| Steering | — | 7ODI 11557553These are two major problem i want to highlight, which need immediate attention One of them is related to steering wheel, which is a major safety concern for this vehicle to be on road. 1) Major safety concern- steering wheel Steering wheel is catchy when you are driving vehicle on high speed, which make this vehicle so difficult to control/ maneuver and struggling to keep this in a lane Steering wheel catchy means- it becomes hard when you steer and then skid before finally engaged. This makes driver nervous and can lead to an accident due… Look up ODI 11557553 at NHTSA ↗ ODI 11571146The major issue that happened to our newly purchased CX 90 last February 3 with more than 500 miles on it started around 5:30 pm of February 8, while my wife is driving this vehicle with my daughter, all of a sudden the car stopped at the middle of the road with warning signs popping up in the dash screen like I-active sense malfunction, hybrid battery malfunction, engine malfunction light on, and on top of these, critical vehicle malfunction. The car won't start and disabled. Also, the vehicle cannot switch to neutral gear to push/pull the v… Look up ODI 11571146 at NHTSA ↗ ODI 11629131While driving (less than 2000 miles on the OD) in our 2024 cx90 SE the vehicle started to shift out of timing and everything shut off at once. The vehicle lost all power and all parts shut down. The vehicle would start back up and power steering went out. Our driving speed was at 30mph so it was extremely scary during rush hour traffic. We had to have it towed to the dealership, we're not sure what the issue will be. Look up ODI 11629131 at NHTSA ↗ | 7ODI 11616728Mazda's Driver Personalization System is highly defective and properly recognizes a driver, at best, 40% of the time. Since multiple functions are tied to this system such as seat position, steering wheel position, infotainment presets, and a variety of other vehicle preferences, this not only causes an inconvenience issue but also a safety issue. The safety problem is that one has to stop the car, put it into Park, press through multiple menus and keystrokes just to change the setting to the correct driver. Look up ODI 11616728 at NHTSA ↗ ODI 11705995Steering wheel gets stuck when turning left on speed 35-50 or over Look up ODI 11705995 at NHTSA ↗ ODI 11718158To Whom It May Concern, I am submitting this complaint to report serious and ongoing safety concerns regarding my Mazda CX-90. I believe this vehicle presents a significant safety risk to occupants and other drivers on the road. Since the date of purchase, this vehicle has been subject to numerous recalls, repeated software updates, and multiple mechanical issues. The number of recalls alone raises concern about the safety and reliability of this model. In addition, the vehicle has been in service many times, and I have frequently been provid… Look up ODI 11718158 at NHTSA ↗ | 6ODI 11571146The major issue that happened to our newly purchased CX 90 last February 3 with more than 500 miles on it started around 5:30 pm of February 8, while my wife is driving this vehicle with my daughter, all of a sudden the car stopped at the middle of the road with warning signs popping up in the dash screen like I-active sense malfunction, hybrid battery malfunction, engine malfunction light on, and on top of these, critical vehicle malfunction. The car won't start and disabled. Also, the vehicle cannot switch to neutral gear to push/pull the v… Look up ODI 11571146 at NHTSA ↗ ODI 11684144"The steering wheel intermittently sticks and feels resistant when switching lanes or making turns, especially at highway speeds. It does not return smoothly to center, making it feel unsafe and unpredictable. I brought the vehicle to the Mazda dealership, but they stated they 'cannot replicate the issue' and refused to perform any repairs. This is a safety concern because the sticky steering can make it difficult to control the vehicle and could potentially lead to a crash. There are no warning lights or error messages displayed when this oc… Look up ODI 11684144 at NHTSA ↗ ODI 11715472Reporting multiple safety-related defects on my 2024 Mazda CX-90. Steering system: At approximately 5,000 miles, the vehicle developed abnormal steering behavior, including inconsistent steering response and abnormal feel during normal driving and turning. The condition affected my ability to steer the vehicle predictably and raised safety concerns, particularly during low-speed turns, parking maneuvers, and city driving. The issue was confirmed by the dealer and required replacement of the steering rack, a major steering component. The vehicl… Look up ODI 11715472 at NHTSA ↗ | 3ODI 11629131While driving (less than 2000 miles on the OD) in our 2024 cx90 SE the vehicle started to shift out of timing and everything shut off at once. The vehicle lost all power and all parts shut down. The vehicle would start back up and power steering went out. Our driving speed was at 30mph so it was extremely scary during rush hour traffic. We had to have it towed to the dealership, we're not sure what the issue will be. Look up ODI 11629131 at NHTSA ↗ ODI 11738895When I’m driving, the steering wheel suddenly gets stuck and pulls against me with force. This is extremely dangerous, especially on the freeway or when going over a bridge , the car pulls in the opposite direction of where I’m steering. The brakes also start squealing very loudly. It feels like the steering wheel is about to lock up while I’m driving, and I’ve had to physically fight it to keep control of the car. This is a serious safety risk, and it feels like the vehicle could lose steering at any moment. Look up ODI 11738895 at NHTSA ↗ ODI 11752549When curving left my steering wheel will get “stuck”. It becomes heavy and then jerks back like it just “unlocked”. I haven’t had to pull it back forcefully, yet, but I’m sure it’s not far off. Went to Mazda dealership who state it’s mechanically related to a rack and pinion within the steering components. My car was part of the initial “sticky steering” recall which the previous owner had done in March of 2024. Happy to allow inspection if needed. My safety, along with the safety of others, is at risk anytime I travel along a curve where I cou… Look up ODI 11752549 at NHTSA ↗ | 0 | 10ODI 11715472Reporting multiple safety-related defects on my 2024 Mazda CX-90. Steering system: At approximately 5,000 miles, the vehicle developed abnormal steering behavior, including inconsistent steering response and abnormal feel during normal driving and turning. The condition affected my ability to steer the vehicle predictably and raised safety concerns, particularly during low-speed turns, parking maneuvers, and city driving. The issue was confirmed by the dealer and required replacement of the steering rack, a major steering component. The vehicl… Look up ODI 11715472 at NHTSA ↗ ODI 11730889I have a 2024 