| Electrical System | — | 211ODI 11509814We were driving vehicle on a neighborhood street with a speed limit of 45 miles per hour. When we got a "High voltage fault warning" from the car. I continued to drive about 10 second more and got a second warning. A different series of warnings appeared the last one being "please pull over and check your electrical system". We pulled into a neighborhood street, turned off the car. We decided to try to make it home which was less than 1/2 mile. Once I restarted the car, both messages cycled through the dashboard. Then the car lost the abi… Look up ODI 11509814 at NHTSA ↗ ODI 11511391I was driving to my parents house when suddenly a message popped up on my driver screen saying that the electrical system has a problem. Driving a little more to reach my parents house and it starts saying to stop and check power supply. We ended up making it to my parents house and decided that it was unsafe to drive anymore with the error message going off. I called a tow truck to tow it back to our dealership in Fremont. When the tow came, I thought we could drive it on the bed but turns out the vehicle wouldn't start. We jumped the 12V batt… Look up ODI 11511391 at NHTSA ↗ ODI 11516145On March/17/2023 @24962 miles Integrated Charge Control Unit failure + 30 AMP Fuse. Hyundai Corporate said parts back order May---June/2023 time frame. 3 inch orange circle came up on my dash with red triangle saying PULL OVER IMMEDIATELY! I was two blocks from dealership and with no problems drive to the service advisor where it died in front of them. Service advisor guessed that the pop I heard just before the circle appeared was the fuse and I drove in on the 12volt battery. I am in the Buy Back process with Hyundai Corporate Case#21170992 Look up ODI 11516145 at NHTSA ↗ | 182ODI 11477732 · 494 miThe contact's father owns a 2022 Hyundai Ioniq 5. The contact stated that as her father attempted to place the vehicle into reverse(R) while in park(P), the gear shifter failed to operate as needed. As her father exited the vehicle with the gear shifter in the park(P)position, the vehicle accelerated on its own into his garage. The air bags did not deploy upon impact. The contact's father was not injured and a police report was not filed. The garage door and pillar were damaged, as well as, the vehicle's driver-side door. The vehicle was initia… Look up ODI 11477732 at NHTSA ↗ ODI 11511572Was in the middle of driving when a loud alert sounded and the dashboard showed the error "Stop vehicle and check power supply". The car otherwise behaved normally. I pulled into a parking log, looked at the only thing I knew how to look at (12v battery), confirmed it was still plugged in, and turned the car back on. The error was still there, but now the car wouldn't go over 26mph. I limped home, called a tow truck to take it to the nearest Hyundai that services electric vehicles, and they told me they'd have to replace the ICCU, which is … Look up ODI 11511572 at NHTSA ↗ ODI 11515756The car was driving fine, and an error popped up indicating to pull over and check battery. As I am going to pull over a red flashing indicator pops up saying “pull over and check battery”. As I start to pull over the car speed drops to 25 miles per hour and fully dies as I make it to the side of the road. Look up ODI 11515756 at NHTSA ↗ | 44ODI 11523131As I was parking my car I got a yellow warning battery light. It said to check the electrical system. When starting the car the warning light came back on and this time the car went into "turtle mode" where the car won't go over 25 miles per hour. After that the car flashed a red warning light and said to stop driving immediately. I called for a tow and the dealership diagnosed the problem as an ICCU and Fuse problem. They informed me they have ordered the part but that it make take over a month to get the part in. The car only has 11,000… Look up ODI 11523131 at NHTSA ↗ ODI 11523386The vehicle does not charge. After multiple attempts by the dealer to fix the issues, the vehicle is still in the shop. I am told it now charges on level 3 chargers (super chargers not available widely) only and does not charge on level 1 and 2. Various parts have been replaced but Hyundai corporate and the dealer has not been able to identify the issue or fix the problem after 45 days. I have filed a complaint with Hyundai and requested that the company buyback the vehicle. No response from Hyundai. I do not feel safe driving the vehicle. … Look up ODI 11523386 at NHTSA ↗ ODI 11524058The vehicle does not illuminate the brake lights when slowing down in ipedal and level 3 regen modes without actually pressing down the brake pedal. Look up ODI 11524058 at NHTSA ↗ | 92ODI 11523775Electrical system not working. The vehicle does not charge. The 12Volt battery is completely dead and vehicle does not start. Before the vehicle gone offline - it was reporting Electrical System is not charging and dead immediately. I towed the vehicle to Route 1 South, South Brunswick, NJ Hyundai Dealership on May 19th, and still in repairs. The main battery pack was showing 90% charge. The vehicle reported problem in the middle of the driving and completely slowed down to below 25Miles before and came to grinding halt. Jumpstarting the vehi… Look up ODI 11523775 at NHTSA ↗ ODI 11524961Started vehicle and heard a loud pop with immediate amber warning to check electrical system with 12 volt battery and EV electrical system warning lights illuminated. While driving to dealerships, vehicle slowed abruptly at Highway speed and warning message said to stop vehicle immediately. Towed to dealership with probable bad integrated charging control unit and high voltage fuse blown. Seems to be an issue with many ioniq 5s. Recall this vehicle! Look up ODI 11524961 at NHTSA ↗ ODI 11527547Called an ICCU failure. It's the control unit that charges the 12V battery from the high voltage battery. The unit fails blowing the high voltage fuse. Failure of this component causes the vehicle to all but shut down, even while driving. This is known by Hyundai. Others have said this happens at about 12 months and 10,000 miles. My car was 53/54weeks old and had 9,300 miles. This failure of this part may have also caused my AC to stop working. As pressure sensor on the 12V system that was working before the component failed was not working wh… Look up ODI 11527547 at NHTSA ↗ | 33ODI 11528080Driving the car about at 45mph then I heard a pop sound from the rear of the car. Car displayed warning "Check Electrical Vehicle System." I pull over, shut it off, then restarted it. The "check Electrical Vehicle System" light stills on then an emergency message displayed 'Stop Vehicle and Check Power Supply.' When I tried to drive to a safe place I noticed the car would not drive faster than 25mph. If this would have happened in a highway this could have been a safety issue. Dealership confirmed that the Integrated Charge Circuit Unit (ICCU) … Look up ODI 11528080 at NHTSA ↗ ODI 11528536Was driving the vehicle in a local road and felt sudden drop in vehicle speed. Had to press hard the acceleration pedal to avoid any collision from behind. The vehicle could not gain enough speed in a ~45~60mile speed zone and driven ~2miles slowly to work place. The vehicle had to be towed to a local delearship as they suggested. The warning message was 'Stop vehicle and check Power supply' immediately after and changed to 'Check EV System' when started ~1hr later at the time of towing. The local dealership diagnosed it to be needing a new ICC… Look up ODI 11528536 at NHTSA ↗ ODI 11538850Check electric charge error displayed, alarm sounding, loss of power to the vehicle while driving (limp mode). Look up ODI 11538850 at NHTSA ↗ | 19ODI 11460054I started my car up right after charging on a rainy day at 2500 miles exactly and got 5 warnings. Check battery, lane assist warning, abs warning, parking brake warning, forward collision warning and bling spot collision avoidance warning lights were on. More or less all these systems triggered a fault. I tried turning it off and on to no luck. As I drove to the dealer my breaks became steadily lighter and lighter with the manual break even clicking at times. My breaking distance was doubled by the time that i got there. Other owners are seein… Look up ODI 11460054 at NHTSA ↗ ODI 11524058The vehicle does not illuminate the brake lights when slowing down in ipedal and level 3 regen modes without actually pressing down the brake pedal. Look up ODI 11524058 at NHTSA ↗ ODI 11527751This is an electric vehicle that features “iPedal” driving, what Hyundai refers to as one-pedal driving. The main safety issue is that when you decelerate using one pedal, which is a fairly aggressive deceleration, the brake lights do not come on unless you lift your foot entirely from the accelerator or apply the brake pedal (which one would rarely do in