2024 Airstream INTERSTATE: complaints, problems and recalls

AN AIRSTREAM INTERSTATE OWNER EXPERIENCED A FIRE IN HIS/HER VEHICLE IN JUNE 2018. HTTP://WWW.AIRFORUMS.COM/FORUMS/F240/ELECTRICAL-BURNING-HEAVY-SMOKE-W-3YR-OLD-GRANDSON-SLEEPING-IN-AI-182891.HTML IT APPEARED THAT A MAGNUM ENERGY INC. MMS1012 CAUGHT FIRE UNDER CONDITIONS IDENTICAL TO THOSE DESCRIBED IN NHTSA SAFETY RECALL REPORT 17V-704. THE DEFECT DESCRIBED IN NHTSA SAFETY RECALL REPORT 17V-704 IS PRESENT IN THE AIRSTREAM INTERSTATE VEHICLES 2014-2018, UNTIL AIRSTREAM CHANGED THE DESIGN OF THE ELECTRICAL SYSTEM IN THE 2019 MODEL YEAR (PR…

Look up ODI 11110623 at NHTSA ↗

TL* THE CONTACT OWNS A 2016 AIRSTREAM INTERSTATE. THE CONTACT STATED THAT A FUSE WAS BLOWN SEVERAL TIMES WITHOUT WARNING, WHICH SHORTED THE VARIOUS INTERIOR LIGHTING, THE GAUGES, MONITORS, AND FUNCTIONS INTERNALLY WITHIN THE RV. EACH TIME THE FAILURE RECURRED, THE LP MONITOR FLASHED AND THE FAILURE WAS PROGRESSING RANDOMLY. THE CONTACT STATED THAT THE FUSE WAS NOT SEPARATELY WIRED AS INDICATED IN THE OWNER'S MANUAL. THE MANUFACTURER WAS CONTACTED SEVERAL TIMES, BUT DID NOT RECEIVE A RESPONSE. THE FAILURE RECURRED. THE APPROXIMATE FAILURE MILEAG…

Look up ODI 10761717 at NHTSA ↗

This complaint concerns a 2016 Airstream Interstate motorhome that has experienced multiple safety-critical failures involving the electrical system, engine starting system, fuel/propulsion system, and electrically controlled exterior components. While driving at highway speed, the exterior power awning deployed without warning or user input. The awning repeatedly extended and retracted uncontrollably, and the control switches were ineffective. I was forced to pull over on the freeway shoulder, cut electrical power to stop the motion, manually…

Look up ODI 11711949 at NHTSA ↗

Driving in the mountains on I-70 in Colorado, the check engine light came on indicating an emission issue. The vehicle would only go a 27 mph in a 65 mph zone. I had to drive in the right lane with semis and other vehicles passing me. I got to the dealer and they are saying the the DEF injector/dosing module (injects urea into the exhaust stream ahead of the SCR catalyst) had failed. This component Needs to be added to the recall list. This is a very dangerous situation and the dealer says he has replace many before. Under the Dieselg…

Look up ODI 11748134 at NHTSA ↗

THIS INCIDENT HAPPENED TO ME IN 2014 AND I DIDN'T THINK MUCH ABOUT IT UNTIL RECENTLY TALKING TO OTHER OWNERS OF THE AIRSTREAM INTERSTATE WHO HAVE HAD SIMILAR OR WORSE INCIDENTS. THAT KNOWLEDGE CAUSED ME TO FILE THIS BELATED REPORT SINCE CURRENT AIRSTREAM INTERSTATES HAVE THIS SAME ISSUE. THIS INCIDENT HAPPENED ON THURSDAY 3/13/2014 WHILE DRIVING FROM GRAND CANYON NATIONAL PARK TO VISIT FRIENDS IN NEW MEXICO. I PULLED OFF THE HIGHWAY AT A SCENIC LOOKOUT SPOT THAT HAD A LOT OF VERY ROUGH PAVEMENT. I ROLLED SLOWLY OVER ONE PARTICULARLY BAD SPOT…

Look up ODI 11104973 at NHTSA ↗

I test drove a black Sprinter (with everything working) in June 2022, and I subsequently mailed a $5,000 deposit in June 2022, to have the vehicle removed off the inventory lot until I tendered the balance. I came to the dealership on [XXX], to purchase the Sprinter that I test drove; and the radio, front tv, rear bench seat, back up camera and step was not working properly. They instructed me to take the RV to a local Georgia location (where I live). Upon inspection and diagnosis Multiple problems found that all need to be addressed. For some …

Look up ODI 11565253 at NHTSA ↗

Follow-up to a prior complaint on this VIN regarding a dangerous limp-mode event caused by a failed DEF injection nozzle. While climbing a steep grade on XXX in [XXX], the DEF dosing nozzle leaked, putting the vehicle into limp mode. Vehicle was limited to ~27 mph while surrounding traffic, including semi-trucks, moved at ~65 mph, creating a serious collision hazard on a grade with limited passing room. An authorized MB dealer (Mercedes-Benz of [XXX], [XXX]) replaced the nozzle. Vehicle then re-entered limp mode with no codes stored. Further …

Look up ODI 11755069 at NHTSA ↗

This complaint concerns a 2016 Airstream Interstate motorhome that has experienced multiple safety-critical failures involving the electrical system, engine starting system, fuel/propulsion system, and electrically controlled exterior components. While driving at highway speed, the exterior power awning deployed without warning or user input. The awning repeatedly extended and retracted uncontrollably, and the control switches were ineffective. I was forced to pull over on the freeway shoulder, cut electrical power to stop the motion, manually…

Look up ODI 11711949 at NHTSA ↗

There is an open recall NHTSA #21V042 that no dealers in Colorado can repair until March 2022. Parts are available but they claim to be book through March due to all the current recalls. This is a safety issue since wet conditions can cause the sensor to disable the electronic stability control. This is on a 4x4 vehicle that will be used during the winter in Colorado. I would like to have an authorized Mercedes repair facility do the repair since the dealer is not able to accommodate a reasonable timeline.

Look up ODI 11435036 at NHTSA ↗

TL* THE CONTACT OWNS A 2001 DODGE 2500. THE VEHICLE WAS BEING USED TO TOW A 2016 AIRSTREAM INTERSTATE. WHILE DRIVING 55 MPH, THE TRAILER VEERED IN BOTH DIRECTIONS. AS A RESULT, THE CONTACT HAD TO STEER THE VEHICLE IN EXCESS IN ORDER TO KEEP THE VEHICLE IN POSITION. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT APPLICABLE. UPDATED 09/23/16*LJ THE CONSUMER STATED THE VEHICLE WAS REPAIRED BY REPLACING THE SUSPENSION. THE CONSUMER …

Look up ODI 10882068 at NHTSA ↗