Mazda CX-90. I want to report that about two years ago I was contacted regarding a recall (or possibly multiple recalls). The steering would become stiff while turning on curves. I took the vehicle to the dealer, and they reprogrammed something, which fixed the issue for a few months (I don’t remember exactly how long). However, the same problem happened again about three times. I brought the vehicle back to the dealer on January 23, 2026, and they did not have the necessary parts to repair it. I told them I was very afraid to dr… Look up ODI 11730889 at NHTSA ↗ ODI 11733123Breaks squeal consistently only 34,000 miles was doing it when I bought it last year and they said it was just cause it was sitting and would get better never really has always squeals when breaking Steering when turning is glitchy catchy sticks like doesn't turn smooth or go back to center smooth causing you or car to jerk turn unsafe like I see recalls for these same similar things but my car doesn't currently have a recall for any of it by entering vin Look up ODI 11733123 at NHTSA ↗ | 0 |
|---|
| Engine | 7ODI 11557553These are two major problem i want to highlight, which need immediate attention One of them is related to steering wheel, which is a major safety concern for this vehicle to be on road. 1) Major safety concern- steering wheel Steering wheel is catchy when you are driving vehicle on high speed, which make this vehicle so difficult to control/ maneuver and struggling to keep this in a lane Steering wheel catchy means- it becomes hard when you steer and then skid before finally engaged. This makes driver nervous and can lead to an accident due… Look up ODI 11557553 at NHTSA ↗ ODI 11571146The major issue that happened to our newly purchased CX 90 last February 3 with more than 500 miles on it started around 5:30 pm of February 8, while my wife is driving this vehicle with my daughter, all of a sudden the car stopped at the middle of the road with warning signs popping up in the dash screen like I-active sense malfunction, hybrid battery malfunction, engine malfunction light on, and on top of these, critical vehicle malfunction. The car won't start and disabled. Also, the vehicle cannot switch to neutral gear to push/pull the v… Look up ODI 11571146 at NHTSA ↗ ODI 11629131While driving (less than 2000 miles on the OD) in our 2024 cx90 SE the vehicle started to shift out of timing and everything shut off at once. The vehicle lost all power and all parts shut down. The vehicle would start back up and power steering went out. Our driving speed was at 30mph so it was extremely scary during rush hour traffic. We had to have it towed to the dealership, we're not sure what the issue will be. Look up ODI 11629131 at NHTSA ↗ | — | 8ODI 11558847On 12/5/2023, upon turn after intersection, loss of power to the engine. Pushing gas provided no response from the engine. Engine power cut to about 10 miles an hour. Felt as the car was driving on battery - as no engine was heard. Was able to pull over to the side. Turned off and on engine 2-3 times but the power wasn't restored. Received warning on dashboard that there is malfunction with engine. Also received errors on Mazda application I had on phone. Engine light was on the dashboard. Photos attached. While obtaining assistance for tow ser… Look up ODI 11558847 at NHTSA ↗ ODI 11643864The wires under the hood were chewed up by rodents. The cars wires are insulated with a soy based wiring coating. My car is at the dealership for repair and deemed undrivable. This is so unfair because the car is new and only has 6200 miles on it. I am now facing insurance deductible. The dealer says the vehicle is undrivable because it is a safety issue and the engine might catch fire Look up ODI 11643864 at NHTSA ↗ ODI 11664437I’ve been experiencing power loss and surges/RPMs drop for nearly a month now while driving at various speeds. Each time, the iStop indicator comes on. This is a serious safety concern. I am extremely worried that the vehicle could stall, especially while my family is in the car, while driving on a busy highway. Undoubtedly, this issue presents a significant risk to the safety of drivers and passengers. I am requesting your assistance in initiating an official recall from the manufacturer for this component failure. Based on my research, I am… Look up ODI 11664437 at NHTSA ↗ | 16ODI 11571146The major issue that happened to our newly purchased CX 90 last February 3 with more than 500 miles on it started around 5:30 pm of February 8, while my wife is driving this vehicle with my daughter, all of a sudden the car stopped at the middle of the road with warning signs popping up in the dash screen like I-active sense malfunction, hybrid battery malfunction, engine malfunction light on, and on top of these, critical vehicle malfunction. The car won't start and disabled. Also, the vehicle cannot switch to neutral gear to push/pull the v… Look up ODI 11571146 at NHTSA ↗ ODI 11577123There has been two dangerous failures both occurring in an intersection. First instance was in December of 2023 whey the fuel pump failed while turning in an intersection. The second incident was a hybrid battery malfunction, rendering my vehicle unusable in the middle of an intersection again. This was 03/2023 Look up ODI 11577123 at NHTSA ↗ ODI 11615790Stopped at a red light on a busy 2-lane road. I-stop function turned the engine off. When the light turned green, releasing the brake caused a "Hybrid Battery Malfunction" error and the engine failed to start. We put the transmission in park and attempted to turn off and turn on the car with the push to start button. When we attempted to start the car with the push to start button, the car would not start. We were unable to shift into neutral to move the car out of the busy 2-lane highway and were blocking traffic for about an hour. The first t… Look up ODI 11615790 at NHTSA ↗ | 11ODI 11558847On 12/5/2023, upon turn after intersection, loss of power to the engine. Pushing gas provided no response from the engine. Engine power cut to about 10 miles an hour. Felt as the car was driving on battery - as no engine was heard. Was able to pull over to the side. Turned off and on engine 2-3 times but the power wasn't restored. Received warning on dashboard that there is malfunction with engine. Also received errors on Mazda application I had on phone. Engine light was on the dashboard. Photos attached. While obtaining assistance for tow ser… Look up ODI 11558847 at NHTSA ↗ ODI 11563143Turning left at intersection at green light , the oncoming traffic sped up and I needed to floor it to not get hit. The my car switch to hybrid and went into a crawl pace. I had to floor it again to wake it up and get the heck out of the way. I don't think the computer is doing a good job talking to the hybrid system and the powertrain during emergency maneuvering. This can be dangerous. I know it scared the hell out me. Look up