2000 Ford E-150: complaints, problems and recalls

ADULT MALE DRIVER, I'VE RAN A TRUCK SALES SINCE 1971, DRIVING ALL BRANDS AN THIS IS A FIRST AND THE MOST DANGEROUS 2 OR 3 MINUTES OF MY LIFE..... DRIVING A 2009 FORD F150 61,62 MPH ON CRUISE, COMING INTO LEARY GEORGIA AN APPROACHING 2 VEHICLES AHEAD OF ME, I TOUCHED THE BRAKE PETAL TO RELEASE THE CRUISE CONTROL. THIS IS THE START OF A NITE MARE. THE THROTTLE WENT WIDE OPEN, FROM 60 I GO TO 75 -80 I HAD TO PASS THE 2 CARS AHEAD IN TOWN OR REAR END THEM. I HAD BOTH FEET ON THE BRAKE AN THE TRANSMISSION KEPT DOWNSHIFTING GIVING…

Look up ODI 10564544 at NHTSA ↗

I HAVE A F150 2011 3.5L ECO BOOST MOTOR THAT FAILED TO ACCELERATE AFTER FILLING UP WITH GAS AT A REST STOP. I WAS NEAR CHICAGO ON INTERSTATE 80/90 I TRIED TO PULL OUT USING THE ACCELERATION RAMP TRAFFIC WAS EXTREMELY HEAVY SO NEEDED TO USE THE ECO BOOST POWER WHEN THE ENGINE STARTED TO SHUTTER AND THE SERVICE ENGINE LIGHT KEEP FLASHING ON THEN OFF. I HAD MY WIFE WITH ME AND WE HAD TO PULL OVER TO SIDE OF THE ROAD BECAUSE THE MOTOR LOST POWER. I COULD NOT GET ONTO THE ROAD BECAUSE OF THE TRAFFIC. THERE WAS A LOT OF SEMI-TRUCK ON THE ROAD T…

Look up ODI 10553220 at NHTSA ↗

I WAS DRIVING 65 ON THE HIGHWAY AND MY TRUCK DOWNSHIFT TO 3RD GEAR THEN BACK TO 5TH GEAR THEN FIRST GEAR. LOCKING MY WHEELS. TIRES SCREECHING. I HAD TO PULL OVER AND TURN MY TRUCK OFF, OPEN THE DOOR TO TRY TO RESET THE VEHICLE. IVE READ THREADS OF PEOPLE HAVING A SIMILAR PROBLEM AND TURNING OFF THE TRUCK, OPENING THE DOOR RESETS THE VEHICLE.. PO722-00 CODE OUTPUT SHAFT SPEED SENSOR CIRCUIT NO SINGLE - PENDING DTC

Look up ODI 11115513 at NHTSA ↗

AS REPORTED TO DEALER : CUSTOMER STATES WHEN ACCELERATING IN LOW GEAR AND LETTING OFF THE ACCELERATOR IT WILL CONTINUE TO MAINTAIN THE RPM UNTIL YOU HIT HARD ON THE BRAKES. MY ADDED COMMENTS IS THAT 1800 RPM WHEN NORMAL HIGHWAY SPEED IS OVER 60 MPH. IN STOP AND GO TRAFFIC THE DRIVER MUST MAINTAIN BRAKE WITH LEFT FOOT AND GAS WITH RIGHT FOOT OR YOU WILL REAR END THE CAR IN FRONT OF YOU. PS DEALER PERFORMED TEST AND STATED AT THIS TIME COMPARED TO LIKE UNITS AND THEY DO THE SAME THING. I TEST DROVE A NEW TRUCK WITH SAME ENGINE AND TRANS. AS…

Look up ODI 10712172 at NHTSA ↗

12/1/2010 EXPLANATION OF TWO LIFE THREATENING SITUATIONS SITUATION ONE: ON MAY 4, 2010, I THE CONSUMER, WAS DRIVING FROM JOHNS CREEK, GEORGIA TO CHATTANOOGA, TENN. THE TRIP WAS ON GEORGIA HWY 400 SOUTH FROM OLD MILTON PKWY TO I-285 WEST AND NORTH ON I-75. THE TIME WAS BETWEEN 3:30 PM AND 5:30PM. THE VAN WAS DIFFICULT TO CONTROL AND WAS MOVING FROM THE LEFT TO THE RIGHT SIDES OF THE TRAFFIC LANE. THE TRAFFIC WAS CONSIDERED NORMAL FOR I-75 WITH 18 WHEEL TRUCK AND PASSENGER CAR TRAFFIC. THE VAN WAS DRIVEN WITH THE FLOW OF TRAFFIC APPROXI…

