U.S. public vehicle records

Newmar DUTCH STAR steering problems

11 complaint narratives mention steering terms.

Key facts

167 owner complaints analyzed

78 distinct recall campaigns

21,000 mi median reported failure mileage

Scope: 1994 to 2023 model years. Data updated: 2026-09-30 (September 30, 2026). 80 complaints include usable failure mileage. View data status.

Steering behavior evidence

11 of 167 complaints match this topic (6.6%). The keyword filter can include complaints that mention a transmission without reporting its failure. View matching rules.

Owner report 11233258 · 2019-07-19 (July 19, 2019)

WHILE ON A DOWNGRADE WITH THE ENGINE BRAKE ENGAGED AND IN 4TH GEAR, AT ABOUT 1900 RPM, THE SIDE MOUNTED FAN EXPLODED SENDING PLASTIC AND METAL PARTS OUT THE REAR OF THE MOTORHOME SHOWERING THE VEHICLE BEING TOWED AND ANOTHER VEHICLE FOLLOWING BEHIND. UPON INSPECTION THE FAN, WHICH IS DRIVEN BY A HYDRAULIC PUMP, WAS SUPPOSED TO BE ATTACHED BY TWO BOLTS TO A CROSS BAR BETWEEN THE RADIATOR AND THE ENGINE. THE BOLT HOLES IN THE HYDRAULIC PUMP WERE ELONGATED AND BOTH BOLTS HAD SHEARED OFF ALLOWING THE PUMP TO FALL DOWN WHICH RESULTED IN THE FAN BLAD…

Owner-reported narrative. 82,000 miles reported. Look up ODI 11233258 at NHTSA ↗

Owner report 874375 · 2000-11-03 (November 3, 2000)

WHILE DRIVING LONG DISTANCE VEHICLE STALLED UNEXPECTEDLY, LOSING ALL POWER STEERING AND BRAKES, WHICH COULD HAVE CAUSEDA CRASH. TOOK TO DEALER. DEALER SAID IT WAS DUE TO THE FUEL FILTER. HOWEVER, THIS PROBLEM OCCURRED 12 TIMES, AND REPLACED FUEL FILTER 10 TIMES, BUT PROBLEM WAS REOCCURRING. *AK THE MOTOR STOPS RUNNING WHILE UNDER MOTION WHEN WATER GETS IN THE FUEL FILTER CAUSING BRAKE AND STEERING LOSS. IT TAKES ONLY A TEASPOON OF WATER TO CLOG THIS FILTER. *YH

Owner-reported narrative. Look up ODI 874375 at NHTSA ↗

Owner report 10292361 · 2009-11-16 (November 16, 2009)

TL*THE CONTACT OWNS A 2000 NEWMAR DUTCH STAR RV TRAILER. HE REPLACED THE TIE ROD PARTS 16 TIMES THE BALL JOINT COMPONENTS WERE REPLACED 8 TIMES IN A NINE YEARS WHICH ARE ALL A PART OF THE STEERING FRONT SUSPENSION. THE CONTACT WAS ONLY REQUIRED TO PAY FOR LABOR. THE MANUFACTURER CONFIRMED THAT THE PARTS ARE WERE REPLACED DUE TO NORMAL WEAR AND TEAR AND WERE NOT DEFECTIVE. THE PARTS ARE NOT RELATED TO A RECALL OR WARRANTY. THE FAILURE MILEAGE WAS 43,000 AND THE CURRENT MILEAGE IS 64,000. UPDATED 12/10/09. *LJ THE CONSUMER STATED HE DISCOVERED T…

Owner-reported narrative. 43,000 miles reported. Look up ODI 10292361 at NHTSA ↗

Owner report 10014396 · 2003-04-15 (April 15, 2003)

WHILE DRIVING THROUGH STOP AND GO TRAFFIC, I NOTICED THAT ONE OR BOTH FRONT BRAKES WERE DRAGGING. THIS WAS EVIDENT BECAUSE THE VEHICLE ACCELERATION WAS REDUCED, THERE WAS A SMELL OF HOT BRAKES, THE VEHICLE DID NOT ROLL WHEN ON A HILL WITH THE BRAKES RELEASED, THERE WAS A VIBRATION IN THE STEERING WHEEL, AND THERE WAS REDUCED FREE PLAY IN THE BRAKE PEDAL. I PULLED OVER AND CHECKED THE FRONT BRAKES, THE RIGHT ONE WAS VERY HOT. I TAPPED ON THE CALIPER WITH A HITCH PIN THAT WAS AVAILABLE, AFTER WHICH THE VEHICLE WAS DRIVABLE. I DROVE THE VEHICL…

Owner-reported narrative. 4,000 miles reported. Look up ODI 10014396 at NHTSA ↗

Owner report 10082900 · 2004-08-20 (August 20, 2004)

THE BUSHING BETWEEN THE POWER STEERING AND AIR COMPRESSOR CONTINUED TO FAIL. WHEN THE BUSHING FAILED, THE ENGINE COOLANT NO LONGER WORKED. IF THE ENGINE OVERHEATED, IT WOULD ENGINE SHUT OFF AND NO STEERING WOULD BE AVAILABLE. *AK *SC THE CONSUMER HAD PROBLEMS WITH THE REAR BRAKES, WHICH TOOK 3-TO 4 SERVICE VISITS TO GET IT FIXED. THERE WAS A RECALL REGARDING THE BRAKE ISSUE. RECALL#03V064000) *JB

Owner-reported narrative. 15,500 miles reported. Look up ODI 10082900 at NHTSA ↗

Explore the data

Vehicle analysis explorer

Inspect model-year patterns, reported mileage, monthly activity and the evidence behind each signal.

Data completeness

167 unique complaints in this selection. Analysis snapshot: 2026-09-30.

47.9%Usable mileage80 / 167 records

94.0%Valid incident date157 / 167 records

100.0%Valid filing date167 / 167 records

94.0%Ordered incident and filing dates157 / 167 records

Missing, zero and invalid mileage is excluded. Dates after the snapshot are excluded. Examples are limited selections, not a representative sample.

Problems by model year

Model-wide comparison of the eight most reported components across the model. Cells show counts and shares within each model year. Open a cell for source examples.

