Rivian R1T recalls by model year

When driving on the highway with ADAS on with lane keeping assist turned on with software 2024.39.01, the truck would constantly pull me back into the center line even if I were not close to the white line on the road. This is very concerning as on a two-lane highway, it pulled me over the center line and towards an oncoming traffic. The latest software update seemed to make it more sensitive, not allowing "ping-ponging" and trying to keep the truck almost too centered, as other cars I have are not this aggressive. I ended up turning off LKA, b…

Look up ODI 11626599 at NHTSA ↗

Rivian passenger airbag is usually disabled (70 % cases) with adult passengers weighing about 125 lbs while they sit correctly in the front passenger seat. There is a warning light "Passenger airbag off". No problems with heavier passengers (> 140 lbs). There are tons of threads about this issue on Rivian forums, Reddit or Facebook groups. Based on these threads, sometimes Rivian service centers try to fix it (often unseccessfully) and sometimes they say it's normal. I've contacted a Rivian service through the Rivian app and they told me that i…

Look up ODI 11636817 at NHTSA ↗

Our rear passenger interior door handle stopped working today. We were unable to open the door from the inside of the car. I messaged Rivian support and we tried a software reset and checked to make sure the the child safety lock wasn’t on. Neither worked so I have scheduled a mobile service appointment for 2/11/2025. Checked inside the door panel and part of the door pull was broken off and loose inside the door. It looks like the cable barrel for the door release could have been anchored there a that was the point of failure.

Look up ODI 11640110 at NHTSA ↗

The front passenger seat sensor does not respond to a 135lb 5’9” person resulting in the airbag being disabled. This has been an issue since we purchased the vehicle and has not been resolved with 4+ visits to the service center. No other vehicles we have driven have ever had this problem.

Look up ODI 11641528 at NHTSA ↗

My driver side door intermittently does not close. There is something wrong with the latch. I called service center over 3 times and still haven’t been given any immediate appointment as the issue of safety is paramount, as I can’t drive with an open door. I still haven’t had this issue resolved.

Look up ODI 11643620 at NHTSA ↗

I Was driving down highway and receive a fe messages in quick order -front sensors off, front camera off, collision detection off, regenerative braking off - started moving toward right shoulder prior to pulling off - car lost speed at high rate putting me in jeopardy of being rear ended. 2025.06.012 code was loaded into truck the day before - this was first real drive after new code loaded into truck - early in the morning the warning for front sensors off, collision detection off, regenerative braking off did come and I pulled off and re…

Look up ODI 11650888 at NHTSA ↗

The vehicle brakes stopped working on the highway moving at 75 MPH. It felt like the brakes were locked mechanically after all the vehicle electronic fault codes appeared in the dash. The incident occurred [XXX] traveling down a highway right after a vehicle battery charge at a charging station. While driving, all error lights came on, including turtle mode, high voltage battery pack fault, front collision warning failure, failure in all 4 motors, failure of ABS and traction control, and most importantly failure in brake. Tried pulsating the …

Look up ODI 11656000 at NHTSA ↗

I believed my car had a problem with the seals of the windows allowing severe wind noise. After attempted repair the problem persisted and, on closer inspection, it became evident that the driver side door is mis-installed and crooked. Rivian attempted to reprair this and only made it worse. The amount of wind/road noise that is coming in now is as if the windows was open. The door frame vibrates and whistles at speed. The mobile tech doesn't feel this is repairable but Rivian won't take responsibility for it. They have denied my BBB clai…

Look up ODI 11653133 at NHTSA ↗

The entertainment and gauge cluster displays begin to slow down and stutter, eventually leading to a full reboot. This causes the ADAS view, as well as the blind spot cameras, and reverse camera to display a still image, even while the vehicle is moving, or display no image at all. Also, if this happens while Highway Drive Assist is active, the state of the system is not displayed and an audible chime is played.

Look up ODI 11657290 at NHTSA ↗

Defective charge port door that has no manual release. If it gets stuck, the vehicle can no longer be charged, potentially stranding the driver. Only solution is a service visit.

