U.S. public vehicle records

Ford BRONCO SPORT electrical problems

245 complaint narratives mention electrical terms.

Key facts

1,362 owner complaints analyzed

32 distinct recall campaigns

32,000 mi median reported failure mileage

Scope: 2021 to 2026 model years. Data updated: 2026-09-30 (September 30, 2026). 336 complaints include usable failure mileage. View data status.

Electrical and battery issues evidence

245 of 1,362 complaints match this topic (18.0%). The keyword filter can include complaints that mention a transmission without reporting its failure. View matching rules.

Owner report 11406545 · 2021-04-05 (April 5, 2021)

THE VEHICLE STALLED [HALTED] ON MY DAUGHTER WHILE IN MOTION IN MOVING TRAFFIC. THE VEHICLE BECAME INOPERABLE AND WAS TOWED TO DEPAULA FORD ALBANY NY. THE VEHICLE STALLED AS A RESULT OF A FAULTY FUEL PUMP AND ONLY HAS 1449 MILES. MY DAUGHTER COULD HAVE BEEN INJURED AS A RESULT OF THE VEHICLE DISABLEMENT IN FLOWING TRAFFIC ON A BUSY CITY STREET. FUEL PUMP REPLACEMENTS ARE A "SUBSTANTIAL DEFECT" THAT IMPAIRS THE CAR'S USE, VALUE, AND MOST IMPORTANT SAFETY. THIS IS A SERIOUS SAFETY DEFECT TO THE FUEL AND EMISSION SYSTEM. FUEL PUMP PROBLE…

Owner-reported narrative. 1,449 miles reported. Look up ODI 11406545 at NHTSA ↗

Owner report 11428010 · 2021-08-06 (August 6, 2021)

The dash cluster was dead and the start button LED just flashed on and off. The battery, checked with a VOM, showed normal voltage. The vehicle would not start. I unhooked one of the battery terminals and waited 10 minutes for the system to reset. After reconnecting the battery the vehicle lit up, behaved and started as normal. One should not have to carry tools to reboot their vehicle.

Owner-reported narrative. Look up ODI 11428010 at NHTSA ↗

Owner report 11432247 · 2021-09-09 (September 9, 2021)

On morning of Sept 2, 2021 I was driving home from my overnight shift as a nurse getting off about 0635, driving down a major street in the downtown area. I was approx 6 blocks from my hospital approaching a busy intersection and my Bronco Sport [2021] lost all power. Because my speed was only 30mph, it was easy to just come to a stop after a short roll Anytime the Bronco Sport shuts off it automatically goes into Park. So I had no power, not even flashers and could not put it into neutral to push it out of the intersection onto a side street…

Owner-reported narrative. 5,000 miles reported. Look up ODI 11432247 at NHTSA ↗

Owner report 11470975 · 2022-06-25 (June 25, 2022)

While driving on surface and freeway, the vehicle dramatically loses fuel pressure and slows down. It's a hazard. Nearly rear-ended on the highway. After a while, pressure resumes, only to fail randomly. No warning or malfunction indicators appear. Vehicle has been at a Ford service center 2 times and is there again, now. First, they changed the battery. Then they told us we didn't drive it enough. Suspiciously, there's a recall addressing the exact same issue on the same make and model, made at a different plant. Perhaps it's related? NHTSA C…

Owner-reported narrative. Look up ODI 11470975 at NHTSA ↗

Owner report 11473343 · 2022-07-11 (July 11, 2022)

There is an electrical issue with the cars running lights, headlights and interior lighting. Intermittently, when the car is shut off and either locked or unlocked, the cars running lights, and/or headlights, and/or interior lighting fail to shut off. This occurs BEYOND the 30 to60 minute delay feature. This happens when you lock the door from the door lock or the key fob. In all cases the car has to be unlocked and relocked, trying either, or re-starting the car, shutting it off and locking the car again. At some point the battery will fai…

Owner-reported narrative. Look up ODI 11473343 at NHTSA ↗

Explore the data

Vehicle analysis explorer

Inspect model-year patterns, reported mileage, monthly activity and the evidence behind each signal.

Data completeness

1,362 unique complaints in this selection. Analysis snapshot: 2026-09-30.

24.7%Usable mileage336 / 1,362 records

100.0%Valid incident date1,362 / 1,362 records

100.0%Valid filing date1,362 / 1,362 records

100.0%Ordered incident and filing dates1,362 / 1,362 records

Missing, zero and invalid mileage is excluded. Dates after the snapshot are excluded. Examples are limited selections, not a representative sample.

Problems by model year

Model-wide comparison of the eight most reported components across the model. Cells show counts and shares within each model year. Open a cell for source examples.

From model yearThrough model year

Component complaint heatmap
Component	2021	2022	2023	2024	2025	2026
Electrical System	20129.0% ODI 11432247 · 5,000 mi On morning of Sept 2, 2021 I was driving home from my overnight shift as a nurse getting off about 0635, driving down a major street in the downtown area. I was approx 6 blocks from my hospital approaching a busy intersection and my Bronco Sport [2021] lost all power. Because my speed was only 30mph, it was easy to just come to a stop after a short roll Anytime the Bronco Sport shuts off it automatically goes into Park. So I had no power, not even flashers and could not put it into neutral to push it out of the intersection onto a side street… Look up ODI 11432247 at NHTSA ↗	7220.1% ODI 11492022 vehicle with 900 miles on it began smoking and caught fire under the hood for no apparent reason. Vehicle was in new condition. Vehicle likely a total loss (see photos). Driver was lucky to escape Look up ODI 11492022 at NHTSA ↗	3421.7% ODI 11548392 Ford Sonic Boom: When starting the 2023 Ford Bronco Sport there was a loud bang/crack sound like an enormous piece of hail fell on the car and the windows were cracking. The car started crackling loudly through the speaker system for about 15 minutes. Car was turned off and everybody exited the vehicle and the crackling continued. Read online that this has happened to other 2023 Ford Broncos and also to the Ford F-150. They have done a software update to hopefully fix the F-150, but they have yet to do one for the 2023 Ford Bronco Sport. T… Look up ODI 11548392 at NHTSA ↗	2725.0% ODI 11588899 The contact owns a 2024 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number 24V267000 (Electrical System, Power Train) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available. Look up ODI 11588899 at NHTSA ↗	25.3% ODI 11754307 1. The Electronic Power Assisted Steering (EPAS) module and/or the front passenger-side suspension components failed, causing a complete loss of steering control and an un-commanded, continuous violent pull to the right. Yes, the vehicle and all malfunctioning components are completely intact and available for immediate inspection upon request. 2. Safety was put at extreme risk during highway speeds. The vehicle violently and continuously swerved directly toward the right-hand passenger side. There were 5 total occupants in the SUV, including m… Look up ODI 11754307 at NHTSA ↗	114.3% ODI 11743715 2026 Bronco SportDescription Your vehicle may display a blank instrument panel cluster ipc screen upon startup. This may occur when the vehicle is restarted within a specific time interval after turning the vehicle off. Safety Risk A blank ipc screen will prevent the driver from seeing critical vehicle information such as the speedometer, warning lights, and warning messages. The inability to see this information increases the risk of a crash. Remedy Software is now available to repair your vehicle. Ford Motor Company has authorized your d… Look up ODI 11743715 at NHTSA ↗
Engine	14821.3% ODI 11448393 · 50,000 mi The contact owns a 2021 Ford Bronco Sport. The contact stated that the vehicle failed to start-up. The check engine warning light was illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 50,000. Look up ODI 11448393 at NHTSA ↗	7922.1% ODI 11452595 Engine makes intermittent metal crunching and scraping sounds at low speeds. Look up ODI 11452595 at NHTSA ↗	3723.6% ODI 11540264 · 250 mi The contact owns a 2023 Ford Bronco Sport. The contact stated while driving 25 MPH, the contact heard an abnormal sound coming from the vehicle. No warning light was illuminated. The vehicle was diagnosed by a dealer and confirmed that the engine and turbo charger was blown, and oil was coming out of the exhaust. The vehicle was not repaired due to parts not being available. The manufacturer was made aware of the failure and was unable to estimate time of arrival for parts. The failure mileage was approximately 250. Look up ODI 11540264 at NHTSA ↗	2422.2% ODI 11593802 On [XXX], my 2024 Ford Bronco Sport spontaneously burst into flames while driven by my [XXX] son. Per a local bystander, there was smoke and fire observed around the undercarriage as he drove down the road. Multiple vehicles began honking while stopped at a red light. A driver alerted my son of the fire. He was able to evacuate along with his [XXX] sister. As they were fleeing to the median of an active highway, the vehicle burst into flames. After several explosions the vehicle continued to burn and melt until the fire dept extinguished… Look up ODI 11593802 at NHTSA ↗	615.8% ODI 11647599 Vehicle was 2 weeks old at 100 miles engine light came on. Received notices that a engine misfire occurred and stated continued driving could further damage engine. Vehicle was towed to dealership where diagnosis said no fix currently available but can continue to drive? Look up ODI 11647599 at NHTSA ↗	114.3% ODI 11743715 2026 Bronco SportDescription Your vehicle may display a blank instrument panel cluster ipc screen upon startup. This may occur when the vehicle is restarted within a specific time interval after turning the vehicle off. Safety Risk A blank ipc screen will prevent the driver from seeing critical vehicle information such as the speedometer, warning lights, and warning messages. The inability to see this information increases the risk of a crash. Remedy Software is now available to repair your vehicle. Ford Motor Company has authorized your d… Look up ODI 11743715 at NHTSA ↗
Power Train	17525.2% ODI 11418461 while driving my shifter was accidentally tapped and went into neutral I went to a parking lot & at a slow speed I could put the car into reverse or park so if you are driving at 65 MPH it can be shifted and will be a safety issue I'm sure Look up ODI 11418461 at NHTSA ↗	6518.2% ODI 11469888 Received a Powertrain malfunction/reduced power warning at 190 miles. Noticed large oil leak on garage floor which turned out was leaking from TPU due to faulty cap. Car has been at dealer for 8 days to replace fluid and cap and no explanation provided for powertrain warning. Look up ODI 11469888 at NHTSA ↗	2012.7% ODI 11534194 The transmission has very rough shifts particularly at low speeds between 1st, 2nd and 3rd gear. It feels like the clutch sometimes does not fully engage, and the vehicle over-revs before finally getting into gear. This causes hesitation and poses a safety danger in particular when making turns like left turns in the city from a stop. I am concerned that even with sufficient space, the vehicle will hesitate to accelerate and I could get into an accident. I have not observed any warning lamps or other messages and the vehicle has not yet been i… Look up ODI 11534194 at NHTSA ↗	2018.5% ODI 11588899 The contact owns a 2024 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number 24V267000 (Electrical System, Power Train) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available. Look up ODI 11588899 at NHTSA ↗	718.4% ODI 11679469 2025 Bronco Do not drive your vehicle until your recall service is complete. Safety Recalls* Loose or missing upper ball joint fastener Recall incomplete Loose or missing upper ball joint fastener Recall incomplete Front upper control arm to knuckle ball joint loose or missing fastener Recall incomplete Inspect seat bolt presence and torque - recall is unable to be performed at this time. Please check the fsa landing page for more details. Recall incomplete Do not drive - front lower arm to frame attachment fastener inspection Recall … Look up ODI 11679469 at NHTSA ↗	114.3% ODI 11761016 2026 Bronco Sport Badlands Sasquatch edition with less than three-thousand miles that we purchased brand new had a major transmission failure and was rendered inoperable. The Bronco Sport transmission pan cracked and the gasket failed upon driving home from a routine, ten minute trip to the grocery store resulting in sudden loss of transmission fluid. The transmission fluid blew all over the engine compartment when this occurred The vehicle had to be towed to the dealership where it remains as of today (one week after the incident occurred). Th… Look up ODI 11761016 at NHTSA ↗
Unknown Or Other	9613.8% ODI 11423655 Small rock hit my windshield and caused a huge 12+ inch crack in the middle of the windshield. Started off as a small crack then grew. Look up ODI 11423655 at NHTSA ↗	5415.1% ODI 11452595 Engine makes intermittent metal crunching and scraping sounds at low speeds. Look up ODI 11452595 at NHTSA ↗	1710.8% ODI 11548392 Ford Sonic Boom: When starting the 2023 Ford Bronco Sport there was a loud bang/crack sound like an enormous piece of hail fell on the car and the windows were cracking. The car started crackling loudly through the speaker system for about 15 minutes. Car was turned off and everybody exited the vehicle and the crackling continued. Read online that this has happened to other 2023 Ford Broncos and also to the Ford F-150. They have done a software update to hopefully fix the F-150, but they have yet to do one for the 2023 Ford Bronco Sport. T… Look up ODI 11548392 at NHTSA ↗	2018.5% ODI 11621750 When I start my Bronco, daily, there a vibration even as I drive out of my garage. Once I’m on the road I don’t feel the vibration. I have taken my Bronco to the dealer 2-3 times and they tell me the Bronco doesn’t do as I stated to them. I can’t make this up, I think the mechanics are not sure what is wrong. I love my Bronco and have owned many fords over the years and have never had this issue. They did tell me, I should drive it more and the vibration should stop. At least they admitted it was happening. I drive 16 miles a day, so I’m not su… Look up ODI 11621750 at NHTSA ↗	25.3% ODI 11679469 2025 Bronco Do not drive your vehicle until your recall service is complete. Safety Recalls* Loose or missing upper ball joint fastener Recall incomplete Loose or missing upper ball joint fastener Recall incomplete Front upper control arm to knuckle ball joint loose or missing fastener Recall incomplete Inspect seat bolt presence and torque - recall is unable to be performed at this time. Please check the fsa landing page for more details. Recall incomplete Do not drive - front lower arm to frame attachment fastener inspection Recall … Look up ODI 11679469 at NHTSA ↗	571.4% ODI 11743715 2026 Bronco SportDescription Your vehicle may display a blank instrument panel cluster ipc screen upon startup. This may occur when the vehicle is restarted within a specific time interval after turning the vehicle off. Safety Risk A blank ipc screen will prevent the driver from seeing critical vehicle information such as the speedometer, warning lights, and warning messages. The inability to see this information increases the risk of a crash. Remedy Software is now available to repair your vehicle. Ford Motor Company has authorized your d… Look up ODI 11743715 at NHTSA ↗
Service Brakes	10114.6% ODI 11442253 · 600 mi The contact owns a 2021 Ford Bronco. The contact stated that an abnormal squealing noise would emit from the vehicle without warning. The contact had taken the vehicle to a dealer where they had kept the vehicle for over a week; she was later informed that the manufacturer was notified, and the noise had been deemed "acceptable. The dealer then notified her that the failure may be linked to moisture on the brakes and that the brakes may be replaced. Upon retrieving the vehicle, the contact was informed that no repairs were performed on the vehi… Look up ODI 11442253 at NHTSA ↗	4412.3% ODI 11462833 Engine makes intermittent metal crunching and scraping sounds at low speeds and when braking in stop an go traffic. And sometimes the sound would be heard the all the time when keeping the car between 25 to 30 mph. Look up ODI 11462833 at NHTSA ↗	85.1% ODI 11550311 The floor board is missing underneath the driver's side. I can see what looks like gears. Not quite sure. Difficulty with braking. Hard to stop. I hear flapping noises coming from rear of vehicle when driving. Not quite if it's the suspension Look up ODI 11550311 at NHTSA ↗	76.5% ODI 11626717 Upon attempting to start vehicle every warning indicator flashed in series across the screen and the SUV would not start nor was the vehicle lockable. Also, the rear door and access glass (where tools, safety equipment, and spare tire is located) could not be opened. The vehicle would not start and could not be placed in neutral to push the vehicle to a safe location. The manufacturer informed me a "failure to communicate" was indicated in their system. Had this occurred in an unsafe location such as on a highway or in a physically dangerous … Look up ODI 11626717 at NHTSA ↗	37.9% ODI 11679469 2025 Bronco Do not drive your vehicle until your recall service is complete. Safety Recalls* Loose or missing upper ball joint fastener Recall incomplete Loose or missing upper ball joint fastener Recall incomplete Front upper control arm to knuckle ball joint loose or missing fastener Recall incomplete Inspect seat bolt presence and torque - recall is unable to be performed at this time. Please check the fsa landing page for more details. Recall incomplete Do not drive - front lower arm to frame attachment fastener inspection Recall … Look up ODI 11679469 at NHTSA ↗	00.0% No examples available for this selection.
Fuel/Propulsion System	608.6% ODI 11443569 I have the same symptoms of recall 21V625000, they check my SUV however they said its not afected by the recall and the problem is still happening. Look up ODI 11443569 at NHTSA ↗	3810.6% ODI 11474812 The wrench icon which refers to the Powertrain system keeps coming on. I received a message from the Ford pass system that there was (Fault) in the Powertrain system. That power was reduced. Further it said to see a dealer right away. All of the Ford Dealers in my area are all booked up. Look up ODI 11474812 at NHTSA ↗	2817.8% ODI 11566060 Fuel pump loose in gas tank. Ocassional smell of fuel in cabin when starting vehicle. RPMs stick at high levels occassionally. Look up ODI 11566060 at NHTSA ↗	2119.4% ODI 11593802 On [XXX], my 2024 Ford Bronco Sport spontaneously burst into flames while driven by my [XXX] son. Per a local bystander, there was smoke and fire observed around the undercarriage as he drove down the road. Multiple vehicles began honking while stopped at a red light. A driver alerted my son of the fire. He was able to evacuate along with his [XXX] sister. As they were fleeing to the median of an active highway, the vehicle burst into flames. After several explosions the vehicle continued to burn and melt until the fire dept extinguished… Look up ODI 11593802 at NHTSA ↗	12.6% ODI 11733206 While driving my 2025 Ford Bronco Sport (approximately 14,600 miles), I made contact with an object on the roadway that did not feel like a severe impact. Immediately afterward, the vehicle began leaking fuel from the underside. The vehicle was not driveable due to the active fuel leak and had to be towed to a dealership for inspection. This situation posed a significant safety risk due to the presence of leaking fuel, which could increase the risk of fire or environmental hazard. There were no warning lights, messages, or prior symptoms bef… Look up ODI 11733206 at NHTSA ↗	00.0% No examples available for this selection.
Fuel System, Gasoline	557.9% ODI 11429610 The contact owns a 2021 Ford Bronco Sport. The contact received a recall notification for NHTSA Campaign Number: 21V625000 (Fuel System, Gasoline) however, the dealer informed the contact that the part for the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not notified of the issue. The contact had not experienced a failure. VIN tool confirms parts not available. Look up ODI 11429610 at NHTSA ↗	5014.0% ODI 11498684 · 549 mi The contact owns a 2022 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 22V859000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the vehicle hesitated while accelerating. Additionally, the engine made rattling sounds while driving. Additionally, the brakes failed to stop the vehicle immediately while the bra… Look up ODI 11498684 at NHTSA ↗	3019.1% ODI 11543907 · 6,000 mi The contact owns a 2023 Ford Bronco. The contact stated while driving approximately 55 MPH, an emissions warning light illuminated. The contact stated that he drove to a dealer who diagnosed that the gas vaporizer cannister had been punctured by road debris. The cannister was made out plastic with no protection from road debris. The contact stated that the cannister was located on the driver’s side of the vehicle approximately 40 inches from the fuel tank. The contact stated that the plastic cannister could be subject to failure from road debri… Look up ODI 11543907 at NHTSA ↗	1211.1% ODI 11678477 The contact owns a 2024 Ford Bronco Sport. The contact received a Carfax notification that the VIN was included in NHTSA Campaign Number: 25V467000(Fuel System, Gasoline); however, the part to do the repair was unavailable. The dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue, but was unable to provide an anticipated date for the parts' availability. The contact had not experienced a failure. Look up ODI 11678477 at NHTSA ↗	00.0% No examples available for this selection.	00.0% No examples available for this selection.
Suspension	223.2% ODI 11465051 The car is stalling on hills!then the car restarts and goes!my auto parking brake automatically comes on and you cannot get it to release! And I have notice the car wanting g to ride to the right of the rd ! Look up ODI 11465051 at NHTSA ↗	72.0% ODI 11576279 Shocks defective. Shocks to be replaced twice on this vehicle with under 50,000 miles. First replaced at about 20,000 miles. Dealership advised that original shocks and now new replacement shocks leak on inspection. Clearly a defective part. Ford knows about this problem. Ford has put out a “service message for technicians” but why isn’t there a recall? Second issue is brake issue. Ford has also issued a “service message for technicians” on this issue. They are aware of the issue and customers are waiting 3 months or more for a “bushing and ha… Look up ODI 11576279 at NHTSA ↗	42.5% ODI 11550311 The floor board is missing underneath the driver's side. I can see what looks like gears. Not quite sure. Difficulty with braking. Hard to stop. I hear flapping noises coming from rear of vehicle when driving. Not quite if it's the suspension Look up ODI 11550311 at NHTSA ↗	21.9% ODI 11676989 Chattering/screeching from right side of the car. Near tires. Took it in and showed example to technician and he heard it. Comes when turning right or backing up right slowly. They discovered it was the rear differential unit and it will be in the shop for 1-2 weeks. Look up ODI 11676989 at NHTSA ↗	37.9% ODI 11742303 Just seen notice that there is a recall notice about the engine and part of the front suspension, just wondering if it affects my vehicle. Look up ODI 11742303 at NHTSA ↗	00.0% No examples available for this selection.

