Explore the records behind recurring owner reports.
47 owner complaints analyzed
3 distinct recall campaigns
70,575 mi median reported failure mileage
Scope: 1973 to 2003 model years. Data updated: . 26 complaints include usable failure mileage. View data status.
All campaigns in the snapshot affecting each model year, including recalls announced years later.
Shared campaigns appear once in each affected model year.
| Category | Count |
|---|---|
| 1987 | 0 |
| 1989 | 0 |
| 1990 | 0 |
| 1993 | 0 |
| 1994 | 0 |
| 1995 | 0 |
| 1997 | 0 |
| 1998 | 0 |
| 1999 | 0 |
| 2000 | 1 |
| 2001 | 1 |
| 2002 | 1 |
| 2003 | 1 |
1987: 0; 1989: 0; 1990: 0; 1993: 0; 1994: 0; 1995: 0; 1997: 0; 1998: 0; 1999: 0; 2000: 1; 2001: 1; 2002: 1; 2003: 1
3 distinct campaigns affect this selection. Announcement dates below are different from vehicle model years. A campaign may cover multiple years.
Reported: 1977-10-25 (October 25, 1977) · Model years: 1978
THE INVOLVED VEHICLES ARE EQUIPPED WITH SAFETY COMPLIANCE CERTIFICATION LABELS AND INCOMPLETE VEHICLE DOCUMENTS THAT INDICATE THAT THE GROSS AXLE WEIGHT RATING (GAWR) IS APPROXIMATELY 0.6 TO 6.0 PERCENT GREATER THAN THE COMBINED LOAD CAPACITY OF THE TIRES AT THE SPECIFIED TIRE INFLATION PRESSURE. THIS FAILS TO COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NOS. 120, "AIR BRAKE SYSTEMS", AND 119, "NEW PNEUMATIC TIRES FOR VEHICLES OTHER THAN PASSENGER CARS", OR 109, "NEW PNEUMATIC TIRES".
Remedy: OWNER WILL RECEIVE CORRECT LABELS BY MAIL, FREE OF CHARGE.
NHTSA campaign record ↗Reported: 1980-06-09 (June 9, 1980) · Model years: 1980
CERTAIN VEHICLES WERE PRODUCED WITH WHEEL ASSEMBLIES THAT MAY HAVE CRACKS NEAR THE BOLT HOLES IN THE WHEEL DISC. DURING VEHICLE USE, THE CRACKS COULD GRADUALLY INCREASE AND RESULT IN PARTIAL OR COMPLETE SEPARATION OF THE WHEEL AND TIRE ASSEMBLY FROM THE VEHICLE.
Remedy: DEALER WILL INSPECT THE WHEEL DISC DATE CODE AND REPLACE THOSE WHEELS INDICATING AN OCTOBER 18, 1979 DATE OF MANUFACTURE.
NHTSA campaign record ↗Reported: 2003-03-07 (March 7, 2003) · Model years: 2000, 2001, 2002, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Consequence: THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
NHTSA campaign record ↗Inspect model-year patterns, reported mileage, monthly activity and the evidence behind each signal.
47 unique complaints in this selection. Analysis snapshot: 2026-10-01.
Missing, zero and invalid mileage is excluded. Dates after the snapshot are excluded. Examples are limited selections, not a representative sample.
Model-wide comparison of the eight most reported components across the model. Cells show counts and shares within each model year. Open a cell for source examples.
