Peterbilt 362 recalls by model year

Reported: 1981-04-20 (April 20, 1981) · Model years: 1981

SOME VEHICLES MAY HAVE BEEN MANUFACTURED WITH A WINDSHIELD MASK HAVING TOO LARGE AN OPENING WHICH WAS NOT ANGLED CORRECTLY. THE TOP OF THE WINDSHIELD COULD COME OUT OF THE RUBBER MOLDING, ALLOWING THE WINDSHIELD GLASS TO SHIFT BACK APPROXIMATELY ONE INCH.

Remedy: ALL INVOLVED VEHICLES WILL HAVE THE MASK REFORMED AND A BRACKET WILL BE ADDED TO ENSURE THE RETENTION OF THE WINDSHIELD.

Reported: 1982-03-02 (March 2, 1982) · Model years: 1981, 1982

A POSSIBILITY EXISTS THAT IF THE CIGARETTE LIGHTER IS DEPRESSED, ENGAGING THE HEATING ELEMENT, LIGHTER MAY NOT AUTOMATICALLY "POP OUT" OR DISENGAGE. AS A RESULT, THE HEATING ELEMENT MAY CONTINUE TO HEAT TO HIGHER THAN NORMAL TEMPERATURES.

Remedy: DEALER WILL INSPECT AND, IF NECESSARY, REPLACE THE LIGHTER WITHOUT CHARGE.

Reported: 1982-05-12 (May 12, 1982) · Model years: 1981, 1982

SOME OF THE INVOLVED VEHICLES MAY DEVELOP CRACKS IN THE FRONT EXTENSION OF THE FRAME RAIL DUE TO DISCREPANCIES INVOLVING THE LOCATION OF A WELD STUD. IN THIS CONDITION, THE FRAME EXTENSION COULD SEPARATE.

Remedy: DEALER WILL INSPECT EXISTING FRAME EXTENTIONS AND, IF NECESSARY, REPLACE THEM AT NO COST TO OWNER.

Reported: 1992-12-23 (December 23, 1992) · Model years: 1981, 1982, 1983

SINGLE THICKNESS TETHER SAFETY BELTS CAN BREAK UNDER THE STRESSES CREATED DURING A VEHICLE CRASH. THE SAFETY BELTS DO NOT COMPLY WITH FMVSS 207 AND 210.

Consequence: BROKEN SAFETY BELTS DO NOT PROVIDE ADEQUATE PROTECTIONFOR SEAT OCCUPANTS IN THE EVENT OF A VEHICLE CRASH.

Remedy: REPLACE SINGLE THICKNESS TETHER SAFETY BELTS WITH DOUBLE THICKNESS TETHER BELTS.

Reported: 1988-07-25 (July 25, 1988) · Model years: 1988

DUE TO AN INCORRECT CAB SUPPORT LEG, THROTTLE ROD WHEN SEPARATED, COULD CAUSE THROTTLE LINKAGE TO LOCK IN THE FULL THROTTLE POSITION.

Consequence: IF THROTTLE LOCKED IN FULL THROTTLE POSITION WHILE THETRUCK IS MOVING, LOSS OF VEHICLE CONTROL COULD RESULT IN AN ACCIDENT.

Remedy: INSTALL A RESTRICTOR PLATE TO THE CAB LEG.

Reported: 2001-03-01 (March 1, 2001) · Model years: 1999

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH TIE ROD ASSEMBLIES MANUFACTURED BY TRW. THE SUSPECT TIE RODS CONTAIN 24-DL MODEL BALL SOCKETS. CERTAIN OF THE TIE ROD BALL-SOCKET BEARINGS HAVE A BELOW-SPECIFICATION CASE DEPTH AND/OR HARDNESS, WHICH CAN LEAD TO PREMATURE WEAR OF THE SOCKET.

Consequence: IF THIS CONDITION OCCURS, THE DRIVER CAN LOSE PARTIAL CONTROL OF THE RIGHT FRONT WHEEL, POSSIBLY RESULTING IN A CRASH.

Remedy: DEALERS WILL REPLACE THE DEFECTIVE BALL SOCKETS AND/OR DRAG LINKS. OWNER NOTIFICATION BEGAN ON APRIL 10, 2001, TO KENWORTH OWNERS AND ON APRIL 25, 2001, TO PETERBILT OWNERS. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KENWORTH AT 1-425-828-5000, PETERBILT AT 1-940-591-4000 OR TRW CUSTOMER SERVICE AT 1-866-280-3287.

Reported: 2001-08-28 (August 28, 2001) · Model years: 1999, 2000

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH TRW TIE ROD ENDS ON CERTAIN MERITOR AXLES. THE TIE ROD AND DRAG LINK BALL STUD ENDS CONTAIN BEARINGS THAT ARE BELOW THE SPECIFIED CASE DEPTH AND/OR HARDNESS.

Consequence: THIS CAN LEAD TO PREMATURE WEAR WITH POSSIBLE SEPARATION OF THE BALL STUD FROM THE SOCKET, INCREASING THE RISK OF LOSS OF CONTROL OF THE VEHICLE.

