| Fuel/Propulsion System | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 535.7%ODI 10464244 · 29,000 miWHEN THE ENGINE IS COLD: THE BIKE STALLS WHEN I AM SLOWING DOWN FOR A STOPLIGHT WITH CLOSED THROTTLE AND THE CLUTCH IN. THIS ISN'T A PROBLEM WHEN THE ENGINE IS WARM. WHEN THE ENGINE IS WARM: 1. THE ENGINE SURGES IN THE FIRST 3 GEARS AT LOWER SPEEDS (UNDER 30MPH) WITH THE THROTTLE BARELY CRACKED OPEN, AND THE ON/OFF IDLE RESPONSE IS ROUGH. THIS REQUIRES DILIGENT CLUTCH WORK TO SMOOTH OUT. 2. IF I REV THE ENGINE FROM IDLE WITH THE CLUTCH IN, THE REVS HANG AND THEN SLOWLY DECREASE BACK TO NORMAL IDLE. 3. REVS HANG ON ACCELERATION AFT… Look up ODI 10464244 at NHTSA ↗ | 650.0%ODI 10465685 · 14,560 miI NOTICED THE SMELL OF FUEL IN MY GARAGE A FEW WEEKS AGO AND THOUGHT IT WAS ONE OF THREE VEHICLES IN IT. I WENT FOR A RIDE THIS PAST WEEK AND AFTER PARKING IT IN THE GARAGE I NOTICE A POOL DO FLUID UNDER THE BIKE. I STOP TO TAKE A LOOK AND IDENTIFY THE FLUID AS GASOLINE. I TOOK IT TO THE DEALER AND THEY TELL ME IT IS THE FUEL PUMP DISCONNECTS THAT ARE LEAKING. THESE CRACKS ARE LEAKING FUEL ONTO THE MOTOR AND ALTERNATOR CREATING A FIRE HAZARD! I HAVE NO DOUBT THAT THIS WOULD HAVE EVENTUALLY LEAD TO A FIRE THAT MOST LIKELY WOULD OF LEAD TO SEVERE… Look up ODI 10465685 at NHTSA ↗ | 375.0%ODI 10460566 · 9,354 miI WAS PREPARING TO REPLACE A DEFECTIVE AIRBOX, A PROBLEM THAT BMW STILL REFUSES TO ISSUE A RECALL FOR EVEN THOUGH BMW HAS UPDATED THE PART IN LATER MODEL YEARS, THAT WAS CAUSING ERRATIC AND UNPREDICTABLE THROTTLE CONTROL WHICH MADE THE BIKE UNSAFE TO RIDE WHEN I NOTICED CRACKS IN THE FUEL TANK. THESE CRACKS ARE LEAKING FUEL ONTO THE MOTOR AND ALTERNATOR CREATING A FIRE HAZARD! I HAVE NO DOUBT THAT THIS WOULD OF EVENTUALLY LEAD TO A FIRE THAT MOST LIKELY WOULD OF LEAD TO SEVERE BODILY HARM OR DEATH! IT APPEARS BMW IS AWARE OF THIS PROBLEM ALSO A… Look up ODI 10460566 at NHTSA ↗ | 538.5%ODI 10466683 · 2,300 miI WAS DRIVING DOWN A ROAD AT A CONSTANT SPEED OF 30 MPH WHEN SUDDENLY AND UNEXPECTEDLY MY BIKE SHUT OFF. I HAD CARS APPROACHING ME FROM THE REAR SO I DECIDED TO MAKE AN IMMEDIATE TURN ONTO A SECONDARY ROAD. AFTER COASTING TO A STOP I IMMEDIATELY TRIED TO START THE BIKE WITH NO SUCCESS. IT SOUNDED LIKE IT WAS OUT OF GAS BUT I KNOW I HAD AT LEAST A HALF OF A TANK. I WENT AHEAD AND PUT MORE GAS IN THE TANK TO TOP IT OFF. AFTERWARDS IT IMMEDIATELY STARTED UP. THE NEXT DAY I WENT FOR ANOTHER RIDE AND THE BIKE STARTED TO PERFORM SLUGGISH. IT APPEAR T… Look up ODI 10466683 at NHTSA ↗ | 00.0%No examples available for this selection. |
|---|
