignition:Switch	—	2 ODI 533725 DRIVER'S POWER WINDOW MALFUNCTIONED. IN ADDITION, TRANSMISSION FAILED/ABS LIGHT INTERMITTENTLY COMES ON/MASTER CYLINDER FAILED, CAUSING AN ACCIDENT/AIR CONDITIONING COMPRESSOR FAILED/TIE RODS REPLACED/TAIL LIGHTS REPEATED LY REPLACED/IGNITION SWITCH FAILED, CAUSING A FIRE/REPEATED ENGINE OIL LEAKS AND CATALYTIC CONVERTER REPLACED. Look up ODI 533725 at NHTSA ↗ ODI 545736 RECALL WORK COMPLETED ON THE TRANSFER CASE ON JULY 1998, HOWEVER TRANSMISSION NEEDED TO BE REBUILT ON MARCH 1999, TRANSFER CASE WAS LEAKING. MJS Look up ODI 545736 at NHTSA ↗	0	2 ODI 707305 CRUISE CONTROL/HORN QUIT WORKING/AIRBAG LIGHT FLASHES, AND SMOKE CAME FROM STEERING COLUMN AT IGNITION SWITCH. AK Look up ODI 707305 at NHTSA ↗ ODI 837469 VEHICLE WAS REPAIRED UNDER RECALL 99V029000, CONCERNING IGNITION SWITCH SHORT. AFTER DEALER PERFORMED THE WORK. CRUISE CONTROL DID NOT WORK. CONUSMER CONTACTED MANUFACTURER AND WAS TOLD TO TAKE THE VEHICLE BACK TO THE DEALER FOR REPAIRS. DEALER CHARGED CONSUMER FOR WORK PERFORMED THE SECOND TIME. AK Look up ODI 837469 at NHTSA ↗	2 ODI 533725 DRIVER'S POWER WINDOW MALFUNCTIONED. IN ADDITION, TRANSMISSION FAILED/ABS LIGHT INTERMITTENTLY COMES ON/MASTER CYLINDER FAILED, CAUSING AN ACCIDENT/AIR CONDITIONING COMPRESSOR FAILED/TIE RODS REPLACED/TAIL LIGHTS REPEATED LY REPLACED/IGNITION SWITCH FAILED, CAUSING A FIRE/REPEATED ENGINE OIL LEAKS AND CATALYTIC CONVERTER REPLACED. Look up ODI 533725 at NHTSA ↗ ODI 715983 YOU CAN PULL THE KEY OUT AND THE VAN WILL STAY RUNNING. CRANK THE VAN AND ALL THE LIGHTS SUCH AS ABS BRAKE, AIRBAG, OIL, ECT. LIGHTS STAY ON AND YOU HAVE TO TURN THE VAN OFF AND THEN CRANK IT AGAIN AND THE LIGHTS USUALLY GO OFF. *AK Look up ODI 715983 at NHTSA ↗	2 ODI 986323 WHILE PARKED IN GARAGE THE AUTO JUST BURST INTO FLAMES AND BURNED COMPLETELY UP. AK JB Look up ODI 986323 at NHTSA ↗ ODI 533725 DRIVER'S POWER WINDOW MALFUNCTIONED. IN ADDITION, TRANSMISSION FAILED/ABS LIGHT INTERMITTENTLY COMES ON/MASTER CYLINDER FAILED, CAUSING AN ACCIDENT/AIR CONDITIONING COMPRESSOR FAILED/TIE RODS REPLACED/TAIL LIGHTS REPEATED LY REPLACED/IGNITION SWITCH FAILED, CAUSING A FIRE/REPEATED ENGINE OIL LEAKS AND CATALYTIC CONVERTER REPLACED. Look up ODI 533725 at NHTSA ↗	0	2 ODI 705053 POWER WINDOWS DO NOT GO DOWN PROPERLY. I HAVE TO MANUALLY PUSH THEM DOWN IN ORDER TO OPEN THEM. THIS STARTED JUST AFTER THE CAR WARRANTY EXPIRED. IN NOVEMBER OF 1998, I WAS UNABLE TO START MY CAR. I LIFTED THE HOOD AND DISCOVERED A SMALL FLAME ON AN ELECTRICAL WIRE. I HAD ALREADY BEEN HAVING PROBLEMS WITH THE KEY NOT FITTING PROPERLY IN THE IGNITION, THE BELL SOUNDING EVEN IF THE KEY WERE NOT INSERTED IN THE IGNITION AND THE DIGITAL READ-OUT OF THE RADIO WILL WORK INTERMITTENTLY. I HAD THE CAR TOWED AND HAD TO HAVE A NEW STARTER INSTALL… Look up ODI 705053 at NHTSA ↗ ODI 546028 VEHICLE EXPERIENCED FAILURE OF SEVERAL COMPONENTS DUE TO BAD WIRING, RECALL ON WIRING HARNESS AND IGNITION SWITCH, HOWEVER DENIED REPAIR REFUND OF FAILURE. (99V028 WIRING HARNESS RECALL- NOT COMPLETED DUE TO LACK OF PARTS). (99V029 IGNITION SWITCH RECALL).MJS Look up ODI 546028 at NHTSA ↗