ODI 11563143 at NHTSA ↗ ODI 11615790Stopped at a red light on a busy 2-lane road. I-stop function turned the engine off. When the light turned green, releasing the brake caused a "Hybrid Battery Malfunction" error and the engine failed to start. We put the transmission in park and attempted to turn off and turn on the car with the push to start button. When we attempted to start the car with the push to start button, the car would not start. We were unable to shift into neutral to move the car out of the busy 2-lane highway and were blocking traffic for about an hour. The first t… Look up ODI 11615790 at NHTSA ↗ | 0 | 0 | 9ODI 11552119Vehicle low fuel indicators remained lighted up even after fulling up the vehicle tank. it appears is a faulty gas sensor, which if is not replaced can lead to false gasoline levels. Look up ODI 11552119 at NHTSA ↗ ODI 11577123There has been two dangerous failures both occurring in an intersection. First instance was in December of 2023 whey the fuel pump failed while turning in an intersection. The second incident was a hybrid battery malfunction, rendering my vehicle unusable in the middle of an intersection again. This was 03/2023 Look up ODI 11577123 at NHTSA ↗ ODI 11686926I bought a brand new 2024 CX90 in May 2025. I was on the on-ramp entering a Highway at an accelerating speed when the car all of a sudden went into a limp mode and was unable to accelerate. This limp mode that kicked in almost caused me to be hit from behind. Immediately on the dash it flashed Engine Malfunction. I had to pull over to the side of the highway and had the car brought to my local Mazda Dealer. My local Mazda dealer stated that the recent recall #25V-568 NTSHA caused the program/software for the car to misread my fuel pump and esse… Look up ODI 11686926 at NHTSA ↗ |
|---|
| Unknown Or Other | 7ODI 11616728Mazda's Driver Personalization System is highly defective and properly recognizes a driver, at best, 40% of the time. Since multiple functions are tied to this system such as seat position, steering wheel position, infotainment presets, and a variety of other vehicle preferences, this not only causes an inconvenience issue but also a safety issue. The safety problem is that one has to stop the car, put it into Park, press through multiple menus and keystrokes just to change the setting to the correct driver. Look up ODI 11616728 at NHTSA ↗ ODI 11705995Steering wheel gets stuck when turning left on speed 35-50 or over Look up ODI 11705995 at NHTSA ↗ ODI 11718158To Whom It May Concern, I am submitting this complaint to report serious and ongoing safety concerns regarding my Mazda CX-90. I believe this vehicle presents a significant safety risk to occupants and other drivers on the road. Since the date of purchase, this vehicle has been subject to numerous recalls, repeated software updates, and multiple mechanical issues. The number of recalls alone raises concern about the safety and reliability of this model. In addition, the vehicle has been in service many times, and I have frequently been provid… Look up ODI 11718158 at NHTSA ↗ | 8ODI 11558847On 12/5/2023, upon turn after intersection, loss of power to the engine. Pushing gas provided no response from the engine. Engine power cut to about 10 miles an hour. Felt as the car was driving on battery - as no engine was heard. Was able to pull over to the side. Turned off and on engine 2-3 times but the power wasn't restored. Received warning on dashboard that there is malfunction with engine. Also received errors on Mazda application I had on phone. Engine light was on the dashboard. Photos attached. While obtaining assistance for tow ser… Look up ODI 11558847 at NHTSA ↗ ODI 11643864The wires under the hood were chewed up by rodents. The cars wires are insulated with a soy based wiring coating. My car is at the dealership for repair and deemed undrivable. This is so unfair because the car is new and only has 6200 miles on it. I am now facing insurance deductible. The dealer says the vehicle is undrivable because it is a safety issue and the engine might catch fire Look up ODI 11643864 at NHTSA ↗ ODI 11664437I’ve been experiencing power loss and surges/RPMs drop for nearly a month now while driving at various speeds. Each time, the iStop indicator comes on. This is a serious safety concern. I am extremely worried that the vehicle could stall, especially while my family is in the car, while driving on a busy highway. Undoubtedly, this issue presents a significant risk to the safety of drivers and passengers. I am requesting your assistance in initiating an official recall from the manufacturer for this component failure. Based on my research, I am… Look up ODI 11664437 at NHTSA ↗ | — | 5ODI 11705191I am reporting an unresolved safety-related defect with my Mazda CX-90. The vehicle began experiencing repeated malfunctions affecting reliable operation while being driven. The issue was reported to the dealer while the vehicle was still under the manufacturer’s original warranty. The vehicle was taken to a Mazda dealership for diagnosis and repair. The problem has not been resolved, and the vehicle has been held at the dealer for over 30 days. I was provided a manufacturer loaner vehicle because my vehicle has not been deemed reliable to ret… Look up ODI 11705191 at NHTSA ↗ ODI 11712279I have a 2024 MAZD CX-90 Preferred Plus AWD. I was driving my [XXX] grandson to preschool and it sounded as though the passenger's door opened while I was driving. In the split second I looked back to check, unfortunately, I hit a guard rail. My grandson was buckled in his car seat. his first words were "Meme, the door opened but I didn't do it". He was buckled in his car seat and I believe the safety door locks were on. There was no warning sound or light indicating the door was open while I drove. I pulled over, got out of the car and looked… Look up ODI 11712279 at NHTSA ↗ ODI 11727151Started the car to go to work and the check engine light came on, I stop started flashing and wouldn’t turn off. Message says there is a malfunction with the hybrid system and to visit Mazda dealer. I had to drive it to work, so it drove fine. But the lights never went off. Look up ODI 11727151 at NHTSA ↗ | 7ODI 11558847On 12/5/2023, upon turn after intersection, loss of power to the engine. Pushing gas provided no response from the engine. Engine power cut to about 10 miles an hour. Felt as the car was driving on battery - as no engine was heard. Was able to pull over to the side. Turned off and on engine 2-3 times but the power wasn't restored. Received warning on dashboard that there is malfunction with engine. Also received errors on Mazda application I had on phone. Engine light was on the dashboard. Photos attached. While obtaining assistance for tow ser… Look up ODI 11558847 at NHTSA ↗ ODI 11664437I’ve been experiencing power loss and surges/RPMs drop for nearly a month now while driving at various speeds. Each