Gmc TOPKICK recalls by model year

Reported: 1994-01-08 (January 8, 1994) · Model years: 1993

THE INTERMEDIATE STEERING SHAFT WAS ASSEMBLED WITH LOOSE OR MISSING UPPER AND LOWER PINCH BOLTS WHICH MAY CAUSE SEPARATION OF THE SHAFT.

Consequence: SEPARATION OF THE INTERMEDIATE STEERING SHAFT RESULTS IN TOTAL LOSS OF STEERING CONTROL AND COULD CAUSE AN ACCIDENT.

Remedy: DEALERS WILL PROPERLY TORQUE LOOSE PINCH BOLTS AND INSTALL PINCH BOLTS WHERE NECESSARY.

Reported: 1996-07-01 (July 1, 1996) · Model years: 1996

THE AUTO-APPLY PARK BRAKE (MANUAL OR AUTO APPLICATION) DOES NOT ALWAYS APPLY. IF THE PARK BRAKE DOES NOT APPLY, THE "SERVICE PARK BRAKE" WARNING LIGHT WILL ILLUMINATE.

Consequence: THE DRIVER MAY NOT NOTICE THE WARNING LIGHT AND EXITS THE VEHICLE. THE VEHICLE COULD ROLL AWAY INCREASING THE RISK OF A VEHICLE ACCIDENT.

Remedy: DEALERS WILL REPLACE THE PARKING BRAKE SOLENOID VALVE WITH ONE HAVING A 12 VOLT COIL AND THE ORIGINAL VALVE SPRING.

Reported: 2002-10-01 (October 1, 2002) · Model years: 2003

CERTAIN MEDIUM DUTY TRUCKS EQUIPPED WITH THE OPTIONAL CATERPILLAR DIESEL ENGINE (LG5) OPTION WERE BUILT WITH A MISROUTED BATTERY CABLE THAT COULD COME IN CONTACT WITH THE EXHAUST PIPE. THE CONDUIT AND THE NYLON CABLE COATING COULD DEGRADE TO THE POINT WHERE THE COPPER WIRE STRANDS OF THE CABLE ARE EXPOSED.

Consequence: IF THE CABLE STRANDS CONTACTED THE EXHAUST PIPE A SHORT CIRCUIT COULD CAUSE THE BATTERY CABLE COATINGS TO IGNITE AND POSSIBLY LEAD TO AN ENGINE COMPARTMENT FIRE.

Remedy: DEALERS WILL INSPECT THE BATTERY CABLE FOR PROPER ROUTING AND REROUTE THE CABLE IF NECESSARY. OWNER NOTIFICATION BEGAN OCTOBER 25, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.

Reported: 2004-03-17 (March 17, 2004) · Model years: 2003, 2004

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE GALVANIZED STEEL TAILGATE SUPPORT CABLES THAT RETAIN THE TAILGATE IN THE FULL OPEN (HORIZONTAL) POSITION MAY CORRODE, WEAKEN, AND EVENTUALLY FRACTURE. IF BOTH CABLES FRACTURED, THE TAILGATE WOULD SUDDENLY DROP AND STRIKE THE TOP SURFACE OF THE REAR BUMPER.

Consequence: ANYONE SITTING OR STANDING ON THE HORIZONTAL SURFACE OF THE TAILGATE WHEN BOTH CABLES FRACTURED COULD BE INJURED BY FALLING FROM THE TAILGATE. ON VEHICLES THAT HAVE HAD THE BUMPER REMOVED, THE TAILGATE MAY DROP EVEN LOWER. ADDITIONALLY, IF THERE IS CARGO ON THE TAILGATE THE CARGO MAY FALL OFF IF THE SUPPORT CABLES FRACTURE.

Remedy: DEALERS WILL REPLACE THE CABLES. INTERIM OWNER NOTIFICATION BEGAN ON APRIL 7, 20004. THE RECALL BEGAN ON SEPTEMBER 24, 2004, WHEN REPLACEMENT PARTS WERE AVAILABLE, AND WILL CONTINUE THROUGH OCTOBER 29, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463, OR VISIT WWW.MYGMLINK.COM, AND ENTER YOUR VEHICLE IDENTIFICATION NUMBER.