Look up ODI 11662670 at NHTSA ↗

Catastrophic failure of rear upper control arm / suspension resulting in temporary loss of control. Occurred driving straight at 35mph without any prior damage or symptoms.

Look up ODI 11663157 at NHTSA ↗

The vehicle caught fire and was completely destroyed. The fire was due to an electrical or battery system defect.

Look up ODI 11662648 at NHTSA ↗

The suspension system has failed three times. The entire system has been replaced by the dealership twice under warranty. The most recent failure has not been addressed, as the dealer is now refusing to make further repairs. The suspension issues significantly affect vehicle handling and steering during normal operation. Under heavy acceleration, the vehicle becomes difficult to control, posing a serious safety risk.

Look up ODI 11676429 at NHTSA ↗

Rivian R1T was brought to independent tire center for tire rotation on same day before 1,000 mile trip. Technician documented: "Drivers side front CV axle bolt almost completely backed out". Bolt took less than one rotation by hand to come off. Documented by tire shop technician. - Possible safety impact by possible failure of half-shaft and loss of steering control and/or wheel loss - The vehicle is scheduled for an inspection by manufacturer July 14, 2025 - There were no warnings or symptoms prior to discovery

Look up ODI 11671561 at NHTSA ↗

Tonight starting at 7:15pm to 8:00pm vehicle switched from all lights +foglights on to daytime driving lights or parking lights. It did this three times. I live in rural setting with hardly any public lighting and a lot of wildlife. I have contacted Rivian regarding this issue multiple times, they tell me the auto high beam selector must be on, auto high beam is not on, they tell me it must be a setting I enabled to which I sent them a recording of the settings showing them I have not enable any settings and anyhow why would auto high beam set…

Look up ODI 11684022 at NHTSA ↗

I was shifting my truck from park to reverse when the shift handle snapped off. There was no warning and I had just driven the vehicle a couple hours earlier. The truck only has 13k miles on it.

Look up ODI 11682044 at NHTSA ↗

HVAC dumping water into drivers side carpet, creating mold, mildew, and slippery carpet. Vehicle was at Rivian service center 2 weeks ago to address this and other issues. This problem continues. Not sure if water is also intruding into electrical areas.

Look up ODI 11684320 at NHTSA ↗

while driving on 85 south warning message appeared.

Look up ODI 11684321 at NHTSA ↗

Vehicle lurched to a stop in a parking lot, unable to shift into gear. Warnings: “motor fault detected”, “system fault detected”, “all wheel drive permanently engaged”, “replace 12v battery. “ Currently being repaired under manufacture warranty. Manufacturer confirmed drive unit needed to be replaced. This could have been a terrible accident if it happened on the freeway. My wife and dog were in the car with me. There were no warning signs leading up to this moment. We were stranded 400 miles from home and needed several tows to get home a…

Look up ODI 11685730 at NHTSA ↗

I was driving about 35-40mpg when the right rear toe link snapped due to inproper torquing. I believe the bolt had backed out then snapped. When I contacted rivian they initially blamed me for it before even in before inspecting the vehicle. Once they inspected it they stated it would be covered under warranty. There was no paint on the bolt to show proper torque had been applied. Which is a standard process for rivian. I had asked them to please check the left rear toe link as well and make sure it’s all torque properly or even replace the…

Look up ODI 11691374 at NHTSA ↗

The vehicle’s Driver+ advanced driver assistance system (including Adaptive Cruise Control and Highway Assist) repeatedly failed during normal highway driving. The system would display “Driver Assistance Features Unavailable – Service Soon” and immediately disable all assisted-driving functions, even in clear weather and well-marked lanes. This occurred intermittently from approximately 1,200 miles onward and continued for over a year despite multiple repair attempts by the manufacturer’s service centers. The malfunction directly affected safe…