time, the iStop indicator comes on. This is a serious safety concern. I am extremely worried that the vehicle could stall, especially while my family is in the car, while driving on a busy highway. Undoubtedly, this issue presents a significant risk to the safety of drivers and passengers. I am requesting your assistance in initiating an official recall from the manufacturer for this component failure. Based on my research, I am… Look up ODI 11664437 at NHTSA ↗ ODI 11705191I am reporting an unresolved safety-related defect with my Mazda CX-90. The vehicle began experiencing repeated malfunctions affecting reliable operation while being driven. The issue was reported to the dealer while the vehicle was still under the manufacturer’s original warranty. The vehicle was taken to a Mazda dealership for diagnosis and repair. The problem has not been resolved, and the vehicle has been held at the dealer for over 30 days. I was provided a manufacturer loaner vehicle because my vehicle has not been deemed reliable to ret… Look up ODI 11705191 at NHTSA ↗ | 0 | 1ODI 11698538I was stopped by a railroad crossing and when I started driving, my automatic emergency braking activated and jerked to a stop. This happened two consecutive days in a row. Gratefully no one was behind me, or they would have rear ended my vehicle. Look up ODI 11698538 at NHTSA ↗ | 1ODI 11765115The vehicle experience a "Severe Engine Malfunction" alert on the dash board. Mazda Dealership stated it was low pressure fuel pump needed to be replaced at a few months of ownership. Automatic wipers malfunctioned because wipers were hitting the front pillars at driver side. Mazda dealership disabled auto wiper functionality. Unknown Leak found on passenger side beneath the battery area. Look up ODI 11765115 at NHTSA ↗ |
|---|
| Electrical System | 6ODI 11571146The major issue that happened to our newly purchased CX 90 last February 3 with more than 500 miles on it started around 5:30 pm of February 8, while my wife is driving this vehicle with my daughter, all of a sudden the car stopped at the middle of the road with warning signs popping up in the dash screen like I-active sense malfunction, hybrid battery malfunction, engine malfunction light on, and on top of these, critical vehicle malfunction. The car won't start and disabled. Also, the vehicle cannot switch to neutral gear to push/pull the v… Look up ODI 11571146 at NHTSA ↗ ODI 11684144"The steering wheel intermittently sticks and feels resistant when switching lanes or making turns, especially at highway speeds. It does not return smoothly to center, making it feel unsafe and unpredictable. I brought the vehicle to the Mazda dealership, but they stated they 'cannot replicate the issue' and refused to perform any repairs. This is a safety concern because the sticky steering can make it difficult to control the vehicle and could potentially lead to a crash. There are no warning lights or error messages displayed when this oc… Look up ODI 11684144 at NHTSA ↗ ODI 11715472Reporting multiple safety-related defects on my 2024 Mazda CX-90. Steering system: At approximately 5,000 miles, the vehicle developed abnormal steering behavior, including inconsistent steering response and abnormal feel during normal driving and turning. The condition affected my ability to steer the vehicle predictably and raised safety concerns, particularly during low-speed turns, parking maneuvers, and city driving. The issue was confirmed by the dealer and required replacement of the steering rack, a major steering component. The vehicl… Look up ODI 11715472 at NHTSA ↗ | 16ODI 11571146The major issue that happened to our newly purchased CX 90 last February 3 with more than 500 miles on it started around 5:30 pm of February 8, while my wife is driving this vehicle with my daughter, all of a sudden the car stopped at the middle of the road with warning signs popping up in the dash screen like I-active sense malfunction, hybrid battery malfunction, engine malfunction light on, and on top of these, critical vehicle malfunction. The car won't start and disabled. Also, the vehicle cannot switch to neutral gear to push/pull the v… Look up ODI 11571146 at NHTSA ↗ ODI 11577123There has been two dangerous failures both occurring in an intersection. First instance was in December of 2023 whey the fuel pump failed while turning in an intersection. The second incident was a hybrid battery malfunction, rendering my vehicle unusable in the middle of an intersection again. This was 03/2023 Look up ODI 11577123 at NHTSA ↗ ODI 11615790Stopped at a red light on a busy 2-lane road. I-stop function turned the engine off. When the light turned green, releasing the brake caused a "Hybrid Battery Malfunction" error and the engine failed to start. We put the transmission in park and attempted to turn off and turn on the car with the push to start button. When we attempted to start the car with the push to start button, the car would not start. We were unable to shift into neutral to move the car out of the busy 2-lane highway and were blocking traffic for about an hour. The first t… Look up ODI 11615790 at NHTSA ↗ | 5ODI 11705191I am reporting an unresolved safety-related defect with my Mazda CX-90. The vehicle began experiencing repeated malfunctions affecting reliable operation while being driven. The issue was reported to the dealer while the vehicle was still under the manufacturer’s original warranty. The vehicle was taken to a Mazda dealership for diagnosis and repair. The problem has not been resolved, and the vehicle has been held at the dealer for over 30 days. I was provided a manufacturer loaner vehicle because my vehicle has not been deemed reliable to ret… Look up ODI 11705191 at NHTSA ↗ ODI 11712279I have a 2024 MAZD CX-90 Preferred Plus AWD. I was driving my [XXX] grandson to preschool and it sounded as though the passenger's door opened while I was driving. In the split second I looked back to check, unfortunately, I hit a guard rail. My grandson was buckled in his car seat. his first words were "Meme, the door opened but I didn't do it". He was buckled in his car seat and I believe the safety door locks were on. There was no warning sound or light indicating the door was open while I drove. I pulled over, got out of the car and looked… Look up ODI 11712279 at NHTSA ↗ ODI 11727151Started the car to go to work and the check engine light came on, I stop started flashing and wouldn’t turn off. Message says there is a malfunction with the hybrid system and to visit Mazda dealer. I had to drive it to work, so it drove fine. But the lights never went off. Look up ODI 11727151 at NHTSA ↗ | — | 11ODI 11615790Stopped at a red light on a busy 2-lane road. I-stop function turned the engine off. When the light turned green, releasing the brake caused a "Hybrid Battery Malfunction" error and the engine failed to start. We put the transmission in park and attempted to turn off and turn