| Service Brakes | 17.1%ODI 10883916TL* THE CONTACT OWNS A 2007 HARLEY-DAVIDSON FLHRC. THE CONTACT STATED THAT WHEN THE REAR BRAKES HAD BEEN APPLIED SEVERAL TIMES THEY FAILED TO ENGAGE AND FUNCTIONED RANDOMLY. THE DEALER WAS NOTIFIED OF THE FAILURE, PROVIDED A COVER FOR THE BRAKE FLUID RESERVOIR BUT DID NOT PROVIDE A DIAGNOSIS TO PREVENT THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND THE CONTACT WAS WAITING FOR A REPAIR SOLUTION TO BE PROVIDED TO A DEALER. THE CONTACT WAS NOT INCLUDED IN NHTSA ACTION NUMBER: PE16009 (SERVICE BRAKES, HYDRAULIC). THE FAILURE MILEAGE … Look up ODI 10883916 at NHTSA ↗ | 216.7%ODI 11047371 · 25,400 miWHILE STARTING TO EXIT AN INTERSTATE HIGHWAY AND ENTERING THE RADIUSED EXIT RAMP, I APPLIED BOTH FRONT AND REAR BRAKES ON MY MOTORCYCLE IN ORDER TO SLOW FROM 65 MPH TO A SAFE EXIT SPEED. WHILE ENTERING THE TURN, THE BRAKE PEDAL FOR THE REAR BRAKES, WENT ALL THE WAY DOWN. I LOST ALL REAR BRAKING ABILITY ON THE EXIT RAMP. I WAS UNABLE TO SAFELY SLOW TO THE POSTED EXIT SPEED. THIS MOTORCYCLE IS EQUIPPED WITH ABS BRAKING. I RETURNED HOME USING FRONT BRAKES ONLY. THE REAR BRAKE RESERVOIR DID NOT LOSE ANY BRAKE FLUID. THE FAILURE WAS NOT CAUSED BY A … Look up ODI 11047371 at NHTSA ↗ | 323.1%ODI 10566734 · 28,663 miWHILE MOVING THE BIKE IN THE GARAGE UNDER POWER, THE FRONT BRAKE LEVER WOULD NOT MOVE. NO FRONT BRAKES!! LIFTED FOOT TO USE REAR BRAKE AND BIKE AND MY SELF FELL OVER AS BIKE HIT ANOTHER MOTORCYCLE IN GARAGE. THE BRAKE ARE FROZEN IN THE NON BRAKING POSITION. BIKE WAS LAST USED 4 DAYS AGO AND NO BRAKE PROBLEMS NOTED AT THAT TIME. HAVING BIKE TOWED TO SHOP FOR REPAIRS. *TR Look up ODI 10566734 at NHTSA ↗ | 375.0%ODI 10915567 · 58,000 miREAR BRAKE FAILURE WITHOUT WARNING DUE TO ABS MODULE FAILURE. HARLEY STATES THAT NOT REPLACING THE BRAKE FLUID EVERY TWO YEARS IS THE ROOT CAUSE, THE FLUID ON MY CYCLE HAS BEEN CHANGED OUT IN ROUGHLY THAT INTERVAL IN MY GARAGE. IF FAILURE IS DUE TO HYGROSCOPIC FLUID THEN A SIMPLE 2YEAR INTERVAL MAY NOT BE SUFFICIENT TO CAPTURE INSTANCES WHERE THE FLUID COMES INTO MORE WATER THAN NORMAL - FOR INSTANCE I COMMUTE IN THE RAIN AND LIVE IN A HUMID ENVIRONMENT. CHIEF CONCERN IS THAT THE BRAKE MODULE FAILS IN STATE WHERE THE BRAKES DON'T FUNCTION … Look up ODI 10915567 at NHTSA ↗ | 4100.0%ODI 10767021 · 21,000 miFRONT BRAKE LEVER WILL NOT MOVE MUCH AND TAKES A LOT OF FORCE TO GET IT TO MOVE. FRONT BRAKE WILL NOT WORK. THIS IS A BIG AND DANGEROUS PROBLEM!! AFTER RESEARCHING, I FOUND IT TO BE A COMMON PROBLEM WITH HARLEY DAVIDSON ABS EQUIPPED BIKES. Look up ODI 10767021 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. |