Power Train:Automatic Transmission	2 ODI 533725 DRIVER'S POWER WINDOW MALFUNCTIONED. IN ADDITION, TRANSMISSION FAILED/ABS LIGHT INTERMITTENTLY COMES ON/MASTER CYLINDER FAILED, CAUSING AN ACCIDENT/AIR CONDITIONING COMPRESSOR FAILED/TIE RODS REPLACED/TAIL LIGHTS REPEATED LY REPLACED/IGNITION SWITCH FAILED, CAUSING A FIRE/REPEATED ENGINE OIL LEAKS AND CATALYTIC CONVERTER REPLACED. Look up ODI 533725 at NHTSA ↗ ODI 545736 RECALL WORK COMPLETED ON THE TRANSFER CASE ON JULY 1998, HOWEVER TRANSMISSION NEEDED TO BE REBUILT ON MARCH 1999, TRANSFER CASE WAS LEAKING. MJS Look up ODI 545736 at NHTSA ↗	—	1 ODI 709239 I PURCHASED THIS VAN TO ACCOMODATE MY FAMILY OF 7. THE A/C AND TRANSMISSION HAD BEEN REPAIRED BY LICENSED TECHNITIONS. THE GAS TANK HAS A SMALL 'HAIRLINE' CRACK THAT I HAVE TRIED TO PATCH MYSELF. I FEEL THE GAS TANK LEAK LOCATED AT THE EDGE OF THE TANK IS A DESIGN FLAW, BUT WHAT DO I KNOW? I JUST WANT MY WIFE TO DRIVE MY FAMILY TO AND FROM THEIR DESTINATIONS SAFELY. I HAVE LIMITED FUNDS FOR ALL THE REPAIRS. THANKS FOR LISTENING. REGARDS, TIMOTHY J. SHINN, PH#[phone removed] Look up ODI 709239 at NHTSA ↗	5 ODI 964213 CONSUMER PURCHASE CAR USED WAS DRIVING CAR AND IT ACCELERATE AND MESS UP TRANSMISSION HAD IT REPLACE AND THE TRANSMISSION WHEN OUT AGAIN. TT Look up ODI 964213 at NHTSA ↗ ODI 10079452 · 60,000 mi UPON STARTING THE VEHICLE, IT ACCELERATED AT A HIGH SPEED AND CRASHED INTO A BUILDING. THE DRIVER'S FOOT WAS ON THE BRAKE PEDAL WHEN SUDDEN ACCELERATION OCCURRED. THE VEHICLE WAS TOTALED. THE INSURANCE COMPANY INDICATED THAT THE INCIDENT WAS INCONCLUSIVE. THERE WAS A TRANSMISSION RECALL 91V189000, BUT THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. AK SC JB Look up ODI 10079452 at NHTSA ↗ ODI 8004451 VEHICLE WAS PARKED. DRIVER TURNED IGNITION AND VEHICLE WAS IDLING WHEN IT STARTED TO REV, SUDDENLY TRANSMISSION JUMPED INTO REVERSE AND HIT A BUILDING.AK Look up ODI 8004451 at NHTSA ↗	3 ODI 832436 CONSUMER HAS MULTIPLE PROBLEMS WITH VEHICLE. A/C "O" RINGS LEAKED FREON/FRONT BRAKE ROTORS WARPED ALL AROUND PRIOR TO RECALL 98EO10000)/TRANSMISSION CONTINUOUSLY HUMMING, (MR-91S41)/FUEL STRONGLY SMELLS INSIDE OF VEHICLE, AND ABS LIGHT STAYS ON. DEALER AND MANUFACTURER CONTACTED AND AWARE OF SOME PROBLEMS, INDICATED VIN# DOES NOT COMPLY TO THE RECALLS. PROBLEMS STILL EXISTS. PROVIDE FURTHER INFORMATION. AK Look up ODI 832436 at NHTSA ↗ ODI 899966 IN DAMP OR WET CONDITIONS REAR BRAKES WILL LOCK UP. TAKEN TO DEALER NUMEROUS TIMES, INSISTED THAT THIS WAS NORMAL FOR THIS VEHICLE. AK THE TRANSMISSION WILL NOT SHIFT CORRECTLY. UP OR DOWN SHIFTS BETWEEN FIRST AND SECOND GEARS IS VERY ROUGH AND SLOPPY. ALSO, WHEN THE WEATHER IS COLD THE TRANSMISSION REFUSES TO SHIFT INTO REVERSE OR FORWARD AT TIMES. THE CONSUMER STATED THAT THE TRANSMISSION WAS REBUILT AT 68,000 BY THE DEALER AND WITHIN A FEW MONTHS THE SAME PROBLEMS STARTED UP AGAIN. *YH Look up ODI 899966 at NHTSA ↗ ODI 533725 DRIVER'S POWER WINDOW MALFUNCTIONED. IN ADDITION, TRANSMISSION FAILED/ABS LIGHT INTERMITTENTLY COMES ON/MASTER CYLINDER FAILED, CAUSING AN ACCIDENT/AIR CONDITIONING COMPRESSOR FAILED/TIE RODS REPLACED/TAIL LIGHTS REPEATED LY REPLACED/IGNITION SWITCH FAILED, CAUSING A FIRE/REPEATED ENGINE OIL LEAKS AND CATALYTIC CONVERTER REPLACED. Look up ODI 533725 at NHTSA ↗	11 ODI 836100 WHILE DRIVING BETWEEN 20 MPH AND 40 MPH TRANSMISSION WENT OUT