| Equipment | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 550.0%ODI 11428529The contact owns a 2018 Jayco Jay Flight. The contact received a notification for NHTSA Campaign Number: 21V425000 (Equipment) however, the part to do the recall repair was not yet available. The dealer had been notified about the recall and the contact was informed to bring the vehicle to the dealer; however, the contact was informed that parts were not yet available. The manufacturer had been notified of the recall. The contact stated that the manufacturer had exceeded a reasonable amount of time for the repair. The contact had not experience… Look up ODI 11428529 at NHTSA ↗ | 750.0%ODI 11415575TL* THE CONTACT OWNS A 2019 JAYCO JAY FLIGHT. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 21V184000 (EQUIPMENT) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT. Look up ODI 11415575 at NHTSA ↗ | 758.3%ODI 11425141The contact owns a 2020 Jayco Jay Flight travel trailer equipped with a Dometic cooking stove with part number: RV1731. The contact received notification of NHTSA Campaign Number: 21V184000 (Equipment). The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue but informed the contact that part was not yet available. The contact was informed that it would be another month for before parts became available. The manufacturer was made aware of the issue. The cont… Look up ODI 11425141 at NHTSA ↗ | 228.6%ODI 11490983The contact's wife owns a 2021 Jayco Jay Flight RV. The contact stated that he had experienced several failures with the trailer. The contact stated that upon delivery of the trailer, the refrigerator would freeze at bottom and defrost at the top. The contact also stated that the stove top would ignite nearly six inches high and could not be adjusted. The contact then received notification of NHTSA Campaign Number: 21V685000 (Equipment) which he linked to the failure. The contact was sent the part to repair the trailer himself; however, due to … Look up ODI 11490983 at NHTSA ↗ | 125.0%ODI 11513482The contact owns a 2022 Jayco Flight RV. The contact received notification of NHTSA Campaign Number: 22V773000 (Equipment) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect. Look up ODI 11513482 at NHTSA ↗ | 00.0%No examples available for this selection. |
|---|
| Electrical System | 00.0%No examples available for this selection. | 150.0%ODI 11142227 · 1,200 miBATTERY QUIT WORKING WHILE PARKED ON A HUNTING TRIP IN THE MOUNTAINS. BOUGHT A NEW BATTERY AND THAT DIDN'T WORK AT ALL. WING NUT ON WIRING FROM BATTERY TO THE CONVERTER MELTED WHICH CAUSED THE WHOLE SYSTEM TO FAIL. Look up ODI 11142227 at NHTSA ↗ | 266.7%ODI 10874852 · 500 miTHE WIRING UNDERNEATH THE TRAILER WAS INSTALLED WITHOUT ANY COVERING AND PLACED DIRECTLY ON TOP OF THE SHARP EDGES OF THE CROSS MEMBERS. AFTER THE FIRST USE THE WIRE INSULATION BECAME DAMAGED AND THE ELECTRICAL SYSTEM BEGAN SHORTING OUT. Look up ODI 10874852 at NHTSA ↗ | 120.0%ODI 11152498TL* THE CONTACT OWNS A 2017 JAYCO JAY FLIGHT TRAVEL TRAILER HAULED BY A 2006 FORD F-150. THE CONTACT STATED THAT THERE WAS AN UNKNOWN RECALL REGARDING THE LIGHTS IN THE CAMPER. THE DEALER (CAMPING WORLD OF BARTOW, 7400 FL-60, BARTOW, FL 33830, [phone removed]) CAME OUT TO REPAIR THE LIGHTS AND NOTICED THAT THERE WAS A SHORT IN THE WIRES. THE DEALER REPLACED ALL THE LIGHTS AND TOOK ALL THE OLD LIGHTS TO BE RETURNED TO THE LIGHT