| Seats | 511.6%ODI 11416133 · 2,000 miHEADLINER CUT TOO LARGE, DOESN'T HOLD REAR PASSENGER CLIMATE CONTROLS, CLIMATE CONTROLS FALL OUT AND HIT REAR PASSENGERS. THIS HAPPENS AT ANY SPEED. Look up ODI 11416133 at NHTSA ↗ | 210.0%ODI 11737009We brought our 2022 Toyota Sienna in for service January 2024 for the driver's seat. The seat would make really loud popping noises that sounded like something was loose when the seat moved forward and backward. We brought the vehicle in, and the service technician discovered that the driver's seat assembly was loose and cracking. The technician removed and replaced faulty components of the seat assembly under warranty. The seat starting having the same issues recently, and we are concerned of an on going safety issue given the instability of t… Look up ODI 11737009 at NHTSA ↗ | 22.9%ODI 11539331The 3rd row seats in the Sienna do not stay stowed as there is no lock. This creates a very dangerous situation when braking. I just got this car a few days ago and already have issues. When I brake or go over bumps, the stowed 3rd row seat pops up a little. That's okay, until you brake. In one instance, I had to brake harder than usual during a traffic incident in front of me, and the 3rd row seats flew forward (up and out of the stowed position) and slammed into the 2nd row seats. It was loud and scary. My child was sitting in the 3rd row (… Look up ODI 11539331 at NHTSA ↗ | 57.2%ODI 11599576Rear foldable seats do not lock down into compartment. They bounce up when you stop just a little hard. Cable has already broken when this occurs. Anything laid on top of these seats when folded will be ejected inside of car. Hitting driver in the head. This is very dangerous. Already brought to dealer and complained and nothing was done. They said that's the way it is. Someone will die if this problem is not taken care of. Look up ODI 11599576 at NHTSA ↗ | 21279.4%ODI 11627562Headed seat barely warm Look up ODI 11627562 at NHTSA ↗ | 323.1%ODI 11741192While slowing to a stop sign at a normal speed, the 3rd row, which does not lock into place, flew into the upright position. Thankfully it had nothing on top of it, but if it did my children in the second row would have been seriously injured. Look up ODI 11741192 at NHTSA ↗ |
|---|
| Unknown Or Other | 37.0%ODI 11730547We were stopped at a stoplight. As soon as we stepped on the gas pedal, there was a loud clunk sound and plastic parts started flying out from under the car. We immediately pulled over. Oil was spilling out everywhere. The transmission oil pump was laying on the inside of the engine compartment. We had towed to Toyota. They diagnosed a bent piston went through engine which also caused a hole in the transmission. I had it towed for a 2nd opinion. Neither toyota or the 2nd opinion had ever seen anything like it. My mechanic also said there are a … Look up ODI 11730547 at NHTSA ↗ | 15.0%ODI 11754257I am reporting a potential safety issue involving the passenger-side power sliding door on a 2022 Toyota Sienna. On XXX my [XXX] child was outside the vehicle in a wagon while the passenger-side sliding door was closing. He reached toward the vehicle, and his fingers became trapped in the sliding door, closest to the front passenger door. The power door did not stop or reverse after contacting his fingers. It continued closing, clicked shut, and fully latched with his fingers caught in the door. We immediately opened the door and removed his … Look up ODI 11754257 at NHTSA ↗ | 1623.5%ODI 11503015No system is failed in our sienna. Only safety problem we have is the rear view mirror completely block off when kid use the entertainment system. When I talk to the deanship, they told me they can't add any rear view camera due to the electrical harness problem. Not sure if anything can be done, please let me know what you guys think. Look up ODI 11503015 at NHTSA ↗ | 1623.2%ODI 11576659Sunroof glass just exploded Look up ODI 11576659 at NHTSA ↗ | 2910.9%ODI 11625111The sliding doors will shut off after 60+ minutes of being left open. In order to close them afterwards, you must fight with the power closing mechanism which makes it incredibly slow to close. This is dangerous if someone is threatening you and you need to get in your car and close the door. Or if a swarm of bees is coming at you. It takes about 30 seconds to close the door when this happens. Toyota claims this is to save power but this makes no sense as an excuse as the rear. Liftgate can stay open indefinitely without problem. Look up ODI 11625111 at NHTSA ↗ | 17.7%ODI 11743184The center console between the front seats has a design defect. When small objects such as a credit card, key fob, or coin are left on the flat surface of the console, they can slip through a gap into the internal storage compartment. Once inside, the object becomes lodged and physically blocks the console lid from opening, locking the owner out of the storage compartment. The console must be partially disassembled to retrieve the object. This is a design flaw, not operator misuse. The flat surface visually appears usable, and the owner's manu… Look up ODI 11743184 at NHTSA ↗ |
