Sutphen CHASSIS recalls by model year

Reported: 2004-06-07 (June 7, 2004) · Model years: 1996, 1997, 1998, 1999, 2000, 2001, 2002, 2003, 2004

ON CERTAIN EMERGENCY/FIRE/RESCUE SINGLE AND TANDEM AXLE CHASSIS, THE BRAKE AIR LINES MAY HAVE BEEN INCORRECTLY ROUTED.

Consequence: IF THE PRIMARY SYSTEM MALFUNCTIONED TO THE POINT OF COMPLETE FAILURE, THE IMPROPER ROUTING WOULD CAUSE THE REAR BRAKES TO BECOME DISABLED THUS REQUIRING THE VEHICLE TO STOP USING ONLY THE FRONT BRAKES, WHICH COULD INCREASE THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT AND CORRECT THE ROUTING OF THE BRAKE LINES. SUTPHEN HAS INSPECTED AND CORRECTED ALL VEHICLES INVOLVED IN THIS CAMPAIGN.

Reported: 2008-02-25 (February 25, 2008) · Model years: 2006

SUTPHEN IS RECALLING 56 MY 2006 FIRE TRUCK CHASSIS EQUIPPED WITH TRW STEERING GEARS, MODELS TAS85. THESE STEERING GEARS CONTAIN POTENTIALLY DEFECTIVE SECTOR SHAFTS WITH AN INCORRECT GEAR TOOTH WHICH MAY INTERFERE WITH THE RACK-PISTON TEETH, RESULTING IN A STICKING OR BINDING CONDITION.

Consequence: THIS CONDITION HAS THE POTENTIAL TO CAUSE THE STEERING GEAR TO STALL AND RESTRICT THE STEERING TURNING ANGLE OF THE VEHICLE WHICH COULD RESULT IN A VEHICLE CRASH.

Remedy: SUTPHEN IS WORKING WITH TRW TO REPLACE THE DEFECTIVE STEERING GEAR (PLEASE SEE 07E101). THE RECALL BEGAN ON MARCH 3, 2008. OWNERS MAY CONTACT TRW AT 765-429-1768 OR SUTPHEN AT 1-866-287-5549.

Reported: 2010-09-14 (September 14, 2010) · Model years: 2006, 2007, 2008

SUTPHEN IS RECALLING CERTAIN MODEL YEAR 2006-2008 AERIALS AND MODEL YEAR 2007-2008 PUMPER FIRE TRUCKS EQUIPPED WITH DETROIT DIESEL SERIES 60 ENGINES. THE SOFTWARE ON THESE ENGINES MAY CAUSE THE ENGINE TO SHUT DOWN UNEXPECTEDLY WHEN A DIESEL PARTICULATE FILTER OVER-TEMPERATURE CONDITION IS DETECTED.

Consequence: UNEXPECTED EMERGENCY VEHICLE ENGINE SHUTDOWN INCREASES THE RISK OF A CRASH AND COULD HAMPER RESCUE OPERATIONS AND PUT THE TRANSPORTED PASSENGER AT RISK.

Remedy: SUTPHEN WILL NOTIFY OWNERS AND DETROIT DIESEL WILL REPAIR THE VEHICLES FREE OF CHARGE BY REPROGRAMMING THE ENGINE MOTOR CONTROL MODULE. PLEASE SEE DAIMLER TRUCKS/DETROIT DIESEL'S DEFECT REPORT 10E-005. THE SAFETY RECALL BEGAN NO OCTOBER 15, 2010. OWNERS MAY CONTACT DETROIT DIESEL AT 1-800-547-0712 OR ON LINE HTTP://WWW.DETROITDIESEL.COM/SUPPORTNETWORK.

Reported: 2011-12-14 (December 14, 2011) · Model years: 2010, 2011, 2012

SUTPHEN IS RECALLING CERTAIN MODEL YEAR 2009 THROUGH 2012 VEHICLES AND EQUIPPED WITH MERITOR WABCO ELECTRONIC STABILITY CONTROL (ESC) MODULES. SEE THE LIST ABOVE FOR THE AFFECTED MODELS. UNDER CERTAIN ROAD AND DRIVING CONDITIONS, VEHICLE BODY ROLL AND ROAD INCLINATION CHARACTERISTICS MAY ADVERSELY AFFECT THE SLIP ANGLE CALCULATION OF THE ELECTRONIC STABILITY CONTROL (ESC) SYSTEM. THIS MIGHT CAUSE THE ESC TO PERCEIVE AN OVER STEERING SITUATION AND THEREFORE APPLY THE OUTER WHEEL BRAKE ON THE FRONT AXLE UNTIL THE VEHICLE IS PERCEIVED TO BE STABLE.

Consequence: IF THE DRIVER IS SLOW TO REACT DURING THIS ESC INTERVENTION, THE VEHICLE MAY DEVIATE FROM THE INTENDED LINE OF TRAVEL, INCREASING THE RISK OF A CRASH.

Remedy: SUTPHEN IS WORKING WITH MERITOR WABCO TO REPLACE THE CONTROL MODULE FREE OF CHARGE. PLEASE SEE MERITOR WABCO DEFECT REPORT 11E-039. THE SAFETY RECALL BEGAN ON DECEMBER 16, 2011. OWNERS MAY CONTACT MERITOR ON TRACK CUSTOMER SERVICE AT 1-866-668-7221.