Itasca SUNCRUISER recalls by model year

Reported: 1993-12-28 (December 28, 1993) · Model years: 1988, 1989

FUEL TANKS LEAK AT THE SEAMS AND/OR BAFFLE CONNECTIONS.

Consequence: FUEL LEAKAGE CAN RESULT IN A FIRE WHEN EXPOSED TO ASOURCE OF IGNITION.

Remedy: WINNEBAGO WILL REPLACE FUEL TANKS THAT ARE FOUND TO BE LEAKING.

Reported: 1989-03-21 (March 21, 1989) · Model years: 1989

AN INCORRECT NUMBER OF BOLTS WAS USED TO FASTEN THE REAR AXLE TO THE FRAME RAILS.

Consequence: THIS COULD ALLOW THE SPRING HANGER TO BECOME DETACHEDFROM THE RAILS AND CAUSE THE REAR AXLE TO SEPARATE FROM THE MOTORHOME, CAUSINGLOSS OF CONTROL WHICH MAY RESULT IN AN ACCIDENT.

Remedy: INSTALL THE CORRECT NUMBER OF FASTENING BOLTS.

Reported: 1989-03-22 (March 22, 1989) · Model years: 1989

DUE TO CONTACT OF THE METAL SLIDE OF THE LOWER DRAWER IN THE BEDROOM CLOSET WITH A 110-VOLT WIRE FROM THE ELECTRICAL CONVERTER, INSULATION MAY BE STRIPPED FROM THE WIRE.

Consequence: A SHORT COULD DEVELOP AND RESULT IN A FIRE.

Remedy: REPAIR TO ELIMINATE CONTACT WITH WIRE FROM ELECTRICAL CONVERTER.

Reported: 1997-02-03 (February 3, 1997) · Model years: 1993, 1995, 1997

THE SPARE TIRE CARRIER HOIST COMPONENTS CAN BECOME LOOSE WHILE TRAVELING AND ALLOW THE SPARE TIRE TO MOVE FROM ITS STORED POSITION TO THE ROAD SURFACE.

Consequence: THE SPARE TIRE CAN CONTACT THE ROAD SURFACE INCREASING THE RISK OF A VEHICLE CRASH OR PROPERTY DAMAGE TO THE FOLLOWING VEHICLES.

Remedy: DEALERS WILL ADD A PRIMARY SPARE TIRE SUPPORT BRACKET.

Reported: 1996-02-21 (February 21, 1996) · Model years: 1995

THE AWNING ATTACHED FOR THE SLIDE-OUT ROOM CAN UNFURL OR UNROLL DURING TRANSIT CAUSING THE BRACKET TO RIP FREE OF THE SIDEWALL.

Consequence: THE AWNING COULD BREAK LOOSE WHILE THE VEHICLE IS IN MOTION RESULTING IN A VEHICLE ACCIDENT AND PERSONAL INJURY.

Remedy: CAREFREE OF COLORADO IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL INSTALL ARM LOCKS, ANTI-BILLOW STUDS AND BRACKETS AS WELL AS WIND DEFLECTORS ON THESE AWNINGS.

Reported: 2010-10-26 (October 26, 2010) · Model years: 1996, 1997, 1998, 1999, 2000, 2001, 2002, 2003, 2004, 2005, 2006, 2007, 2008, 2009, 2010, 2011

WINNEBAGO IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.

Consequence: THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.

Remedy: WINNEBAGO IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE RECALL BEGAN DURING DECEMBER 2010. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR WINNEBAGO AT 1-641-585-3535.

Reported: 1998-01-26 (January 26, 1998) · Model years: 1998

VEHICLE DESCRIPTION: MOTOR HOMES. A LIQUID PROPANE (LP) HOSE WAS INSTALLED IN THE RANGE BURNER BOX. THE ELEVATED TEMPERATURE THE HOSE IS EXPOSED TO INSIDE THIS BOX CAN PREMATURELY AGE THE HOSE CAUSING A POSSIBLE LP LEAK.

Consequence: LP GAS LEAKAGE COULD IGNITE AND RESULT IN BODILY INJURY AND/OR PROPERTY DAMAGE.

