| Electrical System | 3737.4%ODI 11443354The 2021 RAV4 Prime has a known defect with the heat pump causing an alarming sound to be heard within about a 1 minute of startup. The grinding noise causes distraction as it is extremely loud and occurs generally while backing out/maneuvering in tight areas. Toyota released a Service Bulletin in their European Market in October (numbered BE-00612T-TME - "Train Horn noise" from A/C compressor when the vehicle is started), but has not made available the same fixes in the US even months later. Look up ODI 11443354 at NHTSA ↗ | 733.3%ODI 11559943The contact owns a 2022 Toyota Rav4 Prime. The contact received notification of NHTSA Campaign Number: 23V478000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms part… Look up ODI 11559943 at NHTSA ↗ | 3656.3%ODI 11643057The primary instrument display started to go out when it was cold, below 50'F. This could be mitigated by running the engine or running the defrost for a period of time to warm up the area around the display. When it was too cold this winter, that was no longer effective and the display would not come on at all. The car would drive and all of the instruments displayed on the screen would work (cruise control, etc.), but there was no way to know how fast I was going and if there were any warning lights illuminated. Running the car long enoug… Look up ODI 11643057 at NHTSA ↗ | 931.0%ODI 11566051Bought brand new car from Toyota. While driving on Highway at 60 mph car suddenly went dead and catastrophic warning showed up on dash. Was barely able to pull over to side of road. Very dangerous. Had car towed to Toyota who informed me that battery was defective in cold weather and went dead. Battery replaced. Recall inspection is warranted. Look up ODI 11566051 at NHTSA ↗ |
|---|
| Unknown Or Other | 2424.2%ODI 11418659A few months ago I experienced multiple instances of my car self-starting while parked in my garage. I contacted the dealer and then Toyota. In April I received an email/letter stating that the problem had been corrected. However, just this week the problem returned, starting twice two days ago. I have just notified Toyota again and await a response, but due to the safety implications of this issue I am notifying the NHTSA. The safety implications of a car starting without provocation are obvious; for example, a child could climb inside a… Look up ODI 11418659 at NHTSA ↗ | 628.6%ODI 11547608I was driving on a highway going around 45 mph. The sun/moon roof exploded. I wasn't under anything that could have fallen, no cars were around and I did not see anything in the air. It was sunny, 67 degrees with a breeze. This happened on Sunday so no confirmation or inspection has occurred. No warning lamps or messages appeared either before or after it exploded. I do know that Rav4 Prime's will display messages when things break including windows as I was rear-ended and the car was telling me the windows were broken. I called state patrol an… Look up ODI 11547608 at NHTSA ↗ | 1929.7%ODI 11516061Sliding sun roof glass explosion while driving. Glass is clearly projected to the exterior of vehicle and not due to stone/rock hit. No overpass or vehicles in front of driver at the time. No other damage to vehicle. Serious injury could occur when glass falls into the passenger compartment of the vehicle cutting or blinding the driver. The Dealer/Certified Toyota service center replaced the glass under warranty after inspecting the broken sun roof glass. Look up ODI 11516061 at NHTSA ↗ | 620.7%ODI 11581496Panoramic sunroof shattered while my wife was driving down the freeway. No object struck the sunroof but while she was driving it sounded like a shotgun went off and the panoramic roof was shattered. Look up ODI 11581496 at NHTSA ↗ |
|---|
| Service Brakes | 1616.2%ODI 11395499 · 9,300 miI AM EXPERIENCING INCONSISTENT BRAKE FEEL AFTER ABS ACTUATION DURING SLOW AND STEADY APPLICATION OF THE BRAKES ON ROUGH OR SLICK ROAD SURFACES. STOPPING DISTANCES ARE INCREASED COMPARED WITH MY EXPECTATION FOR A GIVEN PEDAL FORCE. PLEASE NOTE THAT THE 2010 TOYOTA PRIUS HAD A SIMILAR ISSUE, AND A RECALL WAS ISSUED UNDER NHTSA CAMPAIGN 10V039000. Look up ODI 11395499 at NHTSA ↗ | 314.3%ODI 11500714This happened to me today but I have also recently heard about another report of the same (facebook rav4 prime web page) I started the car, it had sufficient battery so was in ‘EV’ mode. I placed it in reverse with my foot on the brake pedal. I waited a couple seconds for one reason or another and with my foot still firmly on the brake pedal it started moving in reverse. I pushed the brake pedal extraordinarily hard and the car stopped after a few feet. No incident precipitated from this but I’m keenly aware of the potential. At the moment I c… Look up ODI 11500714 at NHTSA ↗ | 46.3%ODI 11536313Driver was parking the car in a parking lot at a very slow speed. The car suddenly shot forward at a very high rate of speed, requiring evasive steering from trees and a fence, until the car crashed head-on into another vehicle. The driver is very certain the brakes only were applied during the entire time the car shot forward. Airbags were not deployed. Bystanders were within six feet of