| Electrical System | 529.4%ODI 11415003 · 10,100 miSINCE THE BEGINNING OF APRIL 2021, AND JUST AFTER THE ODOMETER TURNED OVER TO 10K MILES, MY E-NIRO HAS BEEN EXPERIENCING A BIZARRE BEHAVIOR THAT POSES A POTENTIALLY SERIOUS SAFETY RISK. THIS TAKES THE FORM OF TOTAL LOSS OF ACCELERATION POWER FOR A FEW SECONDS, USUALLY AFTER DEACCELERATING TO A NEAR STOP (USUALLY, BUT NOT ALWAYS, WHEN USING THE PADDLE ON THE LEFT SIDE OF THE STEERING WHEEL TO REGENERATIVELY BRAKE) THEN PRESSING THE ACCELERATOR PEDAL, OR WHEN MAKING A VERY TIGHT TURN (E.G., INTO A PARKING SPACE). POWER RETURNS A FEW SECONDS AFTER… Look up ODI 11415003 at NHTSA ↗ | 631.6%ODI 11501010 · 17,972 miThe contact owns a 2020 Kia Niro. The contact stated that after charging the battery to 80 percent, the vehicle immediately turned off while reversing out of the charging station. After restarting the vehicle and driving, the failure reoccurred. The vehicle was towed to the dealer who cleared the failure codes and tested drove the vehicle, but no failure was identified. The vehicle was not repaired. The manufacturer was not yet notified of the failure. The failure mileage was 17,972. Look up ODI 11501010 at NHTSA ↗ | 00.0%No examples available for this selection. | 1240.0%ODI 11514336The vehicle has failed to start on 3 occasions and needed to be jumped. When towed to the dealership they’ve been unable to find any issues. Look up ODI 11514336 at NHTSA ↗ | 853.3%ODI 11540438The car continues to not be able to charge at home. My other electric car (different manufacturer polestar) with the same cord charges without issues. The cord only allows 27amps and the car abruptly stops charging over and over. I have to reset it constantly. This continues to be an issue and the car shows no problems with the battery and there is no fix from Kia. Look up ODI 11540438 at NHTSA ↗ | 350.0%ODI 11567398I picked up this car on 12/30/2023. On 1/10/2024, I noticed that the power folding side mirrors were folding slower than normal. On 1/13/2024, I went into the Kia Access app and was greeted by an error message stating that remote commands could not be sent as the battery was under 40%, however the app showed the battery at 80%. On 1/14/2024, I discovered the app was referencing the 12-volt battery, as the car's power mirrors and locks did not function. I needed the car to get to a relative's house to figure out a furnace issue, so the timing co… Look up ODI 11567398 at NHTSA ↗ | 00.0%No examples available for this selection. |
|---|
| Unknown Or Other | 15.9%ODI 11475984During driving or while parked, the vehicle will shut off power brakes, and display an error "Stop Vehicle and Check Regenrative Brakes". When the power brakes shut off, the brake pedal location and feedback change sharply and the responsiveness is severely impaired. This error can occur at any time, which is very dangerous especially at highway speeds or when coming to a stop. I have let an authorized Kia dealership inspect the car for 31 days and did not see the issue. I took the vehicle back, and it happens frequently, so I drove it in wi… Look up ODI 11475984 at NHTSA ↗ | 842.1%ODI 11383350 · 89 miVOLUME ON VESS AND BACKUP ALERT SYSTEM GREATLY EXCEEDS RECOMMENDED LEVELS, TO THE POINT WHERE BACKING UP OUT OF GARAGE CAN ANNOY NEIGHBORS IN THEIR HOMES. WHEN BACKING OUT OF A PARKING SPOT AT A LOCAL STRIP MALL, THE VOLUME OF THE BACKUP ALERT FROM THE VESS WAS SO SHOCKING THAT IT STARTLED A PEDESTRIAN, CAUSING THEM TO TRIP AND ALMOST FALL ON THEIR FACE. KIA DOES NOT PROVIDE A WAY TO REDUCE VESS VOLUME TO CLOSER TO NHTSA RECOMMENDED LEVELS. ALSO, VESS STAYS ENGAGED UP TO AROUND 23 MPH, MAKING IT AN ANNOYANCE TO PEOPLE WE SHARE THE ROAD WITH… Look up ODI 11383350 at NHTSA ↗ | 00.0%No examples available for this selection. | 1343.3%ODI 11434645This complaint is about a vehicle design and implementation issue rather than a malfunction. The implementation of the low speed warning alert for this vehicle is dangerous to pedestrians. Several times, as I was backing out of a parking spot pedestrians have stopped directly behind the moving vehicle and could have been hit. When put into reverse this vehicle emits beeping tone from a speaker mounted in the FRONT bumper of the vehicle. Because the backup alert tone is emitted from the front bumper of the vehicle, the sound is reflected off o… Look up ODI 11434645 at NHTSA ↗ | 426.7%ODI 11536013Charge Interruptions session. The Kia Niro EV interrupt charging on a Level 2 50amp ChargePoint Home Flex charge. I contact the Charger company ChargePoint and reduce the power to 40 amps. The car charging improve slightly but continue interruption. The on board CSS J1772 port of the car overheat and stop charging. Same issue that the Ioniq 5, Ioniq 6, Kia EV6, and Genesis EV. Look up ODI 11536013 at NHTSA ↗ | 350.0%ODI 11596449Emergency stop blocked by a piece of the bottom dash panel under the steering column. There are castings in the underside of the panel covering the steering column that prevent the right foot of a driver with a larger foot/shoe to operate the brake pedal. I have a size 11 shoe and my foot catches on this plastic casting and interferes with the brake operation. Last night a car pulled out of a parking spot in front of me and the protuberance block my foot from applying the brakes. This has happened multiple times and I am forced to drive wit… Look up ODI 11596449 at NHTSA ↗ | 00.0%No examples available for this selection. |
