| Power Train | 4026.7%ODI 11467582Driving down road at 45 mph as usual. Car suddenly shudders and as I pull to a stop car is stuck in neutral. Will not receive gas. Suddenly lurches into first gear, almost making me hit who is in front of me. I pull into center lane and the car is frozen and won't move. I restart the car and it stays stuck in first gear revving high. I limp it home given I'm a few minutes away. Could have caused a serious incident. Look up ODI 11467582 at NHTSA ↗ | 1721.0%ODI 11592535Traveling 350 miles for work, my Maverick was at 2400 miles when both of my front cv boots were spewing grease all over the underside of the truck, stranding me away from home. The truck would shake violently when accelerating to the point I had to pull over. With all the destruction on the underside of the truck, the local dealer (not preferred) informed me that “they didn’t know who or when” but a missing clamp on one side and a torn boot on the other and denied me from claiming my warranty at 2400 miles. There were no warning lights on the d… Look up ODI 11592535 at NHTSA ↗ | 1825.0%ODI 11631987Unknown, My 2024 Ford Maverick has now twice got stuck in reverse (shifter indicates it is in reverse) though the dash shows park and I was unable to start the truck after removing my key and waiting a few moments it would act normal and let me start my truck. The last time it happened I was in the dealer lot and told my sales representative but we couldn’t replicate the problem he said next time it happens to record it and see if it becomes a trend that it would be covered under warranty but until it is replicable they could not do anything I … Look up ODI 11631987 at NHTSA ↗ | 625.0%ODI 116873032025 2.0l Maverick 8f-35 auto trans. on cold start after sitting overnight transmission hesitates to engage and/or shifts harshly on 1st drive of the day so far. Most noticeable on 1-2 upshift. Feels like engine rpm flares or transmission skips before changing gear. Conditions repeat almost daily on first drive from cold start. I am concerned about long-term transmission damage and safety when pulling into traffic. I'm aware this and other issues have been acknowledged by Ford in prior TSBs-the same 8f-35 transmission has rough shifting in 2022… Look up ODI 11687303 at NHTSA ↗ | 00.0%No examples available for this selection. |
|---|
| Electrical System | 3825.3%ODI 11448618Since the date of purchase (10/29/21) I am unable to change/set FM stations. Apps (ie: iHeart, Spotify) and voice command work intermittently. Apps will not work unless phone is plugged in. 911 assist will not work if not paired and connected to a Bluetooth enabled and compatible cell phone (see pg. 59 2022 Maverick owner’s manual). Unsure if lane keeping assistance is working properly. Vehicle was brought to Sam Galloway Ford on 10/30/21. Per Sam Galloway Ford: “Ford is aware of these problems. It is a ‘hardware’ issue.” Look up ODI 11448618 at NHTSA ↗ | 1518.5%ODI 11529197Driving 55-60mph, engine dies, power steering is lost, no throttle response, brake system failure messages every 500-1000ft of driving at any speeds. Battery terminal melted, wiring harness needs to be replaced to junction box with upgraded part. Model : 2023 Lariat Maverick Miles: 1030 Colors: Area 51/desert brown Luxury package Rumble strips saved my life. Look up ODI 11529197 at NHTSA ↗ | 1318.1%ODI 11619446Upon exiting my garage I always stop to close the door. My driveway has incline. I begin to roll back, hit the breaks several times with no engagement, begin pumping the brake pedal several times, no response. Continued to roll in reverse going across the street and hit neighbor's park car in their driveway. Police Officer noted that brake pedal was very low upon applying brakes and a hiss sound of like a vacuum or pressure lost. Reported a claim to insurance company. I never observed any indication of faults. Had truck toed to Greiner Fo… Look up ODI 11619446 at NHTSA ↗ | 520.8%ODI 11641826Purchased vehicle new and after 3 days the power steering became inoperable as well as traction control , hillstart assist and showed that the fowrad camers was in default . Look up ODI 11641826 at NHTSA ↗ | 240.0%ODI 11744344Description On your vehicle, the instrument panel ip upper section may detach from the passenger air bag chute doors during air bag deployment. The airbag is expected to otherwise deploy in position and restrain the occupant as designed. Safety Risk In the event of a crash in which the vehicle deploys the passenger airbag, a part of the ip upper section may detach and strike a vehicle occupant, increasing the risk of injury. Remedy Parts are available to repair your vehicle. Ford Motor Company has authorized your dealer to replace the ip u… Look up ODI 11744344 at NHTSA ↗ |