From model yearThrough model year

Component complaint heatmap
Component	2009	2010	2011	2012	2013	2014	2015	2016	2017	2018	2019	2020	2021	2022	2023
Tires	0Unavailable No examples available for this selection.	0Unavailable No examples available for this selection.	0Unavailable No examples available for this selection.	0Unavailable No examples available for this selection.	0Unavailable No examples available for this selection.	00.0% No examples available for this selection.	00.0% No examples available for this selection.	00.0% No examples available for this selection.	00.0% No examples available for this selection.	00.0% No examples available for this selection.	00.0% No examples available for this selection.	00.0% No examples available for this selection.	00.0% No examples available for this selection.	0Unavailable No examples available for this selection.	00.0% No examples available for this selection.
Engine	0Unavailable No examples available for this selection.	0Unavailable No examples available for this selection.	0Unavailable No examples available for this selection.	0Unavailable No examples available for this selection.	0Unavailable No examples available for this selection.	150.0% ODI 11425314 DEF System Failure Look up ODI 11425314 at NHTSA ↗	120.0% ODI 11435626 I was driving home this weekend in my motorhome and noticed smoke coming out of rear of vehicle. I thought we were on fire. Fortunately I was able to get off the road and no injuries occurred. However, there will be many injuries if this problem is not recalled. The vehicle has a Cummins ISL Diesel motor. Vehicle has 33K miles. The #1 fuel injector line fails. If you look online this has happened many of times. Cummins also has a TSB for failure. Also, the "revised" part comes with a new bracket to prevent future failure. So Cummins is aware of… Look up ODI 11435626 at NHTSA ↗	00.0% No examples available for this selection.	350.0% ODI 11354123 · 11,000 mi WE HAVE HAD TWO DIESEL EXHAUST FLUID (DEF) HEAD FAILURES THAT HAVE REQUIRED REPLACEMENT OF THE DEF HEAD UNIT. THE FIRST SITUATION RESULTED IN A DERATING OF THE ENGINE, LIMITING OUR SPEED TO 4 OR 5 MPH WHILE ON THE INTERSTATE. THE VEHICLE HAD TO BE TOWED 200 MILES TO A SERVICE CENTER, THEN IT TOOK A WEEK TO OBTAIN REPLACEMENT PARTS. THE SECOND SITUATION HAPPENED WITHIN 5 MILES OF A SERVICE CENTER AND WE WERE FORTUNATE ENOUGH TO BE ABLE TO MAKE IT TO THE SERVICE CENTER. HOWEVER, WE ARE SEEING HUNDREDS OF SIMILAR SITUATIONS BEING POSTED TO RV … Look up ODI 11354123 at NHTSA ↗	850.0% ODI 11354474 · 10,000 mi DEF SYSTEM FOR DIESEL ENGINE STARTED TO FAIL CAUSING REDUCTION IN PERFORMANCE OF MOTOR HOME. IF I HAD NOT BEEN ABLE TO GET DIRECTLY TO A FREIGHTLINER SERVICE CENTER, I WOULD HAVE ENDED UP ON THE INTERSTATE ABLE TO GO ONLY FIVE MILES PER HOUR AND NEEDING TO BE TOWED. THIS IS AN ON GOING KNOWN PROBLEM WITH THESE ENGINES MANUFACTURED BY CUMMINS. THIS PARTICULAR PART IS FAILING ON A REGULAR BASIS ACROSS MANY CHASSIS MAKERS CAUSING A POTENTIAL DANGER TO THE OWNERS OF THESE COACHES. THE PARTICULAR PART IS CALLED A DEF HEAD THAT REGULATES AND METERS T… Look up ODI 11354474 at NHTSA ↗	521.7% ODI 11354120 · 4,345 mi WHILE DRIVING, THE CHECK ENGINE LIGHT CAME ON. MOMENTS LATER, ANOTHER CHECK ENGINE LIGHT CAME ON AND THE DEF GAUGE WENT FROM F TO E AND TURNED RED WITH AN ALARM. WE WERE ABOUT 5 MILES FROM OUR DESTINATION. I CALLED NEWMAR WHO PUT SPARTAN ON THE PHONE. IT WAS THE DEF SENSOR. I WAS ASKED TO DRIVE ONE HOUR AWAY ON A TWO LANE ROAD TO A DEALER. I REFUSED. WE EXTENDED OUR STAY BY ONE WEEK UNTIL THE PART CAME IN (BACK ORDERED). MOBILE TECHNICIANS CAME AND INSTALLED THE PART. I ASKED IF I SHOULD HAVE A SPARE SENSOR... JUST IN CASE...AND WAS TO… Look up ODI 11354120 at NHTSA ↗	00.0% No examples available for this selection.	116.7% ODI 11424982 I recently purchased a 2021 Newmar Dutchstar Motorhome, and took delivery recently. The Diesel Exhaust Fluid (DEF) sensor failed in less than 3,000 miles. As a newbie in the motorhome world, I was stunned and very disappointed that this failure occurred so quickly, and also with the ramifications of the failure. When DEF sensors fail the engine can go into derate state which can cause my coach to move at a maximum of 5 mph in less than a couple hundred miles, and then the engine SHUTS DOWN. I contacted Spartan motors, the manufacturer of my ch… Look up ODI 11424982 at NHTSA ↗	0Unavailable No examples available for this selection.	00.0% No examples available for this selection.
Unknown Or Other	0Unavailable No examples available for this selection.	0Unavailable No examples available for this selection.	0Unavailable No examples available for this selection.	0Unavailable No examples available for this selection.	0Unavailable No examples available for this selection.	00.0% No examples available for this selection.	120.0% ODI 11084662 WHEN I ENTER MY VIN, YOUR SITE SAYS THAT "ONE OR MORE PARAMETERS ARE INVALID". I'VE USED THE SITE BEFORE, AND THE VIN IS VALID. WHEN I PUT IN THE VIN, IT SAYS 17/17 AT THE END (INDICATING THAT ALL 17 CHARACTERS WERE ENTERED). Look up ODI 11084662 at NHTSA ↗	125.0% ODI 10928890 · 10,000 mi I HAVE A 2016 NEWMAR DUTCH STAR MOTOR HOME MODEL 4018. IT'S A 40 FT LONG DIESEL PUSHER ON A FREIGHTLINER CHASSIS WITH TOYAL WEIGHT OF 39600 LBS. THE PROBLEM IS POTENTIAL OVERLOADING OF THE FRONT TIRES DUE TO WEIGHT. THE MOTOR HOME WAS JUST WEIGHED AT THE NEWMAR CORP. FACTORY AND THE WEIGHT ON THE FRONT LEFT TIRE WITHOUT PASSENGERS WAS 7355 LBS. THE FRONT TIRES ON THIS VEHICLE ARE MICHELIN 305/70R22.5 LRL SERIES XRV. THEY HAVE A MAXIMUM LOAD RATING OF 7830 LBS.. ADDING THE WEIGHT OF A PASSENGER AND I SITTING IN THE TWO FRONT SEATS I ESTI… Look up ODI 10928890 at NHTSA ↗	116.7% ODI 11384355 · 15,000 mi I OWN A 2017 NEWMAR DUTCH STAR MOTOR HOME ON A FREIGHTLINER CHASSIS. THE DIESEL EXHAUST FLUID (DEF) SENSOR (DEF HEAD) HAS FAILED TWICE. THE FIRST FAILED AT 14,795 MILES AND WAS REPLACED ON 9/24/18. THAT HEAD LASTED ANOTHER 15,000 MILES AND FAILED AT 31,218 AND WAS REPLACED ON 11/25/2020. EACH HEAD LASTED ABOUT 15,000 MILES OR 2 YEARS. THE PART IS MADE BY SHAW DEVELOPMENT WHICH HAS NOT ANSWERED REPEATED ATTEMPTS FOR INFORMATION. AS PART OF THE EMISSIONS SYSTEM, FREIGHTLINER HAS REPLACED BOTH HEADS UNDER THE 5 YEAR FEDERALLY MANDATED WAR… Look up ODI 11384355 at NHTSA ↗	318.8% ODI 11425316 Since purchasing this RV new, I have had the DEF Head fail twice. 1st time was Sep 2019 with a mileage of 14066 and the 2nd time was April 2021 with a mileage of 16018. Both times DEF Header Assemblies were replaced. When these fail the motor can de-rate at any time. Very dangerous when traveling down the highway. Both times the low DEF warning and check engine lights came on. Look up ODI 11425316 at NHTSA ↗	521.7% ODI 11311651 · 6,000 mi LOCKED ENTRY DOOR POPS OPEN WHILE DRIVING. IT HAPPENS ON SMOOTH ROADS, DOESN'T HAVE TO BE A BUMPY ROAD. RV IS AT KNOXVILLE DEALER NOW AND THEY SAY THERE'S NOTHING WRONG WITH DOOR. THIS HAS HAPPENED NUMEROUS TIMES; WE TIE THE DOOR SHUT NOW. Look up ODI 11311651 at NHTSA ↗	233.3% ODI 11338543 · 277 mi FACTORY INSTALLED TIRE PRESSURE MONITORING SYSTEM GIVES FALSE PRESSURE AND TEMPERATURE READINGS WHILE DRIVING. THIS IS A SAFETY CONCERN WHILE DRIVING.DTJB Look up ODI 11338543 at NHTSA ↗	00.0% No examples available for this selection.	0Unavailable No examples available for this selection.	00.0% No examples available for this selection.