Darker cells indicate a larger share of submitted complaints. Components overlap. This measures complaint composition, not failure probability.

Failure mileage by component

Median and middle 50% of usable owner-reported mileages. Ranges require at least five records.

Component failure mileage distribution
Component	Mileage range (25th–75th percentile)	Median	Usable records	Examples
Electrical System	23,500–51,500 mi	36,051 mi	94	ODI 11432247 · 5,000 mi On morning of Sept 2, 2021 I was driving home from my overnight shift as a nurse getting off about 0635, driving down a major street in the downtown area. I was approx 6 blocks from my hospital approaching a busy intersection and my Bronco Sport [2021] lost all power. Because my speed was only 30mph, it was easy to just come to a stop after a short roll Anytime the Bronco Sport shuts off it automatically goes into Park. So I had no power, not even flashers and could not put it into neutral to push it out of the intersection onto a side street… Look up ODI 11432247 at NHTSA ↗ ODI 11478925 · 37,000 mi The contact owns a 2021 Ford Bronco Sport. The contact stated that the vehicle failed to start. There was no warning light illuminated. The vehicle was not drivable. The vehicle was towed to the local dealer, where it was diagnosed that the front belt and two coolant hoses needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 37,000. Look up ODI 11478925 at NHTSA ↗ ODI 11492060 · 9,985 mi Vehicle completely shut down while driving. No working lights and unable to put vehicle in neutral. Was stuck in a lane of traffic with nothing working. Same issue happened less than 2 weeks ago, dealership had the vehicle for 7 days and said they found nothing wrong and couldn’t fix it. Tow truck driver told us it was the second Bronco he tower in 2 days with the same problem. Look up ODI 11492060 at NHTSA ↗
Engine	13,000–72,415 mi	36,594 mi	47	ODI 11448393 · 50,000 mi The contact owns a 2021 Ford Bronco Sport. The contact stated that the vehicle failed to start-up. The check engine warning light was illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 50,000. Look up ODI 11448393 at NHTSA ↗ ODI 11478195 · 4,000 mi I was driving in Atlanta in 4 lanes of heavy traffic. My new Bronco just started slowing down and I was almost killed by traffic swerving around me. The message said deactivated switch and fuel injector faulty. Then Bronco completely stopped and would not crank. 100 degree heat in bad part of town. Stranded and scared. After being towed, the deactivated switch replaced in Ford dealership in Georgia. No loaner given. After 2 weeks at my expense, I get car back. 2 months later it happens again. Now, it’s in dealership for third time for 2 more we… Look up ODI 11478195 at NHTSA ↗ ODI 11502129 · 3,000 mi this has happened twice to me. First time, I was driving around a roundabout - and the engine kicked off and there were a lot of alerts across the screen. I was safely able to coast off the road and onto the side where I sat for a little bit trying to restart it. After pushing the start button several times - it started back up and I was on my way. Most recently, last week - I was driving on the highway and the engine died and so many alerts were going across the screen. I couldn't pay much attention to the errors because a semi almost rammed m… Look up ODI 11502129 at NHTSA ↗
Power Train	20,500–80,316 mi	47,000 mi	58	ODI 11513866 · 4,500 mi On 3/25/23, I was driving down a 40m and then completely shut down. The entire engph road. I had been stopped at a stoplight and as soon as I started to drive again, the car started moving forwardine, all power (dashboard lights, display screen, everything). I panicked and went to go turn the caution lights on--they wouldn't work. As people behind me started honking, I tried to roll down my window to motion them on---the window wouldn't roll down. I had no choice but to open my car door, and stick my hand out to start waving people on behind me… Look up ODI 11513866 at NHTSA ↗ ODI 11521355 · 1,000 mi The contact owns a 2021 Ford Bronco Sport. The contact stated that the vehicle was jerking while shifting into gear, while making turns, and while coming to a complete stop. There was no warning light illuminated. Additionally, the contact stated that the vehicle rolled after shifting into park(P). The vehicle was taken to the dealer to be test-driven. The dealer informed the contact that no issues were found; however, the failure reoccurred. The contact stated that while the vehicle was at the dealer for a brake recall repair, the dealer infor… Look up ODI 11521355 at NHTSA ↗ ODI 11542788 · 30,000 mi The contact owns a 2021 Ford Bronco Sport. The contact stated while at a stop light, the vehicle shut off with several unknown warning lights illuminated. The message "Service Collision Assist" and "System Powering Down" were displayed. After the engine cooled down, the contact was able to restart the vehicle. The vehicle was taken to the dealer who was unable to find a cause for the failure. The contact stated that the failure had reoccurred. The vehicle was not repaired. On another occasion while driving 15 MPH and slowing down, the vehicle l… Look up ODI 11542788 at NHTSA ↗
Unknown Or Other	Too few reports for a range	16,716 mi	4 (sparse)	ODI 11441831 · 100 mi The car stalls out and stops accelerating while on the road, putting me in danger. At first, it displayed service and check engine lights, and the Ford Service Dept said it was a faulty transmission sensor. They replaced it, and now no service and check engine lights appear, but the car continues to have problems accelerating or changing gears. It is driving very loud as well and struggling to drive at high speeds. Consumer stated auto-shutoff at lights is also not working consistently and continues to stay shutoff even after letting go of the … Look up ODI 11441831 at NHTSA ↗ ODI 11549110 · 28,296 mi My 2021 Bronco failed our family on Friday. The Bronco failed to start upon pressing the start and brake pedal. The main console panel started flashing then cycling through all kinds of failure alerts. There was a series loud noises from the engine, the headlights flashed off and on for over 3 minutes and then the engine started smoking. The doors would not open and we were stuck inside while the engine was smoking. That smoke came through the air vents as well. Finally, I was able to get my door open though couldn’t open my son’s rear passenge… Look up ODI 11549110 at NHTSA ↗ ODI 11469676 · 5,135 mi The contact owns a 2022 Ford Bronco Sport. The contact stated while the vehicle was parked in a parking space on the park position, the vehicle unintendedly accelerated and reversed, striking her mother on the knee. The contact was able to get in the vehicle and depress the brake pedal. An appointment was scheduled for a diagnostic test. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 5,135. Look up ODI 11469676 at NHTSA ↗
Service Brakes	3,750–19,500 mi	7,982 mi	31	ODI 11442253 · 600 mi The contact owns a 2021 Ford Bronco. The contact stated that an abnormal squealing noise would emit from the vehicle without warning. The contact had taken the vehicle to a dealer where they had kept the vehicle for over a week; she was later informed that the manufacturer was notified, and the noise had been deemed "acceptable. The dealer then notified her that the failure may be linked to moisture on the brakes and that the brakes may be replaced. Upon retrieving the vehicle, the contact was informed that no repairs were performed on the vehi… Look up ODI 11442253 at NHTSA ↗ ODI 11447359 · 5,025 mi The contact owns a 2021 Ford Bronco Sport. The contact stated that while pulling into her driveway, the brake warning light illuminated and remained on after she had parked the vehicle. The contact stated that the brake warning light illuminated whenever she would start the vehicle. The contact became aware that the vehicle was included in NHTSA Campaign Number: 21V922000 (Service Brakes, Hydraulic) however, the dealer informed the contact that parts for the recall repair were not yet available. The contact stated that the manufacturer had exce… Look up ODI 11447359 at NHTSA ↗ ODI 11455899 · 5,000 mi The contact owns a 2021 Ford Bronco Sport. The contact stated that while his wife was driving, the brake hold system was causing resistance and the vehicle was grinding and shaking. The contact disengaged the brake hold assist. There were no warning lights illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA. The failure mileage was approximately 5,000. Look up ODI 11455899 at NHTSA ↗
Fuel/Propulsion System	Too few reports for a range	4,000 mi	1 (sparse)	ODI 11478195 · 4,000 mi I was driving in Atlanta in 4 lanes of heavy traffic. My new Bronco just started slowing down and I was almost killed by traffic swerving around me. The message said deactivated switch and fuel injector faulty. Then Bronco completely stopped and would not crank. 100 degree heat in bad part of town. Stranded and scared. After being towed, the deactivated switch replaced in Ford dealership in Georgia. No loaner given. After 2 weeks at my expense, I get car back. 2 months later it happens again. Now, it’s in dealership for third time for 2 more we… Look up ODI 11478195 at NHTSA ↗
Fuel System, Gasoline	21,550–64,315 mi	40,000 mi	55	ODI 11502250 · 30,000 mi The contact owned a 2021 Ford Bronco Sport. The contact stated that while driving at 55 MPH, the vehicle inadvertently drove off the roadway and caught fire. The fire started from the front of the vehicle. The air bags were deployed. The contact sustained a broken hip, injuries to her pelvis, left clavicle, and right rib, as well as a head injury causing a minor brain bleed. Medical attention was received. The fire department arrived on the scene and extinguished the fire. A police report was filed. The contact was unaware if a fire department … Look up ODI 11502250 at NHTSA ↗ ODI 11502416 · 25,000 mi The contact owns a 2021 Ford Bronco. The contact received notification of the NHTSA Campaign Number: 22V859000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The contact stated while driving at approximately 55 MPH, several unknown warning lights were intermittently illuminated and the Back Over Prevention screen turned white. The contact stated that the vehicle communication error message was displayed. The contact was able to navigate the vehicle off the road. The contact notified Ford’s AAA for towin… Look up ODI 11502416 at NHTSA ↗ ODI 11514767 · 3,500 mi The contact owns a 2021 Ford Bronco Sport. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power, stalled, and then failed to restart. The loss of power train message was displayed. The vehicle was towed to the local dealer where it was diagnosed that the battery and control module needed to be reprogrammed. The vehicle was repaired. The manufacturer was not contacted. Additionally, the contact received NHTSA Campaign Number: 22V859000 (Fuel System, Gasoline); however, the part to do the recall repair was … Look up ODI 11514767 at NHTSA ↗
Suspension	26,175–70,750 mi	47,500 mi	14	ODI 11533989 · 700 mi The contact owns a 2021 Ford Bronco Sport. The contact stated that while driving at various speeds, there was a loud clicking and rattling sound coming from the front driver's side wheel and both rear wheels. The vehicle was taken to the local dealer who was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 700. Look up ODI 11533989 at NHTSA ↗ ODI 11588733 · 43,000 mi The contact owns a 2021 Ford Bronco Sport. The contact stated while driving at approximately 20 MPH and turning slowly to the left, the contact heard an abnormal grinding sound from the driver's side rear wheel well. The contact stated that the failure also recurred while turning to the right. The contact checked under the driver’s side of the vehicle and noticed that the CV axle was loose where adjoined to the wheel. The contact stated that the passenger’s side rear CV axle was also loose. The contact stated no warning light was illuminated. T… Look up ODI 11588733 at NHTSA ↗ ODI 11596129 · 55,000 mi The contact owns a 2021 Ford Bronco Sport. The contact stated that while driving or while stopped, the rear differential seized, causing the rear wheels to lock up. The contact stated that the vehicle failed to move forward. The vehicle was taken to an independent mechanic and the rear differential fluid was replaced. There were no warning lights illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 55,000.… Look up ODI 11596129 at NHTSA ↗

Complaint and recall timeline

Explore monthly filing activity alongside recall announcements. Up to ten years of monthly history is available.

ComponentPeriod

Solid line: filed complaints. Dashed amber lines: recall announcement dates for this vehicle selection; markers include all recall components. The latest month is partial. Temporal proximity does not establish causation.