TWICE, AND CONSUMER HAD TO HAVE TRANMISSION REPLACED. CURRENTLY, WHILE DRIVING AT 20 MPH TRANMISSION SLIPS INTO NEUTRAL,AND THE CONSUMER CAN'T MOVE VEHICLE OR START THE VEHICLE UP FOR A WHILE. ALSO, VEHICLE IS STALLING AND THE CONSUMER IS LOSING POWER. *AK Look up ODI 836100 at NHTSA ↗ ODI 482463 HEATER CORE FAILED. Look up ODI 482463 at NHTSA ↗ ODI 500854 ENGINE NOISE WHEN TAKING OFF, ALSO ENGINE OIL LEAK. Look up ODI 500854 at NHTSA ↗	6 ODI 826866 WHILE DRIVING THE TRANSFER CASE AND TRANSMISSION VIBRATE AND BECOME DETACHED AT HIGHWAY SPEEDS. THE MANUFACTURER HAS BEEN NOTIFIED. AK Look up ODI 826866 at NHTSA ↗ ODI 868915 CONSUMER WAS TRAVELING ABOUT 75MPH ON HIGHWAY WHEN DRIVESHAFT BENT, CAUSING THE FAILURE OF THE TRANSFER CASE AND TRANSMISSION. VEHICLE WAS VIBRATING AND THERE WAS TRANSMISSION FLUID LEAKING FROM UNDERNEATH VEHICLE. THERE WERE NO PRIOR WARNING. HE TOOK VEHICLE TO DEALERSHIP, AND MECHANIC TOLD HIM THAT HIS VEHICLE WASN'T ON RECALL.AK Look up ODI 868915 at NHTSA ↗ ODI 529034 TRANSMISSION FAILED. Look up ODI 529034 at NHTSA ↗	0
Fuel System, Gasoline:Storage:Tank Assembly	0	1 ODI 709239 I PURCHASED THIS VAN TO ACCOMODATE MY FAMILY OF 7. THE A/C AND TRANSMISSION HAD BEEN REPAIRED BY LICENSED TECHNITIONS. THE GAS TANK HAS A SMALL 'HAIRLINE' CRACK THAT I HAVE TRIED TO PATCH MYSELF. I FEEL THE GAS TANK LEAK LOCATED AT THE EDGE OF THE TANK IS A DESIGN FLAW, BUT WHAT DO I KNOW? I JUST WANT MY WIFE TO DRIVE MY FAMILY TO AND FROM THEIR DESTINATIONS SAFELY. I HAVE LIMITED FUNDS FOR ALL THE REPAIRS. THANKS FOR LISTENING. REGARDS, TIMOTHY J. SHINN, PH#[phone removed] Look up ODI 709239 at NHTSA ↗	—	0	0	0	0	0
Vehicle Speed Control	2 ODI 707305 CRUISE CONTROL/HORN QUIT WORKING/AIRBAG LIGHT FLASHES, AND SMOKE CAME FROM STEERING COLUMN AT IGNITION SWITCH. AK Look up ODI 707305 at NHTSA ↗ ODI 837469 VEHICLE WAS REPAIRED UNDER RECALL 99V029000, CONCERNING IGNITION SWITCH SHORT. AFTER DEALER PERFORMED THE WORK. CRUISE CONTROL DID NOT WORK. CONUSMER CONTACTED MANUFACTURER AND WAS TOLD TO TAKE THE VEHICLE BACK TO THE DEALER FOR REPAIRS. DEALER CHARGED CONSUMER FOR WORK PERFORMED THE SECOND TIME. AK Look up ODI 837469 at NHTSA ↗	5 ODI 964213 CONSUMER PURCHASE CAR USED WAS DRIVING CAR AND IT ACCELERATE AND MESS UP TRANSMISSION HAD IT REPLACE AND THE TRANSMISSION WHEN OUT AGAIN. TT Look up ODI 964213 at NHTSA ↗ ODI 10079452 · 60,000 mi UPON STARTING THE VEHICLE, IT ACCELERATED AT A HIGH SPEED AND CRASHED INTO A BUILDING. THE DRIVER'S FOOT WAS ON THE BRAKE PEDAL WHEN SUDDEN ACCELERATION OCCURRED. THE VEHICLE WAS TOTALED. THE INSURANCE COMPANY INDICATED THAT THE INCIDENT WAS INCONCLUSIVE. THERE WAS A TRANSMISSION RECALL 91V189000, BUT THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. AK SC JB Look up ODI 10079452 at NHTSA ↗ ODI 8004451 VEHICLE WAS PARKED. DRIVER TURNED IGNITION AND VEHICLE WAS IDLING WHEN IT STARTED TO REV, SUDDENLY TRANSMISSION JUMPED INTO REVERSE AND HIT A BUILDING.AK Look up ODI 8004451 at NHTSA ↗	0	—	5 ODI 844032 HAD SHIFTED INTO DRIVE & TOOK FOOT OFF BRAKE,VEHICLE WENT FULL THROTTLE IN PARKING LOT. HIT PILLAR. HAD FAILED TO STOP WHEN BRAKES WERE APPLIED. INTERMITTENT PROBLEM. TAKING VEHICLE TO DEALER. AK THE PROBLEM OCCURED AGAIN BUT THE DEALER SAYS THE PROBLEM COULD NOT