Look up ODI 11694627 at NHTSA ↗

My truck was recently upgraded to software version 2050.38.0. After the upgrade, I drove my truck about 3 miles in about 5 minutes. When I arrived at my destination, I exited the truck to get something out of the rear seat. The rear door was locked; this is normal. I returned to the front seat to unlock the door via the control panel, but the unlock function did not work. The button is in the center touchscreen of the truck. I check the screen on the center console. It appeared the unlock button was disabled due to the information screen f…

Look up ODI 11696263 at NHTSA ↗

the electronic door handles are malfunctioning and not opening or staying open. when they stay in and dont present, the door remains locked and cannot be opened from the outside. This is a safety hazard if an occupant cannot exit the vehicle in an emergency and the door cannot be opened from the outside. I have already had one (drivers door) replaced and now both rear passenger doors are malfunctioning. this is an intermittent problem. I believe this to be a manufacturing defect that should be covered at the cost of the manufacturer.

Look up ODI 11698427 at NHTSA ↗

Vehicles Steering wheel shakes when traveling over 20mph. Dealer has reproduced the problem multiple times but insists it’s a “design limitation”. The shaking can cause loss of control of the vehicle. Dealer refuses to investigate further. This has been occurring since day of purchase.

Look up ODI 11696910 at NHTSA ↗

The car while driving at normal highway speeds announced that there was a high risk of electrocution associated with driving in wet conditions. This was via a red screen in the driver display. Car is 2025 R1T with 15,000 miles on it. Anyway near the vehicle was at risk of being exposed to 400v electricity.

Look up ODI 11703602 at NHTSA ↗

When it rains, or water is allowed to collect on top of the roof, water seeps in through the hinges of the driver and passenger sun visors. Depending on how much water is allowed to collect, it can trickle in or gush right inside the interior of the vehicle. Not only can it come in thru the sun visor hinges, but water also came out of my center roof console where my hazards and SOS button are at, causing me to worry about a water + electricity issue. Furthermore, the water obviously gets the carpeted floor wet. My truck is in the Van Nuys Rivi…

Look up ODI 11708829 at NHTSA ↗

The contact owns a 2026 Rivian R1T. The contact stated that upon starting the vehicle, the messages "Service Parking Brake - Vehicle Unable to Drive" and "Secure Vehicle to Keep from Rolling" were displayed. The vehicle was towed to a service center, where an unknown repair was performed; however, the failure recurred two weeks later. The contact stated that upon verifying the vehicle service history on the Mobile App, the history only listed the infotainment system service. Additionally, a Rivian technician had serviced the vehicle at the resi…

Look up ODI 11713401 at NHTSA ↗

Initially, my instrument screen on my vehicle went black and stopped working. I had to drive roughly 10 miles home without the use of my speedometer. After replacing the AXM module, the cruise control and lane-keeping functions intermittently stop working. The vehicle was at the service center on and off for 57 days before it was returned to me without a resolution. I’m told this issue is affecting 30 vehicles in the Rivian fleet; however, they don't yet have a permanent fix. I brought up my safety concerns and was assured that this issue will…

Look up ODI 11715815 at NHTSA ↗

My vehicle is subject to an active safety recall involving a rear toe bolt that Rivian has identified as potentially shearing and causing loss of vehicle control and a crash. I am located in Ketchikan, Alaska. Rivian does not offer mobile or field service for this recall and requires the vehicle to be transported to either Anchorage or Seattle for repair. Transport to Anchorage is not possible, and while transport to Seattle is possible, there is no viable or predictable way to return the vehicle to my location, potentially leaving me without m…

Look up ODI 11716708 at NHTSA ↗

No changes to the car happened before the airbag system went out.