|---|
| Electrical System | 17.1%ODI 10191585 · 2,886 miRANDOM STALLING OF MOTORCYCLE WHILE BEING OPERATED. THE STALLING HAPPENED NUMEROUS TIMES, APPROXIMATELY 20 TIMES, AND HAS BEEN ONGOING FOR A 5 WEEK PERIOD WITH NO SUCCESS IN DIAGNOSING OR CORRECTING THE PROBLEM. THE STALLING OCCURRED AT LOW SPEED AND AT MODERATE SPEED 55 MPH). IT OCCURRED A FEW TIMES WHILE IDLING AT A RED LIGHT. THERE WAS NO INDICATION WHEN IT WILL HAPPEN, IT WAS LIKE SOMEONE PULLED THE PLUG. THE DEALERSHIP COULD NOT DETERMINE THE CAUSE NOR GET AN ERROR CODE ON THE COMPUTER. THEY HAVE REPLACED THE 02 SENSOR TWICE, TH… Look up ODI 10191585 at NHTSA ↗ | 216.7%ODI 10339675 · 6,545 miMY HARLEY DAVIDSON 2008 ROAD KING CHECK ENGINE LIGHT KEEPS COMING ON AND HARLEY DAVIDSON CAN'T SEEN TO OFFER A SOLUTION. THE ERROR CODE IS PO577 AND HAS SOMETHING TO DO WITH THE CRUISE CONTROL. I'VE HAD IT IN 3 TIMES WITH THE SAME RESULTS. NO FIXES. IN TO THE DEALER TWICE UNDER WARRANTY ONE TIME AFTER THAT. *TR Look up ODI 10339675 at NHTSA ↗ | 323.1%ODI 10432529 · 36,750 miI RECENTLY BOUGHT THIS BIKE USED, I BOUGHT IT FROM A NATIONAL MOTORCYCLE COMPANY WHO DEALS IN RENTAL BIKES. I WAS UNAWARE THIS BIKE YEAR (2009) HAD AN ISSUE WITH THE THROTTLE BY WIRE SYSTEM, AS OF TODAY'S DATE I'VE HAVE HAD THREE INSTANCES WHERE THE BIKE HAS WENT INTO BREAK DOWN MODE BECAUSE OF THIS FAULTY SYSTEM. THE PRIOR TWO INCIDENTS WERE DIAGNOSED AND APPARENTLY FIXED BY MY LOCAL BIKE SHOP, BUT THE SAME PROBLEM KEEPS OCCURRING. DURING THE FIRST INCIDENT, MYSELF AND PASSENGER WERE TRAVELING ON INTERSTATE 95 IN SOUTH FLORIDA AT NIGHT, THE B… Look up ODI 10432529 at NHTSA ↗ | 00.0%No examples available for this selection. | 125.0%ODI 11421413ABS warning light comes on. The ABS system had a recall in 2018/19 to change fluid. It supposedly could create an issue if not done every 2 years. This light came on and part needs to be ordered. The service that was done did not even have 1000 miles on it if it even had 500. I believe this module issue should have been part of the recall Look up ODI 11421413 at NHTSA ↗ | 00.0%No examples available for this selection. | 1100.0%ODI 11001924 · 1,000 mi15 AMP CIRCUIT CONTROLLING STOP LIGHTS, TURN SIGNAL, HORN, CRUISE CONTROL WILL FAIL INTERMITTENTLY. CHECKED FUSE AND IS OK. RETURNED TO DEALER TWICE UNDER WARRANTY AND ONCE OUT OF WARRANTY FOR CIRCUIT REPAIRS. PROBLEM FIXED ONLY FOR SHORT PERIOD BUT REAPPEARS. CIRCUIT PROBLEM MAY NOT APPEAR AT TIME OF DEALER REPAIR AS PROBLEM IS INTERMITTENT. CIRCUIT PROBLEM OCCURS WHEN RIDING MOTORCYCLE AND MAY CORRECT ITSELF SEVERAL TIMES. CIRCUIT PROBLEM OCCURRED DURING 2 YEARS OF WARRANTY, 1 AGAIN ABOUT 1.5 YEARS AGO AND LAST WEEKEND JUNE 17, 2017 Look up ODI 11001924 at NHTSA ↗ | 0UnavailableNo examples available for this selection. |
