Ford F-750 recalls by model year

Reported: 2003-08-05 (August 5, 2003) · Model years: 2004

CERTAIN MEDIUM DUTY CHASSIS CABS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." THE TIRE PLACARD LABEL AND INCOMPLETE VEHICLE LABEL MAY HAVE INCORRECT METRIC (KPA) TIRE PRESSURE INFORMATION (TIRE INFLATION PRESSURE SHOWN IN ENGLISH UNITS (PSI) IS CORRECT), AND TRANSPOSED TIRE SIZE AND RIM SIZE INFORMATION.

Remedy: OWNERS WILL BE SENT CORRECTED LABELS WITH INSTRUCTIONS FOR INSTALLATION. OWNER NOTIFICATION BEGAN AUGUST 8, 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.

Reported: 2003-08-28 (August 28, 2003) · Model years: 2004

CERTAIN MEDIUM DUTY CHASSIS CABS FAIL TO COMPLY TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, "AIR BRAKE SYSTEMS." THE AIR BRAKE LINES MAY BE MISROUTED BETWEEN THE PRIMARY AND SECONDARY RESERVOIR TANKS OF THE AIR BRAKE SYSTEM.

Consequence: IF THE AIR BRAKE LINES ARE MISROUTED, AND THE AIR BRAKE SYSTEM EXPERIENCES A LOSS OF AIR FROM THE PRIMARY AIR TANK, THE VEHICLE WILL NOT HAVE SERVICE AIR BAKE FUNCTION, INCREASING THE RISK OF A CRASH.

Remedy: FORD WILL INSPECT THE AIR BRAKE LINE ROUTING AND IF NECESSARY, REPAIR THE VEHICLE. OWNER NOTIFICATION BEGAN ON SEPTEMBER 12, 2003. OWNERS SHOULD CONTACT FORD AT 1-800-248-0186.

Reported: 2009-12-15 (December 15, 2009) · Model years: 2009

FORD IS RECALLING MODEL YEARS 2009 F-650 AND F-750 TRUCKS. THE CHASSIS WIRE HARNESS MAY HAVE BEEN ASSEMBLED WITHOUT A CONNECTOR SEAL IF THIS SEAL IS MISSING, THE CONNECTOR TERMINALS MAY CORRODE AFFECTING THE PROPER ILLUMINATION OF THE VEHICLE'S REAR BRAKE LAMPS, TAIL LAMPS, TURN SIGNAL LAMPS OR TRAILER LAMPS (IF EQUIPPED.) ALSO, THE FUNCTION OF THE ANTI-LOCK BRAKE SYSTEM MAY BE AFFECTED.

Consequence: INOPERATIVE LAMPS MAY INCREASE THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT THE CONNECTOR AND REPAIR THE MAIN AND REAR CHASSIS WIRE HARNESS IF NECESSARY. A MISSING SEAL WILL BE REPLACED AND ELECTRICAL GREASE APPLIED TO PREVENT FUTURE CORROSION. THE SAFETY RECALL BEGAN ON DECEMBER 16, 2009. OWNERS MAY CONTACT FORD AT 1-866-436-7332 OR THROUGH THE INTERNET AT WWW.FORDOWNER.COM.

Reported: 2009-12-15 (December 15, 2009) · Model years: 2010

FORD IS RECALLING MODEL YEAR 2010 F-650 AND F-750 TRUCKS. THE S-CAM TUBES ON THE AIR BRAKE AXLE ASSEMBLIES WERE NOT GREASED AND CORROSION MAY DEVELOP OVER TIME, WHICH MAY RESTRICT RELEASE OF THE SERVICE BRAKE AT THE AFFECTED WHEEL.

Consequence: IF THIS OCCURS, IT COULD CAUSE EXCESSIVE BRAKE TEMPERATURES, NOISE, BRAKE FADE, ODOR, SMOKE, BRAKE PULL AND POSSIBLY LONGER STOPPING DISTANCES WHICH COULD INCREASE THE RISK OF A CRASH.

