| Service Brakes | 00.0%No examples available for this selection. | 3037.0%ODI 10505496 · 38,400 miCOMPLETE FAILURE OF REAR BRAKE. LINE FAILURE DUE TO CHAFING FROM CLUTCH CABLE AND LOSS OF FLUID. *TR Look up ODI 10505496 at NHTSA ↗ | 3550.0%ODI 10721585 · 9,350 miRIDING MY 09 HARLEY ULTRA, WHEN AT LOW SPEED I HAD TO STOP FOR A CAR STOPPED TO MAKE A LEFT TURN. THE FRONT BRAKE LEVER WAS FROZEN AND COULD NOT APPLY THE BRAKE. I SWERVED OFF INTO THE GRASS TO AVOID HITTING THE CAR. THE REAR BRAKES STILL WORKED BUT AT SLOW SPEEDS I USE THE FRONT SO I CAN PUT MY FEET DOWN WHEN THE BIKE COMES TO A STOP. THIS IS A VERY DANGEROUS SITUATION. AT HIGHER SPEEDS THIS WOULD ABSOLUTELY BE FATAL!! HARLEY CLAIMS THAT IF THE ABS FAILS DUE TO AN ELECTRICAL MALFUNCTION THAT IT WILL " FAIL SAFE" WITH NORMAL, NON ABS BRAKING. T… Look up ODI 10721585 at NHTSA ↗ | 929.0%ODI 10503346 · 8,805 miABS BRAKE SYSTEM MALFUNCTION, WILL NOT ACTIVATE. *TR Look up ODI 10503346 at NHTSA ↗ | 350.0%ODI 10818724 · 10 miI OWN AND OPERATE A HARLEY DAVIDSON FLHTCU ULTRA CLASSIC. WHILE RIDING ON THE HIGHWAY I TRIED TO USE MY FRONT BRAKES TO STOP AT A RED LIGHT AND THE BRAKE LEVER WAS HARD AS A ROCK AND WAS NOT ABLE TO MAKE IT FUNCTION TO STOP THE BIKE, HAD TO RELY ON MY REAR BRAKES WHICH PUT ME IN AN SLIDE BECAUSE OF THE HARD BREAKING TO COMPENSATE FOR THE FRONT BRAKES MALFUNCTION. I MANAGED TO RETURN HOME USING MY REAR BRAKES ONLY. THE MALFUNCTION OF THE FRONT ABS BRAKES OCCURRED WITHOUT NOTICE AND IT IS A HAZARDOUS CONDITION. WHEN I CONTACTED THE LOCAL HD DEA… Look up ODI 10818724 at NHTSA ↗ | 342.9%ODI 10994276 · 35,032 miWE WERE ON A ROAD TRIP AND WHILE TRAVELING IN THE HILL COUNTRY WE STARTED HEARING A POPPING SOUND WHICH AT FIRST THOUGHT IT WAS THE ROAD TAR POPPING BECAUSE IT WAS HOT OUT. AS WE WERE DESCENDING DOWN THE HILL I APPLIED THE REAR BRAKES AND FOUND THAT THEY WENT ALL THE WAY DOWN AND THE VEHICLE FAILED TO SLOW. I APPLIED THE BRAKES SEVERAL TIMES AND THEY FAILED TO WORK. THE POPPING CONTINUED AT WHICH WE REALIZED IT WAS THE BRAKES. WHEN WE GOT THE A MOTORCYCLE STOPPING SPOT AND LET THE BIKE SET FOR A WHILE THE BRAKES CAME BACK AND WERE WORKING AGAIN… Look up ODI 10994276 at NHTSA ↗ | 222.2%ODI 10598041 · 20 miPURCHASED THE 2014 H-D ELECTRAGLIDE ULTRA CLASSIS THE DAY BEFORE REALIZING THE EXISTENCE OF THE DEFECT DESCRIBED HEREIN. WHILE RIDING AT APPROXIMATELY 60 MPH, I SET THE CRUISE CONTROL. THE CRUISE CONTROL IS TO DISENGAGE UPON APPLICATION OF ANY OF THE FOLLOWING: FRONT BRAKE/BACK BRAKE/CLUTCH/ROLLING THE THROTTLE FORWARD. UPON NEARING A VEHICLE AHEAD OF ME, I 'TAPPED' THE FRONT BRAKE; THIS ACTION, HOWEVER DID NOT DISENGAGE THE CRUISE CONTROL. I TRIED AGAIN, USING MORE FORCE ON THE FRONT BRAKE LEVER...AGAIN, THE CRUISE CONTROL REMAINED ENGAGED. I … Look up ODI 10598041 at NHTSA ↗ | 00.0%No examples available for this selection. | 116.7%ODI 10991204 · 4,210 miSCENARIO: 2016 ULTRA 4200 MILES THAT I PURCHASED WITH ZERO MILES FROM THE DEALER. IT HAS ALWAYS BEEN SERVICED BY THE DEALER AS WELL. THE BRAKES WERE FINE. I PARKED AT A RESTAURANT AND WHEN I CAME BACK OUTSIDE I PULLED