DAIMLER TRUCKS IS RECALLING 2,000 MY 2005-2008 BUSINESS CLASS M2 106 VOCATIONAL TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, 'LIGHTS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE VEHICLES DID NOT HAVE FRONT SIDE REFLEX REFLECTORS INSTALLED.
Consequence: UNDER CERTAIN CONDITIONS DURING DARKNESS, VISIBILITY OF THE TRUCK MAY BE IMPAIRED AND A CRASH MAY OCCUR.
Remedy: DEALERS WILL ADD REFLECTORS TO THE HOOD. THE RECALL BEGAN ON JUNE 12, 2008. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.
Reported: 2011-02-01 (February 1, 2011) · Model years: 2005
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2011 FREIGHTLINER CORONADO, COLUMBIA, FLD MILITARY, BUSINESS CLASS M2, CASCADIA, CENTURY, AND WESTERN STAR 4900 TRUCKS MANUFACTURED FROM AUGUST 9, 2010, THROUGH OCTOBER 27, 2010 FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." THESE VEHICLES WERE EQUIPPED WITH LABELS MISSING RECOMMENDED COLD TIRE INFLATION PRESSURES.
Consequence: FAILURE TO FOLLOW PROPER TIRE INFLATION RECOMMENDATIONS CAN RESULT IN TIRE FAILURE, INCREASING THE RISK OF A CRASH.
Remedy: LABELS WITH MISSING INFORMATION WILL BE REPLACED WITH CORRECTED LABELS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 31, 2011. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712. THIS SAFETY RECALL CAMPAIGN IS AN EXPANSION OF A PREVIOUS RECALL (PLEASE SEE 10V-551).
Reported: 2011-03-10 (March 10, 2011) · Model years: 2011
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2011 BUSINESS CLASS M2 106V INCOMPLETE CHASSIS CAB VEHICLES, MANUFACTURED FROM JULY 19, 2010, THROUGH JANUARY 14, 2011. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE HEADLIGHTS ON SOME VEHICLES MAY HAVE BEEN INSTALLED MORE THAN 54" FROM THE ROAD SURFACE.
Consequence: HEADLIGHTS INSTALLED AT HEIGHTS OUTSIDE OF THE PARAMETERS SET BY THE SAFETY STANDARD MAY NOT FULLY ILLUMINATE ROAD SURFACES OR MAY INHIBIT THE ABILITY OF MOTORISTS TO SEE VEHICLES INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE HEADLAMP HEIGHT AND REPLACE ANY NONCONFORMING HEADLIGHTS WITH NEW HEADLIGHTS THAT LOWER THE BULB CENTER SUCH THAT THE HEADLIGHTS MEET THE SAFETY STANDARD FREE OF CHARGE. AN INTERIM LETTER WAS SENT TO OWNERS ON JUNE 1, 2011. THE NOTIFICATION LETTER TO NOTIFY OWNERS THAT THE REMEDY IS NOW AVAILABLE WAS MAILED ON OCTOBER 10, 2011. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.
Reported: 2011-05-18 (May 18, 2011) · Model years: 2011
DTNA IS RECALLING CERTAIN MODEL YEAR 2011 BUSINESS CLASS M2, AND CORONADO, MODEL YEAR 2011-2012 CASCADIA VEHICLES EQUIPPED WITH FONTAINE ULTRA LT FIFTH WHEELS AND MANUFACTURED FROM APRIL 7, 2010, THROUGH MARCH 7, 2011. DURING THE COUPLING PROCESS ON VEHICLES EQUIPPED WITH PRE-MODIFICATION FONTAINE ULTRA LT FIFTH WHEELS, IT IS POSSIBLE FOR THE DRIVER TO PARTIALLY CLOSE THE FIFTH WHEEL LOCK, AND IF RELYING ON A TUG TEST (PULL TEST), AND NOT PERFORMING THE REQUIRED VISUAL INSPECTION, THINK THAT THE FIFTH WHEEL LOCK IS PROPERLY COUPLED TO THE TRAILER KING PIN, WHEN IN FACT, IT IS NOT.
Consequence: IF THE TRACTOR IS NOT FULLY CONNECTED TO THE TRAILER, THE TRAILER MAY DISENGAGE WHILE IN USE, INCREASING THE RISK OF A CRASH.