Monthly counts, recall campaigns and complaint examples

Monthly complaint and recall timeline
Month	Complaints	Campaigns announced	Examples
2024-10	26	None	ODI 11617452 · 100,000 mi The contact owns a 2021 Ford Bronco Sport. The contact stated that while driving 55 MPH, the engine started overheating. The vehicle was towed to a dealer where it was diagnosed that the water pump and the catalytic converter needed to be replaced. The vehicle was repaired; however, the failure persisted. The manufacturer was notified of the failure. The failure mileage was 100,000. Look up ODI 11617452 at NHTSA ↗ ODI 11618237 My transmission is slipping and the vehicle is sputtering at take off. There is a burning smell from the engine of my Bronco Sport. I have seen recall issues on other 2021 Ford Bronco Sports but my VIN is not included. It says that Ford issued for 2021-2024 Bronco Sport for transmission issues. Stating that the transmission park system may have been damaged during assembly. Dealer is saying I need new torque and valve body. Other Bronco Sport customers are also reporting the same issue on Bronco Forum. This vehicle is needed for transportation … Look up ODI 11618237 at NHTSA ↗ ODI 11619269 When turning at low speeds like a drive-thru or in a parking lot, the vehicle makes a skipping or grabbing sound and pulls/lurches slightly until the wheels are straightened. Recommended fix was replacing a front differential ventilation hose, which is not covered by bumper-to-bumper or powertrain warranty, and not a guarantee to fix the issue. Look up ODI 11619269 at NHTSA ↗
2024-11	27	None	ODI 11623595 · 2,000 mi The contact owns a 2021 Ford Bronco Sport. The contact stated that while reversing during morning startup and depressing the brake pedal, the vehicle made an abnormal loud moaning sound. The contact stated that the abnormal loud sound increased over time. There were no warning lights illuminated. The vehicle was taken to the local dealer several times, where the failure was acknowledged, but the vehicle was not diagnosed or repaired. The manufacturer was contacted, and a case was opened, but no additional assistance was provided. The failure mi… Look up ODI 11623595 at NHTSA ↗ ODI 11623905 My ford bronco stalled when I was slowing down at a traffic light. The entire car shutdown. The steering wheel locked up and the car could not be put into neutral. After about 15 minutes the car was able to turn on again. The stalling out at an intersection put me in danger by putting me in a situation where I was stuck in active traffic without the ability to move my car to a safe area off of the main road. There were no warning lights or messages prior to the car completely shutting off at the traffic light. Look up ODI 11623905 at NHTSA ↗ ODI 11624235 · 108,000 mi The contact owns a 2021 Ford Bronco Sport. The contact stated that after refueling and starting the vehicle, the front of the vehicle was shaking abnormally. The contact stated that while driving the vehicle the shaking ceased. The local dealer was contacted, and a service tech was sent to repair the vehicle under NHTSA Campaign Number: 24V267000 (ELECTRICAL SYSTEM, POWER TRAIN) however, the abnormal shaking returned. There were no warning lights illuminated. The contact stated that the abnormal shaking persisted, and the contact waited for the… Look up ODI 11624235 at NHTSA ↗
2024-12	28	None	ODI 11628421 [XXX]. about 3 months ago my wife started to smell what she referred to as raw gas odor in the cabin of car. took it to dealership, nothing found. then again complaint of odor in cabin. nothing found. then again smell in cabin. nothing found. I drove the car 40, mils. on errons. had a after oil smell like a oil breather was disconnected. dealership nothing found. wife it smells bad in cabin of car. my truck went in for service, I took the bronco to work, had to have the windows rolled down. on the way home it was real bad. called Ford Moter co… Look up ODI 11628421 at NHTSA ↗ ODI 11628666 · 45,500 mi The contact owns a 2021 Ford Bronco Sport. The contact stated that while her daughter was starting the vehicle, there was a loud sound before the vehicle lost power. The vehicle was taken to the dealer where it was diagnosed and determined that the battery needed to be replaced. The battery was replaced, and the vehicle was repaired. The manufacturer was notified of the failure but offered no assistance. The approximate failure mileage was 45,500. Look up ODI 11628666 at NHTSA ↗ ODI 11628918 · 36,000 mi The contact owns a 2021 Ford Bronco. The contact stated that while driving at 80 MPH, a warning message displayed reading "Service charging system soon", after which the infotainment system intermittently functioned properly. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the alternator harness. The vehicle was repaired. After investigating the failure, the contact related the failure to NHTSA campaign 24V267000 (Electrical System, Power Train); the VIN was included and the vehicle had alre… Look up ODI 11628918 at NHTSA ↗
2025-01	28	25V019000, 25V049000	ODI 11634480 Battery is healthy, but car wouldn’t start. Car was just inspected and passed with flying colors. The car has stalled three times while driving, and a fourth time, it wouldn’t start. It gave the red battery warning on the dashboard when it wouldn’t start. Waited a few minutes and tried a couple times and it finally started. Drove it home nearby and don’t plan on driving it until problem is eradicated. The battery works sometimes and then doesn’t other times. There’s no warning, just stalls out of nowhere every once in a while. Look up ODI 11634480 at NHTSA ↗ ODI 11634503 The battery that came with the vehicle lasted less than 2 years. It was replaced after one day the car just wouldn’t hold any charge. I have the pep boys receipt and record to prove the battery would no longer hold any charge. Look up ODI 11634503 at NHTSA ↗ ODI 11634786 Tranmission failed at 137k miles. Inspection revealed the tranmission was beyond repair and would have to be replaced. Last maintenance was tranmission fluid change at 95k miles by Ford dealer. Look up ODI 11634786 at NHTSA ↗
2025-02	33	None	ODI 11640318 · 21,626 mi The contact owns a 2021 Ford Bronco Sport. The contact stated that after a year of driving the vehicle, the battery was drained upon an attempt to start the vehicle. The contact was forced to jumpstart the battery to drive the vehicle. The contact took the vehicle to a dealer and paid out-of-pocket to replace the battery. The contact stated that almost two weeks later, the battery failure returned and the was taken back to the same dealer. The contact was provided a loaner vehicle while the dealer inspected the battery. The vehicle was returned… Look up ODI 11640318 at NHTSA ↗ ODI 11640423 · 122,000 mi The contact owns a 2021 Ford Bronco Sport. The contact stated while the vehicle was parked, the transmission failed to shift to park. The battery warning light was illuminated, and the "Charging System Service Now" message was displayed on the instrument panel. The contact researched and was made aware of NHTSA Campaign Number: 24V267000 (Electrical System, Power Train); however, the VIN was not included. The vehicle was taken to an independent mechanic to be diagnosed. The vehicle was not diagnosed or repaired. The manufacturer was not notifie… Look up ODI 11640423 at NHTSA ↗ ODI 11640480 · 28,660 mi The contact owns a 2021 Ford Bronco Sport. The contact stated that while driving at various speeds, the navigation screen intermittently went blank. The contact stated that a "System off to Save Battery Please turn ignition off or start engine," message was displayed on the navigation screen. The contact stated that over time, the instrument panel also went blank and other electrical features also failed to operate as needed. The vehicle was taken to several dealers and an independent mechanic to replace the battery; however, the failure return… Look up ODI 11640480 at NHTSA ↗
2025-03	43	25V158000, 25V165000	ODI 11646221 Vehicle would not start on two occasions, both times the vehicle was jumped and started. On the third occasion the car would not start, the electrical panel flashed all the warning lights and the dashboard continually flashed on and off. It was towed to the Ford Dealership in Oxford, MS in December 2024. The dealership looked over the car, no other issues and advised that this was likely a recall and recommended a battery replacement which I did. I paid $202.65 for the repairs and in February I received a notice for 12 Volt battery recall but n… Look up ODI 11646221 at NHTSA ↗ ODI 11646558 The contact owns a 2021 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V019000 (ELECTRICAL SYSTEM); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available. Look up ODI 11646558 at NHTSA ↗ ODI 11647200 The transmission/ powertrain failed on my ford bronco sport badlands 2021. Had a software update about 2 months ago from ford and the automatic shifting of the bronco sport badlands 2021 became rougher and rougher at low speeds, causing a jerking of the vehicle. When shifting from a stop the vehicle missed a shift and then continued to make whirring noises at all speeds. Upon returning home & to a stop, the vehicle can no longer engage in reverse. No warning lamps or messages were displayed by the vehicle. No event occurred such as an accident … Look up ODI 11647200 at NHTSA ↗
2025-04	47	None	ODI 11652163 When I bought my vehicle in 2021. The brakes makes a squeaky noise when backing up. I took to dealer and the mechanic said it was normal his wife have the same car and her Bronco does the same thing. The brakes still makes noise when backing up and it’s year 2025. I’m thinking about going to another brake pad but buying a new vehicle for it to squeak is not right. Look up ODI 11652163 at NHTSA ↗ ODI 11652379 I hit the start button on my car and it began to flicker lights and start over and over again then it started an electrical fire in the front of the vehicle. We had to quickly disconnect the battery to get it to stop trying to start. I took it to the dealer and they said it was a defective starter. If I didn’t have tools or if my car was in the garage I could have been asphyxiated or my house could have caught on fire. Look up ODI 11652379 at NHTSA ↗ ODI 11652508 · 49,000 mi The contact owns a 2021 Ford Bronco Sport. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power inadvertently. The contact was able to pull over to the shoulder of the roadway. The vehicle was able to restart and operated as needed. The contact stated that the failure had been recurring while driving. No warning light was illuminated. The vehicle was taken to the dealer, where the failure could not be duplicated. The vehicle was not diagnosed or repaired. The contact related the failure to NHTSA Campaign … Look up ODI 11652508 at NHTSA ↗
2025-05	38	25V343000	ODI 11658082 Husbands Ford Bronco sport has had a constant smell of exhaust that fills the interior of the vehicle since purchased. Dealer said there was a “recall and fixed the problem”. It only lasted 2 days until it began again. My husband gets lightheaded and dizzy while driving and has to stop and roll his windows down. He almost passed out while driving home with our children. Dealership says “this is a common problem and Ford doesn’t have enough parts at the moment to fix it and it will be around 2-3 months until they do.” Also, the car has suddenly … Look up ODI 11658082 at NHTSA ↗ ODI 11658236 I was driving 70mph on [XXX] in New Jersey when all of a sudden with no prior warning the battery light came on and my vehicle became very hard to control, I felt it shutting down so I immediately pulled to the only shoulder which happened to be on the left. The car shut down and would not start again. A State Trooper said I can not stay on the left shoulder and decided to push my car to the next exit. Since it was an electrical problem my car kept locking up and would not stay in neutral and the steering kept locking as well. I was being pushe… Look up ODI 11658236 at NHTSA ↗ ODI 11659035 · 40,000 mi The contact owns a 2021 Ford Bronco Sport. The contact stated while driving at an undisclosed speed, the vehicle independently turned off. The contact was unable to restart the vehicle. The vehicle was towed the dealer to have the battery replaced. The vehicle was repaired. The manufacturer was notified of the failure but offered no assistance. The contact related the failure to NHTSA Campaign Number: 25V019000 (ELECTRICAL SYSTEM); and the VIN was included in the recall. The contact was referred to the NHTSA Hotline for assistance. The failure … Look up ODI 11659035 at NHTSA ↗
2025-06	24	25V442000, 25V372000	ODI 11664269 · 73,000 mi The contact owns a 2021 Ford Bronco Sport. The contact stated that upon routine maintenance at the local dealer, it was noticed that the CV axle needed to be replaced. The vehicle was not repaired due to the cost. Upon further investigation, the contact related the failure to NHTSA Campaign Number: 21V074000 (Suspension) and Customer Satisfaction Program: 22B27; however, the VIN was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 73,000. Look up ODI 11664269 at NHTSA ↗ ODI 11664464 I experienced a full loss of battery power with my 2021 Ford Bronco Sport, which I later learned is related to an open recall (Ford Recall #25S02– related to 12V battery defect). Prior to receiving the recall notice, I paid out of pocket to replace the battery after the vehicle failed to start. I brought the issue to my local Ford dealer. At this point, they removed the battery I had just purchased and installed another without fully explaining the claim process or giving me written confirmation that the claim was filed. I escalated the issue… Look up ODI 11664464 at NHTSA ↗ ODI 11664809 · 5,000 mi The contact owns a 2021 Ford Bronco Sport. The contact stated that while operating the vehicle, the instrument panel malfunctioned, with the message "Pull Over and Restart the Engine" displayed. The battery was replaced, and failure was resolved. Additionally, the contact stated while driving at an undisclosed speed, the vehicle suddenly lost motive power and stalled. The vehicle was towed to the local dealer who diagnosed that the engine was faulty and needed to be replaced. The engine was replaced, and the vehicle was repaired. The contact st… Look up ODI 11664809 at NHTSA ↗
2025-07	32	25V467000	ODI 11670733 · 70,000 mi The contact owns a 2021 Ford Bronco Sport. The contact stated while driving at an undisclosed speed, the vehicle jerked abnormally. There was no warning light illuminated. The vehicle was taken to the dealer where it was diagnosed with a fractured and leaking CV boot. The contact was informed that the CV boot needed to be replaced. The vehicle was not repaired. In addition, the contact stated that the vehicle had been at the dealer several times due to the persistent failure. The manufacturer was made aware of the failure and a case was filed. … Look up ODI 11670733 at NHTSA ↗ ODI 11671650 My screen suddenly went black and now I have no back-up camera. My VIN is not associated with the recent camera recall, but it probably should be. This car has been reprogrammed several times for various different recalls (6). Look up ODI 11671650 at NHTSA ↗ ODI 11671668 · 70,000 mi The contact owns a 2021 Ford Bronco Sport. The contact stated that while her daughter was driving at an undisclosed speed, the vehicle inadvertently lost motive power and was unable to accelerate above 30 MPH. The failure persisted; however, the contact was able to drive to the intended destination. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with turbo charger. The contact was informed that the turbo charger needed to be replaced. The vehicle was not repaired. The manufacturer was notified o… Look up ODI 11671668 at NHTSA ↗
2025-08	38	None	ODI 11678289 · 77,000 mi The contact owns a 2021 Ford Bronco Sport. The contact stated that while driving and making right turns at undisclosed low speeds, there was an abnormal growling sound coming from the rear end of the vehicle. The vehicle was taken to the local dealer, where it was diagnosed that the rear drive unit had failed and needed to be replaced. The vehicle was repaired under an unknown Ford TSB. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 77,000. Look up ODI 11678289 at NHTSA ↗ ODI 11679032 Car suddenly and dangerously braked on highway with no other vehicles around. Afterwards the tool and check engine lights came on. All advance trac systems failed. Dealership replaced the broken bolts and rear axle. In review it appears recall 21s04 should apply. Site shows 2021 broncos from Hermosillo plant apply. Rep stated building date range 7/22-11/24. How can this apply to a 2021 ford recall? Look up ODI 11679032 at NHTSA ↗ ODI 11679790 · 75,000 mi The contact owns a 2021 Ford Bronco Sport. The contact stated that while driving at 60 MPH, several unknown warnings lights illuminated, and the vehicle stopped independently. The local dealer was contacted. The vehicle was towed to the dealer to be diagnosed and it was determined that the water pump needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but offered no assistance. The contact was transferred to the NHTSA Hotline to report the failure. The approximate failure mileage was 75,000. Look up ODI 11679790 at NHTSA ↗