| Component | 1989 | 1990 | 1993 | 1994 | 1995 | 1997 | 1998 | 1999 | 2000 | 2001 | 2002 | 2003 |
|---|---|---|---|---|---|---|---|---|---|---|---|---|
| Steering | 1100.0%ODI 11129461 · 28,900 miTHE STEERING WHEEL IS LOSE. THE TWO GAS TANKS DON'T WORK THE TURN SIGNAL U HAVE TO HOLD IT TO WITCH WAY YOUR TURNING. AND THE PULSATING IN THE BRAKE OR ROTOR IS FILLS PUSATING. THE BACK HEATER DON'T WORK. | 00.0%No examples available for this selection. | 133.3%ODI 10610786 · 85,000 miVEHICLE SWAYS AND DRIFTS ON ROAD. EXCESSIVE FREE PLAY IN POWER STEERING GEAR BOX. STEERING GEAR BOX WAS REPLACED BUT WITH ORIGINAL EQUIPMENT CONDITION IS THE SOME. WHY WAS GEAR BOX NOT RECALLED WHEN TIRES WERE RECALLED? IS THERE AN UPGRADED PART THAT WILL SOLVE THE PROBLEM? ( SEE NHTSA REFERENCE #10382765) ALSO FORD TRUCK ENTHUSIASTS FORUMS - STEERING PROBLEMS. *TR | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 116.7%ODI 10070333WE PURCHASED A 1997 FORD E150 RAISED ROOF CONVERSION VAN FROM JIM O'NEAL FORD IN SELLERSBURG, INDIANA JUST ACROSS THE BORDER FROM LOUISVILLE, KENTUCKY. THE CONVERSION WAS BY SUPERIOR IN LOUISVILLE. WE PURCHASED THAT PARTICULAR VAN BECAUSE IT WAS HIGHLY RATED BY FORD MOTOR COMPANY AS A CONVERSION COMPANY. WE DROVE THE VAN FOR SIX YEARS AND JUST RECENTLY TRADED IT IN. IT HAS 97,000 MILES ON IT. THE MAJOR PROBLEM WE HAD WITH THE VAN WAS WITH THE FRONT END. BOTH FORD AND OUR LOCAL TIRE DEALER HAVE TOLD US THAT BECAUSE THE VAN IS RAISED ROOF A… | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 116.7%ODI 10066235 · 65,000 miSTEERING COUPLER CAME LOOSE FROM STREERING BOX. DRIVER WAS DRIVING AT SLOW SPEED SO NO ACCIDENT VAN NEEDED BE TOWED IN FOR REPAIR. *AK | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
| Suspension | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 233.3%ODI 10070333WE PURCHASED A 1997 FORD E150 RAISED ROOF CONVERSION VAN FROM JIM O'NEAL FORD IN SELLERSBURG, INDIANA JUST ACROSS THE BORDER FROM LOUISVILLE, KENTUCKY. THE CONVERSION WAS BY SUPERIOR IN LOUISVILLE. WE PURCHASED THAT PARTICULAR VAN BECAUSE IT WAS HIGHLY RATED BY FORD MOTOR COMPANY AS A CONVERSION COMPANY. WE DROVE THE VAN FOR SIX YEARS AND JUST RECENTLY TRADED IT IN. IT HAS 97,000 MILES ON IT. THE MAJOR PROBLEM WE HAD WITH THE VAN WAS WITH THE FRONT END. BOTH FORD AND OUR LOCAL TIRE DEALER HAVE TOLD US THAT BECAUSE THE VAN IS RAISED ROOF A… | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 116.7%ODI 11671852We rented a Class C RV based on a Ford E-Series chassis from El Monte RV. During our trip, we experienced two dangerous tire tread separations. The first incident occurred on the third day of our trip on the highway. The right rear tire's tread detached while driving at moderate speed (~55–60 mph), causing the tire to explode. The violent separation destroyed the wheel well area and shook the entire vehicle violently. Our RV contained a [XXX] child, and we were forced to stop on the shoulder in a dangerous situation. The second tire separati… | 00.0%No examples available for this selection. | 116.7%ODI 10002527CONSUMER STATED WHEN THE BRAKES WERE APPLIED, THE VEHICLE WOULD STEER TO THE LEFT.*JB | 00.0%No examples available for this selection. |
| Tires | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 1100.0%ODI 10731643 · 63,000 miI WAS DRIVING MY 1995 RV WITH A FORD E350 CHASSIS ON THE FREEWAY IN LAS VEGAS APPROXIMATELY FIVE MILES FROM HOME WHEN I NOTICED A SLIGHT VIBRATION. I TRAVELED ANOTHER FIVE MILES AND THE REAR LEFT OUTSIDE TIRE LOST IT'S TREAD AND BLEW OUT RESULTING IN DAMAGE TO THE WHEEL WELL AND DUMP HOSE STORAGE. THE OUTSIDE TEMPERATURE WAS 110 DEGREES. MY SPEED WAS APPROXIMATELY 55 MPH. THE TIRES ON THE VEHICLE WERE DELTA ESSENTIAL LT225/75 R16 AND WERE PURCHASED IN 2013. THEY HAVE BEEN DRIVEN 10,000 MILES AND VISUALLY APPEAR TO BE IN GOOD CONDITION. THE… | 233.3%ODI 10021919A TIRE BLEW OUT AND DAMAGED THE MOTOR HOME. FIRESTONE LT 225/75/16. PLEASE PROVIDE DETAILS. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 116.7%ODI 10643893 · 80,210 miONE OF OUR VANS' BCT JB42 FRONT TIRE BLEW UP LEAVING FROM A PARKED AREA WITHOUT GOING OVER ANY SHARP OBJECTS OR CURVES. FORTUNATELY NO ONE WAS HURT BUT IT COULD HAVE CAUSED A HUGE ACCIDENT ON THE ROAD. I CHECKED FOR RECALL ON THIS TIRE BUT IT WAS NOT... I WILL NOW HAVE TO REPLACE 12 OF THESE TIRES ON MY OTHER VEHICLES BECAUSE I CAN'T TAKE ANY MORE CHANCES WITH THESE TIRES ALTHOUGH THEY ARE IN DECENT CONDITIONS... I THINK SOMEONE NEEDS TO CHECK INTO THIS TIRE MODEL FOR FUTURE SAFETY. *TR | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