on the car with the push to start button. When we attempted to start the car with the push to start button, the car would not start. We were unable to shift into neutral to move the car out of the busy 2-lane highway and were blocking traffic for about an hour. The first t… Look up ODI 11615790 at NHTSA ↗ ODI 11704444My new Mazda CX-90 failed to restart after being stopped at a stop sign. After restarting manually, the dash displayed the check engine light and the “i-stop malfunction” light. The car now flashes this warning whenever it is on. There is an open recall for this issue (24V-816) but my local Mazda dealer does not pull anything up when they search my VIN. It appears the recall only applies to these vehicles built between 12/23 and 4/24. My car was built in 11/23. I believe this recall should be expanded to included more vehicles like mine. Look up ODI 11704444 at NHTSA ↗ ODI 11705191I am reporting an unresolved safety-related defect with my Mazda CX-90. The vehicle began experiencing repeated malfunctions affecting reliable operation while being driven. The issue was reported to the dealer while the vehicle was still under the manufacturer’s original warranty. The vehicle was taken to a Mazda dealership for diagnosis and repair. The problem has not been resolved, and the vehicle has been held at the dealer for over 30 days. I was provided a manufacturer loaner vehicle because my vehicle has not been deemed reliable to ret… Look up ODI 11705191 at NHTSA ↗ | 2ODI 11521778During normal driving conditions going down a state highway, the vehicle lost speed with adaptive cruise control enabled. Noticing the vehicle was losing speed, I depressed the accelerator pedal. The accelerator pedal was unresponsive and unable to accelerate, I had to maneuver off the highway. Luckily, the car behind my vehicle was far enough behind me and my vehicle was going fast enough that I was able to coast to a safe stop on the side of the highway. A message popped up on the instrument cluster screen informing me to shift the transm… Look up ODI 11521778 at NHTSA ↗ ODI 11737974Hybrid battery recall was replaced and failed a month later for a second time burning other systems and causing a compete failure in the car. It failed in a deserted portion of [XXX] while traveling from [XXX] to [XXX] for important business. This left me stranded in the middle of the [XXX] desert late at night in a dangerous area. It failed on the highway loosing complete power with multiple failures reported on dashboard. I was left stranded in the middle of nowhere with no nearby services or immediate assistance and was forced to remain … Look up ODI 11737974 at NHTSA ↗ | 4ODI 11715472Reporting multiple safety-related defects on my 2024 Mazda CX-90. Steering system: At approximately 5,000 miles, the vehicle developed abnormal steering behavior, including inconsistent steering response and abnormal feel during normal driving and turning. The condition affected my ability to steer the vehicle predictably and raised safety concerns, particularly during low-speed turns, parking maneuvers, and city driving. The issue was confirmed by the dealer and required replacement of the steering rack, a major steering component. The vehicl… Look up ODI 11715472 at NHTSA ↗ ODI 11728149Incident 1: While driving my 2024 Mazda CX-90 PHEV at low-to-moderate speed, the vehicle suddenly and completely locked up without any driver input. There was no gradual slowing or normal braking behavior. Instead, the vehicle went immediately from moving to an abrupt, forceful stop, as if maximum braking was applied instantly. There were no warning lights, alerts, or audible signals before or during the event, and there were no obstacles or vehicles in front of me. Incident 2 (approximately 6 months later): A second, nearly identical event oc… Look up ODI 11728149 at NHTSA ↗ ODI 117345051) What component or system failed? The issue appears to involve the vehicle’s electrical system and hybrid system, as well as brake-related electronic systems. The vehicle displayed multiple warnings including “Hybrid System Malfunction” and “Critical Vehicle Malfunction.” The electronic parking brake system was also affected during the incident, including a situation where the brake could not be released while the vehicle was in motion. The affected components are available for inspection upon request. 2) How was safety put at risk? Safety wa… Look up ODI 11734505 at NHTSA ↗ | 4ODI 11577123There has been two dangerous failures both occurring in an intersection. First instance was in December of 2023 whey the fuel pump failed while turning in an intersection. The second incident was a hybrid battery malfunction, rendering my vehicle unusable in the middle of an intersection again. This was 03/2023 Look up ODI 11577123 at NHTSA ↗ ODI 11633686The fuel gauge and range indicator are faulty. I was doing long-distance highway driving during the holidays. At 1/4 tank, the range indicator said 110 miles until empty. As soon as the needle dipped a fraction below 1/4 tank (about 20 miles later) the range indicator dropped instantly to 40 miles left AND THEN DROPPED ONE MILE PER SECOND UNTIL IT REGISTERED ZERO. The needle also fell at the same rate until I was driving on the interstate with zero range and a gas gauge buried below empty. All of this occurred within one minute. I pulled into t… Look up ODI 11633686 at NHTSA ↗ ODI 11741525My 2024 Mazda CX-90 PHEV Premium Plus has experienced repeated hybrid system failures. The vehicle currently has an active "Hybrid System Malfunction" warning light. This is the latest in a series of 17 recalls and recurring defects since purchase in July 2023. Most recently, the vehicle was out of service from February 14, 2026 to approximately March 18, 2026 due to a severe transmission fluid leak, which the dealer (Nealson Mazda Cool Springs, TN) acknowledged was common in this model. The current hybrid system malfunction warning poses a dir… Look up ODI 11741525 at NHTSA ↗ |
|---|
