New Flyer XDE35 recalls by model year

Reported: 2011-08-22 (August 22, 2011) · Model years: 2010

NEW FLYER IS RECALLING CERTAIN MODEL YEAR 2010 HEAVY DUTY TRANSIT BUSES, MODELS D35LFR, D40LFR, D60LFR, DE40LFR, DE60LFR, XD35, XDE35, AND XDE40, MANUFACTURED FROM SEPTEMBER 30, 2010, THROUGH JUNE 3, 2011, EQUIPPED WITH A CUMMINS ISB, ISL, ISC, or ISX DIESEL ENGINE. THE V-BAND CLAMP ASSEMBLY, PART NUMBERS Q187684, Q187685, AND Q187686, USED TO CONNECT THE INLET AND OUTLET CONE SECTIONS TO THE DIESEL OXIDATION CATALYST (DOC)/DIESEL PARTICULATE FILTER (DPF) INCLUDE A T-BOLT WHICH CAN FRACTURE AND FAIL WHEN SUBJECTED TO STRESS OR LOAD. A FRACTURE OR FAILURE OF THE T-BOLT MAY CAUSE THE CLAMP TO LOOSEN AND THE INLET OR OUTLET SECTIONS ATTACHED TO THE DOC/DPF HOUSING TO DISCONNECT.

Consequence: IF THE INLET OR OUTLET SECTIONS DISCONNECT, HOT EXHAUST GASES CAN VENT PRIOR TO EXITING THE TAILPIPE, CREATING THE RISK OF COMBUSTION AND A FIRE. IF BOTH CLAMPS FAIL, THERE IS A RISK IN SOME APPLICATIONS THAT THE DOC/DPF HOUSING MAY DETACH COMPLETELY, CREATING A ROAD HAZARD.

Remedy: NEW FLYER IS WORKING WITH CUMMINS TO IDENTIFY AND NOTIFY OWNERS OF THE RECALL CAMPAIGN. REPAIRS WILL BE PERFORMED BY AUTHORIZED CUMMINS DEALERS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 1, 2011. OWNERS MAY CONTACT CUMMINS AT 1-812-377-5000 OR NEW FLYER CUSTOMER SERVICES AT 1-204-934-4876.

Reported: 2012-01-04 (January 4, 2012) · Model years: 2010, 2011

NEW FLYER IS RECALLING CERTAIN MODEL YEARS 2009-2012 XDE40, MODEL YEARS 2010-2011 MODELS XD35 AND XDE35, MODEL YEAR 2010 XD40, AND MODEL YEAR 2011 XN40 TRANSIT BUSES, MANUFACTURED FROM JANUARY 2010, THROUGH DECEMBER 2011, AND EQUIPPED WITH A PARKER-HANNIFIN (VANSCO) INSTRUMENT PANEL. THE PROGRAMMING OF THE INSTRUMENT PANEL IS SUCH THAT IF MULTIPLE ERROR MESSAGES ARE RECEIVED BY THE INSTRUMENT PANEL FROM THE VEHICLE POWERTRAIN, THE “CHECK ENGINE” AND/OR “STOP ENGINE” INDICATOR LAMPS ON THE DASH MAY NOT ILLUMINATE AND THE ENGINE MAY ENTER A SAFETY OR SHUTDOWN MODE OF OPERATION.

Consequence: ENGINE SHUTDOWN WOULD RESULT IN LOSS OF VEHICLE PROPULSION OR VEHICLE STALL, EITHER OF WHICH INCREASES THE RISK OF A CRASH.

Remedy: NEW FLYER WILL REPROGRAM THE INSTRUMENT PANEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 9, 2012. NEW FLYER WILL UPLOAD A CORRECTED SOFTWARE VERSION FREE OF CHARGE. OWNERS MAY CONTACT NEW FLYER AT 1-204-934-4876.

Reported: 2012-10-25 (October 25, 2012) · Model years: 2010, 2011

New Flyer is recalling certain model year 2010-2012 transit buses, models C40LF, C40LFR, D35LFR, D40LFR, D60LFR, XD35, XD40, XDE35, XDE40, and XN40. Air pressure may leak from the parking brake chambers causing the parking brakes to drag while the vehicle is driven.

Consequence: If the brakes drag, they may overheat, possibly resulting in a fire.