2025-09	38	None	ODI 11684257 Car was put into drive and wouldn’t go. It would finally go but Everytime the engine changed gears it dropped to 0 rpm’s making it very dangerous to drive!!! Lots of lights came on and my app sent me two things wrong with it. After having it checked the codes said it was a valve body issue. Replacing the transmission is $4000, and I’m not the first with this problem a friend of mine had the same issue a couple weekend before me.Had two mechanics one of which was from the dealership tell me this was happening a lot! It’s very dangerous especiall… Look up ODI 11684257 at NHTSA ↗ ODI 11684571 I am reporting a serious and recurring issue with the catalytic converter on my 2021 Ford Bronco Sport (1.5L EcoBoost), which has resulted in reduced efficiency and partial blockage, causing exhaust gases to enter the cabin and triggering engine code P0171. My safety and the safety of others have been compromised because exhaust fumes, including carbon monoxide, have entered the cabin, which is particularly dangerous as I am currently pregnant. In addition, the engine experiences RPM fluctuations and revs up on its own, sometimes hesitating dur… Look up ODI 11684571 at NHTSA ↗ ODI 11684984 We brought the car to the dealership for oil change and recall fixes. After picking the vehicle up, the transmission failed the next day. The dealership nor Ford customer service have been any help and claim that they didn’t do anything that could have impacted the transmission. They are wanting us to pay $13k to replace the transmission Look up ODI 11684984 at NHTSA ↗
2025-10	36	25V685000	ODI 11690772 · 90,200 mi The contact owns a 2021 Ford Bronco Sport. The contact stated that on several occasions while attempting to start the vehicle, the vehicle failed to start-up with several unknown warning lights illuminated and flickering. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System); however, the part to do the recall repair was not yet available. The vehicle was towed to the dealer, where it was diagnosed and determined that the fuel injector and catalytic converter had failed and needed to be replaced. The dealer confirm… Look up ODI 11690772 at NHTSA ↗ ODI 11691082 RDU (Rear Drive Unit) is beginning to I think fail and I have read on other forums with other people saying there’s failed and can be a safety risk. They are put at risk if the RDU fails while driving resulting in an accident. I haven’t gone to the dealership yet or let anyone else know. I thought doing a simple fluid change would do but it still persist. I’ve done research to understand what’s wrong. There was no warning lights but shuddering or grinding noise would occur and I believe it appeared a few hundred miles ago then go worse overall.… Look up ODI 11691082 at NHTSA ↗ ODI 11692384 The contact owns a 2021 Ford Bronco Sport. The contact received a notification of NHTSA Campaign Number: 25V467000(Fuel System, Gasoline); however, the part to do the recall repair was not yet available. An unknown local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Look up ODI 11692384 at NHTSA ↗
2025-11	27	25V788000	ODI 11697990 In 2024, we had our battery replaced in our 2021 Bronco Sport by the Ford certified dealer in response to Recall Number 24S24. We did not have any issues with the previous battery. They replaced the original battery with the AGM battery, which they represented would prevent the issues that necessitated the recall - catastrophic degradation of the battery and complete loss of drive power. In mid-October 2025, my wife experienced unexpected and complete loss of drive power when exiting the interstate in the car, and was stuck in the freeway exit … Look up ODI 11697990 at NHTSA ↗ ODI 11698123 The contact owns a 2021 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000(Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Look up ODI 11698123 at NHTSA ↗ ODI 11698200 When I try to pump gas, I often will start the gas pump and then it will stop after only filling up about a third of a gallon. It doesn’t happen with every gas pump, but it happens frequently enough that it has become very frustrating. I end up not being able to put gas in my car at times and I have to drive to another gas station. I thought there had been a recall on this issue before and it had been resolved, but I have still been experiencing issues. Look up ODI 11698200 at NHTSA ↗
2025-12	17	None	ODI 11702490 · 69,398 mi The contact owns a 2021 Ford Bronco Sport. The contact stated that while driving at an undisclosed speed, the vehicle hesitated after fueling. There was no warning light illuminated. The contact became aware of a gasoline-like odor while entering and exiting the vehicle. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacture… Look up ODI 11702490 at NHTSA ↗ ODI 11703086 The car has been dying repeatedly and then decides to work again, got a new battery and new alternator and it still died. Ford techs had it and drove it for 200 miles and couldn’t replicate the issue. Now less than a month after that the car is completely dead and won’t even start with a jump. We are towing it to ford. Look up ODI 11703086 at NHTSA ↗ ODI 11703698 The contact owns a 2021 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Look up ODI 11703698 at NHTSA ↗
2026-01	24	None	ODI 11708392 · 91,000 mi The contact owns a 2021 Ford Bronco Sport. The contact stated that while driving approximately 45 MPH, there was a loud scraping sound coming from the engine compartment, and the vehicle jerked abnormally. The vehicle was taken to an independent mechanic, and the failure was associated with the torque converter. The manufacturer was notified of the failure. The failure mileage was 91,000. Look up ODI 11708392 at NHTSA ↗ ODI 11710599 Rear Belt Monitor Fault continues to be an issue. We received this warning light and supposedly had this repaired in October of 2024. The dealership replaced the rear seat belt buckle and reset the codes. This worked for a while but now is happening again. Additionally, we are receiving an airbag warning related to the rear belt monitor. When driving even short distances the warning light appears on screen maybe 5 or 6 times. If a seat belt is disconnected there is no audible warning alert or light to let the driver know that it is not in use… Look up ODI 11710599 at NHTSA ↗ ODI 11710638 · 39,000 mi The contact owns a 2021 Ford Bronco Sport. The contact stated that while driving at an undisclosed speed, there was a grinding sound coming from the engine compartment. There was no warning light illuminated. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, parts for the recall repair were not yet available. The vehicle was taken to a dealer, but was not diagnosed or repaired. The dealer confirmed that parts were not yet available. The manufacturer was not made aware of the failure. The con… Look up ODI 11710638 at NHTSA ↗
2026-02	24	None	ODI 11717430 This vehicle is subject to NHTSA Recall 25V467 involving potential fuel injector cracking and risk of fuel leaking onto the engine, creating a fire hazard. The recall status shows “Remedy Not Yet Available,” leaving the defect unresolved. While driving, the vehicle suddenly displayed an engine overheating warning and immediately entered limp mode, causing abrupt loss of power. The vehicle decelerated unexpectedly and was not able to maintain normal driving speed. This created a dangerous situation in active traffic and required a safety tow. T… Look up ODI 11717430 at NHTSA ↗ ODI 11718441 Recall 25S76 announced on 7/16/25 is still not completed. Ford states parts still not available. After 7 months, there seems to be no sense of urgency on Ford's part or their supplier's part. when will parts be available? Look up ODI 11718441 at NHTSA ↗ ODI 11720562 On 2/19/26 the Vehicle would not go in reverse. This is the second time the vehicle has failed to reverse. The vehicle was towed and fixed by don chalmers ford the first time this happened. Now they stated the vehicle was one day past warranty and would not tow/fix issue. I dropped the vehicle at dc ford on Friday 2/20. Today they called and said they think it is the same issue that was fixed with the transmission and would charge 6-8 thousand to fix it. More if we wanted a new transmission. I have read several reports from other consumers that… Look up ODI 11720562 at NHTSA ↗
2026-03	37	26V122000, 26V201000	ODI 11721545 The transmission failed to shift out of a forward gear when selected. Reverse was selected and the vehicle moved forward into a dangerous situation. It resisted stopping as the brakes were applied. There is no "key" to shut off. I was forced to vigorously apply the brakes to avoid a collision with a train. The car is undriveable. The dealer inspection and an independent inspection confirmed that the transmission was failing in a manner that they were both aware of. Replacement cost has proven to be prohibitive. Numerous warning lamps began to i… Look up ODI 11721545 at NHTSA ↗ ODI 11721766 dragging, grinding, or rubbing noises from the rear of a 2021 Bronco Sport during low-speed turns are a known issue commonly associated with a faulty rear drive unit (RDU), often appearing around 40k-60k miles. This problem, sometimes described as a, shutter or chattering, is often tied to contaminated fluid caused by a defective or improperly designed vent hose that allows debris to enter the system. Look up ODI 11721766 at NHTSA ↗ ODI 11723252 If my car can burn up because of this issue, why isn't a replacement part available? Is Ford going to wait till it burns? Seems to me if the problem is known you'd rather fix it than pay out lawsuits. Look up ODI 11723252 at NHTSA ↗
2026-04	35	26V239000	ODI 11729602 I purchased the 2021 Ford Bronco Sport in August of 2025. There were issues after about a week with all kinds of messages of components not working cycling through constantly on the display. The electric brake would engage on its own while parked and had to be shut off before I could go forwards after starting the vehicle. I took it to the dealership where I bought it and after a few days they said it was a batter issue and replaced it at no cost to me. It worked okay for a short time and then I had the same issues and now added to those were i… Look up ODI 11729602 at NHTSA ↗ ODI 11729950 · 52,000 mi The contact owns a 2021 Ford Bronco Sport. The contact stated that while driving on several occasions at various speeds, the infotainment screen went black or displayed a half-operating screen. An unknown warning light was illuminated with the message "Attention Needed - Service Engine Soon" displayed. The vehicle was taken to a dealer, and it was determined that Part Number: BE52 needed to be replaced. The vehicle was not repaired. The contact stated that while driving on several occasions at various speeds, the check engine warning light illu… Look up ODI 11729950 at NHTSA ↗ ODI 11730190 My 2021 ford bronco sport had a very dangerous issue on April 4th 2026. Nearly run over by a huge semi. Traveling at 70 miles per hour on I- 5 my vehicle had a sudden loss of power and wrench light went on, no prior signs. Semi traveling behind me nearly crashed into semi in the next lane as he slammed on his brakes and veered to the left to avoid running me over. Caused a big problem with the transmission .. Ford dealership now has car. Corning ford, Ca Unsafe to ever drive again with no remedy to fix this deadly problem. Recall 25s… Look up ODI 11730190 at NHTSA ↗
2026-05	30	26V340000	ODI 11735009 I have 130,000 miles on my 2021 Ford Bronco sport. With no warning I'm unable to put vehicle in gear. I attempt to put the car into drive, then reverse and it will not go. The gear gets stuck in park, but unable to park, The car instructs me to intiated emergency park with many warning lights appearing. when driving it jerks , make grinding noises, and I even lost momentum. Ford said the help line states they have attempted to fix the codes and replace the parts on the inside of the transmission and no luck. Ford recommends a new transmission… Look up ODI 11735009 at NHTSA ↗ ODI 11735177 In January of 2026, I took my 2021 Ford bronco sport Outer Banks to the dealership because my car had a wrench light come on and it went into limp mode. Supposedly it was fixed and now it is April 2026 and my car went into limp mode again, it would not shift in the park and would not start and now the dealership is telling me that there’s transmission issues but from what I’ve read, there is clearly been a lot of transmission issues in these vehicles. Look up ODI 11735177 at NHTSA ↗ ODI 11735594 1. While driving my 2021 Ford Bronco Sport, Big Bend, ⁠the automatic transmission (Ford 8F35 8-speed automatic) experienced internal mechanical failure. The vehicle lost the ability to engage reverse gear and the check engine light illuminated. Ford authorized dealer Koons Woodbridge Ford [XXX] ) confirmed the failure under Repair Order #38386 with the finding: "VERIFIED CONCERN. THE TRANSMISSION HAS INTERNAL DAMAGE." The vehicle has not been repaired and is currently at the dealership. 2. How was your safety or the safety of others put at ri… Look up ODI 11735594 at NHTSA ↗
2026-06	59	None	ODI 11741755 The contact owns a 2021 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V467000(Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Look up ODI 11741755 at NHTSA ↗ ODI 11742085 This recall has not been handled as of yet due to unavailable parts at it has almost been a year since it was issued on 7.16.2025. Look up ODI 11742085 at NHTSA ↗ ODI 11742123 I have a running recall from 7/25 that states the fuel injectors can leak and should be replaced by Ford. This is the second attempt to fix the issue on the bronco sport engine. Ford says parts not available now for almost 12 months now. Look up ODI 11742123 at NHTSA ↗
2026-07	41	None	ODI 11749362 · 67,830 mi The contact owns a 2021 Ford Bronco Sport. The contact stated that the check engine warning light illuminated. There was an abnormal odor of exhaust fumes inside the vehicle. Initially, the driver thought it emerged from other vehicles; however, a passenger smelled exhaust fumes, became sick, and vomited once the driver pulled over. The Ford mobile app failed to display any failure codes. The contact related the failure to NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline). The vehicle was taken to a local dealer, where diagnostic trouble… Look up ODI 11749362 at NHTSA ↗ ODI 11751319 I was in another town and my car kept stalling. I was going across traffic and it stalled and almost caused an accident. When I was in a parking lot my car would not go in reverse. I had to be pushed out of the parking space. I have already went to the have this recall fixed once. I know the part is not available but I should not have to keep going every few months to keep getting this done on a vehicle that I am paying on. It is not reliable and I could have caused an accident. Look up ODI 11751319 at NHTSA ↗ ODI 11752632 The contact owns a 2021 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Look up ODI 11752632 at NHTSA ↗
2026-08	38	26V548000, 26V550000	ODI 11754758 ENGINE SPUTTERING BETWEEN 1ST AND 2ND GEAR. RECALL IS STILL NOT RESOLVED REGARDING COMPUTER UPDATE AT THIS TIME AND DEALERSHIP SAID NO CODE NO REPAIR FOR OVER A YEAR. NOW I MUST REPLACE THE TRANSMISSION. FORD HAS KNOWN ABOUT THE ISSUE MANY TSB ISSUED FOR THE POWERTRAIN ISSUE. Look up ODI 11754758 at NHTSA ↗ ODI 11755597 My transmission is surging at low speeds all the way from takeoff to about 60mph. No engine or transmission codes. Look up ODI 11755597 at NHTSA ↗ ODI 11756436 RDU CLUTCH FAILURE Vehicle shutter at low speeds and during deceleration. Issue diagnosed after I had the vehicle inspected by ford dealership Ford TSB for this issue is 26-2328. I believe recall 21S02 should have been expanded to include more. My car was not manufactured during the dates listed for that recall. Ford parts have now switched manufacturers for the RDU CLUTCH which is now on back order. I suspect this issue may be related to the large amounts of PCM software issues ford has had with these vehicles and I believe this RDU fail… Look up ODI 11756436 at NHTSA ↗
2026-09 (partial)	44	None	ODI 11761819 The Oil pump wet belt, made of rubber, experienced the same premature tooth degradation as under the 1.0L EcoBoost engines that were recalled. Rubber components blocked my oil pump resulting in a failure to pump oil while I was driving. This required me to make an emergency stop on an interstate. I have reported this to Ford and they could care less about the safety concern. Look up ODI 11761819 at NHTSA ↗ ODI 11762057 What component or system failed or malfunctioned, and is it available for inspection upon request? The vehicle bucks and runs really rough. I believe it has to do with the open recall that has NOT yet been fixed. The fuel MPGs, xxx miles to empty, etc seems to all be affected. The dealer won't do anything about it. How was your safety or the safety of others put at risk? I'd say it's safe to drive, just not riding that great. Has the problem been reproduced or confirmed by a dealer or independent service center? They say and act like nothing… Look up ODI 11762057 at NHTSA ↗ ODI 11762110 Ford has not provided a repair for fuel injector recall in a reasonable amount of time Look up ODI 11762110 at NHTSA ↗

