| Service Brakes | 1551.7%ODI 10483682 · 17,990 miIT HAS BEEN FOUND THAT THE WHEEL BEARING WEAR OUT PREMATURELY ON TOURING MODELS ESPECIALLY WITH THE ABS SYSTEM. THIS HAPPENED TO ME RIDING DOWN THE ROAD, THE WHEEL BEARINGS CAUSED THE MOTORCYCLE TO WOBBLE AND HAD I NOT BEEN AN EXPERIENCED RIDER I VERY WELL WOULD HAVE GONE DOWN OR HIT ANOTHER VEHICLE. I HAVE HEARD OF OTHER RIDERS THAT THE BEARINGS HAVE WORN OUT ON THEIR MOTORCYCLES ALSO. THE COMPANY SHOULD DO A RECALL TO REMOVE ALL DEFECTIVE WHEEL BEARINGS FROM SERVICE TO PREVENT ANY LOSS OF LIFE. *TR Look up ODI 10483682 at NHTSA ↗ | 1155.0%ODI 10585844 · 31,000 miI WAS ON A COUNTRY ROAD GOING INTO A CORNER. I HIT THE REAR BRAKE TO FIND I DID NOT HAVE ANY REAR BRAKES. AFTER THE ACCIDENT WHEN I GOT THE BIKE HOME AND HAD TIME TO INSPECT IT I FOUND THAT THE REAR BRAKE LIGHT SWITCH HAD BLOW OUT CAUSING THE BACK BRAKES TO FAIL. I CALLED HARLEY CUSTOMER SERVICE AND DID NOT GET ANY ANSWERS OR EVEN A PHONE BACK AFTER I TOLD THEM THAT THEY MAY HAVE A PROBLEM ON THIS MODEL. I THEN CALLED MY DEALER. THEY ARE TRYING TO HELP BUT ARE NOT SURE WHAT THEY CAN DO EITHER. THE END RESULT IS THIS, I HAVE THE SERVICED ON A RE… Look up ODI 10585844 at NHTSA ↗ | 1157.9%ODI 10461323 · 1,480 mi2012 FLHTK ULTRA LIMITED PURCHASED 03/2012. ON MAY 25TH 2012 THE FRONT BRAKE FAILED. THE FRONT BRAKE LEVER WAS HARD AND WOULD NOT MOVE TO ENGAGE THE FRONT BRAKES. I TOOK THE BIKE TO THE DEALER AND THE FOLLOWING TUESDAY I WAS TOLD THE ABS MODULATOR HAD A STUCK VALVE OR SOME UNKNOWN FAILURE AND HD WAS SHIPPING OUT A PART TO FIX IT. THURSDAY THAT SAME WEEK THEY CALLED AND SAID THE BIKE WAS FIXED. I HAVE TALKED TO THE DEALER AND SPENT 5 HOURS ON THE PHONE WITH HD CORPORATE OFFICE CUSTOMER SERVICE. I HAVE BEEN TOLD THAT THERE IS NO WAY FOR ME TO … Look up ODI 10461323 at NHTSA ↗ | 964.3%ODI 10548204 · 10 miTL* THE CONTACT OWNS A 2013 HARLEY-DAVIDSON FLTHTK MOTORCYCLE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE REAR BRAKES FAILED TO RESPOND UPON ENGAGEMENT. THE FRONT BRAKES WERE OPERABLE AND STOPPED THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION WHERE A BLEEDING OF THE BRAKES WAS PERFORMED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 10. UPDATED 10/29/13*CN THE CONSUMER STATED THE LOWER PANEL COVERS WERE FALLING OFF. UPDATED 10/30/2… Look up ODI 10548204 at NHTSA ↗ | 821.6%ODI 10566571HITACHI CABLE INDIANA HAS BEEN PRODUCING BRAKE HOSE PARTS FOR HARLEY DAVIDSON MOTORCYCLES THAT DO NOT PASS "WHIP" TEST PER FMVSS FOR SEVERAL YEARS AND HAS BEEN PROVIDING FALSE DATA FOR TEST RESULTS. *TR Look up ODI 10566571 at NHTSA ↗ | 110.0%ODI 10778492 · 13,000 miWHILE ON A TRIP THROUGH COLORADO I WAS DESCENDING A STEEP MOUNTAIN GRADE. I APPLIED LIGHT PRESSURE TO THE FRONT BRAKE AND FELT A VIBRATION IN THE FRONT END. AS I INCREASED THE FRONT BRAKE PRESSURE WHILE ATTEMPTING TO SLOW FOR A TIGHT TURN, THE VIBRATION INCREASED UNTIL THE ENTIRE MOTORCYCLE SHOOK. THE VIBRATION CEASED ONCE THE SPEED WAS REDUCED BELOW ABOUT 30 MPH OR BRAKE PRESSURE WAS RELEASED. THIS SITUATION CAUSED ME SURPRISE AND DISTRACTION IN A CRITICAL STAGE OF OPERATION AND IT IS MY BELIEF THAT LOSS OF CONTROL IS POSSIBLE IN CERTAIN SITU… Look up ODI 10778492 at NHTSA ↗ | 550.0%ODI 11046397 · 16,240 miWHILE RIDING ON HWY THE FRONT END STARTING SHAKING OUT OF CONTROL , MY FIRST THOUGHT I RAN OVER SOME THING , APPLIED BRAKE BUT THE BRAKE LEVER WENT FLAT NO BRAKING ACTION AT ALL , DUE TO HAVING MANY YEARS RIDING EXPERIENCE I JUST HIT THE KILL SWITCH AND USED THE ENGINE AS A BRAKE LUCKILY IT WORKED AFTER GETTING IT STOPPED I INSPECTED AND FOUND MY FRONT BEARINGS HAD FALLEN APART AND OUT OF THE FRONT WHEEL . I ONLY HAVE 16K MILES ON THE BIKE , WELL THE ABS SYSTEM WORKS OFF THE WHEEL BEARINGS , I AM SUSPECTING THAT'S WHY I LOST MY BRAKES'' THE BE… Look up ODI 11046397 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
