| Air Bags | 525.0%ODI 11448893Front Passenger Seat Malfunction - Intermittent on and off warning No risk yet but BMW road aside assist confirmed that air bag might not deploy on passenger side Vehicle inspected by Irvine BMW and warning or concerns shown, just tried to bill me without root causing the issue. Yes the warning comes up on and off. Intermittent. Look up ODI 11448893 at NHTSA ↗ | 1445.2%ODI 11109656RECEIVED AN ERROR MESSAGE ON BMW 540I 2018, WITH 10600 MILES. PURCHASED AS FACTORY DEMO A LITTLE OVER A MONTH AGO. WILL BE TAKING IT TO SERVICE SOON. HOWEVER I UNDERSTAND THIS IS A LONG STANDING ISSUE WITH BMW-S THAT THE MANUFACTURER IS NOT CORRECTING OR ISSUING RECALLS. Look up ODI 11109656 at NHTSA ↗ | 19.1%ODI 11421080 · 18,000 miThe contact owns a 2019 BMW 540i. The contact stated while driving at various speeds, the vehicle stalled without warning while depressing the accelerator pedal. The contact stated that while attempting to park the vehicle, the failure recurred. The contact continuously depressed the accelerator pedal and the vehicle lunged forward and collided with a barrier and crashed into his neighbor's vehicle. The air bags failed to deploy upon impact. The contact was not treated for any injuries. A police report was not filed. The contact had taken the v… Look up ODI 11421080 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 116.7%ODI 11677962Passenger Restraint service message. Possibly related to airbag seat or floor sensor. Checked BMW customer forums and appears to be widespread issue. Look up ODI 11677962 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
|---|
| Electrical System | 420.0%ODI 11403652 · 21,000 miBACKUP CAMERA IS BLACKING OUT. VERY DANGEROUS. THERE WAS A RECALL FOR 2018-19 BMW'S BUT NOT FOR 2017 BMWS. FORUMS ALSO REPORT A LOT OF PROBLEMS WITH THIS REVERSE CAMERA. Look up ODI 11403652 at NHTSA ↗ | 412.9%ODI 11460740The vehicle was at a complete stop, when the gas pedal was tapped to move forward slightly the vehicle suddenly accelerated out of control. There was an attempt to apply the brakes, but the vehicle continued to accelerate and "Drive Train Malfunction" began to flash on the dashboard of the vehicle. The vehicle proceeded to accelerate as it jumped a curb, crashed into a ditch, before finally becoming lodged in a fence and coming to a complete stop when half of the vehicle was lifted off of the ground. The driver of the vehicle suffered a frac… Look up ODI 11460740 at NHTSA ↗ | 19.1%ODI 11324466 · 8,323 miMY CHECK ENGINE LIGHT CAME ON FOR CHASSIS STABILIZATION AND DRIVETRAIN MALFUNCTION. I TOOK IT TO THE DEALERSHIP AND THEY TOLD ME THEY REPAIR WOULD NOT BE COVERED UNDER WARRANTY. DEALERSHIP ALLEGES A RODENT GNAWED ON A ENGINE WIRING HARNESS. FROM WHAT I GATHER FROM THE DEALERSHIP THIS OCCURS FREQUENTLY. THE MANUFACTURER IS AWARE OF THIS PROBLEM BUT HAS FAILED TO MAKE NECESSARY DESIGN CHANGES TO MAKE THESE WIRING HARNESSES INACCESSIBLE TO RODENTS. MY CASE IS NOT THE WORSE CASE SCENARIO BUT A FIRE COULD HAVE STARTED, MY VEHICLE COULD HAVE BECOME I… Look up ODI 11324466 at NHTSA ↗ | 133.3%ODI 11585538BMW G30 chassis vehicles equipped with the optional Bowers & Wilkins stereo have multiple owners reporting on Bimmerpost owners forum that water incursion damages the front door midrange speakers on both sides of the vehicle due to poor water drainage design. Water is causing the speakers to short out and stop functioning. This is also happening to owners of the BMW F90 chassis with the Bowers & Wilkins optioned stereo speakers. Stock stereo and Harmon Kardon systems seem not to be impacted by this issue. Look up ODI 11585538 at NHTSA ↗ | 111.1%ODI 11749530Starter engine failure. Car failed to start multiple times. Major safety hazard that can cause a short circuit, melt wiring harnesses, and spark an engine bay fire posing