MANUFACTURER. THE CONTACT STATED THAT JAYCO WOULD NOT REPLACE THE WIRING BECAUSE NO ONE WOULD COME OUT AND VERIFY WITH … Look up ODI 11152498 at NHTSA ↗ | 330.0%ODI 11067032TL* THE CONTACT OWNS A 2018 JAYCO RV TRAVEL TRAILER. THE CONTACT RECEIVED A RECALL LETTER FROM JAYCO (# 9901349) FOR THE TRAILER WIRING HARNESS. THE CONTACT CALLED JAYCO CUSTOMER SERVICE AT [phone removed] AND WAS INFORMED THAT THE WIRING FOR THE TRAILER WAS ON BACKORDER ACROSS THE NATION, AND THE CONTACT WOULD JUST HAVE TO WAIT. THE CONTACT STATED THAT HE HAS BEEN WITHOUT THE TRAILER FOR TWO WEEKS DUE TO THE WIRING HARNESS RECALL. THE VIN WAS UNKNOWN. THERE WAS NO MILEAGE. Look up ODI 11067032 at NHTSA ↗ | 214.3%ODI 11339429 · 30 miTHERE HAVE BEEN SO MANY ISSUES WITH OUR CAMPER. WE BOUGHT IT BRAND NEW IN MAY OF 2019, IT STARTED HAVING PROBLEMS WHILE STATIONARY IN AUGUST OF 2019 WHEN WATER STARTED LEAKING THROUGH THE ROOF, DAMAGING THE LIGHT FIXTURES, SOAKING OUR RECLINER, AND THE CARPET/FLOOR NEXT TO THE RECLINER. WE TOOK IT TO OCEAN GROVE AND IT WAS THERE FOR 1 MONTH. THEN SHORTLY AFTER THAT THE SHOWER STARTED LEAKING THROUGH THE FLOOR, MULTIPLE TIMES. EVERY TIME THEY SENT SOMEONE OUT, IT WOULD BE FIXED FOR A FEW DAYS, THEN WE'D HAVE TO CALL THEM BACK TO FIX IT. THIS WEN… Look up ODI 11339429 at NHTSA ↗ | 18.3%ODI 11330437 · 260 miWE BOUGHT A NEW JAY FLIGHT SLX 267BHSW AS WE FELT THIS WAS A GOOD FIT FOR OUR FAMILY OF FIVE. WE TOOK DELIVERY FROM THE DEALER, RVS OF SACRAMENTO, MAY 18, 2020 AND TOOK THE TRAILER ON ITS MAIDEN VOYAGE JUNE 14TH 2020. WE CAMPED AT TRINITY LAKE CALIFORNIA AT TANNERY CAMPGROUND. THERE ARE NO HOOKUPS AT THIS CAMPGROUND SO WAS RUNNING GENERATOR DURING THE DAY AND BATTERY/ PROPANE AT NIGHT. EVERYTHING WAS GOING GREAT UNTIL THE FOURTH DAY WE WERE THERE. I WOKE UP AT 6 IN THE MORNING THURSDAY THE JUNE 18, 2020 TO A VERY LOUD POP AND A RUSHING SOUN… Look up ODI 11330437 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
|---|
| Unknown Or Other | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 428.6%ODI 11351868I BOUGHT A 2019 JAYCO JAYFLIGHT, TRAVEL TRAILER, MODEL 29BHDB. MY SLIDE OUT HAS A MANUFACTURING DEFECT THAT IS ALSO A SAFETY AND A LEGAL ISSUE AS WELL; BECAUSE THE HOLE TO INSERT A CRANK TO MANUALLY OPERATE THE SLIDE SHOULD IT FAIL IS BLOCKED BY THE TANK, SO IF THE SLIDE SHOULD FAIL THERE IS NO WAY TO MANUALLY RETRACT IT, WHICH MEANS THAT I WOULD HAVE TO DRIVE WITH MY SLIDE EXTENDED IF THAT SHOULD HAPPEN, THAT IS A SAFETY ISSUE AND A LEGAL ISSUE BECAUSE IT IS AN OFFENSE TO DRIVE WITH YOUR SLIDE EXTENDED, BUT I WOULD HAVE TO DRIVE TO A REPAIR… Look up ODI 11351868 at NHTSA ↗ | 18.3%ODI 11330437 · 260 miWE BOUGHT A NEW JAY FLIGHT SLX 267BHSW AS WE FELT THIS WAS A GOOD FIT FOR OUR FAMILY OF FIVE. WE TOOK DELIVERY FROM THE DEALER, RVS OF SACRAMENTO, MAY 18, 2020 AND TOOK THE TRAILER ON ITS MAIDEN VOYAGE JUNE 14TH 2020. WE CAMPED AT TRINITY LAKE CALIFORNIA AT TANNERY CAMPGROUND. THERE ARE NO HOOKUPS AT THIS CAMPGROUND SO WAS RUNNING GENERATOR DURING THE DAY AND BATTERY/ PROPANE AT NIGHT. EVERYTHING WAS GOING GREAT UNTIL THE FOURTH DAY WE WERE THERE. I WOKE UP AT 6 IN THE MORNING THURSDAY THE JUNE 18, 2020 TO A VERY LOUD POP AND A RUSHING SOUN… Look up ODI 11330437 at NHTSA ↗ | 228.6%ODI 11469334JAYCO. CONSUMER WRITES IN REGARD TO NHTSA SAFETY RECALL 21V-685. THE CONSUMER STATED THE VEHICLE WAS PERMANENTLY PARKED. THEREFORE, UNABLE TO HAVE THE