|---|
| Service Brakes | 614.0%ODI 11377621THIRD BRAKE LIGHT CONDITION POOR VISABILITY TO OPERATOR ( REAR WINDOW) WHEN BRAKE IS ACTIVATED IN LOW OR DARK LIGHTING CONDITION(S) THERE IS REFLECTION OFF GLASS AND REAR DEFROST ELEMENT(S) WHICH CAUSE LIMITED REAR VISABILITY OUT OF REAR WINDOW GLASS. Look up ODI 11377621 at NHTSA ↗ | 315.0%ODI 11729063While braking, when the vehicle switches from regenerative braking to conventional, the vehical lurches or momentarily speeds up before stopping. All while brake petal is depressed. Look up ODI 11729063 at NHTSA ↗ | 2536.8%ODI 11528287While driving slowly into a parking slot, the brakes released and the vehicle surged over a parking block and into a sign. On a couple of time previously, I have encountered similar situations but never when parking at slow speed. Look up ODI 11528287 at NHTSA ↗ | 1724.6%ODI 11592492I was at a complete stop. There were no obstacles around me or oncoming. When I pressed the accelerator nothing happened for a full 3 seconds, until my vehicle jolted forward at an excessive speed. Brakes were not working. Look up ODI 11592492 at NHTSA ↗ | 10.4%ODI 11691761When i am driving from high speed and trying to use my brakes, the whole rear car will start shaking around 48/45 miles per hour , I can hear our car seat from our baby how it makes vibrating noises and i can see my both door mirrors they're shaking too, and when it drops to 40mil per hour the shaking goes away. Went to the local Toyota dealer 3 times and they're saying that's normal. Very disappointed with a brand new car. We have another new car and doesn't do that for sure... Called Toyota national, open a case and they're saying, mechanic … Look up ODI 11691761 at NHTSA ↗ | 17.7%ODI 11745053Less than 1000 miles on my car i do not remember exact dates hence i have added todays date for incident date.All three incident happend in three different days. Scenario 1 two times. Scenario 2 one time --- SCENARIO 1: Curved Road / No Lane Markings --- Conditions: ACC set at 25 MPH on an undivided two-way road with no lane markings. Parked vehicles present at curves; oncoming traffic at safe distance. Issue: On two separate occasions, the vehicle applied sudden, significant braking without driver input while navigating curves. No imminent co… Look up ODI 11745053 at NHTSA ↗ |
|---|
| Air Bags | 1330.2%ODI 11570618The contact owns a 2021 Toyota Sienna Hybrid. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available. Look up ODI 11570618 at NHTSA ↗ | 315.0%ODI 11628514 · 37,000 miThe contact owns a 2022 Toyota Sienna Hybrid. The contact stated that while operating the vehicle, the SRS and air bag warning lights remained illuminated. The cause of the failure was not yet determined. The manufacturer was notified of the failure, but no assistance was provided. The contact was informed that the vehicle was not included in NHTSA Campaign Number: 23V865000 (AIR BAGS). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was approximately 37,000. Look up ODI 11628514 at NHTSA ↗ | 34.4%ODI 11617771Air bags did not deploy during a major crash took place on 9-25-2024 the vehicle was a total loss. Look up ODI 11617771 at NHTSA ↗ | 11.4%ODI 11691531Keeps bottoming out suspension is specification is stated at 5.6 inches and I measured 3.3/4 unloaded never get a response on my complaints from my last repair and resolution on what they admitted that suspension was too low and wouldn’t put it in writing only saying that vantage mobility saying that it’s height requirements are as stated by vantage but no mention of ground clearance that I wanted them to verify that it’s specifications are stated at 6.5 inches and i measured 3 3/4 empty then they tell me not to go by specs and I’m a retired fr… Look up ODI 11691531 at NHTSA ↗ | 41.5%ODI 11714393What component or system failed or malfunctioned, and is it available for inspection upon request? Airbags did not deploy How was your safety or the safety of others put at risk? Me, my wife & 4 small children were in the vehicle when it was struck - and none of the airbags deployed. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Yes Were there any warning lamps, messages or other sympto… Look up ODI 11714393 at NHTSA ↗ | 00.0%No examples available for this selection. |
|---|