Look up ODI 10375895 at NHTSA ↗

THIS VEHICLE, A 2011 E-150 FORD VAN WAGON. STEERING BECOMES UNCONTROLLABLE STARTING AT 50 MPH AND BECOMES PROGRESSIVELY WORSE AS SPEED INCREASES TO 75 MPH. THE 2 PRIOR INCIDENCES REFERENCED ABOVE OCCURRED BETWEEN 50-75 MPH. ANY SLIGHT ADJUSTMENTS BY DRIVER, ESPECIALLY AT 70 MPH, CREATES SWAY CONDUCIVE TO ROLLOVER. IT SEEMS AS IF THE "POWER ASSIST" INTERFERES WITH DRIVER'S CONTROL OF STEERING WHEEL. AT HIGHER SPEEDS, OVER-STEER IS CREATED AND WHEN THE DRIVER MAKES A CORRECTION, A SWAYING EFFECT IS CREATED. AS SPEED INCREASES, THE POWER ASSIST F…

Look up ODI 10409490 at NHTSA ↗

DRIVING THIS VAN IS VERY DIFFICULT, IT WILL NOT HOLD A STRAIGHT LINE ,WHEN YOU PASS BIG TRUCKS GOING APPROXIMATELY 65 MPH ,THE VACUUM SUCKS IT UP ,AND IT GETS MORE UNCONTROLLABLE,CAUSING A MINOR FISH TALE. OF COURSE FORD CHECKED IT OUT AND FOUND NOTHING WRONG .M---KS COULD NOT DUPLICATE THE PROBLEM..DO NOT DRIVE THIS VAN IF IS AT ALL WINDY,COULD BECOME UNCONTROLLABLE AND UNSAFE . THE WANDERING IN THE STEERING IS NOT ACCEPTABLE .I WOULD NOT RECOMMEND THIS VAN FOR ANYONE. OR ANY BUSINESS. *TR

Look up ODI 10524465 at NHTSA ↗

12-25-2016 AFTER DROOPING OFF MAID AND GARDENER HERE IN HUATULCO MEXICO MY POWER STEERING QUIT. SINCE GOING SO SLOW DOWN HILL ON VILLAGE STREET I THOUGHT THAT MOTOR HAD QUIT. REALIZED THAT MOTOR WAS RUNNING. THEN NOTICED DASH WARNING THAT SAID HILL DESCENT CONTROL FAULT, POWER STEERING ASSIST FAULT, SERVICE ADVANCE TRACK . CALLED DEALER THAT WE BOUGHT TRUCK FROM THEY TOLD ME THERE WAS A COMPUTER UPDATE NEEDED FOR TRUCK. NOT TO HAPPY SINCE I HAD TOLD DEALER WHEN TRUCK WAS IN SHOP THAT WE DRIVE 2850 MILES TO OUR HOME IN HUATULCO MEXICO EACH YEAR…

Look up ODI 10938696 at NHTSA ↗

THE VAN WANDERS BACK AND FORTH AT HIGHWAY SPEEDS (> 60MPH). I HAD THE FRONT END ALIGNMENT AND SUSPENSION CHECKED OUT - ALL OK. PROBLEM GETS WORSE WHEN PULLING A 5000 LB CAMPER - ALMOST A SAFETY ISSUE.

Look up ODI 11002038 at NHTSA ↗

TL* THE CONTACT OWNS A 2016 FORD E-150. THE CONTACT STATED THAT WHILE DRIVING AT CERTAIN SPEEDS, THE STEERING WHEEL AND THE ENTIRE FRONT DRIVER SIDE SEAT VIBRATED. THE VEHICLE WAS TAKEN TO THE DEALER BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 6,500. THE VIN WAS NOT AVAILABLE.

Look up ODI 10854768 at NHTSA ↗

TL* THE CONTACT OWNS A 2010 FORD E-150 EQUIPPED WITH MICHELIN LTX TIRES, SIZE 225/75R/16. THE CONTACT WAS CONCERNED FOR HIS SAFETY SINCE HE HAD NOT RECEIVED THE REPLACEMENT TIRES RELATED TO THE NHTSA RECALL CAMPAIGN NUMBER: 13T012000 (TIRES). THE CONTACT NOTIFIED THE DEALER REGARDING THE TIRE RECALL. THE MANUFACTURER STATED THEY WOULD BE SENDING THE REPLACEMENT TIRES BUT DIDN'T INDICATE HOW SOON THEY WOULD RECEIVE THEM. THE TIRES WERE NOT REPLACED. THE VIN AND FAILURE MILEAGE WAS NOT AVAILABLE.

