2018 Bmw 230I: complaints, problems and recalls

On [XXX], I was driving down the road and a indicator light went off, indicating a malfunction. When I pulled over to the side, I shut the car off. I noticed something around the drivers side front end of the car. When I exited the vehicle, I seen fire (flame) coming from the front drivers side. It was located right in front of the tire. I called 911, Police and EMT was the first responders. By the time the fire department arrived the car was a total loss. The car fire resulted in the car being placed in a junk yard. My insurance wouldn’t cover…

Look up ODI 11758915 at NHTSA ↗

DRIVING DOWN THE FREEWAY AT 65MPH, CAR ENGINE JUST SHUTS DOWN. NO POWER STEERING, NO WAY TO GET OVER. CAR DISPLAY SAYS DRIVE TRAIN ERROR. CAR GOT TOWED TO THE DEALER FOR SERVICE, DEALER "FIXES" ISSUE. 2 DAYS LATER, EXACT SAME THING HAPPENS AGAIN ON THE FREEWAY AT 65MPH. ENGINE JUST SHUTS DOWN. TOWED BACK TO THE DEALER. STILL THERE, NO FIX YET. HOWEVER, HOW IS MY WIFE SUPPOSED TO FEEL SAFE IN THIS CAR NOW. IT CAN DIE ON THE FREEWAY AT ANYTIME AND YOU HAVE NO POWER AND TRAFFIC IS ZOOMING BY.

Look up ODI 11103839 at NHTSA ↗

While driving the vehicle on the Florida turnpike I received the message that the coolant was low, then another message to pull over immediately to prevent engine overheat. I pulled over as soon as I could and the engine ceased to operate. Took the vehicle to a BMW dealership and they told me the engine overheated because a hose from the engine had come undone. They instructed me to file an insurance claim, I Learned that that same hose was part of a BMW service action under bulletin B170121. The car with this problem should be recalled. I …

Look up ODI 11463592 at NHTSA ↗

2022 BMW 230i Coupe (VIN: [XXX]) is under an active, high-priority safety recall for an Engine Starter Fire Risk (Recall 26V-438) with a strict "Park Outside" mandate. The manufacturer currently lists the status as "Remedy Not Available" because redesigned replacement parts do not exist yet. Due to the explicit warning that the vehicle can catch fire spontaneously while parked, I feel completely unsafe operating it or keeping it near my home. BMW Customer Relations refuse to provide a safe interim loaner vehicle, rental coverage, or transport/s…

Look up ODI 11763657 at NHTSA ↗

On January 30, 2026 BMW was made aware of a problem with their starter motors in their 230 series cars that could result in the mechanism failing or in a worst case scenario, a fire starting. They have been aware of this problem for almost four full months and still have no remedy. This is a blatant safety issue and they have taken no action to correct it.

Look up ODI 11733468 at NHTSA ↗

Vehicle was parked at approximately 3:45 PM. While parked, the vehicle engine caught fire sometime in the next hour, approximately. Many eyewitnesses stated that nobody was seen near the vehicle as it started smoking, and then caught fire, with multiple explosions heard. The engine was completely destroyed, but the passenger cabin did not seem to be impacted. BMW has several recalls out for engines catching fire - this model was not included in this recall, but clearly needs to be.

Look up ODI 11620898 at NHTSA ↗

On [XXX], I was driving down the road and a indicator light went off, indicating a malfunction. When I pulled over to the side, I shut the car off. I noticed something around the drivers side front end of the car. When I exited the vehicle, I seen fire (flame) coming from the front drivers side. It was located right in front of the tire. I called 911, Police and EMT was the first responders. By the time the fire department arrived the car was a total loss. The car fire resulted in the car being placed in a junk yard. My insurance wouldn’t cover…

Look up ODI 11758915 at NHTSA ↗

BMW F Series models between 2008-2021 have issues with rear turn signal malfunctions. On my car, the left turn signal stopped working and caused a fault warning. The dealership said the housing needed to be replaced, but then it started working normally, and then the right rear did the same. Since then, I have had intermittent failures on both the left and right sides. A simple google search shows many complaints about this issue as document here: https://www.google.com/search?q=BMW+rear+turn+signal+malfunction&oq=BMW+rear+turn+signal+malfu…

Look up ODI 11746445 at NHTSA ↗

The contact owns a 2022 BMW 230I. The contact stated that while his son was attempting to start the vehicle, the vehicle failed to respond as needed. The contact's son attempted to start the vehicle again, and the check engine warning light was blinking. The vehicle was towed to the dealer, and the vehicle was diagnosed with a misfire and crankshaft failure. The contact was informed that the valve cover, fuel tank, and spark plugs need to be replaced. The contact associated the failure with NHTSA Campaign Number: 26V438000 (Electrical System); …

Look up ODI 11759476 at NHTSA ↗

The contact owns a 2023 BMW 230i. The contact received the recall notification letter for NHTSA Campaign Number: 26V056000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer and the manufacturer were contacted. The contact had not experienced a related failure.

Look up ODI 11743512 at NHTSA ↗

The contact owns a 2024 BMW 230I. The contact received notification of NHTSA Campaign Number: 26V438000(ELECTRICAL SYSTEM); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that at start-up, the vehicle was shaking, vibrating, and had shut off unexpectedly. Additionally, while op…

Look up ODI 11757630 at NHTSA ↗

On 4/17/2025, we purchased 4 BRIDGESTONE tires at Discount Tire Company. The front two tires are model 225 /40 R18 88Y SL BSW BM RF and the rear two tires are model 245 /35 R18 92Y XL BSW BM RF. On 9/3/2025, we had to replace a front tire, due to a hole in the tire from pothole damage going about 40 mph. I can't say the exact safety risk this posed, but a tire getting a hole in it at 40 miles per hour can't be a good thing? These are run-flat tires so they still work but not at high speeds.