the car at one point during the acceleration, prior to the crash. There were no injuries. Earlier, on the day of the crash, the car had a sudden, stro… Look up ODI 11536313 at NHTSA ↗ | 413.8%ODI 11608693I have owned vehicle for 3 months. Noticed loud banging sound whenever brakes are applied at low speeds, on rough bumps/rough road. At times banging is loud enough to sound like vehicle hit something. No issues with braking currently. Not sure if noise is from ABS but sound is coming from front and back. Toyota inspected vehicle and said sound is the ABS activating..."totally normal for newer hybrids and no fix at this time...test drove other 2024 Rav4 Primes and all had same noise". TAS#242180433. No accident/incident to report at this time, h… Look up ODI 11608693 at NHTSA ↗ |
|---|
| Fuel/Propulsion System | 1818.2%ODI 11388815 · 700 miCAR HAS 750 MILES FROM NEW. FUEL GUAGE DISPLAY 3/4 FULL WHEN TANK IS ACTUALLY FULL.. CAUSES OVERFILLING AND LACK OF TRUST IN GUAGE READING. ALSO CAUSES CHARCOAL FILTER TO FILL WITH GAS. CAUSING IT TO FAIL. IN ADDITION CHECK ENGINE LIGHT TO DISPLAY GENERATING NUMEROUS FAULTS COMES. ALL REQUIRE IMMEDIATE DEALER ATTENTION. NO DRIVE CONDITION. Look up ODI 11388815 at NHTSA ↗ | 14.8%ODI 11731867Incident Detail: In April 2026, my 2022 Toyota RAV4 Prime (VIN: [XXX] ) suffered a critical failure where the charging cable became physically locked in the vehicle’s high-voltage (HV) charging port. I transported the vehicle to Ken Garff Cheyenne (authorized Toyota dealer), where management allowed non-certified, non-technical staff to perform unauthorized physical interventions on the HV port. No manufacturer-certified technician was provided for a safe diagnostic. Safety Hazard and Immediate Consequence: Following these unauthorized interve… Look up ODI 11731867 at NHTSA ↗ | 23.1%ODI 11536313Driver was parking the car in a parking lot at a very slow speed. The car suddenly shot forward at a very high rate of speed, requiring evasive steering from trees and a fence, until the car crashed head-on into another vehicle. The driver is very certain the brakes only were applied during the entire time the car shot forward. Airbags were not deployed. Bystanders were within six feet of the car at one point during the acceleration, prior to the crash. There were no injuries. Earlier, on the day of the crash, the car had a sudden, stro… Look up ODI 11536313 at NHTSA ↗ | 13.4%ODI 11719372Affidavit (present first party experience) and Exhibits (proof of claim) In support of claim (complaint) For damages (harm, injury, tort) 1. My legal name is [XXX] . 2. I purchased a 2024 prius prime in tupelo, Mississippi on 09/02/2025. 3. I traded in a prius i had purchased in idaho falls, id in february 2024 for the new 2024 prius prime. 4. My prius trade in was financed with TOYOTA financial (TOYOTA motor corporation). 5. I purchased a new 2024 TOYOTA pruis prime from TOYOTA carlock in tupelo, ms with odometer statement of "10 miles". 6. Th… Look up ODI 11719372 at NHTSA ↗ |
|---|
| Forward Collision Avoidance: Automatic Emergency Braking | 88.1%ODI 11458186On March 19, 2022 I was attempting to make a left turn onto a five lane (including the center left turn lane) road. When the traffic cleared my car (a plug-in hybrid in EV mode) did not accelerate as it usually does, but slowly rolled into the first lane of traffic. I pushed the accelerator to the floor but it stopped in the traffic lane. I had to quickly select reverse and back out of the first lane of oncoming traffic. Luckily the car behind me had not moved up and I had room to avoid an accident. This seemed like it may have been a failur… Look up ODI 11458186 at NHTSA ↗ | 14.8%ODI 11463453The Toyota pre-collision braking system is too slow to release control of the throttle back to the driver. Multiple times it has made the car behave in an unexpected fashion in traffic. The most common scenario is when the driver is stopped and turning left onto a busy street. When a car passes in front of you and you try to accelerate after it passes, the pre-collision braking still thinks there's a car in front of you. Instead of acceleration your car just gently rolls into the street. The driver can't do anything in the moment to override… Look up ODI 11463453 at NHTSA ↗ | 23.1%ODI 11632869I slowly turned right into a parking space, braked to stop but the car didn't stop and instead lurched, jumping forward over the parking curb and hitting a small wall. My foot was on the brake pedal the entire time. It happened at 9:00am on a clear day. I was alone in the car and uninjured. Damage to the car was extensive and estimated at nearly $40,000. As a result, car was totaled by the insurance company. Look up ODI 11632869 at NHTSA ↗ | 13.4%ODI 11676998The driver was pulling into a friend's carport. After crossing a small curb her foot was taken off the gas and was moving to the brake. The car was going slightly uphill as slow as a car can go with no gas pedal depressed. The car then accelerated as if someone pressed the gas to the floor. In a matter of 8 feet it gained enough speed and momentum that when it hit our friend's parked car the 4 door SUV was pushed forward 4 feet. The gas pedal was never pushed by the driver. No failed component was ever identified by multiple inspections by the … Look up ODI 11676998 at NHTSA ↗ |