VEHICLE REPAIRED FREE OF CHARGE. Look up ODI 11469334 at NHTSA ↗ | 125.0%ODI 11530529NHTSA Campaign Number: 22V571000 Vehicle was sold to me new with recall remedy NOT complete Look up ODI 11530529 at NHTSA ↗ | 120.0%ODI 11668748The entry door on my Jayco 264BH has become extremely difficult to open and close because the bottom of the door is rubbing against or making contact with the frame. This makes it nearly impossible for children to enter or exit the RV safely. In addition, closing the door from inside the RV is very difficult, which poses a significant safety risk, especially in emergency situations where quick exit may be necessary. This defect could prevent occupants, including children, from exiting the vehicle quickly and safely. Look up ODI 11668748 at NHTSA ↗ |
|---|
| Suspension | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 120.0%ODI 11256378 · 2,000 miTL* THE CONTACT OWNS A 2017 JAYCO JAY FLIGHT TRAVEL TRAILER. THE CONTACT STATED THAT THE AXLE HANGERS WERE MISALIGNED WHEN THE RV WAS MANUFACTURED. AS A RESULT, THE VEHICLE WOULD NOT MOVE IN A STRAIGHT PATH WHILE BEING HAULED. THE MANUFACTURER WAS CONTACTED AND REFERRED THE CONTACT TO LEBANON RV CENTER (443 TOTT ST, LEBANON, TN 37087, [phone removed]) TO HAVE THE RV REPAIRED. THE RV WAS REPAIRED; HOWEVER, APPROXIMATELY ONE YEAR LATER WHILE DRIVING 55-60 MPH, THE FRONT DRIVER'S SIDE WHEEL ON THE RV SEPARATED FROM THE AXLE. ADDITIONALLY, THE LUG … Look up ODI 11256378 at NHTSA ↗ | 00.0%No examples available for this selection. | 17.1%ODI 11572600Our RV experienced frame failure twice. It was repaired by the rv facility the first time as it was under warranty. 2nd time it was not. This is a widespread and ongoing issue on Lippert frames and needs to be on a recall. The danger of a 45ft 5th wheel frame breaking on a major freeway could be catastrophic. Look up ODI 11572600 at NHTSA ↗ | 18.3%ODI 11442459After a trip from Dallas to Los Angeles, I noticed inside tire wear on the rear tires. After close inspection, found both leaf spring support brackets had separated from the frame and rear axle was ~3" shifted to the left. If we had started to make the trip back home, the axles could've come off the trailer resulting in a terrible accident. Pictures were taken and sent to Good Sam for extended warranty and Jayco was supposed to have been informed to OK the repairs. Not sure if this was done. Look up ODI 11442459 at NHTSA ↗ | 342.9%ODI 11456061We have experienced an axle failure on our 2021 Jayco Travel Trailer. The trailer has never been over GVW. After a month of discussion with Lippert/Jayco they are unwilling to correct the following issue. Lippert's axle sticker (photo attached) states the Static Load Radius as measured is 11.9" & not to exceed this rating by more than 10%. The Baja Edition option as built by Jayco comes with 16" wheels & off road Goodyear tires. My Measurement of the SLR is 14.6" which exceeds the warning on the Lippert axle sticker. This is what I believe cont… Look up ODI 11456061 at NHTSA ↗ | 00.0%No examples available for this selection. | 120.0%ODI 11677927Bought the trailer brand new. One of the leaf springs completely snapped and broke while driving on a smooth road. Trailer was not overloaded. Leaf springs were replaced twice by warranty with the same parts and the springs were flat and W shaped each time. The are supposed to be U shaped. The part they are installing on the trailers are not sufficient and going to cause death or injury. Photo included is the 2nd replacement right after install. Empty of water and leaf springs were already failing! Look up ODI 11677927 at NHTSA ↗ |