Remedy: DEALERS WILL RELOCATE THE FLEXIBLE HOSE OUTSIDE OF THE RANGE BOX.

Reported: 2008-06-13 (June 13, 2008) · Model years: 1999

WINNEBAGO IS RECALLING MY 1999-2002 ULTIMATE ADVANTAGE, ULTIMATE FREEDOM, MY 1999-2001 CHIEFTAIN, MY 2000-2001 BRAVE, MY 2001 JOURNEY MY 2000 MINNIE WINNIE, MY 2000-2002 ITASCA HORIZON, MY 1999 SUNCRUISER, MY 2001 SUNFLYER, AND MY 2000 SUNRISE MOTOR HOMES EQUIPPED WITH NORCOLD REFRIGERATORS. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK.

Consequence: EXTENDED OPERATION OF A LEAKING COOLING UNIT COULD LEAD TO A FIRE FROM GAS WHICH MIGHT ESCAPE.

Remedy: WINNEBAGO IS WORKING WITH NORCOLD TO REPAIR THESE REFRIGERATORS. NORCOLD WILL PROVIDE THERMAL SWITCH KITS TO OWNERS ALONG WITH THE NECESSARY FORMS AND INSTRUCTIONS. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE FOR THIS CAMPAIGN. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR WINNEBAGO AT 1-641-585-3535.

Reported: 2003-02-21 (February 21, 2003) · Model years: 2000, 2001, 2002, 2003

CERTAIN MOTOR HOME CHASSIS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105,"HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THE BRAKE SYSTEM WARNING INDICATOR MAY NOT FUNCTION AS REQUIRED BY THE STANDARD.

Consequence: IN SOME OF THE AFFECTED VEHICLES, THE BRAKE SYSTEM WARNING INDICATOR WILL NOT ILLUMINATE WHEN THE IGNITION IS IN THE START POSITION OR FOR A LOW BRAKE FLUID CONDITION, IF THE BODY BUILDER RELIED SOLELY UPON FORD'S IVM COMPLIANCE STATEMENT FOR THE SYSTEM WARNING INDICATOR.

Remedy: DEALERS WILL REPAIR THESE VEHICLES. OWNER NOTIFICATION BEGAN APRIL 25, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT WINNEBAGO AT 1-641-585-3535.

Reported: 2004-12-22 (December 22, 2004) · Model years: 2003, 2004, 2005

ON CERTAIN MOTOR HOMES BUILT ON A 20,700 GVWR OR GREATER WORKHORSE CHASSIS, THERE MAY NOT BE SUFFICIENT CLEARANCE IN THE AREA WHERE THE FUEL LINE CROSSES THE FRAME CROSS MEMBER.

Consequence: WITHOUT CLEARANCE, A CONDITION COULD DEVELOP WHERE THE CROSS MEMBER MAY WEAR INTO THE FUEL LINE AND A FUEL LEAK MAY DEVELOP. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL REPAIR THESE MOTOR HOMES BY PROVIDING CLEARANCE BETWEEN THE FUEL LINE AND FRAME CROSS MEMBER. THE FUEL LINE WILL BE INSPECTED AND, IF NECESSARY, REPLACED. THE RECALL BEGAN JANUARY 7, 2005. OWNERS SHOULD CONTACT WINNEBAGO AT 1-800-537-1885.

Reported: 2005-09-14 (September 14, 2005) · Model years: 2003, 2005

ON CERTAIN MOTOR HOMES, THE ROOF VENT FOR THE OPTIONAL 4-DOOR REFRIGERATOR WAS INCORRECTLY LOCATED.

Consequence: THIS CAN ALLOW EXCESSIVE HEAT BUILDUP WHICH HAS THE POTENTIAL TO IGNITE SURROUNDING MATERIALS, RESULTING IN PERSONAL INJURY AND/OI VEHICLE AND PROPERTY DAMAGE.

Remedy: DEALERS WILL RELOCATE THE ROOF VENT. THE RECALL BEGAN ON SEPTEMBER 9, 2005. OWNERS MAY CONTACT WINNEBAGO AT 1-641-585-6939.