Look up ODI 11715059 at NHTSA ↗

I purchased all available packages which include pedestrian warning in rear and front, collision warning and automatic breaks, rear collision warning, etc… none of the systems have worked except for the parallel parking assist but now it is starting to malfunction and apply the breaks 100% while I am driving or parking causing near collisions and inability to to move my car while on the road. I also purchased 5G cell service in the car and it has no cell service but says it does however it forces me to use my phone to connect to cellular servic…

Look up ODI 11632053 at NHTSA ↗

Rear traffic cross is a joke. Had in the shop twice and was told it worked as required, took it and checked with cars coming behind me. Maybe worked 30% of the time if the other car was within 3ft. This is not a safety feature as stated. My Cad would notify me when a car was 12ft away.. was told the shop can't do anything further until BMW notifies them. No accidents yet but it may hit the car and not go off. Called the factory rep and he knew of other complaints but his hands were tied, put it inmy file. BMW needs to be …

Look up ODI 11581580 at NHTSA ↗

I HAVE ORDERED MY CAR WITH HELP BY BMW OF NORTH AMERICA (BMW NA) REPRESENTATIVES BY CALLING 800-831- 1117, TO WHOM I EXPRESSED THAT I WANT TO HAVE 3 SAFETY OPTIONS, NAMELY: 1) BLIND SPOT DETECTION, 2) AUTOMATED BRAKING AND 3) FRONT CAMERA. HOWEVER, ONCE I RECEIVED THE CAR, NONE OF THE DESIRED OPTIONS HAVE BEEN INCLUDED ON THE CAR. NOTE THAT THE REPRESENTATIVES ADVISED ME THAT THE AUTOMATED BRAKING IS NOT AVAILABLE, BUT THAT THERE IS FRONT COLLISION WARNING, WHICH PRIMES THE BRAKES, AD WHICH I ACCEPTED. ALL OF WHICH IS AVAILABLE IN DRIVER ASSIS…

Look up ODI 10966573 at NHTSA ↗

None of the 3 navigation apps work in my BRAND NEW 2023 BMW. You’ll see it has me going thru oceans & thru forests or golf courses to get to my destination. But, MORE IMPORTANTLY, the incorrect GPS data is also being sent to EVERY app that utilizes GPS. Therefore, if I need the police or 911 & look at my phone on any app that has GPS my location could be off by miles. If my car is stolen & I look in the MY BMW app the locations could be off by miles. Below, you will see two photos on the same page. They were taken within seconds of each other.…

Look up ODI 11511877 at NHTSA ↗

I purchased all available packages which include pedestrian warning in rear and front, collision warning and automatic breaks, rear collision warning, etc… none of the systems have worked except for the parallel parking assist but now it is starting to malfunction and apply the breaks 100% while I am driving or parking causing near collisions and inability to to move my car while on the road. I also purchased 5G cell service in the car and it has no cell service but says it does however it forces me to use my phone to connect to cellular servic…

Look up ODI 11632053 at NHTSA ↗

IN THE LAST 12 MONTHS I HAD TO REPLACE 4 RUN FLAT TIRES AT A COST OF APPROXIMATELY $1300. THE TIRE WERE COMING OFF THE CAR, THERE WERE BUBBLES IN THE TIRE. BMW SAID "THAT HAPPENS WITH 2-SERIES CARS." THEY SAID THE LOW PROFILE CAUSES THIS WHEN YOU HIT POTHOLES. I DIDN'T HIT ANY POTHOLES. THE CAR THUMPS WHENEVER IT HITS EVEN THE SMALLEST OF BUMPS. I LIVE IN THE BURBS WHERE THE ROADS ARE RELATIVELY SMOOTH. I HAVE NEVER HAD A PROBLEM LIKE THIS BEFORE WITH THE MANY CARS I LEASED BEFORE. BMW OF MT. KISCO WAS TOTALLING UNCARING AND DID NOT OFFER…

Look up ODI 11131665 at NHTSA ↗

I HAVE A 2018 2 SERIES XDRIVE CONVERTIBLE WITH 18' PIRELLI RUN FLAT TIRES. THIS IS MY SECOND 2 SERIES. I HAVE HAD 6 OF THESE TIRES BLOW DUE TO POTHOLES OVER THE TWO CARS I HAVE HAD OVER 4 YEARS. THE LAST ONE THAT BLEW WAS ON FRIDAY ON I65 JUST SOUTH OF LOUISVILLE. I HAD TO WAIT 4 HOURS FOR TOW TRUCK TO TAKE IT TO BMW OF LOUISVILLE. I PROCEEDED ONTO NASHVILLE. I PICKED THE CAR UP ON THE FOLLOWING MONDAY. THE TIRES ARE 18' PIRELLI CINTURATO P7 A S RFT RUN FLAT. THIS IS A CHRONIC PROBLEM WITH THIS CAR. MY BMW SERVICE PERSON SAYS THIS HAPPENS …

Look up ODI 11383876 at NHTSA ↗

BMW Passenger Restraint sensor failure due to a faulty sensor mat, so the passenger seatbelt will not lock or tighten when braking or in the event of an accident. Took it to the dealer and no evidence of a spill or user error that can tamper with the mat, the sensor simply died after minimal use of the passenger seat. This part should be recalled & BMW should have to cover the cost of this safety hazard caused by faulty parts. BMW only covers the sensor mat for 2 years even after replacement, which is unacceptable for a component that is vital …

Look up ODI 11564841 at NHTSA ↗