2022 Ford E-450 problems and owner complaints

BLOWOUT ON LT225/75R16 MICHELIN TIRE ON 2017 THOR MOTORHOME. VIN NUMBER [XXX] . ONLY 2075 MILES ON VEHICLE AND TIRE. DOT 83JH 00YX 115/112.. READ IN MOTORHOME MAGAZINE THAT THIS HAS HAPPENED TO OTHERS. 3 ON ONE MOTORHOME. RIDING ON HIGHWAY. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Look up ODI 10978755 at NHTSA ↗

The contact owns a 2019 Entegra Odyssey RV constructed on a 2019 Ford E450 chassis equipped with Hankook Tires, Tire Line: Dynapro HT, Tire Size: LT225/75/R16, DOT Number: BCXEHUH. The contact stated that upon inflating the tires, his brother was informed that the tires needed to be replaced as they had dry rotted. Additionally, the contact stated that the tires were consistently becoming flat while driving. The Tire dealer and manufacturer were not made aware of the failure. The RV dealer and manufacturer were notified of the failure but provi…

Look up ODI 11483471 at NHTSA ↗

TL* THE CONTACT OWNS A 2014 FORD E-450 EQUIPPED WITH MICHELIN LTX M/S TIRES, SIZE: LT225/75 R16. WHILE DRIVING 45 MPH, THE REAR PASSENGER SIDE TIRE TREAD SEPARATED. THE CONTACT PULLED OVER AND CONTACTED ROADSIDE ASSISTANCE. THE CONTACT STATED THAT THE TREAD ON THE TIRE SEPARATED ON TWO OTHER OCCASIONS WITHIN THE SAME MONTH. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE VEHICLE AND TIRE FAILURE MILEAGE WAS 12,500.

Look up ODI 10984857 at NHTSA ↗

TL* THE CONTACT OWNS A 2015 FORD E-450. WHILE DRIVING AT 55 MPH, THE VEHICLE STALLED. THE CONTACT WAS UNABLE TO RESTART THE VEHICLE AND THE ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TOWED TO A DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE TECHNICIAN WAS ABLE TO RESTART THE VEHICLE BUT WAS UNABLE TO DIAGNOSE OR REPAIR THE VEHICLE. THE FAILURE RECURRED AND THE VEHICLE WAS TOWED TO THE DEALER WHO DIAGNOSED THAT THE FUEL MODULE NEEDED TO BE REPAIRED. THE VEHICLE WAS REPAIRED; HOWEVER, THE CONTACT STATED THAT SHORTLY AFTER THE REPAIR, THE V…

Look up ODI 10764471 at NHTSA ↗

HESITATION/NO POWER AFTER MAKING A TURN, PRIMARILY A LEFT-HAND BUT HAS HAPPENED ALSO AFTER A RIGHT-HAND TURN. THE ENGINE HAS NEVER STALLED OR DISPLAYED FAULT CODES OR A CHECK ENGINE LIGHT ON THE DASH. FORD HAS CHECKED FOR THIS CONDITION.

Look up ODI 10855283 at NHTSA ↗

THIS IS A 24' MOTORHOME. 2017 FORD E-450/ WHILE DRIVING IN REGULAR TRAFFIC, IF VEHICLE IS TRAVELING 50 MPH OR MORE, THE STEERING FEELS LOOSE AND THE WHEELS HAVE A DELAYED REACTION TO THE STEERING. THE VEHICLE DRIFTS VERY STRONGLY TO THE RIGHT OR LEFT WHEN ANOTHER VEHICLE IS PASSING AT A GREATER SPEED THAN I AM TRAVELING. SOMETIMES, THROWING MY VEHICLE ALMOST OFF THE ROAD, BECAUSE WHEN THE VEHICLE I AM IN DRIFTED TO THE RIGHT, THE COUNTER STEERING DOESN'T RESPOND IMMEDIATELY, HENCE IT IS VERY DELAYED. SOMETIMES IT FEELS LIKE THE WHEELS ARE OFF T…

Look up ODI 10993131 at NHTSA ↗

The contact owns a 2021 Ford E-450. The contact received notification of NHTSA Campaign Numbers: 20V795000 (Engine) and 22V089000 (Steering, Service Brakes, Hydraulics) however, the parts to do the recall repairs were not yet available. The dealer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. VIN tool confirms parts not available and Parts distribution disconnect respectively.