| Vehicle Speed Control | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 133.3%ODI 10705128 · 102,000 miON OCTOBER 9, 2009, PURSUANT TO FORD RECALL 05S28, A LOCAL FORD DEALER, DAVIES FORD, CHARLEROI, PENNSYLVANIA, INSTALLED A WIRING HARNESS ON MY VAN. ONLY FIVE DAYS LATER, WHILE MY VAN WAS PARKED, THE ENGINE TURNED OFF,AND THE KEYS REMOVED FROM THE IGNITION, MY VAN CAUGHT FIRE AND WAS COMPLETELY DESTROYED. AN EXPERT INSPECTED THE VAN AND DETERMINED THAT THE FIRE STARTED IN THE EXACT LOCATION WHERE THE MASTER CYLINDER AND SCDS WERE INSTALLED AND THAT THE FIRE WAS CAUSED BY A DEFECTIVE SCDS. THE DEALER PROMISED TO GIVE MA A VAN OF EQUAL VALUE OR … | 2100.0% | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
| Electrical System | 00.0%No examples available for this selection. | 1100.0%ODI 10011732NAR 03/13/2003 WHILE THE CONSUMER WAS PULLING OVER FOR GAS. SHE NOTICED THE VEHICLE WAS ON FIRE, BECAUSE SMOKE WAS COMING IN FROM THE INSIDE OF THE CAR. AS A RESULT OF THE FIRE, SOME INTERIOR AND PAINT DAMAGE OCCURRED. *CB *JB | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 116.7%ODI 10191462 · 9,793 miTL*THE CONTACT OWNS A 2002 FORD E-SERIES. THE CONTACT STATED THAT THE BOLTS ON THE FUSE BOX FAILED AND CAUSED THE VEHICLE'S WIRES TO BECOME EXPOSED. THE DEALER HAS NOT INSPECTED THE VEHICLE. THE ENGINE SIZE AND CORRECT VIN WERE UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 9,793. | 00.0%No examples available for this selection. |
| Electrical System:Wiring | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 116.7%ODI 10126208 · 100,000 miDT: FORD EXPEDITION. NOTHING WAS APPARENT BEFORE THE FAILURE. TWO MINUTES AFTER ARRIVING HOME THERE WAS AN EXPLOSION IN THE ENGINE COMPARTMENT. CONTACTED FORD, THE POLICE, AND THE FIRE DEPARTMENT. THE FIRE DEPARTMENT PUT THE FIRE OUT, AND SAID IT WAS IN THE ENGINE AREA WITH ELECTRICAL ARCING. FORD SAID THEY WERE GOING TO SEND AN INSPECTOR ON 3 DIFFERENT OCCASIONS, BUT NOW SAID THE CASE WAS CLOSED AND WILL NOT BE SEND AN INSPECTOR. *AK | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
| Engine | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 133.3%ODI 10705128 · 102,000 miON OCTOBER 9, 2009, PURSUANT TO FORD RECALL 05S28, A LOCAL FORD DEALER, DAVIES FORD, CHARLEROI, PENNSYLVANIA, INSTALLED A WIRING HARNESS ON MY VAN. ONLY FIVE DAYS LATER, WHILE MY VAN WAS PARKED, THE ENGINE TURNED OFF,AND THE KEYS REMOVED FROM THE IGNITION, MY VAN CAUGHT FIRE AND WAS COMPLETELY DESTROYED. AN EXPERT INSPECTED THE VAN AND DETERMINED THAT THE FIRE STARTED IN THE EXACT LOCATION WHERE THE MASTER CYLINDER AND SCDS WERE INSTALLED AND THAT THE FIRE WAS CAUSED BY A DEFECTIVE SCDS. THE DEALER PROMISED TO GIVE MA A VAN OF EQUAL VALUE OR … | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 150.0%ODI 10817714 · 199,000 miBLEW A SPARK PLUG OUT OF ENGINE 2ND ONE THAT HAS HAPPEN AND IT HAPPENS ALL THE TIME WITH THIS ENGINE | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
| Engine And Engine Cooling:Engine:Gasoline | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 150.0% | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 116.7%ODI 10171394 · 110,000 miI HAVE A 2000 FORD EXPEDITION THAT WHEN DRIVING, AS SOON AS THE LOW FUEL LIGHT COMES ON, THE ENGINE SHUTS OFF. I HAD SEVERAL OCCASIONS WHEN I AM LESS THAN A MILE FROM A GAS STATION, AND THE TRUCK HAS TROUBLE MAKING IT TO THE GAS STATION. THERE ARE SEVERAL INSTANCES WHEN MY SUV IS PARKED UP HILL AND IT HAS MORE THAN A QUARTER TANK OF GAS, AND IT HAS A HARD TIME STARTING. I HAVE TO PUT IT ON NEUTRAL, LET IT ROLL BACKWARDS AND PUT IT ON LEVEL SURFACE BEFORE IT CAN START AGAIN. RECENTLY IT HAS STARTED SHUTTING OFF WHEN I DRIVE, WITH A REASONABLE … | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
Darker cells indicate a larger share of submitted complaints. Components overlap. This measures complaint composition, not failure probability.