|---|
| Power Train | 413.8%ODI 10353491 · 16 miLOUD METALLIC NOISES COMING FROM PRIMARY(COMPENSATOR SPROCKET). LOUD METALLIC BANGING WHEN STARTING ENGINE. THIS IS ON A 2010 HARLEY DAVIDSON MOTORCYCLE. IF THE COMPENSATOR FAILS, AND LOCKS UP, A MOTORCYCLE CRASH IS INEVITABLE. *TR Look up ODI 10353491 at NHTSA ↗ | 210.0%ODI 10691157 · 10,000 miTL* THE CONTACT OWNS A 2011 HARLEY DAVIDSON ULTRA GLIDE LIMITED (NA). THE CONTACT STATED THAT WHILE OPERATING THE MOTORCYCLE AT VARIOUS SPEEDS, THE COMPENSATOR SPROCKET ATTACHED TO THE CRANKSHAFT RATTLED AND VIBRATED. THE MOTORCYCLE WAS TAKEN TO THE DEALER, WHO DIAGNOSED THAT THE FAILURE WAS CAUSED BY A LOOSE BOLT FROM THE SPROCKET. THE COMPENSATOR SPROCKET WAS REPLACED BUT, APPROXIMATELY 10,000 MILES LATER, THE FAILURE RECURRED. THE MOTORCYCLE WAS REPAIRED, BUT THE FAILURE RECURRED A THIRD TIME APPROXIMATELY 10,000 MILES LATER, WHICH DAMAGED T… Look up ODI 10691157 at NHTSA ↗ | 15.3%ODI 10846312 · 8,900 miTRANSMISSION SHIFT LINKAGE FALLS OFF OF THE TRANSMISSION SPLINE BOLT. IT HAPPENED TO ME WITH LESS THAN 9000 MILES. APPARENTLY IT IS A COMMON PROBLEM. I GOT STUCK IN 6TH GEAR AND THERE WERE MANY TIMES ON THE WAY HOME I NEEDED TO NOT COME TO A STOP WITH TWO ON THE BIKE. THERE WAS A FEW TIMES IT WOULD HAVE BEEN SAFER TO DOWN SHIFT ON THE ROAD. THE ISSUE IS A VERY POOR DESIGN WHERE THE SHIFT ARM LEVER MATES TO THE TRANSMISSION SPLINE BOLT. Look up ODI 10846312 at NHTSA ↗ | 214.3%ODI 10585538 · 2,700 miWHILE RIDING MY 2013 HARLEY ULTRA CLASSIC I NOTICED FROM THE DAY I BOUGHT IT 7-9-2013 IT WAS MAKING A NOISE IN THE CHAIN CASE THAT SOUNDS LIKE THE PRIMARY CHAIN IS LOOSE AND MAKING A SLAPPING SOUND. I TOOK THE BIKE BACK TO THE DEALER AND THE SERVICE MANAGER TOLD ME IT WAS NORMAL THEY ALL DO IT. THE NOISE GOT A LITTLE LOUDER OVER THE NEXT TWO MONTHS SO I TOOK THE BIKE BACK ON 10-29-2013 AND A SERVICE TECH TOOK THE BIKE OUT AND SAID IT SOUNDS LIKE THE CHAIN TENSIONER IS NOT WORKING. HE REMOVED THE INSPECTION COVER AND SAID IT LOOKED OK. HE SAID … Look up ODI 10585538 at NHTSA ↗ | 718.9%ODI 10542906 · 84 miI EXPERIENCED COOLANT LEAKAGE AFTER COMING TO A STOP. THE DEALERSHIP SPENT A FEW DAYS TESTING AND MAKING THE REPAIR. AT APPROX.. 300 MILES IT DID IT AGAIN. COOLANT IS VERY SLIPPERY, IF COOLANT GETS ON A MOTORCYCLES TIRES IT WOULD BE ALL BAD. FROM WHAT I HAVE BEEN HEARING, HARLEY IS HAVING ISSUES WITH COOLANT LEAKS ON SELECTED NEW BIKES. THIS IS A WHOLE NEW DESIGN FOR HARLEY DAVIDSON, USED ON 3 2014 HARLEY DAVIDSON MODELS. I REALLY THINK THE ISSUE SHOULD BE INVESTIGATED. *TR Look up ODI 10542906 at NHTSA ↗ | 110.0%ODI 11072437 · 14,870 miCLUTCH BEGAN SLIPPING AT 14,000 MILES WHILE IN 6TH GEAR WHILE ON INTERSTATE. RESULTED IN EVASIVE MANEUVERS BEING TAKEN BY MYSELF AND OTHER MOTORISTS TO AVOID COLLISION, AS I WAS IN THE MIDDLE LANE. DEALERSHIP STATED THAT THE CLUTCH IS NOT COVERED IN WARRANTY. Look up ODI 11072437 at NHTSA ↗ | 00.0%No examples available for this selection. | 675.0%ODI 10946903 · 300 miHYDRAULIC CLUTCH HAS NO ADJUSTMENT AND MY PARTICULAR CLUTCH IS ALL THE WAY AT THE VERY END APPEARS IT MAY EVEN BE SLIPPING SOME LESS THAN 500 MILES ON THE MACHINE AND CLUTCH HAS TO BE WHAT APPEARS TO BE 1/8 INCH FROM THE END BEFORE IT CATCHES AND NO FRICTION ZONE HAS ALMOST GOTTEN ME HIT MORE THAN ONCE DUE TO NO TAKE UP BEFORE RELEASE AND WITH CLUTCH SO FAR HAND HAS SLIPPED FROM CLUTCH HANDLE MORE THAN ONCE. IT HAS ALSO CAUSED ME TO ROLL BACK ALMOST INTO ANOTHER VEHICLE OR HAS CAUSED ME TO KILL THE BIKE TRYING TO TAKE OFF FROM A LIGHT OR STOP. … Look up ODI 10946903 at NHTSA ↗ | 125.0%ODI 11412987 · 10,022 miLOSS OF OIL PRESSURE, POWER, AND ENGINE FAILURE AT