2017 Ford E-250: complaints, problems and recalls

2010 FORD E250. CONSUMER WRITES IN REGARDS TO VEHICLE TIRES RECALL NOTICE. CONSUMER REQUESTS REIMBURSEMENT FOR REPLACEMENT TIRES. *SMD THE CONSUMER STATED ON MARCH 15, 2013, SHE EXPERIENCED A PROBLEM WITH ONE OF THE TIRES. AN INSPECTION REVEALED A BULGE ON THE SIDEWALL. THE TRUCK WAS TAKEN TO A REPAIR SHOP, WHERE SHE WAS INFORMED THE TIRES DID NOT MEET THE OEM SPECIFICATIONS. ALL OF THE TIRES WERE REPLACED AT A COST OF $ 862.94. UPON RECEIPT OF THE RECALL, THE CONSUMER CHECKED THE SPARE TIRE ON THE VAN, AND DISCOVERED IT WAS ONE OF THE RECA…

Look up ODI 10565131 at NHTSA ↗

VEHICLE HAD FOUR NEW TIRES ALL OF SAME BRAND AND SIZE ONE OF THE TIRES HAD A BLOW OUT, REPLACED THE TIRE WITH NEW TIRE OF SAME BRAND AND SIZE. ONE WEEK LATER ANOTHER TIRE STARTED VIBRATING SO WE TOOK IT IN AND THEY CHECKED IT AND FOUND THE TREAD IS SEPARATING FROM THE CARCASS. I HAD THEM PULL ALL FOUR TIRES AND REPLACE WITH NEW TIRES OF DIFFERENT BRAND. I KEPT THE FOUR TIRES AND CHECKED FOR ANY RECALLS. THIS PARTICULAR TIRE DOES NOT HAVE A RECALL YET BUT ANOTHER SIMILAR DOES. THE TIRES WE HAVE ARE THE HANKOOK DYNAPRO AS LT245/75R16 THE TIRE THE…

Look up ODI 10617968 at NHTSA ↗

TL* THE CONTACT OWNS A 2013 FORD E-250 EQUIPPED WITH HANKOOK TIRES, TIRE LINE: DYNAPRO AS, TIRE SIZE: LT245/75R16. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE REAR PASSENGERS SIDE TIRE TREAD SEPARATED FROM THE WHEEL. THE VEHICLE WAS TAKEN TO A DEALER AND THE TIRE WAS NOT REPLACED. THE FAILURE MILEAGE ON BOTH THE VEHICLE AND THE TIRES WAS 11,000. UPDATED 9/4/14*CN THE COMSUMER STATED THE TIRE LOOKS AS IF IT CONTAINS DRY ROT. UPDATED 12/18/2014 *JS

Look up ODI 10616333 at NHTSA ↗

The contact owns a 2013 Ford E-250 equipped with Cooper Tires, Tire Line: Discoverer A/T, Tire Size: 245/75/16, DOT Number: (N/A). The contact stated that while he was inspecting the rear tires, he noticed that the tires were cracked with tread separation. The contact called a tire shop and the tires were replaced with another brand of tires. The manufacturer was not notified of the failure. The approximate tire failure mileage was 10,000. The vehicle failure mileage was not provided.

Look up ODI 11440788 at NHTSA ↗

BRAKES LOCKED UP AND WOULD NOT RELEASE NOR SLOW THE VEHICLE RESULTING IN CRASH. *TR

Look up ODI 10519816 at NHTSA ↗

HAD 1ST EXHAUST HEAT SENSOR GO OUT LAST YEAR APPROX. 50,000 MILES. SECOND ONE ON 8/15/14 APPROX. 110,000 MILES THIRD ONE ON 9/1/14 APPROX. 113,000 MILES ALL THREE TIMES LEFT ME STRANDED ON BUSY INTERSTATE HI-WAY. HAVE EXTENDED WARRANTY SO COVERED FOR PARTS AND LABOR LESS THE 100.00 DEDUCTIBLE. BUT WITH OUT MY TRUCK FOR 2 TO 3 DAYS EACH TIME OVER A 40.00 PART. *TR

Look up ODI 10630825 at NHTSA ↗

The contact owns a 2009 Ford E-250. The contact stated that the vehicle was taken to an independent mechanic to be serviced and was informed that the catalytic converters and an unknown sensor needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 95,484.