Remedy: DEALERS WILL LUBRICATE THE S-CAM TUBE AND CHECK THE S-CAM FOR FREE MOVEMENT AT ALL FOUR WHEEL LOCATIONS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 16, 2009. OWNERS MAY CONTACT FORD AT 1-866-436-7332 OR THROUGH THE INTERNET AT WWW.FORDOWNER.COM.

Reported: 2011-05-03 (May 3, 2011) · Model years: 2011

FORD IS RECALLING CERTAIN MODEL YEAR 2011 F-650 AND F-750 TRUCKS, EQUIPPED WITH AIR BRAKES AND A TRAILER PACKAGE OR TRACTOR PACKAGE, FOR AN INCORRECTLY PROGRAMMED ABS MODULE. AS SUCH, THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, "AIR BRAKE SYSTEMS (ABS)."

Consequence: AN AFFECTED VEHICLE MAY NOT DISPLAY A TRAILER ABS FAULT IN THE CAB OF THE TRUCK WARNING THE DRIVER OF AN EXISTING TRAILER ABS FAILURE. SUCH AN ABS FAILURE MAY RESULT IN TRAILER BRAKE LOCK-UP, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL NOTIFY OWNERS AND REPLACE THE ABS MODULE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 18, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.

Reported: 2012-03-07 (March 7, 2012) · Model years: 2011

FORD IS RECALLING CERTAIN MODEL YEAR 2011 F-650 AND F-750 TRUCKS, MANUFACTURED FROM DECEMBER 3, 2010, THROUGH DECEMBER 20, 2011, EQUIPPED WITH BENDIX ATR-6 ANTILOCK TRACTION RELAY VALVES. IN EXTREMELY COLD CONDITIONS, THE BENDIX RELAY VALVES MAY POTENTIALLY DEVELOP INTERNAL LEAKAGE. INTERNAL LEAKAGE CAN LEAD TO AIR PRESSURE BEING DELIVERED TO AFFECTED PRIMARY OR SECONDARY BRAKE CAUSING CONTINUOUS BRAKE APPLICATION.

Consequence: UNEXPECTED CONTINUOUS BRAKE APPLICATION CAN CAUSE THE BRAKES TO OVERHEAT AND LEAD TO A FIRE. UNEXPECTED CONTINUOUS BRAKE APPLICATION CAN CAUSE THE DRIVER TO LOSE CONTROL OF THE VEHICLE, INCREASING THE RISK OF A CRASH. ALSO, THE BRAKES MAY BE APPLIED WITHOUT ILLUMINATING THE BRAKE LIGHTS, FAILING TO GIVE PROPER WARNING TO OTHER DRIVERS.

Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL INSTALL A BENDIX ATR-6 TRACTION RELAY VALVE KIT. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 12, 2012. OWNERS MAY CONTACT FORD MOTOR COMPANY AT 1-800-392-3673.

Reported: 2014-04-08 (April 8, 2014) · Model years: 2011

DUECO Inc. (DUECO), a manufacturer of utility vehicles, is recalling certain Dueco-modified model year 2009-2011 International 4300, 2010 International 4400, 2009 and 2011 International 7400, 2010 Freightliner M2, 2008-2009 GMC C5500, and 2011 Ford F-750 vehicles, equipped with Sure Power DC-DC converters containing a particular epoxy sealing, aka 'potting', compound. The specific potting compound used in the subject products for insulation was found to be capable of conducting electricity after being exposed to heat.

Consequence: Once electrically conductive, the material is capable of melting and burning, increasing the risk of a fire.

Remedy: DUECO will notify owners, and Sure Power will replace the converters, free of charge. The recall began on May 29, 2014. Owners may contact Dueco at 1-800-558-4004.

Reported: 2012-07-06 (July 6, 2012) · Model years: 2012

FORD IS RECALLING CERTAIN MODEL YEAR 2012 F-650 AND F-750 VEHICLES MANUFACTURED FROM FEBRUARY 1, 2012 THROUGH MARCH 16, 2012. THE CLEAR AND BLACK PRIMER MAY BE MISSING ON CERTAIN WINDSHIELDS WHICH MAY RESULT IN AN INSUFFICIENT BOND BETWEEN THE GLASS AND CAB STRUCTURE.