BE DUPLICATED. YH Look up ODI 844032 at NHTSA ↗ ODI 963284 ABS BRAKES FAILED. TT Look up ODI 963284 at NHTSA ↗ ODI 547394 CRUISE CONTROL IS NOT WORKING. *YC Look up ODI 547394 at NHTSA ↗	2 ODI 836017 WHILE DRIVING AT ANY SPEED AND COMING TO A STOP, AND THEN TRYING TO PULL OFF, VEHICLE WILL DIE OUT WITHOUT ANY PRIOR WARNING. CONSUMER IS LOSING ALOT OF GAS. ALSO, WHEN ON CRUISE CONTROL VEHICLE WILL ACCELERATE BY ITSELF. DEALER CAN'T DETERMINE THE PROBLEM. AK Look up ODI 836017 at NHTSA ↗ ODI 558844 TRANSMISSION FAILED, VEHICLE WAS STUCK IN DRIVE, SHAVINGS WERE FOUND IN THE TRANSMISSION PAN, DEALER ALSO REPLACED THE SHIFTER CABLE. SLC Look up ODI 558844 at NHTSA ↗	1 ODI 558844 TRANSMISSION FAILED, VEHICLE WAS STUCK IN DRIVE, SHAVINGS WERE FOUND IN THE TRANSMISSION PAN, DEALER ALSO REPLACED THE SHIFTER CABLE. *SLC Look up ODI 558844 at NHTSA ↗	0
Service Brakes, Hydraulic:Antilock/Traction Control/Electronic Limited Slip	2 ODI 533725 DRIVER'S POWER WINDOW MALFUNCTIONED. IN ADDITION, TRANSMISSION FAILED/ABS LIGHT INTERMITTENTLY COMES ON/MASTER CYLINDER FAILED, CAUSING AN ACCIDENT/AIR CONDITIONING COMPRESSOR FAILED/TIE RODS REPLACED/TAIL LIGHTS REPEATED LY REPLACED/IGNITION SWITCH FAILED, CAUSING A FIRE/REPEATED ENGINE OIL LEAKS AND CATALYTIC CONVERTER REPLACED. Look up ODI 533725 at NHTSA ↗ ODI 715983 YOU CAN PULL THE KEY OUT AND THE VAN WILL STAY RUNNING. CRANK THE VAN AND ALL THE LIGHTS SUCH AS ABS BRAKE, AIRBAG, OIL, ECT. LIGHTS STAY ON AND YOU HAVE TO TURN THE VAN OFF AND THEN CRANK IT AGAIN AND THE LIGHTS USUALLY GO OFF. *AK Look up ODI 715983 at NHTSA ↗	3 ODI 832436 CONSUMER HAS MULTIPLE PROBLEMS WITH VEHICLE. A/C "O" RINGS LEAKED FREON/FRONT BRAKE ROTORS WARPED ALL AROUND PRIOR TO RECALL 98EO10000)/TRANSMISSION CONTINUOUSLY HUMMING, (MR-91S41)/FUEL STRONGLY SMELLS INSIDE OF VEHICLE, AND ABS LIGHT STAYS ON. DEALER AND MANUFACTURER CONTACTED AND AWARE OF SOME PROBLEMS, INDICATED VIN# DOES NOT COMPLY TO THE RECALLS. PROBLEMS STILL EXISTS. PROVIDE FURTHER INFORMATION. AK Look up ODI 832436 at NHTSA ↗ ODI 899966 IN DAMP OR WET CONDITIONS REAR BRAKES WILL LOCK UP. TAKEN TO DEALER NUMEROUS TIMES, INSISTED THAT THIS WAS NORMAL FOR THIS VEHICLE. AK THE TRANSMISSION WILL NOT SHIFT CORRECTLY. UP OR DOWN SHIFTS BETWEEN FIRST AND SECOND GEARS IS VERY ROUGH AND SLOPPY. ALSO, WHEN THE WEATHER IS COLD THE TRANSMISSION REFUSES TO SHIFT INTO REVERSE OR FORWARD AT TIMES. THE CONSUMER STATED THAT THE TRANSMISSION WAS REBUILT AT 68,000 BY THE DEALER AND WITHIN A FEW MONTHS THE SAME PROBLEMS STARTED UP AGAIN. *YH Look up ODI 899966 at NHTSA ↗ ODI 533725 DRIVER'S POWER WINDOW MALFUNCTIONED. IN ADDITION, TRANSMISSION FAILED/ABS LIGHT INTERMITTENTLY COMES ON/MASTER CYLINDER FAILED, CAUSING AN ACCIDENT/AIR CONDITIONING COMPRESSOR FAILED/TIE RODS REPLACED/TAIL LIGHTS REPEATED LY REPLACED/IGNITION SWITCH FAILED, CAUSING A FIRE/REPEATED ENGINE OIL LEAKS AND CATALYTIC CONVERTER REPLACED. Look up ODI 533725 at NHTSA ↗	0	5 ODI 844032 HAD SHIFTED INTO DRIVE & TOOK FOOT OFF BRAKE,VEHICLE WENT FULL THROTTLE IN PARKING LOT. HIT PILLAR. HAD FAILED TO STOP WHEN BRAKES WERE APPLIED. INTERMITTENT PROBLEM. TAKING VEHICLE TO DEALER. AK THE PROBLEM OCCURED AGAIN BUT THE DEALER SAYS THE PROBLEM COULD NOT BE DUPLICATED. YH Look