an immediate threat to life. Problem was inspected and confirmed by a dealer. Multiple waring lamps and messages appeared. Dealer report stated: STARTER MOTOR FAULTY. ENGINE ELECTRICAL SYSTEM CONCERN: C/S: REPEAT START ATTEMPT INTERMITTEN WARNING LIGHTS. Please issue recall for the safety of all drivers. Look up ODI 11749530 at NHTSA ↗ | 116.7%ODI 11513257On Feb.3, 2023, my wife made a turn into a parking lot. She was driving our 2022 BMW 540. She paused and the engine began to rev up. It then shot forward nearly 50 feet and hurled her over a meridian into another car. She pressed as hard as she could on the brake and suffered a torn meniscus ligament. There were no warning lights and although the car hit front right, no airbags were executed. BMW has not sent an official detailed report from their engineer. BMW advertises brake override so pressing both the brake and accelerator would NOT r… Look up ODI 11513257 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
|---|
| Engine And Engine Cooling:Cooling System:Radiator Assembly | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
|---|
| Engine | 210.0%ODI 11630787Vehicle has severely poor quality coolant hoses made from poor quality material that cannot withstand the flow of pressure within the coolant system process. Leading to the hoses deteriorating from internal pressure thus causing the coolant hoses to leak. The coolant sensors only indicate low coolant levels when there is, 1 and 3/4 inches of coolant liquid left which is 70% lower than the minimum coolant line within the main coolant reservoir which can then lead to engine failure that could result into a vehicle accident or wreck causing injury… Look up ODI 11630787 at NHTSA ↗ | 39.7%ODI 11383989 · 32,000 miWHEN BRAKING TO COME TO A STOP AT A LIGHT, THE ENGINE REVVED UP TO OVER 5000 RPM. I HAD TO SHUT OFF THE CAR TO GET IT TO STOP. WHEN I TURNED THE CAR BACK ON, IT IMMEDIATELY REVVED UP TO OVER 7000, WHILE I STOOD ON THE BRAKE TO PREVENT IT FROM MOVING. SHUT IT OFF AGAIN, PUT FLASHERS ON AND WAITED A MINUTE. RESTARTED AND IT PERFORMED NORMALLY. Look up ODI 11383989 at NHTSA ↗ | 19.1%ODI 11726908I own a 2019 BMW 540 with B58 engine and I have begun noticing abnormal rattling noise from the engine area, which may indicate early stage failure of the oil pump assembly. There are widespread reports from other owners of failure of the oil pump rotor housing/adjusting ring due to heat-related degradation of plastic components. Failure of this component can lead to sudden loss of oil pressure, drivetrain malfunction warnings, and ultimately engine seizure while driving. Sudden engine failure at speed presents a significant safety hazard due t… Look up ODI 11726908 at NHTSA ↗ | 266.7%ODI 11713345Component: Engine Oil Pump (Plastic Internal Variant) Safety Risk: Sudden Loss of Motive Power / Engine Seizure Defect Description: The oil pump in the BMW B58 engine utilizes a plastic tensioning/adjusting ring that is prone to brittle fracture. At only 38,000 miles, my vehicle suffered a catastrophic internal pump failure, resulting in an immediate "Low Oil Pressure" warning and forced engine shutdown. Safety Hazard: Stalling at Speed: This defect causes an immediate loss of propulsion. If this occurs during highway merging or high-speed m… Look up ODI 11713345 at NHTSA ↗ | 111.1%ODI 11749530Starter engine failure. Car failed to start multiple times. Major safety hazard that can cause a short circuit, melt wiring harnesses, and spark an engine bay fire posing an immediate threat to life. Problem was inspected and confirmed by a dealer. Multiple waring lamps and messages appeared. Dealer report stated: STARTER MOTOR FAULTY. ENGINE ELECTRICAL SYSTEM CONCERN: C/S: REPEAT START ATTEMPT INTERMITTEN WARNING LIGHTS. Please issue recall for the safety of all drivers. Look up ODI 11749530 