Look up ODI 11466381 at NHTSA ↗

The contact owns a 2022 Ford E-450. The contact stated while driving 60 MPH, the steering wheel felt loose, and the vehicle was difficult to control. The check engine warning light was illuminated. The vehicle was taken to the dealer and the dealer stated no failure was found, but the failure persisted. The vehicle was taken back to the dealer and the vehicle was repaired. The contact was unsure what was repairs were made or what parts were replaced. The failure persisted. The manufacturer was not contacted. The failure mileage was 3,000.

Look up ODI 11509828 at NHTSA ↗

The brand new JAYCO GREWHAWK is making a whining sound from the chassis. I have not even driven it more than 50 miles. this vehicle needs to be recalled for whatever chassis issues or it could be transmission issues. I will take it back to FORD but this is really bad on ford to sell brand new RVs with such whining sound coming from the chassis. Please alert the new owners about the issues . thank you, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Look up ODI 11614740 at NHTSA ↗

2025 E-450 Safety Recalls* Main control valve body or transmission replacement Recall incomplete INVESTOR REPORTING FOR "amber alert" for all 2025 E-450, as this vin shows NO ACTIVE RECALLS. Yet our factory engineers have issued this RECALL. PLEASE BROADCAST.....

Look up ODI 11679474 at NHTSA ↗

Description When your vehicle is in reverse gear, the vehicles exterior sounder backup alarm may only produce an intermittent warning sound or may be inoperative and produce no warning sound. Safety Risk A backup alarm that does not emit sound may fail to alert pedestrians or other road users of a reversing vehicle, increasing the risk of a crash or injury. Remedy Parts are available to repair your vehicle. Ford Motor Company has authorized your dealer to repair the wiring connection at the exterior sounder backup alarm free of charge. Ne…

Look up ODI 11744042 at NHTSA ↗

DURING MY 1500 MILE RECOMMENDED OIL CHANGE SERVICE, THE FORD DEALER SERVICE TECHNICIAN FOUND A LEAK OF HYDRAULIC FLUID THAT TURNED OUT TO BE COMING FROM THE POWER STEERING / POWER BRAKING HYDRO BOOST UNIT. HE DETERMINED THAT THE LEAK WAS CAUSED BY A FACTORY OVER-TIGHTENING OF A BOLT ON THE UNIT THAT STRIPPED THE THREAD AND CAUSED THE LEAK. THE BOOSTER AND ASSOCIATED HOSES OR LINES NEEDED TO BE REPLACED. I WAS TOLD THAT DRIVING THE VEHICLE WITHOUT THE REPAIR WOULD HAVE BEEN VERY DANGEROUS AND COULD HAVE CAUSED A TOTAL FAILURE OF THE BRAKES. *…

Look up ODI 10561282 at NHTSA ↗

I PURCHASED THIS THOR MOTOR HOME FROM A DEALER ON 09/06/2019, USED OUR FIRST TRIP 260 MILES BOTH WAYS I HAVE FOUND A VERY DIFFICULT TIME ON KEEPING UNIT ON ROAD PROPERLY CONSTANTLY DRIFTING AND VERY FATIGUED IN DRIVING. AT CAMP SIGHT AN IDENTICAL 31W THOR 2018 OWNER STATED HE HAD SAME PROBLEM AN NEIGHBORS STATED THAT STABILIZER NEEDS TO BE REPLACED WITH A SAFETPLUS 31-140 UNIT AND NOW NO PROBLEM. HELP!!! I WOULD CONSIDER THIS TO BE A SAFETY ITEM THAT NEEDS CORRECTION. HIGHWAY 65MPH.

Look up ODI 11258842 at NHTSA ↗

THIS IS A 24' MOTORHOME. 2017 FORD E-450/ WHILE DRIVING IN REGULAR TRAFFIC, IF VEHICLE IS TRAVELING 50 MPH OR MORE, THE STEERING FEELS LOOSE AND THE WHEELS HAVE A DELAYED REACTION TO THE STEERING. THE VEHICLE DRIFTS VERY STRONGLY TO THE RIGHT OR LEFT WHEN ANOTHER VEHICLE IS PASSING AT A GREATER SPEED THAN I AM TRAVELING. SOMETIMES, THROWING MY VEHICLE ALMOST OFF THE ROAD, BECAUSE WHEN THE VEHICLE I AM IN DRIFTED TO THE RIGHT, THE COUNTER STEERING DOESN'T RESPOND IMMEDIATELY, HENCE IT IS VERY DELAYED. SOMETIMES IT FEELS LIKE THE WHEELS ARE OFF T…