|---|
| Power Train | 847.1%ODI 11326198 · 200 miTL* THE CONTACT LEASED A 2019 KIA NIRO. THE CONTACT STATED THAT WHILE DRIVING AT 30 MPH WITH THE ACCELERATOR PEDAL DEPRESSED, THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE WAS EXPERIENCED TWICE. THE VEHICLE WAS TAKEN TO KAEARNY MESA FORD KIA DEALER (7303 CLAIREMONT MESA BOULEVARD, SAN DIEGO, CA 92111, (858)560-6965, AND THE VEHICLE WAS TEST DRIVEN HOWEVER, THE MECHANIC WAS UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 200. Look up ODI 11326198 at NHTSA ↗ | 315.8%ODI 11557339-Abnormal Reduction Gear and/or EV motor Rumble noise as identified in KIA TSB-234. The car is available for inspection. -Car not working properly/increasing the risk of stall or breakdown while driving and therefore increasing the risk of collision/accident. There is a loss of power and increased revolution noise from the reduction gear/EV motor increasing the incidence of vehicle failure during operation and accident, therefore increasing the incidence of property and bodily injury/damage due to known issues by KIA currently being service… Look up ODI 11557339 at NHTSA ↗ | 00.0%No examples available for this selection. | 620.0%ODI 11450489When the KIA is shifted into "park", it will sometimes roll forward or backwards until the brakes are applied by the driver. This doesn't happen all the time and we have not figured out a way to predictably reproduce the results, but it happens a lot. My wife is the primary driver and I have only driven the car about 10 times. It has happened to just me twice in that time frame. It's such a common problem that we have started trying to routinely activate the emergency brake, as the transmission is not reliable in shifting the vehicle into … Look up ODI 11450489 at NHTSA ↗ | 213.3%ODI 11719665The vehicle is a rental vehicle. It experienced two incidents of sudden loss of propulsion within the first two days of operation. During both events, the vehicle became completely unresponsive to accelerator pedal input and would not move despite being placed in Drive. I attempted to shift the vehicle into Park and then back into Drive, but propulsion was not restored. No warning lights, malfunction indicators, or system messages were displayed before or during the failure. The first incident occurred while exiting a car wash. The vehicle be… Look up ODI 11719665 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
|---|
| Service Brakes | 317.6%ODI 11300024 · 6,000 miMY BRAKES FAILED AS I TRIED TO STOP FOR A TRAFFIC LIGHT ON A CITY STREET. THERE WAS A CAR ALREADY STOPPED AT THE LIGHT, WHICH I BUMPED INTO. AS I WAS DEPRESSING THE BRAKE PEDAL, IT 'GAVE', AND THE CAR CONTINUED TO MOVE FORWARD; I WAS UNABLE TO STOP. LUCKILY, I HAD ALREADY SLOWED CONSIDERABLY PRIOR TO THE BRAKES FAILING, SO NO ONE WAS HURT AND THERE WAS MINIMAL DAMAGE. THE OTHER DRIVER LEFT THE SCENE WITHOUT EXCHANGING INFORMATION, AND NO POLICE REPORT WAS FILED. THE KIA SERVICE TECHNICIAN WAS UNABLE TO FIND ANYTHING WRONG WITH THE VEHICLE: NO… Look up ODI 11300024 at NHTSA ↗ | 15.3%ODI 11628061vehicle started jerking suddenly and uncontrollably. It jerked to the side almost gliding into another vehicle there is a smell also coming from the car and wheels have extensive loss of threading due to abrupt change of speed and direction. Controlling the vehicle does this more regularly but this time I almost hit a vehicle to the side of me and I could not get cargo straight for a second it was a quick incident but it's pretty much made me want to check into this recall because it was very scary. And I don't know if it'll get worse because i… Look up ODI 11628061 at NHTSA ↗ | 150.0%ODI 11663437The rear brake rotors on the vehicle are pitted, as confirmed by a local repair shop. The "incident" is ongoing. Kia refuses to repair or replace them under warranty (25,500 miles on the car), claiming they are wear item. However, pitting is not wear, in fact quite the opposite. My analysis (30+ yrs in the auto business): As an EV, regenerative braking means the actual brake systems are rarely used. Noise at