HIGHWAY SPEED DUE TO OIL SUMP AND FAILURE OF OIL PUMP. VEHICLE WAS TRAVELING AT HIGHWAY SPEED ON RESTRICTED ACCESS ROAD. Look up ODI 11412987 at NHTSA ↗ | 375.0%ODI 11219098 · 4,000 miTRANSMISSION LOSES OIL. BRAND NEW MOTORCYCLE LOSS OF TRANSMISSION OIL IN JUST 3 THOUSAND MILES. COULD CAUSE COMPLETE FAILURE AT FREEWAY SPEEDS. POTENTIAL LIFE THREATENING ! HARLEY DAVIDSON REFUSES TO RECALL. Look up ODI 11219098 at NHTSA ↗ | 1100.0%ODI 11675294Rear wheel locked at 40 mph and power cutoff while on a highway on ramp (soft right turn) making the rear wheel slide to the right, causing my passenger and I to fall off the bike hurting our left extremities (legs, arms, wrists, elbows, shoulders) as it slid and ended on its left side on the right shoulder. Harley-Davidson RDRS and Rain Mode were turned on and the road was wet from a previous rain but visible debris on the road. Look up ODI 11675294 at NHTSA ↗ | 150.0%ODI 11571996Recently while riding my motorcycle, I experienced a near total loss of clutch control. Fortunately, was able to safely limp it back to the garage. What I found when checking components, my clutch lever lost most of its tension. I thought it might be a stripped plastic tensioner that others have experienced. Instead, it was partially the plastic push button slipped and the metal retaining threads on the clutch cable separated from the upper clutch cable causing an immediate loss in tension to engage the clutch. I did not take a photo, but i… Look up ODI 11571996 at NHTSA ↗ | 00.0%No examples available for this selection. | 150.0%ODI 11540231Intermittent loss of all throttle control and will shut off, it can happen at anytime it can be stopped at a light or on the freeway this is the 4th time this has happened Look up ODI 11540231 at NHTSA ↗ |
|---|
| Engine | 13.4%ODI 11403192 · 26,000 miI'M EXPERIENCING ISSUES WITH MY TBW. CHECK ENGINE LIGHT CAME ON FOR THE FIRST TIME IN NOVEMBER AT THE END OF A CHARITY RIDE AND I THOUGHT PERHAPS THE PACK RIDE CAUSED IT TO OVERHEAT, AFTER SHUTTING THE BIKE OFF IT WENT AWAY BRIEFLY. DID SOME TROUBLESHOOTING ONLINE AND DISCOVERED THAT THE PLUGS ON THE ECM AND TB WERE TYPICALLY THE ISSUE SO CLEANED, ADDED DIELITHIUM GREASE TO THE CONNECTORS AND ISSUES WENT AWAY. HAPPENED AGAIN, THIS TIME I PULLED THE CEL CODES TO DISCOVER THE TGS AND ETC CODES WERE IN FAULT. AFTER MORE RESEARCH DECID… Look up ODI 11403192 at NHTSA ↗ | 15.0%ODI 11316186 · 48,000 miI HAD JUST PULLED OUT ONTO THE HIGHWAY IN HIGH TRAFFIC AREA AND MY MOTORCYCLE STARTED PRODUCING A CLANKING NOISE FROM THE PRIMARY CASE AND AFTER DOING EXTENSIVE RESEARCH, COME TO THE CONCLUSION THAT THE PRIMARY COMPENSATOR WAS FAILING. AT THE TIME THIS HAPPENED, MY CYCLE ALSO DROPPED VOLTAGE FROM 14.8 VOLTS DC DOWN TO 8 OR 9 VOLTS DC AND CAUSED THE CYCLE TO BOG, AND LOST MECHANICAL POWER ON A HILL WITH HIGH TRAFFIC FROM BOTH DIRECTIONS ON A HEAVILY TRAFFICKED MAIN U.S. HIGHWAY. HAD IT BEEN DAYLIGHT, THE ISSUE COULD HAVE COSTED MY LIFE HAD IT N… Look up ODI 11316186 at NHTSA ↗ | 210.5%ODI 10482478 · 2,252 miWHILE RIDING MY HARLEY MOTOR CYCLE ON VACATION ACROSS NEBRASKA ON HIGHWAY 76 I NOTICED EXTREME HEAT ON THE INSIDE OF MY RIGHT LEG AND LOSS OF POWER. THE INSIDE OF MY RIGHT WAS BURNED AND GOT INFECTED, TOTAL BILL FOR DOCTOR AND TIME OFF FROM WORK WAS APPROXIMATELY $1500.00-$2000.00. THE WORK DONE ON THE MOTOR CYCLE BILL WAS $1487.00. THIS IS SUPPOSE TO TAKE CARE OF THE PROBLEM OF OVER HEATING. NEW HEAD PIPES $524.95, KIT,SESTAGE 1 AIC %)MM$139.95, KIT-EFI SUPER TUNER,SCREA $459.95, JOB CODE;0 TEC: JDK $81.00, DYNO TUNE$275.40. I HAVE PAID ALL EX… Look up ODI 10482478 at NHTSA ↗ | 17.1%ODI 10551330 · 10 miRODE MY NEW HARLEY FLHTK FOR AN HOUR AND THE RIGHT SIDE GOT SO HOT I TIRED AVOIDING TOUCHING IT TO