Look up ODI 10993131 at NHTSA ↗

The contact owns a 2019 Nexus Viper built on a 2018 Ford E-450 chassis. The contact stated while driving 30 MPH, the steering wheel felt loose, and the vehicle would not drive in a straight line. The contact stated no warning light was illuminated. The contact took the RV to an independent mechanic and was informed that the cam bushing was detached from the RV. The vehicle was not repaired. The manufacturer had been informed of the failure and informed the contact that they would tow the RV to a local dealer. The contact stated that when he con…

Look up ODI 11444433 at NHTSA ↗

The contact owns 2021 Ford E-450. The contact stated that while driving at various speeds on the freeway, the contact mentioned that any time another vehicle or object was near the vehicle, it lost steering capabilty. The contact would have to regain control of the steering wheel in order for the steering wheel to resume back to normal. No warning light illuminated. The vehicle was taken to the dealer where it was diagnosed and kept for three days however unable to duplicate the issue. The vehicle was not repaired. The failure recurred. The ma…

Look up ODI 11430282 at NHTSA ↗

I received a recall notice on this vehicle from Ford. Ford Recall 22S08 and NHTSA recall 22V089. Ford does not seem to be aware of this recall nor do you. The earliest Big Valley Ford in Stockton CA appointment I could get was 7/19/22. This is not acceptable based on safety

Look up ODI 11457855 at NHTSA ↗

The brand new JAYCO GREWHAWK is making a whining sound from the chassis. I have not even driven it more than 50 miles. this vehicle needs to be recalled for whatever chassis issues or it could be transmission issues. I will take it back to FORD but this is really bad on ford to sell brand new RVs with such whining sound coming from the chassis. Please alert the new owners about the issues . thank you, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Look up ODI 11614740 at NHTSA ↗

Parking Brake The Sticker on this U-Haul 15 foot Truck says, "Engage the Parking Brake before turning off the Engine, otherwise UNCONTROLLED OPERATION OF VEHICLE may occur.". I pulled on the Parking Brake as the Sticker warned. With my foot off the Gas Pedal, at about 25 - 30 MPH the U-Haul Steered way to the right by itself, and drove onto the Right Curb. This was quite Frightening and Unexpected. Then it happened again later that day at just about 30 MPH, again with my foot off the Gas Pedal and Kind of Coasting into a small Town. Lat…

Look up ODI 11741946 at NHTSA ↗

THIS IS A JAYCO GREYHAWK 31' RV. WHEN THE ENGINE IS WARMED UP IT WILL NOT RESTART IMMEDIATELY UPON BEING SHUT OFF. IT WILL ONLY START AFTER ABOUT 15 MINUTES.

Look up ODI 11093698 at NHTSA ↗

THE MOTORHOME WAS MANUFACTURED WITH A SET OF MICHELIN LT 225 75 16 TIRES. THE DOT # ON ALL 6 OR THE TIRES IS DOTB3JH009X. MICHELIN CLAIMS THEY ARE NOT PART OF THE RECALL AND ARE REFUSING TO REPLACE THEM. THE VEHICLE ONLY HAS 17,722 MILES ON IT. THANK YOU FOR YOU ANTICIPATED ASSISTANCE. STEVE

Look up ODI 11051283 at NHTSA ↗

THOR MOTOR COACH SOLD ME A 2016 FOUR WINDS CLASS C MODEL 23U MOTOR HOME WITH A CLASS IV HITCH THAT IS NOT SAFE FOR THE STATED CAPACITY OF 8,000 POUNDS. IF THE HITCH IS USED IN THE STATED 8,000 POUND CAPACITY, THE HITCH WILL FAIL AND CAUSE AN ACCIDENT. FORD MOTOR COMPANY MAKES THE E450 CHASSIS THAT THE MOTOR HOME BODY IS MOUNTED ON. FORD STATES THAT THE TONGUE WEIGHT FOR A PROPERLY LOADED 8,000 POUND TRAILER SHOULD BE IN THE RANGE OF 800 TO 1,200 POUNDS (10% TO 15%). THOR MOTOR COACH HAS DE-RATED THE HITCH CAPACITY TO 500 POUNDS WHICH RESULTS IN…

Look up ODI 10891901 at NHTSA ↗

While in standard shuttle route emergency egress window imploded inward. This is the 3rd occurrence. Vehicle is a 2017 Ford E-450 Chassis with an Elkhart Coach ECII 25 PASSENGERS PLUS DRIVER shuttle body.