Remedy: New Flyer will notify the owners and the affected brake chambers will be replaced, free of charge. The recall began on November 13, 2012. Owners may contact New Flyer at 1-204-224-6706 for more information.

Reported: 2016-01-26 (January 26, 2016) · Model years: 2010, 2011, 2012, 2013, 2014

New Flyer Industries, Ltd. (New Flyer) is recalling certain model year 2015 New Flyer MD30, 2012 C35LFR, 2010-2011 D35LFR, NABI 35LFW, 2011 D40LFR, 2010-2012 D60LFR and NABI 31LFW, 2010 C40LF, DE35LF, D40LF, DE40LFA, DE60LFA, GE35LFR and GE40LF, 2009 DE60LF and GE40LFR, 2010-2013 C40LFR, DE60LFR, NABI 416 and NABI 60BRT, 2010-2015 XD35, XDE40, NABI 40LFW and 42BRT, 2011-2015 XD40 and XN40, 2013-2015 XD60, XDE60 and XN35, 2010-2014 XDE35, 2013 XE40, 2012-2015 XN60, equipped with certain Recaro Ergo-M Commercial Bus Driver Seats. The affected seats have J-Brackets that may be missing welds which could allow the seat belt anchorage assembly to separate from the J-Bracket.

Consequence: If the seatbelt anchorage assembly separates from the J-Bracket, the bus driver may not be properly restrained in the event of a crash, increasing their risk of injury.

Remedy: New Flyer will notify owners instructing them to inspect their seats for missing welds. Recaro will supply replacement anchorage brackets and cover the labor to replace them if any welds are missing, free of charge. The recall began on February 4, 2016. Owners may contact New Flyer customer service at 1-204-224-6706, or Recaro customer service at 1-800-873-2276. New Flyer's number for this recall is R16-001.

Reported: 2012-03-26 (March 26, 2012) · Model years: 2011

NEW FLYER IS RECALLING CERTAIN MODEL YEAR 2011 XDE35 AND MODEL YEAR 2010-2012 XDE40 HEAVY DUTY TRANSIT BUSES. OVER TIME PARTICULATE DEBRIS CAN ACCUMULATE IN THE LITHIUM-ION ENERGY STORAGE SYSTEM (ESS), AND IN CONJUNCTION WITH MOISTURE, CAN BREACH THE ELECTRICAL ISOLATION OF THE HIGH VOLTAGE BATTERY PACK. A CONDUCTIVE PATH CAN BE CREATED IF THE ELECTRICAL ISOLATION IS BREACHED AT BOTH ENDS OF THE BATTERY.

Consequence: IF THIS CONDITION OCCURS, UNINTENTIONAL DISCHARGE OF THE BATTERY’S STORED ENERGY CAN RESULT, INCREASING THE RISK OF A FIRE.

Remedy: NEW FLYER WILL NOTIFY OWNERS, AND DEALERS WILL INSTALL AN ELECTRICAL CONTACTOR AND MODIFY THE LI-ION ESS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 5, 2012. OWNERS MAY CONTACT NEW FLYER AT 1-204-224-6706.

Reported: 2014-09-04 (September 4, 2014) · Model years: 2013

New Flyer Industries Ltd. (New Flyer) is recalling certain model year 2013 XD35, XDE35, XE40, and 2013-2014 XD40, XD60, XDE40, XDE60, XN35, XN40, and XN60 transit buses. During installation, the Brake Pedal Mounting Plate may have been clamped between the Brake Pedal Assembly and the Brake Valve Actuator (BVA) resulting in a misalignment and binding of the internal piston in the BVA.

Consequence: The binding of the piston may result in increased resistance while applying the brakes and the potential for brake drag once the brake pedal is released. These conditions increase the risk of a crash.

Remedy: New Flyer will notify owners and will replace the brake pedal mounting plate and the Brake Valve Actuator (BVA), free of charge. The recall began on September 15, 2014. Owners may contact New Flyer customer service at 1-204-934-4876. New Flyer's number for this recall is R14-019.

Reported: 2015-06-01 (June 1, 2015) · Model years: 2013, 2014

New Flyer Industries Ltd. (New Flyer) is recalling certain model year 2013 C40LFR, XE40, XN35, and XN60, 2014 XD35, XDE40, and XT60, 2014-2015 XD60, and XT40, 2013-2014 XDE35, and XN40, and 2015 XDE60 transit buses. These vehicles have door controller assemblies that may have a software defect which can cause the rear passenger doors to open, without warning, when the bus accelerates from a stopped position.