Remedy: FONTAINE NOTIFIED OWNERS IN FEBRUARY 2011, AND IS HANDLING THE REMEDY FOR THIS CAMPAIGN. FONTAINE IS IN THE PROCESS OF RETROFITTING ALL AFFECTED VEHICLES, FREE OF CHARGE. OWNERS MAY CONTACT FONTAINE AT 1-800-874-9780 OR DTNA AT 1-800-547-0712.
Inspect model-year patterns, reported mileage, monthly activity and the evidence behind each signal.
Data completeness
3 unique complaints in this selection. Analysis snapshot: 2026-10-01.
100.0%Usable mileage3 / 3 records
100.0%Valid incident date3 / 3 records
100.0%Valid filing date3 / 3 records
100.0%Ordered incident and filing dates3 / 3 records
Missing, zero and invalid mileage is excluded. Dates after the snapshot are excluded. Examples are limited selections, not a representative sample.
Problems by model year
Model-wide comparison of the eight most reported components across the model. Cells show counts and shares within each model year. Open a cell for source examples.
Component complaint heatmap
Component
2005
2006
2007
2008
2011
Exterior Lighting
0Unavailable
No examples available for this selection.
2100.0%ODI 10384457 · 168,000 mi
TL* THE CONTACT OWNS A 2006 FREIGHTLINER BUSINESS CLASS M2 106V. WHILE DRIVING APPROXIMATELY 65 MPH, THE CONTACT NOTICED THE CRUISE CONTROL WOULD NOT DEACTIVATE WHEN PRESSURE WAS APPLIED TO THE BRAKE PEDAL. THE CONTACT STATED THE BRAKE LIGHTS WOULD NOT ILLUMINATE WHEN PRESSURE WAS APPLIED TO THE BRAKE PEDAL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE TECHNICIAN COULD NOT DIAGNOSE THE FAILURE. THE MANUFACTURER WAS CONTACTED AND STATED THERE WAS A RECALL NHTSA CAMPAIGN ID NUMBER: 08V154000 (EXTERIOR LIGHTING:TAIL LIGHTS) BUT THE V…
ON OR ABOUT DECEMBER 24, 2013 THE DRIVER OF THE 2006 FREIGHTLINER M2 106 NOTICED A BURNING SMELL FOLLOWED BY SMOKE WHILE HE WAS OPERATING THE TRUCK. THE DRIVER INDICATED THE SMOKE BEGAN COMING FROM THE SEAM WHERE THE COWL AND HOOD MEET, OFFSET RIGHT OF THE CENTER OF THE TRUCK. THE DRIVER SAID THE SMOKE QUICKLY TURNED TO FIRE WHICH HE WAS UNABLE TO CONTROL AND MINUTES LATER AUTHORITIES ARRIVED TO EXTINGUISH THE FLAMES. MY COMPANY WAS ASKED TO PERFORM AN INSPECTION OF THE TRUCK FOLLOWING THE FIRE AND FOUND EVIDENCE SUGGESTING THAT THE FIRE ORIGIN…
WE HAVE BEEN ADVISED THAT OUR VEHICLE NEEDED $13,887.363 IN ENGINE REPAIRS DUE TO A FAULTY DESIGN OF THE ORIGINAL FUEL INJECTORS. THE ORIGINAL INJECTOR PROBLEM CAUSED EXCESSIVE CARBON BUILD UP AND VALVE WEAR. THIS RESULTED IN THE NEED TO REPLACE THE HEAD AND THE ITEMIZED REPAIRS ON THE ATTACHED FILE "FREIGHTLINER INJ.PDF"
Darker cells indicate a larger share of submitted complaints. Components overlap. This measures complaint composition, not failure probability.
Failure mileage by component
Median and middle 50% of usable owner-reported mileages. Ranges require at least five records.