UP TO THE STREET AND HAD BRAKES. I PULLED OUT ONTO THE STREET AND I HAD NO BRAKES WHATSOEVER ON MY BACK BRAKES AND MY FRONT BRAKES WERE DOING SOME KIND OF GRABBY ON OFF THING AT 10MPH. IT WAS SCARY AS HELL, NO BACK BRAKES AND ALMOST NO FRONT BRAKES. THE BACK BRAKES JUST WENT DOWN ALL OF THE WAY. I HAD TO TRAILER THE… Look up ODI 10991204 at NHTSA ↗ | 125.0%ODI 11494224ABS module failure resulting in front brake locking up. ABS module failed resulting in brake failure. While I was not involved in any incident the failed part showed no signs of beginning to fail. One day I I got onto the motorcycle and when I went to squeeze the front brake it was hard as a rock and it locked up my front wheel. This particular failure happened in my driveway so nobody was in danger but it also had no warning lights on or gave any signs of failure prior to this incident. If this were to happen while riding the motorcycle it c… Look up ODI 11494224 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
|---|
| Power Train | 612.5%ODI 10171068 · 15 miI BOUGHT A 2007 ELECTRA GLIDE ULTRA BY HARLEY DAVIDSON ON SEPT. 8, 2006. I RETURNED THE BIKE ON SEPT. 9, 2006 SAYING IN WAS MAKING TO MUCH NOISE. THEY RODE IT AND SAID IT NEEDED TO BE BROKE IN, AND PUT 1/2 QUART OF TRANSMISSION FLUID IN. I RODE THE BIKE 500 MILES AND RETURNED THE BIKE ON SEPT. 12, 2006 STATING THAT THE PRIMARY SOUNDED LIKE A CAN FULL OF ROCKS, THE 5TH GEAR IN THE TRANSMISSION WHINED SO BAD IT SOUNDED LIKE AN AMBULANCE, AND THE VALVES WERE RATTLING SO BAD THAT YOU COULD NOT HEAR YOURSELF THINK, AND THE EXHAUST PIPES HAD ALREA… Look up ODI 10171068 at NHTSA ↗ | 78.6%ODI 10239666 · 500 miOUT FOR AN AFTERNOON RIDE WITH FRIENDS ON MY 08 ELECTRA GLIDE ULTRA CLASSIC. WHILE ENTERING A LEFT CURVE, THE THROTTLE ACCELERATED ON ITS OWN. THIS CAUSED THE BIKE TO SPEED UP UNEXPECTEDLY AND DRIFT RIGHT. TRIED RETARDING THE THROTTLE AND GOT NO RESPONSE. DEPRESSED THE CLUTCH AND APPLIED REAR BRAKES IN ATTEMPT TO SLOW THE BIKE DOWN WITHOUT RESULTS. THIS RESULTED IN A SERIOUS SINGLE RIDER CRASH WITH LIFE THREATENING INJURIES. THIS BIKE HAS FLY-BY-WIRE THROTTLE. HARLEY DAVIDSON CUSTOMER SERVICE STATES THAT THEY HAVE BEEN AWARE OF THROTT… Look up ODI 10239666 at NHTSA ↗ | 57.1%ODI 10510059 · 50,000 miMY BIKE IS A 2009 ULTRA CLASSIC. I SENT THIS TO ATT: HARLEY DAVIDSON CUSTOMER SERVICE LEAD/MANAGER, AND REALLY GOT NOWHERE WITH THIS ISSUE. I TOOK IT UPON MYSELF TO CHECK ON WHY I HAVE BEEN SEEING GRINDINGS ON MY DRAIN PLUG FROM MY PRIMARY CHAIN CASE. HERE, I FOUND A PIECE OF METAL 7"X 1/2" WIDE STUCK BETWEEN MY PRIMARY CHAIN AND THE CLUTCH PACK GRINDING AWAY TO BREAK AND LODGE INTO THE GEARING WHICH COULD HAVE LOCKED UP THE REAR TIRE. THE METAL IS OFF THE COMPENSATOR BELL HOUSING ( A VERY POOR DESIGN) FROM THE SPRING DISC FLOPPING INSIDE IT WE… Look up ODI 10510059 at NHTSA ↗ | 722.6%ODI 10349293 · 6,525 miTHE 6TH GEAR INDICATOR GOES OUT ON MY 2010 HARLEY FLHTCU AT DIFFERENT TIMES AND FOR NO APPARENT REASON. THIS IS DANGEROUS BECAUSE IF YOU HAVE THE CRUISE CONTROL ENGAGED IT GOES OFF AND WILL NOT WORK UNTIL YOU TURN THE BIKE ON