Median and middle 50% of usable owner-reported mileages. Ranges require at least five records.
| Component | Mileage range (25th–75th percentile) | Median | Usable records | Examples |
|---|---|---|---|---|
| Steering | Too few reports for a range | 65,000 mi | 3 (sparse) | ODI 11129461 · 28,900 miTHE STEERING WHEEL IS LOSE. THE TWO GAS TANKS DON'T WORK THE TURN SIGNAL U HAVE TO HOLD IT TO WITCH WAY YOUR TURNING. AND THE PULSATING IN THE BRAKE OR ROTOR IS FILLS PUSATING. THE BACK HEATER DON'T WORK. ODI 10610786 · 85,000 miVEHICLE SWAYS AND DRIFTS ON ROAD. EXCESSIVE FREE PLAY IN POWER STEERING GEAR BOX. STEERING GEAR BOX WAS REPLACED BUT WITH ORIGINAL EQUIPMENT CONDITION IS THE SOME. WHY WAS GEAR BOX NOT RECALLED WHEN TIRES WERE RECALLED? IS THERE AN UPGRADED PART THAT WILL SOLVE THE PROBLEM? ( SEE NHTSA REFERENCE #10382765) ALSO FORD TRUCK ENTHUSIASTS FORUMS - STEERING PROBLEMS. *TR ODI 10066235 · 65,000 miSTEERING COUPLER CAME LOOSE FROM STREERING BOX. DRIVER WAS DRIVING AT SLOW SPEED SO NO ACCIDENT VAN NEEDED BE TOWED IN FOR REPAIR. *AK |
| Tires | Too few reports for a range | 71,605 mi | 2 (sparse) | ODI 10731643 · 63,000 miI WAS DRIVING MY 1995 RV WITH A FORD E350 CHASSIS ON THE FREEWAY IN LAS VEGAS APPROXIMATELY FIVE MILES FROM HOME WHEN I NOTICED A SLIGHT VIBRATION. I TRAVELED ANOTHER FIVE MILES AND THE REAR LEFT OUTSIDE TIRE LOST IT'S TREAD AND BLEW OUT RESULTING IN DAMAGE TO THE WHEEL WELL AND DUMP HOSE STORAGE. THE OUTSIDE TEMPERATURE WAS 110 DEGREES. MY SPEED WAS APPROXIMATELY 55 MPH. THE TIRES ON THE VEHICLE WERE DELTA ESSENTIAL LT225/75 R16 AND WERE PURCHASED IN 2013. THEY HAVE BEEN DRIVEN 10,000 MILES AND VISUALLY APPEAR TO BE IN GOOD CONDITION. THE… ODI 10643893 · 80,210 miONE OF OUR VANS' BCT JB42 FRONT TIRE BLEW UP LEAVING FROM A PARKED AREA WITHOUT GOING OVER ANY SHARP OBJECTS OR CURVES. FORTUNATELY NO ONE WAS HURT BUT IT COULD HAVE CAUSED A HUGE ACCIDENT ON THE ROAD. I CHECKED FOR RECALL ON THIS TIRE BUT IT WAS NOT... I WILL NOW HAVE TO REPLACE 12 OF THESE TIRES ON MY OTHER VEHICLES BECAUSE I CAN'T TAKE ANY MORE CHANCES WITH THESE TIRES ALTHOUGH THEY ARE IN DECENT CONDITIONS... I THINK SOMEONE NEEDS TO CHECK INTO THIS TIRE MODEL FOR FUTURE SAFETY. *TR |
| Vehicle Speed Control | Too few reports for a range | 102,000 mi | 1 (sparse) | ODI 10705128 · 102,000 miON OCTOBER 9, 2009, PURSUANT TO FORD RECALL 05S28, A LOCAL FORD DEALER, DAVIES FORD, CHARLEROI, PENNSYLVANIA, INSTALLED A WIRING HARNESS ON MY VAN. ONLY FIVE DAYS LATER, WHILE MY VAN WAS PARKED, THE ENGINE TURNED OFF,AND THE KEYS REMOVED FROM THE IGNITION, MY VAN CAUGHT FIRE AND WAS COMPLETELY DESTROYED. AN EXPERT INSPECTED THE VAN AND DETERMINED THAT THE FIRE STARTED IN THE EXACT LOCATION WHERE THE MASTER CYLINDER AND SCDS WERE INSTALLED AND THAT THE FIRE WAS CAUSED BY A DEFECTIVE SCDS. THE DEALER PROMISED TO GIVE MA A VAN OF EQUAL VALUE OR … |
