| Electrical System | 3016.6%ODI 10276362 · 1,450 miTHIS IS A 2009 FLEX DEALER DEMO WITH 1450 MILES. IT HAS DIED TWICE WHILE DRIVING DURING A TEST DRIVE. THE FIRST OCCURRENCE WAS WHILE IN DRIVE, IN A PARKING LOT AT ABOUT 5 MPH. THE ENGINE, A/C, RADIO/ACCESSORY POWER, AND ALL LIGHTS SUDDENLY DIED. IT WAS AS IF THE KEY HAD BEEN TURNED TO "OFF", EXCEPT THAT THE RETAINED ACCESSORY POWER AND ALL DASH/WARNING LIGHTS WENT OUT AS WELL. THE CAR RE-STARTED EASILY ONCE PUT INTO NEUTRAL. THE SECOND OCCURRENCE WAS IN REVERSE, BACKING OUT OF A DRIVEWAY AT ABOUT 3 MPH. THIS TIME THE ENGINE SUDDENLY DIED,… Look up ODI 10276362 at NHTSA ↗ | 139.4%ODI 10335733 · 2,990 mi2010 FORD FLEX 2000 MILES. WHILE DRIVING @ 35 MILES PER HOUR , CHECK ENGINE LIGHT CAME ON AND CAR STALLED. GAS ACCELERATOR WAS INOPERABLE. OPERATOR WAS ABLE TO DRIVE INTO A PARKING LOT CLOSE BY AND BRING CAR TO A COMPLETE STOP WITHOUT ANY INCIDENT. CAR TURNED ON AFTER THE 5TH ATTEMPT. THE CHECK ENGINE LIGHT DISAPPEARED. THE 1ST OCCURRENCE, THE VEHICLE WAS ABLE TO BE STARTED RIGHT AWAY. THIS 2ND OCCURRENCE IT TOOK AWHILE. THEREFORE, VEHICLE WAS TAKEN TO THE DEALERSHIP ( NORTH PARK LINCOLN FORD IN SAN ANTONIO, TX )ON 06/09/10 AND OBD CAME BACK … Look up ODI 10335733 at NHTSA ↗ | 96.3%ODI 10448247 · 9,063 miON AUGUST 8, 2011 AND FEBRUARY 8, 2012, MY NEW FLEX SHUT DOWN WHILE I WAS DRIVING. THE DASHBOARD LIGHTS FLASHED ON, AND THE VEHICLE TURNED OFF - TOTAL ELECTRICAL FAILURE - COULDN'T ACCELERATE OR BRAKE - HAD TO PAINFULLY PULL CAR OFF THE ROAD. CAR WAS TOWED TO DEALER. FORD DEALER PERFORMED DIAGNOSTICS TO NO AVAIL, AS WHEN THE ENGINE SHUT DOWN, I TURNED THE KEY OFF, THEN BACK ON AGAIN - THIS DESTROYED THE DATA. SEEMS LIKE A FUNDAMENTAL DATA SYSTEM FLAW. NONETHELESS, I DROVE AWAY FROM THE DEALERSHIP IN FEAR, ONLY TO HAVE THE INCIDENT RECUR SI… Look up ODI 10448247 at NHTSA ↗ | 1015.6%ODI 10521258 · 8,000 miTHERE ARE SEVERAL DIFFERENT INCIDENCES THAT HAVE OCCURRED. (1) WHILE TURNING A CORNER OR SLOWING DOWN THE A/C WILL SHUT DOWN. (2) THE CONTROL PANEL INSTRUMENTS WILL GO ALL THE WAY OVER TO THE RIGHT AND THEN SURGE FORWARD WHEN TURNING A CORNER. (3) CAR HAS DIED ON SEVERAL OCCASIONS ESPECIALLY WHILE TRYING TO ACCELERATE ONTO HIGHWAY. (4) A/C WILL TURN ON BY ITSELF AND BLOW ON MAXIMUM EVEN WHEN POWER SWITCH IS TURNED OFF. (5) WHEN CAR LOSES POWER, ALL CODES ARE RESET SO DEALER IS UNABLE TO GET A CLEAR REASON WHY CAR IS