2004 Coleman CARAVAN: complaints, problems and recalls
Explore the records behind recurring owner reports.
Key facts
0 owner complaints analyzed
2 distinct recall campaigns
Not available median reported failure mileage
Scope: 2004 model year. Data updated: . 0 complaints include usable failure mileage. View data status.
Most common problems
No owner complaints are recorded for this selection. A complaint can name multiple components.
Component breakdown
Number of unique complaints naming each component. Top eight shown.
No usable records for this chart.
| Category | Count |
|---|
No records.
Reported problems by failure mileage
Complaint counts in mileage bands. These are not failure rates per vehicle or mile.
| Category | Count |
|---|---|
| Under 25,000 | 0 |
| 25,000 to 49,999 | 0 |
| 50,000 to 74,999 | 0 |
| 75,000 to 99,999 | 0 |
| 100,000 to 149,999 | 0 |
| 150,000 and above | 0 |
Under 25,000: 0; 25,000 to 49,999: 0; 50,000 to 74,999: 0; 75,000 to 99,999: 0; 100,000 to 149,999: 0; 150,000 and above: 0
No usable failure mileage is recorded. 0 complaints have missing, zero or invalid mileage.
Complaints over time
Year the complaint was filed, not the vehicle model year or incident year. The snapshot year is partial.
No usable records for this chart.
| Category | Count |
|---|
No records.
Pattern summary
There is not enough complaint evidence to summarize patterns.
Calculated from recorded counts. An AI narrative has not been published for this selection.
Examples from the source records
Examples provide context, not a representative sample or a verified diagnosis.
Recall history
2 distinct campaigns affect this selection. Announcement dates below are different from vehicle model years. A campaign may cover multiple years.
03V452000 · Equipment:Recreational Vehicle/Trailer
Reported: 2003-11-04 (November 4, 2003)
ON CERTAIN TRAVEL TRAILERS EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE OVENS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.
Consequence: AN ELECTRICAL SHORT CAN OCCUR CAUSING THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. THIS COULD RESULT IN EXCESSIVE HEAT, SMOKE, OR POSSIBLY A FIRE.
Remedy: SAMSUNG WILL NOTIFY CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. IN THE MEANTIME, CONSUMERS SHOULD UNPLUG THEIR MICROWAVE, IF POSSIBLE. IF THE CONSUMER IS UNABLE TO UNPLUG THE MICROWAVE, THEY SHOULD LEAVE THE DOOR AJAR UNTIL THE PANEL IS REPLACED. CONSUMERS SHOULD NEVER USE THE MICROWAVE OVEN FOR STORAGE OR LEAVE ANY TOWELS, PAPER, CLOTH OR OTHER PRODUCTS IN THE MICROWAVE AFTER USE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SAMSUNG AT 800-932-3837 OR FLEETWOOD AT 1-800-629-8454.
NHTSA campaign record ↗08V362000 · Equipment:Recreational Vehicle/Trailer
Reported: 2008-07-30 (July 30, 2008)
FLEETWOOD FOLDING IS RECALLING 1,394 MY 2004 CARAVAN, MICRO-LITE AND MY 2005 RESORT TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
Consequence: IF THIS SOLUTION IS EXPOSED TO AN IGNITION SOURCE UNDER CERTAIN SPECIFIC CIRCUMSTANCES, IT CAN RESULT IN A VEHICLE FIRE.
Remedy: FLEETWOOD FOLDING IS WORKING WITH DOMETIC TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR FLEETWOOD FOLDING AT 1-814-445-9661.
NHTSA campaign record ↗Vehicle analysis explorer
Inspect model-year patterns, reported mileage, monthly activity and the evidence behind each signal.
Data completeness
0 unique complaints in this selection. Analysis snapshot: 2026-09-30.
Missing, zero and invalid mileage is excluded. Dates after the snapshot are excluded. Examples are limited selections, not a representative sample.