up ODI 844032 at NHTSA ↗ ODI 963284 ABS BRAKES FAILED. TT Look up ODI 963284 at NHTSA ↗ ODI 547394 CRUISE CONTROL IS NOT WORKING. *YC Look up ODI 547394 at NHTSA ↗	—	2 ODI 533725 DRIVER'S POWER WINDOW MALFUNCTIONED. IN ADDITION, TRANSMISSION FAILED/ABS LIGHT INTERMITTENTLY COMES ON/MASTER CYLINDER FAILED, CAUSING AN ACCIDENT/AIR CONDITIONING COMPRESSOR FAILED/TIE RODS REPLACED/TAIL LIGHTS REPEATED LY REPLACED/IGNITION SWITCH FAILED, CAUSING A FIRE/REPEATED ENGINE OIL LEAKS AND CATALYTIC CONVERTER REPLACED. Look up ODI 533725 at NHTSA ↗ ODI 973463 EXHUAST FUMES ARE LEAKING INTO THE PASSENGER COMPARTMENT AND CAUSE THE PASSENGERS TO BECOME SICK. TT THE ODOMETER MALFUNCTIONS. OIL LIGHTS AND ENGINE LIGHT CONTINUE TO COME ON BECAUSE THE VEHICLE BURNS 1-2 QUARTS OF OIL EVERY WEEK. BRAKES STICK AND THERE WAS BRICKS RUBBING KIND OF SOUND WHEN THE STEERING WHEEL TURNS. THE HORN FAILED. THE WEATHER STRIPPING AROUND THE SLIDE DOOR KEEP COMING OFF. *YH Look up ODI 973463 at NHTSA ↗	1 ODI 543498 ABS SYSTEM FAILED. Look up ODI 543498 at NHTSA ↗	0
Engine And Engine Cooling:Engine:Gasoline	2 ODI 986323 WHILE PARKED IN GARAGE THE AUTO JUST BURST INTO FLAMES AND BURNED COMPLETELY UP. AK JB Look up ODI 986323 at NHTSA ↗ ODI 533725 DRIVER'S POWER WINDOW MALFUNCTIONED. IN ADDITION, TRANSMISSION FAILED/ABS LIGHT INTERMITTENTLY COMES ON/MASTER CYLINDER FAILED, CAUSING AN ACCIDENT/AIR CONDITIONING COMPRESSOR FAILED/TIE RODS REPLACED/TAIL LIGHTS REPEATED LY REPLACED/IGNITION SWITCH FAILED, CAUSING A FIRE/REPEATED ENGINE OIL LEAKS AND CATALYTIC CONVERTER REPLACED. Look up ODI 533725 at NHTSA ↗	11 ODI 836100 WHILE DRIVING BETWEEN 20 MPH AND 40 MPH TRANSMISSION WENT OUT TWICE, AND CONSUMER HAD TO HAVE TRANMISSION REPLACED. CURRENTLY, WHILE DRIVING AT 20 MPH TRANMISSION SLIPS INTO NEUTRAL,AND THE CONSUMER CAN'T MOVE VEHICLE OR START THE VEHICLE UP FOR A WHILE. ALSO, VEHICLE IS STALLING AND THE CONSUMER IS LOSING POWER. *AK Look up ODI 836100 at NHTSA ↗ ODI 482463 HEATER CORE FAILED. Look up ODI 482463 at NHTSA ↗ ODI 500854 ENGINE NOISE WHEN TAKING OFF, ALSO ENGINE OIL LEAK. Look up ODI 500854 at NHTSA ↗	0	2 ODI 836017 WHILE DRIVING AT ANY SPEED AND COMING TO A STOP, AND THEN TRYING TO PULL OFF, VEHICLE WILL DIE OUT WITHOUT ANY PRIOR WARNING. CONSUMER IS LOSING ALOT OF GAS. ALSO, WHEN ON CRUISE CONTROL VEHICLE WILL ACCELERATE BY ITSELF. DEALER CAN'T DETERMINE THE PROBLEM. AK Look up ODI 836017 at NHTSA ↗ ODI 558844 TRANSMISSION FAILED, VEHICLE WAS STUCK IN DRIVE, SHAVINGS WERE FOUND IN THE TRANSMISSION PAN, DEALER ALSO REPLACED THE SHIFTER CABLE. SLC Look up ODI 558844 at NHTSA ↗	2 ODI 533725 DRIVER'S POWER WINDOW MALFUNCTIONED. IN ADDITION, TRANSMISSION FAILED/ABS LIGHT INTERMITTENTLY COMES ON/MASTER CYLINDER FAILED, CAUSING AN ACCIDENT/AIR CONDITIONING COMPRESSOR FAILED/TIE RODS REPLACED/TAIL LIGHTS REPEATED LY REPLACED/IGNITION SWITCH FAILED, CAUSING A FIRE/REPEATED ENGINE OIL LEAKS AND CATALYTIC CONVERTER REPLACED. Look up ODI 533725 at NHTSA ↗ ODI 973463 EXHUAST FUMES ARE LEAKING INTO THE PASSENGER COMPARTMENT AND CAUSE THE PASSENGERS TO BECOME SICK. TT THE ODOMETER MALFUNCTIONS. OIL LIGHTS AND ENGINE LIGHT CONTINUE TO COME ON BECAUSE THE VEHICLE BURNS 1-2 QUARTS OF OIL EVERY WEEK. BRAKES STICK AND THERE WAS BRICKS