Look up ODI 11482879 at NHTSA ↗

. THIS IS A SAFETY CONCERN. WE WERE ON A TRIP AND AT ONE POINT MY RIGHT FOOT TOUCHED THE DOG HOUSE NEAR THE ACCELERATOR. I MOVED MY FOOT VERY QUICKLY BECAUSE IT WAS HOT AND BURNED MY FOOT. WHEN WE ARRIVED HOME, I USED A NON CONTACT THERMOMETER TO MEASURE THE SURFACE TEMPERATURE OF THE DOG HOUSE ON THE DRIVERS SIDE. THE LOWEST TEMPERATURE I FOUND WAS 120 DEGREES AND THE HIGHEST TEMPERATURE WAS 148 DEGREES. THE 148 DEGREE TEMPERATURE WAS NEXT TO WHERE MY FOOT IS WHEN I AM DRIVING. SINCE THIS IS AN RV WE TYPICALLY DRIVE FOR SEVERAL HOURS AT A TIME…

Look up ODI 11251997 at NHTSA ↗

The L shaped bracket that supports the RV hydraulic/motor assembly for the auto leveling system has failed. The weld between two pieces of steel that makes up the bracket has failed. When the bracket fails the assembly is supported temporarily by electrical wires and hydraulic hoses. If it fails further and drags the road or separates completely, there is a possibility of fire under the vehicle and/or death or injury to other drivers on the road. There other safety recalls for this exact failure but my unit was not listed.

Look up ODI 11749775 at NHTSA ↗

The Service Advance Trac light comes on sporadically. This also triggers the Cruise Control and Hill Start Assist to turn off. Any of these malfunctions could prove to be a safety issue particularly with regard to stability and control of the vehicle. The vehicle has not yet been to a dealer for these issues as we are traveling. The malfunction has occurred about 5-6 times while driving, without any particular triggers.There were no early warnings and the first time the service light came on was June 18th and we were on a two lane flat road doi…

Look up ODI 11423803 at NHTSA ↗

The tire pressure monitoring system fails frequently while being driven. The first few times I pulled off the road and checked the pressures, and they were normal. I had the system checked at a Ford dealership and they couldn't find any problem. It failed again. I returned to the dealership and they said they couldn't find a problem and there is nothing they could do for me. So I drive away from the dealership and the same thing happens. Believing that they can't do anything I keep driving and manually checking pressures. Problem returns.…

Look up ODI 11523300 at NHTSA ↗

2025 E-450 Safety Recalls* Main control valve body or transmission replacement Recall incomplete INVESTOR REPORTING FOR "amber alert" for all 2025 E-450, as this vin shows NO ACTIVE RECALLS. Yet our factory engineers have issued this RECALL. PLEASE BROADCAST.....

Look up ODI 11679474 at NHTSA ↗

Description When your vehicle is in reverse gear, the vehicles exterior sounder backup alarm may only produce an intermittent warning sound or may be inoperative and produce no warning sound. Safety Risk A backup alarm that does not emit sound may fail to alert pedestrians or other road users of a reversing vehicle, increasing the risk of a crash or injury. Remedy Parts are available to repair your vehicle. Ford Motor Company has authorized your dealer to repair the wiring connection at the exterior sounder backup alarm free of charge. Ne…

Look up ODI 11744042 at NHTSA ↗

NO CRANK NO START WITH ANTITHEFT ON . LOST COMMUNICATION

Look up ODI 11120875 at NHTSA ↗

TL* THE CONTACT OWNS A 2016 FORD E-450. THE CONTACT STATED THAT THE AUTOMATIC TRANSFER SWITCH CAUGHT FIRE. THE FIRE EXTINGUISHED ITSELF AND A FIRE REPORT WAS NOT FILED. THERE WERE NO INJURIES. THE CONTACT CALLED AN UNKNOWN DEALER, BUT AN APPOINTMENT COULD NOT BE SCHEDULED FOR TWO WEEKS. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC FOR REPAIRS. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 16V598000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS UNKNOWN.