DOING THIS. WE HAD A BLAC… Look up ODI 10521258 at NHTSA ↗ | 20034.5%ODI 10561947 · 2,887 miI HAVE OWNED MY VEHICLE SINCE MARCH 2013 AND HAVE HAD IT IN THE PROCESS MULTIPLE TIMES SINCE - SYNC ISSUES, DEAD BATTERY AND THREE SEATBELT REPLACEMENTS. MY VEHICLE HAS REAR AIRBAG SEATBELTS SUPPOSEDLY FOR SAFETY. INSTEAD, MY KIDS HAVE BEEN FORCED INTO UNSAFE SITUATIONS BECAUSE THE BELTS ARE SO POORLY DESIGNED AS SOON AS THE BLACK PLASTIC COVERING THE BELT BREAKS, THE ENTIRE SEATBELT NO LONGER FUNCTIONS. THIS IS WHOLLY UNACCEPTABLE. I'VE APPROACHED FORD AND SPRINGHILL FORD IN DUNDEE WITHOUT ANY SATISFACTION. MOST RECENTLY I TOOK MY CAR INTO SPR… Look up ODI 10561947 at NHTSA ↗ | 5522.1%ODI 10661941 · 7,000 miMY PREGNANT WIFE WAS PUTTING OUR 20 MONTH OLD SON IN VEHICLE. SHE PLACED HER PURSE WITH THE KEYLESS ENTRY FOB INTO CAR AND CLOSED THE REAR PASSENGER DOOR. SHE FOUND THE VEHICLE NOW ENTIRELY LOCKED AT ALL DOORS AND WOULD NOT OPEN DESPITE THE KEY FOB BEING INSIDE THE VEHICLE. IT IS BELOW FREEZING OUTSIDE AND OUR SON IS NOW LOCKED INTO THE CAR AND GETTING COLDER. MY WIFE CALLED ME. I HAD HER CALL 911. I CALLED FORD ROADSIDE ASSISTANCE AND EXPLAINED THE EMERGENCY WE HAD. FORD ROADSIDE ASSISTANCE SAID THERE IS NOTHING THEY COULD DO AND SUGGESTED I C… Look up ODI 10661941 at NHTSA ↗ | 1311.8%ODI 10933707 · 24,000 miTL* THE CONTACT OWNS A 2015 FORD FLEX. WHILE BOTH THE ENGINE AND AIR CONDITIONING WERE ACTIVATED FOR A SHORT PERIOD OF TIME, THE VEHICLE EXPERIENCED A COMPLETE LOSS OF POWER. THE FAILURE OCCURRED WITHOUT WARNING. THE FAILURE OCCURRED TWICE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT IT WAS OPERATING AS DESIGNED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 24,000. Look up ODI 10933707 at NHTSA ↗ | 2222.4%ODI 11153753 · 29,000 miGAS SMELL AND ELECTRONIC ISSUES. I BOUGHT MY VEHICLE BRAND NEW. I FIRST NOTICED SMELLING GASOLINE AFTER THE FIRST OIL CHANGE, SO I HAD DRIVEN SEVERAL MONTHS.THE DEALERSHIP BLAMED IT ON MY UNDERCOATING STATING THAT'S WHAT I'M SMELLING.IT'S GAS DEFINITELY.I ASKED THEM TO DRIVE IT A WEEK SINCE THE SMELL COMES AND GOES.THEY REFUSED.IT STILL DOES IT AND I HAVE GIVEN UP TRYING TO GET THE DEALERSHIP TO FIND THE ISSUE.THEY DID STATE THE FLEX IS THE SAME BASE AS THE POLICE VEHICLE THAT HAS THE GAS EMISSION LEAK.2ND PROBLEM IS "NO KEY DETECTED" LIGHT COM… Look up ODI 11153753 at NHTSA ↗ | 37.1%ODI 11691098Backup camera frequently goes