2005 Bigdog PITBULL: complaints, problems and recalls

RECALL CAMPAIGN 05V052000 CONCERNING ELECTRIC HARNESS CONTROL. CONSUMER WAS UNABLE TO GET THE DEALER TO HONOR THIS RECALL BECAUSE NO PARTS WERE AVAILABLE AT THIS TIME.*AK

Owner-reported narrative. Look up ODI 10115802 at NHTSA ↗

DT: CONSUMER HAD PURCHASED A BIG DOG PIT BULL 2005 MOTORCYCLE ON MAY 16, 2005. FUEL DELIVERY SYSTEM DID NOT PUMP FUEL THROUGH THE VEHICLE AND VEHICLE WOULD SHUT DOWN AND NOT MOVE, ON JUNE 30, 2005 THE VEHICLE WAS REPLACED, THE REPLACED VEHICLE HAD THE SAME PROBLEM. THE BACK DISC BRAKES LOCKED UP, THE BRAKE WAS SMOKING, VIN NUMBER WAS FOR THE REPLACEMENT VEHICLE, NONE OF THE PROBLEMS HAVE BEEN REPAIRED AS OF NOW, WHEN CONSUMER CONTACTED THE MANUFACTURER, THEY TOLD HIM THAT THEY WOULD GET BACK TO HIM. *AK

Owner-reported narrative. Look up ODI 10127482 at NHTSA ↗

I JUST GOT A LETTER ABOUT A RECALL ON MY 2005 BIGDOG MOTORCYCLE. I HAVE MADE SEVERAL ATTEMPTS (4) TO CONTACT BIGDOG TO SEE IF I CAN TAKE IT ANYWHERE ELSE OTHER THAN THE DEALER WHICH IS ABOUT 30 MILES AWAY, PLUS I DO NOT TRUST THE DEALER (ROLLING THUNDER) TO DO THE WORK PROPERLY BECAUSE OF TERRIBLE WORK DONE IN THE PAST. I HAVE YET TO HEAR BACK FROM THEM. COULD YOU PLEASE HELP. *NM

Owner-reported narrative. Look up ODI 10142009 at NHTSA ↗

CONSUMER COMPLAINT REGARDING 2005 BIG DOG PIT BULL ENGINE UNEXPECTEDLY DIED WHILE RIDING. *TS *JB

Owner-reported narrative. Look up ODI 10146428 at NHTSA ↗

Reported: 2005-04-14 (April 14, 2005)

ON CERTAIN MOTORCYCLES, THE PRIMARY DRIVE SPROCKET NUT MAY BACK OFF THE ENGINE MAIN SHAFT.

Consequence: THIS COULD CAUSE THE PRIMARY DRIVE TO LOCK UP AND CAUSE A CRASH. THIS CONDITION COULD OCCUR WITHOUT ANY PRIOR WARNING.

Remedy: DEALERS WILL INSPECT AND REPLACE THE DRIVE SPROCKET NUT FREE OF CHARGE. THE RECALL BEGAN ON MAY 13, 2005. OWNERS MAY CONTACT BIG DOG AT 316-267-9121.

Reported: 2005-09-28 (September 28, 2005)

ON CERTAIN MOTORCYCLES, THE REAR WHEEL HUB BOLTS COULD LOOSEN AND BACK OUT ALLOWING THE HUB AND BRAKE ROTOR TO DETACH FROM THE WHEEL WITH AN ASSOCIATED LOSS OF STOPPING POWER.

Consequence: THIS CONDITION COULD OCCUR WITHOUT ANY PRIOR WARNING AND COULD RESULT IN A CRASH.

Remedy: DEALERS WILL REMOVE, CLEAN AND REATTACH THE REAR HUB BOLTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 14, 2005. OWNERS MAY CONTACT BIG DOG AT 1-312-267-9121.

Reported: 2006-01-25 (January 25, 2006)

ON CERTAIN MOTORCYCLES, THE KICKSTAND SPRING MAY STRETCH AND DETACH FROM THE MOUNTING BRACKET OR THE KICKSTAND.

Consequence: THIS WILL ALLOW THE KICKSTAND TO DEPLOY INTO THE EXTENDED POSITION AND CAUSE A CRASH.

Remedy: DEALERS WILL INSTALL A NEW KICKSTAND SPRING FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 17, 2006. OWNERS MAY CONTACT BIG DOG AT 316-267-9121.

Reported: 2006-08-11 (August 11, 2006)

ON CERTAIN MOTORCYCLES, THE ELECTRONIC HARNESS CONTROL (EHC) MODULE CAN FAIL RESULTING IN A TOTAL SHUT DOWN OF THE VEHICLE'S ELECTRONIC POWER.

Consequence: THIS CONDITION COULD OCCUR WITHOUT ANY PRIOR WARNING AND COULD RESULT IN A CRASH.

Remedy: DEALERS WILL REPLACE THE EHC MODULES FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 19, 2006. OWNERS MAY CONTACT BIG DOG AT 316-267-9121.

Reported: 2007-08-08 (August 8, 2007)

ON CERTAIN MOTORCYCLES, A WARPED BUS BAR WITHIN THE VOLTAGE REGULATOR CAN CAUSE A SHORT CIRCUIT.

Consequence: THIS COULD POSSIBLY RESULT IN A FIRE.

Remedy: DEALERS WILL REPLACE THE EXISTING CIRCUIT BREAKER LOCATED BETWEEN THE VOLTAGE REGULATOR POSITIVE BATTERY LEAD (B+ LEAD) AND THE POSITIVE BATTERY TERMINAL WITH AN ALTERNATIVE CIRCUIT PROTECTION DEVICE THAT WILL PREVENT A THERMAL EVENT IF THERE IS A SHORT TO GROUND. THE RECALL BEGAN ON OCTOBER 1, 2007. OWNERS MAY CONTACT BIG DOG AT 1-316-219-9129 OR EMAIL TO [email protected].