low speeds prompted the inspection at a local shop. Braking under high speeds does not result in noise, telling me the system relies to… Look up ODI 11663437 at NHTSA ↗ | 13.3%ODI 11639695I bought my 2022 Kia Niro EV new in 2022, and around 40,000 miles, I had a problem with the reduction motor so I replaced it, shortly after that I had a problem with the wheel so I replaced a part called the axle, and shortly after that, the other wheel had the same problem so I replaced the same part, and the Kia employee said that this part only breaks if there is a strong impact (traffic accident) so it's strange. All of this happened in less than 2 years but I had it covered under warranty so I got it fixed, but now the reduction motor prob… Look up ODI 11639695 at NHTSA ↗ | 320.0%ODI 11557277I had front collision that caused by having difficulty switching my foot from acceleration pedal (gas pedal) to brake pedal, my foot movement from gas pedal to brake pedal has been restricted by friction between my shoe and brake pedal that delayed my foot movement and caused the accident, Automatic emergency brake did not function too. Also air bags did not open at this front collision. Look up ODI 11557277 at NHTSA ↗ | 116.7%ODI 11596449Emergency stop blocked by a piece of the bottom dash panel under the steering column. There are castings in the underside of the panel covering the steering column that prevent the right foot of a driver with a larger foot/shoe to operate the brake pedal. I have a size 11 shoe and my foot catches on this plastic casting and interferes with the brake operation. Last night a car pulled out of a parking spot in front of me and the protuberance block my foot from applying the brakes. This has happened multiple times and I am forced to drive wit… Look up ODI 11596449 at NHTSA ↗ | 00.0%No examples available for this selection. |
|---|
| Fuel/Propulsion System | 00.0%No examples available for this selection. | 315.8%ODI 11557339-Abnormal Reduction Gear and/or EV motor Rumble noise as identified in KIA TSB-234. The car is available for inspection. -Car not working properly/increasing the risk of stall or breakdown while driving and therefore increasing the risk of collision/accident. There is a loss of power and increased revolution noise from the reduction gear/EV motor increasing the incidence of vehicle failure during operation and accident, therefore increasing the incidence of property and bodily injury/damage due to known issues by KIA currently being service… Look up ODI 11557339 at NHTSA ↗ | 00.0%No examples available for this selection. | 26.7%ODI 115666192022 NIRO EV PHANTOM BREAKING WARRENTY DENIED WITH NO DAMAGE VISABLE What component or system failed or malfunctioned, and is it available for inspection upon request? ACC SYSTEMS UNKNOWN KIA CLAIMS MY FRONT RADAR BRACKET IS OFF 1.9 DEGREES. THEY STATE THEIR NO NO PHYSICAL DAMAGE The text stating there was no damage, but Kia wants the bracket replaced, that’s reasonable but why they want you to pay for it I don’t yet understand. I will be looking into this as that’s a key point. Were there any warning lamps, messages or other symptoms of … Look up ODI 11566619 at NHTSA ↗ | 320.0%ODI 11613910While driving on freeway, at a speed of 65-70MPH. Vehicle appeared to lose power. Navigation screen turned off, dash display dimmed and vehicle seemed to coast and not accelerate. Speed did drop down a bit, but then powered came back on, screen turned on and was able to accelerate again. No warning lights or error messages appeared on screen. Look up ODI 11613910 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
|---|
| Vehicle Speed Control | 211.8%ODI 11300024 · 6,000 miMY BRAKES FAILED AS I TRIED TO STOP FOR A TRAFFIC LIGHT ON A CITY STREET. THERE WAS A CAR ALREADY STOPPED AT THE LIGHT, WHICH I BUMPED INTO. AS I WAS DEPRESSING THE BRAKE PEDAL, IT 'GAVE', AND THE CAR CONTINUED TO MOVE FORWARD; I WAS UNABLE TO STOP. LUCKILY, I HAD ALREADY SLOWED CONSIDERABLY PRIOR TO THE BRAKES FAILING, SO NO ONE WAS HURT AND THERE WAS MINIMAL DAMAGE. THE OTHER DRIVER LEFT THE SCENE WITHOUT EXCHANGING INFORMATION, AND NO POLICE REPORT WAS FILED. THE KIA SERVICE TECHNICIAN WAS UNABLE TO FIND ANYTHING WRONG WITH THE VEHICLE: NO… Look up ODI 11300024 at NHTSA ↗ | 15.3%ODI 11557339-Abnormal Reduction Gear and/or EV motor Rumble noise as identified in KIA TSB-234. The car is available for inspection. -Car not working properly/increasing the risk of stall or breakdown while driving and therefore increasing the risk of collision/accident. There is a loss of power and increased revolution noise from the reduction gear/EV motor increasing the incidence of vehicle failure during operation and accident, therefore increasing the incidence of property and bodily injury/damage