Emerging complaint spikes

Complete months in the latest six months with at least 10 complaints, at least twice the preceding 12-month average, and at least three square-root deviations above that average.

This is a descriptive screening rule, not a statistical defect finding. Publicity and reporting changes can increase submissions.

No complete months meet the spike thresholds for this selection.

Equal-age model-year comparison

Model-wide cumulative reports during the first three or five calendar years, starting with the model year (age 0). Only fully elapsed windows are compared.

Observation windowFirst model yearSecond model year

2022: 179 complaints · 2023: 118 complaints

Equal observation windows
Model year	Through age 0	Through age 1	Through age 2
2022	41	105	179
2023	25	64	118

Date coverage across each selected cohort

Date basis for all complaints in selected model years
Year	Incident dates used	Filing date fallbacks	Excluded dates
2022	357	0	1
2023	155	0	2

Incident date is preferred when valid and no later than filing; otherwise filing date is used. Model year approximates age. Equal observation time does not adjust for sales, distance driven or reporting delays. One complaint linked to multiple model years can appear in each cohort.

Components reported together

Each cell counts unique complaints naming both components. Open a nonzero cell for examples.

Component co-occurrence matrix
Component	Electrical System	Engine	Power Train	Unknown Or Other	Service Brakes	Fuel/Propulsion System	Fuel System, Gasoline	Suspension
Electrical System	—	99 ODI 11454100 I started my car on 2/15. Drove about .5 miles down the street through a fast food place. Drove another .9 miles down the street. I heard a pop and pulled over immediately and the car was already on fire. The car had around 3542 miles on it. I had just leased it in September. Ford says this was the only vehicle that this has happened too. The inspection is happening with the insurance company as well as Ford Motor Company. No prior issues and no warning signs on the car before the fire. Look up ODI 11454100 at NHTSA ↗ ODI 11481418 After I turned on the car, unbeknownst to me, the Ford Bronco stayed revved up and it did not slow down. I then switched from park to reverse and the Bronco went so fast (>4000rpm) that I ended up hitting the tree so hard that the tree was uprooted. The car was not driveable and it had to be towed. This is under progressive insurance claim: 22-3913700. The insurance company would not check the "inside" of the car (etc...transmission, electrical, etc...) as they say this is prior to the accident. I have called the Ford dealership for assistance … Look up ODI 11481418 at NHTSA ↗ ODI 11502648 Catastrophic engine failure on major highway . The warning message was " Your engine is shutting down " Look up ODI 11502648 at NHTSA ↗	75 ODI 11513866 · 4,500 mi On 3/25/23, I was driving down a 40m and then completely shut down. The entire engph road. I had been stopped at a stoplight and as soon as I started to drive again, the car started moving forwardine, all power (dashboard lights, display screen, everything). I panicked and went to go turn the caution lights on--they wouldn't work. As people behind me started honking, I tried to roll down my window to motion them on---the window wouldn't roll down. I had no choice but to open my car door, and stick my hand out to start waving people on behind me… Look up ODI 11513866 at NHTSA ↗ ODI 11528100 After coming down an incline in my garage at work I stopped at a red light, took my foot off of the brake to let the brake assist kick in and my auto idle kicked off as well. Within seconds my car shut off and the instrument panel started flickering. I got SEVERAL error messages flashing by quickly including the "Park Brake Malfunction Service Now" error. I tried to turn the car back on and kept hearing a clicking sound followed by all of the lights flashing again. I couldn't shift to any other gear and was stuck at this intersection unable … Look up ODI 11528100 at NHTSA ↗ ODI 11538977 I currently am at 14,000 miles on my2021 Bronco Sport. I have had no issues prior to what happened to me on August 9th. While I was at a light my car went completely black with no warning and I was not able to put on hazard lights or put it in neutral to get off the busy highway. I had to call 911 as cars were zipping up close to mine and I was only able to wave my arms to get them to see my car was unoccupied. I was screamed at, honked at all while frantic trying to explain to the 911 operator that I needed a deputy to come and put his lig… Look up ODI 11538977 at NHTSA ↗	38 ODI 11481418 After I turned on the car, unbeknownst to me, the Ford Bronco stayed revved up and it did not slow down. I then switched from park to reverse and the Bronco went so fast (>4000rpm) that I ended up hitting the tree so hard that the tree was uprooted. The car was not driveable and it had to be towed. This is under progressive insurance claim: 22-3913700. The insurance company would not check the "inside" of the car (etc...transmission, electrical, etc...) as they say this is prior to the accident. I have called the Ford dealership for assistance … Look up ODI 11481418 at NHTSA ↗ ODI 11497354 Driving the vehicle between on a highway and, repeatedly, the control panel would completely shut down with the warning that the battery was running low on power. It doesn’t make sense since the vehicle is less than two years old. Look up ODI 11497354 at NHTSA ↗ ODI 11504039 Charging System The vehicle safety systems and monitoring systems shut down due to battery charging system failures. Problem confirmed by Ford engineers. And Ford service where the vehicle is still sitting. Vehicle has been at dealership 90% since 8/2022. They and Ford engineers do not know what’s wrong or why it will not keep a charge. Battery replaced, alternator and more but it still is unsafe to drive. Have too many warnings to count. And we have taken it to dealer for repair but nothing fixes it. And even the Ford engineers do not underst… Look up ODI 11504039 at NHTSA ↗	23 ODI 11449342 Both interior liftgate lights inoperative. However, the "liftgate ajar light", and came on without warning as I was driving. I had not opened the litigate. Radio system skips & pops. fails to load tor loads slowly. Brakes failed to fully engage quickly on a slow turn, causing a total loss accident. Vehicle has 645 miles on it. I love my Bronco Sport. But..is it safe to drive if I order a new one? Can there be a cross check done by VIN to ensure I'm not getting one with the same problem? Specifically, the brakes? The brake issue worries me P… Look up ODI 11449342 at NHTSA ↗ ODI 11534697 On Monday 7-24-2023 5:00pm rush hour in Downtown Gainesville Fl at a red light in the left lane about to turn left my car completely shutoff with no warning. It was if someone disconnected the battery completely from the car. No lights, No screen, No ignition. The traffic light turned green and I immediately pressed my foot on the brake and tried to start the engine. I noticed there were not lights, no sounds and no reaction from the engine. Windows would not go down either. I tried too put the hazards on to signal people and they had no power… Look up ODI 11534697 at NHTSA ↗ ODI 11569394 Touch screen and dash blackout while driving. They just go completely dark. Someone’s it restarts and comes back on but if it’s dark outside I can’t see how fast I’m going. Look up ODI 11569394 at NHTSA ↗	27 ODI 11454100 I started my car on 2/15. Drove about .5 miles down the street through a fast food place. Drove another .9 miles down the street. I heard a pop and pulled over immediately and the car was already on fire. The car had around 3542 miles on it. I had just leased it in September. Ford says this was the only vehicle that this has happened too. The inspection is happening with the insurance company as well as Ford Motor Company. No prior issues and no warning signs on the car before the fire. Look up ODI 11454100 at NHTSA ↗ ODI 11502648 Catastrophic engine failure on major highway . The warning message was " Your engine is shutting down " Look up ODI 11502648 at NHTSA ↗ ODI 11547993 Bought 2021 bronco sport in Dec 21. Since my engine has stuttered and started to die. The panel starts falling as if it is sitting off. This is not the auto engine shut off while idling at a light issue. Upon starting the engine you can hear a ticking and on every certain revelation the vehicle will sputter and start to cut off. It has died on 2 occasions in my driveway, but not yet on the road. It will stutter and start to die almost always in idle, especially in park, but it will do it and stay losing power mainly while driving low speeds o… Look up ODI 11547993 at NHTSA ↗	6 ODI 11624235 · 108,000 mi The contact owns a 2021 Ford Bronco Sport. The contact stated that after refueling and starting the vehicle, the front of the vehicle was shaking abnormally. The contact stated that while driving the vehicle the shaking ceased. The local dealer was contacted, and a service tech was sent to repair the vehicle under NHTSA Campaign Number: 24V267000 (ELECTRICAL SYSTEM, POWER TRAIN) however, the abnormal shaking returned. There were no warning lights illuminated. The contact stated that the abnormal shaking persisted, and the contact waited for the… Look up ODI 11624235 at NHTSA ↗ ODI 11631771 The contact owns a 2021 Ford Bronco Sport. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed, however, the vehicle failed to accelerate as intended. Additionally, the contact stated that the vehicle sputtered. The dealer was made aware of the failure. The vehicle was scheduled for a service appointment to have the recall repairs performed. The contact stated that when the vehicle was taken to the dealer, the contact was informed that the appointment needed to be rescheduled due to dealer scheduling. T… Look up ODI 11631771 at NHTSA ↗ ODI 11685749 · 17,000 mi The contact owns a 2021 Ford Bronco Sport. The contact stated that the rear seat belt monitor fault service required message was displayed. The button had to be depressed and reset. The contact received NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline). The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was not notified of the issue. The failure mileage was approximately 17,000. Look up ODI 11685749 at NHTSA ↗	0
Engine	99 ODI 11454100 I started my car on 2/15. Drove about .5 miles down the street through a fast food place. Drove another .9 miles down the street. I heard a pop and pulled over immediately and the car was already on fire. The car had around 3542 miles on it. I had just leased it in September. Ford says this was the only vehicle that this has happened too. The inspection is happening with the insurance company as well as Ford Motor Company. No prior issues and no warning signs on the car before the fire. Look up ODI 11454100 at NHTSA ↗ ODI 11481418 After I turned on the car, unbeknownst to me, the Ford Bronco stayed revved up and it did not slow down. I then switched from park to reverse and the Bronco went so fast (>4000rpm) that I ended up hitting the tree so hard that the tree was uprooted. The car was not driveable and it had to be towed. This is under progressive insurance claim: 22-3913700. The insurance company would not check the "inside" of the car (etc...transmission, electrical, etc...) as they say this is prior to the accident. I have called the Ford dealership for assistance … Look up ODI 11481418 at NHTSA ↗ ODI 11502648 Catastrophic engine failure on major highway . The warning message was " Your engine is shutting down " Look up ODI 11502648 at NHTSA ↗	—	66 ODI 11473806 problems with the engine loses power and a message appears on the screen of the bus that says "transmission system failure" from the 1st day I bought it and the ford does not solve my problem. Look up ODI 11473806 at NHTSA ↗ ODI 11538977 I currently am at 14,000 miles on my2021 Bronco Sport. I have had no issues prior to what happened to me on August 9th. While I was at a light my car went completely black with no warning and I was not able to put on hazard lights or put it in neutral to get off the busy highway. I had to call 911 as cars were zipping up close to mine and I was only able to wave my arms to get them to see my car was unoccupied. I was screamed at, honked at all while frantic trying to explain to the 911 operator that I needed a deputy to come and put his lig… Look up ODI 11538977 at NHTSA ↗ ODI 11541061 Transmission locked in park while attempting to move off of a traffic light. Brakes locked up, unable to start car. Was stuck in the middle lane on a busy street. Look up ODI 11541061 at NHTSA ↗	30 ODI 11481418 After I turned on the car, unbeknownst to me, the Ford Bronco stayed revved up and it did not slow down. I then switched from park to reverse and the Bronco went so fast (>4000rpm) that I ended up hitting the tree so hard that the tree was uprooted. The car was not driveable and it had to be towed. This is under progressive insurance claim: 22-3913700. The insurance company would not check the "inside" of the car (etc...transmission, electrical, etc...) as they say this is prior to the accident. I have called the Ford dealership for assistance … Look up ODI 11481418 at NHTSA ↗ ODI 11544366 When trying to start the vehicle, it would not crank. Instead, all dash indicator lights, interior lights, and exterior lights began flashing. Numerous random error messages began flashing on the dashboard screen. Then a large plume of smoke began coming out from under the hood and there was an acrid burning smell. No flames were visible so the fire department would not respond when called and advised to have it towed. After much difficulty loading onto a tow truck (the parking brake would not disengage--dash indicated a parking brake fault as… Look up ODI 11544366 at NHTSA ↗ ODI 11549110 · 28,296 mi My 2021 Bronco failed our family on Friday. The Bronco failed to start upon pressing the start and brake pedal. The main console panel started flashing then cycling through all kinds of failure alerts. There was a series loud noises from the engine, the headlights flashed off and on for over 3 minutes and then the engine started smoking. The doors would not open and we were stuck inside while the engine was smoking. That smoke came through the air vents as well. Finally, I was able to get my door open though couldn’t open my son’s rear passenge… Look up ODI 11549110 at NHTSA ↗	19 ODI 11481549 Traveling with cruise control set at 78mph. Service engine light came on without warning and vehicle couldn’t maintain speed. Exited highway to determine what was wrong. Pulled into gas station parking lot and the power brakes failed. The vehicle had two recalls for brakes serviced on 7/7/22. The vehicle is being towed to a dealership as the vehicle had less than 12,400 miles and has been owned less than one year. Any/all components available for inspection. If driver had not had wherewithal to exit highway when they did, there certainly could … Look up ODI 11481549 at NHTSA ↗ ODI 11502129 · 3,000 mi this has happened twice to me. First time, I was driving around a roundabout - and the engine kicked off and there were a lot of alerts across the screen. I was safely able to coast off the road and onto the side where I sat for a little bit trying to restart it. After pushing the start button several times - it started back up and I was on my way. Most recently, last week - I was driving on the highway and the engine died and so many alerts were going across the screen. I couldn't pay much attention to the errors because a semi almost rammed m… Look up ODI 11502129 at NHTSA ↗ ODI 11503000 I HAD RECALL DONE A FEW MONTHS BACK REGARDING MY BREAKS. BREAKS ALWAYS SOUND HORRIBLE WHEN MY VEHICLE IS COLD. WHEN THE RECALL WAS DONE THEY SOUND EVEN WORST. FORD PARTS ARE THE WORST. IM EMBARRASSED EVERY TIME I LEAVE MY DRIVEWAY. DUE TO THE LOUD NOISE. I TOOK MY CAR TO MARINA FORD ON OCTOBER 2022 BECAUSE THE ENGINE SOUNDS HORRIBLE. IT SHAKES. I FEEL LIKE I WILL GET STRANDED. THE DEALER TECH TOLD ME THEY DID NOT HAVE ANYTHING AVAILABLE UNTIL JANUARY 2, 2023. ONCE JANUARY CAME THEY TOLD ME THEY DID NOT PROVIDE RENTAL CARS. IM SCARED TO DRIVE MY… Look up ODI 11503000 at NHTSA ↗	69 ODI 11454100 I started my car on 2/15. Drove about .5 miles down the street through a fast food place. Drove another .9 miles down the street. I heard a pop and pulled over immediately and the car was already on fire. The car had around 3542 miles on it. I had just leased it in September. Ford says this was the only vehicle that this has happened too. The inspection is happening with the insurance company as well as Ford Motor Company. No prior issues and no warning signs on the car before the fire. Look up ODI 11454100 at NHTSA ↗ ODI 11478195 · 4,000 mi I was driving in Atlanta in 4 lanes of heavy traffic. My new Bronco just started slowing down and I was almost killed by traffic swerving around me. The message said deactivated switch and fuel injector faulty. Then Bronco completely stopped and would not crank. 100 degree heat in bad part of town. Stranded and scared. After being towed, the deactivated switch replaced in Ford dealership in Georgia. No loaner given. After 2 weeks at my expense, I get car back. 2 months later it happens again. Now, it’s in dealership for third time for 2 more we… Look up ODI 11478195 at NHTSA ↗ ODI 11502648 Catastrophic engine failure on major highway . The warning message was " Your engine is shutting down " Look up ODI 11502648 at NHTSA ↗	10 ODI 11690772 · 90,200 mi The contact owns a 2021 Ford Bronco Sport. The contact stated that on several occasions while attempting to start the vehicle, the vehicle failed to start-up with several unknown warning lights illuminated and flickering. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System); however, the part to do the recall repair was not yet available. The vehicle was towed to the dealer, where it was diagnosed and determined that the fuel injector and catalytic converter had failed and needed to be replaced. The dealer confirm… Look up ODI 11690772 at NHTSA ↗ ODI 11693691 · 83,000 mi The contact owned a 2021 Ford Bronco. The contact stated that while driving at an undisclosed speed, the contact noticed smoke coming from the front of the vehicle. After pulling to the side of the road, the contact noticed that the engine compartment had caught fire. The fire was extinguished by the Fire Department. A fire report was filed, but a fire report number was not provided. The cause of the fire had not yet been determined. A police report was not filed. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel Syst… Look up ODI 11693691 at NHTSA ↗ ODI 11710954 · 77,000 mi The contact owns a 2021 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated that while operating the vehicle, the check engine warning light remained illuminated, and there was an abnormal sound coming from the vehicle while driving. The contact was unabl… Look up ODI 11710954 at NHTSA ↗	6 ODI 11465051 The car is stalling on hills!then the car restarts and goes!my auto parking brake automatically comes on and you cannot get it to release! And I have notice the car wanting g to ride to the right of the rd ! Look up ODI 11465051 at NHTSA ↗ ODI 11580169 It shakes, rattles and sound like a ship yard while backing up Look up ODI 11580169 at NHTSA ↗ ODI 11617096 Currently at 30,000 miles. Water pump goes out every 10k miles, rear differential went out, front control arm and strut went out. Look up ODI 11617096 at NHTSA ↗