Electrical System	0Unavailable No examples available for this selection.	0Unavailable No examples available for this selection.	0Unavailable No examples available for this selection.	0Unavailable No examples available for this selection.	0Unavailable No examples available for this selection.	00.0% No examples available for this selection.	240.0% ODI 10735331 · 2,235 mi VEHICLE WAS SITTING IN DEALER'S LOT AND CAUGHT FIRE IN THE MIDDLE OF THE NIGHT. INVESTIGATION BY FIRE MARSHALL, AND SUBSEQUENT INSURANCE ADJUSTERS BELIEVE THIS LOSS TO BE DUE TO AN ELECTRICAL PROBLEM IN THE COACH. THE COACH HAS BEEN DEEMED A TOTAL LOSS...UPDATED 10-20/15BF UPDATED 12/4/2017CN Look up ODI 10735331 at NHTSA ↗	00.0% No examples available for this selection.	00.0% No examples available for this selection.	00.0% No examples available for this selection.	313.0% ODI 11321477 THE INSTRUMENT LIGHT PANEL (OPTIVIEW) DOES NOT DIM ENOUGH AND IS TOO BRIGHT AT NIGHT MAKING IT VERY DIFFICULT TO SEE OUTSIDE THE VEHICLE WHEN DRIVING AT NIGHT. ON A DARK RAINY NIGHT THE GLARE FROM THE INSTRUMENT PANEL MAKES FOR DANGEROUS DRIVING CONDITIONS. MY COMPLAINT TO NEWMAR IN APRIL 2019 WAS DEFERRED TO FREIGHTLINER. NOVEMBER OF 2019 FREIGHTLINER SENT TWO TECHNICIANS TO MY HOME WHO SPENT A COUPLE OF HOURS DIAGNOSING AND TAKING PICTURES OF THE PROBLEM. THEY CONCLUDED THE BRIGHTNESS LEVEL OF THE INSTRUMENT PANEL DID DIM IN RESPONSE TO TH… Look up ODI 11321477 at NHTSA ↗	00.0% No examples available for this selection.	00.0% No examples available for this selection.	0Unavailable No examples available for this selection.	150.0% ODI 11506852 The 2023 Newmar Dutch Star 4326 with a Freightliner Custom Chassis was built without an exterior temperature gauge. This is the first vehicle I've seen like this in many years. I'm on our first trip with my family onboard and we're driving thru the NC mountains in a wintery mix with temperatures varying from above to below freezing. I'm very nervous not knowing when the roads will begin to ice over on treacherous roads. I've discussed with Newmar and Freightliner and they both just say they don't know why it's not there and that they cannot add… Look up ODI 11506852 at NHTSA ↗
Equipment:Recreational Vehicle/Trailer	0Unavailable No examples available for this selection.	0Unavailable No examples available for this selection.	0Unavailable No examples available for this selection.	0Unavailable No examples available for this selection.	0Unavailable No examples available for this selection.	00.0% No examples available for this selection.	00.0% No examples available for this selection.	125.0% ODI 11723800 See attached document for complaint. Look up ODI 11723800 at NHTSA ↗	00.0% No examples available for this selection.	00.0% No examples available for this selection.	00.0% No examples available for this selection.	00.0% No examples available for this selection.	00.0% No examples available for this selection.	0Unavailable No examples available for this selection.	00.0% No examples available for this selection.
Exterior Lighting	0Unavailable No examples available for this selection.	0Unavailable No examples available for this selection.	0Unavailable No examples available for this selection.	0Unavailable No examples available for this selection.	0Unavailable No examples available for this selection.	00.0% No examples available for this selection.	00.0% No examples available for this selection.	00.0% No examples available for this selection.	00.0% No examples available for this selection.	00.0% No examples available for this selection.	834.8% ODI 11155595 · 2,200 mi THE DIGITAL DASH IS TOO BRIGHT FOR NIGHT TIME DRIVING. THE SCREEN HAS THE ABILITY TO BE LOWERED, BUT EVEN AT ITS LOWEST SETTING, IT IS FAR TOO BRIGHT. IT CAUSES LOSS OF NIGHT VISION, AND THE INABILITY TO SAFELY DRIVE. THE ONLY CORRECTION THAT CAN BE MADE IS TO COVER THE SCREEN, LOSING ALL ABILITY TO SEE IMPORTANT GAUGES.DTJB Look up ODI 11155595 at NHTSA ↗	00.0% No examples available for this selection.	00.0% No examples available for this selection.	0Unavailable No examples available for this selection.	00.0% No examples available for this selection.
Visibility/Wiper	0Unavailable No examples available for this selection.	0Unavailable No examples available for this selection.	0Unavailable No examples available for this selection.	0Unavailable No examples available for this selection.	0Unavailable No examples available for this selection.	150.0% ODI 11430662 Driver side and Passenger side windows have faulty seals and in temperature conditions below 40 degrees and rainy conditions, these side windows fog up heavily. This is not covered on any warranty or recall. On most of the social media pages for Newmar and RV owners, this is a known issue with the windows on these vehicles and hundreds of owners are having to replace these windows spending thousands of dollars to ensure they are able to see out of these important windows to view their side mirrors. We are from Florida, purchased the RV used … Look up ODI 11430662 at NHTSA ↗	120.0% ODI 11131473 · 24,569 mi THE VEHICLE WAS DRIVING DOWN THE ROAD. THE DRIVER SIDE WINDSHIELD WIPER WHEN ENGAGED AT LOW MEDIUM OR HIGH SPEED BUT IN THE CASE IT FAILED AT LOW SPEED. THE WIPER ON DRIVER SIDE GOES OFF WINDSHIELD TO SIDE MIRROR AND FAILS. DT CONSUMER STATED PRODUCT MALFUNCTIONED DRIVING DOWN THE INTERSTATE. UPDATED 10/9/18JB Look up ODI 11131473 at NHTSA ↗	250.0% ODI 11455299 While driving on I-75 in the Venice, Florida area, the lower half of the window fell off our motorcoach. The window was located on the passenger side about 22 ft from the front. I have learned this morning that many reports of this continue being reported on windows made by Hehr, which is now owned by Lippert. We are so very thankful it did not hit the vehicle behind us. Look up ODI 11455299 at NHTSA ↗	00.0% No examples available for this selection.	212.5% ODI 11128274 · 6,500 mi THE DRIVER'S WINDSHEILD WIPER DOES NOT CONTACT THE GLASS EXCEPT AT THE VERY TOP FOR THE LAST 30% OF THE STROKE LEAVEING THE PORTION DIRECTLY IN FRONT OF THE DRIVER WITHOUT THE NEEDED VIEW. NEWMAR REPLACED THE WIPER BLADE, BUT STILL HAVE THE PROBLEM. Look up ODI 11128274 at NHTSA ↗	14.3% ODI 11508791 Multiple double pane windows are fogging. The driver’s side window fogging between the double pane glass, is causing visibility problem’s creating a safety hazard. Look up ODI 11508791 at NHTSA ↗	116.7% ODI 11636178 Passenger entry door seal has failed and window is fogged making lane changing or viewing very difficult and unsafe. I have tried to contact Newmar and their reply was giving me a statement that my coach is out of warranty and I need to contact a 3rd party vendor for replacement at my cost. I would think a window separation would be a concern for Newmar Corp. I have read many other complaints from Newmar owners. Look up ODI 11636178 at NHTSA ↗	00.0% No examples available for this selection.	0Unavailable No examples available for this selection.	00.0% No examples available for this selection.
Electrical System: Instrument Cluster/Panel	0Unavailable No examples available for this selection.	0Unavailable No examples available for this selection.	0Unavailable No examples available for this selection.	0Unavailable No examples available for this selection.	0Unavailable No examples available for this selection.	00.0% No examples available for this selection.	00.0% No examples available for this selection.	00.0% No examples available for this selection.	00.0% No examples available for this selection.	00.0% No examples available for this selection.	313.0% ODI 11603226 The Freightliner instrument cluster (ICU) screen delaminates and makes it difficult to read the gauges. This issue appears to happen with a lot of 2019 models. Freighter refuses to assist and the cost is $5700 for the cluster + labor. Look up ODI 11603226 at NHTSA ↗	350.0% ODI 11387122 · 1,250 mi I WAS UNABLE TO DIM THE DASH CLUSTER LIGHTS BELOW 100% BRIGHTNESS USING THE MANUFACTURER SUPPLIED DIMMING CONTROLS. I ATTEMPTED ADJUSTMENTS WHILE DRIVING AT NIGHT ON A FREEWAY WITH THE HEADLIGHTS ON, WHILE PARKED IN A REST AREA WITH THE ENGINE RUNNING AND HEADLIGHTS ON AND OFF, AND WITH THE IGNITION ON ACCESSORY WITHOUT THE ENGINE RUNNING. THIS CREATES DANGEROUS BRIGHT GLARE TO THE DRIVERS EYES MAKING DRIVING VERY DIFFICULT AT NIGHT. Look up ODI 11387122 at NHTSA ↗	00.0% No examples available for this selection.	0Unavailable No examples available for this selection.	00.0% No examples available for this selection.