| Power Train | 3ODI 11629131While driving (less than 2000 miles on the OD) in our 2024 cx90 SE the vehicle started to shift out of timing and everything shut off at once. The vehicle lost all power and all parts shut down. The vehicle would start back up and power steering went out. Our driving speed was at 30mph so it was extremely scary during rush hour traffic. We had to have it towed to the dealership, we're not sure what the issue will be. Look up ODI 11629131 at NHTSA ↗ ODI 11738895When I’m driving, the steering wheel suddenly gets stuck and pulls against me with force. This is extremely dangerous, especially on the freeway or when going over a bridge , the car pulls in the opposite direction of where I’m steering. The brakes also start squealing very loudly. It feels like the steering wheel is about to lock up while I’m driving, and I’ve had to physically fight it to keep control of the car. This is a serious safety risk, and it feels like the vehicle could lose steering at any moment. Look up ODI 11738895 at NHTSA ↗ ODI 11752549When curving left my steering wheel will get “stuck”. It becomes heavy and then jerks back like it just “unlocked”. I haven’t had to pull it back forcefully, yet, but I’m sure it’s not far off. Went to Mazda dealership who state it’s mechanically related to a rack and pinion within the steering components. My car was part of the initial “sticky steering” recall which the previous owner had done in March of 2024. Happy to allow inspection if needed. My safety, along with the safety of others, is at risk anytime I travel along a curve where I cou… Look up ODI 11752549 at NHTSA ↗ | 11ODI 11558847On 12/5/2023, upon turn after intersection, loss of power to the engine. Pushing gas provided no response from the engine. Engine power cut to about 10 miles an hour. Felt as the car was driving on battery - as no engine was heard. Was able to pull over to the side. Turned off and on engine 2-3 times but the power wasn't restored. Received warning on dashboard that there is malfunction with engine. Also received errors on Mazda application I had on phone. Engine light was on the dashboard. Photos attached. While obtaining assistance for tow ser… Look up ODI 11558847 at NHTSA ↗ ODI 11563143Turning left at intersection at green light , the oncoming traffic sped up and I needed to floor it to not get hit. The my car switch to hybrid and went into a crawl pace. I had to floor it again to wake it up and get the heck out of the way. I don't think the computer is doing a good job talking to the hybrid system and the powertrain during emergency maneuvering. This can be dangerous. I know it scared the hell out me. Look up ODI 11563143 at NHTSA ↗ ODI 11615790Stopped at a red light on a busy 2-lane road. I-stop function turned the engine off. When the light turned green, releasing the brake caused a "Hybrid Battery Malfunction" error and the engine failed to start. We put the transmission in park and attempted to turn off and turn on the car with the push to start button. When we attempted to start the car with the push to start button, the car would not start. We were unable to shift into neutral to move the car out of the busy 2-lane highway and were blocking traffic for about an hour. The first t… Look up ODI 11615790 at NHTSA ↗ | 7ODI 11558847On 12/5/2023, upon turn after intersection, loss of power to the engine. Pushing gas provided no response from the engine. Engine power cut to about 10 miles an hour. Felt as the car was driving on battery - as no engine was heard. Was able to pull over to the side. Turned off and on engine 2-3 times but the power wasn't restored. Received warning on dashboard that there is malfunction with engine. Also received errors on Mazda application I had on phone. Engine light was on the dashboard. Photos attached. While obtaining assistance for tow ser… Look up ODI 11558847 at NHTSA ↗ ODI 11664437I’ve been experiencing power loss and surges/RPMs drop for nearly a month now while driving at various speeds. Each time, the iStop indicator comes on. This is a serious safety concern. I am extremely worried that the vehicle could stall, especially while my family is in the car, while driving on a busy highway. Undoubtedly, this issue presents a significant risk to the safety of drivers and passengers. I am requesting your assistance in initiating an official recall from the manufacturer for this component failure. Based on my research, I am… Look up ODI 11664437 at NHTSA ↗ ODI 11705191I am reporting an unresolved safety-related defect with my Mazda CX-90. The vehicle began experiencing repeated malfunctions affecting reliable operation while being driven. The issue was reported to the dealer while the vehicle was still under the manufacturer’s original warranty. The vehicle was taken to a Mazda dealership for diagnosis and repair. The problem has not been resolved, and the vehicle has been held at the dealer for over 30 days. I was provided a manufacturer loaner vehicle because my vehicle has not been deemed reliable to ret… Look up ODI 11705191 at NHTSA ↗ | 11ODI 11615790Stopped at a red light on a busy 2-lane road. I-stop function turned the engine off. When the light turned green, releasing the brake caused a "Hybrid Battery Malfunction" error and the engine failed to start. We put the transmission in park and attempted to turn off and turn on the car with the push to start button. When we attempted to start the car with the push to start button, the car would not start. We were unable to shift into neutral to move the car out of the busy 2-lane highway and were blocking traffic for about an hour. The first t… Look up ODI 11615790 at NHTSA ↗ ODI 11704444My new Mazda CX-90 failed to restart after being stopped at a stop sign. After restarting manually, the dash displayed the check engine light and the “i-stop malfunction” light. The car now flashes this warning whenever it is on. There is an open recall for this issue (24V-816) but my local Mazda dealer does not pull anything up when they search my VIN. It appears the recall only applies to these vehicles built between 12/23 and 4/24. My car was built in 11/23. I believe this recall should be expanded to included more vehicles like mine. Look up ODI 11704444 at NHTSA ↗ ODI 11705191I am reporting an unresolved safety-related defect with my Mazda CX-90. The vehicle began experiencing repeated malfunctions affecting reliable operation while being driven. The issue was reported to the dealer while the vehicle was still under the manufacturer’s original warranty. The vehicle was taken to a Mazda dealership for diagnosis and repair. The problem has not been resolved, and the vehicle has been held at the dealer for over 30 days. I was provided a manufacturer loaner vehicle because my vehicle has not been deemed reliable to ret… Look up ODI 11705191 at NHTSA ↗ | — | 0 | 3ODI 11728149Incident 1: While driving my 2024 Mazda CX-90 PHEV at low-to-moderate speed, the vehicle suddenly and completely locked up without any driver input. There was no gradual slowing or normal braking behavior. Instead, the vehicle went immediately from moving to an abrupt, forceful stop, as if maximum braking was applied instantly. There were no warning lights, alerts, or audible signals before or during the event, and there were no obstacles or vehicles in front of me. Incident 2 (approximately 6 months later): A second, nearly identical event oc… Look up ODI 11728149 at NHTSA ↗ ODI 11738895When I’m driving, the steering wheel suddenly gets stuck and pulls against me with force. This is extremely dangerous, especially on the freeway or when going over a bridge , the car pulls in the opposite direction of where I’m steering. The brakes also start squealing very loudly. It feels like the steering wheel is about to lock up while I’m driving, and I’ve had to physically fight it to keep control of the car. This is a