Look up ODI 11720146 at NHTSA ↗

The vehicle experienced a failure of the air suspension system, initially presenting with warnings indicating the vehicle was raising and advising not to drive to avoid damage. Shortly thereafter, the vehicle became visibly uneven, tilting approximately 2–3 inches to the driver side. I took the vehicle to Rivian service, where they confirmed the air suspension had failed. The repair was not covered under warranty, so I initially declined service while attempting to escalate the issue. During this time, the condition worsened significantly, with…

Look up ODI 11726980 at NHTSA ↗

Incident Overview: In late February 2026, at approximately 114,000 miles, this 2022 Rivian R1T suffered a comprehensive failure of its kinetic (hydraulic) suspension system. The failure occurred during normal on-road operation at approximately 60 mph in temperate (60°F) conditions. The vehicle has no history of off-road use or heavy hauling. Safety Risk & Critical Failure Mode: The suspension is a safety-critical system essential for vehicle stability, emergency braking, and predictable handling. A loss of hydraulic integrity in this system di…

Look up ODI 11728138 at NHTSA ↗

While traveling at highway speed on Interstate 95, the vehicle experienced a complete and sudden loss of propulsion. The vehicle would not respond to the Vehicle Restart function. The driver was able to safely pull to the shoulder from the right lane. The vehicle was towed to a Rivian service center, where technicians identified a low-voltage event matching a known Rivian engineering investigation. Rivian confirmed no current repair exists and that engineering is actively working on software improvements. The vehicle was returned unrepaired aft…

Look up ODI 11721867 at NHTSA ↗

2022 Rivian R1T, VIN [XXX] . Recurring suspension defects since delivery June 2022, documented across 18 service visits over 3.5 years. Rivian performed multiple repairs including Gen 2 suspension component replacement. This defect has never been permanently resolved. On July 11, 2025, El Segundo service center [XXX] ) repaired the front end lowering in standard parking mode , causing the vehicle to sit unlevel and knock the tires out of alignment when driving off. They repaired the suspension and corrected the alignment. In August 2025 a rela…

Look up ODI 11728560 at NHTSA ↗

2022 Rivian R1T, VIN [XXX] . On March 14, 2026, my service appointment at El Segundo Rivian service center [XXX] ) was deleted from the Rivian app along with all service requests and a timestamped customer message thread documenting my visit that day. Deleted items included active recall remedies FSAM-1795 (seat belt retractor bolts improperly torqued, NHTSA notification mailed ~March 9, 2026) and FSAM-1794 / NHTSA 26V003 (rear toe link improper reassembly, risk of joint separation while driving, notification mailed ~February 24, 2026), plus t…

Look up ODI 11728566 at NHTSA ↗

I was driving late night to a campsite in a very rural part of the Big Island of [XXX] , about 45 minutes from where I live. I was by myself except for my dog, in the passenger seat. I was on a country road with a 30 mph speed limit, going about 25 mph. I engaged the cruise control and it immediately went up to 40-45 mph, far faster than the limit and far faster than was safe given the wet conditions and windy road. As I tried to slow the car down, using the steering while cruise control adjustment buttons, I steered through a curve and rathe…

Look up ODI 11729578 at NHTSA ↗

Rear Suspension Dampers leaking prematurely which could cause unsafe driving issues.

Look up ODI 11736755 at NHTSA ↗

I was driving to a restaurant and out of nowhere started hearing this metal-on-metal sound 1/4 mile before I got there. I pulled into the parking lot and it kept getting worse, so I called Rivian to tow the car. They confirmed it was a hub and shaft bolt that came loose. I have video of the sound it made if needed. The Rivian technicians took the pictures that I am uploading here.

Look up ODI 11739639 at NHTSA ↗

Vehicle gave a warning to service the electrical system and then shut down preventing any operation. Luckily I was in a parking lot and not on a roadway impeding traffic or jeopardizing safety while driving. Could smell burnt electrical from within cabin. Had to have towed to service center and explained that condensation from air conditioner leaked onto high voltage heater coils and shorted out electrical system. Seems like a poor design that this was even possible. Dealer indicated this was not uncommon.

Look up ODI 11742855 at NHTSA ↗

The R1T has four cameras to assist the driver and provide warnings for lane changes, etc. The cameras are routinely failing while I am driving the vehicle. This started after an OTA software update. A software reset will turn the cameras back on, though they have repeatedly failed. Rivian attempted to correct the issue by replacing the front camera, which they determined was faulty. The cameras have continued to fail since then.

