Mitsubishi Caribbean GALANT recalls by model year

Reported: 1998-12-10 (December 10, 1998) · Model years: 1986, 1987, 1989, 1990, 1991

VEHICLE DESCRIPTION: PASSENGER VEHICLES SOLD IN THE CARIBBEAN. IN THE FRONT PASSENGER SEAT OF THESE VEHICLES, WHICH ARE EQUIPPED WITH TAKATA BELT BUCKLES, THE SEAT BELT RELEASE BUTTONS, WHICH ARE MADE OF ABS PLASTIC MATERIAL AND MARKED "PRESS," CAN BREAK, ALLOWING PIECES TO FALL INTO THE BUCKLE ASSEMBLY.

Consequence: IF PIECES FALL INTO THE BUCKLE ASSEMBLY, THE BUCKLE MAY NOT OPERATE PROPERLY, FAILING TO PROPERLY RESTRAIN AN OCCUPANT IN THE EVENT OF A CRASH.

Remedy: DEALERS WILL REPAIR THE FRONT SEAT BELT BUCKLES.

Reported: 2001-04-06 (April 6, 2001) · Model years: 1994, 1995, 1996, 1997, 1998

VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE. ALSO, MMC HAS ADDED THE POTENTIAL OF LEAKING MOISTURE, WHICH CAN CAUSE THE BALL STUD TO CORRODE.

Consequence: THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH. THIS CAMPAIGN SUPERCEDES MMC'S PREVIOUS SAFETY RECALL CAMPAIGN, SEE 99V-066.

Remedy: DEALERS WILL INSPECT THE LOWER LATERAL ARM BALL JOINT FOR WEAR. BALL JOINTS THAT EXHIBIT WEAR BEYOND THE ESTABLISHED TOLERANCE WILL BE REPLACED WITH NEWLY DESIGNED LATERAL ARM BALL JOINTS. BALL JOINTS THAT ARE WITHIN THE ESTABLISHED TOLERANCE WILL BE CLEANED AND A SPECIAL SEALANT WILL BE APPLIED TO PREVENT INTRUSION OF MOISTURE.

Reported: 1999-05-19 (May 19, 1999) · Model years: 1994, 1995, 1996

VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE.

Consequence: THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH.

Remedy: DEALERS WILL INSPECT THE RUBBER BOOTS, AND IF THE BOOT IS DAMAGED, THEY WILL REPLACE THE LOWER LATERAL ARM AND BALL JOINT ON THE AFFECTED VEHICLES.

Reported: 2000-08-10 (August 10, 2000) · Model years: 1999, 2000

VEHICLE DESCRIPTION: PASSENGER VEHICLES. A NUT IN THE STEERING GEAR ASSEMBLY WAS NOT PROPERLY TIGHTENED, RESULTING IN SYMPTOMS RANGING FROM STEERING WHEEL VIBRATION TO STIFF STEERING, AND IN THE WORST CASE, NO ABILITY TO TURN LEFT.

Consequence: A LOSS OF STEERING CONTROL COULD INCREASE THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT THESE VEHICLES AND REPLACE THE STEERING GEAR ASSEMBLY IF A LOOSE NUT CONNECTION IS FOUND.

Reported: 1999-11-01 (November 1, 1999) · Model years: 1999, 2000

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE COLUMN SWITCH LEVERS CAN BECOME LOOSE OR BREAK OVER TIME.

Consequence: LOOSENING OR CRACKING OF THE LEVERS CAN CAUSE DIRECTIONAL LAMPS THAT DO NOT SELF-CANCEL OR OPERATE, HEAD LAMPS THAT DO NOT TURN OFF, WINDSHIELD WASHERS THAT OPERATE CONTINUOUSLY AND/OR WINDSHIELD WIPERS THAT DO NOT OPERATE.

Remedy: DEALERS WILL INSTALL A REDESIGNED SWITCH.

Reported: 1999-11-23 (November 23, 1999) · Model years: 1999, 2000

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH V6 ENGINES AND FEDERAL EMISSION EQUIPMENT. THE BATTERY CABLE HARNESS CAN BECOME HEAT DAMAGED BY THE FRONT EXHAUST MANIFOLD WHICH COULD CAUSE GROUNDED CIRCUITS.

Consequence: THIS CIRCUIT FAILURE COULD CAUSE ANY OF THE FOLLOWING TO OCCUR: (1) THE ENGINE WILL NOT START BECAUSE THE MAIN FUSE WILL BLOW IF THE POWER LEAD IS GROUNDED; (2) THE LOW OIL PRESSURE WARNING LAMP WILL ILLUMINATE IF THE SIGNAL WIRE IS GROUNDED; (3) THE AIRCONDITIONING SYSTEM WILL BECOME INOPERATIVE IF THE LEAD TO THE MAGNETIC CLUTCH IS GROUNDED; AND (4) THE TURN SIGNAL/HAZARD LAMPS WILL BECOME INOPERATIVE IF THE VOLTAGE MONITOR LEAD IS GROUNDED.

Remedy: DEALERS WILL REMOVE AND DISCARD A METAL MANIFOLD BRACKET (FROM GALANT MODELS ONLY - ECLIPSE HAS NO SUCH BRACKET). DEALERS WILL ALSO INSPECT THE HARNESS. IF THE HARNESS WIRES SHOW NO DAMAGE, THE DEALER WILL INSTALL A HEAT INSULATOR ALONG WITH HEAT RESISTANT HARNESS CLIPS. IF THE HARNESS WIRES DO SHOW DAMAGE, THE DEALERS WILL INSTALL A NEW HARNESS WITH PREINSTALLED INTEGRAL HEAT PROTECTION.

Reported: 2001-09-25 (September 25, 2001) · Model years: 2000

VEHICLE DESCRIPTION: PASSENGER VEHICLES BUILT WITH V6 ENGINES TO FEDERAL EMISSION STANDARDS. THE POWER STEERING FLUID FEED TUBE CAN COME IN CONTACT WITH AN EXHAUST MANIFOLD MOUNTED HEAT SHIELD CAUSING A HOLE TO BE WORN THROUGH THE POWER STEERING PIPE ALLOWING FLUID LEAKAGE.

Consequence: LEAKING POWER STEERING FLUID CAN RESULT IN A FIRE AND CONTINUED LOSS OF FLUID WILL RESULT IN A LOSS OF POWER ASSIST, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE POWER STEERING TUBE WITH ONE HAVING A NEW ROUTING. OWNER NOTIFICATION BEGAN MARCH 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MITSUBISHI CARIBBEAN AT 1-787-251-8715.

Reported: 2000-09-26 (September 26, 2000) · Model years: 2001

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE HARNESS FOR THE CRANKSHAFT POSITION SENSOR COULD COME IN CONTACT WITH A NEW PROTECTIVE SHIELD CAUSING A GROUNDED CIRCUIT.

Consequence: PROLONGED WIRING HARNESS CONTACT WITH THE HEAT SHIELD WILL CAUSE THE WIRING INSULATION TO WEAR AND EVENTUALLY TO GROUND OUT. THIS COULD CAUSE THE ENGINE TO DIE-OUT, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL RE-ROUTE THE CRANKSHAFT POSITION SENSOR HARNESS.