AND OFF AGAIN. *TR Look up ODI 10349293 at NHTSA ↗ | 00.0%No examples available for this selection. | 228.6%ODI 10586584 · 1,890 miWHILE UP-SHIFTING GEARS FROM 2ND TO 3RD THE CLUTCH FAILED AND I COULD NOT DISENGAGE THE TRANSMISSION. I MANUALLY DOWN-SHIFTED TO FIRST TO SLOW DOWN THEN TURNED INTO A PARKING LOT TO GET OUT OF TRAFFIC AND TRIED TO FIND NEUTRAL TO BE ABLE TO STOP SAFELY BUT RAN OUT OF SPACE BEFORE I HAD TO APPLY THE BRAKES AND STALL THE ENGINE. AS THE ENGINE BEGAN TO STALL THE MOTORCYCLE STARTED TO JUMP & BUCK AND I LOST CONTROL AND FELL OVER. I EXTENDED MY LEG TO TRY AND STAY UPRIGHT BUT COULD NOT HOLD THE BIKE UPRIGHT AND SPRANG OR JAMMED MY KNEE. I CHECKE… Look up ODI 10586584 at NHTSA ↗ | 444.4%ODI 10594273 · 4,884 miTL* THE CONTACT OWNS A 2014 HARLEY DAVIDSON ELECTRA GLIDE FLHTCU. THE CONTACT STATED THAT AFTER HAVING THE VEHICLE REPAIRED UNDER THE NHTSA CAMPAIGN NUMBER: 13V515000 (POWER TRAIN); THE CLUTCH FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE CLUTCH MASTER CYLINDER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 4,884. Look up ODI 10594273 at NHTSA ↗ | 150.0%ODI 10884336TL* THE CONTACT OWNS A 2015 HARLEY-DAVIDSON ULTRA FLHTCU. THE CONTACT STATED THAT THE RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 15V2160000 (POWER TRAIN) WAS RECEIVED IN AUGUST OF 2015. AFTER CONTACTING THE DEALER ON MULTIPLE OCCASIONS, THE PARTS WERE NOT AVAILABLE UNTIL JULY OF 2016, IN WHICH TIME THE MOTORCYCLE WAS REPAIRED. THE CONTACT WAS CONCERNED THAT IT TOOK THE MANUFACTURER NEARLY ONE YEAR TO DISTRIBUTE THE PARTS NEEDED TO REPAIR THE SAFETY DEFECT. THE MANUFACTURE WAS NOT CONTACTED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. Look up ODI 10884336 at NHTSA ↗ | 116.7%ODI 11123500 · 9,200 miPURCHASED A NEW 2016 ULTRA CLASSIC HARLEY DAVIDSON NOW HAS 9200 MILE THE COMPENSATOR STARTED TO RATTLE BEFORE I WAS ABLE TO MAKE IT HOME THE COMPENSATOR WENT COMPLETELY WHILE DRIVING ON HIGHWAY Look up ODI 11123500 at NHTSA ↗ | 125.0%ODI 11750346 · 45,490 miThe contact owns a 2017 Harley-Davidson FLHTCU. The contact stated that while riding at 5 MPH, the motorcycle failed to shift out of gear or stop as needed. The motorcycle fell over on the contact’s right leg, causing the leg to become swollen. The contact used a bag of ice to help with the swelling. The motorcycle was repaired under NHTSA Campaign Number: 18V734000 (Power Train); however, the failure persisted. The dealer was not contacted. The manufacturer was made aware of the failure. The failure mileage was approximately 45,490. Look up ODI 11750346 at NHTSA ↗ | 1100.0%ODI 11471487 · 17,000 miThe contact owns a 2018 Harley-Davidson FLHTCU. The contact stated that upon starting the motorcycle, the clutch released independently without warning. Due to the failure, the contact was forcefully jerked backwards while on the motorcycle. The motorcycle was taken to a dealer by trailer and the contact was informed that fluid in the secondary clutch actuator cylinder had leaked into the transmission. The contact was given an estimate for the repair. Upon investigation, the contact