Darker cells indicate a larger share of submitted complaints. Components overlap. This measures complaint composition, not failure probability.

Failure mileage by component

Median and middle 50% of usable owner-reported mileages. Ranges require at least five records.

Component failure mileage distribution
Component	Mileage range (25th–75th percentile)	Median	Usable records	Examples
Tires	18,750–32,575 mi	24,045 mi	12	ODI 10500087 · 50,000 mi BF GOODRICH COMMERCIAL T/A 235 85 16 DOT ANOR XXXX XXXX LESS THAN 500 MILES OF USE THE TREAD SEPARATED FROM TIRE IN PIECES HITTING AND DAMAGING DUMP TANKS AND PIPING. MICHELIN RECALLED DOT BFOR JD11 XXXX THAT'S ON MY RV BUT ITS WASN'T THE ONE THAT BLEW ON MY RV. I BELIEVE THERE ARE SOME OTHER DOT' SEQUENCES THAT SHOULD BE RECALLED. TR UPDATED 4/26/13 CN Look up ODI 10500087 at NHTSA ↗ ODI 10065234 · 64,383 mi CONSUMER WAS UNABLE TO HAVE THE TIRE RECALL 04V037000 REPAIRED BECAUSE WHEN HE CALLED THE MANUFACTURER'S TELEPHONE NUMBER THERE WAS A RECORDING THAT GAVE ANOTHER TELEPHONE NUMBER TO CALL. WHEN THE CONSUMER CALLED THE OTHER NUMBER IT CONNECTED HIM TO A FLOWER SHOP. ALSO, CONSUMER HAD BEEN TRYING FOR A MONTH TO CALL THE DEALER TO HAVE RECALL REPAIRS PERFORMED, BUT WAS UNABLE TO OBTAIN THE DEALERS TELEPHONE NUMBER. AK Look up ODI 10065234 at NHTSA ↗ ODI 10064993 · 11,000 mi 3 TIRES WERE REPLACED WITHIN 11,000 MILES. SIDEWALL BLEW OUT ON ALL THREE TIRES. AS A RESULT, CONSUMER ALMOST HAD AN ACCIDENT.AK Look up ODI 10064993 at NHTSA ↗
Engine	4,836–13,554 mi	7,705 mi	8	ODI 11233258 · 82,000 mi WHILE ON A DOWNGRADE WITH THE ENGINE BRAKE ENGAGED AND IN 4TH GEAR, AT ABOUT 1900 RPM, THE SIDE MOUNTED FAN EXPLODED SENDING PLASTIC AND METAL PARTS OUT THE REAR OF THE MOTORHOME SHOWERING THE VEHICLE BEING TOWED AND ANOTHER VEHICLE FOLLOWING BEHIND. UPON INSPECTION THE FAN, WHICH IS DRIVEN BY A HYDRAULIC PUMP, WAS SUPPOSED TO BE ATTACHED BY TWO BOLTS TO A CROSS BAR BETWEEN THE RADIATOR AND THE ENGINE. THE BOLT HOLES IN THE HYDRAULIC PUMP WERE ELONGATED AND BOTH BOLTS HAD SHEARED OFF ALLOWING THE PUMP TO FALL DOWN WHICH RESULTED IN THE FAN BLAD… Look up ODI 11233258 at NHTSA ↗ ODI 11354123 · 11,000 mi WE HAVE HAD TWO DIESEL EXHAUST FLUID (DEF) HEAD FAILURES THAT HAVE REQUIRED REPLACEMENT OF THE DEF HEAD UNIT. THE FIRST SITUATION RESULTED IN A DERATING OF THE ENGINE, LIMITING OUR SPEED TO 4 OR 5 MPH WHILE ON THE INTERSTATE. THE VEHICLE HAD TO BE TOWED 200 MILES TO A SERVICE CENTER, THEN IT TOOK A WEEK TO OBTAIN REPLACEMENT PARTS. THE SECOND SITUATION HAPPENED WITHIN 5 MILES OF A SERVICE CENTER AND WE WERE FORTUNATE ENOUGH TO BE ABLE TO MAKE IT TO THE SERVICE CENTER. HOWEVER, WE ARE SEEING HUNDREDS OF SIMILAR SITUATIONS BEING POSTED TO RV … Look up ODI 11354123 at NHTSA ↗ ODI 11415723 · 21,215 mi RV WENT INTO 5MPH DERATE DUE TO DEF HEADER MALFUNCTION. I WAS VERY LUCKY TO BE IN AN RV PARK, HOWEVER THERE IS NO WAY TO REPLACE THE DEF HEADER WITHOUT RAISING THE RV (DUE TO THE LOCATION OF THE TANK), SO IT COULDN'T BE REPLACED THERE. I HAD AN APPOINTMENT TO REPLACE THE DEF HEADER AT FREIGHTLINER OF HOUSTON, DUE TO THE WARNING LIGHTS. HOWEVER WHEN I STARTED TO DRIVE THERE FOR THE APPOINTMENT, I FOUND THE RV WOULD NOT GO OVER 5MPH. SINCE THE DEALER WAS 60 MILES AWAY (AND IT WAS THE NEAREST ONE), THERE WAS NO WAY I COULD MAKE IT. Look up ODI 11415723 at NHTSA ↗
Unknown Or Other	3,000–13,750 mi	8,000 mi	6	ODI 10366753 · 23,427 mi THIS IS 2ND RECALL FOR NORCOLD REFRIGERATOR IN OUR RV. RV IS IN STORAGE, BUILDING AND USED TO LIVE IN. FROZEN FOOD IN FREEZER, AND NO WHERE ELSE TO STORE IT. IT IS OVER 200 MILES TO CLOSEST REPAIR PLACE, AND INSURANCE ON RV IS FOR STORAGE ONLY AND NOT DRIVING. WILL COST OVER 200 DOLLARS FOR ROUND TRIP TO ACCOMPLISH DEFECTIVE NORCOLD PRODUCT. INSURANCE FOR RV TO MAKE TRIP WILL BE EXTRA AND OVER THE 200 DOLLAR AMOUNT. IF TURN OFF REFRIG, FREEZER WILL LOSE OVER $350 PERISHABLE ITEMS. WE ARE RETIRED, HAVE SOME DISABILITY, AND ON LIMITED INCOME. … Look up ODI 10366753 at NHTSA ↗ ODI 10928890 · 10,000 mi I HAVE A 2016 NEWMAR DUTCH STAR MOTOR HOME MODEL 4018. IT'S A 40 FT LONG DIESEL PUSHER ON A FREIGHTLINER CHASSIS WITH TOYAL WEIGHT OF 39600 LBS. THE PROBLEM IS POTENTIAL OVERLOADING OF THE FRONT TIRES DUE TO WEIGHT. THE MOTOR HOME WAS JUST WEIGHED AT THE NEWMAR CORP. FACTORY AND THE WEIGHT ON THE FRONT LEFT TIRE WITHOUT PASSENGERS WAS 7355 LBS. THE FRONT TIRES ON THIS VEHICLE ARE MICHELIN 305/70R22.5 LRL SERIES XRV. THEY HAVE A MAXIMUM LOAD RATING OF 7830 LBS.. ADDING THE WEIGHT OF A PASSENGER AND I SITTING IN THE TWO FRONT SEATS I ESTI… Look up ODI 10928890 at NHTSA ↗ ODI 11384355 · 15,000 mi I OWN A 2017 NEWMAR DUTCH STAR MOTOR HOME ON A FREIGHTLINER CHASSIS. THE DIESEL EXHAUST FLUID (DEF) SENSOR (DEF HEAD) HAS FAILED TWICE. THE FIRST FAILED AT 14,795 MILES AND WAS REPLACED ON 9/24/18. THAT HEAD LASTED ANOTHER 15,000 MILES AND FAILED AT 31,218 AND WAS REPLACED ON 11/25/2020. EACH HEAD LASTED ABOUT 15,000 MILES OR 2 YEARS. THE PART IS MADE BY SHAW DEVELOPMENT WHICH HAS NOT ANSWERED REPEATED ATTEMPTS FOR INFORMATION. AS PART OF THE EMISSIONS SYSTEM, FREIGHTLINER HAS REPLACED BOTH HEADS UNDER THE 5 YEAR FEDERALLY MANDATED WAR… Look up ODI 11384355 at NHTSA ↗