blank. I noticed an active recall for other ford vehicles and wanted to report I’m having the same issue with my 2017 ford flex, so I’m hoping the flexes will be added to the recall. Look up ODI 11691098 at NHTSA ↗ | 1116.4%ODI 11349111 · 35,197 miTHE AIR CONDITIONER WILL TURN OFF BY ITSELF OR BLOW HOT AIR OUT OF NO WHERE. SOMETIMES IT WILL BLOW HOT AIR IN THE FRONT AND COLD IN THE REAR AND VICE VERSA. THE RADIO INTERMITTENTLY SHUTS OFF AS WELL. THERE ARE TIMES WHERE MY KEY FAB WILL NOT LOCK OR UNLOCK MY CAR. THE A/C PROBLEM.HAPPENS WHEN THE CAR IS IN MOTION. THE RADIO WILL HAPPEN WHEN IN MOTION OR AT A STAND STILL. THE KEY FAB IS WHEN THE CAR IS STATIONARY. Look up ODI 11349111 at NHTSA ↗ | 228.8%ODI 11458049Backup Camera functions intermittently. This began at approx 37k miles and 25months of age (vehicle built in June 2019). Backup camera may work, or not, when the vehicle is put in to reverse. This is very similar to the behavior described in other Ford backup camera recalls for other vehicles. Seems like the 2019 Flex should be added. This poses a danger when backing the vehicle. Look up ODI 11458049 at NHTSA ↗ |
|---|
| Steering | 179.4%ODI 10469017 · 3,611 miTWICE WHILE DRIVING MY FORD FLEX, I HAD SPONTANEOUS TOTAL SHUT DOWNS OF THE ENGINE. THE FIRST TIME, MY CAR WAS ONLY A FEW MONTHS OLD AND I WAS IDLING IN FRONT OF A FRIEND'S HOUSE WHEN ALL THE LIGHTS CAME ON AND IT COMPLETELY DIED. I STARTED IT RIGHT BACK UP (AND IT SUBSEQUENTLY PERFORMED PERFECTLY) AND I DROVE IT TO FORD WHERE THEY DID SOME DIAGNOSTICS CHECKS AND FOUND NO ANOMALY. IT CONCERNED ME BUT THINKING IT MAY BE A FUEL INJECTION ISSUE WHILE ONLY IDLING, I WENT ABOUT MY BUSINESS. ON JULY 20, 2012, AT 38K MILE, MY FORD FLEX DIED AGAIN! TOT… Look up ODI 10469017 at NHTSA ↗ | 3122.3%ODI 10459242 · 26,000 miWHILE DRIVING 30 MPH THE CAR SIMPLY DIES. ALL LIGHTS COME ON AND THE CAR JUST SHUTS OFF. LEFT WITH NO BRAKES, STEERING, OR CONTROL. DEALER BROUGHT IN ENGINEER, AFTER A WEEK WITH THE CAR DEALER CANNOT REPLICATE PROBLEM. FORD MOTOR COMPANY DECIDES NOTHING IS WRONG AND FORCE ME TO TAKE DANGEROUS CAR BACK. INCIDENT OCCURRED TWICE IN THE MONTH OF APRIL/MAY. *TT Look up ODI 10459242 at NHTSA ↗ | 5638.9%ODI 10362759 · 40 miCAR SHUT OFF COMPLETELY WHILE DRIVING. IT HAS HAPPENED TWICE ONCE ON THE HIGHWAY AND ONCE ON A RESIDENTIAL STREET WHILE MAKING A LEFT HAND TURN BOTH TIMES POWER STEERING WAS GONE. TOOK