at NHTSA ↗ | 116.7%ODI 11513257On Feb.3, 2023, my wife made a turn into a parking lot. She was driving our 2022 BMW 540. She paused and the engine began to rev up. It then shot forward nearly 50 feet and hurled her over a meridian into another car. She pressed as hard as she could on the brake and suffered a torn meniscus ligament. There were no warning lights and although the car hit front right, no airbags were executed. BMW has not sent an official detailed report from their engineer. BMW advertises brake override so pressing both the brake and accelerator would NOT r… Look up ODI 11513257 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
|---|
| Seat Belts | 315.0%ODI 11075186 · 7,500 miI HAD DROPPED OFF THE VEHICLE FOR SWAPPING OUT MY WINTER TIRES FOR ALL SEASON TIRES. THEIR TECHNICIANS REMOVED THE REAR SEAT BELT LATCHES AND INSTALLED THEM INCORRECTLY. THIS WORK WAS NEITHER APPROVED BY ME OR MENTIONED ON THE WORK ORDER. I WAS ALSO NOT VERBALLY INFORMED OF THIS WORK BEING PERFORMED. THIS WORK WAS CLEARLY NOT TESTED OR COMPLETED PROPERLY BY THEIR TECHNICIANS. IT CAUSED THE REAR SEAT BELTS TO NOT LATCH INTO PLACE CORRECTLY AND I WAS UNABLE TO INSTALL MY CHILD'S CAR SEAT TO THE CAR SECURELY. THE WORK WAS PERFORMED BY BMW OF SP… Look up ODI 11075186 at NHTSA ↗ | 1135.5%ODI 11109656RECEIVED AN ERROR MESSAGE ON BMW 540I 2018, WITH 10600 MILES. PURCHASED AS FACTORY DEMO A LITTLE OVER A MONTH AGO. WILL BE TAKING IT TO SERVICE SOON. HOWEVER I UNDERSTAND THIS IS A LONG STANDING ISSUE WITH BMW-S THAT THE MANUFACTURER IS NOT CORRECTING OR ISSUING RECALLS. Look up ODI 11109656 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 111.1%ODI 11490291 · 10,000 miThe contact owns a 2021 BMW 540I. The contact stated that on multiple occasions, the front and rear passenger’s and driver’s side seat belts failed to detach after being connected. The contact stated that he forced the rear passenger’s side seat belt to detach with a screwdriver. No warning lights was illuminated. The vehicle was taken to the dealer where the dealer stated that candy was lodged in the buckle. The contact stated that the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and a case was opened. Th… Look up ODI 11490291 at NHTSA ↗ | 116.7%ODI 11677962Passenger Restraint service message. Possibly related to airbag seat or floor sensor. Checked BMW customer forums and appears to be widespread issue. Look up ODI 11677962 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
|---|
| Seats | 420.0%ODI 11448893Front Passenger Seat Malfunction - Intermittent on and off warning No risk yet but BMW road aside assist confirmed that air bag might not deploy on passenger side Vehicle inspected by Irvine BMW and warning or concerns shown, just tried to bill me without root causing the issue. Yes the warning comes up on and off. Intermittent. Look up ODI 11448893 at NHTSA ↗ | 1032.3%ODI 11110925 · 6,500 miFOR A FEW MONTHS NOW, MY CAR HAS BEEN THROWING A "PASSENGER RESTRAINT SYSTEM MALFUNCTION" ERROR. IT HAPPENS SPORADICALLY AND ONLY STAYS UP FOR BETWEEN 1 AND 5 MINUTES AT A TIME. IT WILL HAPPEN WHETHER THE CAR IS MOVING OR NOT, AND EVEN SOMETIMES AS SOON AS I TURN THE CAR ON. I HAVE BEEN SUBMITTING THE TELECOMMUNICATIONS SINCE IT STARTED. I TRIED TO HAVE IT FIXED BY THOMPSON BMW, ONLY TO BE TOLD, LIKE THE OTHER USER WHO HAS THIS PROBLEM ON HERE, THAT THEY THINK MOISTURE IS THE CULPRIT. I HAVE NEVER HAD ANY RAIN OR ANY OTHER MOISTURE GET INTO THE… Look up ODI 11110925 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
|---|