iPedal mode). Hyundai needs to rethink their concept of operations for how their brake lights should operate. People are at risk of getting rear-ended. I didn’t realize this was how the vehi… Look up ODI 11527751 at NHTSA ↗ | 4ODI 11652002Instrument panel on car will not turn on when car is started. Thus, all advanced cruise control and safety systems do not function. Car has not been to the dealership for repair yet. There were no warnings or any other indication that there was an impending problem. Look up ODI 11652002 at NHTSA ↗ ODI 11716969ICCU FAILED and Hyundai service states that part is back ordered indefinitely. Has been 2 weeks with no further updates Additionally service department is unable to repair forward monitoring sensors that quit working with the smallest amount of precipitation, sometimes just from road condensation. Look up ODI 11716969 at NHTSA ↗ ODI 11689922FORWARD ATTENTION WARNING When driving, the vehicle randomly and repeatedly warns the driver to pay attention to the road even when the driver is facing forward and paying attention to the road. The system will also randomly and repeatedly alarm, disable cruise control and apply the brakes even when the driver has both hands on the wheel and is facing forward. This has nearly caused crashes. Hyundai states the system is working as designed and suggested: 1. Driver is too tall for the system see my eyes. 2. Do not wear prescription glasses. … Look up ODI 11689922 at NHTSA ↗ |
|---|
| Fuel/Propulsion System | 211ODI 11509814We were driving vehicle on a neighborhood street with a speed limit of 45 miles per hour. When we got a "High voltage fault warning" from the car. I continued to drive about 10 second more and got a second warning. A different series of warnings appeared the last one being "please pull over and check your electrical system". We pulled into a neighborhood street, turned off the car. We decided to try to make it home which was less than 1/2 mile. Once I restarted the car, both messages cycled through the dashboard. Then the car lost the abi… Look up ODI 11509814 at NHTSA ↗ ODI 11511391I was driving to my parents house when suddenly a message popped up on my driver screen saying that the electrical system has a problem. Driving a little more to reach my parents house and it starts saying to stop and check power supply. We ended up making it to my parents house and decided that it was unsafe to drive anymore with the error message going off. I called a tow truck to tow it back to our dealership in Fremont. When the tow came, I thought we could drive it on the bed but turns out the vehicle wouldn't start. We jumped the 12V batt… Look up ODI 11511391 at NHTSA ↗ ODI 11516145On March/17/2023 @24962 miles Integrated Charge Control Unit failure + 30 AMP Fuse. Hyundai Corporate said parts back order May---June/2023 time frame. 3 inch orange circle came up on my dash with red triangle saying PULL OVER IMMEDIATELY! I was two blocks from dealership and with no problems drive to the service advisor where it died in front of them. Service advisor guessed that the pop I heard just before the circle appeared was the fuse and I drove in on the 12volt battery. I am in the Buy Back process with Hyundai Corporate Case#21170992 Look up ODI 11516145 at NHTSA ↗ | — | 83ODI 11514095After a few minutes of driving, the vehicle presented a warning "Check Electric Vehicle System" and then got really slow. We were able to limp back home, where it is now parked. Hyundai has not had availability to diagnose the issue. Look up ODI 11514095 at NHTSA ↗ ODI 11520367On 4/24/23, without an prior warning vehicle suddenly became undrivable. Received message: "Stop vehicle and check power supply". Car could lim along < 25mph for short distances. This condition along with indifferent Hyundai roadside assist left me stranded out of state for 5 hours before telling me to find my own way to tow the car. Car is at dealership with a diagnosed ICCU/ICCU fuse issue. To date I am being told that the parts are on back order for 2-3 weeks. Based upon online posts by others with this issue, this is not a realistic e… Look up ODI 11520367 at NHTSA ↗ ODI 11522548Likely ICCU failure incapacitated vehicle while in motion on highway. Vehicle decelerated uncontrollably and would not re-accelerate. Shortly thereafter 12v battery warning appeared and vehicle was no longer operable. Series of warning lights. “check electric vehicle system” upon car starting, “Stop vehicle and check power supply” shortly after starting drive, "12v battery very low" immediately before vehicle went completely dead. Look up ODI 11522548 at NHTSA ↗ | 7ODI 11657228Hyundai Ioniq EV's have a continuing issue with a component called that "ICCU". The ICCU and high voltage fuse failed even after two recalls meant to monitor that problem and update the software. Luckily, mine failed in my driveway at home which did not put me in immediate risk. However, many people have this part fail while driving on roads and highways with zero warning. There have been two ICCU-related recalls that my car has had. When I started my vehicle I heard a "pop" and then the dashboard said "Check vehicle electrical system" an… Look up ODI 11657228 at NHTSA ↗ ODI 11713986The component that malfunctioned is the Integrated Charge Control Unit (ICCU) and related high-voltage charging system in my 2022 Hyundai Ioniq 5. The ICCU controls AC (Level 2) charging, DC fast charging functions, and power delivery. The ICCU assembly and charging components were serviced and replaced by an authorized Hyundai dealer and are available for inspection through service records. This defect created a safety risk because the vehicle experienced complete charging failure and reduced-power operation. Loss of charging capability can le… Look up ODI 11713986 at NHTSA ↗ ODI 11719583I was traveling on the freeway when I got a warning saying “check electrical.”i started to pull over on the freeway and my car went into “turtle mode “and I made it off the offramp but almost got rear ended. I was half a mile from home so I limp home in a tow truck towed off. It was determined it is the ICCU. Look up ODI 11719583 at NHTSA ↗ | 29ODI 11524961Started vehicle and heard a loud pop with immediate amber warning to check electrical system with 12 volt battery and EV electrical system warning lights illuminated. While driving to dealerships, vehicle slowed abruptly at Highway speed and warning message said to stop vehicle immediately. Towed to dealership with probable bad integrated charging control unit and high voltage fuse blown. Seems to be an issue with many ioniq 5s. Recall this vehicle! Look up ODI 11524961 at NHTSA ↗ ODI 11535998When in motion, the “EV Start Stop”button is still allowed to turn off the vehicle if accidentally pressed. This happened to me while on the highway and moving about 15-20 MPH. The vehicle suddenly lose power and wouldn’t accelerate. I could not move the vehicle, without hitting the EV Start Stop button several times. Look up ODI 11535998 at NHTSA ↗ ODI 11538435While driving on the highway on 8/12 at around 4pm, with another passenger, doing approximately 65 MPH I received a "Check Electric Vehicle System" warning on my dashboard. The car showed no prior warnings, no other lights were on. MyHyundai app was also showing no diagnostic issues with the car. The car battery was showing a 77% charge at the time. I swerved on to the shoulder, putting myself in danger as this is a really busy highway. I checked the car and could not find anything wrong. Hyundai had not contacted me regarding any recalls. I … Look up ODI 11538435 at NHTSA ↗ | 16ODI 11578415My vehicle was fully charged. About 1 mile after leaving my house, I received a warning message on my display (vehicle electrical system error or similar). Shortly after I received another message that power was reduced, then finally, "stop driving". I pulled into the nearest driveway and called roadside assistance. At that point, the vehicle was COMPLETELY dead. No lights or power whatsoever. I could not activate the car to shift into neutral. I had my vehicle towed to the dealership. They said it was due to a faulty ICCU and fuse. … Look up ODI 11578415 at NHTSA ↗ ODI 11581623I was driving 75mph on the freeway and I heard a pop and then the electrical warning system on the car lit up. I lost power to the car and was only able to accelerate minimally. There was a warning of low battery and the vehicle was going to lose power. I turned on my hazard lights and was able to get to the exit and was able to exit the freeway safely. Once the vehicle lost power I was unable to open the charger door, start the vehicle, use any of the key fob functions and had to jump the 12V battery, only to die immediately after. There is n… Look up ODI 11581623 at NHTSA ↗ ODI 11714329The ICCU component failed. I lost propulsion while driving and almost got rear ended. The dealership