serious safety risk, and it feels like the vehicle could lose steering at any moment. Look up ODI 11738895 at NHTSA ↗ ODI 11761759Our 2024 Mazda CX-90 has experienced the same significant malfunction on two separate occasions while being driven on busy public roads. The vehicle displayed an “Acceleration Limited Due to Battery Condition” warning and experienced significantly reduced/limited acceleration while driving. This put the occupants and other motorists at risk because the vehicle could not accelerate normally in traffic. A similar occurrence while merging, crossing an intersection, or traveling in heavy traffic could potentially result in a collision. The vehicle… Look up ODI 11761759 at NHTSA ↗ | 4ODI 11737446My 2024 Mazda CX-90 MHEV has experienced multiple life-threatening sudden engine stalls and a complete loss of motive power while driving in active traffic lanes. The first incident occurred on December 31, 2024, when the vehicle abruptly shut down with an "Engine Malfunction" dashboard alert. The vehicle was towed to an authorized Mazda dealership (Palatine, IL), where it was held for a week, but technicians stated they could not replicate the issue and returned the car to me as safe. On March 30, 2026, the exact same failure recurred. While… Look up ODI 11737446 at NHTSA ↗ ODI 11741525My 2024 Mazda CX-90 PHEV Premium Plus has experienced repeated hybrid system failures. The vehicle currently has an active "Hybrid System Malfunction" warning light. This is the latest in a series of 17 recalls and recurring defects since purchase in July 2023. Most recently, the vehicle was out of service from February 14, 2026 to approximately March 18, 2026 due to a severe transmission fluid leak, which the dealer (Nealson Mazda Cool Springs, TN) acknowledged was common in this model. The current hybrid system malfunction warning poses a dir… Look up ODI 11741525 at NHTSA ↗ ODI 11747228The lower fuel pump is going out. It is a known issue with the car. I was driving out of town and the car started to stall. My steering has become ruggish while on the trip as well, and steering was complicated during heavy winds. The car has been inspected by dealer and both warning lights have been cleared. But the issues still remain. Look up ODI 11747228 at NHTSA ↗ |
|---|
| Forward Collision Avoidance: Adaptive Cruise Control | 0 | 0 | 0 | 2ODI 11521778During normal driving conditions going down a state highway, the vehicle lost speed with adaptive cruise control enabled. Noticing the vehicle was losing speed, I depressed the accelerator pedal. The accelerator pedal was unresponsive and unable to accelerate, I had to maneuver off the highway. Luckily, the car behind my vehicle was far enough behind me and my vehicle was going fast enough that I was able to coast to a safe stop on the side of the highway. A message popped up on the instrument cluster screen informing me to shift the transm… Look up ODI 11521778 at NHTSA ↗ ODI 11737974Hybrid battery recall was replaced and failed a month later for a second time burning other systems and causing a compete failure in the car. It failed in a deserted portion of [XXX] while traveling from [XXX] to [XXX] for important business. This left me stranded in the middle of the [XXX] desert late at night in a dangerous area. It failed on the highway loosing complete power with multiple failures reported on dashboard. I was left stranded in the middle of nowhere with no nearby services or immediate assistance and was forced to remain … Look up ODI 11737974 at NHTSA ↗ | 0 | — | 0 | 0 |
|---|
| Service Brakes | 10ODI 11715472Reporting multiple safety-related defects on my 2024 Mazda CX-90. Steering system: At approximately 5,000 miles, the vehicle developed abnormal steering behavior, including inconsistent steering response and abnormal feel during normal driving and turning. The condition affected my ability to steer the vehicle predictably and raised safety concerns, particularly during low-speed turns, parking maneuvers, and city driving. The issue was confirmed by the dealer and required replacement of the steering rack, a major steering component. The vehicl… Look up ODI 11715472 at NHTSA ↗ ODI 11730889I have a 2024 Mazda CX-90. I want to report that about two years ago I was contacted regarding a recall (or possibly multiple recalls). The steering would become stiff while turning on curves. I took the vehicle to the dealer, and they reprogrammed something, which fixed the issue for a few months (I don’t remember exactly how long). However, the same problem happened again about three times. I brought the vehicle back to the dealer on January 23, 2026, and they did not have the necessary parts to repair it. I told them I was very afraid to dr… Look up ODI 11730889 at NHTSA ↗ ODI 11733123Breaks squeal consistently only 34,000 miles was doing it when I bought it last year and they said it was just cause it was sitting and would get better never really has always squeals when breaking Steering when turning is glitchy catchy sticks like doesn't turn smooth or go back to center smooth causing you or car to jerk turn unsafe like I see recalls for these same similar things but my car doesn't currently have a recall for any of it by entering vin Look up ODI 11733123 at NHTSA ↗ | 0 | 1ODI 11698538I was stopped by a railroad crossing and when I started driving, my automatic emergency braking activated and jerked to a stop. This happened two consecutive days in a row. Gratefully no one was behind me, or they would have rear ended my vehicle. Look up ODI 11698538 at NHTSA ↗ | 4ODI 11715472Reporting multiple safety-related defects on my 2024 Mazda CX-90. Steering system: At approximately 5,000 miles, the vehicle developed abnormal steering behavior, including inconsistent steering response and abnormal feel during normal driving and turning. The condition affected my ability to steer the vehicle predictably and raised safety concerns, particularly during low-speed turns, parking maneuvers, and city driving. The issue was confirmed by the dealer and required replacement of the steering rack, a major steering component. The vehicl… Look up ODI 11715472 at NHTSA ↗ ODI 11728149Incident 1: While driving my 2024 Mazda CX-90 PHEV at low-to-moderate speed, the vehicle suddenly and completely locked up without any driver input. There was no gradual slowing or normal braking behavior. Instead, the vehicle went immediately from moving to an abrupt, forceful stop, as if maximum braking was applied instantly. There were no warning lights, alerts, or audible signals before or during the event, and there were no obstacles or vehicles in front of me. Incident 2 (approximately 6 months later): A second, nearly identical event oc… Look up ODI 11728149 at NHTSA ↗ ODI 117345051) What component or system failed? The issue appears to involve the vehicle’s electrical system and hybrid system, as well as brake-related electronic systems. The vehicle displayed multiple warnings including “Hybrid System Malfunction” and “Critical Vehicle Malfunction.” The electronic parking brake system was also affected during the incident, including a situation where the brake could not be released while the vehicle was in motion. The affected components are available for inspection upon request. 