Reported: 2009-07-29 (July 29, 2009) · Model years: 2003

WINNEBAGO IS RECALLING 1,547 MODEL YEAR 2001-2003 RECREATIONAL VEHICLES EQUIPPED WITH NORCOLD MODEL 1200LRIM REFRIGERATORS, MANUFACTURED FROM MARCH 1, 2001 TO DECEMBER 31, 2002, WITH SERIAL NUMBERS BETWEEN 1273701 AND 1536607, NON-CONSECUTIVELY. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK. IF A LEAK OCCURS AND THE REFRIGERATOR CONTINUES TO BE OPERATED AFTER SOLUTION CIRCULATION HAS CEASED THE HEAT SOURCE COULD GENERATE VERY HIGH TEMPERATURES. AT SUCH HIGH TEMPERATURES, THE COOLING UNIT COULD RUPTURE.

Consequence: IF A LEAK OCCURS AND THE UNIT IS CONTINUES TO OPERATE, HYDROGEN GAS MAY BE EXPELLED AND CAN BE IGNITED, RESULTING IN A FIRE, POSSIBLY CAUSING SERIOUS INJURY OR DEATH.

Remedy: WINNEBAGO IS WORKING WITH NORCOLD AND NORCOLD WILL NOTIFY OWNERS AND THE VEHICLE'S REFRIGERATOR WILL BE REPAIRED FREE OF CHARGE (PLEASE SEE 09E-027). OWNERS MAY CONTACT NORCOLD'S RECALL CENTER AT 1-800-767-9101.

Reported: 2004-12-18 (December 18, 2004) · Model years: 2004, 2005

CERTAIN SEAT BELT BUCKLES ON SOME MOTOR HOMES FAIL TO CONFORM TO THE LOAD REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."

Consequence: THE SEAT BELT BUCKLE MAY UNLATCH IN THE EVENT OF A VEHICLE CRASH, POSSIBLY RESULTING IN PERSONAL INJURY TO THE SEAT OCCUPANT.

Remedy: DEALERS WILL REPLACE THE BUCKLES. THE RECALL BEGAN ON NOVEMBER 12, 2004. OWNERS SHOULD CONTACT AMSAFE AT 1-574-266-8330 OR WINNEBAGO AT 1-800-537-1885.

Reported: 2005-03-02 (March 2, 2005) · Model years: 2005

CERTAIN MOTOR HOMES BUILT ON 24,000-LB GROSS VEHICLE WEIGHT RATING (GVWR)WORKHORSE CHASSIS WITH 235/80R22.5G XRV TIRES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, 'TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS.' THE MOTOR HOMES WERE INADVERTENTLY EQUIPPED WITH AN INCORRECT LOAD RANGE TIRE LABEL.

Consequence: FAILURE TO FOLLOW PROPER VEHICLE LOADING SPECIFICATIONS AND TIRE INFLATION RECOMMENDATIONS CAN RESULT IN TIRE DAMAGE AND VEHICLE INSTABILITY, WHICH COULD RESULT IN A CRASH.

Remedy: OWNERS WILL BE MAILED SUPPLEMENTARY TIRE LABELS CONTAINING THE CORRECT TIRE INFLATION INFORMATION. IF AN OWNER DESIRES, THEIR DEALER CAN INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON MARCH 24, 2005. OWNERS MAY CONTACT WINNEBAGO AT 641-585-6939.

Reported: 2009-04-08 (April 8, 2009) · Model years: 2005, 2006

WINNEBAGO IS RECALLING 2,331 MY 2002-2004 BRAVE AND ITASCA SUNRISE MY 2005 2006 WINNEBAGO VOYAGE, ADVENTURER, ITASCA SUNRISE AND SUNCRUISER MOTOR HOMES. THE PROPANE TANK MOUNTING BRACKET MAY HAVE AN INCOMPLETE OR IMPROPER WELD.

Consequence: SHOULD THE WELD FAIL, THE PROPANE TANK CAN TIP OR FALL, POSSIBLY RELEASING PROPANE WHICH HAS THE POTENTIAL TO IGNITEA FIRE, RESULTING IN PERSONAL INJURY AND/OR VEHICLE AND PROPERTY DAMAGE.

