Newmar MOUNTAIN AIRE brakes problems

I CARRIED MY 2001 NEWMAR MOUNTAIN AIRE, TO DANNY'S RV REPAIR IN DENTON, TX DUETO RECALL 51101-C WORKHRSE REFUSED TO HONOR THE (A) RIGHT FRONT PART# W8001709, $50.91 . AND THE LABOR FOR RIGHT REAR ABSCODE APPEARED ON TEST DRIVE) AND THE RF, LR, LABOR @ 29.40 EACH= $88.20 . I PAID OUT OF POCKET FOR SOMETHING I FEEL SHOULD HAVE COST ME NOTHING AS DIRECTED IN THE RECALL. PLEASE INVESTIGATE AND LET ME KNOW YOUR FINDINGS. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Look up ODI 10418562 at NHTSA ↗

ABS BRAKE FAILURE AND LOSS OF CRUISE CONTROL. HAPPENED DURING STOP AND GO TRAFFIC. CALIPERS HUNG UP AND OVER HEATED BRAKES BURNING OUT ABS SENSOR. SAME PROBLEM ON 2002, 2001 WORKHORSE CHASSIS. RECALL SHOULD HAVE INCLUDED 2003 AS PROBLEM IS THE SAME. MANY COMPLAINTS ABOUT SAME YEAR AND SAME SITUATION AS MINE. WORKHORSE SHOULD HAVE NOTIFIED OWNERS TO LUBE CALIPER SLIDES IMMEDIATELY. *TR

Look up ODI 10238036 at NHTSA ↗

RIGHT FRONTS BRAKE LOCK UP CAUSING LOSS OF CONTROL PULLED ME INTO THE DITCH. SECOND PROBLEM 2000 THOUSAND MILES LATER, RIGHT REAR BRAKE DRAGGING AND OVER HEATING. RIGHT FRONT WHEEL OVER HEATED AND CAUSED OIL TO BOIL OUT OF BEARING, TOWED TO REPAIR SHOP FOR FIX. *TR

Look up ODI 10246619 at NHTSA ↗

VEHICLE RUNNING NORMALLY, ACCELERATED TO MERGE WITH TRAFFIC, ENGINE BEGAN TO MISS THEN BACKFIRED. MISS CONTINUED AND THE VEHICLE WOULDN'T ACCELERATE PAST 55 MPH. PULLED TO SIDE OF THE ROAD TO CHECK FOR ANY VISUAL PROBLEMS, NONE NOTED. ENGINE STARTED NORMALLY AND I FINISHED THE 30 MILE DRIVE HOME. CHANGED FUEL FILTER, AIR FILTER AND MAF SENSOR. ENGINE STARTED NORMALLY AND I TOOK IT FOR A TEST DRIVE. AFTER 20 MILES WITH NO ISSUES I ATTEMPTED AN ACCELERATION AND AGAIN IT LOST POWER, SKIPPING/MISSING AND BACKFIRED. PULLED INTO A REST AREA AND…

Look up ODI 10641506 at NHTSA ↗

EXHAUST PIPE COMPLETELY SHEERED OFF AT TURBO, BLOWING THE HOT FLUE GASES BACK TOWARDS THE BEDROOM AND ENGINE ELECTRONICS. AMASSED THAT NOTHING STARTED ON FIRE, PROBLEM FOUND WHEN COACH WENT IN FOR ITS ANNUAL INSPECTION AND OIL CHANGE

Look up ODI 11010922 at NHTSA ↗

I PURCHASED THE UNIT WITH 25,000 MILES. THE DEF SYSTEM FAILED ENROUTE TO THE DEALER I PURCHASED IT FROM AND FAILED AGAIN AFTER APPROXIMATELY 3,000 MILES AFTER REPAIR. THE ENTIRE DEF HEADER WAS REPLACED. THIS IS AN EXTREMELY DANGEROUS SITUATION WHEN THE VEHICLE GOES IN TO DERATE. MY MOTORHOME IS 53,000 LBS AND 45'. ADD A TOW VEHICLE AND IT IS VERY DANGEROUS WHEN THIS HAPPENS. I WAS HEADING TO LAS VEGAS NV FROM QUARTZITE, AZ WHEN THIS HAPPEND ON A TWO LANE HIGHWAY. NO PLACE TO PULL OVER TO EVEN CHECK ANYTHING. THESE DEF SYSTEMS CONTINUE T…

Look up ODI 11384396 at NHTSA ↗

NORCOLD 1200 RECALL, BACK OF REFRIDGE CAUGHT FIRE WHILE ON GAS SETTING IN DRIVEWAY AT MY HOME AFTER A RETURN TRIP TO FLA.

Look up ODI 10958794 at NHTSA ↗

IN THE SPRING OF 2016, WE HAD TAKEN A TRIP FROM HOME TO LAKE WRIGHT-PATMAN ABOUT 80 MILES AWAY. UPON ARRIVING AT OUR CAMPING SPACE, WE NOTICED THE TOP OF THE WINDSHIELDS WERE BULGING OUT FROM THE ROOF. WE COVERED THE ROOF AND TOP OF THE WINDSHIELDS WITH A TARP TO PREVENT RAIN FROM COMING INTO THE BUS. WE CONTACTED NEWMAR'S CUSTOMER SUPPORT VIA EMAIL AND TELEPHONE TO DETERMINE WHAT COULD BE DONE TO REPAIR THE WINDSHIELDS. WE CONTACTED PACE GLASS IN TEXARKANA, TX TO MAKE THE REPAIRS USING SCHEMATICS PROVIDED TO US BY NEWMAR. IN REMOVING THE …

