2003 Fleetwood SOUTHWIND: complaints, problems and recalls

2003 FLEETWOOD 32VS HAS SUFFERED ENGINE SHUT DOWN 19 TIMES.*MR THE DIAGNOSTIC TEST READS "ENGINE REDUCED POWER". THE ENGINE CONTINUED TO IDLE ROUGH BUT THERE WAS NO THROTTLE POWER. IN ONE YEAR THE COACH HAS BEEN TO THE WORKHORSE REPAIR STATION SIX TIMES FOR THE SAME PROBLEM. SO FAR THE PROBLEM HAS NOT BEEN FIXED. THE COACH WOULD USUALLY RESTART AND PROCEED NORMALLY AFTER BEING ALLOWED TO COOL FOR ABOUT TWO HOURS. *NM

Owner-reported narrative. Look up ODI 10117299 at NHTSA ↗

DT*: THE CONTACT STATED THERE ARE CURRENTLY NO PROBLEMS WITH THE MICROWAVE, BUT A RECALL LETTER WAS RECEIVED, MARCH 16, 2006. THE RECALL, #03V452000, IS ON THE MICROWAVE. THE MANUFACTURER HAS BEEN CONTACTED AND SUGGESTED MULTIPLE PLACES TO HAVE THE REPAIRS MADE; NONE OF THESE PLACES HAVE BEEN WILLING TO ASSIST IN THE REPAIR. UPDATED 5/2/2006 - SAMSUNG SENT RECALL 04-E-031 FOR THE MICROWAVE. THE CONSUMER CALL THE 800 NUMBER AND THEY SET UP AND APPT AND SENT A WORK ORDER TO APPLIANCE STORE. THE APPLIANCE STORE CHANGED THEIR MIND AND REFUSED…

Owner-reported narrative. 2,700 miles reported. Look up ODI 10154017 at NHTSA ↗

TL*THE CONTACT OWNS A 2003 FLEETWOOD SOUTHWIND. WHILE DRIVING 15 MPH, THE FRONT BRAKES FAILED AS THE CONTACT ATTEMPTED TO STOP THE VEHICLE AND HE SMELLED SOMETHING BURNING. WHEN THE BRAKES COOLED DOWN, HE TOOK THE VEHICLE TO A REPAIR SHOP AND THE MECHANIC STATED THAT THE PADS WERE WORN AND THE ROTORS NEEDED TO BE CHANGED. THE VEHICLE WAS REPAIRED, HOWEVER, THE FAILURE RECURRED FOUR MONTHS LATER. THE NUMBER OF CYLINDERS AND POWERTRAIN WERE UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 24,000.

Owner-reported narrative. 24,000 miles reported. Look up ODI 10202050 at NHTSA ↗

UPON ENTERING ONTO A HIGHWAY FROM A PLACE OF BUSINESS WE HEARD A VERY LOUD SNAP NOISE. JUST THINKING IT WAS A PIECE OF ICE COMING THE COACH. WHEN WE REACHED OUR FINAL DESTINATION, WE DISCOVERED A BROKEN LEAF SPRING ON THE RIGHT REAR AXEL. THIS COULD HAVE BEEN VERY SERIOUS HAD THE OTHER SPRING BROKEN WHILE MOVING{ THROUGH MOUNTAINS}! *TR

Owner-reported narrative. 7,828 miles reported. Look up ODI 10215746 at NHTSA ↗

TL*THE CONTACT OWNS A 2003 FLEETWOOD SOUTHWIND W22. ON JULY 3 2007, WHILE DRIVING 45 MPH, THE FRONT PASSENGER SIDE OF THE VEHICLE SHOOK. THE CONTACT SMELLED SOMETHING BURNING AND PULLED OVER TO THE SIDE OF THE ROAD. HE NOTICED THAT THE BRAKE CALIPER LOCKED. THE FAILURE WAS REPAIRED AT THE COST OF $837. ON FEBRUARY 1, 2008, THE DRIVER'S SIDE CALIPER ALSO FAILED. THE CONTACT PULLED OVER AND WAITED UNTIL THE CALIPER RELEASED. SHE THEN DROVE THE VEHICLE TO THE DEALER AND THEY REPAIRED THE FAILURE AT THE COST OF $873. THE MANUFACTURER WAS NO…

Owner-reported narrative. 24,162 miles reported. Look up ODI 10217972 at NHTSA ↗

TL*THE CONTACT OWNS A 2003 FLEETWOOD SOUTH WIND. THE CONTACT NOTICED THAT THE TRAILER HITCH PUSHED UP INTO HIS COACH. AS A RESULT, THE HITCH CRUSHED THE FIBERGLASS. UPON INSPECTION, HE FOUND THAT THE BOTTOM PART OF THE HITCH WELD HAD NOT PENETRATED THE STEEL. THERE IS A SAFETY RECALL FOR THE TRAILER HITCHES (NHTSA CAMPAIGN ID 04V352000). THE CURRENT MILEAGE WAS 24,000 AND FAILURE MILEAGE WAS 17,000. THE VEHICLE PURCHASE DATE WAS UNAVAILABLE.