service department confirmed the ICCU issue. The dealership service department has inspected the vehicle. I had a dead 12v a month prior that I had asked the service department to look at and test the ICCU. They did not test the ICCU. The car warned me 30 seconds maybe less before i lost propulsion. Look up ODI 11714329 at NHTSA ↗ | 3ODI 11527751This is an electric vehicle that features “iPedal” driving, what Hyundai refers to as one-pedal driving. The main safety issue is that when you decelerate using one pedal, which is a fairly aggressive deceleration, the brake lights do not come on unless you lift your foot entirely from the accelerator or apply the brake pedal (which one would rarely do in iPedal mode). Hyundai needs to rethink their concept of operations for how their brake lights should operate. People are at risk of getting rear-ended. I didn’t realize this was how the vehi… Look up ODI 11527751 at NHTSA ↗ ODI 11743216OnXXX, as we approached what I call the 6 o’clock position of a round-about in [XXX], we had braked almost to a full stop (0-5 mph) to wait on the car ahead of us to enter the round-about when we felt increasing movement. Despite braking, to wait on that car, our car with increasing speed started shoving that car into the circle. Fortunately, he was able to drive away from us, but that car had been damaged on the back and right side. With that obstacle out of the way, our car rapidly and exponentially increased speed - all while we were full… Look up ODI 11743216 at NHTSA ↗ ODI 11650928My wife was parking the 2024 ioniq and it lurched forward at a high rate of speed and slammed into another car parked in our driveway and drove that vehicle through our home garage door. She feels certain that her foot was on the brake, but even if she accidentally slipped and appleid the brake the forward collision system should have prevented the accident additionally the impact occurred with such force it is unlikely due to human error as it pushed our very heavy 4Runner back 3 feet and thorough a closed garage door. Look up ODI 11650928 at NHTSA ↗ | 1ODI 11528988Cruise control became disabled and then unable to accelerate when pressing down on accelerator Look up ODI 11528988 at NHTSA ↗ |
|---|
| Power Train | 182ODI 11477732 · 494 miThe contact's father owns a 2022 Hyundai Ioniq 5. The contact stated that as her father attempted to place the vehicle into reverse(R) while in park(P), the gear shifter failed to operate as needed. As her father exited the vehicle with the gear shifter in the park(P)position, the vehicle accelerated on its own into his garage. The air bags did not deploy upon impact. The contact's father was not injured and a police report was not filed. The garage door and pillar were damaged, as well as, the vehicle's driver-side door. The vehicle was initia… Look up ODI 11477732 at NHTSA ↗ ODI 11511572Was in the middle of driving when a loud alert sounded and the dashboard showed the error "Stop vehicle and check power supply". The car otherwise behaved normally. I pulled into a parking log, looked at the only thing I knew how to look at (12v battery), confirmed it was still plugged in, and turned the car back on. The error was still there, but now the car wouldn't go over 26mph. I limped home, called a tow truck to take it to the nearest Hyundai that services electric vehicles, and they told me they'd have to replace the ICCU, which is … Look up ODI 11511572 at NHTSA ↗ ODI 11515756The car was driving fine, and an error popped up indicating to pull over and check battery. As I am going to pull over a red flashing indicator pops up saying “pull over and check battery”. As I start to pull over the car speed drops to 25 miles per hour and fully dies as I make it to the side of the road. Look up ODI 11515756 at NHTSA ↗ | 83ODI 11514095After a few minutes of driving, the vehicle presented a warning "Check Electric Vehicle System" and then got really slow. We were able to limp back home, where it is now parked. Hyundai has not had availability to diagnose the issue. Look up ODI 11514095 at NHTSA ↗ ODI 11520367On 4/24/23, without an prior warning vehicle suddenly became undrivable. Received message: "Stop vehicle and check power supply". Car could lim along < 25mph for short distances. This condition along with indifferent Hyundai roadside assist left me stranded out of state for 5 hours before telling me to find my own way to tow the car. Car is at dealership with a diagnosed ICCU/ICCU fuse issue. To date I am being told that the parts are on back order for 2-3 weeks. Based upon online posts by others with this issue, this is not a realistic e… Look up ODI 11520367 at NHTSA ↗ ODI 11522548Likely ICCU failure incapacitated vehicle while in motion on highway. Vehicle decelerated uncontrollably and would not re-accelerate. Shortly thereafter 12v battery warning appeared and vehicle was no longer operable. Series of warning lights. “check electric vehicle system” upon car starting, “Stop vehicle and check power supply” shortly after starting drive, "12v battery very low" immediately before vehicle went completely dead. Look up ODI 11522548 at NHTSA ↗ | — | 7ODI 11713986The component that malfunctioned is the Integrated Charge Control Unit (ICCU) and related high-voltage charging system in my 2022 Hyundai Ioniq 5. The ICCU controls AC (Level 2) charging, DC fast charging functions, and power delivery. The ICCU assembly and charging components were serviced and replaced by an authorized Hyundai dealer and are available for inspection through service records. This defect created a safety risk because the vehicle experienced complete charging failure and reduced-power operation. Loss of charging capability can le… Look up ODI 11713986 at NHTSA ↗ ODI 11719583I was traveling on the freeway when I got a warning saying “check electrical.”i started to pull over on the freeway and my car went into “turtle mode “and I made it off the offramp but almost got rear ended. I was half a mile from home so I limp home in a tow truck towed off. It was determined it is the ICCU. Look up ODI 11719583 at NHTSA ↗ ODI 11647491ICCU ASSY and Fuse had to be replaced as well as the 12 volt battery which failed a few weeks after. The car lost power on a main road 2/3/25 and we were just able to get into a parking lot. The message to check power supply came on and we lost power immediately. The 12 volt battery failed when I went to pick the car up from the dealership after they worked on the bluelink settings that had to be reconfigured a couple weeks later 2/25/25. I was lucky that I didn't have to be towed that time. I had just got into the car to leave and the wa… Look up ODI 11647491 at NHTSA ↗ | 30ODI 11527547Called an ICCU failure. It's the control unit that charges the 12V battery from the high voltage battery. The unit fails blowing the high voltage fuse. Failure of this component causes the vehicle to all but shut down, even while driving. This is known by Hyundai. Others have said this happens at about 12 months and 10,000 miles. My car was 53/54weeks old and had 9,300 miles. This failure of this part may have also caused my AC to stop working. As pressure sensor on the 12V system that was working before the component failed was not working wh… Look up ODI 11527547 at NHTSA ↗ ODI 11527794Car literally DIED while driving. Went from normal speed to 12mph to 6mph to dead. ICCU failure. Look up ODI 11527794 at NHTSA ↗ ODI 11539696While driving at highway speeds, there was a loud pop and the display showed "reduce power mode". We had to improvise a stopping place despite being far from home. There was no warning or issues beforehand. This incident was risky because of the loss of power while on a high speed thoroughfare and limited stopping options. The vehicle required a jump to move onto tow truck to take to dealership, where it has remained for two weeks without an estimate for repair. The symptoms.seem consistent with ICCU failure. Look up ODI 11539696 at NHTSA ↗ | 16ODI 11532858When driving for a distance at higher speeds, power will suddenly drop to the zero point btw acceleration and regeneration. You can feel the car start to drag as the power drops. If you press hard on the accelerator to stop it from slowing, it will suddenly jump forward. This has happened now on several long trips where I am constatly fighting with the car to keep it powered and not slipping into the zero zone. When it leaps forward the lane assist will also grab control and make it difficult to control the car. The car also stops slowing co… Look up ODI 11532858 at NHTSA ↗ ODI 11538850Check electric charge error displayed, alarm sounding, loss of power to the vehicle while driving (limp mode). Look up ODI 11538850 at NHTSA ↗ ODI 11553133Every so often when I am driving on the highway, the car just looses power and I may catch a message that flashes on my display, "Emergency Braking". The event last no longer than