| Structure:Body | 37.0%ODI 11416133 · 2,000 miHEADLINER CUT TOO LARGE, DOESN'T HOLD REAR PASSENGER CLIMATE CONTROLS, CLIMATE CONTROLS FALL OUT AND HIT REAR PASSENGERS. THIS HAPPENS AT ANY SPEED. Look up ODI 11416133 at NHTSA ↗ | 15.0%ODI 11731906Rear windshield shattered between 4/16/2026, 10:04 AM and 4/16/2026, 6:43 PM without reason, no one near it to cause this broken windshield. I have Simplisafe camera that showed no one was near the car. See attached pictures. Look up ODI 11731906 at NHTSA ↗ | 22.9%ODI 11542856I parked the car in the garage and my child left the passanger side sliding door open. Then, the door malfunctioned because it would not electronically close after being left open more than 80 minutes. I tried to manually close the door, but encountered resistance. Afterwards, I pushed the "power door main switch" and was able to close the door manually. Our safety was at risk because if a dangerous person or aniaml was approaching, there is no intuitive way to quickly close the door. The vehicle DID NOT provide any warning messages about… Look up ODI 11542856 at NHTSA ↗ | 45.8%ODI 11672717Trunk will not open or close properly. Made a screeching sound when you open or close initially. Then eventually it stops opening or closing unless you assist. Look up ODI 11672717 at NHTSA ↗ | 124.5%ODI 11704484We were notified by Toyota that the second row seat rails had incomplete welds. Toyota recommended no one ride in the second row, and no child car seats should be installed in the second row. This greatly impacts the use and safety of the vehicle for our family of five. Additionally, the value of the vehicle has been impacted. Dealerships are not willing to give fair value for a trade-in because they know the vehicle will sit on their lot for an unknown amount of time before the repair is available. At this time (now 60+ days since the recall w… Look up ODI 11704484 at NHTSA ↗ | 17.7%ODI 11734127The sun roof glass spontaneously combusted Look up ODI 11734127 at NHTSA ↗ |
|---|
| Visibility/Wiper | 49.3%ODI 11377621THIRD BRAKE LIGHT CONDITION POOR VISABILITY TO OPERATOR ( REAR WINDOW) WHEN BRAKE IS ACTIVATED IN LOW OR DARK LIGHTING CONDITION(S) THERE IS REFLECTION OFF GLASS AND REAR DEFROST ELEMENT(S) WHICH CAUSE LIMITED REAR VISABILITY OUT OF REAR WINDOW GLASS. Look up ODI 11377621 at NHTSA ↗ | 15.0%ODI 11731906Rear windshield shattered between 4/16/2026, 10:04 AM and 4/16/2026, 6:43 PM without reason, no one near it to cause this broken windshield. I have Simplisafe camera that showed no one was near the car. See attached pictures. Look up ODI 11731906 at NHTSA ↗ | 68.8%ODI 11498384Driving along a rural road under 40 mph at 11:30 at night with no other traffic present. There was a slight transition in pavement from a possible small culvert replacement. The defrost was on high and it was 22 degrees outside. The windshield cracked just above the defrost vent. Look up ODI 11498384 at NHTSA ↗ | 22.9%ODI 11634896Driver side outside rear view mirror shakes and makes driver nauseous. Mirror was replaced in December and replacement mirror shakes as well. Right side (passenger) doesn't shake. Vehicle now has 6500 miles on it. Original equipment windshield has a wavy appearance for the right 1/3 of it (in front of the front passenger seat). Both issues have been brought up with Mitchell Toyota in San Angelo, TX. The dealer will not replace the driver side mirror again, saying "some movement is allowable", even though the passenger mirror doesn't do … Look up ODI 11634896 at NHTSA ↗ | 62.2%ODI 11647225With the TV pulled down, there is absolutely no visibility though the rear view mirror even when adjusting the seat and mirror. Look up ODI 11647225 at NHTSA ↗ | 17.7%ODI 11704150This minivan has the entertainment system, when using the TV screen, it blocks the rearview mirror where you are unable to see out of the back window. I have not seen any warning labels. I am unsure if it has been inspected by the manufacturer, and police and insurance reps have not inspected mine. Look up ODI 11704150 at NHTSA ↗ |
|---|
| Electrical System | 37.0%ODI 11746943Unexpected failure of the acceleration pedal to accelerate from a complete stop to a go at an intersection. The electric vehicle (EV) motor began accelerating up to about 3 mph than instantly had a failure to accelerate, even with the gas pedal continuously pushed to the floor. After about 4 to 5 seconds the engine kicked on and began accelerating. The failure seemed to occur during the EV motor swapping over to the gas powered engine. This has been the fourth occurrence and can be extremely dangerous at intersections with oncoming traffic. No … Look up ODI 11746943 at NHTSA ↗ | 210.0%ODI 11729260I am reporting a recurring safety-related defect involving driver-assistance and steering-wheel controls on my 2022 Toyota Sienna Limited, VIN [XXX] ry 