Look up ODI 10983412 at NHTSA ↗

THE INSTRUMENT PANEL BRIGHTNESS CANNOT BE ADJUSTED, CAUSING GLARE WHEN DRIVING AT NIGHT IRRESPECTIVE OF WHETHER IT IS IN-MOTION OR STATIONARY. AS SUCH, THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NUMBER 101, "CONTROL AND DISPLAYS." THE ONLY WAY I CAN DRIVE AT NIGHT IS TO COVER THE GLASS DISPLAY SO THAT I DO NOT GET THE GLARE REFLECTING FROM THE SIDE WINDOWS AND WINDSHIELD. WHEN THE GLASS DASH IS COVERED YOU LOSE CRITICAL INFORMATION INCLUDING VEHICLE SPEED. THE GLARE OBSCURES SEEING OUT THE WI…

Look up ODI 11383084 at NHTSA ↗

VEHICLE WAS PARKED WITH PARKING BRAKE ON IN MY DRIVEWAY FOR 3 DAYS . PARKING BRAKES FAILED AN THE MOTORHOME ROLLED OFF MY DRIVEWAY AND INTO THE YARD HITTING ONE OF MY OTHER VEHICLES. AFTER CONTACTING NEWMAR AND FREIGHTLINER I WAS INFORMED THAT A PRESSURE SWITCH HAD FAILED AND CAUSED THE BRAKES TO RELEASE. WHAT IF THIS HAD HAPPENED AT A GAS STATION WITH MY FAMILY IN IT. THE LIGHTS IN THE DASHBOARD INDICATE THE PARKING BRAKES ARE INGUAGED BUT THERE ARE NO BRAKES. THE PART FREIGHTLINER SAID FAILED IS 06-32698-000 SWITCH-PRESSURE

Look up ODI 11331358 at NHTSA ↗

TL* THE CONTACT OWNED A 2002 NEWMAR MOUNTAIN AIRE. WHILE DRIVING AT APPROXIMATELY 65 MPH, THE BRAKE PEDAL WAS DEPRESSED AND FAILED TO RESPOND. AS A RESULT, THE VEHICLE FLIPPED TO THE SIDE AND ROLLED INTO AN EMBANKMENT. THERE WERE NO INJURIES AND A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED AND TOWED TO A TOW YARD. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 80,000. UPDATED 05/06/16*BF *CN

Look up ODI 10849746 at NHTSA ↗

I DELIVERED OUR RV TO A CERTIFIED WORKHORSE REPAIR CENTER TO HAVE THE #51101-C BRAKE RECALL ADDRESSED. THE WORKMANSHIP WAS EXCELLENT. MY COMPLAINT IS WORKHORSE DOES NOT WANT TO PAY FOR THE COMPLETE REPAIR. THEIR ARGUMENT IS THAT THE RV WASN'T DRIVEN ENOUGH. I PURCHASED THIS RV USED AND FOUND OUT ABOUT THE RECALL WHEN I REGISTERED IT WITH WORKHORSE.COM. WHEN YOU READ THE TROUBLE TREE, PARAGRAPH 1.3/A, ALL THESE PARTS WERE CHANGED AND COMPLETED IN STEPS 8 & 9. THE TROUBLE TREE SAYS IT IS COVERED BUT THE WORKHORSE SERVICE DEPT. DOESN'T WANT TO PAY…

Look up ODI 10537041 at NHTSA ↗

WHEN CHANGING MY OIL IN THE MOTOR HOME , I WAS LOOKING AT THE COMPONETS OF THE UNDERCARRIAGE AND WAS SHOCKED TO SEE THAT THE RIGHT SIDE MOTOR MOUNT WAS MISSING ONE BOLT COMPLETELY AND THE OTHER ONE WAS JUST HANGING BY A FEW THREADS. MY FAMILY AND I HAD JUST RETURNED FROM A TRIP TO PENNSLYVANIA , IF THE ENGINE HAD FALLEN WHILE WE WERE ON THE ROAD IT COULD HAVE CAUSED A WRECK. I CONTACTED THE COMPANY (NEWMAR) AND THEY SAID THAT THEY WERE NOT RESPONSIBLE, THAT WORKHORSE, THE MANUFACTURE OF THE CHASSIS WAS. I CONTACTED WORKHORSE AND REPOR…

Look up ODI 10129246 at NHTSA ↗

WHILE DRIVING ALONG HIGHWAY 28, APPROXIMATELY 75 MILES SOUTH OF SALMON IDAHO, THE ENTIRE FRONT WINDSHIELD BROKE LOOSE AND ENTERED INTO THE CAB. IT WAS STOPPED BY THE TV AND STORAGE UNITS. BOTH WINDSHIELDS, DRIVER, AND PASSENGER WERE DESTROYED, AND THE CENTER SUPPORT BRACKET BUCKLED. WAS ABLE TO INSTITUTE SOME TEMPORARY REPAIRS AND BROUGHT THE VEHICLE HOME. ONCE HOME, I FIRST CONTACTED THE FACTORY, WHO ASKED ME TO TAKE IT TO THEIR DEALER AND HAVE THE OPENING OF THE WINDSHIELD MEASURED, AND TO HAVE THE DEALER FAX IT TO THEM. THEN CONTACTED T…

Look up ODI 10079222 at NHTSA ↗

TL* - THE CONTACT'S DOMETIC REFRIGERATOR IN HER 2001 NEWMAR MOUNTAIN AIRE HAD A PETITE CRACK IN THE BOILER TUBE. THE CRACK CAUSED A SUFFICIENT AMOUNT OF SOLUTION/GAS TO BE RELEASED INTO THE AIR. THE CONTACT HAS REPLACED THE DOMETIC REFRIGERATOR WHICH IS ALSO LISTED IN THE RV MAGAZINE AS A RECALL.

Look up ODI 10176835 at NHTSA ↗