Consequence: If the rear bus door opens while the bus is in motion, there is an increased risk of injury for the passengers.

Remedy: New Flyer will notify owners, and dealers will update the Door Controller Assembly software, free of charge. The recall began on June 24, 2015. Owners may contact New Flyer customer service at 1-204-224-6706. New Flyer's number for this recall is R15-006.

Reported: 2022-12-20 (December 20, 2022) · Model years: 2013, 2014, 2015, 2016, 2017, 2018, 2019, 2020, 2021, 2022

New Flyer of America, Inc. (New Flyer) is recalling certain 2013-2022 XDE35, XDE40, XDE60, XE40, XN40, 2017-2022 XE60, 2014-2022 XT40 and XT60 transit buses equipped with a double tilt steering column. The steering column connection to the upper steering shaft may become loose.

Consequence: A loose steering shaft can cause a loss of steering, increasing the risk of a crash.

Remedy: Dealers will replace the steering column and shaft components, free of charge. Owner notification letters were mailed on February 1, 2023. Owners may contact New Flyer's customer service at 1-204-224-6706. New Flyer's number for this recall is R22-035.

Reported: 2016-04-19 (April 19, 2016) · Model years: 2014

New Flyer Industries Ltd. (New Flyer) is recalling certain model year 2013 C40LFR, XN35, 2014-2016 XD35, XD60, XDE40, 2015-2016 XD40, XDE60, 2014 XDE35, 2013-2015 XE40, 2013-2016 XN40, XN60, and 2014-2015 XT40, and XT60 transit buses. These buses have an Electric Transit Operator (ETO) controller that controls the bus door motor function which may have a software defect which can cause failure of the rear door guide roller linkage resulting in a bus' rear door opening unexpectedly while the bus is in motion.

Consequence: If the rear bus door opens unexpectedly while the bus is in motion, there is an increased risk of injury for the passengers.

Remedy: New Flyer will notify owners, and dealers will install a firmware upgrade, and replace the roller bracket plates, free of charge. The recall began on May 4, 2016. Owners may contact New Flyer customer service at 1-204-224-6706. New Flyer's number for this recall is R16-005.

Reported: 2015-09-04 (September 4, 2015) · Model years: 2015

New Flyer Industries Ltd. (New Flyer) is recalling certain model year 2014-2015 New Flyer XDE40 and XD40, 2014 XD60, XN35 and XN60, 2015 XDE35, and 2013-2015 XN40 transit buses. The affected vehicles may be equipped with an improperly torqued front axle center link retaining clamp on the tie rod. As a result, the tie rod may disconnect, causing a loss of steering.

Consequence: A loss of steering increases the risk of a crash.

Remedy: New Flyer will notify owners, and dealers will inspect the vehicles to verify that the center link retaining clamp is properly torqued. Any components displaying play or movement will be replaced. These repairs will be performed free of charge. The recall began on October 1, 2015. Owners may contact New Flyer customer service at 1-204-224-6706. New Flyer's number for this recall is R15-015.

Reported: 2020-08-06 (August 6, 2020) · Model years: 2016

New Flyer of America Inc. (New Flyer) is recalling certain 2015-2016 XDE60, XDE40 and 2016 XDE35 transit buses equipped with specific Allison Transmission drive units. The pressure switches on these Drive Units may fail, possibly resulting in a loss of drive.

Consequence: A loss of drive can disable the vehicle unexpectedly, increasing the risk of a crash. Additionally, offloading passengers to transfer them to another bus can increase the risk of injury.

Remedy: New Flyer will notify owners, and Allison Transmissions will remove and replace the two C1 and C2 pressure switches on each hybrid drive motor, and also inspect and correct for debris accumulation in the associated pressure switch plumbing, free of charge. The recall began August 17, 2020. Owners may contact New Flyer customer service at 1-204-224-6706. New Flyer's number for this recall is R20-007.

Reported: 2017-08-30 (August 30, 2017) · Model years: 2017

New Flyer Industries Ltd. (New Flyer) is recalling certain 2015-2016 MD30, 2016 MD35, 2017 XD35, XD60, XDE35, XDE40, XDE60, XN35 and 2016-2017 XD40 and XN40 transit buses, equipped with certain Recaro Commercial Bus Driver Seats (models Ergo R, Ergo D, AM71, AM72 and AM80). The seat belt buckle may be stuck in the locked position, preventing the seat belt tongue from being able to be inserted and locked.