|---|
| Unknown Or Other | 2315.3%ODI 11448618Since the date of purchase (10/29/21) I am unable to change/set FM stations. Apps (ie: iHeart, Spotify) and voice command work intermittently. Apps will not work unless phone is plugged in. 911 assist will not work if not paired and connected to a Bluetooth enabled and compatible cell phone (see pg. 59 2022 Maverick owner’s manual). Unsure if lane keeping assistance is working properly. Vehicle was brought to Sam Galloway Ford on 10/30/21. Per Sam Galloway Ford: “Ford is aware of these problems. It is a ‘hardware’ issue.” Look up ODI 11448618 at NHTSA ↗ | 1214.8%ODI 11516067Windshield will groan and shift when driving , sound is always present and gets louder on uneven roads and bum. Ford stated it was a normal sounds, several maverick owners have had this problem Look up ODI 11516067 at NHTSA ↗ | 1419.4%ODI 11607634At certain times, the touch screen will freeze, specifically, it had frozen on the navigation, which also didn't allow the back up camera to work/be displayed. The screen also got bery hot to the touch. This was about a 90° day. This has happened on several occasions. I have seen an almost exact problem on the maverick forum here. [XXX] And was compelled to also make a report to the nhtsa. I have a scheduled service appointment this coming Monday, August 12. So we will see how that goes. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFOR… Look up ODI 11607634 at NHTSA ↗ | 14.2%ODI 11679489Recall data refreshed on Aug 09,2025 0 Unrepaired Recalls associated with this VIN for 2025 Maverick Please update the following reported RECALL to investor notifications forwarded for NHTSA: 2025 Maverick Safety Recalls* Securing the passenger airbag disable indicator padi lamp to the instrument bezel Recall incomplete Block heater element replacement Recall incomplete Please BROADCAST for NHTSA as amber alert for HIGHWAY AND SAFETY control Look up ODI 11679489 at NHTSA ↗ | 240.0%ODI 11741973The info screen, Instrument cluster and backup camera are very dark, it's so dark you can't see the fuel level and engine temperature level, if I switch the headlamp switch to off the screen gets brighter in auto mode its dark, lately it's been flickering and going bright to dark. been to dealer 2x they say," no updates available, no stored codes, lights operating as designed no issues found'. I have checked other vehicles 2026 same year model and their instrument cluster and backup camera and info screen are very bright and clearly visible. I… Look up ODI 11741973 at NHTSA ↗ |
|---|
| Engine | 1610.7%ODI 11546175This vehicle was purchased in 2021 with a 3 year 36k mile warranty. At 39k miles the truck has started to shut off randomly while driving. It has put us in very dangerous situations and it happens multiple times every day. The vehicle will be driving down the road and suddenly shut off. It will not switch to neutral so cannot be pulled off the road. It will not turn on for at least 20 minutes so we get stuck in the middle of the road. Sometimes it will turn back on but other times it has to be jumped. Ford is telling us that any repairs will no… Look up ODI 11546175 at NHTSA ↗ | 78.6%ODI 116137692023 Ford Maverick 2.0L engine current mileage 5300 Noticed oil leak on top of engine valve cover. Ford Mechanic stated there are (3) current service related engine leak issues with Maverick. (1) Plastic valve cover cracked (2) Turbo Oil leak (3) Timing Cover Leak. Mechanic stated a die test will need to be performed. After review of online forums, this appears to be a more common issue and can cause engine fire, especially since High Pressure fuel pump is also located on top of the engine. With Ford spreading repairs across three known issu… Look up ODI 11613769 at NHTSA ↗ | 811.1%ODI 