Electrical System	3,500–21,000 mi	6,970 mi	5	ODI 10154219 · 6,970 mi REAR SLIDE ON 2005 NEWMAR DUTCH STAR RETRACTS WITHOUT WARNING. THIS HAS OCCURRED TWICE. LUCKILY WE OR OUR PETS WERE NOT INJURED. THIS OCCURRED WHILE VEHICLE WAS PARKED, AUTOMATIC JACKS WERE DEPLOYED, BUT HAVE NEVER WORKED PROPERLY SINCE THE UNIT WAS PURCHASED NEW IN AUG 2005. JB Look up ODI 10154219 at NHTSA ↗ ODI 10240210 · 21,000 mi BUSSMAN BOX IS MOUNTED ON FLOOR OF COMPARTMENT BELOW BATTERY COMPARTMENT. WATER ENTERING THE COMPARTMENT CAN POOL ON THE FLOOR AND FLOOD THE BUSSMAN BOX, RESULTING IN AN ELECTRICAL FIRE. IF THE BUSSMAN BOX IS SHORT CIRCUITED THE VEHICLE ENGINE CANNOT BE STARTED AND MAY STOP ENTIRELY. TR Look up ODI 10240210 at NHTSA ↗ ODI 10454456 · 32,000 mi I OWN A 1998 NEWMAR DUTCHSTAR ON A FREIGHTLINER CHASSIS WITH A 3126 CAT MOTOR. THE ISSUES OUTLINED BELOW BEGAN WHEN LOWERING THE JACKS. THEN SPREAD TO LOW SPEED RPMS AT DIFFERENT PERIODS OF OPERATION, CAUSING A TOTAL ELECTRICAL SYSTEM SHUT DOWN, (TO INCLUDE LIGHTS, POWER STEERING, POWER BRAKES, ENGINE, A/C, RADIO, ETC), THUS CAUSING A UNSAFE OPERATING CONDITION. OVER TIME THE ISSUE BEGAN DURING DIFFERENT OPERATIONAL PERIODS WHEN DIFFERENT ELECTRICAL DRAWS WERE PRESENT (SUCH AS WHILE USING LIGHTS, DEFROST AND WIPERS, ENGINE FAN COMING ON, ETC.).… Look up ODI 10454456 at NHTSA ↗
Equipment:Recreational Vehicle/Trailer	21,000–29,923 mi	23,427 mi	5	ODI 10254975 · 21,000 mi TLTHE CONTACT OWNS A 2000 NEWMAR DUTCHSTAR RV. THE VEHICLE HAS A DOMETIC REFRIGERATOR, MODEL NDR1062. THE CONTACT STATED THAT THE REFRIGERATOR IN THE RV COMPLETELY FAILED. HE TOOK THE VEHICLE TO A LOCAL REPAIR SHOP AND THE REFRIGERATOR WAS REPLACED AT THE COST OF $200.00. ONE YEAR LATER, HE RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 07V075000 (EQUIPMENT:RECREATIONAL VEHICLE). THE MANUFACTURER STATED THAT BECAUSE THE UNIT WAS NOT REPAIRED BEFORE MARCH OF 2007, THE CONTACT WOULD NOT BE ENTITLED TO REIMBURSEMENT. THE FAILURE AND … Look up ODI 10254975 at NHTSA ↗ ODI 10304750 · 50,000 mi TLTHE CONTACT OWNS A 2001 NEWMAR DUTCHSTAR RV. THE RV HAS A DOMETIC REFRIGERATOR, MODEL NUMBER NDR1062. THE CONTACT NOTICED A YELLOW RESIDUE LEAKING FROM THE REFRIGERATOR AND SMELLED AMMONIA. IN ADDITION, SMOKE EXPELLED INSIDE OF THE VEHICLE. THE RV WAS TAKEN TO TWO INDEPENDENT DEALERS WHO STATED THE REFRIGERATOR WAS UNABLE TO BE REPAIRED FOR THE MALFUNCTIONS AND REQUIRED REPLACEMENT. THE CONTACT PURCHASED A NEW REFRIGERATOR UNAWARE OF THE RECALL UNDER NHTSA CAMPAIGN ID NUMBER 08E032000 (EQUIPMENT). DOMETIC REFUSED TO REIMBURSE FOR TH… Look up ODI 10304750 at NHTSA ↗ ODI 10236928 · 29,923 mi OUR DOMETIC REFRIGERATOR FOR OUR RV MODEL#NDR1062 S/N24200040 LEAKED ALL OF ITS COOLANT FROM A FAILURE IN THE COOLING TUBES AND DOMETIC REFUSES TO REPAIR THE LEAK - DID NOT ADMIT ON PHONE THAT THERE WAS ANY FATIGUE IN THE WELD AND NOW WE FIND THERE IS A RECALL ON THIS REFRIGERATOR DUE TO WELD FATIGUE BUT THEY FAIL TO REPAIR OUR REFRIGERATOR AT THEIR COST. *TR Look up ODI 10236928 at NHTSA ↗
Exterior Lighting	800–2,200 mi	1,000 mi	5	ODI 10279239 · 25,000 mi DURING OUR PRETRIP INSPECTION WE ALWAYS CHECK ALL LIGHTS PRIOR TO DRIVING THE VEHICLE. THE CENTER HIGH MOUNTED BRAKE LIGHT LED ELEMENTS RANDOMLY FAIL TO LIGHT. SOMETIMES THE ENTIRE CENTER HIGH MOUNTED BRAKE LIGHT HAS FAILED TO ILLUMINATE. TR Look up ODI 10279239 at NHTSA ↗ ODI 11155595 · 2,200 mi THE DIGITAL DASH IS TOO BRIGHT FOR NIGHT TIME DRIVING. THE SCREEN HAS THE ABILITY TO BE LOWERED, BUT EVEN AT ITS LOWEST SETTING, IT IS FAR TOO BRIGHT. IT CAUSES LOSS OF NIGHT VISION, AND THE INABILITY TO SAFELY DRIVE. THE ONLY CORRECTION THAT CAN BE MADE IS TO COVER THE SCREEN, LOSING ALL ABILITY TO SEE IMPORTANT GAUGES.DT*JB Look up ODI 11155595 at NHTSA ↗ ODI 11155746 · 800 mi THE DIGITAL DASH IN MY MOTORHOME IS TOO BRIGHT AT NIGHT. IT IS IMPOSSIBLE TO DIM THE PANEL SUFFICIENTLY TO REDUCE GLARE AND REFLECTION FROM THE DASHBOARD ONTO THE WINDSHIELD AND SIDE WINDOWS. THIS IS A SUBSTANTIAL SAFETY HAZARD AS IT PREVENTS BEING ABLE TO SEE ADEQUATELY OUTSIDE THE RV AT DUSK AND AT NIGHT. THIS AFFECTS LANE CHANGES, THE ABILITY TO SEE THE MIRRORS WHILE BACKING AND OTHER OPERATIONAL FACETS. EVEN WHILE STANDING STILL THE VISIBILITY TO OUTSIDE IS POOR. THE INSTRUMENT PANEL SHOULD BE ABLE TO DIM ALL THE WAY TO DARK OR AT LEAST … Look up ODI 11155746 at NHTSA ↗
Visibility/Wiper	Too few reports for a range	15,535 mi	2 (sparse)	ODI 11131473 · 24,569 mi THE VEHICLE WAS DRIVING DOWN THE ROAD. THE DRIVER SIDE WINDSHIELD WIPER WHEN ENGAGED AT LOW MEDIUM OR HIGH SPEED BUT IN THE CASE IT FAILED AT LOW SPEED. THE WIPER ON DRIVER SIDE GOES OFF WINDSHIELD TO SIDE MIRROR AND FAILS. DT CONSUMER STATED PRODUCT MALFUNCTIONED DRIVING DOWN THE INTERSTATE. UPDATED 10/9/18JB Look up ODI 11131473 at NHTSA ↗ ODI 11128274 · 6,500 mi THE DRIVER'S WINDSHEILD WIPER DOES NOT CONTACT THE GLASS EXCEPT AT THE VERY TOP FOR THE LAST 30% OF THE STROKE LEAVEING THE PORTION DIRECTLY IN FRONT OF THE DRIVER WITHOUT THE NEEDED VIEW. NEWMAR REPLACED THE WIPER BLADE, BUT STILL HAVE THE PROBLEM. Look up ODI 11128274 at NHTSA ↗
Electrical System: Instrument Cluster/Panel	Too few reports for a range	14,125 mi	2 (sparse)	ODI 11387122 · 1,250 mi I WAS UNABLE TO DIM THE DASH CLUSTER LIGHTS BELOW 100% BRIGHTNESS USING THE MANUFACTURER SUPPLIED DIMMING CONTROLS. I ATTEMPTED ADJUSTMENTS WHILE DRIVING AT NIGHT ON A FREEWAY WITH THE HEADLIGHTS ON, WHILE PARKED IN A REST AREA WITH THE ENGINE RUNNING AND HEADLIGHTS ON AND OFF, AND WITH THE IGNITION ON ACCESSORY WITHOUT THE ENGINE RUNNING. THIS CREATES DANGEROUS BRIGHT GLARE TO THE DRIVERS EYES MAKING DRIVING VERY DIFFICULT AT NIGHT. Look up ODI 11387122 at NHTSA ↗ ODI 11697220 · 27,000 mi The contact owns a 2020 Newmar Dutch Star RV. The contact stated that while the RV was parked and occupied, the contact attempted to start the RV and became aware that the instrument panel was displaying a black screen. The dealer was contacted. The RV was not taken to a dealer nor an independent mechanic to be diagnosed. The RV was not repaired. The manufacturer was notified of the failure and informed the contact that the RV was out of warranty. The approximate failure mileage was 27,000. Look up ODI 11697220 at NHTSA ↗