| Electrical System | Too few reports for a range | 9,793 mi | 1 (sparse) | ODI 10191462 · 9,793 miTL*THE CONTACT OWNS A 2002 FORD E-SERIES. THE CONTACT STATED THAT THE BOLTS ON THE FUSE BOX FAILED AND CAUSED THE VEHICLE'S WIRES TO BECOME EXPOSED. THE DEALER HAS NOT INSPECTED THE VEHICLE. THE ENGINE SIZE AND CORRECT VIN WERE UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 9,793. |
| Electrical System:Wiring | Too few reports for a range | 100,000 mi | 1 (sparse) | ODI 10126208 · 100,000 miDT: FORD EXPEDITION. NOTHING WAS APPARENT BEFORE THE FAILURE. TWO MINUTES AFTER ARRIVING HOME THERE WAS AN EXPLOSION IN THE ENGINE COMPARTMENT. CONTACTED FORD, THE POLICE, AND THE FIRE DEPARTMENT. THE FIRE DEPARTMENT PUT THE FIRE OUT, AND SAID IT WAS IN THE ENGINE AREA WITH ELECTRICAL ARCING. FORD SAID THEY WERE GOING TO SEND AN INSPECTOR ON 3 DIFFERENT OCCASIONS, BUT NOW SAID THE CASE WAS CLOSED AND WILL NOT BE SEND AN INSPECTOR. *AK |
| Engine | Too few reports for a range | 150,500 mi | 2 (sparse) | ODI 10705128 · 102,000 miON OCTOBER 9, 2009, PURSUANT TO FORD RECALL 05S28, A LOCAL FORD DEALER, DAVIES FORD, CHARLEROI, PENNSYLVANIA, INSTALLED A WIRING HARNESS ON MY VAN. ONLY FIVE DAYS LATER, WHILE MY VAN WAS PARKED, THE ENGINE TURNED OFF,AND THE KEYS REMOVED FROM THE IGNITION, MY VAN CAUGHT FIRE AND WAS COMPLETELY DESTROYED. AN EXPERT INSPECTED THE VAN AND DETERMINED THAT THE FIRE STARTED IN THE EXACT LOCATION WHERE THE MASTER CYLINDER AND SCDS WERE INSTALLED AND THAT THE FIRE WAS CAUSED BY A DEFECTIVE SCDS. THE DEALER PROMISED TO GIVE MA A VAN OF EQUAL VALUE OR … ODI 10817714 · 199,000 miBLEW A SPARK PLUG OUT OF ENGINE 2ND ONE THAT HAS HAPPEN AND IT HAPPENS ALL THE TIME WITH THIS ENGINE |
| Engine And Engine Cooling:Engine:Gasoline | Too few reports for a range | 110,000 mi | 1 (sparse) | ODI 10171394 · 110,000 miI HAVE A 2000 FORD EXPEDITION THAT WHEN DRIVING, AS SOON AS THE LOW FUEL LIGHT COMES ON, THE ENGINE SHUTS OFF. I HAD SEVERAL OCCASIONS WHEN I AM LESS THAN A MILE FROM A GAS STATION, AND THE TRUCK HAS TROUBLE MAKING IT TO THE GAS STATION. THERE ARE SEVERAL INSTANCES WHEN MY SUV IS PARKED UP HILL AND IT HAS MORE THAN A QUARTER TANK OF GAS, AND IT HAS A HARD TIME STARTING. I HAVE TO PUT IT ON NEUTRAL, LET IT ROLL BACKWARDS AND PUT IT ON LEVEL SURFACE BEFORE IT CAN START AGAIN. RECENTLY IT HAS STARTED SHUTTING OFF WHEN I DRIVE, WITH A REASONABLE … |
Explore monthly filing activity alongside recall announcements. Up to ten years of monthly history is available.