Look up ODI 11039800 at NHTSA ↗

Parking Brake The Sticker on this U-Haul 15 foot Truck says, "Engage the Parking Brake before turning off the Engine, otherwise UNCONTROLLED OPERATION OF VEHICLE may occur.". I pulled on the Parking Brake as the Sticker warned. With my foot off the Gas Pedal, at about 25 - 30 MPH the U-Haul Steered way to the right by itself, and drove onto the Right Curb. This was quite Frightening and Unexpected. Then it happened again later that day at just about 30 MPH, again with my foot off the Gas Pedal and Kind of Coasting into a small Town. Lat…

Look up ODI 11741946 at NHTSA ↗

TL* THE CONTACT OWNS A 2013 FORD E-450. WHILE OPERATING THE VEHICLE, THE "SERVICE VEHICLE" WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER (MORRIS BUFFALO FORD, 702 E. HIGHWAY 55, BUFFALO, MN) WHERE IT WAS DIAGNOSED THAT THE CLUTCH CYLINDER WELL INSIDE THE TRANMISSION WAS CRACKED AND THE TRANSMISSION NEEDED TO BE REBUILT. THE MANUFACTURER WAS NOTIFIED AND NO ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 70,000.

Look up ODI 11073007 at NHTSA ↗

TL* THE CONTACT OWNS A 2015 FORD E-450. WHILE OPERATING THE VEHICLE, THE "SERVICE VEHICLE" WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER (MORRIS BUFFALO FORD, 702 E. HIGHWAY 55, BUFFALO MN) WHERE IT WAS DIAGNOSED THAT THE CLUTCH CYLINDER WELL INSIDE THE TRANMISSION HAD CRACKED AND THE TRANSMISSION NEEDED TO BE REBUILT. THE MANUFACTURER WAS NOTIFIED AND NO ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 100,000.

Look up ODI 11072827 at NHTSA ↗

TL* THE CONTACT OWNS A 2016 FORD E-450. THE CONTACT STATED THAT WHILE IN REVERSE, THE VEHICLE ACCELERATED WITHOUT ANY WARNING CRASHING INTO A MOBILE HOME. THE CONTACT STATED NO INJURIES WERE SUSTAINED. A POLICE REPORT WAS NOT FILED. THE CONTACT STATED AS A RESULT OF THE FAILURE THE VEHICLE HAS FAILED TO SHIFT FROM THE REVERSE POSITION. THE DEALER KAYSER AUTOMOTIVE GROUP (2303 WEST BELTLINE HIGHWAY, MADISON, WI 53713 [phone removed]) WAS CONTACTED FOR A DIAGNOSTIC TEST TO BE PERFORMED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWAR…

Look up ODI 11144717 at NHTSA ↗

TRANSMISSIONS 6R140 HAVE PREMATURE FAILURE THIS IS OUR 6TH TRANSMISSION TO GO OUT IN OUR 5 VANS, WHEN TRANSMISSION GOES OUT, THE TORQUE CONVERTER FAILS WHICH RESULTS IN VEHICLE STALLING IN ROAD WAY THE VEHICLE WHILE JERK REALLY HARD AND GIVE DRIVE WHIPLASH AND WHEN VEHICLE IS GOING UP HILL WHEN THE TORQUE CONVERTER FAILS THE VAN WILL SLAM TO A STOP, STALL THEN START ROLLING BACKWARDS OR FORWARDS WITH NO BRAKES OR POWERSTEERING. WHEN THIS HAPPENS DRIVER HAS NO BREAKS OR POWERSTEERING AND MOST TIMES THIS HAS HAPPENED THE DRIVER CANT QUICKLY RESTA…

Look up ODI 11479886 at NHTSA ↗

The component that failed was the driveline on our RV. Specifically, the driveline was installed at an incorrect angle, which caused excessive vibrations and loud noises while driving at highway speeds. The improper driveline angle posed a serious safety risk to my family and others on the road. The vibrations were severe enough to affect vehicle handling and stability, especially at higher speeds. There was also concern that the continued stress could lead to mechanical failure or component separation, which could result in loss of control o…

Look up ODI 11655655 at NHTSA ↗

Description When your vehicle is in reverse gear, the vehicles exterior sounder backup alarm may only produce an intermittent warning sound or may be inoperative and produce no warning sound. Safety Risk A backup alarm that does not emit sound may fail to alert pedestrians or other road users of a reversing vehicle, increasing the risk of a crash or injury. Remedy Parts are available to repair your vehicle. Ford Motor Company has authorized your dealer to repair the wiring connection at the exterior sounder backup alarm free of charge. Ne…

Look up ODI 11744042 at NHTSA ↗