Owner-reported narrative. 17,000 miles reported. Look up ODI 10222165 at NHTSA ↗

LED CLUSTER ON DASH FADED AND BECAME UNREADABLE. COULD NOT READ THE GEAR THE VEHICLE WAS IN, E.G. PARK, REVERSE, OR DRIVE, MILEAGE, AND TRIP MILEAGE WAS ALSO UNREADABLE, BUT DID NOT CREATE SAFETY ISSUE. *TR

Owner-reported narrative. 20,000 miles reported. Look up ODI 10233842 at NHTSA ↗

BRAKE FAILURE ON A 2003 FLEETWOOD WORKHORSE CHASSIS MOTORHOME. PEDAL GOES TO THE FLOOR. *TR

Owner-reported narrative. 20,888 miles reported. Look up ODI 10246044 at NHTSA ↗

Reported: 2003-09-16 (September 16, 2003)

ON CERTAIN MOTORHOMES BUILT ON WORKHORSE CHASSIS, THE HYDRAULIC HOSE OPERATING THE LEVELING JACK SYSTEM WAS ROUTED SO IT PLACES THE HOSE TOO CLOSE TO THE ENGINE EXHAUST. THE HOT EXHAUST CAN CAUSE THE HYDRAULIC HOSE TO MELT OR ABRADE, RELEASING HYDRAULIC FLUID.

Consequence: IF THE HYDRAULIC FLUID SHOULD IGNITE BY AN EXHAUST GAS RECIRCULATING TUBE OR OTHER HEAT SOURCE, THIS COULD CAUSE A FIRE.

Remedy: DEALERS WILL INSPECT AND REPLACE DAMAGED HOSES AND RELOCATE THE AFFECTED HYDRAULIC LINES. OWNER NOTIFICATION IS EXPECTED TO BEGIN OCTOBER 3, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FLEETWOOD AT 1-800-322-8216.

Reported: 2003-11-04 (November 4, 2003)

ON CERTAIN TRAVEL TRAILERS EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE OVENS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.

Consequence: AN ELECTRICAL SHORT CAN OCCUR CAUSING THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. THIS COULD RESULT IN EXCESSIVE HEAT, SMOKE, OR POSSIBLY A FIRE.

Remedy: SAMSUNG WILL NOTIFY CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. IN THE MEANTIME, CONSUMERS SHOULD UNPLUG THEIR MICROWAVE, IF POSSIBLE. IF THE CONSUMER IS UNABLE TO UNPLUG THE MICROWAVE, THEY SHOULD LEAVE THE DOOR AJAR UNTIL THE PANEL IS REPLACED. CONSUMERS SHOULD NEVER USE THE MICROWAVE OVEN FOR STORAGE OR LEAVE ANY TOWELS, PAPER, CLOTH OR OTHER PRODUCTS IN THE MICROWAVE AFTER USE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SAMSUNG AT 800-932-3837 OR FLEETWOOD AT 1-800-629-8454.

Reported: 2004-07-20 (July 20, 2004)

CERTAIN MOTOR HOMES EQUIPPED WITH DRAW TITE HITCH RECEIVERS MAY BE MISSING ONE OR MORE WELDS BETWEEN THE HITCH RECEIVER BOX AND THE BOTTOM SUPPORT PLATE.

Consequence: THE WELDS COULD BREAK, ALLOWING THE HITCH RECEIVER BOX AND THE TOWED LOAD TO SEPARATE FROM THE TOWING VEHICLE, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT AND REPLACE THE HITCH RECEIVER. THE RECALL IS EXPECTED TO BEGIN DURING AUGUST 2004. OWNERS SHOULD CONTACT FLEETWOOD AT 1-800-322-8216.

Reported: 2006-04-12 (April 12, 2006)

CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS AND EQUIPPED WITH ACTIA CORPORATE INSTRUMENT CLUSTERS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 101 "CONTROLS AND DISPLAYS" AND NO. 105 "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." IF THE BRAKE FAIL INPUT FALLS BELOW A VOLTAGE OF 1.5V, THE BRAKE FAILURE LAMP AND ALARM WILL BE ACTIVATED. ALSO ACTIVATION OF THE ABS TELLTALE WHEN THE ABS IS NOT PROPERLY FUNCTIONING DOES NOT ALWAYS OCCUR.

