1995 Chevrolet CAPRICE: complaints, problems and recalls

NHTSA#95-V-221-000; THESE VEHICLES WERE PRODUCED WITH AN IMPROPERLY ADJUSTED TRANSMISSION SHIFT CONTROL LINKAGE. THIS DOES NOT MEET WITH THE REQUIREMENTS OF FMVSS NO. 114, "THEFT PROTECTION." CONSUMER HAS THE SAME PROBLEM. HOWEVER THIS VEHICLE WAS NOT RECALL DUE TO THE VIN. *AK

Owner-reported narrative. Look up ODI 10022831 at NHTSA ↗

RECALL #96 V 018 000/ GM LOWER CONTROL ARM: WHEN DRIVING AT LOW SPEEDS AND MAKING EITHER LEFT OR RIGHT TURN, THERE WOULD BE A KNOCKING OR BANGING SOUND. THE VEHICLE HAS BEEN TO THE DEALER ON ONE OCCASION AND THEY TIGHTEN THE LOWER CONTROL ARM BALL JOINT ATTACHMENT NUT. NOW THE PROBLEM HAS RECURRED AGAIN. MANUFACTURER WAS NOTIFIED AND THEY INFORMED THE CONSUMER THAT THE VEHICLE WAS NOT COVERED UNDER ANY RECALL AT THAT TIME. PLEASE FEEL FREE TO PROVIDE ANY FURTHER INFORMATION CONCERNING THIS ISSUE AND FILL OUT THE REMAINING QUESTIONNAIRE. *PH…

Owner-reported narrative. Look up ODI 10032436 at NHTSA ↗

WHILE DRIVING 35 MPH, THE FRONT DRIVER SIDE WHEEL FELL OFF. THE VEHICLE WAS TOWED. *JB

Owner-reported narrative. 90,000 miles reported. Look up ODI 10044694 at NHTSA ↗

I WAS DRIVING A 1995 CHEVROLET CAPRICE AND WAS STOPPED WHILE ATTEMPTING TO ENTER THE HIGHWAY. I WAS HIT IN THE REAR BY A CAR GOING 50 MPH WHO DID NOT SEE THAT I WAS STOPPED. THE DRIVERS SEAT COLLAPSED INTO THE RECLINED POSITION AND THREW ME INTO THE REAR SEAT. MY SEAT BELT WAS ON AND LIMITED MY MOVEMENT. IN ADDITION, I PULLED ON THE STEERING WHEEL AND BROKE IT AT THE 10 O'CLOCK AND PARTIALLY SEPERATED AT THE 2 O'CLOCK POSITIONS. THE FAILURE OF THE SEAT CAUSED INJURY TO MYSELF WITH NO SUPPORT TO MY NECK AND HEAD. MY QUESTION IS: IS THE SE…

Owner-reported narrative. 168,000 miles reported. Look up ODI 10063683 at NHTSA ↗

THE DRIVER'S SIDE SEAT BELT RETRACTOR FAILED. THE SPRINGS POPPED OUT OF THE PLASTIC, CAUSING THE SPRING TO NO LONGER HOLD TENSION. *AK THE DRIVER'S SIDE SEAT BELT WOULD NO LONGER HOLD THE BELT TENSIONER TO ADJUST TO THE DRIVER'S BODY. THE SEAT BELTS RETRACTOR SPRING HAD BROKEN THROUGH THE PLASTIC RETAINER, WHICH CAUSED THE BELT TO STAY PERMANENTLY IN THE FULL EXTENDED POSITION. *SC *JB

Owner-reported narrative. 120,000 miles reported. Look up ODI 10075757 at NHTSA ↗

TL*THE CONTACT OWNS A 1995 CHEVROLET CAPRICE. THE CONTACT STATED THAT THE AUTOMATIC TRANSMISSION WAS LEAKING WHILE DRIVING 55 MPH. CHEVROLET STATED THAT THE VIN WAS NOT INCLUDED IN RECALL NUMBER 95V221000 (POWER TRAIN:AUTOMATIC TRANSMISSION). THE CONTACT ALSO STATED THAT THE POWER STEERING WAS LEAKING AND THAT THE VEHICLE WOULD SHIFT FROM PARK TO DRIVE OCCASIONALLY, WITHOUT THE KEY IN THE IGNITION. THE POWERTRAIN AND PURCHASE DATE WERE UNKNOWN. THE CURRENT MILEAGE WAS 78,000 AND FAILURE MILEAGE WAS 77,000.