Remedy: DEALERS WILL INSPECT AND PROPERLY WELD THE BRACKET FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT WINNEBAGO AT 800-537-1885.

Reported: 2006-07-05 (July 5, 2006) · Model years: 2006, 2007

CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS MAY HAVE BEEN EQUIPPED WITH INCORRECT STEERING INTERMEDIATE SHAFTS. THE STEERING COULD BECOME LOOSE AT THE STEERING BOX DURING TIGHT STEERING MANEUVERS.

Consequence: THIS STEERING CONDITION COULD RESULT IN A LOSS OF STEERING CONTROL, INCREASING THE RISK OF A CRASH.

Remedy: WORKHORSE IS CONDUCTING THIS RECALL (PLEASE SEE 06V148000) AND WILL INSPECT AND, IF NECESSARY, REPLACE THE STEERING INTERMEDIATE SHAFT. OWNERS MAY CONTACT WORKHORSE AT 1-877-294-6883 OR WINNEBAGO AT 1-641-585-3535.

Reported: 2007-10-18 (October 18, 2007) · Model years: 2007, 2008

CERTAIN MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, 'LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.' THE REAR AND REAR-SIDE RED REFLECTORS ARE LOCATED ABOVE THE 60-INCH HEIGHT LIMIT.

Consequence: NON-STANDARD SIDE MARKER AND REFLECTOR LIGHTS COULD REDUCE VISIBILITY OF VEHICLES AND INCREASE THE POTENTIAL FOR A CRASH.

Remedy: DEALERS WILL ADD REFLEX REFLECTORS IN COMPLIANT LOCATIONS FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 5, 2007. OWNERS MAY CONTACT WINNEBAGO AT 641-585-3535.

Reported: 2007-08-20 (August 20, 2007) · Model years: 2008

ON CERTAIN MOTOR HOMES, THE PASSENGER SIDE WINDSHIELD WIPER MAY FAIL TO OPERATE PROPERLY.

Consequence: INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE IMPAIRED VISIBILITY WHICH HAS THE POTENTIAL TO RESULT IN PERSONAL INJURY AND/OR VEHICLE AND PROPERTY DAMAGE.

Remedy: DEALERS WILL INSTALL NEW WIPER LINKAGE FROM THE WIPER MOTOR TO THE PIVOT ASSEMBLIES. THE RECALL BEGAN ON AUGUST 31, 2007. OWNERS MAY CONTACT WINNEBAGO AT 1-641-585-3535.

Reported: 2010-10-05 (October 5, 2010) · Model years: 2009, 2010, 2011

WINNEBAGO IS RECALLING CERTAIN MODEL YEAR 2008 WINNEBAGO VOYAGE AND, ITASCA SUNRISE AND, MODEL YEAR 2009-2011 WINNEBAGO ADVENTURER AND, ITASCA SUNCRUISER MOTOR HOMES BECAUSE THE DINETTE AREA SEAT BELT RESTRAINTS ON THOSE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES." IN A COLLISION, THE GENERATED CRASH FORCES CAN CAUSE THE RESTRAINT'S ATTACHMENT TO TEAR AND ALLOW THE ANCHOR TO SEPARATE FROM THE BODY OF THE VEHICLE.

Consequence: IF THE RESTRAINT SEPARATES FROM THE VEHICLE DURING A CRASH, THE BELT WILL NOT PROPERLY RESTRAIN THE SEAT OCCUPANT, INCREASING THE RISK OF INJURY OR DEATH TO THE OCCUPANT.

Remedy: WINNEBAGO WILL NOTIFY OWNES AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 17, 2010. OWNERS MAY CONTACT WINNEBAGO AT 1-800-537-1885.