about a second. When this phantom braking happens, so far, it has not been so severe to feel dangerous just unsettling! Look up ODI 11553133 at NHTSA ↗ | 8ODI 11479985When my IONIQ5 slowly starts and stops while the brake pedal engages or disengages, a noise, something like "click," comes from the rear passenger wheel house. Then, the brakes feel somewhat slippery. I think this has something to do with a transition between the regen brake and the traditional brake. The noise comes up every time I drive. Sometimes, I feel very unsafe because I am worried that the brake system fails. Look up ODI 11479985 at NHTSA ↗ ODI 11523849This vehicle's brake lights do not come on when using regenerative braking. The regenerative braking can bring this car to a complete stop fairly quickly and the brake lights should come on. Several near misses of people almost rear-ending me, and a few got mad enough that I feared a road rage incident. This after only owning the car for 2 weeks. Look up ODI 11523849 at NHTSA ↗ ODI 11553133Every so often when I am driving on the highway, the car just looses power and I may catch a message that flashes on my display, "Emergency Braking". The event last no longer than about a second. When this phantom braking happens, so far, it has not been so severe to feel dangerous just unsettling! Look up ODI 11553133 at NHTSA ↗ | 2ODI 11550946Driving on freeway when adaptive cruise control turns off and had a sudden complete loss of acceleration, we had steering and brakes only. Sudden reduction of car speed in traffic could cause accident. Has only happened once in 20k miles. (no acceleration) Adaptive cruise control shuts off for no reason, but dealer couldn't replicate. In recent 8k trip we photographed warning on dash 17 + times after shut down. Dealer couldn't find any saved trouble codes for this. No warnings prior to any occurrence only after, dash turned off on acceleration … Look up ODI 11550946 at NHTSA ↗ ODI 117244821 Vehicle fails to start x 6 , dealer unable to fix, falsely identified 2 documented DTCs P31C507 specifically indicates a "possible condition with your Vehicle Control Unit (VCU) / Low DC-DC Converter (LDC)" dealer stated as charger problem when this is often associated with thousands of ICCU problems in this vehicle 2 many ADAS cruise control faults. A vehicle slows and, once stopped, at freeway speed on corners or when a large vehicle is in a nearby, separate lane. Fails to detect the vehicle in the next lane when activating lane change. 3.… Look up ODI 11724482 at NHTSA ↗ |
|---|
| Unknown Or Other | 44ODI 11523131As I was parking my car I got a yellow warning battery light. It said to check the electrical system. When starting the car the warning light came back on and this time the car went into "turtle mode" where the car won't go over 25 miles per hour. After that the car flashed a red warning light and said to stop driving immediately. I called for a tow and the dealership diagnosed the problem as an ICCU and Fuse problem. They informed me they have ordered the part but that it make take over a month to get the part in. The car only has 11,000… Look up ODI 11523131 at NHTSA ↗ ODI 11523386The vehicle does not charge. After multiple attempts by the dealer to fix the issues, the vehicle is still in the shop. I am told it now charges on level 3 chargers (super chargers not available widely) only and does not charge on level 1 and 2. Various parts have been replaced but Hyundai corporate and the dealer has not been able to identify the issue or fix the problem after 45 days. I have filed a complaint with Hyundai and requested that the company buyback the vehicle. No response from Hyundai. I do not feel safe driving the vehicle. … Look up ODI 11523386 at NHTSA ↗ ODI 11524058The vehicle does not illuminate the brake lights when slowing down in ipedal and level 3 regen modes without actually pressing down the brake pedal. Look up ODI 11524058 at NHTSA ↗ | 7ODI 11657228Hyundai Ioniq EV's have a continuing issue with a component called that "ICCU". The ICCU and high voltage fuse failed even after two recalls meant to monitor that problem and update the software. Luckily, mine failed in my driveway at home which did not put me in immediate risk. However, many people have this part fail while driving on roads and highways with zero warning. There have been two ICCU-related recalls that my car has had. When I started my vehicle I heard a "pop" and then the dashboard said "Check vehicle electrical system" an… Look up ODI 11657228 at NHTSA ↗ ODI 11713986The component that malfunctioned is the Integrated Charge Control Unit (ICCU) and related high-voltage charging system in my 2022 Hyundai Ioniq 5. The ICCU controls AC (Level 2) charging, DC fast charging functions, and power delivery. The ICCU assembly and charging components were serviced and replaced by an authorized Hyundai dealer and are available for inspection through service records. This defect created a safety risk because the vehicle experienced complete charging failure and reduced-power operation. Loss of charging capability can le… Look up ODI 11713986 at NHTSA ↗ ODI 11719583I was traveling on the freeway when I got a warning saying “check electrical.”i started to pull over on the freeway and my car went into “turtle mode “and I made it off the offramp but almost got rear ended. I was half a mile from home so I limp home in a tow truck towed off. It was determined it is the ICCU. Look up ODI 11719583 at NHTSA ↗ | 7ODI 11713986The component that malfunctioned is the Integrated Charge Control Unit (ICCU) and related high-voltage charging system in my 2022 Hyundai Ioniq 5. The ICCU controls AC (Level 2) charging, DC fast charging functions, and power delivery. The ICCU assembly and charging components were serviced and replaced by an authorized Hyundai dealer and are available for inspection through service records. This defect created a safety risk because the vehicle experienced complete charging failure and reduced-power operation. Loss of charging capability can le… Look up ODI 11713986 at NHTSA ↗ ODI 11719583I was traveling on the freeway when I got a warning saying “check electrical.”i started to pull over on the freeway and my car went into “turtle mode “and I made it off the offramp but almost got rear ended. I was half a mile from home so I limp home in a tow truck towed off. It was determined it is the ICCU. Look up ODI 11719583 at NHTSA ↗ ODI 11647491ICCU ASSY and Fuse had to be replaced as well as the 12 volt battery which failed a few weeks after. The car lost power on a main road 2/3/25 and we were just able to get into a parking lot. The message to check power supply came on and we lost power immediately. The 12 volt battery failed when I went to pick the car up from the dealership after they worked on the bluelink settings that had to be reconfigured a couple weeks later 2/25/25. I was lucky that I didn't have to be towed that time. I had just got into the car to leave and the wa… Look up ODI 11647491 at NHTSA ↗ | — | 8ODI 11569668It is UNKNOWN what component or system failed There was a sudden and total electrical failure with the inability to safely move the car. If this electrical failure had occurred on a turnpike or expressway it would have been a catastrophic event. Car was flat bedded to a dealership Dashboard warning provided less than 5 min time and 0.5 mile before ceasing to operate at all although car's computer thought that the car's health was OK. Look up ODI 11569668 at NHTSA ↗ ODI 11657228Hyundai Ioniq EV's have a continuing issue with a component called that "ICCU". The ICCU and high voltage fuse failed even after two recalls meant to monitor that problem and update the software. Luckily, mine failed in my driveway at home which did not put me in immediate risk. However, many people have this part fail while driving on roads and highways with zero warning. There have been two ICCU-related recalls that my car has had. When I started my vehicle I heard a "pop" and then the dashboard said "Check vehicle electrical system" an… Look up ODI 11657228 at NHTSA ↗ ODI 11715398The Ioniq 5 has a known issue with a part called the ICCU. When the part fails, which it seems to inevitably do despite multiple recall repair visits and software upgrades, the car ceases to be driveable. In advance of this moment when your multi ton vehicle turns into a brick you get a short warning saying pull over, but that is not always possible. The car starts loudly beeping and reduces its max speed to 12 mph, which is not great on the freeway. The ICCU is a huge safety problem, a known issue that Hyundai is well aware of, and the part ne… Look up ODI 11715398 at NHTSA ↗ | 3ODI 11514327Hi! My vehicle went under a recall repair last month. Once completed, the acceleration significantly decreased in the ECO drive train mode. The other modes are working as before. I have been advised that this