PREVENT BURNING MYSELF. THE AIR CLEANER WAS SO I HOT MY RIGHT PANT LEG LOOKED LIKE IT HAD BEEN IRONED. MY POSTERIOR WAS SOAKED WITH SWEAT MAKING FOR A VERY UNCOMFORTABLE RIDE. EVEN THE LEFT SIDE ON THE PRIMARY CASE WAS UNCOMFORTABLE TO THE TOUCH. I WAS JUST CRUISING BACK COUNTRY ROADS NOT RIDING IN TRAFFIC AND THE AIR TEMP WAS ONLY ABOUT 60 FAHRENHEIT NOT CELSIUS THOUGH THE AMBIENT TEMP AROUND ME WAS PROBABLY 60C OR GREATER. AFTER THIS I HAD THE… Look up ODI 10551330 at NHTSA ↗ | 1232.4%ODI 10543071 · 80 miNEW ENGINE OVERHEATING DUMPING COOLANT OUT OF OVERFLOW TUBE UNDERNEATH MOTORCYCLE AND ON TO REAR TIRE CREATING A SAFETY RISK. FOUR OVERHEATING INCIDENTS WITHIN THE FIRST 400 MILES OF ENGINE LIFE. ENGINE BREAK IN WITH MALFUNCTIONING COOLING SYSTEM CREATING EXCESSIVE ENGINE HEAT AND RISK OF IMPROPER BREAK IN OR ENGINE DAMAGE. *TR Look up ODI 10543071 at NHTSA ↗ | 440.0%ODI 11072438 · 6,000 miSPARK PLUG WIRE LEADING TO FRONT CYLINDER RUBS AGAINST THE FUEL TANK, LEADING TO ABRASION THROUGH THE INSULATION OF THE SPARK PLUG WIRE. REPLACEMENT OF PARK PLUG WIRE UNDER WARRANTY DENIED BY FORT BRAGG HARLEY DAVIDSON. ABRASION THROUGH THE INSULATION BY CONTACT OF THE FUEL TANK COULD LEAD TO FIRE OR EXPLOSION SHOULD THE WIRE ARC ON THE FUEL TANK OR IF FUEL LEAKS. Look up ODI 11072438 at NHTSA ↗ | 110.0%ODI 11255545 · 9,960 miTL* THE CONTACT OWNS A 2016 HARLEY-DAVIDSON FLHTK LIMITED. WHILE DRIVING WITH THE CRUISE CONTROL ACTIVATED, IT DISENGAGED AUTOMATICALLY WHEN GOING OVER BUMPS IN THE ROAD. ALSO, THE THROTTLE WOULD DECREASE AND THE VEHICLE LOST POWER. ON JULY 30, 2019, WHILE PULLING OUT OF A PARKING LOT, THE THROTTLE COMPLETELY FAILED IN TRAFFIC. THE CONTACT HAD TO ROLL THE VEHICLE TO THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO LA CROSSE AREA HARLEY-DAVIDSON (1116 OAK FOREST DR, ONALASKA, WI 54650, [phone removed]) WHERE IT WAS DIAGNOSED THAT THE SIX TERMINAL … Look up ODI 11255545 at NHTSA ↗ | 112.5%ODI 11012209 · 2,500 miIT IS TRANSFERRING OIL FROM THE TRANSMISSION TO THE PRIMARY WHILE RIDING. THIS CAUSES THE PRIMARY TO OVERFILL WHICH RESULTS IN CLUTCH ISSUES AND DIFFICULTY FINDING NEUTRAL. THE TRANSMISSION IS GOING DOWN WHICH IS PROBABLY DECREASING ITS LIFE AND COULD CAUSE IT TO LOCK UP DUE TO LOW OIL LEVEL. THIS IS POTENTIAL SAFETY ISSUE THAT COULD LEAD TO A CATASTROPHIC ACCIDENT IF THIS OCCURS AT HIGHER SPEEDS. BIKE HAS ONLY 2500 MILES ON IT AND SHOULD NOT BE DOING THIS. NO ACKNOWLEDGEMENT FROM THE DEALER. Look up ODI 11012209 at NHTSA ↗ | 250.0%ODI 11025236 · 526 miHEAD BOLT BROKE ON FRONT CYLINDER OF ENGINE CAUSING HEAD GASKET TO FAIL, WHICH LED TO OIL LEAK FROM HEAD GASKET. THIS LED TO ENGINE OIL BEING LEAKED ONTO SIDE OF MOTORCYCLE AS WELL AS ON PASSENGER BOOTS AND ONTO REAR TIRE. THIS OCCURRED WHILE VEHICL WAS TRAVELLING ON HIGHWAY WITH ENGINE AT OPERATING TEMPERATURE .WASINFORMED BY HARLEY MASTER TECH THAT THEY HAD SEEN THIS ON NUMEROUS OCCASIONS Look up ODI 11025236 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 1100.0%ODI 11752988 · 3,800 miThe contact owns a 2022 Harley-Davidson FLHTK. The contact stated that while riding approximately 70 MPH, the motorcycle went into LIMP Mode and unexpectedly downshifted. The motorcycle was taken to the same local dealer on various occasions to be diagnosed; however, the failure could not be duplicated. The contact stated that the failure was associated with an automatic safety feature. The motorcycle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 3,800. Look up ODI 11752988 at NHTSA ↗ | 00.0%No examples available for this selection. |
|---|