Component failure mileage distribution
Component
Mileage range (25th–75th percentile)
Median
Usable records
Examples
Exterior Lighting
Too few reports for a range
156,744 mi
2 (sparse)
ODI 10384457 · 168,000 mi
TL* THE CONTACT OWNS A 2006 FREIGHTLINER BUSINESS CLASS M2 106V. WHILE DRIVING APPROXIMATELY 65 MPH, THE CONTACT NOTICED THE CRUISE CONTROL WOULD NOT DEACTIVATE WHEN PRESSURE WAS APPLIED TO THE BRAKE PEDAL. THE CONTACT STATED THE BRAKE LIGHTS WOULD NOT ILLUMINATE WHEN PRESSURE WAS APPLIED TO THE BRAKE PEDAL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE TECHNICIAN COULD NOT DIAGNOSE THE FAILURE. THE MANUFACTURER WAS CONTACTED AND STATED THERE WAS A RECALL NHTSA CAMPAIGN ID NUMBER: 08V154000 (EXTERIOR LIGHTING:TAIL LIGHTS) BUT THE V…
ON OR ABOUT DECEMBER 24, 2013 THE DRIVER OF THE 2006 FREIGHTLINER M2 106 NOTICED A BURNING SMELL FOLLOWED BY SMOKE WHILE HE WAS OPERATING THE TRUCK. THE DRIVER INDICATED THE SMOKE BEGAN COMING FROM THE SEAM WHERE THE COWL AND HOOD MEET, OFFSET RIGHT OF THE CENTER OF THE TRUCK. THE DRIVER SAID THE SMOKE QUICKLY TURNED TO FIRE WHICH HE WAS UNABLE TO CONTROL AND MINUTES LATER AUTHORITIES ARRIVED TO EXTINGUISH THE FLAMES. MY COMPANY WAS ASKED TO PERFORM AN INSPECTION OF THE TRUCK FOLLOWING THE FIRE AND FOUND EVIDENCE SUGGESTING THAT THE FIRE ORIGIN…
ON OR ABOUT DECEMBER 24, 2013 THE DRIVER OF THE 2006 FREIGHTLINER M2 106 NOTICED A BURNING SMELL FOLLOWED BY SMOKE WHILE HE WAS OPERATING THE TRUCK. THE DRIVER INDICATED THE SMOKE BEGAN COMING FROM THE SEAM WHERE THE COWL AND HOOD MEET, OFFSET RIGHT OF THE CENTER OF THE TRUCK. THE DRIVER SAID THE SMOKE QUICKLY TURNED TO FIRE WHICH HE WAS UNABLE TO CONTROL AND MINUTES LATER AUTHORITIES ARRIVED TO EXTINGUISH THE FLAMES. MY COMPANY WAS ASKED TO PERFORM AN INSPECTION OF THE TRUCK FOLLOWING THE FIRE AND FOUND EVIDENCE SUGGESTING THAT THE FIRE ORIGIN…
WE HAVE BEEN ADVISED THAT OUR VEHICLE NEEDED $13,887.363 IN ENGINE REPAIRS DUE TO A FAULTY DESIGN OF THE ORIGINAL FUEL INJECTORS. THE ORIGINAL INJECTOR PROBLEM CAUSED EXCESSIVE CARBON BUILD UP AND VALVE WEAR. THIS RESULTED IN THE NEED TO REPLACE THE HEAD AND THE ITEMIZED REPAIRS ON THE ATTACHED FILE "FREIGHTLINER INJ.PDF"
Explore monthly filing activity alongside recall announcements. Up to ten years of monthly history is available.
Solid line: filed complaints. Dashed amber lines: recall announcement dates for this vehicle selection; markers include all recall components. The latest month is partial. Temporal proximity does not establish causation.
Monthly counts, recall campaigns and complaint examples
Monthly complaint and recall timeline
Month
Complaints
Campaigns announced
Examples
2024-11
0
None
No examples available for this selection.
2024-12
0
None
No examples available for this selection.
2025-01
0
None
No examples available for this selection.
2025-02
0
None
No examples available for this selection.
2025-03
0
None
No examples available for this selection.
2025-04
0
None
No examples available for this selection.
2025-05
0
None
No examples available for this selection.
2025-06
0
None
No examples available for this selection.
2025-07
0
None
No examples available for this selection.
2025-08
0
None
No examples available for this selection.
2025-09
0
None
No examples available for this selection.
2025-10
0
None
No examples available for this selection.
2025-11
0
None
No examples available for this selection.
2025-12
0
None
No examples available for this selection.
2026-01
0
None
No examples available for this selection.
2026-02
0
None
No examples available for this selection.
2026-03
0
None
No examples available for this selection.
2026-04
0
None
No examples available for this selection.
2026-05
0
None
No examples available for this selection.
2026-06
0
None
No examples available for this selection.
2026-07
0
None
No examples available for this selection.
2026-08
0
None
No examples available for this selection.
2026-09
0
None
No examples available for this selection.
2026-10 (partial)
0
None
No examples available for this selection.
