Pierce ARROW recalls by model year

Reported: 1989-01-02 (January 2, 1989) · Model years: 1980, 1981

WITH BOTH PASSENGER SEAT BELTS IN USE, IN THE EVENT A HIGH SPEED COLLISION, THE MIDDLE SEAT BELT ANCHOR NUT AND BOLT MAY PULL THROUGH THE SHEET METAL FLOOR.

Consequence: VEHICLES WOULD NOT COMPLY WITH FMVSS 210.

Remedy: INSTALL MID ANCHOR REINFORCEMENT TO COMPLY WITH PULL TEST REQUIREMENTS OF FMVSS 210.

Reported: 2008-06-20 (June 20, 2008) · Model years: 1982, 1983, 1984, 1985, 1986, 1987, 1988, 1989, 1990, 1991

PIERCE IS RECALLING 2,372 MY 1982-1991 ARROW, MY 1983-1989 DASH, AND MY 1987-1989 DASH D8000 EMERGENCY VEHICLES EQUIPPED WITH TRW STEERING COLUMNS. THE LOWER END OF THE TRW STEERING COLUMN IS ATTACHED TO A 90 DEGREE GEAR BOX AS IT PASSES THROUGH THE FLOOR OF THE CAB. IF THE SHAFT IS NOT WELL ALIGNED WITH THE GEAR BOX INPUT, A SIDE LOAD IS INDUCED IN THE LOWER SHAFT BEARING. THIS SIDE LOAD CAN CAUSE BEARING FAILURE. IF THE LOWER STEERING COLUMN BEARING FAILS, THE BEARING RACE OR COMPRESSION SPRING CUTS INTO THE HOLLOW STEERING SHAFT TUBE.

Consequence: THIS FAILURE MOST LIKELY WILL OCCUR ON HIGH MILEAGE VEHICLES DURING LOW SPEED, HIGH STEERING EFFORT EVENTS, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE ORIGINAL TRW STEERING COLUMN WITH A NEW TRW STEERING COLUMN RETROFIT KIT. THE SAFETY RECALL BEGAN ON OCTOBER 15, 2008. OWNERS MAY CONTACT PIERCE AT 1-920-832-3000.

Reported: 1994-05-09 (May 9, 1994) · Model years: 1983, 1984, 1985, 1986, 1987, 1988, 1989, 1990, 1991, 1992, 1993

THE STEERING GEAR BRACKET USED TO MOUNT THE POWER STEERING GEAR TO THE CHASSIS FRAME CAN CRACK AND FAIL.

Consequence: THIS CAN CAUSE THE STEERING GEAR TO BIND, RESULTING IN A LOSS OF STEERING CONTROL AND A POSSIBLE ACCIDENT.

Remedy: DEALERS WILL INSPECT VEHICLES AND REPLACE THE BRACKETS WITH NEWLY DESIGNED BRACKETS. UNTIL REPLACEMENT BRACKETS ARE AVAILABLE, OWNERS ARE ADVISED TO INSPECT THE BRACKETS FOR CRACKS, AND CONTACT PIERCE MANUFACTURING FOR REPAIR INFORMATION.

Reported: 1990-01-18 (January 18, 1990) · Model years: 1989

CABLE PORTION OF SAFETY BELT ASSEMBLY (FEMALE RECEPTACLE MOUNTED INBOARD ON LEFT HAND SIDE, DRIVER'S SIDE, IN CREW CAB JUMP AREA) HAS BEEN TWISTED.

Consequence: TWISTING CABLE REDUCES ITS HOLDING CAPACITY AND SAFETY BOLT COULD FAIL IN A CRASH, INCREASING THE POTENTIAL FOR INJURY TO OCCUPANT.

Remedy: REPLACE SAFETY BELT ASSEMBLY.

Reported: 2011-07-26 (July 26, 2011) · Model years: 1995, 1996, 1997, 1998, 1999, 2000, 2001

PIERCE HAS DECIDED THAT CERTAIN MODEL YEAR 1995-2008 ARROW XT, DASH, CUSTOM CONTENDER, LANCE, ENFORCER, PIERCE ARROW, QUANTUM, SABER AND COMMERCIAL FIRE TRUCKS MANUFACTURED FROM JANUARY 2, 1995, THROUGH JANUARY 21, 2008, CONTAIN A SAFETY DEFECT. THESE VEHICLES ARE EQUIPPED WITH FUEL TANK STRAPS THAT MAY CORRODE DUE TO WINTER ROAD SALT OR LIQUID DE-ICING CHEMICALS. IF THE FUEL TANK STRAPS CORRODE SUFFICIENTLY, THE FUEL TANK SUPPORTING STRAPS MAY FRACTURE AND THE FUEL TANK MAY FALL FROM THE VEHICLE.

Consequence: THE VEHICLES MAY LOSE POWER AND STALL. IN ADDITION, THE FUEL TANK MAY RUPTURE AND SPILL DIESEL FUEL ON THE ROADWAY. EITHER OF THESE OUTCOMES MAY CAUSE A FIRE TRUCK OR SURROUNDING VEHICLES TO SLIP OR SLIDE ON THE ROADWAY SURFACE, INCREASING THE RISK OF A CRASH.

Remedy: FOR FIRE TRUCKS THAT ARE LESS THAN 10 YEARS OLD, DEALERS WILL INSPECT THE FUEL TANK STRAPS AND REPLACE THEM IF NECESSARY WITH STAINLESS STEEL STRAPS FREE OF CHARGE. FOR VEHICLES THAT ARE OLDER THAN 10 YEARS, PIERCE IS NOT OFFERING A FREE REMEDY, BUT WILL OFFER FOR PURCHASE REPLACEMENT FUEL TANKS STRAPS AND PROVIDE INSTRUCTIONS FOR INSTALLATION. THE SAFETY RECALL BEGAN ON AUGUST 27, 2011. OWNERS MAY CONTACT PIERCE AT 1-920-832-3000.