Reported: 2005-06-16 (June 16, 2005) · Model years: 2003, 2004, 2005

CERTAIN 2003-2005 MODEL YEAR 4500/5500 SERIES CHEVROLET KODIAK, SCHOOL BUS CHASSIS, AND GMC TOPKICK VEHICLES; AND 2003-2004 MODEL YEAR GMC SCHOOL BUS CHASSIS VEHICLES EQUIPPED WITH AN 8.1L ENGINE AND HYDROMAX BRAKE SYSTEM. THE POWER STEERING HOSE MAY COME INTO CONTACT WITH A PORTION OF THE INTERMEDIATE STEERING SHAFT. A HOLE COULD BE WORN IN THE HOSE AND A LOSS OF HYDRAULIC FLUID WOULD OCCUR.

Consequence: IF THERE IS SUFFICIENT AMOUNT OF FLUID LOSS, THE DRIVER WILL HEAR A NOISE FROM THE POWER STEERING PUMP, THE BRAKE WARNING LIGHT AND WARNING TONE WILL ACTIVATE. INCREASED EFFORT MAY BE REQUIRED FOR STEERING AND BRAKING, INCREASING THE RISK OF A CRASH.

Remedy: GM WILL NOTIFY ITS CUSTOMERS AND DEALERS WILL REROUTE THE POWER STEERING HOSE. IF THE STEEL BRAIDING OF THE HOSE IS EXPOSED, DEALERS ARE TO REPLACE THE HOSE FREE OF CHARGE. THE RECALL BEGAN ON JULY 12, 2005. OWNERS MAY CONTACT CHEVROLET AT 800-630-2438 OR GMC AT 866-996-9463.

Reported: 2007-10-04 (October 4, 2007) · Model years: 2003, 2004, 2005, 2006, 2007

ON CERTAIN MEDIUM DUTY TRUCKS EQUIPPED WITH ZF MODEL 8018 STEERING GEARS, THE STEERING GEAR MAY HAVE BEEN PRODUCED INCORRECTLY. A STEERING GEAR WITH THIS CONDITION MAY PRODUCE THE FEELING OF HITTING A CURB AND A CRACKING OR PINGING SOUND WHEN THE STEERING WHEEL IS TURNED.

Consequence: THE STEERING WHEEL POSITION MAY BE OFF-CENTER AND INCREASED EFFORT MAY BE REQUIRED WHEN TURNING, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT FOR CERTAIN DATE CODES AND VERIFY THE MILEAGE ON STEERING GEARS AND REPLACE GEARS AS NECESSARY. THE RECALL BEGAN ON OCTOBER 25, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463; OR ISUZU AT 1-800-255-6727.

Reported: 2004-03-10 (March 10, 2004) · Model years: 2004

ON CERTAIN TRUCKS, THE SWITCH RETAINER HOLDING THE BRAKE BOOSTER PUSH ROD AND THE BRAKE PEDAL TOGETHER COULD BE MISSING.

Consequence: THIS COULD CAUSE THE PUSH ROD AND PEDAL TO SEPARATE, RESULTING IN A LOSS OF FOUNDATION BRAKES AND INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT AND INSTALL A NEW RETAINER IF MISSING. OWNER NOTIFICATION BEGAN MARCH 5, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT GMCICT AT 1-800-862-4389.

Reported: 2005-02-08 (February 8, 2005) · Model years: 2004, 2005

CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.

Consequence: IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.

Remedy: DEALERS WILL TEST THE HYDRO-BOOST ASSEMBLY FOR FUNCTIONAL OPERATION OF THE TWO-FUNCTION VALVE. IF THE HYDRO-BOOST ASSEMBLY FAILS THE TEST, DEALERS WILL REPLACE THE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 23, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC TRUCKS AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493.

Reported: 2006-07-13 (July 13, 2006) · Model years: 2006

CERTAIN MEDIUM DUTY TRUCKS EQUIPPED SR-7 BENDIX BRAKE VALVES, THE CHECK VALVE INSIDE THE VALVE CAVITY MAY NOT PROPERLY SET, CAUSING INTERNAL AIR LEAKAGE. IF THE CHECK VALVE DOES NOT PROPERLY SEAT, THE RESULTING LEAKAGE CAN CAUSE A DELAY IN THE APPLICATION OF THE SPRING BRAKES TO PARK THE VEHICLE AFTER OPERATOR PULLS THE DASH VALVE BUTTON.