discovered that prior to owning the motorcycle, the motorcycle… Look up ODI 11471487 at NHTSA ↗ | 1100.0%ODI 11245658 · 1,012 miTL* THE CONTACT OWNS A 2019 HARLEY-DAVIDSON ELECTRA GLIDE (FLHTCU). WHILE THE VEHICLE WAS BEING SERVICED AT CAPRARA BROTHERS/F.X. CAPRARA MOTORCYCLES, INC. (LOCATED AT 17890 GOODNOUGH ST, ADAMS CENTER, NY 13606, [phone removed]), THE CONTACT WAS INFORMED THAT TRANSMISSION FLUID WAS LEAKING INTO THE PRIMARY CASE. THE CONTACT STATED THAT THE DEALER WAS ABLE TO INSTALL A KIT IN THE MOTORCYCLE TO PREVENT FURTHER LEAKS. THE CONTACT WAS CONCERNED THAT THE TRANSMISSION CASE COULD LOSE ALL FLUIDS WITHOUT THE RIDER KNOWING, WHICH COULD CAUSE A CATASTROP… Look up ODI 11245658 at NHTSA ↗ |
|---|
| Vehicle Speed Control | 36.3%ODI 10194998ON JUNE 26, 2007 I WAS HEADING HOME IN A 2007 HARLEY DAVIDSON ULTRA CLASSIC WHEN I NOTICED THE IDLE SPEED CONTINUED TO INCREASE. EVERY TIME I ENGAGED THE CLUTCH THE ENGINE SPEED WOULD TAKE AN EXCESSIVE AMOUNT OF TIME TO DECREASE, AND THE IDLE SPEED WOULD CONTINUALLY INCREASE EACH TIME. I CALLED THE DEALERSHIP TO GET THE MOTORCYCLE INSPECTED. ON THE WAY TO THE DEALERSHIP THE ENGINE SPEED WAS AROUND 3600 RPMS. HOWEVER, THE NORMAL SPEED WAS 800 RPMS. DUE TO THE ENGINE IDLE SPEED NOW THE SAME AS RUNNING SPEED, IT WAS EXTREMELY DIFFICULT TO … Look up ODI 10194998 at NHTSA ↗ | 44.9%ODI 10448488 · 31,540 miWHILE RIDING AT 60MPH, THE ENGINE SLOWED THE BIKE DOWN TO 25MPH. I WAS LUCKY THAT I WAS NOT IN TRAFFIC WHERE A SURPRISE SLOW DOWN WOULD HAVE BEEN VERY DANGEROUS. I WAS ABLE TO RIDE THE BIKE ON THE SHOULDER AT 25MPH, AND LET TRAFFIC GO AROUND ME UNTIL THERE WAS AN OPPORTUNITY TO SAFELY GET OFF OF THE ROAD. I TURNED THE ENGINE OFF AND WAITED 4 TO 5 MINUTES. I THEN RESTARTED THE ENGINE, THE ENGINE RESPONDED NORMALLY, AND I RODE HOME WITH NO FURTHER PROBLEMS. THIS HAS HAPPENED 2 MORE TIMES OVER THE LAST 3 MONTHS. THE LAST TIME WAS THE MOST D… Look up ODI 10448488 at NHTSA ↗ | 1115.7%ODI 10246884 · 225 miPURCHASED NEW 2009 FLHTCU ELECTRA GLIDE CLASSIC, BIKE IS AT DEALER FOR 3RD TIME, FOR BUCKING A SURGING, ENGINE CUTS IN AND OUT, WHILE THROTTLE POSITION SENSOR AND RPM DO NOT CHANGE, CAUSING BIKE TO JUST SURGE OUT OF CONTROL. DEALER OCEAN COUNTY HARLEY DAVIDSON HAS REPLACED EVERY SENSOR AND ECM AND BIKE GETS WORSE. IT IS UNRIDEABLE AND DOWNRIGHT DANGEROUS! I REFUSE TO TAKE MY LIFE AND PUT IT IN THE HANDS OF HARLEY DAVIDSON WHO DOES NOT SEEM TO GIVE A DARN WHETHER I GET KILLED ON THIS THING. *TR Look up ODI 10246884 at NHTSA ↗ | 722.6%ODI 10349293 · 6,525 miTHE 6TH GEAR INDICATOR GOES OUT ON MY 2010 HARLEY FLHTCU AT DIFFERENT TIMES AND FOR NO APPARENT REASON. THIS IS DANGEROUS BECAUSE IF YOU HAVE THE CRUISE CONTROL ENGAGED IT GOES OFF AND WILL NOT WORK UNTIL YOU TURN THE BIKE ON AND OFF AGAIN. *TR Look up ODI 10349293 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 222.2%ODI 10598041 · 20 miPURCHASED THE 2014 H-D ELECTRAGLIDE ULTRA CLASSIS THE DAY BEFORE REALIZING THE EXISTENCE OF THE DEFECT DESCRIBED HEREIN. WHILE RIDING AT APPROXIMATELY 60 MPH, I SET THE CRUISE CONTROL. THE CRUISE CONTROL IS TO DISENGAGE UPON APPLICATION OF ANY OF THE FOLLOWING: FRONT BRAKE/BACK BRAKE/CLUTCH/ROLLING THE THROTTLE FORWARD. UPON NEARING A VEHICLE AHEAD OF ME, I 'TAPPED' THE FRONT BRAKE; THIS ACTION, HOWEVER DID NOT DISENGAGE THE CRUISE CONTROL. I TRIED AGAIN, USING MORE FORCE ON THE FRONT BRAKE LEVER...AGAIN, THE CRUISE CONTROL REMAINED ENGAGED. I … Look up ODI 10598041 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