|---|
| Power Train | 55.1%ODI 11519151Car won't accelerate for about 1 to 2 seconds from stopped. Didn't have the issue before the 23TA01 recall performed at the Dealership. Look up ODI 11519151 at NHTSA ↗ | 314.3%ODI 11463453The Toyota pre-collision braking system is too slow to release control of the throttle back to the driver. Multiple times it has made the car behave in an unexpected fashion in traffic. The most common scenario is when the driver is stopped and turning left onto a busy street. When a car passes in front of you and you try to accelerate after it passes, the pre-collision braking still thinks there's a car in front of you. Instead of acceleration your car just gently rolls into the street. The driver can't do anything in the moment to override… Look up ODI 11463453 at NHTSA ↗ | 11.6%ODI 11632869I slowly turned right into a parking space, braked to stop but the car didn't stop and instead lurched, jumping forward over the parking curb and hitting a small wall. My foot was on the brake pedal the entire time. It happened at 9:00am on a clear day. I was alone in the car and uninjured. Damage to the car was extensive and estimated at nearly $40,000. As a result, car was totaled by the insurance company. Look up ODI 11632869 at NHTSA ↗ | 26.9%ODI 11605531I have oiwned the car for 3 months and there has not been a problem previously. As I was pulling into a parking space at work, going less than 5 mph, i took my foot off the accelerator and coasting in while intending to brake, stop, and turn the car off. Suddenly, the car accelerated forward quickly, propelling the car over a tall curb, over a small grassy area, and onto the open parking lot. I subsequently applied the break, the car stopped, I drove back to the same spot. and was able to park and turn the car off. A report was filed with … Look up ODI 11605531 at NHTSA ↗ |
|---|
| Vehicle Speed Control | 44.0%ODI 11467556We have COMPLETELY lost brakes on MULTIPLE occasions for a few seconds per occasion. Brake loss has occurred upon slow, even braking and on flat, dry, even pavement with no pot poles or loose gravel around. When this happens, an orange light appears on the dash, we lose brakes for a few seconds, the car regains brakes, and jolts forward with no change in foot position on the brake pedal. We have taken the car to the dealer multiple times and every single time this incident has occurred the rear right wheel speed shows about a 10% variation in s… Look up ODI 11467556 at NHTSA ↗ | 00.0%No examples available for this selection. | 69.4%ODI 11536313Driver was parking the car in a parking lot at a very slow speed. The car suddenly shot forward at a very high rate of speed, requiring evasive steering from trees and a fence, until the car crashed head-on into another vehicle. The driver is very certain the brakes only were applied during the entire time the car shot forward. Airbags were not deployed. Bystanders were within six feet of the car at one point during the acceleration, prior to the crash. There were no injuries. Earlier, on the day of the crash, the car had a sudden, stro… Look up ODI 11536313 at NHTSA ↗ | 13.4%ODI 11676998The driver was pulling into a friend's carport. After crossing a small curb her foot was taken off the gas and was moving to the brake. The car was going slightly uphill as slow as a car can go with no gas pedal depressed. The car then accelerated as if someone pressed the gas to the floor. In a matter of 8 feet it gained enough speed and momentum that when it hit our friend's parked car the 4 door SUV was pushed forward 4 feet. The gas pedal was never pushed by the driver. No failed component was ever identified by multiple inspections by the … Look up ODI 11676998 at NHTSA ↗ |
|---|
| Visibility/Wiper | 33.0%ODI 11719816Close the door and the rear view window shattered. Look up ODI 11719816 at NHTSA ↗ | 00.0%No examples available for this selection. | 11.6%ODI 11716205The digital instrument cluster display failed completely while the vehicle was in operation. The speedometer, warning indicators, and safety alerts were not visible, making it unsafe to drive due to inability to monitor speed or receive critical warnings. There were no prior warning messages before the failure occurred. The vehicle was inspected by an authorized Toyota dealer, Toyota of Temecula, who confirmed instrument cluster failure. The vehicle has been out of service since November 25, 2025. The dealership has ordered a replacement instr… Look up ODI 11716205 at NHTSA ↗ | 413.8%ODI 11611262Panoramic moon roof exploded while driving with no impact to the glass. The explosion sounded like a gun shot inside the car. This sudden explosive noise put the driver, and all other vehicles on the road, in danger due to the panicked reflex of the driver. Upon inspection, it's evident that the glass shattered along all 4 edges rather than from a single point of impact. This would indicate an issue with the glass, the installation, or both. Vehicle was taken to dealer and customer was told it would not be covered under warranty. Look up ODI 11611262 at NHTSA ↗ |
|---|