RUBBING KIND OF SOUND WHEN THE STEERING WHEEL TURNS. THE HORN FAILED. THE WEATHER STRIPPING AROUND THE SLIDE DOOR KEEP COMING OFF. *YH Look up ODI 973463 at NHTSA ↗	—	2 ODI 500038 ENGINE MISSES. DSH Look up ODI 500038 at NHTSA ↗ ODI 558844 TRANSMISSION FAILED, VEHICLE WAS STUCK IN DRIVE, SHAVINGS WERE FOUND IN THE TRANSMISSION PAN, DEALER ALSO REPLACED THE SHIFTER CABLE. SLC Look up ODI 558844 at NHTSA ↗	2 ODI 549265 POSSIBLE WIRING HARNESS IN THE ENGINE FAILURE RESULTING IN FIRE. NLM Look up ODI 549265 at NHTSA ↗ ODI 706738 DRIVING APPROXIMATELY 30 MPH VEHICLE STALLED IN ROADWAY. OPENED HOOD AND OBSERVED FIRE IN TOP CENTER REAR OF ENGINE COMPARTMENT. WAS UNABLE TO EXTINQUISH FIRE, RESULTING IN TOTAL DESTRUCTION OF VEHICLE. *AK Look up ODI 706738 at NHTSA ↗
Power Train:Automatic Transmission:Lever And Linkage:Column Shift	0	6 ODI 826866 WHILE DRIVING THE TRANSFER CASE AND TRANSMISSION VIBRATE AND BECOME DETACHED AT HIGHWAY SPEEDS. THE MANUFACTURER HAS BEEN NOTIFIED. AK Look up ODI 826866 at NHTSA ↗ ODI 868915 CONSUMER WAS TRAVELING ABOUT 75MPH ON HIGHWAY WHEN DRIVESHAFT BENT, CAUSING THE FAILURE OF THE TRANSFER CASE AND TRANSMISSION. VEHICLE WAS VIBRATING AND THERE WAS TRANSMISSION FLUID LEAKING FROM UNDERNEATH VEHICLE. THERE WERE NO PRIOR WARNING. HE TOOK VEHICLE TO DEALERSHIP, AND MECHANIC TOLD HIM THAT HIS VEHICLE WASN'T ON RECALL.AK Look up ODI 868915 at NHTSA ↗ ODI 529034 TRANSMISSION FAILED. Look up ODI 529034 at NHTSA ↗	0	1 ODI 558844 TRANSMISSION FAILED, VEHICLE WAS STUCK IN DRIVE, SHAVINGS WERE FOUND IN THE TRANSMISSION PAN, DEALER ALSO REPLACED THE SHIFTER CABLE. *SLC Look up ODI 558844 at NHTSA ↗	1 ODI 543498 ABS SYSTEM FAILED. Look up ODI 543498 at NHTSA ↗	2 ODI 500038 ENGINE MISSES. DSH Look up ODI 500038 at NHTSA ↗ ODI 558844 TRANSMISSION FAILED, VEHICLE WAS STUCK IN DRIVE, SHAVINGS WERE FOUND IN THE TRANSMISSION PAN, DEALER ALSO REPLACED THE SHIFTER CABLE. SLC Look up ODI 558844 at NHTSA ↗	—	0
Electrical System:Wiring:Front Underhood	2 ODI 705053 POWER WINDOWS DO NOT GO DOWN PROPERLY. I HAVE TO MANUALLY PUSH THEM DOWN IN ORDER TO OPEN THEM. THIS STARTED JUST AFTER THE CAR WARRANTY EXPIRED. IN NOVEMBER OF 1998, I WAS UNABLE TO START MY CAR. I LIFTED THE HOOD AND DISCOVERED A SMALL FLAME ON AN ELECTRICAL WIRE. I HAD ALREADY BEEN HAVING PROBLEMS WITH THE KEY NOT FITTING PROPERLY IN THE IGNITION, THE BELL SOUNDING EVEN IF THE KEY WERE NOT INSERTED IN THE IGNITION AND THE DIGITAL READ-OUT OF THE RADIO WILL WORK INTERMITTENTLY. I HAD THE CAR TOWED AND HAD TO HAVE A NEW STARTER INSTALL… Look up ODI 705053 at NHTSA ↗ ODI 546028 VEHICLE EXPERIENCED FAILURE OF SEVERAL COMPONENTS DUE TO BAD WIRING, RECALL ON WIRING HARNESS AND IGNITION SWITCH, HOWEVER DENIED REPAIR REFUND OF FAILURE. (99V028 WIRING HARNESS RECALL- NOT COMPLETED DUE TO LACK OF PARTS). (99V029 IGNITION SWITCH RECALL).MJS Look up ODI 546028 at NHTSA ↗	0	0	0	0	2 ODI 549265 POSSIBLE WIRING HARNESS IN THE ENGINE FAILURE RESULTING IN FIRE. NLM Look up ODI 549265 at NHTSA ↗ ODI 706738 DRIVING APPROXIMATELY 30 MPH VEHICLE STALLED IN ROADWAY. OPENED HOOD AND OBSERVED FIRE IN TOP CENTER REAR OF ENGINE COMPARTMENT. WAS UNABLE TO EXTINQUISH FIRE, RESULTING IN TOTAL DESTRUCTION OF VEHICLE. *AK Look up ODI 706738 at NHTSA ↗	0	—