recall service was required by the NTSB. There are reports of this occurring on credible websites as well. I did report it to Hyundai, they didn't believe me. So, I am reporting this to you. Please fix my car! Look up ODI 11514327 at NHTSA ↗ ODI 11715997I am reporting a safety-related defect involving unintended vehicle movement on my Hyundai Ioniq 5 (Model Year 2023, SEL AWD). Observed behavior: With the vehicle in Drive and the Auto Hold function active (indicated by the white “AUTO HOLD” indicator in the instrument cluster), I brought the vehicle to a complete stop by pressing the brake pedal. Auto Hold engaged (text now green), the vehicle remained stationary, and I removed my foot from the brake. After approximately three minutes of remaining stopped, a driver-assistance system error mes… Look up ODI 11715997 at NHTSA ↗ ODI 11762153Driving home near my apartment, I had to join a busy highway from a full stop. I found a small gap and tried to accelerate to quickly merge into traffic, when my car made a high pitched alert noise and noticably did not accelerate beyond about 25 miles per hour on a 45-50mph highway with heavy traffic. I turned on my hazards and still ended up with a line up of cars honking behind me. Flooring the accelerator did absolutely nothing to increase my speed. On slight downhills I could get up to about 40mph but as soon as it leveled off my speed wen… Look up ODI 11762153 at NHTSA ↗ | 5ODI 11524058The vehicle does not illuminate the brake lights when slowing down in ipedal and level 3 regen modes without actually pressing down the brake pedal. Look up ODI 11524058 at NHTSA ↗ ODI 11541676Vehicle suspension in the rear feels unsettled when coming to a stop using regenerative brakes. If you hit a small pothole or recessed manhole cover the rear of the vehicle feels like the rear suspension is jumping. I've taken it to the dealer and they noticed it and also it occurred on a new ioniq 5 they had on the lot also. Look up ODI 11541676 at NHTSA ↗ ODI 11591277When you place the car in park a recall was done so that the emergency parking brake automatically engages. Well between 30 seconds to a minute after the car is in park, the brake disengage. When you go to set it manually after it disengage, it will still disengage. Look up ODI 11591277 at NHTSA ↗ | 1ODI 11700113Despite going back to the dealer to address the issue, and trying all the recommended modifications, the Forward Attention Warning (FAW) goes off repeatedly when the car is utilizing adaptive cruise control. I have written and called Hyundai National to ask to defeat this feature and it is not allowed. This FAW alarm (ironically) diverts my attention from driving as I am having to constantly respond to the alarm. I need the adaptive cruise control in certain situations and Hyundai will not allow me to override the FAW when the car is in adaptiv… Look up ODI 11700113 at NHTSA ↗ |
|---|
| Engine | 92ODI 11523775Electrical system not working. The vehicle does not charge. The 12Volt battery is completely dead and vehicle does not start. Before the vehicle gone offline - it was reporting Electrical System is not charging and dead immediately. I towed the vehicle to Route 1 South, South Brunswick, NJ Hyundai Dealership on May 19th, and still in repairs. The main battery pack was showing 90% charge. The vehicle reported problem in the middle of the driving and completely slowed down to below 25Miles before and came to grinding halt. Jumpstarting the vehi… Look up ODI 11523775 at NHTSA ↗ ODI 11524961Started vehicle and heard a loud pop with immediate amber warning to check electrical system with 12 volt battery and EV electrical system warning lights illuminated. While driving to dealerships, vehicle slowed abruptly at Highway speed and warning message said to stop vehicle immediately. Towed to dealership with probable bad integrated charging control unit and high voltage fuse blown. Seems to be an issue with many ioniq 5s. Recall this vehicle! Look up ODI 11524961 at NHTSA ↗ ODI 11527547Called an ICCU failure. It's the control unit that charges the 12V battery from the high voltage battery. The unit fails blowing the high voltage fuse. Failure of this component causes the vehicle to all but shut down, even while driving. This is known by Hyundai. Others have said this happens at about 12 months and 10,000 miles. My car was 53/54weeks old and had 9,300 miles. This failure of this part may have also caused my AC to stop working. As pressure sensor on the 12V system that was working before the component failed was not working wh… Look up ODI 11527547 at NHTSA ↗ | 29ODI 11524961Started vehicle and heard a loud pop with immediate amber warning to check electrical system with 12 volt battery and EV electrical system warning lights illuminated. While driving to dealerships, vehicle slowed abruptly at Highway speed and warning message said to stop vehicle immediately. Towed to dealership with probable bad integrated charging control unit and high voltage fuse blown. Seems to be an issue with many ioniq 5s. Recall this vehicle! Look up ODI 11524961 at NHTSA ↗ ODI 11535998When in motion, the “EV Start Stop”button is still allowed to turn off the vehicle if accidentally pressed. This happened to me while on the highway and moving about 15-20 MPH. The vehicle suddenly lose power and wouldn’t accelerate. I could not move the vehicle, without hitting the EV Start Stop button several times. Look up ODI 11535998 at NHTSA ↗ ODI 11538435While driving on the highway on 8/12 at around 4pm, with another passenger, doing approximately 65 MPH I received a "Check Electric Vehicle System" warning on my dashboard. The car showed no prior warnings, no other lights were on. MyHyundai app was also showing no diagnostic issues with the car. The car battery was showing a 77% charge at the time. I swerved on to the shoulder, putting myself in danger as this is a really busy highway. I checked the car and could not find anything wrong. Hyundai had not contacted me regarding any recalls. I … Look up ODI 11538435 at NHTSA ↗ | 30ODI 11527547Called an ICCU failure. It's the control unit that charges the 12V battery from the high voltage battery. The unit fails blowing the high voltage fuse. Failure of this component causes the vehicle to all but shut down, even while driving. This is known by Hyundai. Others have said this happens at about 12 months and 10,000 miles. My car was 53/54weeks old and had 9,300 miles. This failure of this part may have also caused my AC to stop working. As pressure sensor on the 12V system that was working before the component failed was not working wh… Look up ODI 11527547 at NHTSA ↗ ODI 11527794Car literally DIED while driving. Went from normal speed to 12mph to 6mph to dead. ICCU failure. Look up ODI 11527794 at NHTSA ↗ ODI 11539696While driving at highway speeds, there was a loud pop and the display showed "reduce power mode". We had to improvise a stopping place despite being far from home. There was no warning or issues beforehand. This incident was risky because of the loss of power while on a high speed thoroughfare and limited stopping options. The vehicle required a jump to move onto tow truck to take to dealership, where it has remained for two weeks without an estimate for repair. The symptoms.seem consistent with ICCU failure. Look up ODI 11539696 at NHTSA ↗ | 8ODI 11569668It is UNKNOWN what component or system failed There was a sudden and total electrical failure with the inability to safely move the car. If this electrical failure had occurred on a turnpike or expressway it would have been a catastrophic event. Car was flat bedded to a dealership Dashboard warning provided less than 5 min time and 0.5 mile before ceasing to operate at all although car's computer thought that the car's health was OK. Look up ODI 11569668 at NHTSA ↗ ODI 11657228Hyundai Ioniq EV's have a continuing issue with a component called that "ICCU". The ICCU and high voltage fuse failed even after two recalls meant to monitor that problem and update the software. Luckily, mine failed in my driveway at home which did not put me in immediate risk. However, many people have this part fail while driving on roads and highways with zero warning. There have been two ICCU-related recalls that my car has had. When I started my vehicle I heard a "pop" and then the dashboard said "Check vehicle electrical system" an… Look up ODI 11657228 at NHTSA ↗ ODI 11715398The Ioniq 5 has a known issue with a part called the ICCU. When the part fails, which it seems to inevitably do despite multiple recall repair visits and software upgrades, the car ceases to be driveable. In advance of this moment when your multi ton vehicle turns into a brick you get a short warning saying pull over, but that is not always possible. The car starts loudly beeping and reduces its max speed to 12 mph, which is not great on the freeway. The ICCU is a huge safety