|---|
| Electrical System | 00.0%No examples available for this selection. | 44.9%ODI 10267538 · 8,300 mi2008 HARLEY DAVIDSON FLHTCUI (ULTRA CLASSIC. ENGINE QUIT WHILE CRUISING AT 50MPH. DIAGNOSED AS IGNITION COIL FAILURE. *TR Look up ODI 10267538 at NHTSA ↗ | 1014.3%ODI 10246884 · 225 miPURCHASED NEW 2009 FLHTCU ELECTRA GLIDE CLASSIC, BIKE IS AT DEALER FOR 3RD TIME, FOR BUCKING A SURGING, ENGINE CUTS IN AND OUT, WHILE THROTTLE POSITION SENSOR AND RPM DO NOT CHANGE, CAUSING BIKE TO JUST SURGE OUT OF CONTROL. DEALER OCEAN COUNTY HARLEY DAVIDSON HAS REPLACED EVERY SENSOR AND ECM AND BIKE GETS WORSE. IT IS UNRIDEABLE AND DOWNRIGHT DANGEROUS! I REFUSE TO TAKE MY LIFE AND PUT IT IN THE HANDS OF HARLEY DAVIDSON WHO DOES NOT SEEM TO GIVE A DARN WHETHER I GET KILLED ON THIS THING. *TR Look up ODI 10246884 at NHTSA ↗ | 516.1%ODI 10455951 · 17,900 miRIDING ALONG AT 60 MPH WHEN THE BIKE WENT INTO "LIMP MODE". I IMMEDIATELY LOST ALL THROTTLE RESPONSE AND MY SPEED INSTANTLY DROPPED TO 10 MPH. ONCE THE BIKE GOES INTO THIS "LIMP MODE", THE SPEED IS AUTOMATICALLY LIMITED TO 10 MPH. THE ENGINE LIGHT CAME ON AND I HAD TO RIDE AT 10 MPH DOWN A BUSY STREET WITH MY FLASHERS ON TO PREVENT GETTING REAR ENDED BY ALL THE CARS. THIS "LIMP MODE" IS A KNOWN ISSUE WITH HARLEY DAVIDSON (CHECK IT OUT ON GOOGLE OR AT HDFORUMS.COM. HARLEY IS APPARENTLY REFUSING TO ACKNOWLEDGE THE ISSUE WITH THE BIKES. THRO… Look up ODI 10455951 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 111.1%ODI 10794565 · 14,600 miAFTER USING THE USB AS A MEDIA SOURCE, THE NEXT TIME THE MOTORCYCLE IS POWER CYCLED THE STEREO DEFAULTS TO FM AND RESETS THE FADE CONTROL. HARLEY INITIALLY SAID THIS WAS DUE TO SOFTWARE, BUT THEN CHANGED TO SAYING IT WAS NORMAL OPERATION. ON NOVEMBER 16TH, I SPOKE WITH CASE MANAGER (JOHN), WHO ADVISED THAT THIS IS DUE TO THE SYSTEM SENSING A VOLTAGE CHANGE WHEN SHUTTING DOWN. I HAVE REPLACED THE HEAD UNIT TWICE; ONCE WITH A FACTORY REFURBISHED DEVICE, AND THEN WITH A 2015 MODEL. I MUST NOTE THAT I DID NOT HAVE THIS ISSUE FOR THE FIRST 2 YEARS O… Look up ODI 10794565 at NHTSA ↗ | 150.0%ODI 11316843 · 150,000 miAFTER RIDING IN THE RAIN. BIKE WAS STATIONARY. . ALL GAUGES (SPEEDO, TACH, FUEL & VOLT) WENT OUT. NEXT DAY CAME BACK ON. BIKE WAS STATIONARY. BUT A WEEK LATER WENT OUT AGAIN AND STILL OUT. BIKE WAS STATIONARY. Look up ODI 11316843 at NHTSA ↗ | 116.7%ODI 11048522 · 3,000 miELECTRICAL SYSTEM MALFUNCTION. SCREEN FOR GPS AND RADIO STOPPED WORKING Look up ODI 11048522 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
|---|