Consequence: AT NIGHT THE INSTRUMENT CLUSTER LIGHTS MAY FAIL AND THE DRIVER MAY NOT BE ABLE TO SEE THE INSTRUMENT PANEL GAUGES AND THE BRAKE WARNING LIGHT INDICATOR WHICH COULD INCREASING THE RISK OF A CRASH.

Remedy: WORKHORSE IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN AND REPROGRAM THE INSTRUMENT PANEL CLUSTER FREE OF CHARGE. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731 OR FLEETWOOD AT 1-800-322-8216.

Reported: 2007-03-19 (March 19, 2007)

CERTAIN MOTOR HOMES AND TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Consequence: RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.

Remedy: FLEETWOOD WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST YOU IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR FLEETWOOD AT 1-800-322-8216.

Reported: 2008-07-15 (July 15, 2008)

FLEETWOOD IS RECALLING 70,101 MY 2003-2007 SOUTHWIND, PACE ARROW, BOUNDER, FLAIR, STORM, FIESTA, TERRA GAS CLASS A MOTOR HOMES; BOUNDER, DISCOVERY, PROVIDENCE, EXCURSION, EXPEDITION, REVOLUTION, AMERICAN EAGLE, AMERICAN HERITAGE, AMERICAN TRADITION DIESEL CLASS A MOTOR HOMES; JAMBOREE TIOGA CLASS C MOTOR HOMES; AND PROWLER, WILDERNESS, TERRY, MALLARD, PIONEER, PRIDE AND TRIUMPH CONVENTIONAL AND FIFTH WHEEL TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATORS MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Consequence: IF THIS SOLUTION IS EXPOSED TO AN IGNITION SOURCE UNDER CERTAIN SPECIFIC CIRCUMSTANCES, IT CAN RESULT IN A VEHICLE FIRE.

Remedy: FLEETWOOD IS WORKING WITH DOMETIC TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR FLEETWOOD AT 1-800-322-8216.

Reported: 2009-06-02 (June 2, 2009)

FLEETWOOD IS RECALLING 509 MY 2001-2008 CLASS A MOTOR HOMES EQUIPPED WITH AXLES THAT INCLUDE BOSCH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED WITH OCCASIONAL OR SEASONAL VEHICLE OPERATION MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION. THIS CAN RESULT IN ABNORMAL HEAT GENERATION AT THE WHEEL END CAUSING BRAKE DRAG. THE DRIVER WOULD NORMALLY HAVE WARNING OF THE BRAKE DRAG IF UNDETECTED BY THE DRIVER.

Consequence: THE DRIVER WOULD NORMALLY DETECT THE BRAKE DRAG BUT IF UNDETECTED THE TEMPERATURE INCREASE AT THE WHEEL END CAN EVENTUALLY LEAD TO SOFT PEDAL CONDITIONS DUE TO BRAKE FLUID BOIL, AND POSSIBLE EXTENDED STOPPING DISTANCE INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT AND REPLACE THE NECESSARY COMPONENTS FREE OF CHARGE. WORKHORSE IS HANDLING THE REMEDY FOR THIS CAMPAIGN PLEASE SEE 09V-110. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731. WORKHORSE WILL CONDUCT THE OWNER AND DEALER NOTIFICATION.

Reported: 2009-07-28 (July 28, 2009)

FLEETWOOD RV IS RECALLING CERTAIN MODEL YEAR 2005 AND 2006 MOTORHOMES MANUFACTURED BETWEEN JULY 24, 2004 AND MARCH 11, 2005, EQUIPPED WITH NORCOLD MODEL 1200LR, 1200LRIM, AND 1201LRIM REFRIGERATORS WITH SERIAL NUMBERS BETWEEN 1273701 AND 1536607, NON-CONSECUTIVELY. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK. IF A LEAK OCCURS AND THE REFRIGERATOR CONTINUES TO BE OPERATED AFTER SOLUTION CIRCULATION HAS CEASED THE HEAT SOURCE COULD GENERATE VERY HIGH TEMPERATURES. AT SUCH HIGH TEMPERATURES, THE COOLING UNIT COULD RUPTURE.

Consequence: IF A LEAK OCCURS AND THE UNIT IS CONTINUES TO OPERATE, HYDROGEN GAS MAY BE EXPELLED AND CAN BE IGNITED, RESULTING IN A FIRE, POSSIBLY CAUSING SERIOUS INJURY OR DEATH.

Remedy: FLEETWOOD RV WILL NOTIFY OWNERS AND THE VEHICLE'S REFRIGERATOR WILL BE REPAIRED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING SEPTEMBER 2009. OWNERS MAY CONTACT FLEETWOOD RV AT 1-800-509-3418 OR NORCOLD'S RECALL CENTER AT 1-800-767-9101.