| Electrical System | 26.9%ODI 10340776 · 2,750 miAFTER PURCHASING A 2010 HARLEY DAVIDSON ELECTRA-GLIDE ULTRA CLASSIC LIMITED IN OCT 2009, I EXPERIENCED THE FOLLOWING WHILE ON A RIDE FROM MY HOME TO RICHMOND VA: ?STEREO CONSTANTLY WENT ON AND OFF WITH INTERMITTENT INTERCOM AND VOLUME CONTROL PROBLEMS. ?BATTERY AND ENGINE LIGHT WENT ON AND OFF THROUGHOUT THE ENTIRE TRIP. ?BIKE WOULD NOT START UNLESS THE FUSE PANEL WAS PRESSED ON TWO (2) OCCASIONS. ?LOST ALL ACCELERATION ABILITY WITH THE THROTTLE AT 65MPH IN THE MIDDLE OF THE FREEWAY AFTER GOING OVER A BUMP IN THE ROAD. WE WERE FORTUNATE … Look up ODI 10340776 at NHTSA ↗ | 15.0%ODI 11316186 · 48,000 miI HAD JUST PULLED OUT ONTO THE HIGHWAY IN HIGH TRAFFIC AREA AND MY MOTORCYCLE STARTED PRODUCING A CLANKING NOISE FROM THE PRIMARY CASE AND AFTER DOING EXTENSIVE RESEARCH, COME TO THE CONCLUSION THAT THE PRIMARY COMPENSATOR WAS FAILING. AT THE TIME THIS HAPPENED, MY CYCLE ALSO DROPPED VOLTAGE FROM 14.8 VOLTS DC DOWN TO 8 OR 9 VOLTS DC AND CAUSED THE CYCLE TO BOG, AND LOST MECHANICAL POWER ON A HILL WITH HIGH TRAFFIC FROM BOTH DIRECTIONS ON A HEAVILY TRAFFICKED MAIN U.S. HIGHWAY. HAD IT BEEN DAYLIGHT, THE ISSUE COULD HAVE COSTED MY LIFE HAD IT N… Look up ODI 11316186 at NHTSA ↗ | 421.1%ODI 10459905 · 3,401 miREGULATOR FAILED IN HOT CLIMATE. *TR Look up ODI 10459905 at NHTSA ↗ | 00.0%No examples available for this selection. | 616.2%ODI 10549772 · 1,025 miA PUSH TO TALK BUTTON FOR THE CB COMMUNICATION SYSTEM ON ALL HARLEYS FOR WELL OVER 10 YEARS HAS BEEN ON THE LEFT SIDE OF THE HANDLE BAR BUTTON CLUSTER FOR BIKES WITH CB AND RADIO. ON THE NEW 2014 THE BUTTON WAS SWITCHED WITH THE CRUISE CONTROL BUTTON (WHICH WAS MOVED TO THE LEFT SIDE) AND MOVED TO THE RIGHT HAND SIDE CONTROL CLUSTER. BECAUSE OF THIS AND THE NEED TO CONTINUALLY GRAB THE THROTTLE CONTROL, THE BUTTON IS NOT AS EASY TO REACH WHILE RIDING. THE ON/OFF SWITCH FOR THE BIKE IS DIRECTLY NEXT TO THE THROTTLE GRIP. BECAUSE OF THIS THE … Look up ODI 10549772 at NHTSA ↗ | 220.0%ODI 11072438 · 6,000 miSPARK PLUG WIRE LEADING TO FRONT CYLINDER RUBS AGAINST THE FUEL TANK, LEADING TO ABRASION THROUGH THE INSULATION OF THE SPARK PLUG WIRE. REPLACEMENT OF PARK PLUG WIRE UNDER WARRANTY DENIED BY FORT BRAGG HARLEY DAVIDSON. ABRASION THROUGH THE INSULATION BY CONTACT OF THE FUEL TANK COULD LEAD TO FIRE OR EXPLOSION SHOULD THE WIRE ARC ON THE FUEL TANK OR IF FUEL LEAKS. Look up ODI 11072438 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 150.0%ODI 11540231Intermittent loss of all throttle control and will shut off, it can happen at anytime it can be stopped at a light or on the freeway this is the 4th time this has happened Look up ODI 11540231 at NHTSA ↗ |
|---|
| Wheels | 620.7%ODI 10463351 · 7,300 miWHILE DRIVING APPROX 45MPH I HEARD A LOUD METAL GRINDING SOUND COMING FROM MY FRONT WHEEL. I PULLED OFF THE ROAD AND NOTICED THE RIGHT FRONT WHEEL BEARING WAS COMING APART. I HAD THE BIKE TOWED TO MY DEALER WHERE THEY CONFIRMED THE RIGHT FRONT WHEEL BEARING FAILED. I HAD THE DEALER REGISTER THE INCIDENT WITH HARLEY DAVIDSON. *TR Look up ODI 10463351 at NHTSA ↗ | 210.0%ODI 10542296 · 11,896 miTHE FRONT WHEEL BEARINGS STARTED MAKING METAL TO METAL NOISES OFF AND ON WHILE THE HANDLE BARS WOULD VIBRATE. IT IS ALL OVER THE INTERNET THAT HARLEY DAVIDSON CHANGED TO A SMALLER WHEEL BEARING AND THEY COME FROM SOUTH KOREA AND DELHI, INDIA. THERE IS NO SCHEDULED MAINTENANCE ON THIS EVER AND THEY SHOULD NOT GO BAD AT 11,000 MILES. THE BEARINGS RUINED THE WHEEL AND WILL COST $550 TO REPLACE IT AND A TOTAL OF $909 TO COMPLETE THE REPAIR. THE SAFETY ISSUE IS THAT THE FRONT WHEEL COULD HAVE LOCKED UP AND CAUSED AN ACCIDENT WITH INJURIES AND OR… Look up ODI 10542296 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 12.7%ODI 10543071 · 80 miNEW ENGINE OVERHEATING DUMPING COOLANT OUT OF OVERFLOW TUBE UNDERNEATH MOTORCYCLE AND ON TO REAR TIRE CREATING A SAFETY RISK. FOUR OVERHEATING INCIDENTS WITHIN THE