| Engine And Engine Cooling | 918.8%ODI 10174225 · 4 mi2007 HARLEY DAVIDSON FLHTCUI, EXPERIENCING INTENSE HEAT FROM THE RIGHT REAR CYLINDER, WHEN THE BIKE IS STOPPED IN TRAFFIC IT IS UNBEARABLE, I AM FEARFUL IT WILL BURN THE UNDERSIDE OF MY RIGHT THIGH. DISCUSSED WITH THE DEALER AND WAS TOLD, THERE IS NOTHING THAT CAN BE DONE. IT WAS SUGGESTED THAT I REMOVE THE LOWER FAIRINGS, BUT THIS HAD NO EFFECT ON THE HEAT WHEN THE BIKE WAS STOPPED. AS I SAID, I AM AFRAID I WILL BE BURNED BY THIS. *NM Look up ODI 10174225 at NHTSA ↗ | 44.9%ODI 10238995 · 250 miTHE THROTTLE CONTROL ON THE MOTORCYCLE IS A "THROTTLE BY WIRE" TYPE OF CONTROL AND THE IDLE POSITION DOES NOT REMAIN CONSTANT. ONE TIME THE MOTOR WILL IDLE AT 1050 RPM'S AND THE NEXT TIME IT WILL IDLE AT 1400 RPM'S. ALSO WHILE DRIVING THE MOTORCYCLE THE IDLE POINT WILL INCREASE AND YOU CAN END UP WITH THE "IDLE POINT" AT 1800 RPM'S WHEN IT SHOULD BE SETTING AT 1050RPM'S. HARLEY DAVIDSON HAS NOT TAKEN ANY ACTION TO ADDRESS THIS HIGH IDLE CONDITION AND IT PUTS THE DRIVER AND PASSENGER IN DANGER OF A ACCIDENT. *TR Look up ODI 10238995 at NHTSA ↗ | 57.1%ODI 10246013 · 533 miTHIS VEHICLE IS A NEW HARLEY-DAVIDSON 2009 FLHTUCTG TRI-GLIDE TRIKE, THAT WENT IN FOR IT'S FIRST 500 (ACTUAL MILES 533) MILE SERVICE CHECK. AT DEPARTURE OF THE DEALERSHIP AFTER THE SERVICE WAS COMPLIED WITH, AND WITHIN 1 MILE, I HEARD A NOISE FROM UNDERCARRIAGE OF THE TRIKE, AT WHICH I COULD NOT DETERMINE WHAT THE SOUND WAS AT THE TIME. I BACKED UP AND LOOKED FOR ANYTHING THAT MAY HAVE FALLEN OFF OF THE TRIKE WITH NO AVAIL, AS IT WAS DARK AT THE TIME OF LEAVING THE DEALERSHIP, AND CONTINUED HOME (ABOUT 30 MILES AWAY). THE NEXT DAY I RODE… Look up ODI 10246013 at NHTSA ↗ | 13.2%ODI 10455951 · 17,900 miRIDING ALONG AT 60 MPH WHEN THE BIKE WENT INTO "LIMP MODE". I IMMEDIATELY LOST ALL THROTTLE RESPONSE AND MY SPEED INSTANTLY DROPPED TO 10 MPH. ONCE THE BIKE GOES INTO THIS "LIMP MODE", THE SPEED IS AUTOMATICALLY LIMITED TO 10 MPH. THE ENGINE LIGHT CAME ON AND I HAD TO RIDE AT 10 MPH DOWN A BUSY STREET WITH MY FLASHERS ON TO PREVENT GETTING REAR ENDED BY ALL THE CARS. THIS "LIMP MODE" IS A KNOWN ISSUE WITH HARLEY DAVIDSON (CHECK IT OUT ON GOOGLE OR AT HDFORUMS.COM. HARLEY IS APPARENTLY REFUSING TO ACKNOWLEDGE THE ISSUE WITH THE BIKES. THRO… Look up ODI 10455951 at NHTSA ↗ | 116.7%ODI 10408742 · 356 miHARLEY DAVIDSON TRI GLIDE 2011 MOTORCYCLE EXCESSIVE HEAT BLOWING FROM RIGHT SIDE OF ENGINE WHILE RIDING OVER 55 MPH FOR 25 MINUTES AT A TIME OVER 2 HOUR PERIOD CAUSED 2ND DEGREE BURNS, BLISTERS, SCABBING AND SCARRING TO BACK OF RIGHT LEG. 356 TOTAL MILES ON MOTORCYCLE PURCHASED NEW. HD INSPECTION POST INJURY STATES THE MOTORCYCLE IS OPERATING PER SPECIFICATIONS TO MEET EPA STANDARD. NO ALTERATIONS AND UNDER WARRANTY. *TR Look up ODI 10408742 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
|---|