Look up ODI 10598440 at NHTSA ↗

WE HAVE A VAN THAT HAS MICHELIN TIRES (225/75 R16). THE VEHICLE HAD 37000 MILES AT THE TIME OF THE FIRST INCIDENT AND THE TIRE BEGAN TO SHOW SEPARATION ON 6/2/2013 AT 3 PM. THE TIRE WAS REPLACED AT A CERTIFIED TIRE BUSINESS. THE OPPOSITE REAR TIRE BEGAN TO SEPARATE ON THE SUBSEQUENT TRIP AS WE TRAVELED TO HOUSTON ON 6/6/2013. WE WERE TRAVELING AROUND 60 MILES PER HOUR AND AGAIN THE TIRE SHOWED SIGNS OF SEPARATION. *TR

Look up ODI 10519378 at NHTSA ↗

TL* THE CONTACT OWNS A 2012 FORD ECONOLINE E150. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 13T012000 (TIRES). THE DEALER WAS CONTACTED AND MADE HIM AWARE THAT THE MANUFACTURER DID NOT HAVE THE TIRES AVAILABLE FOR REPLACEMENT. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

Look up ODI 10611061 at NHTSA ↗

ON APPROXIMATELY 8/25/2010, WHILE DRIVING ON THE HIGHWAY THE VEHICLE SUDDENLY SHUT DOWN ELECTRICALLY. IT COULDN'T BE STARTED BY AAA. IT WAS TOWED TO A LOCAL REPAIR SHOP AND THEY FOUND A BURNED WIRE THAT WENT FROM THE FUSE BOX TO A JUNCTION BOX. HE TOLD ME THAT THIS IS AN ENGINEERING DEFECT IN THE VEHICLE AS THE WIRE IS TOO CLOSE TO THE BRAKES AND WHEN IT GETS HOT THE WIRE BURNS OUT. HE ALSO SAID THAT THE VEHICLE CAN EVENTUALLY GO ON FIRE. IT WAS REPAIRED AND THEN ON 9/25/2011 THE SAME THING OCCURRED. I HAD THE VEHICLE TOWED TO AMERICAN FORD ON …

Look up ODI 10428911 at NHTSA ↗

TL* THE CONTACT OWNS A 2011 FORD E-150. WHILE DRIVING AT ANY SPEED, THE VEHICLE MADE A VERY LOUD NOISE AND DECREASED IN SPEED WHILE TURNING. THE STEERING WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE RACK AND PINION ELECTRONIC ASSIST FAILED. THE VEHICLE WAS NOT REPAIRED AND THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 217,000.

Look up ODI 10874920 at NHTSA ↗

UGA

Look up ODI 10948604 at NHTSA ↗

TL* THE CONTACT OWNS A 2013 FORD E-150. WHILE DRIVING 65 MPH, AN UNKNOWN WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 108,000.

Look up ODI 10808266 at NHTSA ↗

WHEN STARTED 3 SEPARATE TIMES 4X4 WAS ENGAGED BY ITSELF JUST BARELY TOUCHED 4WHEEL DRIVE SWITCH AND IT WENT OFF ALSO DID IT AGAIN WHEN I WAS DRIVING

Look up ODI 10722873 at NHTSA ↗

TL* THE CONTACT OWNS A 2015 FORD E-150. WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE DECELERATED ON ITS OWN. THE FAILURE RECURRED DURING THE 1,100 MILE ROAD TRIP. THE VEHICLE HAD JUST BEEN REPAIRED ACCORDING TO NHTSA CAMPAIGN NUMBER: 15V614000 (FORWARD COLLISION AVOIDANCE). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VEHICLE NEEDED TO BE REPROGRAMMED. THE FAILURE MILEAGE WAS 4,000.

Look up ODI 10788340 at NHTSA ↗

THE ELECTRONICS ON THE DASH RESET, CAUSING THE RADIO TO MALFUNCTION AND OTHER RELATED ISSUES WITH DATE, TIME AND RADIO PROGRAMS, DIMMING CONTROLS, AND UNKNOWN OTHER ISSUES. THE DEALER RESETS, BUT I HAVE TOO KEEP RETURNING FOR CORRECTIONS. THIS MUST BE COMPLETED BY A THIRD PARTY. THIS IS NOT CORRECT AS I HAVE NO IDEA WHAT OTHER COMPONENTS ARE AFFECTED. BY THIS. THE DEALER SAYS THE DASHBOARD SYSTEMS MAY NEED TO BE EXCHANGED. WHY?