Reported: 2012-06-18 (June 18, 2012) · Model years: 2009

WINNEBAGO INDUSTRIES (WINNEBAGO) IS RECALLING CERTAIN MODEL YEAR 2009 THROUGH 2012 WINNEBAGO COMMERCIAL VEHICLE MODEL J38S, MODEL YEAR 2009 AND 2010 ADVENTURER MOTORHOMES MANUFACTURED FROM OCTOBER 30, 2008, THROUGH SEPTEMBER 9, 2011, AND ONE 2009 ITASCA SUNCRUISER MOTORHOME BUILT NOVEMBER 2009. THESE MOTORHOMES CHASSIS ARE EQUIPPED WITH BOSCH HYDRAULIC DISC BRAKES WHICH WHEN EXPOSED TO LONG PERIODS OF TIME OF NON-DRIVING MAY EXPERIENCE DIAMETRICAL BRAKE CALIPER PISTON GROWTH AND REDUCED PISTON TO BORE CLEARANCE POTENTIALLY LEADING TO BRAKE DRAG AND OVERHEATING RESULTING IN REDUCED BRAKE PERFORMANCE.

Consequence: REDUCED BRAKE PERFORMANCE INCREASES THE RISK OF A CRASH.

Remedy: FREIGHTLINER CUSTOM CHASSIS (FCCC) WILL NOTIFY OWNERS, AND DEALERS WILL REPAIR THE VEHICLES, FREE OF CHARGE. THE MANUFACTURER HAS NOT YET PROVIDED THE AGENCY WITH A REMEDY OR OWNER NOTIFICATION SCHEDULE FOR THIS CAMPAIGN. OWNERS MAY CONTACT WINNEBAGO AT 1-641-585-3535 OR DAIMLER TRUCKS AT 1-800-547-0712.

Reported: 2012-02-16 (February 16, 2012) · Model years: 2011, 2012, 2013

WINNEBAGO IS RECALLING CERTAIN MODEL YEAR 2011-2012 WINNEBAGO AND ITASCA MOTOR HOMES BUILT ON A FORD F-53 CHASSIS. THE ‘PRNDL’ CABLE MAY BREAK AT THE ATTACHMENT TO THE TRANSMISSION CONTROL SELECTOR ARM ASSEMBLY MOUNTED ON THE STEERING COLUMN. IF THE CABLE BREAKS, THE TRANSMISSION GEAR INDICATOR IN THE ‘PRNDL’ DISPLAY IN THE INSTRUMENT PANEL WILL REMAIN IN THE FIRST GEAR POSITION REGARDLESS OF THE GEAR SELECTED.

Consequence: AN INCORRECT GEAR INDICATION IN THE INSTRUMENT PANEL MAY PREVENT THE DRIVER FROM KNOWING IF THEY ARE IN PARK OR REVERSE, INCREASING THE RISK OF A CRASH.

Remedy: WINNEBAGO WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE TRANSMISSION SELECTOR ARM ASSEMBLY AND THE ‘PRNDL’ CABLE ASSEMBLY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 2, 2012. OWNERS MAY CONTACT WINNEBAGO INDUSTRIES OWNER RELATIONS AT 1-641-585-6939.

Reported: 2012-08-08 (August 8, 2012) · Model years: 2012

Winnebago is recalling certain model year 2012-2013 Winnebago and Itasca motor homes. A cutting machine may have scored the copper propane tubing resulting in unknown long-term reliability.

Consequence: If the copper tubing fails, propane can escape leading to a fire or explosion which can result in property damage, personal injury, or death.

Remedy: Winnebago will notify owners, and dealers will replace the copper tubing, free of charge. The recall began on September 6, 2012. Owners may contact Winnebago Industries Owner Relations at 1-641-585-6939.

Reported: 2013-04-24 (April 24, 2013) · Model years: 2012, 2013, 2014

Winnebago Industries is recalling certain model year 2012-2014 Minnie Winnie, Aspect, Sightseer, Adventurer, and Journey motorhomes; and model year 2012-2014 Itasca Spirit, Cambria, Sunova, Suncruiser, and Meridian motorhomes. The affected vehicles were manufactured January 10, 2012, through April 5, 2013 and may be missing a range enclosure.

Consequence: A missing range enclosure may allow the gas range flame to be extinguished due to air flow. In such a case, propane gas will continue to flow without a flame. If propane continues to flow, in the presence of an ignition source, it may suddenly combust resulting in a fire and/or personal injury.

Remedy: Winnebago notify owners and dealers will install a range enclosure, free of charge. The safety recall began on May 20, 2013. Owners may contact Winnebago at 1-641-585-3535. Winnebago's recall campaign number is 128.