FIRST 400 MILES OF ENGINE LIFE. ENGINE BREAK IN WITH MALFUNCTIONING COOLING SYSTEM CREATING EXCESSIVE ENGINE HEAT AND RISK OF IMPROPER BREAK IN OR ENGINE DAMAGE. *TR Look up ODI 10543071 at NHTSA ↗ | 00.0%No examples available for this selection. | 440.0%ODI 11046397 · 16,240 miWHILE RIDING ON HWY THE FRONT END STARTING SHAKING OUT OF CONTROL , MY FIRST THOUGHT I RAN OVER SOME THING , APPLIED BRAKE BUT THE BRAKE LEVER WENT FLAT NO BRAKING ACTION AT ALL , DUE TO HAVING MANY YEARS RIDING EXPERIENCE I JUST HIT THE KILL SWITCH AND USED THE ENGINE AS A BRAKE LUCKILY IT WORKED AFTER GETTING IT STOPPED I INSPECTED AND FOUND MY FRONT BEARINGS HAD FALLEN APART AND OUT OF THE FRONT WHEEL . I ONLY HAVE 16K MILES ON THE BIKE , WELL THE ABS SYSTEM WORKS OFF THE WHEEL BEARINGS , I AM SUSPECTING THAT'S WHY I LOST MY BRAKES'' THE BE… Look up ODI 11046397 at NHTSA ↗ | 00.0%No examples available for this selection. | 125.0%ODI 11354102 · 16,662 miTIRE DEVELOPED SLICING IN THE TREAD HAVE HAD MULTIPLE HARLEY DEALERS TELL ME THEY HAVE SEEN THIS PROBLEM Look up ODI 11354102 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
|---|
| Vehicle Speed Control | 13.4%ODI 10637924 · 41,260 miI TURNED ONTO NORTHBOUND US HIGHWAY 281 FROM EASTBOUND SOUTH DAKOTA HIGHWAY 26 AND ACCELERATED NORMALLY TO 65 MPH AND ACTIVATED THE ELECTRONIC CRUISE CONTROL IN 6TH GEAR. WITHIN A FEW SECONDS I HEARD A NUMBER OF SQUEALS FROM THE FRONT END AND THE HANDLEBARS BEGAN SHAKING VIOLENTLY. I APPLIED THE BRAKES TO RAPIDLY SLOW THE MOTORCYCLE DOWN. AT 50 MPH THE SHAKING STOPPED. I DISENGAGED THE CLUTCH AND DIDN'T FEEL ANY NOTICEABLE RESISTANCE. I STOPPED AND INSPECTED THE FRONT WHEEL AND SAW THE BEARING SHIELD HAD MOVED AWAY FROM THE BEARING . I WAS… Look up ODI 10637924 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 17.1%ODI 11325581MY FRONT BRAKES ON MY 2013 HARLEY DOSE NOT WORK MOST OF THE TIME AND IT IS HARD TO PULL IN THE BRAKE LEVER TO WHERE WHEN I PULL THE BRAKE LEVER IN AND CAN NOT MOVE THE LEVER WITH NO BRAKES...AND SOME TIMES THE FRONT WHEEL LOCKS UP BY JUST SITTING OR AT A STOP LIGHT AND MY SPEED CONTROL STOPS WORKING ON AND OFF AND HAVE A ENGINE LIGHT THAT GOES ON AND OFF VIN #[XXX] REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) *CC Look up ODI 11325581 at NHTSA ↗ | 410.8%ODI 10552482 · 700 miTHIS 2014 HD FLHTK HAD THE HYDRAULIC CLUTCH SERVICED IN OCTOBER 2013 UNDER THE MASSIVE HD CLUTCH RECALL PROGRAM. HOWEVER, I INSPECTED THE BIKE AND INFORMED THE DEALER THAT THE CLUTCH FLUID LOW. IT WAS BELOW THE SIGHT GLASS ON THE MASTER CYLINDER (ACUTELY AT THE BOTTOM OF THE SIGHT GLASS). I WAS INFORMED THAT THE CYLINDER WAS FULL AND CANNOT BE FILLED TO THE SIGHTLINE BECAUSE OF THE DESIGN. ON NOVEMBER 15, 2013 DRIVING 40 MILES FROM HOME AT 45 MPH WHEN I APPROACHED A TRAFFIC LIGHT AND STARTED TO DOWN SHIFT. SHIFTING BECAME HARDER AND HAD TROU… Look up ODI 10552482 at NHTSA ↗ | 00.0%No examples available for this selection. | 110.0%ODI 11255545 · 9,960 miTL* THE CONTACT OWNS A 2016 HARLEY-DAVIDSON FLHTK LIMITED. WHILE DRIVING WITH THE CRUISE CONTROL ACTIVATED, IT DISENGAGED AUTOMATICALLY WHEN GOING OVER BUMPS IN THE ROAD. ALSO, THE THROTTLE WOULD DECREASE AND THE VEHICLE LOST POWER. ON JULY 30, 2019, WHILE PULLING OUT OF A PARKING LOT, THE THROTTLE COMPLETELY FAILED IN TRAFFIC. THE CONTACT HAD TO ROLL THE VEHICLE TO THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO LA CROSSE AREA HARLEY-DAVIDSON (1116 OAK FOREST DR, ONALASKA, WI 54650, [phone removed]) WHERE IT WAS DIAGNOSED THAT THE SIX TERMINAL … Look up ODI 11255545 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 125.0%ODI 11470676Twist Grip Sensor ECM Code p2138 and P1510. twist grip sensor correlation error and Electronic throttle control limited performance