Power Train	75 ODI 11513866 · 4,500 mi On 3/25/23, I was driving down a 40m and then completely shut down. The entire engph road. I had been stopped at a stoplight and as soon as I started to drive again, the car started moving forwardine, all power (dashboard lights, display screen, everything). I panicked and went to go turn the caution lights on--they wouldn't work. As people behind me started honking, I tried to roll down my window to motion them on---the window wouldn't roll down. I had no choice but to open my car door, and stick my hand out to start waving people on behind me… Look up ODI 11513866 at NHTSA ↗ ODI 11528100 After coming down an incline in my garage at work I stopped at a red light, took my foot off of the brake to let the brake assist kick in and my auto idle kicked off as well. Within seconds my car shut off and the instrument panel started flickering. I got SEVERAL error messages flashing by quickly including the "Park Brake Malfunction Service Now" error. I tried to turn the car back on and kept hearing a clicking sound followed by all of the lights flashing again. I couldn't shift to any other gear and was stuck at this intersection unable … Look up ODI 11528100 at NHTSA ↗ ODI 11538977 I currently am at 14,000 miles on my2021 Bronco Sport. I have had no issues prior to what happened to me on August 9th. While I was at a light my car went completely black with no warning and I was not able to put on hazard lights or put it in neutral to get off the busy highway. I had to call 911 as cars were zipping up close to mine and I was only able to wave my arms to get them to see my car was unoccupied. I was screamed at, honked at all while frantic trying to explain to the 911 operator that I needed a deputy to come and put his lig… Look up ODI 11538977 at NHTSA ↗	66 ODI 11473806 problems with the engine loses power and a message appears on the screen of the bus that says "transmission system failure" from the 1st day I bought it and the ford does not solve my problem. Look up ODI 11473806 at NHTSA ↗ ODI 11538977 I currently am at 14,000 miles on my2021 Bronco Sport. I have had no issues prior to what happened to me on August 9th. While I was at a light my car went completely black with no warning and I was not able to put on hazard lights or put it in neutral to get off the busy highway. I had to call 911 as cars were zipping up close to mine and I was only able to wave my arms to get them to see my car was unoccupied. I was screamed at, honked at all while frantic trying to explain to the 911 operator that I needed a deputy to come and put his lig… Look up ODI 11538977 at NHTSA ↗ ODI 11541061 Transmission locked in park while attempting to move off of a traffic light. Brakes locked up, unable to start car. Was stuck in the middle lane on a busy street. Look up ODI 11541061 at NHTSA ↗	—	19 ODI 11537691 Beginning at approximately 25,000 miles the vehicle started exhibiting stuttering at low speeds (<10 mph) while turning. this happened in both forward and reverse and turning either direction. I originally reported it as possible CV joint issue. Dealer informed me it was a known issue and drained and replaced the RDU fluid. Issue went away but resurfaced around the 50,000 mile mark. same results that the issue went away. Issue came once again at ~ 75,000 miles at which point I was informed that it was no longer covered by warranty. I paid to ha… Look up ODI 11537691 at NHTSA ↗ ODI 11548015 When reversing there is the absolute worst extremely loud embarrassing metallic screeching sound, considerable to a ships horn. Once you press brake fully and come to a complete stop the sounds ceases, let go of the brake it come right back. You can put it in drive and then back to reversing, same thing. Dealership was informed in 2022, said they fixed it. Spring/Summer of 2023 after complaining again was told part was ordered, could not be told what part. September 2023 was told no part was ordered, issue was fixed. October 2023 had a m… Look up ODI 11548015 at NHTSA ↗ ODI 11559397 Car stopped while driving. Couldn’t get the car into neutral to move it out of the road. Would not crank. Leaking oil. Look up ODI 11559397 at NHTSA ↗	13 ODI 11541061 Transmission locked in park while attempting to move off of a traffic light. Brakes locked up, unable to start car. Was stuck in the middle lane on a busy street. Look up ODI 11541061 at NHTSA ↗ ODI 11548015 When reversing there is the absolute worst extremely loud embarrassing metallic screeching sound, considerable to a ships horn. Once you press brake fully and come to a complete stop the sounds ceases, let go of the brake it come right back. You can put it in drive and then back to reversing, same thing. Dealership was informed in 2022, said they fixed it. Spring/Summer of 2023 after complaining again was told part was ordered, could not be told what part. September 2023 was told no part was ordered, issue was fixed. October 2023 had a m… Look up ODI 11548015 at NHTSA ↗ ODI 11568977 · 1,000 mi The contact owns a 2021 Ford Bronco Sport. The contact stated that while reversing, there was a loud squealing sound coming from the vehicle. The vehicle was taken to the local dealer who inspected the braking system but was unable to determine the cause of the failure, or where the sound was coming from. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 1,000. Look up ODI 11568977 at NHTSA ↗	23 ODI 11596698 Vehicle experienced power terrain failure causing vehicle to stop while driving in the middle of the road meanwhile cars avoid hitting my vehicle. I had my [XXX] old in the backseat at the time and this incident could have caused injury or possibly death. Vehicle has also experienced accelerator issues. Vehicle would lag 3-5 seconds for vehicle accelerator to speed up when pressing on accelerator. Fortunately no major accidents, but I am concerned that the issues I have experienced thus far with the Bronco 2021, it can potentially cause a majo… Look up ODI 11596698 at NHTSA ↗ ODI 11631525 The car caught fire the morning of Dec 11, 2024 while the vehicle's owner was driving their children to school. There are photos and a fire report is being generated. The vehicle's owner and her children could have been killed. Early indications are that the fire was caused by the same faulty engine/exhaust system defect that the owner has been complaining to Ford about for years. It is assumed the fire report will confirm that. For the past two or more years the vehicle has been emitting exhaust fumes into the passenger compartment of the vehi… Look up ODI 11631525 at NHTSA ↗ ODI 11636144 The car has now on three separate occasions lost power while driving. As I slow down coming to stop or reducing speed car will completely lose power and then struggle to restart. Both occasions were on busy roads. Additionally, when you put fuel in the car it does not turn on right away it smells like fuel is burning and fumes enter into the cabin. When you push start after fueling it struggles to turn car on to drive. There is full accessory power but no power to drive the car even when giving it gas. It requires multiple attempts at starting … Look up ODI 11636144 at NHTSA ↗	7 ODI 11521355 · 1,000 mi The contact owns a 2021 Ford Bronco Sport. The contact stated that the vehicle was jerking while shifting into gear, while making turns, and while coming to a complete stop. There was no warning light illuminated. Additionally, the contact stated that the vehicle rolled after shifting into park(P). The vehicle was taken to the dealer to be test-driven. The dealer informed the contact that no issues were found; however, the failure reoccurred. The contact stated that while the vehicle was at the dealer for a brake recall repair, the dealer infor… Look up ODI 11521355 at NHTSA ↗ ODI 11624235 · 108,000 mi The contact owns a 2021 Ford Bronco Sport. The contact stated that after refueling and starting the vehicle, the front of the vehicle was shaking abnormally. The contact stated that while driving the vehicle the shaking ceased. The local dealer was contacted, and a service tech was sent to repair the vehicle under NHTSA Campaign Number: 24V267000 (ELECTRICAL SYSTEM, POWER TRAIN) however, the abnormal shaking returned. There were no warning lights illuminated. The contact stated that the abnormal shaking persisted, and the contact waited for the… Look up ODI 11624235 at NHTSA ↗ ODI 11631771 The contact owns a 2021 Ford Bronco Sport. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed, however, the vehicle failed to accelerate as intended. Additionally, the contact stated that the vehicle sputtered. The dealer was made aware of the failure. The vehicle was scheduled for a service appointment to have the recall repairs performed. The contact stated that when the vehicle was taken to the dealer, the contact was informed that the appointment needed to be rescheduled due to dealer scheduling. T… Look up ODI 11631771 at NHTSA ↗	6 ODI 11588733 · 43,000 mi The contact owns a 2021 Ford Bronco Sport. The contact stated while driving at approximately 20 MPH and turning slowly to the left, the contact heard an abnormal grinding sound from the driver's side rear wheel well. The contact stated that the failure also recurred while turning to the right. The contact checked under the driver’s side of the vehicle and noticed that the CV axle was loose where adjoined to the wheel. The contact stated that the passenger’s side rear CV axle was also loose. The contact stated no warning light was illuminated. T… Look up ODI 11588733 at NHTSA ↗ ODI 11617096 Currently at 30,000 miles. Water pump goes out every 10k miles, rear differential went out, front control arm and strut went out. Look up ODI 11617096 at NHTSA ↗ ODI 11625978 REAR DIFFERENTIAL- CAR IS SHUDDERING WHILE TURNING- SAFETY ISSUE Look up ODI 11625978 at NHTSA ↗
Unknown Or Other	38 ODI 11481418 After I turned on the car, unbeknownst to me, the Ford Bronco stayed revved up and it did not slow down. I then switched from park to reverse and the Bronco went so fast (>4000rpm) that I ended up hitting the tree so hard that the tree was uprooted. The car was not driveable and it had to be towed. This is under progressive insurance claim: 22-3913700. The insurance company would not check the "inside" of the car (etc...transmission, electrical, etc...) as they say this is prior to the accident. I have called the Ford dealership for assistance … Look up ODI 11481418 at NHTSA ↗ ODI 11497354 Driving the vehicle between on a highway and, repeatedly, the control panel would completely shut down with the warning that the battery was running low on power. It doesn’t make sense since the vehicle is less than two years old. Look up ODI 11497354 at NHTSA ↗ ODI 11504039 Charging System The vehicle safety systems and monitoring systems shut down due to battery charging system failures. Problem confirmed by Ford engineers. And Ford service where the vehicle is still sitting. Vehicle has been at dealership 90% since 8/2022. They and Ford engineers do not know what’s wrong or why it will not keep a charge. Battery replaced, alternator and more but it still is unsafe to drive. Have too many warnings to count. And we have taken it to dealer for repair but nothing fixes it. And even the Ford engineers do not underst… Look up ODI 11504039 at NHTSA ↗	30 ODI 11481418 After I turned on the car, unbeknownst to me, the Ford Bronco stayed revved up and it did not slow down. I then switched from park to reverse and the Bronco went so fast (>4000rpm) that I ended up hitting the tree so hard that the tree was uprooted. The car was not driveable and it had to be towed. This is under progressive insurance claim: 22-3913700. The insurance company would not check the "inside" of the car (etc...transmission, electrical, etc...) as they say this is prior to the accident. I have called the Ford dealership for assistance … Look up ODI 11481418 at NHTSA ↗ ODI 11544366 When trying to start the vehicle, it would not crank. Instead, all dash indicator lights, interior lights, and exterior lights began flashing. Numerous random error messages began flashing on the dashboard screen. Then a large plume of smoke began coming out from under the hood and there was an acrid burning smell. No flames were visible so the fire department would not respond when called and advised to have it towed. After much difficulty loading onto a tow truck (the parking brake would not disengage--dash indicated a parking brake fault as… Look up ODI 11544366 at NHTSA ↗ ODI 11549110 · 28,296 mi My 2021 Bronco failed our family on Friday. The Bronco failed to start upon pressing the start and brake pedal. The main console panel started flashing then cycling through all kinds of failure alerts. There was a series loud noises from the engine, the headlights flashed off and on for over 3 minutes and then the engine started smoking. The doors would not open and we were stuck inside while the engine was smoking. That smoke came through the air vents as well. Finally, I was able to get my door open though couldn’t open my son’s rear passenge… Look up ODI 11549110 at NHTSA ↗	19 ODI 11537691 Beginning at approximately 25,000 miles the vehicle started exhibiting stuttering at low speeds (<10 mph) while turning. this happened in both forward and reverse and turning either direction. I originally reported it as possible CV joint issue. Dealer informed me it was a known issue and drained and replaced the RDU fluid. Issue went away but resurfaced around the 50,000 mile mark. same results that the issue went away. Issue came once again at ~ 75,000 miles at which point I was informed that it was no longer covered by warranty. I paid to ha… Look up ODI 11537691 at NHTSA ↗ ODI 11548015 When reversing there is the absolute worst extremely loud embarrassing metallic screeching sound, considerable to a ships horn. Once you press brake fully and come to a complete stop the sounds ceases, let go of the brake it come right back. You can put it in drive and then back to reversing, same thing. Dealership was informed in 2022, said they fixed it. Spring/Summer of 2023 after complaining again was told part was ordered, could not be told what part. September 2023 was told no part was ordered, issue was fixed. October 2023 had a m… Look up ODI 11548015 at NHTSA ↗ ODI 11559397 Car stopped while driving. Couldn’t get the car into neutral to move it out of the road. Would not crank. Leaking oil. Look up ODI 11559397 at NHTSA ↗	—	17 ODI 11448962 Unknown. When backing up there is a howling sound while applying the brakes. The cause maybe the brake linings or rotors. Look up ODI 11448962 at NHTSA ↗ ODI 11455071 EVERY morning when reversing out of my driveway my brakes make a very loud noise. It's been going on for several months and is only getting worse. I've taken it up to the dealership and they cannot find the problem. Look up ODI 11455071 at NHTSA ↗ ODI 11488227 MAKES A LOUD MOANING SOUND WHEN REVERSING AFTER VEHICLE HAS SAT FOR A FEW HOURS. BRAKE PADS ARE FINE, DOES NOT HAPPEN WHEN BRAKING WHILE GOING FORWARD. ONLY BRAKING WHILE GOING IN REVERSE. Look up ODI 11488227 at NHTSA ↗	15 ODI 11507913 The vehicle was acting weird and not providing power in the way that I would expect it when accelerating. If the vehicle cannot accelerate, I am at risk because I may be merging into traffic and a car could hit me. I tried calling the dealer but they don't have a solution to the problem yet. It is a safety recall but they don't have a way to fix it. There's also a lawsuit that I'm not related to but about this same issue. So I'm concerned this is going to take a long time to be solved. The screen inside the car malfunctioned and turned off b… Look up ODI 11507913 at NHTSA ↗ ODI 11601231 I took my vehicle in to have the flash system updated to pass the emissions test for Louisiana. Ford charged me over $200 for a failure on that system from purchase, and no dealership would get back to me until I took my vehicle across town to have the system reset. Hollingsworth Ford told me that this wouldn't be covered under their system because I took this in out of warranty, but this is a problem since vehicle purchase. Look up ODI 11601231 at NHTSA ↗ ODI 11641486 The recall that is currently out my car is experiencing some issues they stated but there’s no remedy for it at the time!! And I went to the dealership to have older recalls checked they won’t do it for the front suspension or fuel injectors Look up ODI 11641486 at NHTSA ↗	0	5 ODI 11488227 MAKES A LOUD MOANING SOUND WHEN REVERSING AFTER VEHICLE HAS SAT FOR A FEW HOURS. BRAKE PADS ARE FINE, DOES NOT HAPPEN WHEN BRAKING WHILE GOING FORWARD. ONLY BRAKING WHILE GOING IN REVERSE. Look up ODI 11488227 at NHTSA ↗ ODI 11641486 The recall that is currently out my car is experiencing some issues they stated but there’s no remedy for it at the time!! And I went to the dealership to have older recalls checked they won’t do it for the front suspension or fuel injectors Look up ODI 11641486 at NHTSA ↗ ODI 11679032 Car suddenly and dangerously braked on highway with no other vehicles around. Afterwards the tool and check engine lights came on. All advance trac systems failed. Dealership replaced the broken bolts and rear axle. In review it appears recall 21s04 should apply. Site shows 2021 broncos from Hermosillo plant apply. Rep stated building date range 7/22-11/24. How can this apply to a 2021 ford recall? Look up ODI 11679032 at NHTSA ↗
Service Brakes	23 ODI 11449342 Both interior liftgate lights inoperative. However, the "liftgate ajar light", and came on without warning as I was driving. I had not opened the litigate. Radio system skips & pops. fails to load tor loads slowly. Brakes failed to fully engage quickly on a slow turn, causing a total loss accident. Vehicle has 645 miles on it. I love my Bronco Sport. But..is it safe to drive if I order a new one? Can there be a cross check done by VIN to ensure I'm not getting one with the same problem? Specifically, the brakes? The brake issue worries me P… Look up ODI 11449342 at NHTSA ↗ ODI 11534697 On Monday 7-24-2023 5:00pm rush hour in Downtown Gainesville Fl at a red light in the left lane about to turn left my car completely shutoff with no warning. It was if someone disconnected the battery completely from the car. No lights, No screen, No ignition. The traffic light turned green and I immediately pressed my foot on the brake and tried to start the engine. I noticed there were not lights, no sounds and no reaction from the engine. Windows would not go down either. I tried too put the hazards on to signal people and they had no power… Look up ODI 11534697 at NHTSA ↗ ODI 11569394 Touch screen and dash blackout while driving. They just go completely dark. Someone’s it restarts and comes back on but if it’s dark outside I can’t see how fast I’m going. Look up ODI 11569394 at NHTSA ↗	19 ODI 11481549 Traveling with cruise control set at 78mph. Service engine light came on without warning and vehicle couldn’t maintain speed. Exited highway to determine what was wrong. Pulled into gas station parking lot and the power brakes failed. The vehicle had two recalls for brakes serviced on 7/7/22. The vehicle is being towed to a dealership as the vehicle had less than 12,400 miles and has been owned less than one year. Any/all components available for inspection. If driver had not had wherewithal to exit highway when they did, there certainly could … Look up ODI 11481549 at NHTSA ↗ ODI 11502129 · 3,000 mi this has happened twice to me. First time, I was driving around a roundabout - and the engine kicked off and there were a lot of alerts across the screen. I was safely able to coast off the road and onto the side where I sat for a little bit trying to restart it. After pushing the start button several times - it started back up and I was on my way. Most recently, last week - I was driving on the highway and the engine died and so many alerts were going across the screen. I couldn't pay much attention to the errors because a semi almost rammed m… Look up ODI 11502129 at NHTSA ↗ ODI 11503000 I HAD RECALL DONE A FEW MONTHS BACK REGARDING MY BREAKS. BREAKS ALWAYS SOUND HORRIBLE WHEN MY VEHICLE IS COLD. WHEN THE RECALL WAS DONE THEY SOUND EVEN WORST. FORD PARTS ARE THE WORST. IM EMBARRASSED EVERY TIME I LEAVE MY DRIVEWAY. DUE TO THE LOUD NOISE. I TOOK MY CAR TO MARINA FORD ON OCTOBER 2022 BECAUSE THE ENGINE SOUNDS HORRIBLE. IT SHAKES. I FEEL LIKE I WILL GET STRANDED. THE DEALER TECH TOLD ME THEY DID NOT HAVE ANYTHING AVAILABLE UNTIL JANUARY 2, 2023. ONCE JANUARY CAME THEY TOLD ME THEY DID NOT PROVIDE RENTAL CARS. IM SCARED TO DRIVE MY… Look up ODI 11503000 at NHTSA ↗	13 ODI 11541061 Transmission locked in park while attempting to move off of a traffic light. Brakes locked up, unable to start car. Was stuck in the middle lane on a busy street. Look up ODI 11541061 at NHTSA ↗ ODI 11548015 When reversing there is the absolute worst extremely loud embarrassing metallic screeching sound, considerable to a ships horn. Once you press brake fully and come to a complete stop the sounds ceases, let go of the brake it come right back. You can put it in drive and then back to reversing, same thing. Dealership was informed in 2022, said they fixed it. Spring/Summer of 2023 after complaining again was told part was ordered, could not be told what part. September 2023 was told no part was ordered, issue was fixed. October 2023 had a m… Look up ODI 11548015 at NHTSA ↗ ODI 11568977 · 1,000 mi The contact owns a 2021 Ford Bronco Sport. The contact stated that while reversing, there was a loud squealing sound coming from the vehicle. The vehicle was taken to the local dealer who inspected the braking system but was unable to determine the cause of the failure, or where the sound was coming from. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 1,000. Look up ODI 11568977 at NHTSA ↗	17 ODI 11448962 Unknown. When backing up there is a howling sound while applying the brakes. The cause maybe the brake linings or rotors. Look up ODI 11448962 at NHTSA ↗ ODI 11455071 EVERY morning when reversing out of my driveway my brakes make a very loud noise. It's been going on for several months and is only getting worse. I've taken it up to the dealership and they cannot find the problem. Look up ODI 11455071 at NHTSA ↗ ODI 11488227 MAKES A LOUD MOANING SOUND WHEN REVERSING AFTER VEHICLE HAS SAT FOR A FEW HOURS. BRAKE PADS ARE FINE, DOES NOT HAPPEN WHEN BRAKING WHILE GOING FORWARD. ONLY BRAKING WHILE GOING IN REVERSE. Look up ODI 11488227 at NHTSA ↗	—	2 ODI 11503000 I HAD RECALL DONE A FEW MONTHS BACK REGARDING MY BREAKS. BREAKS ALWAYS SOUND HORRIBLE WHEN MY VEHICLE IS COLD. WHEN THE RECALL WAS DONE THEY SOUND EVEN WORST. FORD PARTS ARE THE WORST. IM EMBARRASSED EVERY TIME I LEAVE MY DRIVEWAY. DUE TO THE LOUD NOISE. I TOOK MY CAR TO MARINA FORD ON OCTOBER 2022 BECAUSE THE ENGINE SOUNDS HORRIBLE. IT SHAKES. I FEEL LIKE I WILL GET STRANDED. THE DEALER TECH TOLD ME THEY DID NOT HAVE ANYTHING AVAILABLE UNTIL JANUARY 2, 2023. ONCE JANUARY CAME THEY TOLD ME THEY DID NOT PROVIDE RENTAL CARS. IM SCARED TO DRIVE MY… Look up ODI 11503000 at NHTSA ↗ ODI 11648129 I was unaware of any previous recalls before I purchased my Bronco Sport used. There is an active recall that has no remedy for the battery. I am actively having issues with my fuel system. It was inspected more than once. Diagnostics returned zero issues 3 times and no warning lights. I insisted further inspection this time which revealed bad purge valve, charcoal canister full of fuel, coolant leak resulting in water pump replacement needed. No warning lights. No codes, active or stored. Due to the absence of codes, they will not replace my f… Look up ODI 11648129 at NHTSA ↗	1 ODI 11502250 · 30,000 mi The contact owned a 2021 Ford Bronco Sport. The contact stated that while driving at 55 MPH, the vehicle inadvertently drove off the roadway and caught fire. The fire started from the front of the vehicle. The air bags were deployed. The contact sustained a broken hip, injuries to her pelvis, left clavicle, and right rib, as well as a head injury causing a minor brain bleed. Medical attention was received. The fire department arrived on the scene and extinguished the fire. A police report was filed. The contact was unaware if a fire department … Look up ODI 11502250 at NHTSA ↗	4 ODI 11488227 MAKES A LOUD MOANING SOUND WHEN REVERSING AFTER VEHICLE HAS SAT FOR A FEW HOURS. BRAKE PADS ARE FINE, DOES NOT HAPPEN WHEN BRAKING WHILE GOING FORWARD. ONLY BRAKING WHILE GOING IN REVERSE. Look up ODI 11488227 at NHTSA ↗ ODI 11576279 Shocks defective. Shocks to be replaced twice on this vehicle with under 50,000 miles. First replaced at about 20,000 miles. Dealership advised that original shocks and now new replacement shocks leak on inspection. Clearly a defective part. Ford knows about this problem. Ford has put out a “service message for technicians” but why isn’t there a recall? Second issue is brake issue. Ford has also issued a “service message for technicians” on this issue. They are aware of the issue and customers are waiting 3 months or more for a “bushing and ha… Look up ODI 11576279 at NHTSA ↗ ODI 11550311 The floor board is missing underneath the driver's side. I can see what looks like gears. Not quite sure. Difficulty with braking. Hard to stop. I hear flapping noises coming from rear of vehicle when driving. Not quite if it's the suspension Look up ODI 11550311 at NHTSA ↗