Owner-reported narrative. 77,000 miles reported. Look up ODI 10197855 at NHTSA ↗

I HAVE A 1995 CHEVROLET CAPRICE. MY REAR LOWER CONTROL ARM (PASSENGER SIDE) BROKE WHILE DRIVING. THANKFULLY, IT HAPPENED AT LOW SPEED AND NEAR MY HOME. THE CONTROL ARM BROKE ALL THE WAY THROUGH, RIGHT AT THE STABILIZER BAR ATTACHMENT... EXACTLY AS DESCRIBED IN RECALL 96V020000. THE PART THAT BROKE IS UNDER RECALL, ID 96V020000. I GAVE THE CHEVROLET DEALER THIS INFORMATION AND THEY "COULD NOT FIND" THE RECALL. I ALSO CALLED AND EMAILED CHEVROLET, ESSENTIALLY GETTING THE SAME RESPONSE --IGNORANCE. MY COMPLAINT IS I HAD TO PAY FOR THE REPAIR MYSEL…

Owner-reported narrative. 136,000 miles reported. Look up ODI 10198544 at NHTSA ↗

TL*THE CONTACT OWNS A 1995 CHEVROLET CAPRICE. THE VEHICLE HAS PEP BOYS FUTURA, SIZE P235/70R15 TIRES. ON TWO SEPARATE OCCASIONS, WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE VIBRATED. THE CONTACT IMMEDIATELY PULLED OFF THE ROAD AND INSPECTED THE FRONT DRIVER SIDE TIRE. HE DISCOVERED A BULGE ON THE TREAD OF THE TIRE AT 14,000 MILES. THE CONTACT TOOK THE VEHICLE TO A TIRE DEALER AND THEY REPLACED THE TIRE. APPROXIMATELY TWO MONTHS LATER, THE CONTACT FELT A VIBRATION AND DISCOVERED THAT THE DRIVER SIDE REAR TIRE HAD A BULGE AT 16,000 MILE…

Owner-reported narrative. 163,000 miles reported. Look up ODI 10207621 at NHTSA ↗

Reported: 1995-04-24 (April 24, 1995)

THESE VEHICLES FAIL TO CONFORM TO FMVSS NO. 124, "ACCELERATOR CONTROL SYSTEMS." AT LOW TEMPERATURES, EXCESSIVE FRICTION CAN OCCUR IN THE ACCELERATOR PEDAL ASSEMBLY.

Consequence: CONSEQUENCE OF NON-COMPLIANCE: IN THE EVENT OF A FAILURE OF THE TROTTLE RETURN SPRING, IF THERE IS EXCESSIVE FRICTION IN THE PEDAL ASSEMBLY, THE ENGINE SPEED MAY NOT RETURN TO IDLE INCREASING THE POTENTIAL FOR A VEHICLE CRASH.

Remedy: DEALERS WILL REPLACE THE ACCELERATOR PEDAL ASSEMBLY.

Reported: 1995-11-03 (November 3, 1995)

THESE VEHICLES WERE SHIPPED WITH BOTH THE SUPPLEMENTAL INFLATABLE RESTRAINT CAUTION LABEL AND A ROOF RACK CAUTION LABEL INSTALLED ON THE SAME SIDE OF THE SUN VISOR. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO.208, "OCCUPANT CRASH PROTECTION."

Consequence: CONSEQUENCE OF NON-COMPLIANCE: OPERATORS COULD FAIL TO NOTICE AND HEED THE WARNING LABELS.