| Fuel System, Gasoline | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 17.1%ODI 10340775 · 8,734 mi2005 BMW K1200S MOTORCYCLE. QUICK DISCONNECTS ON HIGH PRESSURE SIDE OF FUEL LINE, LOCATED BETWEEN THE FUEL PUMP AND FUEL INJECTORS ARE POORLY MADE OF NYLON AND WEAR OUT. MY MOTORCYCLE HAS ALWAYS BEEN GARAGED AND ONLY HAS 8,734 MILES ON IT. THE LOCAL BMW SHOP KNOWS THIS IS A PROBLEM WITH THIS MODEL AND WILL REPLACE THE QDS WITH A METAL VERSION. I NOTICED THE LEAK (SPRAY) IN MY GARAGE AND FEEL [XXX] LUCKY I WAS NOT ON THE HIGHWAY AY 70 MPH AND IN FLAMES. IF YOU WOULD LIKE TO VERIFY THE SCOPE OF THIS PROBLEM, JUST LOOK TO THE BMW TECH FORUMS ON TH… Look up ODI 10340775 at NHTSA ↗ | 216.7%ODI 10430822 · 24,000 miTHE BIKE HAD BEEN SERVICED ABOUT 3 WEEKS BEFORE. I WAS RIDING A 3 MILE TRIP INTO TOWN AND NOTICED A STRONG GASOLINE SMELL, THINKING IT WAS THE CAR I WAS BEHIND, HOWEVER IT INCREASED, AND WHEN I GOT TO TOWN, IT WAS OBVIOUS THAT IT WAS COMING FROM MY M CYCLE, AND HAD GOT VERY STRONG. I CALLED THE SERVICE PEOPLE WHO CAME AND TOOK IT AWAY. THERE WAS A FLOW OF FUEL UNDER THE TANK ON THE INSIDE OF THE FAIRING, AND THE SMELL WAS OVERPOWERING. (THE SYSTEM IS ALWAYS POSITIVE PRESSURE, EVEN WHEN NOT ON, APPARENTLY). MY MECHANIC, WHO USED TO BE LEAD MECHA… Look up ODI 10430822 at NHTSA ↗ | 125.0%ODI 10349961 · 15,349 miTHIS MOTORCYCLE HAS A STALLING ISSUE THAT OCCURS INTERMITTENTLY. I CONSIDER IT VERY DANGEROUS AS THE VEHICLE IS VERY DIFFICULT TO START AFTER STALLING AND LEAVES THE OPERATOR VULNERABLE TO BE RUN DOWN FROM BEHIND. IT USUALLY OCCURS AS YOU PULL IN THE CLUTCH WHEN APPROACHING AN INTERSECTION TO STOP FOR A TRAFFIC LIGHT OR STOP SIGN. *TR Look up ODI 10349961 at NHTSA ↗ | 430.8%ODI 10277288 · 2,005 mi1. NORMAL OPERATION OF BMW 2008 K1200S MOTORCYCLE WAS IN PROGRESS. WHILE SLOWING FOR STOPLIGHTS OR TRAFFIC, PULLING IN THE VEHICLE'S CLUTCH AND ROLLING OFF THE THROTTLE (EITHER WHILE DOWNSHIFTING FROM 2ND TO 1ST GEAR, OR SIMPLY PULLING IN THE CLUTCH WHILE IN FIRST GEAR AND ROLLING OFF OF THE THROTTLE), THE VEHICLE'S MOTOR STALLS AND THE ENGINE SHUTS OFF. 2.) THE STALLING GENERALLY OCCURS SPORADICALLY, ONCE EVERY FEW WEEKS, AND GENERALLY ONLY ONCE OR TWICE PER RIDING SESSION, OVER THE VEHICLE OWNERSHIP PERIOD (JANUARY 2009-CURRENT). HOWEVER, A … Look up ODI 10277288 at NHTSA ↗ | 1100.0%ODI 10593699TL* THE CONTACT OWNS A 2010 BMW K1200S MOTORCYCLE. THE CONTACT STATED THAT HE WAS CONCERNED FOR HIS SAFETY SINCE THE DEALER WAS TAKING A LONG TIME TO SCHEDULE THE REPAIRS FOR NHTSA RECALL CAMPAIGN NUMBER: 13V617000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS MADE AWARE OF THE DELAY. THERE WERE NO FAILURES AT THIS TIME. THE CURRENT MILEAGE WAS 1,200. RK Look up ODI 10593699 at NHTSA ↗ |
|---|