Reported: 2012-09-14 (September 14, 2012) · Model years: 2013

Winnebago is recalling a model year 2013 Winnebago and 2013 Itasca motor home built on a Ford F-53 chassis. The steering gear bracket may have been secured with nuts that may damage the bolts due to an incompatibility between the installation torque and the nut finish.

Consequence: The bolts may fracture, leading to separation of the steering gear and thus a loss of vehicle control, increasing the risk of a crash.

Remedy: These vehicles have been repaired prior to being sold, therefore an owner notification notice will not be issued. Consumers may contact Winnebago Industries owner relations at 1-641-585-6939.

Reported: 2013-04-26 (April 26, 2013) · Model years: 2013, 2014

Winnebago Industries, Inc. (Winnebago) is recalling certain model year 2013-2014 Winnebago Access, Aspect, Sightseer, Vista, Adventurer, Forza and Itasca Impulse, Cambria, Sunova, Sunstar, Suncruiser motorhomes manufactured February 20, 2013, through April 25, 2013. If the awning installation sequence was not completely followed, the awning motor may unknowningly become damaged. A damaged motor may lead to an unfurling of the awning.

Consequence: If motor damage occurs, it is possible that the awning can unfurl unexpectedly, either while the motorhome is at rest or while in transit, increasing the risk of personal injury or a vehicle crash.

Remedy: Winnebago will notify owners and Dometic staff will replace the affected motors with a design that is not subject to an out-of-sequence installation error. The recall began on July 17, 2013. Owners may contact Winnebago at 1-800-537-1885 or Dometic at 1-888-447-0003 for more information. Owners are being instructed not to drive their vehicle until repairs can be performed.

Reported: 2017-12-07 (December 7, 2017) · Model years: 2013, 2014, 2015, 2016, 2017, 2018

Winnebago Industries, Inc. (Winnebago) is recalling certain 2013-2018 Winnebago Era, Travato, Minnie Winnie, Fuse, View, Trend, Aspect, Brave, Vista, Sightseer, Adventurer, Forza, Journey, Tour, Revel, Paseo, Chalet, Access, and Intent motorhomes and Commercial vehicles, and 2013-2018 Itasca Spirit, Navion, Cambria, Tribute, Sunstar, Sunova, Suncruiser, Solei, Meridian, Elipse, Horizon, Reyo, and Via motorhomes. These vehicles are equipped with Kidde Plastic-Handle or Push Button 'Pindicator' fire extinguishers that may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Consequence: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Remedy: Winnebago will notify owners, instructing them to contact Kidde for replacement or aftermarket fire extinguishers, free of charge. The recall began on January 19, 2018. Owners may contact Winnebago customer service at 1-641-585-3535, or Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information.

Reported: 2015-10-16 (October 16, 2015) · Model years: 2015, 2016

Winnebago Industries, Inc (Winnebago) is recalling certain model year 2015-2016 Winnebago Brave, Sightseer, Vista and Adventurer motorhomes and Itasca Tribute, Sunova, Sunstar, and Suncruiser motorhomes manufactured from July 13, 2015, through October 6, 2015. The affected vehicles, built on Ford chassis, can be shifted out of 'PARK' without applying the brakes, due to an incorrect shift cable bracket and an improper shift cable adjustment.

Consequence: If the vehicle can be shifted into reverse without the brakes being applied, the vehicle may unintentionally move, increasing the risk of a crash.

Remedy: Ford will notify owners, and Ford dealers will replace the transmission shift control bracket and adjust the transmission shift cable, free of charge. The recall began on November 12, 2015. Owners may contact Winnebago customer service at 1-641-585-3535 or Ford customer service at 1-866-436-7332.

Reported: 2015-11-16 (November 16, 2015) · Model years: 2015

Winnebago Industries, Inc. (Winnebago) is recalling certain model year 2015-2016 Winnebago Journey and Adventurer motorhomes, and 2015 Itasca Meridian and Suncruiser motorhomes manufactured March 20, 2014, through November 6, 2015, and equipped with Atwood on demand water heaters, models OD45, OD50, and OD50CW. The affected water heaters have a water and gas valve that may cause the water heater to overheat the water in the hot water supply tap.