Solid line: filed complaints. Dashed amber lines: recall announcement dates for this vehicle selection; markers include all recall components. The latest month is partial. Temporal proximity does not establish causation.
| Month | Complaints | Campaigns announced | Examples |
|---|---|---|---|
| 2024-11 | 0 | None | No examples available for this selection. |
| 2024-12 | 0 | None | No examples available for this selection. |
| 2025-01 | 0 | None | No examples available for this selection. |
| 2025-02 | 0 | None | No examples available for this selection. |
| 2025-03 | 0 | None | No examples available for this selection. |
| 2025-04 | 0 | None | No examples available for this selection. |
| 2025-05 | 0 | None | No examples available for this selection. |
| 2025-06 | 0 | None | No examples available for this selection. |
| 2025-07 | 1 | None | ODI 11671852We rented a Class C RV based on a Ford E-Series chassis from El Monte RV. During our trip, we experienced two dangerous tire tread separations. The first incident occurred on the third day of our trip on the highway. The right rear tire's tread detached while driving at moderate speed (~55–60 mph), causing the tire to explode. The violent separation destroyed the wheel well area and shook the entire vehicle violently. Our RV contained a [XXX] child, and we were forced to stop on the shoulder in a dangerous situation. The second tire separati… |
| 2025-08 | 0 | None | No examples available for this selection. |
| 2025-09 | 0 | None | No examples available for this selection. |
| 2025-10 | 0 | None | No examples available for this selection. |
| 2025-11 | 0 | None | No examples available for this selection. |
| 2025-12 | 0 | None | No examples available for this selection. |
| 2026-01 | 0 | None | No examples available for this selection. |
| 2026-02 | 0 | None | No examples available for this selection. |
| 2026-03 | 0 | None | No examples available for this selection. |
| 2026-04 | 0 | None | No examples available for this selection. |
| 2026-05 | 0 | None | No examples available for this selection. |
| 2026-06 | 0 | None | No examples available for this selection. |
| 2026-07 | 0 | None | No examples available for this selection. |
| 2026-08 | 0 | None | No examples available for this selection. |
| 2026-09 | 0 | None | No examples available for this selection. |
| 2026-10 (partial) | 0 | None | No examples available for this selection. |
Complete months in the latest six months with at least 10 complaints, at least twice the preceding 12-month average, and at least three square-root deviations above that average.
This is a descriptive screening rule, not a statistical defect finding. Publicity and reporting changes can increase submissions.
No complete months meet the spike thresholds for this selection.
Model-wide cumulative reports during the first three or five calendar years, starting with the model year (age 0). Only fully elapsed windows are compared.
2002: 2 complaints · 2003: 1 complaints
| Model year | Through age 0 | Through age 1 | Through age 2 |
|---|---|---|---|
| 2002 | 2 | 2 | 2 |
| 2003 | 0 | 1 | 1 |
| Year | Incident dates used | Filing date fallbacks | Excluded dates |
|---|---|---|---|
| 2002 | 6 | 0 | 0 |
| 2003 | 4 | 0 | 0 |
Incident date is preferred when valid and no later than filing; otherwise filing date is used. Model year approximates age. Equal observation time does not adjust for sales, distance driven or reporting delays. One complaint linked to multiple model years can appear in each cohort.
Each cell counts unique complaints naming both components. Open a nonzero cell for examples.