Problems by model year
Model-wide comparison of the eight most reported components across the model. Cells show counts and shares within each model year. Open a cell for source examples.
| Component | 2000 | 2001 | 2002 | 2003 | 2004 |
|---|---|---|---|---|---|
| Structure | 00.0%No examples available for this selection. | 133.3%ODI 10478203WENT TO CLEAN THE TRAILER AND WHEN I WENT INTO THE BATHROOM I NOTICED THAT THE FLOOR IMMEDIATELY ADJACENT TO THE SHOWER/TUB WAS SAGGING AND SPONGY. THE TRAILER HAS NOT BEEN USED IN 1 - 2 YEARS. THIS TRAILER ALSO HAS A TENDENCY TO LEAK AROUND THE PULL OUT FRONT BED, AND WE HAVE HAD THAT REPAIRED NUMEROUS TIMES AFTER WE FIRST BOUGHT THE TRAILER. FROM LOOKING AT THE INTERNET THIS TRAILER'S TENDENCY TO LEAK AND DAMAGE THE FLOORS IS NOT NEW AND IF THE MANUFACTURER KNEW ABOUT THIS PROBLEM THEN IT SHOULD BE REPAIRED AT THEIR EXPENSE. *TR | 337.5% | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. |
| Equipment | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 112.5%ODI 10243858I HAVE A 2002 COLEMAN CARAVAN AND THE REFRIGERATOR IN THE CAMPER STARTED DEFROSTING AND HAD A STRONG AMMONIA SMELL INSIDE AND OUTSIDE THE CAMPER. THERE IS YELLOW STUFF COMING OUT IN A PANEL IN THE REAR OF THE CAMPER AND STRONG ODOR INSIDE THE CAMPER AS WELL. I FOUND OUT ABOUT A RECALL ON THESE YESTERDAY AND CALLED AND THE COMPANY SAID THE ONLY THING THEY WILL DO IS PAY A DEALER TO PUT A "SHIELD" OVER THE PART THAT IS CRACKED THAT THE STUFF LEAKED OUT FROM AND NOTHING MORE. THEY SAID THAT IT WAS A FIRE HAZARD AND THE SHIELD WOULD CONTAIN A FIRE … | 1100.0%ODI 10363941OUR 2003 COLEMAN CARAVAN RV ALMOST BURNED UP ON OCTOBER 31, 2010 BECAUSE OF THE REFRIGERATOR. I HEARD A SIZZLING SOUND AND TOOK BACK OFF REFRIGERATOR, IT WAS VERY HOT. I TURNED THE GAS OFF AND UNHOOKED BATTERY. I CONTACTED DOMETIC TO LET THEM KNOW THAT THE RECALL DID NOT FIX OURS AND WAS TOLD IT WAS UP TO ME TO FIX THAT THERE WAS NOTHING MORE THEY WOULD DO. THANK GOD I CHECKED OUR CAMPER OR IT PROBABLY WOULD HAVE BURNT UP. *TR | 0UnavailableNo examples available for this selection. |
| Equipment:Recreational Vehicle/Trailer | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 225.0%ODI 10060604SAMSUNG RECREATIONAL VEHICLE MICROWAVE. MODEL NUMBER MR5492W. *JB | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. |
| Engine And Engine Cooling:Engine:Gasoline | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 112.5%ODI 10031629 · 56,000 miCONSUMER STATES THAT WHEN TRYING TO ACCELERATE, THE GAS PEDAL HAS TO ALMOST BE PRESS TO THE FLOOR BEFORE IT ENGAGES. RPM'S ARE AT 3000. PLEASE PROVIDE ANY FURTHER INFORMATION. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. |
| Engine And Engine Cooling:Engine:Gasoline:Belts And Associated Pulleys | 150.0%ODI 10103453 · 54,061 miTHE SERPENTINE BELT FELL THE VEHICLE OFF EACH TIME THE VEHICLE DROVE OVER WATER. THE DEALER REPLACED THE BELT AND IT HAS BECOME A CONTINUAL PROBLEM. *JB | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. |
| Latches/Locks/Linkages:Doors:Latch | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 112.5%ODI 10007085THE LOCKS ON THE PASSENGER REAR DOOR SPORADICALLY LOCKED AND UNLOCKED. *JB | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. |
| Power Train:Axle Assembly:Axle Shaft:Seal | 00.0%No examples available for this selection. | 133.3%ODI 10036713 · 500 miCOLEMAN / FLEETWOOD CARAVAN TRAVEL TRAILERS MODEL YEARS 2001 THROUGH PRESENT HAVE INCORRECTLY CUTOUT SLOTS FOR THE AXLE LEAF SPRING ATTACHMENT SHACKLES. THE ATTACHMENT BOLTS STRIKE THE FRAME WHEN THE SUSPENSION MOVES, CAUSING THE BOLT HEADS TO POUND GASHES INTO THE FRAME. EVENTUALLY THE BOLT LOCKS INTO THE FRAME AND THE SUSPENSION FREEZES UP. THIS CAUSES THE TRAILER TO SWAY DRAMATICALLY AT HIGHWAY SPEED AND CAUSES A LOSS OF CONTROL. DAMAGE TO THE ATTACHMENT BOLTS CAN ALSO RESULT IN THE SUSPENSION COMING APART. I OWN A 2002 MODEL AND HAD TO … | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. |
| Seat Belts:Rear/Other | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 112.5%ODI 10024128AS A RESULT OF A VEHICLE CRASH PASSENGER'S REAR SEAT BELT RELEASED RESULTING IN CHILD BEING TOSSED OUT OF SEAT. *AK | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. |
Darker cells indicate a larger share of submitted complaints. Components overlap. This measures complaint composition, not failure probability.