| Service Brakes | 00.0%No examples available for this selection. | 150.0%ODI 11183945 · 26,000 miABS SYSTEM FAILED AT 26K, UPON RESEARCH,FOUND THIS TO BE VERY COMMON TO THIS YEAR/MODEL, AND ,OF COURSE, VERY DANGEROUS ON A MOTORCYCLE.A REPLACEMENT ABS UNIT COST IS MORE THAT THE VALUE OF THE VEHICLE!, AS A RETIRED FIREFIGHTER, I CAN'T AFFORD THIS RIDICULOUS EXPENSE,ANS AS A RESULT,HAVE REMOVED THE SYSTEM, RESULTING IN NO POWER BRAKES,NO ABS, AND NO SPEEDOMETER. Look up ODI 11183945 at NHTSA ↗ | 321.4%ODI 10617881 · 21,000 miRIDING APPROXIMATELY 45MPH AND APPROACHING A TRAFFIC LIGHT THAT TURNED YELLOW, I ATTEMPTED TO STOP USING THE HANDBRAKE. BRAKING WAS NEARLY NONEXISTENT AND IMMEDIATELY A RED WARNING LIGHT APPEARED ACCOMPANIED BY A BRAKE FAILURE LIGHT. THE FOOT BRAKE DID NOT FUNCTION AS WELL. AT THIS POINT THE LIGHT WAS TURNING RED AND I HAD NO CHANCE OF DOWNSHIFTING TO USE ENGINE BRAKING, SO MY ONLY HOPE TO AVOID AN ACCIDENT WAS TO DOWNSHIFT AND PROCEED THROUGH THE INTERSECTION. I HAD LOST ALL BRAKING ABILITY ON A MOTORCYCLE WHILE TRAVELING OVER 40MPH IN A HEAVY… Look up ODI 10617881 at NHTSA ↗ | 325.0%ODI 10644893 · 20,145 miTHE ABOVE BIKES ABS SERVO PUMP FAILED AND THIS IS COMMON AMONGST K1200S OWNERS. BMW NEEDS TO FIX THIS SAFETY ISSUE. THE ABOVE PROBLEM HAS BEEN A RECALL IN GERMANY. *TR Look up ODI 10644893 at NHTSA ↗ | 00.0%No examples available for this selection. | 215.4%ODI 10563847 · 7,000 miTL* THE CONTACT OWNS A 2008 BMW K1200 S MOTORCYCLE. THE CONTACT STATED THAT WHILE DECELERATING, THE FRONT BRAKES PULSATED. THE CONTACT ALSO MENTIONED THAT THE BRAKE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT THE BRAKES NEEDED TO BE REPLACED DUE TO A COMPUTER FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 7,000. THE VIN WAS NOT AVAILABLE. Look up ODI 10563847 at NHTSA ↗ | 00.0%No examples available for this selection. |
|---|
| Engine | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 17.1%ODI 10464244 · 29,000 miWHEN THE ENGINE IS COLD: THE BIKE STALLS WHEN I AM SLOWING DOWN FOR A STOPLIGHT WITH CLOSED THROTTLE AND THE CLUTCH IN. THIS ISN'T A PROBLEM WHEN THE ENGINE IS WARM. WHEN THE ENGINE IS WARM: 1. THE ENGINE SURGES IN THE FIRST 3 GEARS AT LOWER SPEEDS (UNDER 30MPH) WITH THE THROTTLE BARELY CRACKED OPEN, AND THE ON/OFF IDLE RESPONSE IS ROUGH. THIS REQUIRES DILIGENT CLUTCH WORK TO SMOOTH OUT. 2. IF I REV THE ENGINE FROM IDLE WITH THE CLUTCH IN, THE REVS HANG AND THEN SLOWLY DECREASE BACK TO NORMAL IDLE. 3. REVS HANG ON ACCELERATION AFT… Look up ODI 10464244 at NHTSA ↗ | 00.0%No examples available for this selection. | 125.0%ODI 10460566 · 9,354 miI WAS PREPARING TO REPLACE A DEFECTIVE AIRBOX, A PROBLEM THAT BMW