2) How was safety put at risk? Safety wa… Look up ODI 11734505 at NHTSA ↗ | 3ODI 11728149Incident 1: While driving my 2024 Mazda CX-90 PHEV at low-to-moderate speed, the vehicle suddenly and completely locked up without any driver input. There was no gradual slowing or normal braking behavior. Instead, the vehicle went immediately from moving to an abrupt, forceful stop, as if maximum braking was applied instantly. There were no warning lights, alerts, or audible signals before or during the event, and there were no obstacles or vehicles in front of me. Incident 2 (approximately 6 months later): A second, nearly identical event oc… Look up ODI 11728149 at NHTSA ↗ ODI 11738895When I’m driving, the steering wheel suddenly gets stuck and pulls against me with force. This is extremely dangerous, especially on the freeway or when going over a bridge , the car pulls in the opposite direction of where I’m steering. The brakes also start squealing very loudly. It feels like the steering wheel is about to lock up while I’m driving, and I’ve had to physically fight it to keep control of the car. This is a serious safety risk, and it feels like the vehicle could lose steering at any moment. Look up ODI 11738895 at NHTSA ↗ ODI 11761759Our 2024 Mazda CX-90 has experienced the same significant malfunction on two separate occasions while being driven on busy public roads. The vehicle displayed an “Acceleration Limited Due to Battery Condition” warning and experienced significantly reduced/limited acceleration while driving. This put the occupants and other motorists at risk because the vehicle could not accelerate normally in traffic. A similar occurrence while merging, crossing an intersection, or traveling in heavy traffic could potentially result in a collision. The vehicle… Look up ODI 11761759 at NHTSA ↗ | 0 | — | 0 |
|---|
| Fuel/Propulsion System | 0 | 9ODI 11552119Vehicle low fuel indicators remained lighted up even after fulling up the vehicle tank. it appears is a faulty gas sensor, which if is not replaced can lead to false gasoline levels. Look up ODI 11552119 at NHTSA ↗ ODI 11577123There has been two dangerous failures both occurring in an intersection. First instance was in December of 2023 whey the fuel pump failed while turning in an intersection. The second incident was a hybrid battery malfunction, rendering my vehicle unusable in the middle of an intersection again. This was 03/2023 Look up ODI 11577123 at NHTSA ↗ ODI 11686926I bought a brand new 2024 CX90 in May 2025. I was on the on-ramp entering a Highway at an accelerating speed when the car all of a sudden went into a limp mode and was unable to accelerate. This limp mode that kicked in almost caused me to be hit from behind. Immediately on the dash it flashed Engine Malfunction. I had to pull over to the side of the highway and had the car brought to my local Mazda Dealer. My local Mazda dealer stated that the recent recall #25V-568 NTSHA caused the program/software for the car to misread my fuel pump and esse… Look up ODI 11686926 at NHTSA ↗ | 1ODI 11765115The vehicle experience a "Severe Engine Malfunction" alert on the dash board. Mazda Dealership stated it was low pressure fuel pump needed to be replaced at a few months of ownership. Automatic wipers malfunctioned because wipers were hitting the front pillars at driver side. Mazda dealership disabled auto wiper functionality. Unknown Leak found on passenger side beneath the battery area. Look up ODI 11765115 at NHTSA ↗ | 4ODI 11577123There has been two dangerous failures both occurring in an intersection. First instance was in December of 2023 whey the fuel pump failed while turning in an intersection. The second incident was a hybrid battery malfunction, rendering my vehicle unusable in the middle of an intersection again. This was 03/2023 Look up ODI 11577123 at NHTSA ↗ ODI 11633686The fuel gauge and range indicator are faulty. I was doing long-distance highway driving during the holidays. At 1/4 tank, the range indicator said 110 miles until empty. As soon as the needle dipped a fraction below 1/4 tank (about 20 miles later) the range indicator dropped instantly to 40 miles left AND THEN DROPPED ONE MILE PER SECOND UNTIL IT REGISTERED ZERO. The needle also fell at the same rate until I was driving on the interstate with zero range and a gas gauge buried below empty. All of this occurred within one minute. I pulled into t… Look up ODI 11633686 at NHTSA ↗ ODI 11741525My 2024 Mazda CX-90 PHEV Premium Plus has experienced repeated hybrid system failures. The vehicle currently has an active "Hybrid System Malfunction" warning light. This is the latest in a series of 17 recalls and recurring defects since purchase in July 2023. Most recently, the vehicle was out of service from February 14, 2026 to approximately March 18, 2026 due to a severe transmission fluid leak, which the dealer (Nealson Mazda Cool Springs, TN) acknowledged was common in this model. The current hybrid system malfunction warning poses a dir… Look up ODI 11741525 at NHTSA ↗ | 4ODI 11737446My 2024 Mazda CX-90 MHEV has experienced multiple life-threatening sudden engine stalls and a complete loss of motive power while driving in active traffic lanes. The first incident occurred on December 31, 2024, when the vehicle abruptly shut down with an "Engine Malfunction" dashboard alert. The vehicle was towed to an authorized Mazda dealership (Palatine, IL), where it was held for a week, but technicians stated they could not replicate the issue and returned the car to me as safe. On March 30, 2026, the exact same failure recurred. While… Look up ODI 11737446 at NHTSA ↗ ODI 11741525My 2024 Mazda CX-90 PHEV Premium Plus has experienced repeated hybrid system failures. The vehicle currently has an active "Hybrid System Malfunction" warning light. This is the latest in a series of 17 recalls and recurring defects since purchase in July 2023. Most recently, the vehicle was out of service from February 14, 2026 to approximately March 18, 2026 due to a severe transmission fluid leak, which the dealer (Nealson Mazda Cool Springs, TN) acknowledged was common in this model. The current hybrid system malfunction warning poses a dir… Look up ODI 11741525 at NHTSA ↗ ODI 11747228The lower fuel pump is going out. It is a known issue with the car. I was driving out of town and the car started to stall. My steering has become ruggish while on the trip as well, and steering was complicated during heavy winds. The car has been inspected by dealer and both warning lights have been cleared. But the issues still remain. Look up ODI 11747228 at NHTSA ↗ | 0 | 0 | — |
|---|