problem, a known issue that Hyundai is well aware of, and the part ne… Look up ODI 11715398 at NHTSA ↗ | — | 4ODI 11563407ICCU failed and Fuse failed, causing car to go into turtle mode, barely made it hope to have it towed to dealer Look up ODI 11563407 at NHTSA ↗ ODI 11568130Driving the vehicle on the highway for longer than 60 miles at highway speeds the vehicle goes into “power limited” mode and a turtle pops up on the screen. You are unable to accelerate the car and once this happens you have to leave the car off for at least 5 minutes and then not drive above 65mph again or it will keep happening over and over. After taking it to the shop Hyundai Corporate said we need to drive the car again to see if they had fixed it. Approximately 65 miles into the trip it happened again and this time I was almost rear ended… Look up ODI 11568130 at NHTSA ↗ ODI 11711755My 2023 Hyundai Ioniq 5 suffered a sudden Integrated Charging Control Unit (ICCU) failure that put me in grave danger. As I left my workplace in the evening, I heard a “pop” sound and got the dashboard warning, “Check Electrical Vehicle System.” It was unclear what the warning meant. I had 65% charge left at that point. As I began driving, the gas pedal “stuck,” not allowing me to accelerate past 25 mph, and it felt like the car was dragging. I did not know what was happening. The “Check Electrical Vehicle System” warning returned but gave no … Look up ODI 11711755 at NHTSA ↗ | 2ODI 11626861When driving in i-Pedal, which is a "one pedal driving option", sometimes after pausing the car rolls backs several inches. This appears to be a defect with the powetrain, regenerative braking engine, or otherwise. Hyundai's dealership has been advised of this issue; they have escalated this internally. A car in drive forward should never due to electrical or software reasons be told to move backwards -- which is what is happening here. Look up ODI 11626861 at NHTSA ↗ ODI 11735454On April 20th while parking the vehicle suddenly had a power surge crossing over multiple curbs and across a parking lot and landscaped areas and hitting a tree. The vehicle refused to brake and the driver airbag never deployed. Look up ODI 11735454 at NHTSA ↗ | 0 |
|---|
| Vehicle Speed Control | 33ODI 11528080Driving the car about at 45mph then I heard a pop sound from the rear of the car. Car displayed warning "Check Electrical Vehicle System." I pull over, shut it off, then restarted it. The "check Electrical Vehicle System" light stills on then an emergency message displayed 'Stop Vehicle and Check Power Supply.' When I tried to drive to a safe place I noticed the car would not drive faster than 25mph. If this would have happened in a highway this could have been a safety issue. Dealership confirmed that the Integrated Charge Circuit Unit (ICCU) … Look up ODI 11528080 at NHTSA ↗ ODI 11528536Was driving the vehicle in a local road and felt sudden drop in vehicle speed. Had to press hard the acceleration pedal to avoid any collision from behind. The vehicle could not gain enough speed in a ~45~60mile speed zone and driven ~2miles slowly to work place. The vehicle had to be towed to a local delearship as they suggested. The warning message was 'Stop vehicle and check Power supply' immediately after and changed to 'Check EV System' when started ~1hr later at the time of towing. The local dealership diagnosed it to be needing a new ICC… Look up ODI 11528536 at NHTSA ↗ ODI 11538850Check electric charge error displayed, alarm sounding, loss of power to the vehicle while driving (limp mode). Look up ODI 11538850 at NHTSA ↗ | 16ODI 11578415My vehicle was fully charged. About 1 mile after leaving my house, I received a warning message on my display (vehicle electrical system error or similar). Shortly after I received another message that power was reduced, then finally, "stop driving". I pulled into the nearest driveway and called roadside assistance. At that point, the vehicle was COMPLETELY dead. No lights or power whatsoever. I could not activate the car to shift into neutral. I had my vehicle towed to the dealership. They said it was due to a faulty ICCU and fuse. … Look up ODI 11578415 at NHTSA ↗ ODI 11581623I was driving 75mph on the freeway and I heard a pop and then the electrical warning system on the car lit up. I lost power to the car and was only able to accelerate minimally. There was a warning of low battery and the vehicle was going to lose power. I turned on my hazard lights and was able to get to the exit and was able to exit the freeway safely. Once the vehicle lost power I was unable to open the charger door, start the vehicle, use any of the key fob functions and had to jump the 12V battery, only to die immediately after. There is n… Look up ODI 11581623 at NHTSA ↗ ODI 11714329The ICCU component failed. I lost propulsion while driving and almost got rear ended. The dealership service department confirmed the ICCU issue. The dealership service department has inspected the vehicle. I had a dead 12v a month prior that I had asked the service department to look at and test the ICCU. They did not test the ICCU. The car warned me 30 seconds maybe less before i lost propulsion. Look up ODI 11714329 at NHTSA ↗ | 16ODI 11532858When driving for a distance at higher speeds, power will suddenly drop to the zero point btw acceleration and regeneration. You can feel the car start to drag as the power drops. If you press hard on the accelerator to stop it from slowing, it will suddenly jump forward. This has happened now on several long trips where I am constatly fighting with the car to keep it powered and not slipping into the zero zone. When it leaps forward the lane assist will also grab control and make it difficult to control the car. The car also stops slowing co… Look up ODI 11532858 at NHTSA ↗ ODI 11538850Check electric charge error displayed, alarm sounding, loss of power to the vehicle while driving (limp mode). Look up ODI 11538850 at NHTSA ↗ ODI 11553133Every so often when I am driving on the highway, the car just looses power and I may catch a message that flashes on my display, "Emergency Braking". The event last no longer than about a second. When this phantom braking happens, so far, it has not been so severe to feel dangerous just unsettling! Look up ODI 11553133 at NHTSA ↗ | 3ODI 11514327Hi! My vehicle went under a recall repair last month. Once completed, the acceleration significantly decreased in the ECO drive train mode. The other modes are working as before. I have been advised that this recall service was required by the NTSB. There are reports of this occurring on credible websites as well. I did report it to Hyundai, they didn't believe me. So, I am reporting this to you. Please fix my car! Look up ODI 11514327 at NHTSA ↗ ODI 11715997I am reporting a safety-related defect involving unintended vehicle movement on my Hyundai Ioniq 5 (Model Year 2023, SEL AWD). Observed behavior: With the vehicle in Drive and the Auto Hold function active (indicated by the white “AUTO HOLD” indicator in the instrument cluster), I brought the vehicle to a complete stop by pressing the brake pedal. Auto Hold engaged (text now green), the vehicle remained stationary, and I removed my foot from the brake. After approximately three minutes of remaining stopped, a driver-assistance system error mes… Look up ODI 11715997 at NHTSA ↗ ODI 11762153Driving home near my apartment, I had to join a busy highway from a full stop. I found a small gap and tried to accelerate to quickly merge into traffic, when my car made a high pitched alert noise and noticably did not accelerate beyond about 25 miles per hour on a 45-50mph highway with heavy traffic. I turned on my hazards and still ended up with a line up of cars honking behind me. Flooring the accelerator did absolutely nothing to increase my speed. On slight downhills I could get up to about 40mph but as soon as it leveled off my speed wen… Look up ODI 11762153 at NHTSA ↗ | 4ODI 11563407ICCU failed and Fuse failed, causing car to go into turtle mode, barely made it hope to have it towed to dealer Look up ODI 11563407 at NHTSA ↗ ODI 11568130Driving the vehicle on the highway for longer than 60 miles at highway speeds the vehicle goes into “power limited” mode and a turtle pops up on the screen. You are unable to accelerate the car and once this happens you have to leave the car off for at least 5 minutes and then not drive above 65mph again or it will keep happening over and over. After taking it to the shop Hyundai Corporate said we need to drive the car again to see if they had fixed it. Approximately 65 miles into the trip it happened again and this time I was almost rear ended… Look up ODI 11568130 at NHTSA ↗ ODI 11711755My 2023 Hyundai Ioniq 5 suffered a sudden Integrated Charging Control Unit (ICCU) failure that put me in grave danger. As I left my workplace in the evening, I heard a “pop” sound and got the