Fuel/Propulsion System	27 ODI 11454100 I started my car on 2/15. Drove about .5 miles down the street through a fast food place. Drove another .9 miles down the street. I heard a pop and pulled over immediately and the car was already on fire. The car had around 3542 miles on it. I had just leased it in September. Ford says this was the only vehicle that this has happened too. The inspection is happening with the insurance company as well as Ford Motor Company. No prior issues and no warning signs on the car before the fire. Look up ODI 11454100 at NHTSA ↗ ODI 11502648 Catastrophic engine failure on major highway . The warning message was " Your engine is shutting down " Look up ODI 11502648 at NHTSA ↗ ODI 11547993 Bought 2021 bronco sport in Dec 21. Since my engine has stuttered and started to die. The panel starts falling as if it is sitting off. This is not the auto engine shut off while idling at a light issue. Upon starting the engine you can hear a ticking and on every certain revelation the vehicle will sputter and start to cut off. It has died on 2 occasions in my driveway, but not yet on the road. It will stutter and start to die almost always in idle, especially in park, but it will do it and stay losing power mainly while driving low speeds o… Look up ODI 11547993 at NHTSA ↗	69 ODI 11454100 I started my car on 2/15. Drove about .5 miles down the street through a fast food place. Drove another .9 miles down the street. I heard a pop and pulled over immediately and the car was already on fire. The car had around 3542 miles on it. I had just leased it in September. Ford says this was the only vehicle that this has happened too. The inspection is happening with the insurance company as well as Ford Motor Company. No prior issues and no warning signs on the car before the fire. Look up ODI 11454100 at NHTSA ↗ ODI 11478195 · 4,000 mi I was driving in Atlanta in 4 lanes of heavy traffic. My new Bronco just started slowing down and I was almost killed by traffic swerving around me. The message said deactivated switch and fuel injector faulty. Then Bronco completely stopped and would not crank. 100 degree heat in bad part of town. Stranded and scared. After being towed, the deactivated switch replaced in Ford dealership in Georgia. No loaner given. After 2 weeks at my expense, I get car back. 2 months later it happens again. Now, it’s in dealership for third time for 2 more we… Look up ODI 11478195 at NHTSA ↗ ODI 11502648 Catastrophic engine failure on major highway . The warning message was " Your engine is shutting down " Look up ODI 11502648 at NHTSA ↗	23 ODI 11596698 Vehicle experienced power terrain failure causing vehicle to stop while driving in the middle of the road meanwhile cars avoid hitting my vehicle. I had my [XXX] old in the backseat at the time and this incident could have caused injury or possibly death. Vehicle has also experienced accelerator issues. Vehicle would lag 3-5 seconds for vehicle accelerator to speed up when pressing on accelerator. Fortunately no major accidents, but I am concerned that the issues I have experienced thus far with the Bronco 2021, it can potentially cause a majo… Look up ODI 11596698 at NHTSA ↗ ODI 11631525 The car caught fire the morning of Dec 11, 2024 while the vehicle's owner was driving their children to school. There are photos and a fire report is being generated. The vehicle's owner and her children could have been killed. Early indications are that the fire was caused by the same faulty engine/exhaust system defect that the owner has been complaining to Ford about for years. It is assumed the fire report will confirm that. For the past two or more years the vehicle has been emitting exhaust fumes into the passenger compartment of the vehi… Look up ODI 11631525 at NHTSA ↗ ODI 11636144 The car has now on three separate occasions lost power while driving. As I slow down coming to stop or reducing speed car will completely lose power and then struggle to restart. Both occasions were on busy roads. Additionally, when you put fuel in the car it does not turn on right away it smells like fuel is burning and fumes enter into the cabin. When you push start after fueling it struggles to turn car on to drive. There is full accessory power but no power to drive the car even when giving it gas. It requires multiple attempts at starting … Look up ODI 11636144 at NHTSA ↗	15 ODI 11507913 The vehicle was acting weird and not providing power in the way that I would expect it when accelerating. If the vehicle cannot accelerate, I am at risk because I may be merging into traffic and a car could hit me. I tried calling the dealer but they don't have a solution to the problem yet. It is a safety recall but they don't have a way to fix it. There's also a lawsuit that I'm not related to but about this same issue. So I'm concerned this is going to take a long time to be solved. The screen inside the car malfunctioned and turned off b… Look up ODI 11507913 at NHTSA ↗ ODI 11601231 I took my vehicle in to have the flash system updated to pass the emissions test for Louisiana. Ford charged me over $200 for a failure on that system from purchase, and no dealership would get back to me until I took my vehicle across town to have the system reset. Hollingsworth Ford told me that this wouldn't be covered under their system because I took this in out of warranty, but this is a problem since vehicle purchase. Look up ODI 11601231 at NHTSA ↗ ODI 11641486 The recall that is currently out my car is experiencing some issues they stated but there’s no remedy for it at the time!! And I went to the dealership to have older recalls checked they won’t do it for the front suspension or fuel injectors Look up ODI 11641486 at NHTSA ↗	2 ODI 11503000 I HAD RECALL DONE A FEW MONTHS BACK REGARDING MY BREAKS. BREAKS ALWAYS SOUND HORRIBLE WHEN MY VEHICLE IS COLD. WHEN THE RECALL WAS DONE THEY SOUND EVEN WORST. FORD PARTS ARE THE WORST. IM EMBARRASSED EVERY TIME I LEAVE MY DRIVEWAY. DUE TO THE LOUD NOISE. I TOOK MY CAR TO MARINA FORD ON OCTOBER 2022 BECAUSE THE ENGINE SOUNDS HORRIBLE. IT SHAKES. I FEEL LIKE I WILL GET STRANDED. THE DEALER TECH TOLD ME THEY DID NOT HAVE ANYTHING AVAILABLE UNTIL JANUARY 2, 2023. ONCE JANUARY CAME THEY TOLD ME THEY DID NOT PROVIDE RENTAL CARS. IM SCARED TO DRIVE MY… Look up ODI 11503000 at NHTSA ↗ ODI 11648129 I was unaware of any previous recalls before I purchased my Bronco Sport used. There is an active recall that has no remedy for the battery. I am actively having issues with my fuel system. It was inspected more than once. Diagnostics returned zero issues 3 times and no warning lights. I insisted further inspection this time which revealed bad purge valve, charcoal canister full of fuel, coolant leak resulting in water pump replacement needed. No warning lights. No codes, active or stored. Due to the absence of codes, they will not replace my f… Look up ODI 11648129 at NHTSA ↗	—	0	4 ODI 11580169 It shakes, rattles and sound like a ship yard while backing up Look up ODI 11580169 at NHTSA ↗ ODI 11641486 The recall that is currently out my car is experiencing some issues they stated but there’s no remedy for it at the time!! And I went to the dealership to have older recalls checked they won’t do it for the front suspension or fuel injectors Look up ODI 11641486 at NHTSA ↗ ODI 11724824 Fuel system 1. I don't know what failed because the dealership didn't do anything to repair it. It is available for inspection upon request 2. Intensely strong fuel odor at the front of the car, inside and out. Strong exhaust odor at the back of the car. It is not safe to operate a car if it smells like fuel. 3. Dealership had it for 3 weeks and said there is nothing wrong. Now they are ignoring me. I am taking it to an independent mechanic. 4. Ford said they inspected it but they didn;t because there's all kinds of issues with this c… Look up ODI 11724824 at NHTSA ↗
Fuel System, Gasoline	6 ODI 11624235 · 108,000 mi The contact owns a 2021 Ford Bronco Sport. The contact stated that after refueling and starting the vehicle, the front of the vehicle was shaking abnormally. The contact stated that while driving the vehicle the shaking ceased. The local dealer was contacted, and a service tech was sent to repair the vehicle under NHTSA Campaign Number: 24V267000 (ELECTRICAL SYSTEM, POWER TRAIN) however, the abnormal shaking returned. There were no warning lights illuminated. The contact stated that the abnormal shaking persisted, and the contact waited for the… Look up ODI 11624235 at NHTSA ↗ ODI 11631771 The contact owns a 2021 Ford Bronco Sport. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed, however, the vehicle failed to accelerate as intended. Additionally, the contact stated that the vehicle sputtered. The dealer was made aware of the failure. The vehicle was scheduled for a service appointment to have the recall repairs performed. The contact stated that when the vehicle was taken to the dealer, the contact was informed that the appointment needed to be rescheduled due to dealer scheduling. T… Look up ODI 11631771 at NHTSA ↗ ODI 11685749 · 17,000 mi The contact owns a 2021 Ford Bronco Sport. The contact stated that the rear seat belt monitor fault service required message was displayed. The button had to be depressed and reset. The contact received NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline). The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was not notified of the issue. The failure mileage was approximately 17,000. Look up ODI 11685749 at NHTSA ↗	10 ODI 11690772 · 90,200 mi The contact owns a 2021 Ford Bronco Sport. The contact stated that on several occasions while attempting to start the vehicle, the vehicle failed to start-up with several unknown warning lights illuminated and flickering. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System); however, the part to do the recall repair was not yet available. The vehicle was towed to the dealer, where it was diagnosed and determined that the fuel injector and catalytic converter had failed and needed to be replaced. The dealer confirm… Look up ODI 11690772 at NHTSA ↗ ODI 11693691 · 83,000 mi The contact owned a 2021 Ford Bronco. The contact stated that while driving at an undisclosed speed, the contact noticed smoke coming from the front of the vehicle. After pulling to the side of the road, the contact noticed that the engine compartment had caught fire. The fire was extinguished by the Fire Department. A fire report was filed, but a fire report number was not provided. The cause of the fire had not yet been determined. A police report was not filed. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel Syst… Look up ODI 11693691 at NHTSA ↗ ODI 11710954 · 77,000 mi The contact owns a 2021 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated that while operating the vehicle, the check engine warning light remained illuminated, and there was an abnormal sound coming from the vehicle while driving. The contact was unabl… Look up ODI 11710954 at NHTSA ↗	7 ODI 11521355 · 1,000 mi The contact owns a 2021 Ford Bronco Sport. The contact stated that the vehicle was jerking while shifting into gear, while making turns, and while coming to a complete stop. There was no warning light illuminated. Additionally, the contact stated that the vehicle rolled after shifting into park(P). The vehicle was taken to the dealer to be test-driven. The dealer informed the contact that no issues were found; however, the failure reoccurred. The contact stated that while the vehicle was at the dealer for a brake recall repair, the dealer infor… Look up ODI 11521355 at NHTSA ↗ ODI 11624235 · 108,000 mi The contact owns a 2021 Ford Bronco Sport. The contact stated that after refueling and starting the vehicle, the front of the vehicle was shaking abnormally. The contact stated that while driving the vehicle the shaking ceased. The local dealer was contacted, and a service tech was sent to repair the vehicle under NHTSA Campaign Number: 24V267000 (ELECTRICAL SYSTEM, POWER TRAIN) however, the abnormal shaking returned. There were no warning lights illuminated. The contact stated that the abnormal shaking persisted, and the contact waited for the… Look up ODI 11624235 at NHTSA ↗ ODI 11631771 The contact owns a 2021 Ford Bronco Sport. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed, however, the vehicle failed to accelerate as intended. Additionally, the contact stated that the vehicle sputtered. The dealer was made aware of the failure. The vehicle was scheduled for a service appointment to have the recall repairs performed. The contact stated that when the vehicle was taken to the dealer, the contact was informed that the appointment needed to be rescheduled due to dealer scheduling. T… Look up ODI 11631771 at NHTSA ↗	0	1 ODI 11502250 · 30,000 mi The contact owned a 2021 Ford Bronco Sport. The contact stated that while driving at 55 MPH, the vehicle inadvertently drove off the roadway and caught fire. The fire started from the front of the vehicle. The air bags were deployed. The contact sustained a broken hip, injuries to her pelvis, left clavicle, and right rib, as well as a head injury causing a minor brain bleed. Medical attention was received. The fire department arrived on the scene and extinguished the fire. A police report was filed. The contact was unaware if a fire department … Look up ODI 11502250 at NHTSA ↗	0	—	1 ODI 11764351 · 124,000 mi The contact owns a 2021 Ford Bronco Sport. The contact stated that while operating the vehicle, exhaust fumes and a fuel odor entered the cabin, and the check engine warning light illuminated. The engine misfired, and the vehicle hesitated while driving. Upon inspecting under the hood, the contact discovered black soot in the engine compartment. The vehicle was taken to a local dealer for diagnosis, where the dealer determined that the piston solenoid, catalytic converter, and driver’s side lower control arm and bushing needed replacement. The … Look up ODI 11764351 at NHTSA ↗
Suspension	0	6 ODI 11465051 The car is stalling on hills!then the car restarts and goes!my auto parking brake automatically comes on and you cannot get it to release! And I have notice the car wanting g to ride to the right of the rd ! Look up ODI 11465051 at NHTSA ↗ ODI 11580169 It shakes, rattles and sound like a ship yard while backing up Look up ODI 11580169 at NHTSA ↗ ODI 11617096 Currently at 30,000 miles. Water pump goes out every 10k miles, rear differential went out, front control arm and strut went out. Look up ODI 11617096 at NHTSA ↗	6 ODI 11588733 · 43,000 mi The contact owns a 2021 Ford Bronco Sport. The contact stated while driving at approximately 20 MPH and turning slowly to the left, the contact heard an abnormal grinding sound from the driver's side rear wheel well. The contact stated that the failure also recurred while turning to the right. The contact checked under the driver’s side of the vehicle and noticed that the CV axle was loose where adjoined to the wheel. The contact stated that the passenger’s side rear CV axle was also loose. The contact stated no warning light was illuminated. T… Look up ODI 11588733 at NHTSA ↗ ODI 11617096 Currently at 30,000 miles. Water pump goes out every 10k miles, rear differential went out, front control arm and strut went out. Look up ODI 11617096 at NHTSA ↗ ODI 11625978 REAR DIFFERENTIAL- CAR IS SHUDDERING WHILE TURNING- SAFETY ISSUE Look up ODI 11625978 at NHTSA ↗	5 ODI 11488227 MAKES A LOUD MOANING SOUND WHEN REVERSING AFTER VEHICLE HAS SAT FOR A FEW HOURS. BRAKE PADS ARE FINE, DOES NOT HAPPEN WHEN BRAKING WHILE GOING FORWARD. ONLY BRAKING WHILE GOING IN REVERSE. Look up ODI 11488227 at NHTSA ↗ ODI 11641486 The recall that is currently out my car is experiencing some issues they stated but there’s no remedy for it at the time!! And I went to the dealership to have older recalls checked they won’t do it for the front suspension or fuel injectors Look up ODI 11641486 at NHTSA ↗ ODI 11679032 Car suddenly and dangerously braked on highway with no other vehicles around. Afterwards the tool and check engine lights came on. All advance trac systems failed. Dealership replaced the broken bolts and rear axle. In review it appears recall 21s04 should apply. Site shows 2021 broncos from Hermosillo plant apply. Rep stated building date range 7/22-11/24. How can this apply to a 2021 ford recall? Look up ODI 11679032 at NHTSA ↗	4 ODI 11488227 MAKES A LOUD MOANING SOUND WHEN REVERSING AFTER VEHICLE HAS SAT FOR A FEW HOURS. BRAKE PADS ARE FINE, DOES NOT HAPPEN WHEN BRAKING WHILE GOING FORWARD. ONLY BRAKING WHILE GOING IN REVERSE. Look up ODI 11488227 at NHTSA ↗ ODI 11576279 Shocks defective. Shocks to be replaced twice on this vehicle with under 50,000 miles. First replaced at about 20,000 miles. Dealership advised that original shocks and now new replacement shocks leak on inspection. Clearly a defective part. Ford knows about this problem. Ford has put out a “service message for technicians” but why isn’t there a recall? Second issue is brake issue. Ford has also issued a “service message for technicians” on this issue. They are aware of the issue and customers are waiting 3 months or more for a “bushing and ha… Look up ODI 11576279 at NHTSA ↗ ODI 11550311 The floor board is missing underneath the driver's side. I can see what looks like gears. Not quite sure. Difficulty with braking. Hard to stop. I hear flapping noises coming from rear of vehicle when driving. Not quite if it's the suspension Look up ODI 11550311 at NHTSA ↗	4 ODI 11580169 It shakes, rattles and sound like a ship yard while backing up Look up ODI 11580169 at NHTSA ↗ ODI 11641486 The recall that is currently out my car is experiencing some issues they stated but there’s no remedy for it at the time!! And I went to the dealership to have older recalls checked they won’t do it for the front suspension or fuel injectors Look up ODI 11641486 at NHTSA ↗ ODI 11724824 Fuel system 1. I don't know what failed because the dealership didn't do anything to repair it. It is available for inspection upon request 2. Intensely strong fuel odor at the front of the car, inside and out. Strong exhaust odor at the back of the car. It is not safe to operate a car if it smells like fuel. 3. Dealership had it for 3 weeks and said there is nothing wrong. Now they are ignoring me. I am taking it to an independent mechanic. 4. Ford said they inspected it but they didn;t because there's all kinds of issues with this c… Look up ODI 11724824 at NHTSA ↗	1 ODI 11764351 · 124,000 mi The contact owns a 2021 Ford Bronco Sport. The contact stated that while operating the vehicle, exhaust fumes and a fuel odor entered the cabin, and the check engine warning light illuminated. The engine misfired, and the vehicle hesitated while driving. Upon inspecting under the hood, the contact discovered black soot in the engine compartment. The vehicle was taken to a local dealer for diagnosis, where the dealer determined that the piston solenoid, catalytic converter, and driver’s side lower control arm and bushing needed replacement. The … Look up ODI 11764351 at NHTSA ↗	—