Consequence: If the seat belt cannot be latched, the bus may be operated without the seat belt being used, increasing the risk of injury in the event of a crash.

Remedy: New Flyer has notified owners and work with the supplier to replace the buckle housings, free of charge. The recall began September 15, 2017. Owners may contact New Flyer customer service at 1-204-224-6706. New Flyers' number for this recall is R17-017.

Reported: 2018-03-07 (March 7, 2018) · Model years: 2017

New Flyer of America Inc. (New Flyer) is recalling certain 2016-2018 XDE40 and XDE60 and 2017 XDE35 Heavy Duty Urban Transit buses. The plastic end-caps of the drive shaft slip yoke may crack and fail.

Consequence: Failure of the drive shaft end-caps would result in a loss of drive power, increasing the risk of a crash.

Remedy: New Flyer will notify owners, and dealers will inspect the drive shaft slip yoke, replacing any drive shaft that has plastic end-caps on the slip yoke, free of charge. The recall began on March 22, 2018. Owners may contact New Flyer customer service at 1-204-224-6706. New Flyer's number for this recall is R18-002.

Reported: 2018-09-12 (September 12, 2018) · Model years: 2017

New Flyer of America Inc. (New Flyer) is recalling certain 2016-2018 New Flyer XDE60, XDE40, and 2017 XDE35 transit buses, equipped with certain Allison transmission hybrid drive units. The pressure switches on these drive units may fail, possibly resulting in a loss of drive.

Consequence: A loss of drive can disable the vehicle unexpectedly, increasing the risk of a crash.

Remedy: New Flyer will notify owners, and Allison Transmission service centers will replace the C1 and C2 pressure switches, free of charge. The recall began on September 25, 2018. Owners may contact New Flyer customer service at 1-204-224-6706. New Flyer's number for this recall is R18-014.

Reported: 2021-05-18 (May 18, 2021) · Model years: 2017

New Flyer of America, Inc. (New Flyer) is recalling certain 2017-2021 XD40, XD35, 2016-2021 XD60, 2017 XDE35, 2016-2020 XDE40, XDE60 vehicles. The sealing washer may not seat correctly in the pilot bore holes, allowing the high pressure fuel rail assembly to leak.

Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.

Remedy: New Flyer will inspect the rail threads, and replace the rail as necessary, free of charge. Owner notification letters were mailed on June 28, 2021. Owners may contact New Flyer customer service at 1-204-224-6706. New Flyer's number for this recall is R21-008.

Reported: 2025-12-19 (December 19, 2025) · Model years: 2021, 2024, 2025, 2026

New Flyer of America, Inc. (New Flyer) is recalling certain XD35, XDE35, XE35, XN35, XD40, XDE40, XE40, XHE40, XN40, XT40, XD60, XDE60, XE60, XN60, XT60, and XHE60 transit buses. Please refer to New Flyer's recall report for specific model year information. The antilock braking (ABS) and electronic stability control (ESC) module may lose communication and fail without illuminating the warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 121, "Air Brake Systems" and 136, "Electronic Stability Control Systems on Heavy Vehicles."

Consequence: An ABS or ESC warning light that fails to illuminate will not alert the driver to the loss of ABS or ESC, increasing the risk of a crash.

Remedy: New Flyer will update the software, free of charge. Owner notification letters were mailed February 17, 2026. Owners may contact New Flyer's customer service at 1-800-241-2947.

Reported: 2023-10-20 (October 20, 2023) · Model years: 2022

New Flyer of America, Inc. (New Flyer) is recalling certain 2021-2023 XD35, 2022-2023 XD40, XD60, XN35, XN60, 2022 XDE35, and 2021-2022 XE40 transit buses. The Gross Axle Weight Rating (GAWR) and Gross Vehicle Weight Rating (GVWR) listed on the certification labels are incorrect, which can allow the vehicle to be overloaded. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 120, "Wheels and Rims - Other than Passenger Cars."

Consequence: An overloaded vehicle can increase the risk of a crash.

Remedy: New Flyer will provide and/or install new labels, free of charge. Owner notification letters were mailed November 9, 2023. Owners may contact New Flyer customer service at 1-800-241-2947.