CAR TO DEALER AND THEY CANNOT FIND ANYTHING BECAUSE IT DID NOT LEAVE A SIGNATURE. THE CAR HAS BEEN IN THE DEALERSHIP SHOP FOR TWO WEEKS NOW. *TR Look up ODI 10362759 at NHTSA ↗ | 2335.9%ODI 10482817 · 5,020 miFIRST INCIDENT HAPPENED WHILE DRIVING ABOUT 40 MILES AN HOUR. IDIOT LIGHTS CAME ON THE DASH AND THE CARS ENGINE TURNED OFF. THANKFULLY I WAS ABLE TO GET CAR OFF TO THE SIDE OF ROAD. CAR CRANKED RIGHT BACK UP. 5 DAYS LATER WHILE SITTING IN A FAST FOOD LINE, SAME THING HAPPENED AND WAS ABLE TO CRANK CAR. CALLED DEALERSHIP IN TOWN, BROUGHT CAR IN AND THEY SAID, "NOTHING IS WRONG WITH YOUR CAR, COME AND GET IT" PICKED UP CAR. 2 DAYS LATER WHILE DRIVING IT DOWN OUR STREET, I STOPPED TO GET MAIL ABOUT 9PM AND THE CAR TOTALLY DIED. NO POWER AT ALL. WA… Look up ODI 10482817 at NHTSA ↗ | 14625.2%ODI 10552923 · 36,300 miI WAS TURNING A CORNER AND SOMETHING POPPED AND THE CAR WOULD NOT STEER. THE ONLY THING THAT STOPPED THE CAR WAS THE CURVE, AS I WAS MAKING THE TURN, AND THAT CAUSED A LOT OF DAMAGE. SUTTON FORD LINCOLN IN MATTESON, IL SAID THEY WOULD NOT REPAIR THE DAMAGES CAUSED BY THE LEMON-FORD-FLEX THAT WAS SOLD TO ME BECAUSE THE VEHICLE WAS 300 MILES OUT OF THE WARRANTY. SUTTON FORD LINCOLN IN MATTESON, IL THAN SAID IT WOULD HAVE TO BE REPORTED TO INSURANCE. SO I REPORTED IT TO INSURANCE AND THE REPAIR SHOP, THAT WAS REPAIRING THE DAMAGES, SAID THEY F… Look up ODI 10552923 at NHTSA ↗ | 6425.7%ODI 10818149 · 40,000 miTL* THE CONTACT OWNS A 2014 FORD FLEX. WHILE DRIVING APPROXIMATELY 20 MPH, THE STEERING WHEEL LOCKED UP AND MADE A LOUD GRINDING NOISE WHILE BEING TURNED. THERE WERE NO WARNING INDICATORS. THE VEHICLE WAS TAKEN TO A LOCAL DEALER WHERE IT WAS DIAGNOSED AND RECOMMENDED THAT THE STEERING MODULE NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WERE NO RECALLS. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS ADVISED TO FILE A COMPLAINT WITH NHTSA. THE FAILURE MILEAGE WAS APPROXIMATELY 40,000. Look up ODI 10818149 at NHTSA ↗ | 1917.3%ODI 11011309 · 73,000 miMY POWER STEERING FAILURE INDICATOR CAME ON (WHILE I WAS DRIVING), INDICATING A NEED FOR IMMEDIATE SERVICE. UPON TESTING, IT WAS DETERMINED THAT THE STEERING GEAR WAS FAULTY...ON A 2015 VEHICLE!! THIS COULD HAVE CAUSED AN ACCIDENT IF THE GEAR FAILED WHILE I WAS DRIVING. I WOULD NOT EXPECT SUCH A FAILURE IN A 2015 VEHICLE. IT LOOKS LIKE PREVIOUS FORD MODELS HAVE BEEN RECALLED DUE TO A SIMILAR ISSUE. I