Consequence: AN INSUFFICIENT BOND MAY RESULT IN A SEPARATION OF THE WINDSHIELD FROM THE CAB, INCREASING THE RISK OF PERSONAL INJURY OR DEATH.

Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL REMOVE AND INSPECT THE WINDSHIELD FOR URETHANE ADHESION, AND REPLACE OR REINSTALL THE WINDSHIELD AS REQUIRED, FREE OF CHARGE. THE RECALL BEGAN ON JULY 31, 2012. OWNERS MAY CONTACT FORD AT 1-866-436-7332.

Reported: 2019-06-07 (June 7, 2019) · Model years: 2017, 2018

Mickey Truck Bodies, Inc. (Mickey Truck Bodies) is recalling certain 2017-2018 Ford F-750 based vehicles equipped with ASA Electronics Voyager monitors used to display the back-up camera image. The affected monitors may revert back to the factory default settings which may cause the camera image to be reversed.

Consequence: The driver may inadvertently turn the wrong direction to avoid an object behind the vehicle, increasing the risk of a crash.

Remedy: Mickey Truck Bodies will work with ASA Electronics to notify owners, and provide a remedy to keep the image from reversing, free of charge. The recall began May 9, 2019. Owners may contact ASA Electronics customer service at 1-800-384-4400 or Mickey Truck Bodies at 1-336-882-6806.

Reported: 2020-11-10 (November 10, 2020) · Model years: 2021

Ford Motor Company (Ford) is recalling certain 2021 F-650 and F-750 vehicles equipped with 7.3L gas engines. The transmission oil cooler line may contact the air conditioning compressor pulley, possibly causing a transmission fluid leak.

Consequence: Leaking transmission fluid may contact hot engine components, increasing the risk of an engine compartment fire.

Remedy: Ford will notify owners, and dealers will inspect transmission oil cooler lines for proper orientation and damage, correcting the lines and replacing any that are damaged, free of charge. The recall began December 21, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S66.

Reported: 2022-01-14 (January 14, 2022) · Model years: 2021

Ford Motor Company (Ford) is recalling certain 2021 Super Duty F-250, F-350, F-450, F-550, F-600, and Medium Duty F-650 and F-750 vehicles equipped with 6.7L diesel engines. A small void may be present in the top-center of the vehicle's underhood secondary fuel filter cap, which may progress to a pinhole over time, allowing fuel to leak from the top of the secondary fuel filter.

Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire or injury.

Remedy: Dealers will replace the primary and secondary fuel filters, free of charge. Owner notification letters were mailed January 28, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S01.

Reported: 2024-12-20 (December 20, 2024) · Model years: 2021, 2022

Ford Motor Company (Ford) is recalling certain 2020-2022 F-Super Duty F250, F350, F450, F550, F600, and 2021-2022 F-650, F750 vehicles. Biodiesel deposits may form on the pump drivetrain roller components, which could lead to failure of the high pressure fuel pump.

Consequence: High pressure fuel pump failure can cause a loss of drive power, increasing the risk of a crash.

Remedy: Dealers will update the powertrain control module (PCM) and Transmission Control Module (TCM) software, free of charge. Owner notification letters were mailed January 23, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S78.

Reported: 2026-03-17 (March 17, 2026) · Model years: 2022

Ford Motor Company (Ford) is recalling certain 2020-2022 F-Super Duty F250, F350, F450, F550, 2021-2022 F600, and 2022 F750 vehicles previously repaired incorrectly under recall number 24V957. Biodiesel deposits may form on the pump drivetrain roller components, which could lead to failure of the high pressure fuel pump.

Consequence: High pressure fuel pump failure can cause a loss of drive power, increasing the risk of a crash.

Remedy: Dealers will update the powertrain control module (PCM) software, free of charge. Owner notification letters were mailed mailed April 7, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S17. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 18, 2026.