Co-reporting does not establish that one component caused another concern.

Recurring narrative patterns

Specific keyword mentions beyond broad component labels. Matching includes negations and comparisons and does not confirm a diagnosis.

Search patterns

8 patterns with matching reports.

Brake response concerns

63 mentions · 2.7% of complaints

Median mileage: 60,000 mi (1 usable records).

ODI 533946

ABS BRAKE FAILURE.

Look up ODI 533946 at NHTSA ↗

ODI 820351

ADVANCED TO STOP LIGHT, APPLIED BRAKE, BRAKE PEDAL WENT TO THE FLOOR. RAN INTO SEVERAL CARS. *AK

Look up ODI 820351 at NHTSA ↗

ODI 567440

THE BRAKE PEDAL WENT DOWN WHEN THE BRAKE WAS APPLIED. ALSO THE MASTER CYLINDER RESERVOIR HAD TO BE TOPPED UP CONSTANTLY DUE TO BRAKE FLUID DRIPPING FROM A CRACK IN THE BRAKE HOSE. THE MECHANIC EXAMINED A SIMILAR FORD AEROSTAR 1990 AND STATED THAT THE PROBLEM WAS THE SAME LIKE THE 1988 FORD AEROSTAR.( WRITTEN IN BY A PROFFESSIONAL MECHANIC)*YH

Look up ODI 567440 at NHTSA ↗

Matching rule

Stalling or loss of power

52 mentions · 2.3% of complaints

Median mileage: 115,000 mi (3 usable records).

ODI 826925

CONSUMER EXPERIENCING ENGINE STALLING UPON STARTING THE VEHICLE. AFTER ENGINE WARMS UP, THE VEHICLE WOULD RUN NORMALLY. DEALER WAS NOT NOTIFIED. *AK

Look up ODI 826925 at NHTSA ↗

ODI 479698

ENGINE STALLS/WATER GOES EVERYWHERE WHENEVER AIR CONDITIONER OR HEATER IS ON AND VEHICLE IS STOPPED.

Look up ODI 479698 at NHTSA ↗

ODI 504563

VEHICLE MISSES/STALLS INTERMITTENTLY, ALSO CAUGHT FIRE ONCE.

Look up ODI 504563 at NHTSA ↗

Matching rule

\b(stall\w*|loss of power|lost power|engine shut\w* off)\b

Steering assistance concerns

36 mentions · 1.6% of complaints

Median mileage: 108,000 mi (3 usable records).

ODI 802043

POWER STEERING GEAR SEAL FAILS CONTINUOUSLY, RESULTING IN (4) REPLACEMENTS OF SAME PART. *AK

Look up ODI 802043 at NHTSA ↗

ODI 534869

POWER STEERING PUMP FAILED.

Look up ODI 534869 at NHTSA ↗

ODI 826676

WHILE DRIVING 50 TO 55 MPH STEERING WHEEL LOCKED UP, CAUSING VEHICLE TO ROLL OVER. ALSO BOTH REAR SEATS IN VEHICLE BECAME DISCONNECTED IN ACCIDENT. CAUSE UNKNOWN.

Look up ODI 826676 at NHTSA ↗

Matching rule

\b(power steer\w*|steering assist\w*|steering lock\w*|steering wheel lock\w*)\b

Fuel smell or leak mentions

31 mentions · 1.3% of complaints

Median mileage: 132,000 mi (2 usable records).