mode. Look up ODI 11470676 at NHTSA ↗ | 1100.0%ODI 11675294Rear wheel locked at 40 mph and power cutoff while on a highway on ramp (soft right turn) making the rear wheel slide to the right, causing my passenger and I to fall off the bike hurting our left extremities (legs, arms, wrists, elbows, shoulders) as it slid and ended on its left side on the right shoulder. Harley-Davidson RDRS and Rain Mode were turned on and the road was wet from a previous rain but visible debris on the road. Look up ODI 11675294 at NHTSA ↗ | 150.0%ODI 11607522A redesign in the left and right handle controls of the Harley 2014 model’s, the Press to Talk (PTT) button and Cruise Control buttons were switched from the left hand grip to the right throttle/brake hand grip. The PTT button is used for the Citizens Band (CB) radio. The PTT button had always been located on the left hand grip and the Cruise Control button had always been located on the right throttle/brake hand grip. In order for the operator to use the CB to talk, the PTT button is used. To activate the PTT button, the operator’s right thum… Look up ODI 11607522 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
|---|
| Steering | 413.8%ODI 10432514 · 65 miI PURCHASED A USED VEHICLE IN MAY OF 2011. IMMEDIATELY EXPERIENCED AT INTERMITTENT SPEEDS AND NON-SPECIFIC CONDITIONS THE FRONT END WILL START TO WOBBLE IN EVER INCREASING INTENSITY, IF HANDS ARE OFF THE HANDLE BARS. WITH HAND ON THE BARS, THE CONDITION CAN BE FELT BUT IS KEPT UNDER MORE CONTROL OF THE RIDER. HAT HIGH SPEEDS IT IS MORE PRESENT EVEN WITH HANDS ON THE HANDLE BARS. THIS CONDITION DID NOT EXIST IN HARLEY MOTORCYCLES UNTIL THE FRAME ENGINEERING AND MAJOR REDESIGN CHANGE IN THE 2009, 2010 AND 2011 (AND PRESUMABLY UP) MOTORCYCLES. I … Look up ODI 10432514 at NHTSA ↗ | 15.0%ODI 104264222011 HARLEY DAVIDSON ELECTRA-GLIDE ULTRA-LIMITED (103CU), BOUGHT NEW JUNE 2011. REPORTED TO DEALERSHIP THAT, THE FRONT END SHAKES VIOLENTLY WITH HANDS REMOVED FROM HANDLEBARS AT AROUND 30 TO 35 MPH. THE VIBRATION FROM THE FRONT END CAUSES THE HANDLEBARS TO SHAKE VIOLENTLY AND WITHOUT IMMEDIATE HANDS BACK ON THE BARS THE VIBRATION INCREASES TO THE POINT OF POSSIBLE ?LOSS OF CONTROL? OF THE MOTORCYCLE; THIS ISSUE WILL CAUSE SERIOUS INJURY OR DEATH TO RIDER AND PASSENGER. DEALERSHIP CHECKED ALL SPECIFICATIONS FOR FRONT END AND REPORTED NO ISSUE… Look up ODI 10426422 at NHTSA ↗ | 15.3%ODI 10701901 · 500 miWHEN SLOWING DOWN RAPIDLY, THE FRONT END WOBBLES FIERCELY, YOU HAVE TO BE HOLDING ON VERY TIGHTLY AND MAKE IT STOP FASTER FOR IT TO BE CORRECTED, I HAVE HAD THE BIKE IN THE SHOP SEVERAL TIMES AND NO RESOLUTION. IT IS DANGEROUS. *TR Look up ODI 10701901 at NHTSA ↗ | 17.1%ODI 11025031 · 17,000 miWHILE OUT RIDING WITH MY MEETUP MOTORCYCLE GROUP ALONG BACK COUNTRY ROADS ON THE EASTERN SHORE OF MARYLAND. WE WERE APPROACHING A SHARP RIGHT HAND TURN IN THE ROAD WHEN I FIRST APPLIED MY BRAKES THE BRAKES NEVER COMPLETELY ENGAGED. AFTER REAPPLYING THE BRAKES IN A PANIC STOP CONDITION THE ABS SYSTEM NEVER KICKED IN, HOWEVER THE REAR BRAKES DID EVENTUALLY ENGAGE RESULTING IN THE BIKE LAYING DOWN A LONG SKIDMARK AND THE REAR TIRE GOING INTO A FISHTAIL MOTION. THE RESULT WAS I CROSSED OVER THE ONCOMING TRAFFIC LINE AND END UP OFF OF THE ROAD ON TH… Look up ODI 11025031 at NHTSA ↗ | 25.4%ODI 10556957 · 450 miENGINE COOLANT LEAKING FROM COOLANT PUMP CASING. INSPECTED COOLANT RESERVOIR WHICH WAS PRESSURED UP AND FULL(NO AIR GAP). AFTER ENGINE COOLED, THEN COOLANT LEVEL BELOW COLD FULL LEVEL. DEALER STATED THEY COULD NOT REPRODUCE EPISODE. AT 30 TO 33 MPH, THERE IS A WOBBLE/SHIMMY IN THE HANDLE BARS/FRONT END. MORE SO ON DECELERATION,BUT HAVE FELT WHEN TURNING. FIRST TIME DEALER STATED THEY COULD NOT REPRODUCE. PROBLEM HAS CONTINUED. DEALER STATED THEY CAN REPRODUCE. THEY RODE OTHER BIKES OF THIS MODEL AND ALL BIKES HANDLE THIS WAY, SO THEY C… Look up ODI 10556957 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