STILL REFUSES TO ISSUE A RECALL FOR EVEN THOUGH BMW HAS UPDATED THE PART IN LATER MODEL YEARS, THAT WAS CAUSING ERRATIC AND UNPREDICTABLE THROTTLE CONTROL WHICH MADE THE BIKE UNSAFE TO RIDE WHEN I NOTICED CRACKS IN THE FUEL TANK. THESE CRACKS ARE LEAKING FUEL ONTO THE MOTOR AND ALTERNATOR CREATING A FIRE HAZARD! I HAVE NO DOUBT THAT THIS WOULD OF EVENTUALLY LEAD TO A FIRE THAT MOST LIKELY WOULD OF LEAD TO SEVERE BODILY HARM OR DEATH! IT APPEARS BMW IS AWARE OF THIS PROBLEM ALSO A… Look up ODI 10460566 at NHTSA ↗ | 215.4%ODI 10585511 · 7,300 miTHE BIKE REPEATEDLY STALLED DURING DECELERATION WITH A CLOSED THROTTLE BEFORE COMING TO A STOP. CLUTCH WAS ENGAGED. THIS HAS HAPPENED MANY TIMES BEFORE AND I'VE HAD ENOUGH OF IT. I'VE READ THREADS ONLINE ABOUT THIS ISSUE AND BMW DOESN'T SEEM TO HAVE AN ANSWER (SEEMS TO DENY THE PROBLEM). THIS IS A VERY UNSAFE ISSUE WHEN ON A MOTORCYCLE. *JS Look up ODI 10585511 at NHTSA ↗ | 00.0%No examples available for this selection. |
|---|
| Electrical System | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 17.1%ODI 11696711*2005 BMW K1200s ABS Power Brake system became and is Intermittent. Is available for inspection. Dealer owner and mechanic stated they were unaware of any said BMW ABS problems * On my birthday , Riding my motorcycle approximately 40mph, no indicator light on, no prier symptoms existed and unaware that the ABS Power Brake system was (off) not operating and as I needed to slow down, the system allowed me to over press/squeeze front power brake lever. Front Power BRAKE turned on and I eminently became a member of The over the Handle Bar's Club. *… Look up ODI 11696711 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 215.4%ODI 10289371 · 400 miI BOUGHT A BRAND NEW BMW K1200S IN OCT 2008. SINCE I BOUGHT IT HAS HAD A STALLING PROBLEM THAT MY DEALER CANNOT FIX AND BMW USA REFUSES TO ADDRESS. I HAVE ASK FOR THE MOTORCYCLE TO EITHER BE FIXED, REPLACED, OR REIMBURSE ME MY $19,000 CASH THAT I PAID FOR THE BIKE. THE MOTORCYCLE IS UNFIT FOR ROAD USE DUE TO THE FACT THAT IT STALLS EXCESSIVELY AND I FEEL UNSAFE. IF YOU GOTO THE INTERNET AND PUNCH IN KEY WORDS BMW K1200S STALLING YOU'LL FIND 30 TO 40 PAGES OF PEOPLE HAVING THE SAME PROBLEM WITH CASES EVEN BEING REPORTED OF PEOPLE GETTING HIT FR… Look up ODI 10289371 at NHTSA ↗ | 00.0%No examples available for this selection. |
|---|