Emerging complaint spikes
Complete months in the latest six months with at least 10 complaints, at least twice the preceding 12-month average, and at least three square-root deviations above that average.
This is a descriptive screening rule, not a statistical defect finding. Publicity and reporting changes can increase submissions.
No complete months meet the spike thresholds for this selection.
Equal-age model-year comparison
Model-wide cumulative reports during the first three or five calendar years, starting with the model year (age 0). Only fully elapsed windows are compared.
2008: 0 complaints · 2011: 0 complaints
Equal observation windows
Model year
Through age 0
Through age 1
Through age 2
2008
0
0
0
2011
0
0
0
Date coverage across each selected cohort
Date basis for all complaints in selected model years
Year
Incident dates used
Filing date fallbacks
Excluded dates
2008
1
0
0
2011
0
0
0
Incident date is preferred when valid and no later than filing; otherwise filing date is used. Model year approximates age. Equal observation time does not adjust for sales, distance driven or reporting delays. One complaint linked to multiple model years can appear in each cohort.
Components reported together
Each cell counts unique complaints naming both components. Open a nonzero cell for examples.
Component co-occurrence matrix
Component
Exterior Lighting
Electrical System
Engine
Exterior Lighting
—
1ODI 10577614 · 145,488 mi
ON OR ABOUT DECEMBER 24, 2013 THE DRIVER OF THE 2006 FREIGHTLINER M2 106 NOTICED A BURNING SMELL FOLLOWED BY SMOKE WHILE HE WAS OPERATING THE TRUCK. THE DRIVER INDICATED THE SMOKE BEGAN COMING FROM THE SEAM WHERE THE COWL AND HOOD MEET, OFFSET RIGHT OF THE CENTER OF THE TRUCK. THE DRIVER SAID THE SMOKE QUICKLY TURNED TO FIRE WHICH HE WAS UNABLE TO CONTROL AND MINUTES LATER AUTHORITIES ARRIVED TO EXTINGUISH THE FLAMES. MY COMPANY WAS ASKED TO PERFORM AN INSPECTION OF THE TRUCK FOLLOWING THE FIRE AND FOUND EVIDENCE SUGGESTING THAT THE FIRE ORIGIN…
ON OR ABOUT DECEMBER 24, 2013 THE DRIVER OF THE 2006 FREIGHTLINER M2 106 NOTICED A BURNING SMELL FOLLOWED BY SMOKE WHILE HE WAS OPERATING THE TRUCK. THE DRIVER INDICATED THE SMOKE BEGAN COMING FROM THE SEAM WHERE THE COWL AND HOOD MEET, OFFSET RIGHT OF THE CENTER OF THE TRUCK. THE DRIVER SAID THE SMOKE QUICKLY TURNED TO FIRE WHICH HE WAS UNABLE TO CONTROL AND MINUTES LATER AUTHORITIES ARRIVED TO EXTINGUISH THE FLAMES. MY COMPANY WAS ASKED TO PERFORM AN INSPECTION OF THE TRUCK FOLLOWING THE FIRE AND FOUND EVIDENCE SUGGESTING THAT THE FIRE ORIGIN…
Co-reporting does not establish that one component caused another concern.
Recurring narrative patterns
Specific keyword mentions beyond broad component labels. Matching includes negations and comparisons and does not confirm a diagnosis.
1 patterns with matching reports.
Brake response concerns
1 mentions · 33.3% of complaints
Median mileage: 168,000 mi (1 usable records).
ODI 10384457 · 168,000 mi
TL* THE CONTACT OWNS A 2006 FREIGHTLINER BUSINESS CLASS M2 106V. WHILE DRIVING APPROXIMATELY 65 MPH, THE CONTACT NOTICED THE CRUISE CONTROL WOULD NOT DEACTIVATE WHEN PRESSURE WAS APPLIED TO THE BRAKE PEDAL. THE CONTACT STATED THE BRAKE LIGHTS WOULD NOT ILLUMINATE WHEN PRESSURE WAS APPLIED TO THE BRAKE PEDAL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE TECHNICIAN COULD NOT DIAGNOSE THE FAILURE. THE MANUFACTURER WAS CONTACTED AND STATED THERE WAS A RECALL NHTSA CAMPAIGN ID NUMBER: 08V154000 (EXTERIOR LIGHTING:TAIL LIGHTS) BUT THE V…