THINK THERE MUST BE A DESIGN OR MANUFACTURING FLAW. GIVEN THAT THIS IS RELATED TO STEERING AND CREATES A HIGH RISK OF INJURY IN THE EVENT OF AN … Look up ODI 11011309 at NHTSA ↗ | 88.2%ODI 11152009 · 25,000 miPOWER STEERING WOULD NOT ENGAGE WHEN CAR WAS STARTED IN MORNING AFTER TWO DAYS OF LONG DRIVING. WOULD NOT ENGAGE WITH REPEATED EFFORTS AT STARTING. HAD PREVIOUSLY FAILED BRIEFLY WHILE CAR WAS IN MOTION AT LESS THAN 10 MILES PER HOUR, SIX MONTHS BEFORE, BUT REINSTITUTED WHEN SEAT BELT WAS FASTENED. Look up ODI 11152009 at NHTSA ↗ | 37.1%ODI 11372679 · 30,000 miON MONDAY, SEPT 28, 2020 AT APPROXIMATELY 10:30 AM WHILE DRIVING SOUTHBOUND ON INTERSTATE 5 (JUST BEFORE THE WEST MOUNTAIN VIEW OVERPASS IN FIREBAUGH CA) DOING 70 MPH, THE CAR BEGAN FISHTAILING ERRATICALLY - SWERVING BETWEEN LANES. FORTUNATELY, THE DRIVER WAS ABLE TO MANEUVER THE CAR TO THE RIGHT SHOULDER OF THE INTERSTATE WITHOUT HITTING ANYTHING OR ANYONE OR EVEN ROLLING THE VEHICLE. (AT THE TIME THERE WAS AN AVERAGE AMOUNT OF TRAFFIC ON THE ROAD.) WE INITIALLY BELIEVED THAT WHAT WE HAD EXPERIENCED WAS A BLOWOUT, BUT AFTER INSPECTION, ALL TH… Look up ODI 11372679 at NHTSA ↗ | 23.0%ODI 11383237 · 64,853 miWHILE DRIVING THE VEHICLE (IT WAS IN MOTION), ON HWY 290 (NEAR MANOR, TX), THE STEERING ON OUR 2018 FORD FLEX SEIZED UP AND THE CAR WAS IMPOSSIBLE TO TURN. DUE TO COMPLETE LACK OF STEERING, THE CAR WAS AN IMMEDIATE DANGER TO DRIVE AND IT WAS EXTREMELY DIFFICULT TO GET SAFELY OFF THE ROAD, BUT MY HUSBAND WAS ABLE TO DO SO. HE WAS LUCKY TO AVOID A MAJOR COLLISION. THE NEXT DAY WE CALLED FOR THE CAR TO BE TOWED TO THE DEALER. THE TOW TRUCK DRIVER WAS ABLE TO START THE CAR WITHOUT ANY ISSUE. WITH EXTREME MANUAL FORCE APPLIED, THE TOW TRUCK DRIV… Look up ODI 11383237 at NHTSA ↗ | 31.2%ODI 11727347The power steering has stopped working. After starting the car it shows a "Steering Assist Fault" message and the steering doesn't work. Thankfully this happened when the car was stopped. My car battery is fine so this must be a failure in the Electric Power Assisted Steering (EPAS) system. Look up ODI 11727347 at NHTSA ↗ |
|---|