| Engine | 24.2%ODI 10485130 · 10,868 miTL* THE CONTACT OWNS A 2007 HARLEY DAVIDSON FLHTCU MOTORCYCLE. WHILE DRIVING APPROXIMATELY 35 MPH, THE OIL PRESSURE WARNING LIGHT ILLUMINATED AS THE ENGINE BEGAN TO VIBRATE ABNORMALLY. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN ADVISED THE CONTACT THAT THE SHIFTING FLY WHEEL WOULD HAVE TO BE REPLACED. THE SHIFTING FLY WHEEL ALSO CAUSED THE OIL PUMP TO BECOME FRACTURED. THE TECHNICIAN ALSO ADVISED THAT THERE WERE NO APPROVED FACTORY REMEDIES THAT WOULD REPAIR THE FAILURE. THE TECHNICIAN SUGGESTED THAT THE CONTACT… Look up ODI 10485130 at NHTSA ↗ | 33.7%ODI 10488104 · 70,000 miTL* THE CONTACT OWNS A 2008 HARLEY DAVIDSON FLHTCU. THE CONTACT ATTEMPTED TO START THE VEHICLE BUT FLAMES WERE COMING FROM THE CARBURETOR. THE CONTACT ATTEMPTED TO RESTART THE VEHICLE AND THE FAILURE RECURRED. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE TO THE DEALER TO BE INSPECTED; HOWEVER, THEY WOULD NOT ADDRESS THE CAUSE OF FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND STATED THEY WOULD REPLACE THE COMPENSATOR ASSEMBLY AT HIS EXPENSE. THE FAILURE MILEAGE WAS 70,000. Look up ODI 10488104 at NHTSA ↗ | 68.6%ODI 10515560 · 15,245 miTRAVELING ON MAJOR HIGHWAY AND THE SPEED DROPS TO 15 MPH HARLEY DAVIDSON CALLS IT LIMP MODE , SECOND TIME IT HAS HAPPENED NOT FUN ON THE HIGHWAY. HARLEY DEALER SAYS THEY CANNOT FIND ANYTHING WRONG. *TR Look up ODI 10515560 at NHTSA ↗ | 412.9%ODI 10584426 · 23,000 miAS PER SERVICE BULLETIN ; TT418-A ,ELECTRICAL CONNECTOR CORROSION AND FRETTING CAUSING THE ENGINE TO SHUT DOWN DUE TO VIBRATION . THIS SITUATION IS HAZARDOUS AS THE BIKE CAN FAIL IN HEAVY TRAFFIC AND INTERSECTIONS . HARLEY DAVIDSON IS AWARE OF THIS SITUATION SENSE 2008 . AS TO DATE THERE IS NO RECALL PLANNED. *TR Look up ODI 10584426 at NHTSA ↗ | 00.0%No examples available for this selection. | 114.3%ODI 10607984 · 2,800 miTL* THE CONTACT OWNS A 2013 HARLEY DAVIDSON FLHTCU. THE CONTACT STATED THAT THE CATALYTIC CONVERTER WAS CONTINUOUSLY OVERHEATING AND CAUSING THE HEAT SHIELD TO FAIL. THE CONTACT WAS CONCERNED ABOUT THE POTENTIAL OF THE FAILURE CAUSING SEVERE BURNS. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN STATED THAT THE VEHICLE WAS WORKING NORMALLY. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 2,800. THE CURRENT MILEAGE WAS 2,900. Look up ODI 10607984 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 125.0%ODI 11242859 · 13,500 miHEAD GASKET LETS LOOSE AND OIL ALL OVER REAR TIRE! VEHICLE ON HIGHWAY IN MOTION, NOT GOOD. Look up ODI 11242859 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
|---|
| Service Brakes, Hydraulic | 36.3%ODI 10275871 · 25,000 miBRAKE FAILURE OF REAR BRAKE ON 2007 HARLEY DAVIDSON MODEL FLHTCUI .REAR BRAKE FAILED TO OPERATE BECAUSE BRAKE LINE DEVELOPED A SMALL HOLE FROM ABRASION BY CONTACT WITH THE CLUTCH CABLE. *TR Look up ODI 10275871 at NHTSA ↗ | 56.2%ODI 102083742008 HARLEY DAVIDSON MOTORCYCLE DEFECTIVE FRONT BRAKE SYSTEM. CONSUMER STATED THAT HE GOT INTO AN ACCIDENT THE DAY HE BOUGHT THE MOTORCYCLE. MECHANIC STATED THAT THERE WAS NOTHING WRONG WITH THE MOTORCYCLE. *KB THE CONSUMER STATED AS HE WAS ATTEMPTING TO STOP, HE BEGAN TO GEAR THE MOTORCYCLE DOWN FROM A SPEED OF 35 MPH AND BEGAN TO FEATHER THE FRONT BRAKE TO REDUCE SPEED. THE SECOND TIME HE GENTLY SQUEEZED THE FRONT BRAKE HANDLE, AND IT DIDN'T FEEL COMPLETELY NORMAL. THE THIRD TIME HE TOUCHED THE BRAKE LEVER THE FRONT BRAKE AND WHEEL COMPLETE… Look up ODI 10208374 at NHTSA ↗ | 34.3%ODI 