dashboard warning, “Check Electrical Vehicle System.” It was unclear what the warning meant. I had 65% charge left at that point. As I began driving, the gas pedal “stuck,” not allowing me to accelerate past 25 mph, and it felt like the car was dragging. I did not know what was happening. The “Check Electrical Vehicle System” warning returned but gave no … Look up ODI 11711755 at NHTSA ↗ | — | 14ODI 11503875I was driving on the highway using advanced highway assist and the car became completely unresponsive. I was traveling 75mph on a major highway with a semi behind me and one to my right in the slow lane. The car stopped accelerating and I was unable to resume driving. I was forced to coast to a stop on the side of the highway. I had my daughter with me and were I not able to safely maneuver between the semi trucks, we could have been killed or seriosuly injured in a high speed crash. Look up ODI 11503875 at NHTSA ↗ ODI 11509793The ioniq 5 has a one pedal driving mode, where the car will come to a complete stop without needing to press the brake pedal, similar to other EV's. In this mode, the gas pedal operates differently then in a conventional car - pressing the pedal approximately 1/3 of the way down represents neutral, where the car coasts. Pressing the pedal less then that - between 1/3 and not pressing it at all, applies braking power to the car, either through regenerative braking or the application of the physical brakes. The issue is, the brake lights on t… Look up ODI 11509793 at NHTSA ↗ ODI 11553133Every so often when I am driving on the highway, the car just looses power and I may catch a message that flashes on my display, "Emergency Braking". The event last no longer than about a second. When this phantom braking happens, so far, it has not been so severe to feel dangerous just unsettling! Look up ODI 11553133 at NHTSA ↗ | 12ODI 11503875I was driving on the highway using advanced highway assist and the car became completely unresponsive. I was traveling 75mph on a major highway with a semi behind me and one to my right in the slow lane. The car stopped accelerating and I was unable to resume driving. I was forced to coast to a stop on the side of the highway. I had my daughter with me and were I not able to safely maneuver between the semi trucks, we could have been killed or seriosuly injured in a high speed crash. Look up ODI 11503875 at NHTSA ↗ ODI 11522378While driving on highway I got below messages “Safety Functions are limited radar block warning message” Warning message went away after 15 minutes but then “Stop Vehicle Check Power Supply” warning message appeared and vehicle slowed on highway and stopped after 2 miles. Dealer replaced ICCU and Fuse that controls high voltage (charges 12v battery from main battery). Look up ODI 11522378 at NHTSA ↗ ODI 11528266Hyundai's connected car service (bluelink) suffered an outage that resulted in driver profiles on many Hyundai vehicles being deleted/reset. No notice was provided and the profiles were not recovered. As a result, the vehicles did not funtion as expected. Driver assist settings were set to default (steering, braking, and acceleration functions included). Hyundai provided instructions on how to set up a new profile in response rather than restoring the customer data to their personally owned hardware (car). Look up ODI 11528266 at NHTSA ↗ |
|---|
| Service Brakes | 19ODI 11460054I started my car up right after charging on a rainy day at 2500 miles exactly and got 5 warnings. Check battery, lane assist warning, abs warning, parking brake warning, forward collision warning and bling spot collision avoidance warning lights were on. More or less all these systems triggered a fault. I tried turning it off and on to no luck. As I drove to the dealer my breaks became steadily lighter and lighter with the manual break even clicking at times. My breaking distance was doubled by the time that i got there. Other owners are seein… Look up ODI 11460054 at NHTSA ↗ ODI 11524058The vehicle does not illuminate the brake lights when slowing down in ipedal and level 3 regen modes without actually pressing down the brake pedal. Look up ODI 11524058 at NHTSA ↗ ODI 11527751This is an electric vehicle that features “iPedal” driving, what Hyundai refers to as one-pedal driving. The main safety issue is that when you decelerate using one pedal, which is a fairly aggressive deceleration, the brake lights do not come on unless you lift your foot entirely from the accelerator or apply the brake pedal (which one would rarely do in iPedal mode). Hyundai needs to rethink their concept of operations for how their brake lights should operate. People are at risk of getting rear-ended. I didn’t realize this was how the vehi… Look up ODI 11527751 at NHTSA ↗ | 3ODI 11527751This is an electric vehicle that features “iPedal” driving, what Hyundai refers to as one-pedal driving. The main safety issue is that when you decelerate using one pedal, which is a fairly aggressive deceleration, the brake lights do not come on unless you lift your foot entirely from the accelerator or apply the brake pedal (which one would rarely do in iPedal mode). Hyundai needs to rethink their concept of operations for how their brake lights should operate. People are at risk of getting rear-ended. I didn’t realize this was how the vehi… Look up ODI 11527751 at NHTSA ↗ ODI 11743216OnXXX, as we approached what I call the 6 o’clock position of a round-about in [XXX], we had braked almost to a full stop (0-5 mph) to wait on the car ahead of us to enter the round-about when we felt increasing movement. Despite braking, to wait on that car, our car with increasing speed started shoving that car into the circle. Fortunately, he was able to drive away from us, but that car had been damaged on the back and right side. With that obstacle out of the way, our car rapidly and exponentially increased speed - all while we were full… Look up ODI 11743216 at NHTSA ↗ ODI 11650928My wife was parking the 2024 ioniq and it lurched forward at a high rate of speed and slammed into another car parked in our driveway and drove that vehicle through our home garage door. She feels certain that her foot was on the brake, but even if she accidentally slipped and appleid the brake the forward collision system should have prevented the accident additionally the impact occurred with such force it is unlikely due to human error as it pushed our very heavy 4Runner back 3 feet and thorough a closed garage door. Look up ODI 11650928 at NHTSA ↗ | 8ODI 11479985When my IONIQ5 slowly starts and stops while the brake pedal engages or disengages, a noise, something like "click," comes from the rear passenger wheel house. Then, the brakes feel somewhat slippery. I think this has something to do with a transition between the regen brake and the traditional brake. The noise comes up every time I drive. Sometimes, I feel very unsafe because I am worried that the brake system fails. Look up ODI 11479985 at NHTSA ↗ ODI 11523849This vehicle's brake lights do not come on when using regenerative braking. The regenerative braking can bring this car to a complete stop fairly quickly and the brake lights should come on. Several near misses of people almost rear-ending me, and a few got mad enough that I feared a road rage incident. This after only owning the car for 2 weeks. Look up ODI 11523849 at NHTSA ↗ ODI 11553133Every so often when I am driving on the highway, the car just looses power and I may catch a message that flashes on my display, "Emergency Braking". The event last no longer than about a second. When this phantom braking happens, so far, it has not been so severe to feel dangerous just unsettling! Look up ODI 11553133 at NHTSA ↗ | 5ODI 11524058The vehicle does not illuminate the brake lights when slowing down in ipedal and level 3 regen modes without actually pressing down the brake pedal. Look up ODI 11524058 at NHTSA ↗ ODI 11541676Vehicle suspension in the rear feels unsettled when coming to a stop using regenerative brakes. If you hit a small pothole or recessed manhole cover the rear of the vehicle feels like the rear suspension is jumping. I've taken it to the dealer and they noticed it and also it occurred on a new ioniq 5 they had on the lot also. Look up ODI 11541676 at NHTSA ↗ ODI 11591277When you place the car in park a recall was done so that the emergency parking brake automatically engages. Well between 30 seconds to a minute after the car is in park, the brake disengage. When you go to set it manually after it disengage, it will still disengage. Look up ODI 11591277 at NHTSA ↗ | 2ODI 11626861When driving in i-Pedal, which is a "one pedal driving option", sometimes after pausing the car rolls backs several inches. This appears to be a defect with the powetrain, regenerative braking engine, or otherwise. Hyundai's dealership has been advised of this issue; they have escalated this internally. A