| Unknown Or Other | 179.4%ODI 10429888 · 50 miUPON MODERATE TO HEAVY ACCELERATION THE CABIN FILLS WITH CARBON MONOXIDE (EXHAUST FUMES) POST CATALYTIC CONVERTER. IF CABIN IS NOT QUICKLY VENTILATED BY OPENING ALL WINDOWS THE EYES ARE IRRITATED AND A VERY STRONG ROTTEN EGG SMELL RESULTS INDICATIVE THAT THE EXHAUST IS ENTERING THE CABIN AREA AFTER THE CATALYTIC CONVERTERS. THE VEHICLE HAS BEEN SERVICED BY TWO FORD DEALERSHIPS WHO REPLACED THE CABIN VENT BAFFLES. THIS HOWEVER DID NOT FIX THE PROBLEM. FORD CONCEDES IT IS A PROBLEM THAT STILL EXISTS ON 25% OF ALL FLEX MODELS BUT REFUSES TO MITIGA… Look up ODI 10429888 at NHTSA ↗ | 75.0%ODI 10895792ECO BOOST ENGINE STALL DUE TO CONDENSATION OF AIR FROM THE COLD AIR COMPRESSOR IN THE TURBO CHARGER FOR THE ENGINE. HAVE HAD CAR SERVICED SEVERAL TIMES AND DEALER OR MECHANIC CAN NOT RESOLVE PROBLEM. HAPPEN IN FREEWAY AT HIGH SPEED BUT HAS ALSO HAPPENED IN THE STREET AT 20 - 30 MPH Look up ODI 10895792 at NHTSA ↗ | 117.6%ODI 10695149 · 52,000 miMY WIFE WAS DRIVING DOWN THE INTERSTATE YESTERDAY, WHEN THE REAR PASSENGER DOOR WINDOW SHATTERED INTO PIECES FOR APPARENTLY NO REASON. THANKFULLY NO ONE WAS INJURED. BASED ON INFORMATION FOUND ON THE INTERNET, THIS HAS HAPPENED WITH OTHER FORD MODELS AND YEARS AS WELL. I HAVE SEEN WHERE NHTSA HAS INVESTIGATED THIS SIMILAR ISSUE WITH 2010-2011 FORD ESCAPE AND MERCURY MARINER, BUT HAVE NOT BEEN ABLE TO FIND THE RESULTS OF THE INVESTIGATION. CARCOMPLAINTS.COM SHOWS 3 COMPLAINTS ABOUT THE SAME ISSUE WITH THE FORD FLEX. *TR Look up ODI 10695149 at NHTSA ↗ | 57.8%ODI 10823506 · 48,000 miTHE RIGHT REAR DOOR SENSOR SAYS THAT THE DOOR IS OPEN WHEN IT IS NOT. TRIED TO CLOSE IT A FEW TIMES BUT THAT DIDN'T WORK. NOW I CAN'T LOCK MY CAR AT NIGHT BECAUSE MY CAR ALARM WILL GO OFF THINKING THAT SOMEONE IS TRYING TO BREAK IN. IT HAS NOW HAPPENED APPROXIMATELY SIX OR SEVEN TIMES NOW. I SEE THAT OTHER PEOPLE HAVE REPORTED THE SAME ISSUE. THIS SHOULD BE A RECALL. Look up ODI 10823506 at NHTSA ↗ | 7813.4%ODI 10608793 · 49,050 miTHE VEHICLE DOOR AJAR ALARM IS SAYING THAT THE DOOR IS STILL OPEN EVEN THOUGH THE DOOR IS SECURELY SHUT. THIS HAPPENED FIRST WHEN WE WERE GOING TO BE GETTING OUT OF THE CAR AND WE THOUGHT WE DIDN'T GET THE DOOR SHUT TIGHTLY. HOWEVER, MULTIPLE TIMES OVER THE PAST 7-10 DAYS THE DOOR AJAR ALARM IS GOING OFF, EVEN WHEN TRAVELING DOWN THE ROAD AFTER IT WAS PREVIOUSLY NOT ON AND THE DOOR IS SECURELY SHUT. THIS IS VERY DISTRACTING AS A LOUD BUZZING NOISE SUDDENLY COMES ON WHEN YOU ARE DRIVING DOWN THE HIGHWAY AND CAUSES THE DRIVER TO BECOME DISTRAC… Look up ODI 10608793 at NHTSA ↗ | 249.6%ODI 10859853 · 10,100 miSHORTLY AFTER I PURCHASED MY FORD FLEX WE NOTICED A HORRIBLE