due to known issues by KIA currently being service… Look up ODI 11557339 at NHTSA ↗ | 00.0%No examples available for this selection. | 26.7%ODI 11559245Started 2-3 months ago and is progressively getting worse. Battery drop from charged down to 2% randomly. Battery would drop 1% every 3 seconds. During highway drive it would cancel out cruise control and/or limited power down to 30mph. Which almost caused accident for the sudden loss of power. Brought to dealer and found no issues, waiting for next appointment in 2 weeks (next opening) to bring in for second look. Currently renting a vehicle since it is life threatening to just have no power in range and acceleration. Look up ODI 11559245 at NHTSA ↗ | 213.3%ODI 11583492I pulled the vehicle out of my garage yesterday and drove it out and turned it around and put it in reverse to park it on a very slight incline on my driveway close to the garage to clean it, put it in park, and shut if off. I spent a couple hours vacuuming and cleaning it. I then went to turn it on to back it into my garage for the night and it lurched backwards in an alarming scary way - I rolled my passenger window down and asked my husband who was right there if there was something in the way that I had just tried to run over with my car.… Look up ODI 11583492 at NHTSA ↗ | 00.0%No examples available for this selection. | 1100.0%ODI 11757547I was slowly driving in the parking lot of the Meadowmeer Golf course on [XXX] today, Monday XXX at about 11:30AM. As I began the turn to pull into a parking space, at about 5 miles an hour, the car rapidly and unexpectedly accelerated. I immediately slammed on the brakes, leaving skid marks on the payment. Before the car stopped it drove into a curb around a flower garden. The i-pedal was not engaged. Myself and the passengers were frightened but not injured. No one has inspected the car as yet. There were no messages. I am trying to reach th… Look up ODI 11757547 at NHTSA ↗ |
|---|
| Engine | 211.8%ODI 11326198 · 200 miTL* THE CONTACT LEASED A 2019 KIA NIRO. THE CONTACT STATED THAT WHILE DRIVING AT 30 MPH WITH THE ACCELERATOR PEDAL DEPRESSED, THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE WAS EXPERIENCED TWICE. THE VEHICLE WAS TAKEN TO KAEARNY MESA FORD KIA DEALER (7303 CLAIREMONT MESA BOULEVARD, SAN DIEGO, CA 92111, (858)560-6965, AND THE VEHICLE WAS TEST DRIVEN HOWEVER, THE MECHANIC WAS UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 200. Look up ODI 11326198 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 413.3%ODI 11514336The vehicle has failed to start on 3 occasions and needed to be jumped. When towed to the dealership they’ve been unable to find any issues. Look up ODI 11514336 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
|---|
| Forward Collision Avoidance: Adaptive Cruise Control | 00.0%No examples available for this selection. | 15.3%ODI 11439629The Adaptive Cruise Control System is not working. It is available for inspection upon request. The cruise control system does not reset, but rather retains the last set point. When I start the car and touch the accelerator, the car assumes the last set speed setting. In my case that is 60mph. It does not matter what I do, the car accelerates to 60mph. I can "cancel" the setting", tap on the brakes, or try to reset the system to a different speed. I am trying to get an appointment with the dealer for his evaluation. There have been no accident… Look up ODI 11439629 at NHTSA ↗ | 00.0%No examples available for this selection. | 26.7%ODI 11482958When driving with ACC engaged in traffic at a speed below the target speed the vehicle will sometimes speed up. This seems to happen when the ACC radar loses the return from the vehicle ahead -- for example when when a ahead vehicle changes lanes in stop-and-go traffic, I think this may happen if the side of the vehicle merging into the lane is relatively "clean" and most of the radar energy is reflected away. When this happens the car will start accelerating to the target speed, in rush hour traffic the spacing between vehicles can be quite t… Look up ODI 11482958 at NHTSA ↗ | 16.7%ODI 11507006There have been days where the weather starts out to be low to no rain or snow and then while driving from Kenosha, WI to Milwaukee, WI the rain or snow gets heavier or mild and the smart cruise control will stop and say radar blocked and it will disable the use of it and disable regenitive braking as well. So if you are driving doing 70+ the speed limit on the interstate all of a sudden it will terminate without any warning and now all of a sudden the car behind you is in your truck space so you have to excellerate extremely to avoid getting h… Look up ODI 11507006 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
|---|