10423261 · 24,925 miREAR BRAKE LIGHT PRESSURE SWITCH FAILURE. THE SWITCH WHICH TRIGGERS THE REAR BRAKE LIGHT TO TOGGLE ON WHEN THE REAR BRAKE LEVER IS DEPRESSED IS A HYDRAULIC PRESSURE SWITCH. THIS SWITCH FAILED ALLOWING BRAKE FLUID TO PASS THROUGH THE SWITCH AND SPRAY OUT THE END WHERE THE TERMINALS ARE ATTACHED. THIS SPRAYING FLUID CAUGHT FIRE DUE TO THE HEAT OF THE EXHAUST PIPE WHICH IS CLOSE BY. BIKE WAS SITTING AT A LIGHT WHEN I SMELLED SOMETHING BURNING. A RIDING BUDDY NOTICED A SMALL FIRE LOCATED JUST BELOW THE RIGHT SIDE PASSENGER FLOORBOARD. I WAS STOPPED… Look up ODI 10423261 at NHTSA ↗ | 13.2%ODI 11097969 · 21,250 miTL* THE CONTACT OWNS A 2010 HARLEY-DAVIDSON FLHTCU. WHILE DRIVING 20 MPH, THE REAR BRAKE PEDAL FAILED TO OPERATE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 18V076000 (SERVICE BRAKES, HYDRAULIC). THE MOTORCYCLE WAS TAKEN TO BLUE RIDGE HARLEY-DAVIDSON (2002 13TH AVE DR. SE, HICKORY, NC 28602) WHERE THE RECALL WAS REPAIRED ALONG WITH SOME OTHER UNKNOWN BRAKE REPAIRS. THE CONTACT STATED THAT THE BRAKE REPAIRS THAT HE PAID FOR SHOULD HAVE BEEN INCLUDED IN THE RECALL. THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE FAILURE MILEAGE WAS 2… Look up ODI 11097969 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
|---|
| Wheels | 00.0%No examples available for this selection. | 33.7%ODI 10414250 · 19,500 miI WAS RIDING AT ABOUT 60 MPH WHEN MY FRONT WHEEL BEARING STARTED TO FAIL (NOISE ONLY, NOT CATASTROPHIC). I WAS NEXT TO AN INDEPENDENT HARLEY SHOP AND WAS ABLE TO GET THE BEARING REPLACED. DURING A CONVERSATION WITH THE OWNER, I LEANED THAT HARLEY CHANGED WHEEL BEARING WITH 2007 MODELS. HE HAD NEVER REPLACED A WHEEL BEARING, EXCEPT ON BIKES WITH VERY HIGH MILEAGE, PRIOR TO THE 2007 MODEL. HE HAS CHANGED AN ALARMING NUMBER ON 2007 AND NEWER MODELS WITH AROUND 20000 MILES ON THE ODOMETER. I PICKED UP A JULY '11 THUNDER PRESS MOTORCYCLE NEWSPAPER… Look up ODI 10414250 at NHTSA ↗ | 45.7%ODI 10354512 · 23,000 miHAD A FRONT WHEEL BEARING FAILURE ON A 09 HARLEY ULTRA WITH 23000 MILES AT FULL INTERSTATE SPEED. BIKE STARTED VIBRATING BAD AND WAS ABLE TO PULL TO SIDE OF ROAD. HAD TO WRECKER IT HOME 250 MILES. *TR Look up ODI 10354512 at NHTSA ↗ | 26.5%ODI 10515839 · 17,000 miWHILE RIDING I BEGAN TO FEEL A VIBRATION IN THE HANDLEBARS I HADN'T FELT BEFORE TODAY. IT DIDN'T SEEM TO AFFECT ANYTHING ELSE. AFTER PARKING THE BIKE AND CONDUCTING A VISUAL INSPECTION I FOUND A SEAL ON THE LEFT FRONT WHEEL BEARING HAD SEPARATED EXPOSING THE BALL BEARINGS. IT APPEARED TO HAVE LOST 1-2 BALLS DUE TO THE METAL RINGS THAT RETAIN THE BALLS HAD BROKEN IN SEVERAL PLACES. *TR Look up ODI 10515839 at NHTSA ↗ | 116.7%ODI 10748553 · 11,720 miNOTICED INCREASING WOBBLE IN TURNS, HANDLE BARS SHAKE AT OCCASION, TOOK TO DEALER, HE TEST RODE AND SAID IT WAS THE FRONT WHEEL BEARINGS WERE SHOT, AND THAT THIS IS A COMMON OCCURRENCE ON 09-12 HARLEYS, HE SAID HARLEY HAS SINCE BEEN USING A DIFFERENT BEARING, AND THAT THE REPLACEMENT WHEEL BEARINGS WERE AN UPGRADED PRODUCT. Look up ODI 10748553 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
|---|