| Engine And Engine Cooling:Engine | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 17.1%ODI 10403676 · 23,000 miMY 2005 BMW K1200S HAS HAD AN ENGINE FAILURE. WHILE HEADING WEST ON I 110 IN HARRISION COUNTY I HAD NOTICED A SLIGHT JERK IN THE ENGINE, 5 SECONDS LATER I HAD A SUDDEN EXPLOSION. I HAD THOUGHT I HAD A BLOWOUT ON THE REAR TIRE BUT AS I WAS TRYING TO CONTROL THE MOTORCYCLE I NOTICED A HUGE AMOUNT OF SMOKE BEHIND ME THAT FILLED THE INTERSTATE ON BOTH SIDES THAT WAS VERY DENSE. WHEN FINALLY COMING TO A STOP JUST PAST THE PASS CHRISTIAN EXIT IN THE SERVICE LANE I NOTICED OIL POURING FROM THE BOTTOM OF THE MOTOR. HAD THE TRAFFIC BEEN HEAVY I'M SURE I… Look up ODI 10403676 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 215.4%ODI 10278124 · 1,574 miENGINE STALL/DIE AT LOW SPEED DECERATION TO STOP. INTERMINTENT, ONE IN 30-50 STOPS. TOOK TO DEALER 3 TIMES FOR TESTING SITUATION COULD NOT BE DUPLLICATED BECAUSE OF LACK OF TEST TIME AVAILABLE. *TR Look up ODI 10278124 at NHTSA ↗ | 00.0%No examples available for this selection. |
|---|
| Engine And Engine Cooling | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 17.1%ODI 10175239 · 16,000 mi2005 BMW K1200S MOTORCYCLE STALLS UNEXPECTEDLY. THIS MOTORCYCLE HAS STALLED REPEATEDLY WHEN CLOSING THE THROTTLE TO SLOW WHILE MAKING A CORNER, OR WHEN APPROACHING A STOP SIGNAL. THE MOST RECENT WAS AT THE INTERSECTION OF BELL RD AND THE I-17 FREEWAY IN PHOENIX ARIZONA IN RUSH HOUR TRAFFIC ON NOV. 17, 2005. AS I APPROACHED THE INTERSECTION PREPARING TO MAKE A LEFT TURN, WEST BOUND ON BELL RD. THE MOTORCYCLE STALLED WHILE DOING 25 MPH. THE CAR BEHIND ME ALMOST HIT MY REAR TIRE BUT MANAGED TO SLOW DOWN TO MISS ME. AFTER FINISHING THE TURN WI… Look up ODI 10175239 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 17.7%ODI 10277288 · 2,005 mi1. NORMAL OPERATION OF BMW 2008 K1200S MOTORCYCLE WAS IN PROGRESS. WHILE SLOWING FOR STOPLIGHTS OR TRAFFIC, PULLING IN THE VEHICLE'S CLUTCH AND ROLLING OFF THE THROTTLE (EITHER WHILE DOWNSHIFTING FROM 2ND TO 1ST GEAR, OR SIMPLY PULLING IN THE CLUTCH WHILE IN FIRST GEAR AND ROLLING OFF OF THE THROTTLE), THE VEHICLE'S MOTOR STALLS AND THE ENGINE SHUTS OFF. 2.) THE STALLING GENERALLY OCCURS SPORADICALLY, ONCE EVERY FEW WEEKS, AND GENERALLY ONLY ONCE OR TWICE PER RIDING SESSION, OVER THE VEHICLE OWNERSHIP PERIOD (JANUARY 2009-CURRENT). HOWEVER, A … Look up ODI 10277288 at NHTSA ↗ | 00.0%No examples available for this selection. |
|---|
| Electronic Stability Control (Esc) | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 17.7%ODI 10650163ABS BRAKE FAILURE LIGHT CAME ON AFTER RAIN FALL, BRAKING IS IMPACTED, WAS TOLD THAT MANY OWNERS HAVE PROBLEMS WITH ABS BRAKE MOTOR FAILURE DUE TO BAD MOTOR AND /OR MOTOR BRUSHES STICKING TO ARMITURE IN MOTOR. I-BMW.COM USERS HAVE NOTED THE SAME THING WITH BMW MOTORCYCLES. THIS DOES EFFECT THE USE OF THE BRAKES. *TR Look up ODI 10650163 at NHTSA ↗ | 00.0%No examples available for this selection. |
|---|