Consequence: The overheating of the water may result in the release of steam, possibly causing the operator to scald themselves and increasing the risk of injury.

Remedy: Winnebago will notify owners. The remedy for this recall is still under development. The recall began on January 26, 2016. Owners may contact Winnebago customer service at 1-641-585-3535, or Atwood customer service at 1-574-264-2131.

Reported: 2015-12-22 (December 22, 2015) · Model years: 2015, 2016

Winnebago Industries, Inc. (Winnebago) is recalling certain model year 2015-2016 Winnebago Sightseer, Vista, and Adventurer motorhomes manufactured August 1, 2014 through August 31, 2015, and 2015-2016 Itasca Sunova, Sunstar, and Suncruiser motorhomes manufactured August 1, 2014, through August 31, 2015. The affected vehicles have electrically operated entry/exit steps that may extend down and out while the vehicle is moving.

Consequence: If the steps extend while the vehicle is being driven, the steps may strike a person or another vehicle, increasing the risk of injury or a crash.

Remedy: Winnebago will notify owners, and dealers will replace the step switch connections at no charge. The recall began on February 12, 2016. Owners may contact Winnebago customer service at 1-641-585-3535.

Reported: 2024-11-01 (November 1, 2024) · Model years: 2015, 2016, 2017, 2018

Winnebago Industries, Inc. (Winnebago) is recalling certain 2014-2018 Sightseer, Itasca Sunova, 2016-2025 Forza, Vista, and Itasca/Winnebago Sunstar, 2015-2025 Adventurer, 2015-2024 Commercial Vehicle, 2015-2028 Itasca Suncruiser, and 2016-2017 Itasca Solei recreational vehicles. The hood bracket adhesive may have been incorrectly applied which can allow the bracket to detach.

Consequence: A detached hood bracket may become a road hazard and increase the risk of a crash.

Remedy: Dealers will inspect and repair as necessary, free of charge. Owner notification letters began being mailed January 31, 2025. Owners may contact Winnebago at 1-800-537-1885. Winnebago's number for this recall is 192.

Reported: 2016-03-16 (March 16, 2016) · Model years: 2016

Winnebago Industries, Inc. (Winnebago) is recalling certain model year 2015 Winnebago Adventurer vehicles manufactured January 16, 2016, to March 8, 2016, and 2015-2016 Itasca Suncruiser vehicles manufactured January 6, 2016, to March 8, 2016. In the affected vehicles, the bolts that attach the hitch to the frame were not properly torqued.

Consequence: Improper torquing of the hitch bolts could cause the hitch to detach, increasing the risk of a crash.

Remedy: Winnebago will notify owners, and dealers will inspect and, where necessary, replace the hitch attachment bolts free of charge. The recall began on April 15, 2016. Owners may contact Winnebago customer service at 1-641-585-3535. Winnebago's number for this recall is 140.

Reported: 2024-10-01 (October 1, 2024) · Model years: 2016, 2017, 2018

Winnebago Industries, Inc. (Winnebago) is recalling certain 2013-2017 Tour, 2013-2018 Journey, 2014-2022 Forza, 2015-2016 Brave, 2015-2019 Grand Tour, 2015-2021 Vista, 2016-2018 Adventurer, Sightseer, 2016-2021 Commercial Vehicle, 2018-2021 Intent, Sunstar, 2018-2020 Horizon, Itasca 2013-2017 Ellipse, Meridian, 2014-2017 Solei, 2015-2016 Tribute, 2015-2018 Sunstar, 2016-2018 Suncruiser, and Sunova motorhomes. The turn signals may have a smaller than required luminous lens area. As such these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 108, "Lamps, Reflective Devices, and Associated Equipment."

Consequence: A small lens can make it difficult for other drivers to see the turn signal, increasing the risk of a crash.

Remedy: Dealers will replace the turn signals, free of charge. Owner notification letters were mailed April 17, 2026. Owners may contact Winnebago Customer Care at 1-800-537-1885. Winnebago's number for this recall is 189.