Complaint and recall timeline

Explore monthly filing activity alongside recall announcements. Up to ten years of monthly history is available.

ComponentPeriod

Solid line: filed complaints. Dashed amber lines: recall announcement dates for this vehicle selection; markers include all recall components. The latest month is partial. Temporal proximity does not establish causation.

Monthly counts, recall campaigns and complaint examples

Monthly complaint and recall timeline
Month	Complaints	Campaigns announced	Examples
2024-10	2	None	ODI 11620605 The Freightliner chassis under this motorhome uses a Power Distribution Module (PDM) that is a fuse panel "block" that powers several coach items, from taillights, brake lights, engine cooling, air conditioning and several other components. The PDM intermittently fails as it can't support the amount of power it must distribute without overheating and shutting off several components as you drive. Especially dangerous is the lost of rear brake and taillights. The PDM was recalled by Freightliner and was replaced with the same item. I'm only gue… Look up ODI 11620605 at NHTSA ↗ ODI 11621192 My Newmar motorhome has 20,000 miles on it. When driving on the highway the steering intermittantly gets about 60% harder to steer for approximately 20 minutes then goes back to normal. It happens repeatedly and regardless of whether you are turning or going straight. Last week the problem became much worse. More importantly I was exiting the highway and the steering wheel turned by itself back to center while I was turning! Thank god I was moving slowly and was able to stop. I turned the motorhome engine off and restarted it and the steering w… Look up ODI 11621192 at NHTSA ↗
2024-11	1	None	ODI 11627009 Last week I had the air dryer filter replaced at Colton Truck Terminal in Colton Ca. Subsequently, I did the complete 7 step air brake system check and discovered that during total loss of air pressure , the emergency brakes would not auto apply. I replaced the dash hand valve and the problem still persists, so I installed the original valve and took the coach back to Colton Truck Terminal to diagnose the problem. Attached is the paper work from Colton Truck Terminal diagnosing the issue and the correction of that issue. Also on that paperw… Look up ODI 11627009 at NHTSA ↗
2024-12	0	None	No examples available for this selection.
2025-01	1	None	ODI 11636178 Passenger entry door seal has failed and window is fogged making lane changing or viewing very difficult and unsafe. I have tried to contact Newmar and their reply was giving me a statement that my coach is out of warranty and I need to contact a 3rd party vendor for replacement at my cost. I would think a window separation would be a concern for Newmar Corp. I have read many other complaints from Newmar owners. Look up ODI 11636178 at NHTSA ↗
2025-02	0	None	No examples available for this selection.
2025-03	0	None	No examples available for this selection.
2025-04	0	None	No examples available for this selection.
2025-05	0	None	No examples available for this selection.
2025-06	0	None	No examples available for this selection.
2025-07	0	None	No examples available for this selection.
2025-08	0	None	No examples available for this selection.
2025-09	0	None	No examples available for this selection.
2025-10	0	None	No examples available for this selection.
2025-11	3	None	ODI 11700840 · 102,000 mi Odometer Fraud. The contact purchased a 2000 Newmar Dutch Star RV. After driving the RV on a road trip, it was discovered that there was a mileage discrepancy. The RV was a private sale. At the time of purchase, the RV mileage was 102,000, and at the time it was taken to an independent mechanic, it was determined that the odometer had been disconnected. The contact contacted the State Enforcement Agency for odometer fraud and was referred to an attorney. The mileage remained 102,000. The contact was unable to determine the actual mileage. Look up ODI 11700840 at NHTSA ↗ ODI 11697973 The digital dash is delaminating and makes it hard to see all of the safety items displayed on the dash. Everything is distorted, this is a SAFETY ISSUE. This is a know issue that occurs on many Freightliner products. ( The chassis is Freightliner ) Freightliner will not accept any responsibility beyond the normal warranty timeframe. Freightliner wants $ 7,000.00 ~ for the repair and then how long will this last?? I appears that this is a major issue for Freightliner chassis, and you have to do is google it and many posts come up discussing… Look up ODI 11697973 at NHTSA ↗ ODI 11697220 · 27,000 mi The contact owns a 2020 Newmar Dutch Star RV. The contact stated that while the RV was parked and occupied, the contact attempted to start the RV and became aware that the instrument panel was displaying a black screen. The dealer was contacted. The RV was not taken to a dealer nor an independent mechanic to be diagnosed. The RV was not repaired. The manufacturer was notified of the failure and informed the contact that the RV was out of warranty. The approximate failure mileage was 27,000. Look up ODI 11697220 at NHTSA ↗
2025-12	0	None	No examples available for this selection.
2026-01	1	None	ODI 11713195 I purchased a 2020 Newmar Dutchstar RV on [XXX] and first noticed the Tire Pressure Monitoring Sytem (TPMS) start to malfunction shortly after. The first indication of the malfunction were nuisance warnings stating tire overheat conditions, followed by constant communication warnings and multiple tires not indicating anything at all. The current state of the TPMS as of today [XXX] is it does not function at all with a constant communication error displayed on the dash panel. I received SF644A-C from DTNA in March 2022 stating the TPMS control… Look up ODI 11713195 at NHTSA ↗
2026-02	0	None	No examples available for this selection.
2026-03	1	None	ODI 11723800 See attached document for complaint. Look up ODI 11723800 at NHTSA ↗
2026-04	0	None	No examples available for this selection.
2026-05	0	None	No examples available for this selection.
2026-06	0	None	No examples available for this selection.
2026-07	0	None	No examples available for this selection.
2026-08	0	None	No examples available for this selection.
2026-09 (partial)	0	None	No examples available for this selection.

Emerging complaint spikes

Complete months in the latest six months with at least 10 complaints, at least twice the preceding 12-month average, and at least three square-root deviations above that average.

This is a descriptive screening rule, not a statistical defect finding. Publicity and reporting changes can increase submissions.

No complete months meet the spike thresholds for this selection.

Equal-age model-year comparison

Model-wide cumulative reports during the first three or five calendar years, starting with the model year (age 0). Only fully elapsed windows are compared.

Observation windowFirst model yearSecond model year

2022: 0 complaints · 2023: 2 complaints

Equal observation windows
Model year	Through age 0	Through age 1	Through age 2
2022	0	0	0
2023	1	2	2

Date coverage across each selected cohort

Date basis for all complaints in selected model years
Year	Incident dates used	Filing date fallbacks	Excluded dates
2022	0	0	0
2023	2	0	0

Incident date is preferred when valid and no later than filing; otherwise filing date is used. Model year approximates age. Equal observation time does not adjust for sales, distance driven or reporting delays. One complaint linked to multiple model years can appear in each cohort.

Components reported together

Each cell counts unique complaints naming both components. Open a nonzero cell for examples.