car in drive forward should never due to electrical or software reasons be told to move backwards -- which is what is happening here. Look up ODI 11626861 at NHTSA ↗ ODI 11735454On April 20th while parking the vehicle suddenly had a power surge crossing over multiple curbs and across a parking lot and landscaped areas and hitting a tree. The vehicle refused to brake and the driver airbag never deployed. Look up ODI 11735454 at NHTSA ↗ | 14ODI 11503875I was driving on the highway using advanced highway assist and the car became completely unresponsive. I was traveling 75mph on a major highway with a semi behind me and one to my right in the slow lane. The car stopped accelerating and I was unable to resume driving. I was forced to coast to a stop on the side of the highway. I had my daughter with me and were I not able to safely maneuver between the semi trucks, we could have been killed or seriosuly injured in a high speed crash. Look up ODI 11503875 at NHTSA ↗ ODI 11509793The ioniq 5 has a one pedal driving mode, where the car will come to a complete stop without needing to press the brake pedal, similar to other EV's. In this mode, the gas pedal operates differently then in a conventional car - pressing the pedal approximately 1/3 of the way down represents neutral, where the car coasts. Pressing the pedal less then that - between 1/3 and not pressing it at all, applies braking power to the car, either through regenerative braking or the application of the physical brakes. The issue is, the brake lights on t… Look up ODI 11509793 at NHTSA ↗ ODI 11553133Every so often when I am driving on the highway, the car just looses power and I may catch a message that flashes on my display, "Emergency Braking". The event last no longer than about a second. When this phantom braking happens, so far, it has not been so severe to feel dangerous just unsettling! Look up ODI 11553133 at NHTSA ↗ | — | 2ODI 11503875I was driving on the highway using advanced highway assist and the car became completely unresponsive. I was traveling 75mph on a major highway with a semi behind me and one to my right in the slow lane. The car stopped accelerating and I was unable to resume driving. I was forced to coast to a stop on the side of the highway. I had my daughter with me and were I not able to safely maneuver between the semi trucks, we could have been killed or seriosuly injured in a high speed crash. Look up ODI 11503875 at NHTSA ↗ ODI 11652207The Forward Attention Warning system in the refreshed 2025 Ioniq 5 gives constant false positives for both my wife and myself when we are driving the car. With Hyundai's HDA and lane keep active, the system keeps chiming, claiming that the driver is not looking at the road when we are. In fact, the calibration is so poor that it is a safety issue. The constant random warnings are very distracting, and sometimes the system does not recapture your eyes before timing out and hard braking the car on the highway. This is really unacceptable and … Look up ODI 11652207 at NHTSA ↗ |
|---|
| Forward Collision Avoidance: Adaptive Cruise Control | 4ODI 11652002Instrument panel on car will not turn on when car is started. Thus, all advanced cruise control and safety systems do not function. Car has not been to the dealership for repair yet. There were no warnings or any other indication that there was an impending problem. Look up ODI 11652002 at NHTSA ↗ ODI 11716969ICCU FAILED and Hyundai service states that part is back ordered indefinitely. Has been 2 weeks with no further updates Additionally service department is unable to repair forward monitoring sensors that quit working with the smallest amount of precipitation, sometimes just from road condensation. Look up ODI 11716969 at NHTSA ↗ ODI 11689922FORWARD ATTENTION WARNING When driving, the vehicle randomly and repeatedly warns the driver to pay attention to the road even when the driver is facing forward and paying attention to the road. The system will also randomly and repeatedly alarm, disable cruise control and apply the brakes even when the driver has both hands on the wheel and is facing forward. This has nearly caused crashes. Hyundai states the system is working as designed and suggested: 1. Driver is too tall for the system see my eyes. 2. Do not wear prescription glasses. … Look up ODI 11689922 at NHTSA ↗ | 1ODI 11528988Cruise control became disabled and then unable to accelerate when pressing down on accelerator Look up ODI 11528988 at NHTSA ↗ | 2ODI 11550946Driving on freeway when adaptive cruise control turns off and had a sudden complete loss of acceleration, we had steering and brakes only. Sudden reduction of car speed in traffic could cause accident. Has only happened once in 20k miles. (no acceleration) Adaptive cruise control shuts off for no reason, but dealer couldn't replicate. In recent 8k trip we photographed warning on dash 17 + times after shut down. Dealer couldn't find any saved trouble codes for this. No warnings prior to any occurrence only after, dash turned off on acceleration … Look up ODI 11550946 at NHTSA ↗ ODI 117244821 Vehicle fails to start x 6 , dealer unable to fix, falsely identified 2 documented DTCs P31C507 specifically indicates a "possible condition with your Vehicle Control Unit (VCU) / Low DC-DC Converter (LDC)" dealer stated as charger problem when this is often associated with thousands of ICCU problems in this vehicle 2 many ADAS cruise control faults. A vehicle slows and, once stopped, at freeway speed on corners or when a large vehicle is in a nearby, separate lane. Fails to detect the vehicle in the next lane when activating lane change. 3.… Look up ODI 11724482 at NHTSA ↗ | 1ODI 11700113Despite going back to the dealer to address the issue, and trying all the recommended modifications, the Forward Attention Warning (FAW) goes off repeatedly when the car is utilizing adaptive cruise control. I have written and called Hyundai National to ask to defeat this feature and it is not allowed. This FAW alarm (ironically) diverts my attention from driving as I am having to constantly respond to the alarm. I need the adaptive cruise control in certain situations and Hyundai will not allow me to override the FAW when the car is in adaptiv… Look up ODI 11700113 at NHTSA ↗ | 0 | 12ODI 11503875I was driving on the highway using advanced highway assist and the car became completely unresponsive. I was traveling 75mph on a major highway with a semi behind me and one to my right in the slow lane. The car stopped accelerating and I was unable to resume driving. I was forced to coast to a stop on the side of the highway. I had my daughter with me and were I not able to safely maneuver between the semi trucks, we could have been killed or seriosuly injured in a high speed crash. Look up ODI 11503875 at NHTSA ↗ ODI 11522378While driving on highway I got below messages “Safety Functions are limited radar block warning message” Warning message went away after 15 minutes but then “Stop Vehicle Check Power Supply” warning message appeared and vehicle slowed on highway and stopped after 2 miles. Dealer replaced ICCU and Fuse that controls high voltage (charges 12v battery from main battery). Look up ODI 11522378 at NHTSA ↗ ODI 11528266Hyundai's connected car service (bluelink) suffered an outage that resulted in driver profiles on many Hyundai vehicles being deleted/reset. No notice was provided and the profiles were not recovered. As a result, the vehicles did not funtion as expected. Driver assist settings were set to default (steering, braking, and acceleration functions included). Hyundai provided instructions on how to set up a new profile in response rather than restoring the customer data to their personally owned hardware (car). Look up ODI 11528266 at NHTSA ↗ | 2ODI 11503875I was driving on the highway using advanced highway assist and the car became completely unresponsive. I was traveling 75mph on a major highway with a semi behind me and one to my right in the slow lane. The car stopped accelerating and I was unable to resume driving. I was forced to coast to a stop on the side of the highway. I had my daughter with me and were I not able to safely maneuver between the semi trucks, we could have been killed or seriosuly injured in a high speed crash. Look up ODI 11503875 at NHTSA ↗ ODI 11652207The Forward Attention Warning system in the refreshed 2025 Ioniq 5 gives constant false positives for both my wife and myself when we are driving the car. With Hyundai's HDA and lane keep active, the system keeps chiming, claiming that the driver is not looking at the road when we are. In fact, the calibration is so poor that it is a safety issue. The constant random warnings are very distracting, and sometimes the system does not recapture your eyes before timing out and hard braking the car on the highway. This is really unacceptable and … Look up ODI 11652207 at NHTSA ↗ | — |
|---|