Consequence: THE DELAYED PARKING BRAKE APPLICATION CAN OCCUR WITHOUT WARNING, LEADING TO UNINTENDED VEHICLE ROLLAWAY INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT THE VALVES AND REPLACE IT FREE OF CHARGE. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR ISUZU AT 1-800-255-6727.

Reported: 2006-08-16 (August 16, 2006) · Model years: 2006

CERTAIN TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, "AIR BRAKE SYSTEMS." AN INTERNAL CONTROL AND CHECK VALVE WITHIN THE AIR BRAKE APPLICATION VALVE ASSEMBLY WAS CONFIGURED IMPROPERLY, PREVENTING AIR FROM FLOWING THROUGH THE BRAKE SYSTEM AS DESIGNED. IN THE EVENT OF AN EMERGENCY STOP, THE VEHICLE'S STOPPING DISTANCE WOULD BE INCREASED.

Consequence: IF STOPPING DISTANCE WAS LIMITED, A VEHICLE CRASH COULD RESULT.

Remedy: DEALERS WILL REPLACE THE AIR BRAKE APPLICATION VALVE ASSEMBLY ON C-SERIES OR REROUTE THE AIR BRAKE LINES ON T-SERIES FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 20, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463 AND ISUZU AT 1-800-255-6727.

Reported: 2007-08-28 (August 28, 2007) · Model years: 2006, 2007

ON CERTAIN STRAIGHT TOWING OR NON-TOWING TRUCKS EQUIPPED WITH BENDIX AIR BRAKES, THE AIR BRAKE PARK CONTROL VALVE MAY DEVELOP EITHER AN INTERNAL AIR LEAK OR AN AIR RESTRICTION. THE PARK BRAKE MAY NOT RELEASE OR MAY RELEASE ONLY PARTIALLY.

Consequence: IF THE VEHICLE IS ON AN UNEVEN SURFACE, THE PARK BRAKE MAY NOT HOLD THE VEHICLE AND COULD RESULT IN UNINTENDED VEHICLE MOVEMENT AND A VEHICLE CRASH. THIS CONDITION DOES NOT AFFECT NORMAL SERVICE BRAKING.

Remedy: DEALERS WILL INSPECT AND REPLACE THE EXTERNAL CHECK VALVE ON THE AIR BRAKE PARK CONTROL VALVE IF THE INSPECTION DETERMINES THE EXTERNAL CHECK VALVE IS DAMAGED, THE AIR BRAKE PARK CONTROL VALVE WILL BE REPLACED AND MAY REQUIRE THE REPLACEMENT OF AN INTERNAL CHECK VALVE IN THE AIR BRAKE PARK CONTROL VALVE. REMEDY WILL BE FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 22, 2007. OWNERS MAY CONTACT GM AT 1-800-862-4389 OR ISUZU AT 1-800-255-6727.

Reported: 2007-04-10 (April 10, 2007) · Model years: 2007

ON CERTAIN TRUCKS, THE REAR DRIVE AXLE HOUSING WAS MANUFACTURED WITH STEEL BELOW THE SPECIFIED THICKNESS AND, AS A RESULT, IT COULD DEVELOP A CRACK.

Consequence: IF A CRACK DEVELOPS AND IS NOT DETECTED AND REPAIRED, THE OUTBOARD END OF THE HOUSING COULD EVENTUALLY SEPARATE, ALLOWING THE HUB, AXLE SHAFT, OR WHEEL AND BRAKE ASSEMBLY TO SEPARATE FROM THE VEHICLE INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT AND REPLACE THE AXLE FREE OF CHARGE. THE RECALL BEGAN ON APRIL 12, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.

Reported: 2007-05-02 (May 2, 2007) · Model years: 2007

ON CERTAIN MEDIUM DUTY CONVENTIONAL AND TILT CAB TRUCKS EQUIPPED WITH 7.8L DIESEL ENGINES AND AIR BRAKES, THE AIR COMPRESSOR MAY NOT BUILD ENOUGH AIR PRESSURE TO SUPPORT THE AIR BRAKE SYSTEM.