11622043The engine has had counts of misfire in all 4 cylinders, since 1 week after I bought this brand-new pickup truck. The misfire counts are getting more and more, although there is NOT any warning codes, nor loss of power. Look up ODI 11622043 at NHTSA ↗ | 625.0%ODI 11671635 · 3,400 miThe contact owned a 2025 Ford Maverick. The contact stated that while the vehicle was parked in her residence's driveway at night, the vehicle had caught fire. The contact stated that she saw that flames had started showing under the vehicle near the front passenger side. The contact stated that the flames spread to the rear of the vehicle, and she heard and felt two loud explosions. The vehicle was fully engulfed in flames and had also started a fire in another vehicle parked near it, as well as started a fire on the side of the contact's resi… Look up ODI 11671635 at NHTSA ↗ | 00.0%No examples available for this selection. |
|---|
| Service Brakes | 96.0%ODI 11464070EL DIA 21 DE MARZO DEL 2022 LLEGANDO A MI CASA Y PARA SER BIEN ESPECIFICA FRENTE A MI CASA ME ESTABA ACOMODANDO PARA COLOCAR EN RIVERSA MI GUAGUA Y LA MISMA SE ACELERO SOLA Y LOS FRENOS NO LE FUNCIONARON, CAUSANDO QUE ME FUERA POR UN RISCO. LOS AIR BAGS NUNCA LE ABRIERON. Look up ODI 11464070 at NHTSA ↗ | 44.9%ODI 11529197Driving 55-60mph, engine dies, power steering is lost, no throttle response, brake system failure messages every 500-1000ft of driving at any speeds. Battery terminal melted, wiring harness needs to be replaced to junction box with upgraded part. Model : 2023 Lariat Maverick Miles: 1030 Colors: Area 51/desert brown Luxury package Rumble strips saved my life. Look up ODI 11529197 at NHTSA ↗ | 811.1%ODI 11611933New 2024 Ford Maverick. 12,000 miles. At around 10K miles, a factory recall regarding the firmware driving the brake light system was performed. This has 'broken' the factory installed trailer braking system that applies braking to an attached trailer with electric brakes. This is very dangerous, since failed trailer braking can cause a severe accident. The factory system shows alerts on the dash: when a trailer is electrically connected to the truck, the system responds with "Trailer connected". And now, that same message appears, but as s… Look up ODI 11611933 at NHTSA ↗ | 312.5%ODI 11690294In the first week with only 107 miles, the brakes failed 3 times at very low speeds. Once while backing out and no brakes at all. 2 days later while turning a corner in a parking light they totally failed and I just missed hitting a car. And the 3rd time when I was trying driving out of the Ford dealership they failed and I hit the dealership truck and damaged both vehicles. They didn’t believe me until I took it to the garage and parked it. Then they started it up it had no brakes. Look up ODI 11690294 at NHTSA ↗ | 240.0%ODI 11744344Description On your vehicle, the instrument panel ip upper section may detach from the passenger air bag chute doors during air bag deployment. The airbag is expected to otherwise deploy in position and restrain the occupant as designed. Safety Risk In the event of a crash in which the vehicle deploys the passenger airbag, a part of the ip upper section may detach and strike a vehicle occupant, increasing the risk of injury. Remedy Parts are available to repair your vehicle. Ford Motor Company has authorized your dealer to replace the ip u… Look up ODI 11744344 at NHTSA ↗ |
|---|
| Structure:Body | 128.0%ODI 11489982The 2022 Ford Maverick has a design flaw the harms the environment and places driver and passengers at risk. Specifically the vehicle does not have a metal skid plate which places the Evap System at risk for damage. If the system is damaged the vehicle is still driveable, but doing so allows gas vapors into the environment and worse, possibly into the passenger compartment. Looking under the vehicle, one finds some sort of fabric or mesh material which is definately not robust enough to protect the evap system components from damage. Driving… Look up ODI 11489982 at NHTSA ↗ | 67.4%ODI 11516067Windshield will groan and shift when driving , sound is always present and gets louder on uneven roads and bum. Ford stated it was a normal sounds, several maverick owners have had this problem Look up ODI 11516067 at NHTSA ↗ | 