Component co-occurrence matrix
Component	Tires	Engine	Unknown Or Other	Electrical System	Equipment:Recreational Vehicle/Trailer	Exterior Lighting	Visibility/Wiper	Electrical System: Instrument Cluster/Panel
Tires	—	0	0	0	0	0	0	0
Engine	0	—	1 ODI 11425316 Since purchasing this RV new, I have had the DEF Head fail twice. 1st time was Sep 2019 with a mileage of 14066 and the 2nd time was April 2021 with a mileage of 16018. Both times DEF Header Assemblies were replaced. When these fail the motor can de-rate at any time. Very dangerous when traveling down the highway. Both times the low DEF warning and check engine lights came on. Look up ODI 11425316 at NHTSA ↗	1 ODI 11620605 The Freightliner chassis under this motorhome uses a Power Distribution Module (PDM) that is a fuse panel "block" that powers several coach items, from taillights, brake lights, engine cooling, air conditioning and several other components. The PDM intermittently fails as it can't support the amount of power it must distribute without overheating and shutting off several components as you drive. Especially dangerous is the lost of rear brake and taillights. The PDM was recalled by Freightliner and was replaced with the same item. I'm only gue… Look up ODI 11620605 at NHTSA ↗	0	1 ODI 11620605 The Freightliner chassis under this motorhome uses a Power Distribution Module (PDM) that is a fuse panel "block" that powers several coach items, from taillights, brake lights, engine cooling, air conditioning and several other components. The PDM intermittently fails as it can't support the amount of power it must distribute without overheating and shutting off several components as you drive. Especially dangerous is the lost of rear brake and taillights. The PDM was recalled by Freightliner and was replaced with the same item. I'm only gue… Look up ODI 11620605 at NHTSA ↗	0	0
Unknown Or Other	0	1 ODI 11425316 Since purchasing this RV new, I have had the DEF Head fail twice. 1st time was Sep 2019 with a mileage of 14066 and the 2nd time was April 2021 with a mileage of 16018. Both times DEF Header Assemblies were replaced. When these fail the motor can de-rate at any time. Very dangerous when traveling down the highway. Both times the low DEF warning and check engine lights came on. Look up ODI 11425316 at NHTSA ↗	—	0	2 ODI 10229933 TWO ATTEMPTS TO CORRECT THE PRODUCT FAILURE RESULTED IN FAILURE AND THE MANUFACTURE DENIED FURTHER RESPONSIBILITY. *TR Look up ODI 10229933 at NHTSA ↗ ODI 10366753 · 23,427 mi THIS IS 2ND RECALL FOR NORCOLD REFRIGERATOR IN OUR RV. RV IS IN STORAGE, BUILDING AND USED TO LIVE IN. FROZEN FOOD IN FREEZER, AND NO WHERE ELSE TO STORE IT. IT IS OVER 200 MILES TO CLOSEST REPAIR PLACE, AND INSURANCE ON RV IS FOR STORAGE ONLY AND NOT DRIVING. WILL COST OVER 200 DOLLARS FOR ROUND TRIP TO ACCOMPLISH DEFECTIVE NORCOLD PRODUCT. INSURANCE FOR RV TO MAKE TRIP WILL BE EXTRA AND OVER THE 200 DOLLAR AMOUNT. IF TURN OFF REFRIG, FREEZER WILL LOSE OVER $350 PERISHABLE ITEMS. WE ARE RETIRED, HAVE SOME DISABILITY, AND ON LIMITED INCOME. … Look up ODI 10366753 at NHTSA ↗	0	1 ODI 11508791 Multiple double pane windows are fogging. The driver’s side window fogging between the double pane glass, is causing visibility problem’s creating a safety hazard. Look up ODI 11508791 at NHTSA ↗	3 ODI 11611246 The area on the dash where you read all the gauges is delaminating. This is a hazard as the gauges are hard to see and affected Look up ODI 11611246 at NHTSA ↗ ODI 11697973 The digital dash is delaminating and makes it hard to see all of the safety items displayed on the dash. Everything is distorted, this is a SAFETY ISSUE. This is a know issue that occurs on many Freightliner products. ( The chassis is Freightliner ) Freightliner will not accept any responsibility beyond the normal warranty timeframe. Freightliner wants $ 7,000.00 ~ for the repair and then how long will this last?? I appears that this is a major issue for Freightliner chassis, and you have to do is google it and many posts come up discussing… Look up ODI 11697973 at NHTSA ↗ ODI 11615680 The dash displaying the instrument panel is bubbling up and it prevents you from reading your instruments. The glare it causes is dangerous. Hearing from other customers that own the same RV tells me this is a common issue and there should be a recall. Look up ODI 11615680 at NHTSA ↗
Electrical System	0	1 ODI 11620605 The Freightliner chassis under this motorhome uses a Power Distribution Module (PDM) that is a fuse panel "block" that powers several coach items, from taillights, brake lights, engine cooling, air conditioning and several other components. The PDM intermittently fails as it can't support the amount of power it must distribute without overheating and shutting off several components as you drive. Especially dangerous is the lost of rear brake and taillights. The PDM was recalled by Freightliner and was replaced with the same item. I'm only gue… Look up ODI 11620605 at NHTSA ↗	0	—	1 ODI 10154219 · 6,970 mi REAR SLIDE ON 2005 NEWMAR DUTCH STAR RETRACTS WITHOUT WARNING. THIS HAS OCCURRED TWICE. LUCKILY WE OR OUR PETS WERE NOT INJURED. THIS OCCURRED WHILE VEHICLE WAS PARKED, AUTOMATIC JACKS WERE DEPLOYED, BUT HAVE NEVER WORKED PROPERLY SINCE THE UNIT WAS PURCHASED NEW IN AUG 2005. *JB Look up ODI 10154219 at NHTSA ↗	2 ODI 11321477 THE INSTRUMENT LIGHT PANEL (OPTIVIEW) DOES NOT DIM ENOUGH AND IS TOO BRIGHT AT NIGHT MAKING IT VERY DIFFICULT TO SEE OUTSIDE THE VEHICLE WHEN DRIVING AT NIGHT. ON A DARK RAINY NIGHT THE GLARE FROM THE INSTRUMENT PANEL MAKES FOR DANGEROUS DRIVING CONDITIONS. MY COMPLAINT TO NEWMAR IN APRIL 2019 WAS DEFERRED TO FREIGHTLINER. NOVEMBER OF 2019 FREIGHTLINER SENT TWO TECHNICIANS TO MY HOME WHO SPENT A COUPLE OF HOURS DIAGNOSING AND TAKING PICTURES OF THE PROBLEM. THEY CONCLUDED THE BRIGHTNESS LEVEL OF THE INSTRUMENT PANEL DID DIM IN RESPONSE TO TH… Look up ODI 11321477 at NHTSA ↗ ODI 11620605 The Freightliner chassis under this motorhome uses a Power Distribution Module (PDM) that is a fuse panel "block" that powers several coach items, from taillights, brake lights, engine cooling, air conditioning and several other components. The PDM intermittently fails as it can't support the amount of power it must distribute without overheating and shutting off several components as you drive. Especially dangerous is the lost of rear brake and taillights. The PDM was recalled by Freightliner and was replaced with the same item. I'm only gue… Look up ODI 11620605 at NHTSA ↗	0	1 ODI 11603226 The Freightliner instrument cluster (ICU) screen delaminates and makes it difficult to read the gauges. This issue appears to happen with a lot of 2019 models. Freighter refuses to assist and the cost is $5700 for the cluster + labor. Look up ODI 11603226 at NHTSA ↗
Equipment:Recreational Vehicle/Trailer	0	0	2 ODI 10229933 TWO ATTEMPTS TO CORRECT THE PRODUCT FAILURE RESULTED IN FAILURE AND THE MANUFACTURE DENIED FURTHER RESPONSIBILITY. *TR Look up ODI 10229933 at NHTSA ↗ ODI 10366753 · 23,427 mi THIS IS 2ND RECALL FOR NORCOLD REFRIGERATOR IN OUR RV. RV IS IN STORAGE, BUILDING AND USED TO LIVE IN. FROZEN FOOD IN FREEZER, AND NO WHERE ELSE TO STORE IT. IT IS OVER 200 MILES TO CLOSEST REPAIR PLACE, AND INSURANCE ON RV IS FOR STORAGE ONLY AND NOT DRIVING. WILL COST OVER 200 DOLLARS FOR ROUND TRIP TO ACCOMPLISH DEFECTIVE NORCOLD PRODUCT. INSURANCE FOR RV TO MAKE TRIP WILL BE EXTRA AND OVER THE 200 DOLLAR AMOUNT. IF TURN OFF REFRIG, FREEZER WILL LOSE OVER $350 PERISHABLE ITEMS. WE ARE RETIRED, HAVE SOME DISABILITY, AND ON LIMITED INCOME. … Look up ODI 10366753 at NHTSA ↗	1 ODI 10154219 · 6,970 mi REAR SLIDE ON 2005 NEWMAR DUTCH STAR RETRACTS WITHOUT WARNING. THIS HAS OCCURRED TWICE. LUCKILY WE OR OUR PETS WERE NOT INJURED. THIS OCCURRED WHILE VEHICLE WAS PARKED, AUTOMATIC JACKS WERE DEPLOYED, BUT HAVE NEVER WORKED PROPERLY SINCE THE UNIT WAS PURCHASED NEW IN AUG 2005. *JB Look up ODI 10154219 at NHTSA ↗	—	0	0	0
Exterior Lighting	0	1 ODI 11620605 The Freightliner chassis under this motorhome uses a Power Distribution Module (PDM) that is a fuse panel "block" that powers several coach items, from taillights, brake lights, engine cooling, air conditioning and several other components. The PDM intermittently fails as it can't support the amount of power it must distribute without overheating and shutting off several components as you drive. Especially dangerous is the lost of rear brake and taillights. The PDM was recalled by Freightliner and was replaced with the same item. I'm only gue… Look up ODI 11620605 at NHTSA ↗	0	2 ODI 11321477 THE INSTRUMENT LIGHT PANEL (OPTIVIEW) DOES NOT DIM ENOUGH AND IS TOO BRIGHT AT NIGHT MAKING IT VERY DIFFICULT TO SEE OUTSIDE THE VEHICLE WHEN DRIVING AT NIGHT. ON A DARK RAINY NIGHT THE GLARE FROM THE INSTRUMENT PANEL MAKES FOR DANGEROUS DRIVING CONDITIONS. MY COMPLAINT TO NEWMAR IN APRIL 2019 WAS DEFERRED TO FREIGHTLINER. NOVEMBER OF 2019 FREIGHTLINER SENT TWO TECHNICIANS TO MY HOME WHO SPENT A COUPLE OF HOURS DIAGNOSING AND TAKING PICTURES OF THE PROBLEM. THEY CONCLUDED THE BRIGHTNESS LEVEL OF THE INSTRUMENT PANEL DID DIM IN RESPONSE TO TH… Look up ODI 11321477 at NHTSA ↗ ODI 11620605 The Freightliner chassis under this motorhome uses a Power Distribution Module (PDM) that is a fuse panel "block" that powers several coach items, from taillights, brake lights, engine cooling, air conditioning and several other components. The PDM intermittently fails as it can't support the amount of power it must distribute without overheating and shutting off several components as you drive. Especially dangerous is the lost of rear brake and taillights. The PDM was recalled by Freightliner and was replaced with the same item. I'm only gue… Look up ODI 11620605 at NHTSA ↗	0	—	0	0
Visibility/Wiper	0	0	1 ODI 11508791 Multiple double pane windows are fogging. The driver’s side window fogging between the double pane glass, is causing visibility problem’s creating a safety hazard. Look up ODI 11508791 at NHTSA ↗	0	0	0	—	0
Electrical System: Instrument Cluster/Panel	0	0	3 ODI 11611246 The area on the dash where you read all the gauges is delaminating. This is a hazard as the gauges are hard to see and affected Look up ODI 11611246 at NHTSA ↗ ODI 11697973 The digital dash is delaminating and makes it hard to see all of the safety items displayed on the dash. Everything is distorted, this is a SAFETY ISSUE. This is a know issue that occurs on many Freightliner products. ( The chassis is Freightliner ) Freightliner will not accept any responsibility beyond the normal warranty timeframe. Freightliner wants $ 7,000.00 ~ for the repair and then how long will this last?? I appears that this is a major issue for Freightliner chassis, and you have to do is google it and many posts come up discussing… Look up ODI 11697973 at NHTSA ↗ ODI 11615680 The dash displaying the instrument panel is bubbling up and it prevents you from reading your instruments. The glare it causes is dangerous. Hearing from other customers that own the same RV tells me this is a common issue and there should be a recall. Look up ODI 11615680 at NHTSA ↗	1 ODI 11603226 The Freightliner instrument cluster (ICU) screen delaminates and makes it difficult to read the gauges. This issue appears to happen with a lot of 2019 models. Freighter refuses to assist and the cost is $5700 for the cluster + labor. Look up ODI 11603226 at NHTSA ↗	0	0	0	—