Look up ODI 11513410 at NHTSA ↗

SPARK PLUG WAS PUSHED OUT OF THE CYLINDER HEAD BY CYLINDER COMPRESSION RESULTING IN POWER LOSS AND FIRE CONCERN. THESE ARE FACTORY INSTALLED SPARK PLUGS AND HAVE NEVER BEEN SERVICED. THE CONDITION OCCURRED AFTER A 200 MILE TRIP. THIS VEHICLE HAS 95K MILES AND HAS BEEN ROUTINELY SERVICED.

Look up ODI 11021315 at NHTSA ↗

TL* THE CONTACT OWNS A 2011 FORD E-250. THE CONTACT STATED THAT THE ENGINE WARNING INDICATOR WAS CONSTANTLY ILLUMINATED. THE DEALER STATED THAT THE UREA PUMP WAS CONTAMINATED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 36,606. JCC

Look up ODI 10621472 at NHTSA ↗

VEHICLE WARNING SYSTEM INDICATED TO SAFELY STOP TRUCK IMMEDIATELY. TRUCK WOULD NOT RESTART. TRUCK WAS TOWED TO DEALERSHIP (~60 MILES). FORD REPLACED ONE OF THE EXHAUST GAS SENSORS UNDER WARRANTY. DEALERSHIP PERSONNEL INDICATED THAT THIS WAS A RECURRING PROBLEM AND IT WOULD PROBABLY HAPPEN AGAIN. MARCH OF 2015 SIMILAR CIRCUMSTANCES, VEHICLE WARNING SYSTEMS INDICATED TO SAFELY STOP TRUCK IMMEDIATELY. TRUCK CONTINUED RUNNING AND DROVE THE 80 MILES BACK TO DEALERSHIP. MILEAGE AT THE DATE OF THE SECOND OCCURRENCE WAS ~54,500. A DIFFERENT EXH…

Look up ODI 10693668 at NHTSA ↗

The vehicle Blew a spark plug while driving. It took place right as I attempted to accelerate up to highway speed of 50 MPH. When I had it checked the mechanic said the number 3 plug was blown out and I had a busted injector. Vehicle mileage is 164k. The repair was over $1100.00 with none being covered under my full coverage insurance policy. I need to let others know what to expect from their Ford vehicle... Found out that this is a frequent problem with Ford Engines 5.4 Liter V-8..

Look up ODI 11507184 at NHTSA ↗

NUMBER 2 SPARK BELOW OUT OF THE MOTOR,WHEN DRIVING

Look up ODI 11151284 at NHTSA ↗

TL* THE CONTACT OWNS A 2009 FORD E-250. THE CONTACT PURCHASED THE VEHICLE IN MAY AND IT IS USED OCCASIONALLY. ON JANUARY 29TH THE CONTACT DROVE THE VEHICLE. SHE STATES AFTER THE DRIVING THE VEHICLE, THE MOTOR WAS LEFT RUNNING. THE VEHICLE BEGAN TO TAKE OFF ON ITS OWN. THE CONTACT STATES THE GENTLEMEN IN THE VEHICLE TRIED TO STOP THE VEHICLE BUT IT BEGAN TO PICK UP SPEED. SHE STATED THAT WHILE THE VEHICLE WAS BACKING UP THERE WERE NO LIGHTS INDICATING THE VEHICLE WAS BACKING UP. SHE STATED THAT THE VEHICLE SHOT FORWARD AND THE REVERSE LIGHTS …

Look up ODI 10311835 at NHTSA ↗

TL*THE DRIVER OWNS A 2010 FORD E-250. WHILE DRIVING APPROXIMATELY 15 MPH THE DRIVER ATTEMPTED TO APPLY THE BRAKES BUT THE PEDAL WOULD NOT ENGAGE. THE VEHICLE THEN SURGED FORWARD UNTIL IT CRASHED. THE CONTACT WAS UNAWARE IF A POLICE REPORT WAS FILED OR NOT. THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE THE FAILURE WAS NOT DIAGNOSED WHEN THE COMPLAINT WAS FILED. THE FAILURE AND CURRENT MILEAGES WERE UNAVAILABLE.

Look up ODI 10378797 at NHTSA ↗

The contact owns a 2013 Ford E-250. The contact stated that while driving at a very low rate of speed while approaching a stoplight the driver depressed the brake pedal to stop and the vehicle erroneously accelerated forward and crashed into the rear of a second vehicle. During the incident, no injuries were reported and no police report was taken. The vehicle was examined by an independent mechanic but the cause of the failure was not determined. The manufacturer and local dealer were not notified. The failure mileage was 53,200.

Look up ODI 11452199 at NHTSA ↗