34.2%ODI 11617246Water is leaking into the passenger compartment after rain storms and accumulating in the carpet of the front passenger footwell causing mold. Look up ODI 11617246 at NHTSA ↗ | 14.2%ODI 11728937The passenger side floor is soaking wet every time it rains. Google says this is a defect with the windshield cowl, which other owners say is a common problem. Our safety is at risk with potential for mold, rust, and water intrusion into the electrical system. The truck is going to the dealership on Monday to have this issue addressed. It has been reproduced every time it rains. It has not been inspected by anyone other than myself. There were no warnings or alerts. We've noticed the wet carpet a couple times and researched the problem. Look up ODI 11728937 at NHTSA ↗ | 00.0%No examples available for this selection. |
|---|
| Steering | 64.0%ODI 11634785Front CV axles. Front end shakes really bad at 30-50 mph. Dealer changed front passenger side CV axle but it still shakes really bad. I'll be bringing it back to the dealership, but warranty expires soon they need to have a recall and a better replacement part for this fix. I am not the only one with this problem. Look up ODI 11634785 at NHTSA ↗ | 56.2%ODI 11529197Driving 55-60mph, engine dies, power steering is lost, no throttle response, brake system failure messages every 500-1000ft of driving at any speeds. Battery terminal melted, wiring harness needs to be replaced to junction box with upgraded part. Model : 2023 Lariat Maverick Miles: 1030 Colors: Area 51/desert brown Luxury package Rumble strips saved my life. Look up ODI 11529197 at NHTSA ↗ | 811.1%ODI 11628460In reducing the truck's speed, there is a sharp-pitched, loud, one-click sound , when I turn the steering to the right hand side. (This sound seems to come from the driver's left side, between the front door and the rear door.) It happens very often, but not every time. Look up ODI 11628460 at NHTSA ↗ | 14.2%ODI 11641826Purchased vehicle new and after 3 days the power steering became inoperable as well as traction control , hillstart assist and showed that the fowrad camers was in default . Look up ODI 11641826 at NHTSA ↗ | 120.0%ODI 11767301Customer Concern – Highway-Speed Vibration There is a noticeable, consistent vibration that begins at approximately 50 MPH and above and becomes most prevalent around 60 MPH. The vibration is present while maintaining a steady speed and does not appear to be related to acceleration or throttle input. The truck continues to track straight and does not noticeably pull to either side. There is also a slight rhythmic “doot-doot-doot” type noise noticeable at highway speeds when the radio is off. The rhythm appears to remain fairly constant rather t… Look up ODI 11767301 at NHTSA ↗ |
|---|
| Back Over Prevention | 74.7%ODI 11618418The contact owns a 2022 Ford Maverick. The contact received notification of NHTSA Campaign Number: 24V684000 (Back Over Prevention); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available. Look up ODI 11618418 at NHTSA ↗ | 56.2%ODI 11617656The contact owns a 2023 Ford Maverick. The contact received notification of NHTSA Campaign Number: 24V684000 (Back Over Prevention); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available. Look up ODI 11617656 at NHTSA ↗ | 79.7%ODI 11630115The contact owns a 2024 Ford Maverick. The contact received notification of NHTSA Campaign Number: 24V684000 (Back Over Prevention); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was not contacted. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available. Look up ODI 11630115 at NHTSA ↗ | 14.2%ODI 11663534 · 349 miThe contact called for a friend who owns a 2025 Ford Maverick. The contact stated that while driving at an undisclosed speed, the back over prevention camera did not function as intended. The contact stated that the control system features were inoperable. The vehicle was taken to several dealers where it was diagnosed with a software failure. The contact was informed that there was no remedy available to repair the vehicle. The vehicle was not repaired. The manufacturer was made aware of the failure. The contact was advised to take the vehicle… Look up ODI 11663534 at NHTSA ↗ | 00.0%No examples available for this selection. |
|---|