Remedy: DEALERS WILL REMOVE AND REPLACE ALL AFFECTED TIE RODS AND DRAG LINKS WITH DIFFERENT DESIGNED ENDS. OWNER NOTIFICATION BEGAN OCTOBER 24, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT PETERBILT AT 1-940-591-4000 OR KENWORTH AT 1-425-828-5000.

Reported: 2001-06-05 (June 5, 2001) · Model years: 1999, 2000, 2001

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS. A CHANGE IN THE INTERNAL LINKAGE OF CERTAIN CAB DOORS HAS CREATED A POSSIBLE BINDING CONDITION.

Consequence: IF THE LINKAGE BINDS, FULL ENGAGEMENT OF THE DOOR LATCH MAY NOT OCCUR, ALLOWING THE DOOR TO OPEN INADVERTENTLY.

Remedy: DEALERS WILL MODIFY THE DOOR LINKAGE TO CORRECT THE POTENTIAL OF BINDING. OWNER NOTIFICATION BEGAN JUNE 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT PETERBILT AT 1-940-591-4000.

Reported: 2002-07-15 (July 15, 2002) · Model years: 1999, 2000

HEAVY DUTY TRUCKS EQUIPPED WITH TRW TIE ROD ENDS ON CERTAIN ARVINMERITOR AND DANA AXLES. PETERBILT WILL RECALL 1,434 VEHICLES EQUIPPED WITH ARVINMERITOR AXLES MANUFACTURED FROM DECEMBER 11, 1999, TO MAY 14, 2000, AND FROM JULY 22 TO SEPTEMBER 30, 2000. KENWORTH WILL RECALL 859 VEHICLES EQUIPPED WITH ARVINMERITOR VEHICLES MANUFACTURED FROM DECEMBER 11, 1999, TO MAY 23, 2000, AND FROM JULY 27, 2000, TO SEPTEMBER 30, 2000 AND KENNWORTH WILL RECALL AN ADDITIONAL 4,151 VEHICLES EQUIPPED WITH DANA AXLES AND MANUFACTURED FROM JUNE 23 TO DECEMBER 6, 1999, AND FROM MAY 23 TO SEPTEMBER 30, 2000. THE TIE ROD AND DRAG LINK BALL STUD ENDS CONTAIN BEARINGS THAT ARE BELOW THE SPECIFIED CASE DEPTH AND/OR HARDNESS.

Consequence: THIS CAN LEAD TO PREMATURE WEAR WITH POSSIBLE SEPARATION OF THE BALL STUD FROM THE SOCKET, INCREASING THE RISK OF LOSS OF CONTROL OF THE VEHICLE.

Remedy: DEALERS WILL REMOVE AND REPLACE ALL AFFECTED TIE RODS AND DRAG LINKS WITH DIFFERENT DESIGNED ENDS. OWNER NOTIFICATION BEGAN JULY 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT PETERBILT AT 1-940-591-4201 OR KENWORTH AT 1-425-828-5440.

Reported: 2002-01-15 (January 15, 2002) · Model years: 2001

ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH MERITOR WABCO PNEUMATIC ANITLOCK BRAKE SYSTEM (ABS) VALVE PACKAGES, THE ASSEMBLY BOLTS ON THESE VALVE PACKAGES WERE NOT TIGHTENED CORRECTLY.

Consequence: BOLTS TORQUED BELOW SPECIFICATION WILL NOT RELIABLY PREVENT AIR LEAKAGE AT THE AFFECTED ABS VALVE PACKAGE INTERFACE JOINTS ONCE THE COMPONENT BEGINS NORMAL VEHICLE OPERATION. IF AIR LEAKS DEVELOP AT ANY OF THE ABS VALVE PACKAGE INTERFACE JOINTS, BRAKE SYSTEM PRESSURE REDUCTIONS COULD OCCUR DURING BRAKING OR NORMAL OPERATION WITH UNITS EQUIPPED WITH THE TRACTION CONTROL OPTION, POTENTIALLY EXTENDING STOPPING DISTANCES, POSSIBLY RESULTING IN A VEHICLE CRASH.

Remedy: DEALERS WILL TIGHTEN THE FASTENERS TO THE PROPER SPECIFICATION. OWNER NOTIFICATION BEGAN FEBRUARY 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KENWORTH AT 1-425-828-5440 OR PETERBILT AT 1-940-591-4201.

Reported: 2003-10-20 (October 20, 2003) · Model years: 2003

ON CERTAIN TRUCKS EQUIPPED WITH DANA SPICER INTEGRAL KNUCKLE AND STEER ARM ASSEMBLIES, THE STEER AXLE ASSEMBLIES MAY HAVE A LONGITUDINAL CRACK IN THE STEER ARM.

Consequence: IF THE CRACK SHOULD PROPAGATE OVER TIME, THE BALL COULD BECOME LOOSE RESULTING IN A LOSS OF STEERING, WHICH COULD RESULT IN A CRASH.

Remedy: DEALERS WILL INSPECT AND REPLACE THE KNUCKLE AND STEER ARM ASSEMBLIES. OWNER NOTIFICATION BEGAN JANUARY 5, 2004. OWNERS SHOULD CONTACT KENWORTH AT 1-425-828-5440 OR PETERBILT AT 1-940-591-4201.