2018 Fleetwood DISCOVERY LXE: complaints, problems and recalls

March 2020, Driver's side low beam lens cracked upon debris impact but still operated. Sealed outside with clear packing tape. July 22, 2023, ordered replacement LED headlights from Kaper II, they had said original lights are not available any longer. In investigating in January of 2023, found a recall for same problem on vehicles manufactured just prior to mine. Details of recall (RECALL CAMPAIGN #170720REV) matched headlights in my coach. Contacted REV Fleetwood, they said not specified VIN in recall, no coverage. Contacted Kaper II (headli…

Owner-reported narrative. Look up ODI 11549568 at NHTSA ↗

Reported: 2017-07-27 (July 27, 2017)

REV Recreation Group (REV) is recalling certain 2017-2018 Fleetwood Discovery and Discovery LXE, and Holiday Rambler Endeavor, Endeavor XE, and Admiral XE motorhomes, as well as 2018 Monaco Diplomat, Fleetwood Pace Arrow, Bounder, Flair, and Storm motorhomes, and Holiday Rambler Navigator and Vacationer XE motorhomes. The affected vehicles may have been manufactured with headlights that do not have tempered glass lenses.

Consequence: If the headlamp lens is not tempered, it may crack or break, which may cause decreased illumination and/or premature failure of the headlight bulb, increasing the risk of a crash.

Remedy: REV Recreation Group will notify owners, and authorized REV dealers will inspect, and if necessary, replace non-tempered, defective headlamp lenses with new headlamp lenses, free of charge. The recall began on September 8, 2017. Owners may contact REV customer service at 1-800-509-3417. REVs number for the recall is 170720REV.

Reported: 2017-12-19 (December 19, 2017)

REV Recreation Group (REV) is recalling certain 2018 American Coach American Dream, American Revolution, Fleetwood Discovery, Discovery LXE, Holiday Rambler Endeavor, Endeavor XE, and Monaco Marquis recreational vehicles. Water may enter the 12-volt harness connectors due to missing gaskets or the placement of the pin connectors, potentially causing an electrical short.

Consequence: An electrical short can increase the risk of a crash.

Remedy: REV Recreation Group will notify owners, and dealers will inspect, and if necessary, install a gasket for each affected harness pin connector and re-route harnesses that terminate near luggage compartment number five, free of charge. The recall began on February 15, 2018. Owners may contact REV customer service at 1-800-509-3417. REV's number for this recall is 171213REV.

Reported: 2018-03-19 (March 19, 2018)

REV Recreation Group (REV) is recalling certain 2018 American Coach American Dream and American Revolution motorhomes, Fleetwood Discovery, Discovery LXE, Pace Arrow and Pace Arrow LXE motorhomes, Holiday Rambler Endeavor, Endeavor XE, Navigator and Navigator XE motorhomes and Monaco Marquis and Signature motorhomes equipped with an Aurora heating, ventilation and air conditioning (HVAC) system. The wires for the HVAC system potentiometer may become disconnected from the quick connect terminals.

Consequence: If the potentiometer wires detach and are reconnected incorrectly, there is an increased risk of a fire.

Remedy: REV will notify owners, and dealers will inspect the potentiometer and solder the wires or replace the control panel, if necessary, free of charge. The recall began on May 14, 2018. Owners may contact REV customer service at 1-800-509-3417. REV's number for this recall is 180315REV.

Reported: 2018-03-28 (March 28, 2018)

REV Recreation Group (REV) is recalling certain 2018 Fleetwood Axon and Pulse, Holiday Rambler Reno and Prodigy, Monaco Marquis and American Coach American Dream motorhomes, 2017-2018 Fleetwood Bounder, Discovery, Discovery LXE, Flair, Jamboree, Southwind, Pace Arrow, Pace Arrow LXE and Storm motorhomes, Holiday Rambler Admiral XE, Endeavor, Endeavor XE, Navigator XE, Navigator, Vacationer, Vacationer XE and Vesta and American Coach American Eagle motorhomes and 2017 Holiday Rambler Scepter, Monaco Diplomat, and American Coach American Revolution motorhomes. The mounting screws for the satellite dish may not have been fastened through the sheet steel reinforcement, possibly allowing the satellite dish to detach from the roof while driving.

Consequence: If the satellite dish detaches from the roof while driving, it can increase the risk of a crash or injury.

Remedy: REV will notify owners, and dealers will resecure the satellite dish to the roof with a metal reinforcement, free of charge. The recall began on May 14, 2018. Owners may contact REV customer service at 1-800-509-3417. REV's number for this recall is 180322REV. Note: This recall supersedes recall 17V-802. Any vehicle repaired under that campaigned is not included in this one as the remedy for both recalls is the same.