|---|
| Structure:Body | 00.0%No examples available for this selection. | 150.0%ODI 11270434 · 1,500 miTL* THE CONTACT OWNS A 2015 JAYCO JAY FLIGHT 23RB. THE CONTACT STATED THAT THE BOLTS FELL OUT OF THE SUPPORT STEEL FRAME AND ALMOST CAUSED THE WATER TANK TO FALL OFF. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 1,500. Look up ODI 11270434 at NHTSA ↗ | 133.3%ODI 11547277Winntec LPG Regulator Modell 6020 PI.0-15.6 q6.R280 Mh26696 This regulator failed and caused our fridge to overheat and catch fire causing damage to the roof and fridge area.I feel someone should be responsible for the damage caused by this regulator.Thank you Look up ODI 11547277 at NHTSA ↗ | 120.0%ODI 11204842TL* THE CONTACT OWNS A 2017 JAYCO JAY FLIGHT. THE CONTACT STATED THAT THE TRAILER'S BLACK WATER TANK DETACHED WHILE DRIVING. THE CONTACT CALLED CAMPING WORLD OF HILLSBORO (LOCATED AT 6503 SE ALEXANDER ST, HILLSBORO, OR 97123, [phone removed]) AND LEFT A VOICE MESSAGE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. *DT *DT CARFAX CANNOT PROCESS THIS REQUEST. VEHICLE GETTING DIAGNOSED.*JB SAFETY RECALL REPORT ATTACHED. *JB Look up ODI 11204842 at NHTSA ↗ | 00.0%No examples available for this selection. | 17.1%ODI 11339429 · 30 miTHERE HAVE BEEN SO MANY ISSUES WITH OUR CAMPER. WE BOUGHT IT BRAND NEW IN MAY OF 2019, IT STARTED HAVING PROBLEMS WHILE STATIONARY IN AUGUST OF 2019 WHEN WATER STARTED LEAKING THROUGH THE ROOF, DAMAGING THE LIGHT FIXTURES, SOAKING OUR RECLINER, AND THE CARPET/FLOOR NEXT TO THE RECLINER. WE TOOK IT TO OCEAN GROVE AND IT WAS THERE FOR 1 MONTH. THEN SHORTLY AFTER THAT THE SHOWER STARTED LEAKING THROUGH THE FLOOR, MULTIPLE TIMES. EVERY TIME THEY SENT SOMEONE OUT, IT WOULD BE FIXED FOR A FEW DAYS, THEN WE'D HAVE TO CALL THEM BACK TO FIX IT. THIS WEN… Look up ODI 11339429 at NHTSA ↗ | 18.3%ODI 11362912 · 3,500 miTL* THE CONTACT OWNS A 2020 DODGE RAM 3500 HAULING A 2020 JAYCO 5TH WHEEL TRAILER. THE CONTACT STATED THAT WHILE DRIVING AT 65 MPH, THE HITCH TO THE CARGO CARRIER FRACTURED WITHOUT WARNING. THE CONTACT NOTICED WITHIN TWO MILES THAT THE GENERATOR, TRAILER AND THE CARGO CARRIER WERE NOT SECURELY ATTACHED TO THE VEHICLE. A DEALER WAS NOT CONTACTED. THE TRAILER WAS NOT FOUND. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE HOWEVER, NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE ON THE VEHICLE WAS APPROXIMATELY 22,000, 3,500 ON THE 5TH WHEEL… Look up ODI 11362912 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
|---|
| Equipment:Recreational Vehicle/Trailer | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 17.1%ODI 11451912The contact owns a 2019 Jayco Jay Flight. The contact received notification of NHTSA Campaign Number: 12v425000 (Equipment). The contact stated that the dealer had exceeded a reasonable amount of time for the recall repair to become available. The manufacturer was made aware of the issue. The contact stated that the part was not available. The contact had not experienced a failure. Parts Distribution Disconnect. Look up ODI 11451912 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 240.0%ODI 11526482174BH-rear emergency latch is not secure when opened it can easily become ajar and may strike child in the eye causing damage. Small bumps in to the handle cause the window to shut and the handle to move back into the sleeping quarters. Further in the event a child needed to escape the window one must hold the window up. A child would not be able to hold the window up causing a safety issue. Latch catch should be larger. 