|---|
| Power Train | 214.3%ODI 10466374 · 24,000 miI WAS RIDING MY 2007 HARLEY DAVIDSON ROAD KING CLASSIC AT APPROXIMATELY 60 MPH WITH A PASSENGER WHEN THE BOLTS HOLDING THE REAR SPROCKET TO THE REAR WHEEL STARTED BACKING OUT. THE HEADS OF THE BOLTS STARTED HITTING THE SWING ARM AND SHEARING OFF. AS THIS HAPPENED THE BIKE LURCHED VIOLENTLY AND WAS DIFFICULT TO CONTROL. I WAS ABLE TO SLOW AND PULL TO THE SIDE OF THE ROAD WITHOUT CRASHING. UPON INSPECTION THE BOLTS TORE UP THE REAR WHEEL HUB, THE SPROCKET, AND THE SWING ARM. I WAS LUCKY THAT THE BACK TIRE DIDN'T LOCK UP AND CAUSE ME TO LOSE CONTR… Look up ODI 10466374 at NHTSA ↗ | 216.7%ODI 10690884 · 30,345 miTHE GEAR SHIFT AND HEAL-TOE SHIFT LEVERS FELL OFF THE MOTORCYCLE WHILE TRAVELING ON AN INTERSTATE HIGHWAY AT A SPEED OF ABOUT 75 MPH, LEAVING NO MECHANISM FOR CHANGING GEARS. I HAVE RECEIVED ANECDOTAL INFORMATION FROM MANY OTHER RIDERS OF HARLEY DAVIDSON MOTORCYCLES THAT THE LOSS OF THE HEAL-TOE SHIFT LEVERS IS A FREQUENT OCCURRENCE, AND THEY ARE FORCED TO REPLACE THE SHIFT LEVERS WITH ACCESSORIES FROM INDEPENDENT PARTS MANUFACTURERS. I HAVE WITNESSED MANY SUCH AFTER-MARKET MODIFICATIONS DURING MY TRAVELS. Look up ODI 10690884 at NHTSA ↗ | 215.4%ODI 10899813I WAS HAVING ISSUE WITH BATTERYS GOING BAD AND IT TURNS OUT TO BE THE COMPENSATOR IN WHICH IF I DIDN'T GET FIXED IT COULD HAVE CAUSED ME TO CRASH MY BIKE. IT'S A KNOWN ISSUE WITH IN THESES YEARS FROM 08 TO 2011. Look up ODI 10899813 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. |
|---|
| Vehicle Speed Control | 214.3%ODI 10191585 · 2,886 miRANDOM STALLING OF MOTORCYCLE WHILE BEING OPERATED. THE STALLING HAPPENED NUMEROUS TIMES, APPROXIMATELY 20 TIMES, AND HAS BEEN ONGOING FOR A 5 WEEK PERIOD WITH NO SUCCESS IN DIAGNOSING OR CORRECTING THE PROBLEM. THE STALLING OCCURRED AT LOW SPEED AND AT MODERATE SPEED 55 MPH). IT OCCURRED A FEW TIMES WHILE IDLING AT A RED LIGHT. THERE WAS NO INDICATION WHEN IT WILL HAPPEN, IT WAS LIKE SOMEONE PULLED THE PLUG. THE DEALERSHIP COULD NOT DETERMINE THE CAUSE NOR GET AN ERROR CODE ON THE COMPUTER. THEY HAVE REPLACED THE 02 SENSOR TWICE, TH… Look up ODI 10191585 at NHTSA ↗ | 216.7%ODI 10509345 · 5,000 miWHILE TRAVELING ON THE BELTWAY AT 60 MILES AN HOUR MY MOTORCYCLE WENT INTO A LIMP MODE. SPEED DROPPED TO 15 MILES AN HOUR QUICKLY AND WOULD NOT GO