Look up ODI 10938984 at NHTSA ↗

The contact owns a 2021 Ford E-150. The contact stated when he exited his vehicle, the electronic running board functionality was not operating. As the contact attempted to step out of his vehicle onto the ground, he fell and injured his right knee. The contact also stated his grandson almost experienced an injury from the faulty running board. There were no warning lights illuminated. The contact reported to the medical facility and received a shot in his right knee for the injury. The vehicle was taken to the dealer and diagnosed failure with…

Look up ODI 11475754 at NHTSA ↗

TL* THE CONTACT OWNS A 2009 FORD E-150. WHILE DRIVING 25 MPH, THE NUMBER SEVEN DRIVER SIDE SPARK PLUG FAILED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TREAD ON THE CYLINDER HEAD WAS STRIPPED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 134,000.

Look up ODI 10860521 at NHTSA ↗

AS THE DRIVER APPROACHED AN INTERSECTION THE BRAKE PEDAL LOCKED UP AND THE VEHICLE COULD NOT SLOW TO STOP CAUSING AN ACCIDENT AS THE VEHICLE PROCEEDED THROUGH THE INTERSECTION ON A RED LIGHT. THE SAME ISSUE HAPPENED APPROXIMATELY TWO MONTHS BEFORE AND WAS SUPPOSEDLY REPAIRED BY THE DEALER. HOWEVER THE SAME PROBLEM HAPPENED AGAIN. (THIS COMPLAINT IS SIMILAR TO COMPLAINT NUMBER 10918568 AND THAT COMPLAINT IMPROPERLY NOTED THAT THERE WAS NO POLICE REPORT - THE REPORT IS ATTACHED WITH THIS COMPLAINT. ALSO, THIS COMPLAINT SUPPLEMENTS THE PRIOR…

Look up ODI 10918721 at NHTSA ↗

DRIVING NEW F150 FORD (MY BROTHERS TRUCK) ENGINE STARTED MISFIRING, HAD TOWED TO FORD IN SULLIVAN, MO WHERE THE NEXT MORNING A MECHANIC BLEW UP THE ENGINE DURING TEST DRIVE.....WAS TOLD WARRANTY COVERED EXPENSES AND RENTAL AND REPAIRS, 3 MONTHS LATER TOLD NO SORRY YOU PAY THE CUSTOMER.....LIED TO BY FORD. *TR

Look up ODI 10463853 at NHTSA ↗

ON SUNDAY, AUGUST 20, DRIVING S81 JUST BEFORE THE SALEM EXIT, THE 2012 FORD E-150 WHITE CARGO VAN 4.6L ROMEO ENGINE BLEW A SPARK PLUG OUT OF THE #3 CYLINDER HEAD WHILE ACCELERATING FROM 40 MPH. THE PLANNED TRIP STARTED FROM HARRISBURG PA TO ANDREWS NC. TO WITNESS A SOLAR ECLIPSE. ENGINE FAILURE HAPPEN AT APPROXIMATELY 40MPH JUST NORTH OF THE SALEM EXIT OFF 81 SOUTH. THERE WAS NO SHOP AVAILABLE TILL NEXT DAY TO REPAIR DAMAGE.. DAMAGES INCLUDED A OVERNIGHT STAY, MISSING THE SOLAR ECLIPSE OF 2017 AND REPAIR AND PARTS COST OF OVER $300.00 SPARK P…

Look up ODI 11056596 at NHTSA ↗

TRUCK SHOOK AN STOP RUNNING

Look up ODI 10860746 at NHTSA ↗

AS REPORTED TO DEALER : CUSTOMER STATES WHEN ACCELERATING IN LOW GEAR AND LETTING OFF THE ACCELERATOR IT WILL CONTINUE TO MAINTAIN THE RPM UNTIL YOU HIT HARD ON THE BRAKES. MY ADDED COMMENTS IS THAT 1800 RPM WHEN NORMAL HIGHWAY SPEED IS OVER 60 MPH. IN STOP AND GO TRAFFIC THE DRIVER MUST MAINTAIN BRAKE WITH LEFT FOOT AND GAS WITH RIGHT FOOT OR YOU WILL REAR END THE CAR IN FRONT OF YOU. PS DEALER PERFORMED TEST AND STATED AT THIS TIME COMPARED TO LIKE UNITS AND THEY DO THE SAME THING. I TEST DROVE A NEW TRUCK WITH SAME ENGINE AND TRANS. AS…

Look up ODI 10712172 at NHTSA ↗