14JUN2023 [edit]: (From 11526481) Trailer contains multiple Appliances that use LP in small quarters including sleeping how… Look up ODI 11526482 at NHTSA ↗ |
|---|
| Exterior Lighting | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 133.3%ODI 10874852 · 500 miTHE WIRING UNDERNEATH THE TRAILER WAS INSTALLED WITHOUT ANY COVERING AND PLACED DIRECTLY ON TOP OF THE SHARP EDGES OF THE CROSS MEMBERS. AFTER THE FIRST USE THE WIRE INSULATION BECAME DAMAGED AND THE ELECTRICAL SYSTEM BEGAN SHORTING OUT. Look up ODI 10874852 at NHTSA ↗ | 240.0%ODI 11099974TL* THE CONTACT OWNS A 2017 JAYCO JAY FLIGHT. WHILE ATTEMPTING TO OPERATE THE CEILING LIGHTS, AN ABNORMAL PLASTIC BURNING ODOR WAS DETECTED INSIDE THE CAMPER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V290000 (INTERIOR LIGHTING); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER (ALBANY RV, 48 RENSSELAER AVE, LATHAM, NY 12110, [phone removed]) WAS CONTACTED AND CONFIRMED THAT THE PART WAS NOT AVAILABLE FOR THE RE… Look up ODI 11099974 at NHTSA ↗ | 110.0%ODI 11462732The contact owns a 2018 Jayco Flight SLX trailered to a 2005 Chevrolet Tahoe. The contact stated while driving approximately 60 MPH, it was discovered the exterior lights were not functioning as designed. The trailer was diagnosed by a local mechanic that the wiring from the junction box of the front trailer was cut by a diamond plate, which caused the lights to be inoperable. The vehicle was repaired. The manufacturer was not notified of the failure. A failure mileage was not available. Invalid VIN Wires going from junction box up front of tra… Look up ODI 11462732 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
|---|
| Wheels | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 120.0%ODI 11256378 · 2,000 miTL* THE CONTACT OWNS A 2017 JAYCO JAY FLIGHT TRAVEL TRAILER. THE CONTACT STATED THAT THE AXLE HANGERS WERE MISALIGNED WHEN THE RV WAS MANUFACTURED. AS A RESULT, THE VEHICLE WOULD NOT MOVE IN A STRAIGHT PATH WHILE BEING HAULED. THE MANUFACTURER WAS CONTACTED AND REFERRED THE CONTACT TO LEBANON RV CENTER (443 TOTT ST, LEBANON, TN 37087, [phone removed]) TO HAVE THE RV REPAIRED. THE RV WAS REPAIRED; HOWEVER, APPROXIMATELY ONE YEAR LATER WHILE DRIVING 55-60 MPH, THE FRONT DRIVER'S SIDE WHEEL ON THE RV SEPARATED FROM THE AXLE. ADDITIONALLY, THE LUG … Look up ODI 11256378 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 114.3%ODI 11530005We recently purchased this camper and in preparation I crawled under it and looked around and what I saw made me cringe. The welding on the frame was the worst welding I've seen in years on a product for sale the main beams that tie the camper front to back were only welded on one side of the beam and there are four sides that could be welded. And upon further inspection found the weld on the main beam in the rear has already started to crack side.mounts for the camper body are only welded half the length of the bracket to the frame. The only … Look up ODI 11530005 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
|---|