ABOVE 15 MPH. THIS HAS HAPPENED TO ME SEVERAL TIMES. RECENTLY TOOK THE BIKE TO THE DEALER AND THEY REPLACED A SENSOR IN THE HANDLE BAR. THIS DID NOT FIX THE PROBLEM, HAVE TO TAKE THE BIKE BACK TO THE DEALER AGAIN DUE TO THE SAME RECURRING PROBLEM. WHEN THIS OCCURS IT IS VERY SCARY. NOT SURE IF ANYONE HAS BEEN INJURED OR DIED AS A RESULT OF THIS PROBLEM (WHAT I EXPERIENCED IT WILL ONLY BE A MATT… Look up ODI 10509345 at NHTSA ↗ | 17.7%ODI 10510385 · 17,000 miTL* THE CONTACT OWNS A 2009 HARLEY DAVIDSON ROAD KING MOTORCYCLE. THE CONTACT STATED THAT THE THROTTLE WARNING LIGHT ILLUMINATED AND THE VEHICLE ENGAGED INTO IDLE MODE. THE CONTACT STATED THAT THE VEHICLE DID NOT STALL, BUT DID BECOME UNRESPONSIVE. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE THROTTLE SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 17,000. *TR UPDATED 8/5/13 *CN Look up ODI 10510385 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. |
|---|
| Steering | 17.1%ODI 10621181 · 1,200 miWHILE CHANGING LANES ON THE HIGHWAY I ENCOUNTERED A WOBBLE IN THE STEERING. I CHECKED THE STEERING HEAD BEARING FOR PROPER ADJUSTMENT PER FACTORY SPECS AND FOUND IT TO BE PROPERLY ADJUSTED. I HAVE ALWAYS HAD THE SAME WOBBLE AND NOTED WHEN SPEED IS INCREASED THE WOBBLE APPEARS WITHOUT BEING PROVOKED WITH A LEAN ANGLE. I HAVE BEEN RIDING FOR 46 YEARS AND HAVE BEEN TEACHING MOTORCYCLE SAFETY FOR 13 YEARS. I HAVE NEVER HAD ANYTHING LIKE THIS HAPPEN ON ANY OTHER MOTORCYCLE (INCLUDING PREVIOUS HD SPORTSTER). THE BEST WAY I FOUND TO RECOVERING FROM T… Look up ODI 10621181 at NHTSA ↗ | 216.7%ODI 10339611 · 500 miMY 2008 HARLEY DAVIDSON ROAD KING CLASSIC WITH CRUISE CONTROL PULLS TO THE LEFT WHEN HANDS ARE TAKEN OFF THE HANDLE BARS. THE BIKE ONLY HAS 3400 MILES ON IT AND WAS TAKEN TO THE DEALER THE FIRST MONTH I HAD IT FOR THIS PROBLEM. NO FIX FOUND AND NOW THEY HAVE HAD IT FOR 6 WEEKS WITH NO FIX. IF YOU HAVE TO TAKE YOUR HANDS OFF THE BARS FOR A SECOND TO ADJUST YOUR HELMET, GLASSES OR REMOVE A BUG THAT GETS IN YOUR EYE THE BIKE STARTS TO PULL TO THE LEFT AND YOU HAVE TO LEAN VERY FAR TO THE RIGHT TO KEEP IT GOING STRAIGHT. THIS IS A VERY LETHAL P… Look up ODI 10339611 at NHTSA ↗ | 17.7%ODI 10494660 · 18,000 miWHEN DECELERATING, AND BIKE IS BETWEEN 35-45 MPH, A HARSH FRONT END WOBBLE OCCURS. CAN BE LIMITED BY TIGHTLY GRIPPING THE BARS. DEALER INDICATED IT WAS THE TIRES, THOUGH THEY WERE NEW. HAVE REPLACED THE TIRES TWICE SINCE AND STILL NO FIX. DEALER'S SOLUTION NOW IS TO SUSTAIN A HARD GRIP ON THE BARS AT ALL TIMES, WHICH IS UNSAFE AND NOT A PRACTICAL SOLUTION. IN THE INCIDENT ON 6/16/11, IT CAUSED LOSS OF CONTROL AND A SLOW-SPEED TUMBLE FROM THE BIKE, IN WHICH MY ELBOW WAS INJURED. *TR Look up ODI 10494660 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. |