|---|
| Fuel/Propulsion System | 13.4%ODI 11403192 · 26,000 miI'M EXPERIENCING ISSUES WITH MY TBW. CHECK ENGINE LIGHT CAME ON FOR THE FIRST TIME IN NOVEMBER AT THE END OF A CHARITY RIDE AND I THOUGHT PERHAPS THE PACK RIDE CAUSED IT TO OVERHEAT, AFTER SHUTTING THE BIKE OFF IT WENT AWAY BRIEFLY. DID SOME TROUBLESHOOTING ONLINE AND DISCOVERED THAT THE PLUGS ON THE ECM AND TB WERE TYPICALLY THE ISSUE SO CLEANED, ADDED DIELITHIUM GREASE TO THE CONNECTORS AND ISSUES WENT AWAY. HAPPENED AGAIN, THIS TIME I PULLED THE CEL CODES TO DISCOVER THE TGS AND ETC CODES WERE IN FAULT. AFTER MORE RESEARCH DECID… Look up ODI 11403192 at NHTSA ↗ | 00.0%No examples available for this selection. | 15.3%ODI 10482478 · 2,252 miWHILE RIDING MY HARLEY MOTOR CYCLE ON VACATION ACROSS NEBRASKA ON HIGHWAY 76 I NOTICED EXTREME HEAT ON THE INSIDE OF MY RIGHT LEG AND LOSS OF POWER. THE INSIDE OF MY RIGHT WAS BURNED AND GOT INFECTED, TOTAL BILL FOR DOCTOR AND TIME OFF FROM WORK WAS APPROXIMATELY $1500.00-$2000.00. THE WORK DONE ON THE MOTOR CYCLE BILL WAS $1487.00. THIS IS SUPPOSE TO TAKE CARE OF THE PROBLEM OF OVER HEATING. NEW HEAD PIPES $524.95, KIT,SESTAGE 1 AIC %)MM$139.95, KIT-EFI SUPER TUNER,SCREA $459.95, JOB CODE;0 TEC: JDK $81.00, DYNO TUNE$275.40. I HAVE PAID ALL EX… Look up ODI 10482478 at NHTSA ↗ | 00.0%No examples available for this selection. | 12.7%ODI 10617216 · 200 miTHE FRONT SPARK PLUG WIRE ON 2014 HARLEY DAVIDSON TOURING MOTORCYCLES IS ROUTED ALONG THE LEFT SIDE OF THE FRAME UNDER THE FUEL TANK. AT THE POINT WHERE THE FRONT SPARK PLUG WIRE EMERGES FROM BENEATH THE FUEL TANK, THE SPARK PLUG WIRE TOUCHES AND RUBS AGAINST THE FUEL TANK. THERE HAVE BEEN NUMEROUS REPORTS FROM OWNERS OF THESE MOTORCYCLES OF THE INSULATION BEING DAMAGED OVER TIME BY THE CONTINUOUS RUBBING ON THE TANK CREATING THE POTENTIAL FOR AN ELECTRICAL SHORT CIRCUIT AND FIRE AT THE FUEL TANK. THE POTENTIAL FOR A FIRE IS FURTHER SUPPORTE… Look up ODI 10617216 at NHTSA ↗ | 220.0%ODI 11143417 · 6,000 miAFTER SITTING IN THE SUN APPROX. 8 HOURS, WHILE IN MOTION, ENGINE DIED APPROX. 2 SECONDS WHEN STOPPING, TURNING OR ACCELERATING. 1 TIME ENGINE SPUTTERED WHEN IT DIED AT A STOP, THE OTHER TIMES ENGINE JUST STOPPED RUNNING. STARTED RIGHT BACK UP. OK IF FUEL TANK AND PCM (SEAT) ARE COVERED OR BIKE IN GARAGE. BEEN TO DEALERSHIP TWICE, THEY WERE UNABLE TO VERIFY. DIED SEVERAL TIMES FROM 3/18/17. Look up ODI 11143417 at NHTSA ↗ | 00.0%No examples available for this selection. | 225.0%ODI 11055610 · 3,500 miON A DAILY BASIS, WHILE OPERATING THE MOTORCYCLE WITH THE CLUTCH ENGAGED, IN GEAR, AND AT IDLE SPEED, THE ENGINE WILL STALL. THIS OCCURS WHEN YOU ARE STOPPING FOR A STOP SIGN, RED LIGHT, OR IN BUMPER-TO-BUMPER TRAFFIC. WHEN THIS OCCURS, YOU CAN NOT RESTART THE ENGINE. NEW RESTRICTIONS ON THE MOTORCYCLE DO NOT ALLOW THE ENGINE TO BE STARTED WITH THE MOTORCYCLE CLUTCH ENGAGED WITH IT "IN GEAR". YOU MUST COME TO A COMPLETE STOP, PLACE THE TRANSMISSION IN NEUTRAL. AND THEN YOU ARE ALLOWED TO RESTART THE ENGINE. THIS IS PROBLEMATIC AT BEST AND EXTRE… Look up ODI 11055610 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 150.0%ODI 11610671While going to work on freeway doing 70 bike went into limp mode and I lost all throttle luckily I got out of traffic and was able to limp to dealership where bike has been 3 days now totally UNSAT especially when I researched online and see this is a common problem why hasn't Harley been made to fix this or do more people need to get hurt or die before you all will make Harley fix this problem! Look up ODI 11610671 at NHTSA ↗ |
|---|