Consequence: IF THIS CONDITION WERE TO OCCUR WHILE THE VEHICLE WAS STATIONARY (BRAKES APPLIED) THE AIR BRAKES WOULD REMAIN APPLIED AND PREVENT THE VEHICLE FROM MOVING. IF THIS CONDITION WERE TO OCCUR WHILE THE VEHICLE WAS IN MOTION, THE DUAL SYSTEM AIR PRESSURE GAUGES WOULD REGISTER THE DROP IN PRESSURE. IF THE PRESSURE CONTINUED TO DROP, THE LOW AIR PRESSURE WARNING BUZZER AND WARNING LAMP WOULD ACTIVATE AS DESIGNED, WARNING THE DRIVER TO MOVE THE VEHICLE TO A SAFETY LOCATION. IF THE DRIVER IGNORES THESE WARNINGS AND CONTINUES TO DRIVE THE VEHICLE, AND IF THERE WAS A CONTINUED LOSS OF PRESSURE, THE REAR SPRING PARKING BRAKES WOULD AUTOMATICALLY APPLY, PREVENTING THE TRUCK FROM BEING DRIVEN.

Remedy: DEALERS WILL REPLACE THE AIR COMPRESSOR HEAD. THE RECALL BEGAN ON MAY 23, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR ISUZU AT 1-800-255-6727.

Reported: 2009-07-29 (July 29, 2009) · Model years: 2007

GM IS RECALLING 1,880 MODEL YEAR 2007 CHEVROLET KODIAK AND T-SERIES, GMC TOPKICK AND T-SERIES, AND ISUZU F-SERIES AND H-SERIES PASSENGER VEHICLES EQUIPPED WITH 7.8L DIESEL ENGINE. THE AIR COMPRESSOR IN SOME OF THESE VEHICLES MAY NOT BUILD ENOUGH AIR PRESSURE TO SUPPORT THE AIR BRAKE SYSTEM. IF THIS CONDITION WERE TO OCCUR WHILE THE VEHICLES WAS STATIONARY (BRAKES APPLIED), THE AIR BRAKES WOULD REMAIN APPLIED AND PREVENT THE VEHICLE FROM MOVING.

Consequence: IF THE DRIVER IGNORES THESE WARNINGS AND CONTINUES TO DRIVE THE VEHICLE, AND IF THERE WAS A CONTINUED LOSS OF PRESSURE, THE REAR SPRING PARKING BRAKES WOULD AUTOMATICALLY APPLY, PREVENTING THE TRUCK FROM BEING DRIVEN.

Remedy: DEALERS WILL INSPECT THE AIR COMPRESSOR FOR ITS ABILITY TO BUILD AIR PRESSURE, AND EITHER MODIFY THE AIR COMPRESSOR BY ELIMINATION OF THE SUPPRESSION VALVE OR REPLACE THE AIR COMPRESSOR ASSEMBLY FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING AUGUST 2009. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727 OR AT WWW.GMOWNERCENTER.COM.

Reported: 2008-08-06 (August 6, 2008) · Model years: 2008

GM IS RECALLING 319 MY 2008 CHEVROLET KODIAK AND GMC TOPKICK TRUCKS EQUIPPED WITH CATERPILLAR C9 DIESEL ENGINES. THE FUEL PUMP OUTLET CHECK PLUG MAY BE CRACKED WHICH COULD CAUSE FUEL TO SPRAY AND LEAK.

Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: GENERAL MOTORS IS WORKING WITH CATERPILLAR (PLEASE SEE 08E042). CATERPILLAR WILL REPLACE THE FUEL PUMP PLUG FREE OF CHARGE. OWNERS MAY CONTACT CATERPILLAR AT 1-800-447-4986, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463 OR OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .

Reported: 2018-04-26 (April 26, 2018) · Model years: 2009

General Motors LLC (GM) is recalling certain 2009-2014 Chevrolet Silverado HD and GMC Sierra HD, 2009 GMC Topkick 5000, 6000, 7000 and 8000 Series and Isuzu F Series, and 2009-2018 Chevrolet Express, and GMC Savana vehicles, equipped with certain Plastic-Handle Fire Extinguishers or Push Button 'Pindicator' Fire Extinguishers. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Consequence: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Remedy: GM will notify owners, instructing them to contact Kidde to get a replacement fire extinguisher, free of charge. The recall began June 11, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Isuzu customer service at 1-866-441-9638. GM's number for this recall is 18146.