Co-reporting does not establish that one component caused another concern.

Recurring narrative patterns

Specific keyword mentions beyond broad component labels. Matching includes negations and comparisons and does not confirm a diagnosis.

Search patterns

8 patterns with matching reports.

Warning lights and dashboard alerts

265 mentions · 19.5% of complaints

Median mileage: 35,782 mi (176 usable records).

ODI 11414295 · 2,294 mi

TL* THE CONTACT OWNS A 2021 FORD BRONCO SPORT. THE CONTACT STATED WHILE DRIVING 25 MPH, THE VEHICLE STALLED. THERE WAS NO WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TOWED TO STEVEN'S JERSEY CITY FORD (740 NJ-440, JERSEY CITY, NJ 07305) BUT NOT YET DIAGNOSED OR REPAIRED. THE CONTACT ALSO STATED THAT THE FRONT AXLE WAS REPAIRED PRIOR TO THE FAILURE. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE CONTACT WAS INFORMED THAT HE WOULD RECEIVE A CALLBACK. THE FAILURE MILEAGE WAS APPROXIMATELY 2,294.

Look up ODI 11414295 at NHTSA ↗

ODI 11418897 · 1,000 mi

The contact owns a 2021 Ford Bronco Sport. The contact stated while driving at various speeds, the vehicle hesitated with the accelerator pedal depressed. There was no warning light illuminated. The vehicle was taken to the local dealer to be diagnosed. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA for assistance. The failure mileage was approximately 1,000.

Look up ODI 11418897 at NHTSA ↗

ODI 11432247 · 5,000 mi

Look up ODI 11432247 at NHTSA ↗

Matching rule

\b(warning light\w*|check engine|dashboard warning\w*|malfunction indicator)\b

Stalling or loss of power

136 mentions · 10.0% of complaints

Median mileage: 32,691 mi (47 usable records).

ODI 11406545 · 1,449 mi

Look up ODI 11406545 at NHTSA ↗

ODI 11414295 · 2,294 mi

Look up ODI 11414295 at NHTSA ↗

ODI 11414378 · 198 mi

NOT EVEN 200 MILES, ENGINE BEGAN RATTLING AND STALLING OUT. I WAS STRANDED IN THE MIDDLE OF THE ROAD AT A GREEN LIGHT. DEALERSHIP CLAIMS TORQUE CONVERTER PROBLEM. BRAND NEW BADLANDS PACKAGE. 2 LITER 4CYL ECOBOOST 250HP

Look up ODI 11414378 at NHTSA ↗

Matching rule

\b(stall\w*|loss of power|lost power|engine shut\w* off)\b

Brake response concerns

56 mentions · 4.1% of complaints

Median mileage: 17,500 mi (38 usable records).

ODI 11446596 · 9,000 mi

The contact owns a 2021 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 21V922000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that while reversing at 5 MPH, the brake pedal was stiff while depressed and the brakes failed to engage, causing the contact to crash into a parked vehicle. The contact received medical treatment at the hospital for whiplash and back injuries. No police report was filed. The dealer was made aware of the failure and has pos…

Look up ODI 11446596 at NHTSA ↗

ODI 11448687 · 4,200 mi

The contact owns a 2021 Ford Bronco Sport. The contact received a recall notification for NHTSA Campaign Number: 21V922000 (Service Brakes, Hydraulic) however, the dealer informed the contact that the part to do the recall repair was not yet available. The contact stated that the brake pedal would make abnormal squeaking sounds while driving. There were no warning lights illuminated. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not notified of the failure. The veh…

Look up ODI 11448687 at NHTSA ↗

ODI 11449342

Both interior liftgate lights inoperative. However, the "liftgate ajar light", and came on without warning as I was driving. I had not opened the litigate. Radio system skips & pops. fails to load tor loads slowly. Brakes failed to fully engage quickly on a slow turn, causing a total loss accident. Vehicle has 645 miles on it. I love my Bronco Sport. But..is it safe to drive if I order a new one? Can there be a cross check done by VIN to ensure I'm not getting one with the same problem? Specifically, the brakes? The brake issue worries me P…

Look up ODI 11449342 at NHTSA ↗

Matching rule

Hard or delayed shifting

44 mentions · 3.2% of complaints

Median mileage: 12,500 mi (9 usable records).

ODI 11511567 · 9,000 mi

The contact owns a 2021 Ford Bronco Sport. The contact stated that while reversing, there was an abnormal grinding noise detected coming from the brakes. While driving at various speeds around a curb, the steering wheel was jerking. There were no warning lights illuminated. The vehicle was taken to the local dealer and the mechanic was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was not contacted. The approximate failure mileage was 9,000.

Look up ODI 11511567 at NHTSA ↗

ODI 11521355 · 1,000 mi

The contact owns a 2021 Ford Bronco Sport. The contact stated that the vehicle was jerking while shifting into gear, while making turns, and while coming to a complete stop. There was no warning light illuminated. Additionally, the contact stated that the vehicle rolled after shifting into park(P). The vehicle was taken to the dealer to be test-driven. The dealer informed the contact that no issues were found; however, the failure reoccurred. The contact stated that while the vehicle was at the dealer for a brake recall repair, the dealer infor…

Look up ODI 11521355 at NHTSA ↗

ODI 11548006

While driving vehicle will flash place hands on wheel while hands are on the wheel. It will then turn off sound system and cut off adaptive features until I shake my steering wheel irrationally to the left and right. It will also jerk the vehicle into other lanes to try and correct to stay in lane, while I'm inside of the lines issuing the adaptive driving features. If there is a break in the lines, ie: turning lane or intersection the adaptive wants to jerk course into other lanes. While driving down the expressway, if a car on either side…

Look up ODI 11548006 at NHTSA ↗

Matching rule

Battery drain and no-start mentions

39 mentions · 2.9% of complaints

Median mileage: Unavailable (0 usable records).

ODI 11428010

Look up ODI 11428010 at NHTSA ↗

ODI 11448737

First time the engine lights came on and turned off the car could not restart, needed a new engine the first engine had 830 miles. Second time car stalled and the car would not start they replaced the engine again this time that engine had about 1,200 miles. Third time the car did the same thing with about 1,400 miles. All three times I was driving on Busy roads almost got hit all three times. Dealership did not give me any paperwork

Look up ODI 11448737 at NHTSA ↗

ODI 11465216

When trying to start my new Ford Bronco with 3000 miles on it in my driveway , the vehicle would not start and there were no lights on the dashboard , everything was black . When the vehicle was jumped , it started , but the console and radio was still black and when you put the car in drive it just stalled out. The tow truck came and could not put the vehicle in neutral so he had to drag the car onto the bed of the truck . It was taken to the dealership and they had the vehicle for a week and said they could not find a problem and after a few …

Look up ODI 11465216 at NHTSA ↗

Matching rule

Fuel smell or leak mentions

19 mentions · 1.4% of complaints

Median mileage: Unavailable (0 usable records).

ODI 11621921

The evaporative emissions system failure involving the purge valve and vapor canister purge valve is a recurrent issue on this car and has been reported by hundreds if not thousand of bronco sport owners. The safety issue that arises from this is that we are emitting more fuel vapors into the atmosphere, not only does this not help with emissions control into the atmosphere, but it decreases fuel efficiency and increases gasoline smell into the vehicles cabin.

Look up ODI 11621921 at NHTSA ↗

ODI 11681192

The component is the fuel injector, which is a part of the engine's fuel delivery system. According to the recall notice from Ford, this component has the potential to crack. The component is known to be defective and has been inspected by a Ford dealership service department upon my request and was told there's no solution as of yet by Ford. My family's safety, including that of my toddler who is a daily passenger, is at significant risk due to the potential for an underhood fire. The recall notice explicitly states that a crack in the fuel…

Look up ODI 11681192 at NHTSA ↗

ODI 11695272

After Ford completed Recall 25S76 on my 2021 Ford Bronco Sport (VIN [XXX] ), which involves replacing high-pressure fuel injectors due to the risk of cracking and fuel leaks, the check engine light returned immediately after the road test. The Ford dealer’s diagnostic confirmed: “After installing high-pressure fuel injectors, cleared codes, road tested and check engine light came back on, performed further P/P test, found high-pressure fuel pump with internal fault which caused a back-pressure concern and took out low-side fuel pump.” The high…

Look up ODI 11695272 at NHTSA ↗

Matching rule

\b(fuel leak\w*|gas leak\w*|gas(?:oline)? smell|smell\w* (?:of )?(?:fuel|gas))\b

Steering assistance concerns

15 mentions · 1.1% of complaints

Median mileage: 28,000 mi (5 usable records).

ODI 11575637

On February 5, 2024, the engine of a Bronco Sport shut off while driving and the dashboard lights began flashing with multiple warnings and notifications. The car would not restart and the gear shift was locked, preventing the driver from moving the vehicle out of the road during rush hour traffic. A tow truck was called, but after 30 minutes, the driver was able to restart the car and canceled the tow truck. The car was taken to the dealership on February 6, 2024, but the cause of the incident has not been diagnosed. On February 4, 2024, the …

Look up ODI 11575637 at NHTSA ↗

ODI 11586132 · 28,000 mi

The contact owns a 2021 Ford Bronco Sport. The contact stated that while stopped at a red light with the fuel-saving feature activated, the engine did not immediately restart after releasing the brake pedal. Also, while driving at approximately 40 MPH, the braking system erroneously activated causing the vehicle to abruptly stop in the middle of an intersection. The failure had also occurred while parking the vehicle. The vehicle was towed to the local dealer who performed service to the power steering system but after retrieving the vehicle th…

Look up ODI 11586132 at NHTSA ↗

ODI 11596510

In March 0f 2024, while traveling down the highway at 65 mph, vehicle lost power suddenly, engine shut off, and loss of power steering with no warning, no check engine lights, no change in temperature to motor. Vehicle was towed to dealership in which they advised the engine was locked up and later determined the turbo had failed, likely leading to the engine failure. The 2021 Ford Bronco Sport only had 30,000 miles so it is apparent this motor and or turbo has some type of fault. Dealership did not cover under warranty as vehicle had brande…

Look up ODI 11596510 at NHTSA ↗

Matching rule

\b(power steer\w*|steering assist\w*|steering lock\w*|steering wheel lock\w*)\b

Oil consumption or dilution

3 mentions · 0.2% of complaints

Median mileage: Unavailable (0 usable records).

ODI 11655021

The water pump has been replaced twice already and the water pump needs to be replaced again at 105,000 miles. This will be the fourth water pump this vehicle has. The originally came with, two replacements, and now the one that it needs because it is leaking like the previous three. The turbo charger failed and was burning oil. That was replaced. A month later it is back at the dealership being replaced again

Look up ODI 11655021 at NHTSA ↗

ODI 11632343

I have had gas in the oil 3 different times now. I had went over to lafontaine on [XXX] , and they said it was because I was 500 miles before an oil change. I knew that gas and oil didn’t mix so I fought for the car to stay at the dealership and the whole time I was being told I was crazy and not to waste the technicians time after the 2nd time of it being there. I then for the 3rd time went to Ford dealership located in Fenton, and at that time they could not indicate the cause, but told me they sold that car and there was various issues befor…

Look up ODI 11632343 at NHTSA ↗

ODI 11736874

The apparent failure involves the engine lubrication and/or cooling system. After approximately 30 minutes of driving, I noticed a strong burning oil/fluid/exhaust-type odor. Initially, I believed it was coming from other vehicles because my vehicle had passed inspection about two weeks earlier. Once parked and away from traffic, it became clear the odor was coming from my vehicle. About one hour later, I discovered a large puddle of oil underneath the vehicle. Upon inspection, the coolant reservoir was nearly empty and the engine oil level was…

Look up ODI 11736874 at NHTSA ↗

Matching rule

\b(oil consumption|burn\w* oil|consum\w* oil|oil dilution|gas(?:oline)? in (?:the )?oil)\b