| Component | Steering | Suspension | Tires | Vehicle Speed Control | Electrical System | Electrical System:Wiring | Engine | Engine And Engine Cooling:Engine:Gasoline |
|---|---|---|---|---|---|---|---|---|
| Steering | — | 1ODI 10070333WE PURCHASED A 1997 FORD E150 RAISED ROOF CONVERSION VAN FROM JIM O'NEAL FORD IN SELLERSBURG, INDIANA JUST ACROSS THE BORDER FROM LOUISVILLE, KENTUCKY. THE CONVERSION WAS BY SUPERIOR IN LOUISVILLE. WE PURCHASED THAT PARTICULAR VAN BECAUSE IT WAS HIGHLY RATED BY FORD MOTOR COMPANY AS A CONVERSION COMPANY. WE DROVE THE VAN FOR SIX YEARS AND JUST RECENTLY TRADED IT IN. IT HAS 97,000 MILES ON IT. THE MAJOR PROBLEM WE HAD WITH THE VAN WAS WITH THE FRONT END. BOTH FORD AND OUR LOCAL TIRE DEALER HAVE TOLD US THAT BECAUSE THE VAN IS RAISED ROOF A… | 1ODI 10070333WE PURCHASED A 1997 FORD E150 RAISED ROOF CONVERSION VAN FROM JIM O'NEAL FORD IN SELLERSBURG, INDIANA JUST ACROSS THE BORDER FROM LOUISVILLE, KENTUCKY. THE CONVERSION WAS BY SUPERIOR IN LOUISVILLE. WE PURCHASED THAT PARTICULAR VAN BECAUSE IT WAS HIGHLY RATED BY FORD MOTOR COMPANY AS A CONVERSION COMPANY. WE DROVE THE VAN FOR SIX YEARS AND JUST RECENTLY TRADED IT IN. IT HAS 97,000 MILES ON IT. THE MAJOR PROBLEM WE HAD WITH THE VAN WAS WITH THE FRONT END. BOTH FORD AND OUR LOCAL TIRE DEALER HAVE TOLD US THAT BECAUSE THE VAN IS RAISED ROOF A… | 0 | 0 | 0 | 0 | 0 |
| Suspension | 1ODI 10070333WE PURCHASED A 1997 FORD E150 RAISED ROOF CONVERSION VAN FROM JIM O'NEAL FORD IN SELLERSBURG, INDIANA JUST ACROSS THE BORDER FROM LOUISVILLE, KENTUCKY. THE CONVERSION WAS BY SUPERIOR IN LOUISVILLE. WE PURCHASED THAT PARTICULAR VAN BECAUSE IT WAS HIGHLY RATED BY FORD MOTOR COMPANY AS A CONVERSION COMPANY. WE DROVE THE VAN FOR SIX YEARS AND JUST RECENTLY TRADED IT IN. IT HAS 97,000 MILES ON IT. THE MAJOR PROBLEM WE HAD WITH THE VAN WAS WITH THE FRONT END. BOTH FORD AND OUR LOCAL TIRE DEALER HAVE TOLD US THAT BECAUSE THE VAN IS RAISED ROOF A… | — | 1ODI 10070333WE PURCHASED A 1997 FORD E150 RAISED ROOF CONVERSION VAN FROM JIM O'NEAL FORD IN SELLERSBURG, INDIANA JUST ACROSS THE BORDER FROM LOUISVILLE, KENTUCKY. THE CONVERSION WAS BY SUPERIOR IN LOUISVILLE. WE PURCHASED THAT PARTICULAR VAN BECAUSE IT WAS HIGHLY RATED BY FORD MOTOR COMPANY AS A CONVERSION COMPANY. WE DROVE THE VAN FOR SIX YEARS AND JUST RECENTLY TRADED IT IN. IT HAS 97,000 MILES ON IT. THE MAJOR PROBLEM WE HAD WITH THE VAN WAS WITH THE FRONT END. BOTH FORD AND OUR LOCAL TIRE DEALER HAVE TOLD US THAT BECAUSE THE VAN IS RAISED ROOF A… | 0 | 0 | 0 | 0 | 0 |
| Tires | 1ODI 10070333WE PURCHASED A 1997 FORD E150 RAISED ROOF CONVERSION VAN FROM JIM O'NEAL FORD IN SELLERSBURG, INDIANA JUST ACROSS THE BORDER FROM LOUISVILLE, KENTUCKY. THE CONVERSION WAS BY SUPERIOR IN LOUISVILLE. WE PURCHASED THAT PARTICULAR VAN BECAUSE IT WAS HIGHLY RATED BY FORD MOTOR COMPANY AS A CONVERSION COMPANY. WE DROVE THE VAN FOR SIX YEARS AND JUST RECENTLY TRADED IT IN. IT HAS 97,000 MILES ON IT. THE MAJOR PROBLEM WE HAD WITH THE VAN WAS WITH THE FRONT END. BOTH FORD AND OUR LOCAL TIRE DEALER HAVE TOLD US THAT BECAUSE THE VAN IS RAISED ROOF A… | 1ODI 10070333WE PURCHASED A 1997 FORD E150 RAISED ROOF CONVERSION VAN FROM JIM O'NEAL FORD IN SELLERSBURG, INDIANA JUST ACROSS THE BORDER FROM LOUISVILLE, KENTUCKY. THE CONVERSION WAS BY SUPERIOR IN LOUISVILLE. WE PURCHASED THAT PARTICULAR VAN BECAUSE IT WAS HIGHLY RATED BY FORD MOTOR COMPANY AS A CONVERSION COMPANY. WE DROVE THE VAN FOR SIX YEARS AND JUST RECENTLY TRADED IT IN. IT HAS 97,000 MILES ON IT. THE MAJOR PROBLEM WE HAD WITH THE VAN WAS WITH THE FRONT END. BOTH FORD AND OUR LOCAL TIRE DEALER HAVE TOLD US THAT BECAUSE THE VAN IS RAISED ROOF A… | — | 0 | 0 | 0 | 0 | 0 |