|---|
| Engine | 17.1%ODI 10461619 · 14,500 miTL* THE CONTACT OWNS A 2007 HARLEY DAVIDSON ROAD KING. THE CONTACT STATED THE BURNING FUMES EMITTED FROM THE ENGINE COMPARTMENT. AFTER INSPECTING THE MOTORCYCLE HE NOTICED THAT THREE DIFFERENT WIRE HARNESS MELTED. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 14,500. Look up ODI 10461619 at NHTSA ↗ | 00.0%No examples available for this selection. | 215.4%ODI 10899813I WAS HAVING ISSUE WITH BATTERYS GOING BAD AND IT TURNS OUT TO BE THE COMPENSATOR IN WHICH IF I DIDN'T GET FIXED IT COULD HAVE CAUSED ME TO CRASH MY BIKE. IT'S A KNOWN ISSUE WITH IN THESES YEARS FROM 08 TO 2011. Look up ODI 10899813 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. |
|---|
| Power Train:Manual Transmission | 214.3%ODI 10175518DT*: THE CONTACT STATED THE HARLEY DAVIDSON FLHRC MOTORCYCLES TRANSMISSION MADE A RATTLING SOUND. THE SERVICE DEALER EXPRESSED THERE WAS NO DEFECT OR FIX AVAILABLE. THE CONTACT EXPRESSED CONCERN OF A DEFECT. Look up ODI 10175518 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 125.0%ODI 10290019 · 308 mi10/27/09, DRIVING 2010 HARLEY DAVIDSON 110 SCREAMING EAGLE (FLHTCUSE5), AT APPROX 20 MPH. ENGAGED CLUTCH TO STOP AND IT HAD NO EFFECT, BIKE CONTINUED UNDER POWER. UNABLE TO SHIFT GEARS, SLAMMED ON BREAKS AND BIKE STALLED, IN TRAFFIC. UPON RESTARTING, UNABLE TO SHIFT GEARS, UNABLE TO CONTROL VEHICLE FORWARD MOTION, HAD TO TURN VEHICLE OFF AT INTERSECTIONS TO RETURN 1 ' 2 MILES HOME. DEALERSHIP HAD NO IDEA WHAT COULD CAUSE. SIMPLE INTERNET SEARCH FOUND COMMON PROBLEM WITH HD 110 SCREAMING EAGLE HYDRAULIC CLUTCH. BLEEDING AIR BUBBLES FROM C… Look up ODI 10290019 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. |
|---|
| Engine And Engine Cooling | 214.3%ODI 10173056 · 1,200 miDT*: THE CONTACT STATED THE HEAT FROM THE ENGINE AND EXHAUST CAUSED BURNS TO THE CONTACT'S INNER THIGHS TWICE. THE VEHICLE COULD BE DRIVEN IF THE TEMPERATURE OUTSIDE WAS OVER 75 DEGREES. THE DEALERSHIP AND FACTORY REPRESENTATIVE DETERMINED THE VEHICLE WAS OPERATING UNDER NORMAL CONDITIONS. UPDATED 12/26/2006 - THE 2007 HD TOURING MODELS HAVE A NEW AND BIGGER ENGINE. THE EXHAUST PIPES ON THESE MODELS ARE 450-600 DEGREE F AND ARE ONLY 3-4 INCHES FROM THE DRIVER'S LEGS. THEY CAUSED BURNS, ARE DISTRACTING, AND UNCOMFORTABLE. *NM Look up ODI 10173056 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. |
|---|