Gmc C6500 recalls by model year

Reported: 1974-09-04 (September 4, 1974) · Model years: 1974

Reported: 2000-09-07 (September 7, 2000) · Model years: 1998, 1999, 2000, 2001

VEHICLE DESCRIPTION: SCHOOL BUSES, MEDIUM DUTY TRUCKS AND TRACTORS BUILT WITH BENDIX AIR ABS WITH AN EC-17 1030R ELECTRONIC CONTROL UNIT (ECU), THERE HAVE BEEN REPORTS OF UNWANTED ABS ACTIVATION AT LOW SPEEDS CAUSED BY 1) CHAFED ABS WHEEL SPEED SENSOR WIRES ON ROTATING PARTS OR 2) A DAMAGED COMPONENT AT THE WHEEL END THAT GENERATES A CERTAIN TYPE OF ERRATIC SENSOR SIGNAL.

Consequence: THIS CONDITION COULD CAUSE THE ABS ECU TO EXHAUST THE AIR AT THE AIR BRAKE MODULATORS FOR ONE OR MORE OF THE WHEELS. THIS COULD RESULT IN EXTENDED BRAKING DISTANCES AND A POSSIBLE CRASH.

Remedy: DEALERS WILL REPLACE THE ABS ECU.

Reported: 1998-04-08 (April 8, 1998) · Model years: 1998

VEHICLE DESCRIPTION: MEDIUM DUTY TRUCKS EQUIPPED WITH AIR BRAKES AND ANTI-LOCK BRAKE SYSTEMS. CHAFFING OF THE ELECTRIC BRAKE CONTROL HARNESS CAN OCCUR RESULTING IN AN ELECTRICAL GROUNDING CONDITION. THIS WILL ILLUMINATE A WARNING LIGHT ON THE INSTRUMENT PANEL AND SHUT OFF THE ABS FEATURE.

Consequence: THIS CONDITION CAN CAUSE REDUCED BRAKING CAPABILITY OF THE FRONT BRAKES, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT THE HARNESS FOR CHAFFING AND PROPER ROUTING AND WILL REPAIR IF NECESSARY.

Reported: 2000-08-23 (August 23, 2000) · Model years: 1999, 2000

VEHICLE DESCRIPTION: MEDIUM DUTY TRUCKS. THE TRANSMISSION FLUID COULD LEAK FROM A HEAT DEGRADED TRANSMISSION FLUID COOLER HOSE ONTO THE EXHAUST SYSTEM ON THE PASSENGER'S SIDE OF THE VEHICLE.

Consequence: THIS CONDITION COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSTALL A NEW TRANSMISSION FLUID COOLER INLET HOSE AND OUTLET HOSE DESIGNED WITH A HEAT SLEEVE AND ENSURE ADEQUATE CLEARANCE TO THE EXHAUST SYSTEM TAKE-DOWN PIPE. DEALERS WILL ALSO INSPECT THE RIGHT-HAND EXHAUST MANIFOLD SEAL FOR LEAKAGE, AND REPLACE IF NECESSARY.

Reported: 2002-11-04 (November 4, 2002) · Model years: 1999, 2000

CERTAIN MEDIUM DUTY C-SERIES AND B7 SCHOOL BUS CHASSIS EQUIPPED WITH A 7.4 LITER GAS ENGINE AND AN IMPCO LPG CONVERSION KIT. SOME OF THESE VEHICLES MAY HAVE ENGINE BACKFIRES WITH SUFFICIENT FORCE TO DAMAGE THE ENGINE AIR INTAKE SYSTEM AND THE AIR CLEANER FILTER ELEMENT.

Consequence: IF THE DAMAGED AIR CLEANER PARTS ARE DISLODGED FROM THEIR NORMAL POSITION, THESE PARTS COULD COME IN CONTACT WITH THE HOT EXHAUST MANIFOLD AND/OR HOT EXHAUST GAS RECIRCULATION (EGR) VALVE TUBE RESULTING IN A POSSIBLE ENGINE COMPARTMENT FIRE.

Remedy: DEALERS WILL INSTALL A REDESIGNED MIXER BONNET AND AIR CLEANER HOUSING COVER, SELECTIVE UPGRADES IN VARIOUS CONNECTIONS RELATED TO THE AIR INDUCTION SYSTEM, AND IF NEEDED, A NEW AIR CLEANER FILTER. OWNER NOTIFICATION BEGAN DECEMBER 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.

Reported: 1999-11-15 (November 15, 1999) · Model years: 1999

VEHICLE DESCRIPTION: MEDIUM DUTY CONVENTIONAL CAB TRUCKS AND SCHOOL BUS CHASSIS EQUIPPED WITH AN AUTOMATIC TRANSMISSION, HAVE TRANSMISSION SHIFT CABLE END RODS THAT HAVE NOT BEEN CRIMPED TO THE PROPER SPECIFICATION. OVER TIME, THE SHIFT CABLE COULD BE PULLED OUT OF THE ROD END CAUSING THE DRIVER TO LOSE THE ABILITY TO MANUALLY CHANGE TRANSMISSION GEARS.

Consequence: WITH THIS CONDITION, THE VEHICLE MAY MOVE IN A DIRECTION NOT ANTICIPATED BY THE DRIVER, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSTALL A NEW SHIFT CABLE.

Reported: 2002-07-11 (July 11, 2002) · Model years: 2001, 2002

ON CERTAIN MEDIUM DUTY TRUCKS EQUIPPED WITH 8.1 L ENGINES AND LEFT HAND OR DUAL FUEL TANKS, SOME OF THESE VEHICLES HAVE A CONDITION WHERE THE FUEL FILTER-TO-COMPONENT BOX MOUNTING BOLTS ARE REVERSED. WITH THE BOLTS REVERSED, THE THREADED BOLT END IS ORIENTED TOWARD THE FRONT WALL OF THE LEFT HAND FUEL TANK.

Consequence: IN THE EVENT OF A FRONTAL CRASH, THE THREADED END OF THE BOLTS COULD PIERCE THE FRONT WALL OF THE FUEL TANK RESULTING IN FLUE LEAKAGE. IF AN IGNITION SOURCE WERE PRESENT, FUEL LEAKAGE COULD RESULT IN A VEHICLE FIRE.

Remedy: DEALERS WILL INSPECT AND CORRECTLY INSTALL THE TWO FUEL FILTER MOUNTING BOLTS, IF NECESSARY. OWNER NOTIFICATION BEGAN AUGUST 8, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.

Reported: 2015-02-25 (February 25, 2015) · Model years: 2007

Farber Specialty Vehicles (Farber) is recalling various specialty vehicles modified by Farber and equipped with model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack.

Consequence: If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.

Remedy: Farber will notify owners to take their vehicles to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began on March 24, 2015. Owners may contact Farber customer service at 1-800-331-3188, or Ricon customer service at 1-800-322-2884. Farber's number for this recall is 14E-041.