Remedy: A NEW ROOF RACK CAUTION LABEL, WITH INSTALLATION INSTRUCTIONS, WILL BE SENT DIRECTLY TO OWNERS. OWNERS WILL INSTALL THE LABEL OR HAVE THEIR DEALER INSTALL THE LABEL FOR THEM.

Reported: 1995-11-16 (November 16, 1995)

THESE VEHICLES WERE PRODUCED WITH AN IMPROPERLY ADJUSTED TRANSMISSION SHIFT CONTROL LINKAGE. THIS DOES NOT MEET WITH THE REQUIREMENTS OF FMVSS NO. 114, "THEFT PROTECTION."

Consequence: CONSEQUENCE OF NON-COMPLIANCE: IT MAY BE POSSIBLE TO SHIFT FROM THE "PARK" POSITION WITH THE IGNITION KEY REMOVED INCREASING THE RISK OF A VEHICLE ACCIDENT RESULTING FROM THE UNINTENDED MOVEMENT OF A PARKED VEHICLE.

Remedy: DEALERS WILL ADJUST THE SHIFT CONTROL LINKAGE SYSTEM.

Reported: 1996-01-30 (January 30, 1996)

DEFECTIVE LOWER CONTROL ARM BALL JOINT ATTACHMENT NUTS WERE NOT PROPERLY TORQUED AND CAN LOOSEN.

Consequence: THE LOWER CONTROL ARM BALL JOINT CAN LOOSEN, FATIGUE, AND SEPARATE FROM THE FRONT SUSPENSION KNUCKLE RESULTING IN A LOSS OF VEHICLE CONTROL.

Remedy: DEALERS WILL INSPECT BOTH FRONT LOWER CONTROL ARM BALL JOINT ATTACHMENT NUTS FOR PROPER TORQUE. IF THE BALL JOINT HAS LOOSENED, BOTH THE BALL JOINT AND THE KNUCKLE WILL BE REPLACED.

Reported: 1996-01-30 (January 30, 1996)

DEFECTIVE LOWER CONTROL ARM BALL JOINT ATTACHMENT NUTS WERE NOT PROPERLY TORQUED AND CAN LOOSEN.

Consequence: IF THE LOWER CONTROL ARM BALL JOINT LOOSENS, FATIGUES AND SEPARATES FROM THE FRONT SUSPENSION KNUCKLE, IT COULD CAUSE LOSS OF VEHICLE CONTROL.

Remedy: DEALERS WILL INSPECT BOTH FRONT LOWER CONTROL ARM BALL JOINT ATTACHMENT NUTS FOR PROPER TORQUE. IF THE BALL JOINT HAS LOOSENED FROM THE KNUCKLE, BOTH THE BALL JOINT AND THE KNUCKLE WILL BE REPLACED.

Reported: 1996-01-31 (January 31, 1996)

THE REAR LOWER CONTROL ARM CAN CRACK AT THE REAR STABILIZER BAR ATTACHMENT.

Consequence: THIS CONDITION CAN BE AGGRAVATED BY THE SEVERE DUTY CYCLE OF THESE VEHICLES AND EVENTUALLY CAUSE THE LOWER CONTROL ARM TO FRACTURE COMPLETELY CAUSING A LOSS OF VEHICLE CONTROL WITHOUT PRIOR WARNING.

Remedy: DEALERS WILL REPLACE BOTH REAR LOWER CONTROL ARMS AND REAR STABILIZER BAR ATTACHMENTS.

Reported: 1996-12-10 (December 10, 1996)

THE WHEEL LUG NUTS WERE NOT TIGHTENED TO THE PROPER SPECIFICATION DURING ASSEMBLY.

Consequence: THIS CONDITION COULD RESULT IN A FRACTURE OF THE WHEEL STUDS CAUSING THE WHEEL TO SEPARATE FROM THE VEHICLE.

Remedy: DEALERS WILL TIGHTEN THE VEHICLE'S WHEEL LUG NUTS TO THE PROPER SPECIFICATION.