Failure mileage by component
Median and middle 50% of usable owner-reported mileages. Ranges require at least five records.
| Component | Mileage range (25th–75th percentile) | Median | Usable records | Examples |
|---|---|---|---|---|
| No usable records for this analysis. | ||||
Complaint and recall timeline
Explore monthly filing activity alongside recall announcements. Up to ten years of monthly history is available.
Solid line: filed complaints. Dashed amber lines: recall announcement dates for this vehicle selection; markers include all recall components. The latest month is partial. Temporal proximity does not establish causation.
Monthly counts, recall campaigns and complaint examples
| Month | Complaints | Campaigns announced | Examples |
|---|---|---|---|
| 2024-10 | 0 | None | No examples available for this selection. |
| 2024-11 | 0 | None | No examples available for this selection. |
| 2024-12 | 0 | None | No examples available for this selection. |
| 2025-01 | 0 | None | No examples available for this selection. |
| 2025-02 | 0 | None | No examples available for this selection. |
| 2025-03 | 0 | None | No examples available for this selection. |
| 2025-04 | 0 | None | No examples available for this selection. |
| 2025-05 | 0 | None | No examples available for this selection. |
| 2025-06 | 0 | None | No examples available for this selection. |
| 2025-07 | 0 | None | No examples available for this selection. |
| 2025-08 | 0 | None | No examples available for this selection. |
| 2025-09 | 0 | None | No examples available for this selection. |
| 2025-10 | 0 | None | No examples available for this selection. |
| 2025-11 | 0 | None | No examples available for this selection. |
| 2025-12 | 0 | None | No examples available for this selection. |
| 2026-01 | 0 | None | No examples available for this selection. |
| 2026-02 | 0 | None | No examples available for this selection. |
| 2026-03 | 0 | None | No examples available for this selection. |
| 2026-04 | 0 | None | No examples available for this selection. |
| 2026-05 | 0 | None | No examples available for this selection. |
| 2026-06 | 0 | None | No examples available for this selection. |
| 2026-07 | 0 | None | No examples available for this selection. |
| 2026-08 | 0 | None | No examples available for this selection. |
| 2026-09 (partial) | 0 | None | No examples available for this selection. |
Emerging complaint spikes
Complete months in the latest six months with at least 10 complaints, at least twice the preceding 12-month average, and at least three square-root deviations above that average.
This is a descriptive screening rule, not a statistical defect finding. Publicity and reporting changes can increase submissions.
No complete months meet the spike thresholds for this selection.
Equal-age model-year comparison
Model-wide cumulative reports during the first three or five calendar years, starting with the model year (age 0). Only fully elapsed windows are compared.
2003: 0 complaints · 2004: 0 complaints
| Model year | Through age 0 | Through age 1 | Through age 2 |
|---|---|---|---|
| 2003 | 0 | 0 | 0 |
| 2004 | 0 | 0 | 0 |
Date coverage across each selected cohort
| Year | Incident dates used | Filing date fallbacks | Excluded dates |
|---|---|---|---|
| 2003 | 1 | 0 | 0 |
| 2004 | 0 | 0 | 0 |
Incident date is preferred when valid and no later than filing; otherwise filing date is used. Model year approximates age. Equal observation time does not adjust for sales, distance driven or reporting delays. One complaint linked to multiple model years can appear in each cohort.
Components reported together
Each cell counts unique complaints naming both components. Open a nonzero cell for examples.
| Component |
|---|
| No usable records for this analysis. |
Co-reporting does not establish that one component caused another concern.
Recurring narrative patterns
Specific keyword mentions beyond broad component labels. Matching includes negations and comparisons and does not confirm a diagnosis.
0 patterns with matching reports.
No narratives match the published patterns.