ODI 834042

WHENEVER FILLING UP THE FUEL TANK WOULD NOTICE FUEL LEAKING OUT OF THE GAS TANK, AND STRONG GAS FUMES. TOOK VEHICLE TO AUTOMATIVE SHOP & HAD 2 SEALS REPLACED. THE FUEL TANK WAS NOT INSPECTED. PROBLEM STILL EXISTS. *AK *ML

Look up ODI 834042 at NHTSA ↗

ODI 10046079 · 144,000 mi

CONSUMER IS STILL HAVING PROBLEMS WITH FUEL TANK LEAKING AFTER RECALL 98V190000 REPAIRS WERE DONE. CONSUMER SMELLS GAS FUMES INSIDE VEHICLE . *AK *NM

Look up ODI 10046079 at NHTSA ↗

ODI 10048534 · 120,000 mi

THE VAN WAS UNABLE TO PASS STATE INSPECTION DUE TO A GAS LEAK FROM THE TOP OF THE FUEL TANK. THERE WAS A FUEL TANK CRACK RECALL, BUT THE VEHICLE IDENTIFICATION NUMBER WAS OUTSIDE THE REMEDY SCOPE. *JB *MR *NM

Look up ODI 10048534 at NHTSA ↗

Matching rule

\b(fuel leak\w*|gas leak\w*|gas(?:oline)? smell|smell\w* (?:of )?(?:fuel|gas))\b

Warning lights and dashboard alerts

26 mentions · 1.1% of complaints

Median mileage: Unavailable (0 usable records).

ODI 832219

WHEN DRIVING CHECK ENGINE LIGHT CAME ON. PULLED OVER AND SMOKE CAME FROM HOOD OF ENGINE, VEHICLE CAUGHT FIRE. DEALER CONTACTED, AND STATED POINT OF IMPACT WITH FIRE AND PARTIAL LOSS. PROBLEM REPEATED ONE YEAR LATER. PROVIDE FURTHER INFORMATION. *AK

Look up ODI 832219 at NHTSA ↗

ODI 962928

CHECK ENGINE LIGHT WOULD STAY ON. *AK

Look up ODI 962928 at NHTSA ↗

ODI 484490

SHORT IN MASTER CYLINDER WIRING, CAUSING BRAKE/ABS WARNING LIGHTS TO STAY ON. *AK

Look up ODI 484490 at NHTSA ↗

Matching rule

\b(warning light\w*|check engine|dashboard warning\w*|malfunction indicator)\b

Hard or delayed shifting

13 mentions · 0.6% of complaints

Median mileage: 76,161 mi (2 usable records).

ODI 516738

TRANSMISSION FAILED CAUSING HESITATION/JERKING.

Look up ODI 516738 at NHTSA ↗

ODI 970098

AUTO-TRAN:VEHICLE LEFT RUNNING IN PARK, DRIVER GOT IN CAR, ATTEMPTED TO SHIFT FROM PARK TO REVERSE, ENGINE RACED, VEHICLE LURCHED FORWARD;TIRES SPUN;HIT TREE.

Look up ODI 970098 at NHTSA ↗

ODI 968668

THE TRANSMISSION, WHILE DRIVING, JERKS THE TRUCK. PLEASE DESCRIBE. *AK

Look up ODI 968668 at NHTSA ↗

Matching rule

Battery drain and no-start mentions

5 mentions · 0.2% of complaints

Median mileage: Unavailable (0 usable records).

ODI 557642

VEHICLE WOULD NOT START DUE TO FAILURE OF THE IGNITION MODULE. *MJS

Look up ODI 557642 at NHTSA ↗

ODI 862300

WHEN STARTING CAR IT WON'T START, VEHICLE HAS POWER, BUT WON'T TURN OVER. WHEN SHIFTING INTO DRIVE THEN BACK INTO PARK, VEHICLE WILL START. CONSUMER FELT SHIFT LEVER WAS NOT LOCKING PROPERLY AND CAR MAY ROLL. *AK

Look up ODI 862300 at NHTSA ↗

ODI 9005097

VEHICLE WOULD NOT START. TRANSMISSION TRANSFER CABLE CONSISTS OF INNER CABLE INSIDE METAL, RUBBER COVERING WITH ASBESTO COVERING (BURNED THRU) TO PROTECT AGAINST HOT EXHAUST PIPES AND MANIFOLD.

Look up ODI 9005097 at NHTSA ↗

Matching rule

Oil consumption or dilution

2 mentions · 0.1% of complaints

Median mileage: Unavailable (0 usable records).

ODI 975241

ENGINE ON THE VEHICLE IS BURNING OIL EVERY 800 MILES. TT

Look up ODI 975241 at NHTSA ↗

ODI 480446

NOISY ENGINE/EXCESSIVE OIL CONSUMPTION/MAIN BEARING FAILURE. *TW

Look up ODI 480446 at NHTSA ↗

Matching rule

\b(oil consumption|burn\w* oil|consum\w* oil|oil dilution|gas(?:oline)? in (?:the )?oil)\b