| Vehicle Speed Control | 0 | 0 | 0 | — | 0 | 0 | 1ODI 10705128 · 102,000 miON OCTOBER 9, 2009, PURSUANT TO FORD RECALL 05S28, A LOCAL FORD DEALER, DAVIES FORD, CHARLEROI, PENNSYLVANIA, INSTALLED A WIRING HARNESS ON MY VAN. ONLY FIVE DAYS LATER, WHILE MY VAN WAS PARKED, THE ENGINE TURNED OFF,AND THE KEYS REMOVED FROM THE IGNITION, MY VAN CAUGHT FIRE AND WAS COMPLETELY DESTROYED. AN EXPERT INSPECTED THE VAN AND DETERMINED THAT THE FIRE STARTED IN THE EXACT LOCATION WHERE THE MASTER CYLINDER AND SCDS WERE INSTALLED AND THAT THE FIRE WAS CAUSED BY A DEFECTIVE SCDS. THE DEALER PROMISED TO GIVE MA A VAN OF EQUAL VALUE OR … | 1 |
| Electrical System | 0 | 0 | 0 | 0 | — | 0 | 0 | 0 |
| Electrical System:Wiring | 0 | 0 | 0 | 0 | 0 | — | 0 | 0 |
| Engine | 0 | 0 | 0 | 1ODI 10705128 · 102,000 miON OCTOBER 9, 2009, PURSUANT TO FORD RECALL 05S28, A LOCAL FORD DEALER, DAVIES FORD, CHARLEROI, PENNSYLVANIA, INSTALLED A WIRING HARNESS ON MY VAN. ONLY FIVE DAYS LATER, WHILE MY VAN WAS PARKED, THE ENGINE TURNED OFF,AND THE KEYS REMOVED FROM THE IGNITION, MY VAN CAUGHT FIRE AND WAS COMPLETELY DESTROYED. AN EXPERT INSPECTED THE VAN AND DETERMINED THAT THE FIRE STARTED IN THE EXACT LOCATION WHERE THE MASTER CYLINDER AND SCDS WERE INSTALLED AND THAT THE FIRE WAS CAUSED BY A DEFECTIVE SCDS. THE DEALER PROMISED TO GIVE MA A VAN OF EQUAL VALUE OR … | 0 | 0 | — | 0 |
| Engine And Engine Cooling:Engine:Gasoline | 0 | 0 | 0 | 1 | 0 | 0 | 0 | — |
Co-reporting does not establish that one component caused another concern.
Specific keyword mentions beyond broad component labels. Matching includes negations and comparisons and does not confirm a diagnosis.
3 patterns with matching reports.
1 mentions · 2.1% of complaints
Median mileage: Unavailable (0 usable records).
AFTER A RAINY STORM AND STRONG GUSTY WINDS VEHICLE CAUGHT ON FIRE; ALSO, BATTERY DRAINED OVERNIGHT AND BUZZER RANG THROUGH SPEAKER UPON OPENING DOOR.*AK
\b(parasitic drain|battery drain\w*|dead battery|won.t start|would not start|no.start)\b1 mentions · 2.1% of complaints
Median mileage: 85,000 mi (1 usable records).
VEHICLE SWAYS AND DRIFTS ON ROAD. EXCESSIVE FREE PLAY IN POWER STEERING GEAR BOX. STEERING GEAR BOX WAS REPLACED BUT WITH ORIGINAL EQUIPMENT CONDITION IS THE SOME. WHY WAS GEAR BOX NOT RECALLED WHEN TIRES WERE RECALLED? IS THERE AN UPGRADED PART THAT WILL SOLVE THE PROBLEM? ( SEE NHTSA REFERENCE #10382765) ALSO FORD TRUCK ENTHUSIASTS FORUMS - STEERING PROBLEMS. *TR
\b(power steer\w*|steering assist\w*|steering lock\w*|steering wheel lock\w*)\b1 mentions · 2.1% of complaints
Median mileage: 20,000 mi (1 usable records).
WHILE BRAKING 50 MPH BRAKE WARNING LIGHT ILLUMINATED. THIS CAUSED EXTENDED STOPPING DISTANCE. CONSUMER USED THE EMERGENCY BRAKE TO STOP THE VEHICLE. DEALERSHIP WAS NOTIFED, BUT DID NOT RESOLVE THE PROBLEM.*AK
\b(warning light\w*|check engine|dashboard warning\w*|malfunction indicator)\b