Look up ODI 11745247 at NHTSA ↗

This vehicle has experienced two separate failures of the high-voltage (HV) battery pack, each resulting in a different drive unit being damaged and total loss of electrical systems while driving. First incident (July 28, 2025): While driving, all warning lights illuminated and the vehicle indicated a possible electrical hazard. The vehicle lost power completely. It was taken to a Rivian service center on July 29, 2025, and was not returned until August 15, 2025 , a total of 17 days out of service. Rivian’s technicians found multiple faults in …

Look up ODI 11747254 at NHTSA ↗

In July of 2025 while driving my entire air suspension collapsed on the highway slamming the vehicle down onto it's bumpstops. Rivian covered a "fix" of this under warrant. In December the rear shock was leaking. Now in July of this year while driving the front air suspension collapsed to it's bump stop again.

Look up ODI 11748125 at NHTSA ↗

2024 Rivian R1T has a persistent pulling defect and safety hazard. Four repair attempts at Rivian Denver Service Center all failed: 1. Jul 16, 2025 - WO-1452784, 16,117 mi: Alignment performed. Defect continued. 2. Aug 11, 2025 - WO-1530133, 16,936 mi: Same-day return. Second alignment. Defect continued. 3. Nov 3-4, 2025 - WO-1745098, 20,520 mi: Rivian lead technician ride-along confirmed pull in writing: "After 2 alignments, vehicle is still pulling. Confirmed by lead technician." Tire rotation attempted. Defect continued. 4. Dec …

Look up ODI 11748570 at NHTSA ↗

On February 15, 2025, Rivian performed Field Service Action FSAM-1507 on my 2024 Rivian R1T at 11,590 miles. Hub-to-knuckle fasteners were found loose in four structural locations. This was identified as a safety-related field service action. A second field service action, FSAM-1678 (front halfshaft NVH washers), was performed November 3–4, 2025. I am reporting both actions to create a federal record of the structural safety deficiencies in this vehicle.

Look up ODI 11748574 at NHTSA ↗

SYSTEMS AFFECTED: Electrical System (12V Power Supply / Low-Voltage), Climate Control (HVAC System / Thermal Management), Towing / Recovery DESCRIPTION OF SAFETY HAZARD & DEFECT: My 2022 Rivian R1T experienced a sudden, complete electrical failure due to a defective HVAC system, resulting in a dangerous hard-bricked state that rendered the vehicle totally inoperable. Approximately 30 days prior to the incident, the vehicle underwent a comprehensive inspection at a Rivian Service Center where both the HVAC system and 12-volt battery system were …

Look up ODI 11755183 at NHTSA ↗

After gently removing the fabric cover of our Cybex Eternis S All-In-One car seat to wash it according to the manufacturer's care instructions, and then putting the cover back on, the car ride immediately following, the red plastic pieces designed to hold the cover in place completely snapped off. This structural failure exposed two sharp, unshielded metal screws directly in the child's seating area. Because these screws were left fully exposed by the broken plastic, they created an immediate laceration hazard. As a direct result of this defect…

Look up ODI 11756504 at NHTSA ↗

Was parking and when I hit the park button. A lot of error lights came on. After a reset, I have an Airbag needs service error.

Look up ODI 11760048 at NHTSA ↗

The seat belt came completely dislodged from the seat base as my passenger was getting into the car and fastening their seat belt

Look up ODI 11761200 at NHTSA ↗

I am reporting repeated suspension and structural failures involving my 2022 Rivian R1T. In April 2026, at approximately 90,537 miles, Rivian performed a comprehensive inspection and found both front lower control arm bushings torn, the right rear damper leaking, and the rear subframe cracked. Rivian’s own service documentation specifically stated that the vehicle was “unsafe to operate due to damage to the rear subframe” and recommended that the vehicle be towed. Rivian subsequently replaced the rear subframe, both front lower control arms, …

Look up ODI 11763217 at NHTSA ↗

The 12v battery died in less than 3 years. Rivian replaced at cost over $500. Unacceptable. Their new battery only warrenty for 2 years.

Look up ODI 11762549 at NHTSA ↗