8, 2026, I brought the vehicle to Parkway Toyota in [XXX] bec [XXX] tion” warning appeared and cruise control stopped working. The dealer diagnosed the issue as related to the 12V battery, replaced the battery, and advised that the condition was resolved. The same malfunction later recurred. I returned to Parkway Toyota on March 18-19, 2026 for the same problem. I reported that the issue had r… Look up ODI 11729260 at NHTSA ↗ | 68.8%ODI 11546748On July 7, 2023 I paid in full and was given possession of the 7 passenger seating Toyota van. The car has automatic door locking mechanism as part of the electrical system and can be locked from inside the car. The van is used to transport 2 children in car seats who can touch car components. We were given one Keyfob by the dealership and we were told that Toyota manufacturer did not have a second Keyfob to give at that time; we were told that we would get the second Keyfob within a few weeks. We were not told prior to purchasing the car th… Look up ODI 11546748 at NHTSA ↗ | 11.4%ODI 11643123Van purchased new October 2024. On two separate occasions, one in late 2024 and next today, [XXX], when pulling into street from a stop, there is no throttle response. You push the accelerator at varying pressure and no response for 2-3 seconds. This is a severe safety issue as it could cause an accident with oncoming traffic. No error lights illuminated on dash. Have seen other complaints on NHTSA website and social media as well. Will take to dealer but reporting a major safety issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMAT… Look up ODI 11643123 at NHTSA ↗ | 31.1%ODI 11706692On [XXX], I purchased a new Toyota Sienna 2025 from Toyota Pasadena. The car has had frequent “check rear seat” and “check 3rd row seat” alerts everyday I drive. I have contacted Toyota Motors a few times since May, 2025, and visited Toyota Pasadena countless times to solve this error since April, 2025. After their “alarm specialist” checked my vehicle, they started to intentionally ignore my repair request. It seems Toyota knows the problem but couldn’t fix it in an easy and cheap way. Toyota Pasadena always insisted on me seeing their alar… Look up ODI 11706692 at NHTSA ↗ | 00.0%No examples available for this selection. |
|---|
| Vehicle Speed Control | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 22.9%ODI 11660961multiple times this has been an issue. I stepped on the break and the car essentially leaps forward typically when going up down or straight. In November 2024 it happened while going up a hill slowly and I bumped into the vehicle ahead of me. My vehicle had no damage, but the car in front of me had to get a new skid plate and my insurance doubled because of it. Since the incident in November 2024, my car has unintentionally accelerated intermittently. finally, April 2025 this happened my car started shaking jolted forward, engine revving, and … Look up ODI 11660961 at NHTSA ↗ | 710.1%ODI 11577720Vehicle was driving on a slow traffic local street at roughly 10MPH. Spacing between car in front of me was around 30 ft. I was gliding towards front and ready to brake. Suddenly the vehicle start to accelerate hard by itself without driver’s operation. I tried to engage brake / gas pedal and was not helping. Front collision system did not activate like it suppose to. I ended up turn sharp right towards road curb and hit pole at average speed of 30mph or less. No air bag deployed. I then switch to Park. No warning lights pop up. All safety feat… Look up ODI 11577720 at NHTSA ↗ | 10.4%ODI 11759695While driving my 2025 Toyota Sienna XLE with Sure Grip Push‑Rock electronic hand controls, the acceleration suddenly stops working without warning. When this happens, the hand control will not accelerate at all , only the brake still works , leaving me coasting in traffic with no way to speed up. This has happened multiple times at different speeds and creates an immediate danger because I can only slow down or stop, not accelerate out of the situation. At the same time these acceleration failures occur, the vehicle shows a “SRS Airbag System … Look up ODI 11759695 at NHTSA ↗ | 17.7%ODI 11745053Less than 1000 miles on my car i do not remember exact dates hence i have added todays date for incident date.All three incident happend in three different days. Scenario 1 two times. Scenario 2 one time --- SCENARIO 1: Curved Road / No Lane Markings --- Conditions: ACC set at 25 MPH on an undivided two-way road with no lane markings. Parked vehicles present at curves; oncoming traffic at safe distance. Issue: On two separate occasions, the vehicle applied sudden, significant braking without driver input while navigating curves. No imminent co… Look up ODI 11745053 at NHTSA ↗ |
|---|