1983 Ford ECONOLINE: complaints, problems and recalls

TL* THE CONTACT OWNS A 1983 FORD ECONOLINE VAN, EQUIPPED WITH COOPER LIFELINER CLASSIC II TIRES, SIZE 255/70/R15. THE CONTACT STATED THAT THERE WERE CRACKS AND BLISTERS IN THE SIDEWALL OF THE FOUR TIRES. THE CONTACT WAS ABLE TO SEE THE METAL INSIDE THE TIRE. THE FAILURE WAS REPORTED TO THE MANUFACTURER, WHO REFUSED TO PROVIDE ASSISTANCE. THE FAILURE MILEAGE WAS 5,000. THE CURRENT VEHICLE MILEAGE WAS 110,000. KMJ UPDATED 8/26/13 *CN THE CONSUMER DISCOVERED CRACKS IN THE TIRE EXPOSING THE INSIDE WIRES.

Owner-reported narrative. 5,000 miles reported. Look up ODI 10523905 at NHTSA ↗

VAN WAS BOUGHT USED FROM DEALER BUT I KNEW PREVIOUS OWNER. VAN HAD 4 LIKE NEW TIRES. VAN WAS IN NEAR MINT CONDITION DESPITE AGE AND MILEAGE. WHILE ON VACATION, RIGHT REAR TIRE BLEW OUT. BIG HOLE, STEEL BELT SHREDDED. WAS ABLE TO CHANGE SPARE DESPITE VERY HAZARDOUS LOCATION. MADE IT INTO DOUGLAS GEORGIA, EVERYTHING CLOSED EXCEPT WAL-MART. REPLACED TIRE WITH GOODYEAR TIRE. ABOUT 1 MONTH LATER WAS NEAR DOTHAN ALABAMA AND ABOUT 45 MILES FROM HOME WHEN I NOTICED SAME SYMPTOMS OTHER TIRE HAD DISPLAYED BEFORE BLOWING OUT. TRIED TO MAKE IT HOME BUT TIR…

Owner-reported narrative. Look up ODI 729578 at NHTSA ↗

Reported: 1982-12-13 (December 13, 1982)

SOME OF THE INVOLVED VEHICLES MAY HAVE A DIODE IN THE ELECTRICAL FUEL PUMP CIRCUIT THAT MAY SHORT DURING ENGINE STARTING DUE TO INADEQUATE CAPACITY TO WITHSTAND CURRENT DRAW. A SHORT CIRCUIT WOULD RESULT IN NORMAL ENGINE STARTING, BUT THE PUMP WILL NOT CONTINUE TO SUPPLY THE ENGINE WITH FUEL.

Remedy: THE DEALER WILL REPLACE DEFECTIVE ELEMENT IN THE ELECTRICAL FUEL PUMP CIRCUIT WITH A NEW RELAY FEED WIRING ASSEMBLY WHICH CONTAINS A LARGER CAPACITY DIODE, FREE OF CHARGE.

Reported: 1983-03-07 (March 7, 1983)

THE PARKING GEAR MAY NOT ENGAGE, EVEN THOUGH THE GEAR SHIFT LEVER IS PLACED IN THE "PARK" POSITION. THIS OCCURS IF THE LINKAGE INSIDE THE TRANSMISSION THAT ACTUATES THE PARK GEAR WAS IMPROPERLY MANUFACTURED. A PIN THAT RETAINS COMPONENTS ON A LINKAGE (ACTUATING) ROD COULD BREAK AND THE LINKAGE MAY NOT ENGAGE THE PARKING GEAR.

Remedy: DEALER WILL INSPECT AND, IF NECESSARY, REPLACE THE PARKING PAWL ACTUATING ROD ASSEMBLY.

Reported: 1985-05-14 (May 14, 1985)

WHEN FRONTALLY IMPACTED INTO A FIXED BARRIER AT 30 MPH, AS SPECIFIED IN FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 301, THE LEFT FRAME RAILS OF SUCH VEHICLES MAY DISPLACE INBOARD, PINCHING THE FUEL/WATER SEPARATOR CANISTER BETWEEN THE FRAME RAIL AND ENGINE SUFFICIENTLY TO DISPLACE THE FUEL/WATER SEPARATOR DRAIN ROD, ALLOWING THE CONTENTS OF THE CANISTER TO DRAIN. CONSEQUENCE OF DEFECT: FUEL LEAK DURING OR AFTER A CRASH INCREASES THE POSSIBILITY OF A FIRE.

Remedy: INSTALL A CANISTER SHIELD, A REVISED DESIGN DRAIN ROD SHIELD, AND MODIFY FUEL/WATER SEPARATOR MOUNTING BRACKET.

Reported: 1987-07-21 (July 21, 1987)

EXPULSION OF FUEL DUE TO OVERPRESSURIZATION.

Consequence: FUEL OR FUEL VAPORS IN THE PRESENCE OF AN IGNITIONSOURCE CAN CAUSE A FIRE.

Remedy: MODIFICATION OF THE BASE FUEL VENTING AND EMISSION CONTROL SYSTEM TO REDUCE OPERATING TEMPERATURES AND FUEL SYSTEM PRESSURES.

Reported: 1987-09-09 (September 9, 1987)

VEHICLES ARE SUBJECT TO EXCESSIVE UNDERHOOD TEMPERATURES AND FUEL SYSTEM PRESSURES IN SEVERE DUTY APPLICATIONS.

Consequence: THIS CREATES POTENTIAL FOR FUEL EXPULSION FROM THE FUELFILLER PIPE WHICH IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN AFIRE.

Remedy: INSTALL MODIFICATION KITS TO MINIMIZE POSSIBILITY OF FUEL EXPULSION AND TO SHIELD UNDERBODY COMPONENTS FROM EXHAUST SYSTEM HEAT.