| Steering | 15.0%ODI 11508276The steering wheel will not go to its set position. BMW Dealer Service ran tests and found that the steering column hall effect sensor is faulty and is integral to the steering column. They have mentioned that the steering wheel adjustment will stop functioning in the future. If the steering wheel column cant be adjusted, it seems to create risky driving conditions for the driver. The dealer has reproduced and confirmed the issue. There were no other symptoms or warning messages. Look up ODI 11508276 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 111.1%ODI 11488196Intermittent vibration at highway speeds. Brought to the BMW dealership and they stated the right front wheel was out of round. I never hit a pothole or anything that would cause damage. The dealer "repaired" the wheel, but the problem still exists. Brought the vehicle back and am now told that BMW has started offering non-run flat tires on new cars. I feel that the run flat tires coupled with the low-profile wheels could be the issue. Also, feel that the wheels are poorly made and are prone to being warped. Look up ODI 11488196 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
|---|
| Power Train | 15.0%ODI 11382938"REFILL COOLANT" INDICATOR DISPLAYS EVEN WITH FULL RESERVOIRS. TWO TRIPS TO THE DEALER SO FAR, FOR REPAIRS. COMES ON WHEN DRIVING OR WHEN PARKED, AFTER DRIVING; AFTER OPENING DRIVER DOOR. FOR EXAMPLE, DRIVE ONE DAY. PARKED OVER NIGHT. MESSAGE DISPLAYS NEXT DAY WHEN DRIVER DOOR IS OPENED. GOES AWAY AGAIN AFTER A DRIVE, WITHOUT ADDING ANY FLUID. SAME EXACT ISSUE AS OTHERS ARE EXPERIENCING HERE: HTTPS://G30.BIMMERPOST.COM/FORUMS/SHOWTHREAD.PHP?T=1526216&PAGE=1 Look up ODI 11382938 at NHTSA ↗ | 26.5%ODI 11460740The vehicle was at a complete stop, when the gas pedal was tapped to move forward slightly the vehicle suddenly accelerated out of control. There was an attempt to apply the brakes, but the vehicle continued to accelerate and "Drive Train Malfunction" began to flash on the dashboard of the vehicle. The vehicle proceeded to accelerate as it jumped a curb, crashed into a ditch, before finally becoming lodged in a fence and coming to a complete stop when half of the vehicle was lifted off of the ground. The driver of the vehicle suffered a frac… Look up ODI 11460740 at NHTSA ↗ | 19.1%ODI 11324466 · 8,323 miMY CHECK ENGINE LIGHT CAME ON FOR CHASSIS STABILIZATION AND DRIVETRAIN MALFUNCTION. I TOOK IT TO THE DEALERSHIP AND THEY TOLD ME THEY REPAIR WOULD NOT BE COVERED UNDER WARRANTY. DEALERSHIP ALLEGES A RODENT GNAWED ON A ENGINE WIRING HARNESS. FROM WHAT I GATHER FROM THE DEALERSHIP THIS OCCURS FREQUENTLY. THE MANUFACTURER IS AWARE OF THIS PROBLEM BUT HAS FAILED TO MAKE NECESSARY DESIGN CHANGES TO MAKE THESE WIRING HARNESSES INACCESSIBLE TO RODENTS. MY CASE IS NOT THE WORSE CASE SCENARIO BUT A FIRE COULD HAVE STARTED, MY VEHICLE COULD HAVE BECOME I… Look up ODI 11324466 at NHTSA ↗ | 00.0%No examples available for this selection. | 333.3%ODI 11727007 · 66,700 miThe contact owns a 2021 BMW 540I. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. There was an abnormal sound coming from the vehicle before the vehicle lost motive power. No warning lights were illuminated. The contact stated that the vehicle failed to respond while in drive(D) or reverse(R). The vehicle was towed to the dealer, where it was diagnosed with a driveshaft failure. The contact was informed that the driveshaft needed to be rep… Look up ODI 11727007 at NHTSA ↗ | 350.0%ODI 11715820While turning my 2022 BMW 540i onto a busy, 50 MPH road, the vehicle suffered a catastrophic drivetrain failure, without any physical trauma such as encountering a curb or pothole. The car experienced a total and immediate loss of motive power (propulsion), leaving me coasting in live traffic. This created an extreme safety hazard as I was unable to accelerate or maintain speed to clear the roadway safely. The failure occurred immediately after a significant temperature stress: taken from a heated garage, driven with no issue for 40 minutes, … Look up ODI 11715820 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
|---|