Co-reporting does not establish that one component caused another concern.

Recurring narrative patterns

Specific keyword mentions beyond broad component labels. Matching includes negations and comparisons and does not confirm a diagnosis.

Search patterns

5 patterns with matching reports.

Warning lights and dashboard alerts

13 mentions · 7.8% of complaints

Median mileage: 5,409 mi (7 usable records).

ODI 11415723 · 21,215 mi

RV WENT INTO 5MPH DERATE DUE TO DEF HEADER MALFUNCTION. I WAS VERY LUCKY TO BE IN AN RV PARK, HOWEVER THERE IS NO WAY TO REPLACE THE DEF HEADER WITHOUT RAISING THE RV (DUE TO THE LOCATION OF THE TANK), SO IT COULDN'T BE REPLACED THERE. I HAD AN APPOINTMENT TO REPLACE THE DEF HEADER AT FREIGHTLINER OF HOUSTON, DUE TO THE WARNING LIGHTS. HOWEVER WHEN I STARTED TO DRIVE THERE FOR THE APPOINTMENT, I FOUND THE RV WOULD NOT GO OVER 5MPH. SINCE THE DEALER WAS 60 MILES AWAY (AND IT WAS THE NEAREST ONE), THERE WAS NO WAY I COULD MAKE IT.

Look up ODI 11415723 at NHTSA ↗

ODI 11386835 · 5,000 mi

CHECK ENGINE LIGHT CAME ON, CONTACTED CUMMINS WITH CODE. I WAS TOLD THE DEF HEAD NEEDED TO BE REPLACED. MOTORHOME HAD 5211 MILES. MADE AN APPOINTMENT AND HAD HEAD REPLACED

Look up ODI 11386835 at NHTSA ↗

ODI 11425265

The failure has occurred in the emission system. The DEF SENSOR set off 2 Check Engine light warnings on the dash. It did not tell me any other information. I was fortunate to return from my trip without incident. However, after speaking with the chassis manufacturer (Spartan), I was fortunate to be able to continue. Had I gone any further the engine would have begun a shutdown leaving my 24 ton RV stranded roadside. It could have been very serious breakdown on a metro highway causing major traffic jams or left stranded in a remote location…

Look up ODI 11425265 at NHTSA ↗

Matching rule

\b(warning light\w*|check engine|dashboard warning\w*|malfunction indicator)\b

Steering assistance concerns

5 mentions · 3.0% of complaints

Median mileage: 32,000 mi (3 usable records).

ODI 11233258 · 82,000 mi

Look up ODI 11233258 at NHTSA ↗

ODI 874375

Look up ODI 874375 at NHTSA ↗

ODI 10082900 · 15,500 mi

Look up ODI 10082900 at NHTSA ↗

Matching rule

\b(power steer\w*|steering assist\w*|steering lock\w*|steering wheel lock\w*)\b

Brake response concerns

3 mentions · 1.8% of complaints

Median mileage: 30,500 mi (2 usable records).

ODI 10280374 · 57,000 mi

TL*THE CONTACT OWNS A 1997 NEWMAR DUTCH STAR RV. WHILE DRIVING APPROXIMATELY 20 MPH ON A STEEP MOUNTAIN, THERE WAS NO RESPONSE WHEN THE BRAKE PEDAL WAS DEPRESSED. THE TRANSMISSION FAILED TO LOCK INTO GEAR WHILE DRIVING DOWNHILL. AFTER THE BRAKE PEDAL WAS DEPRESSED MULTIPLE TIMES, THE RV SLOWED DOWN. THE BRAKES WERE FUNCTIONAL UNTIL HE REACHED HIS DESTINATION. THE RV WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION AND THEY STATED THAT THE BRAKE SYSTEM WAS BURNING. THE TECHNICIAN REPLACED THE REAR BRAKE SYSTEM AND THE MANUFACTURER WAS NOTI…

Look up ODI 10280374 at NHTSA ↗

ODI 10014396 · 4,000 mi

Look up ODI 10014396 at NHTSA ↗

ODI 11599190

I experienced unintended collision braking with dash warnings flashing. I was trying to accelerate from a side street onto a two-lane state highway. The motorhome came to a complete stop after getting up to about 30-35 MPH. After an extraordinarily long minute or so I was able to accelerate a second time and the motorhome did unintended braking a second time! It was very scary because I was blocking a busy highway in one direction, and I was not sure what to do. I finally turned the engine off, turned the ignition key on, and waited to mak…

Look up ODI 11599190 at NHTSA ↗

Matching rule

Stalling or loss of power

3 mentions · 1.8% of complaints

Median mileage: 27,350 mi (2 usable records).

ODI 10175590 · 39,200 mi

DT*: THE CONTACT STATED WHILE DRIVING 50 MPH ON WET ROADS IN THE RAIN, MOISTURE WAS PICKED UP THROUGH THE INTAKE MANIFOLD. THE VEHICLE PARTIALLY LOST POWER, BUT KEPT MOVING. THE VEHICLE WAS NOT SEEN BY A DEALER. PRIOR TO THIS INCIDENT, THE AIR INTAKE TUBE HAD BEEN REPLACED BY A SERVICE DEALER DUE TO THE SAME ISSUE, BUT THE PROBLEMS PERSISTED. THE MANUFACTURER WAS CONTACTED, WHO STATED THAT THE CONTACT HAD THE MOST UP TO DATE FIX FOR THIS PROBLEM, AND THAT IT SHOULD NOT HAVE RECURRED A SECOND TIME.

Look up ODI 10175590 at NHTSA ↗

ODI 874375

Look up ODI 874375 at NHTSA ↗

ODI 10082900 · 15,500 mi

Look up ODI 10082900 at NHTSA ↗

Matching rule

\b(stall\w*|loss of power|lost power|engine shut\w* off)\b

Fuel smell or leak mentions

1 mentions · 0.6% of complaints

Median mileage: 47,305 mi (1 usable records).

ODI 10192968 · 47,305 mi

HAD BAD FUEL LEAK CAUSED BY USE OF ULTRA LOW SULFER DIESEL FUEL.(ULDF). REPLACED FUEL TRANSFER (LIFT) PUMP P/N 4935007 OLD PUMPWAS AVAILABLE. *AK

Look up ODI 10192968 at NHTSA ↗

Matching rule

\b(fuel leak\w*|gas leak\w*|gas(?:oline)? smell|smell\w* (?:of )?(?:fuel|gas))\b