EXHAUST SMELL INSIDE THE VEHICLE AS WE WERE DRIVING DOWN THE ROAD. I TOOK IT TO THE FORD DEALERSHIP WHERE WE BOUGHT IT TO BE LOOKED AT AND THEY DID SEVERAL THINGS AND TOLD ME THEY COULDN'T FIX IT AND DIDN'T KNOW HOW AND THAT THERE WERE SEVERAL OTHER OWNERS OF FLEXES THAT HAD THE SAME COMPLAINT BUT COULDN'T FIX EITHER. I CALLED THE FORD MANUFACTURER MYSELF AND THEY HAVE DIRECTED MANY THINGS TO BE DONE TO MY VEHICLE BY DIFFERENT DEALERSHIPS, STILL NO RESULTS!!! MY CAR HAS BEEN IN THE SH… Look up ODI 10859853 at NHTSA ↗ | 1210.9%ODI 11034696 · 14,400 miEXHAUST LEAK INTO VEHICLE WHEN GOING UP HILLS OR ACCELERATING. DEALER TESTING SHOWED HIGH LEVELS OF CARBON MONOXIDE IN VEHICLE. AFTER BEING IN THE SHOP FOR 9 CONTINUOUS WEEKS THEY HAVE REDUCED BUT NOT ELIMINATED THE EXHAUST LEAK Look up ODI 11034696 at NHTSA ↗ | 1414.3%ODI 10893150 · 38 miPURCHASED A NEW 2016 FORD FLEX ON JULY 29, 2016, DROVE IT MOST OF THE DAY ON SATURDAY AND SMELLED EXHAUST FUMES MOSTLY EVERY TIME I EXILIRATED. WENTTO URGENT CARE SICK FROM EXHAUST FUME POISONING, GOT WORSE AS DAY WENT BY AND WENT TO A REGULAR HOSPITAL ER. BROUGHT VEHICLE BACK TO DEALER ON MONDAY AND AFTER THEM RESEARCHING THE PROBLEM, IT WAS FAULTY VENT IN REAR CAUSING EXHAUSTING TO ENTER INTO INTERIOR. Look up ODI 10893150 at NHTSA ↗ | 1331.0%ODI 11329528 · 27,000 miLOSS OF POWER, RPM TOO HIGH FOR NORMAL SHIFTING UP TO 6 RPMS. CAT CONVERTER NOISE AFTER CAR SHUT OFF DUE TO GETTING TO HOT. FLUCTUATION RPM AT IDLE. OIL ON TOP OF VALVE COVER. *TR Look up ODI 11329528 at NHTSA ↗ | 1928.4%ODI 11115748 · 900 miI HAVE A 2018 FORD FLEX WITH 900 MILES ON IT . I TOOK MY FIRST ROAD TRIP IN 8-4-2018 AND WHILE ACCELERATING HARD TO GET ONTO THE INTERSTATE I NOTICED EXHAUST FUMES WERE COMING INTO THE CABIN AT AN ALARMING RATE , I HAD TO SLOW DOWN AND ROLL THE WINDOWS DOWN IT GOT SO BAD,MY EYES WERE BURNING ,FELT SICK AND MY CHEST FELT FUNNY. I TRIED IT SEVERAL MORE TIME WITH THE SAME RESULTS. IT SEEMS LIKE IT HAPPENS WORSE WHEN I HAVE MAX AIR ON. NORMAL CITY DRIVING I DON'T NOTICE IT. I CAN'T TELL IF IT IS COMING THRU THE VENTS OR THE SEAL ON THE BACK DOOR. Look up ODI 11115748 at NHTSA ↗ | 5220.9%ODI 11312000 · 6,500 miOCCASIONALLY WHEN I AM TURNING LEFT OR RIGHT THERE IS A CLUNKING NOISE UNDER THE FRONT END OF MY CAR. I TYPICALLY BACK INTO A PARKING SPACE AND WHEN I AM LINING UP MY CAR TO BACK IN IS MOSTLY WHEN THE NOISE OCCURS. IT IS A LOUD SOUND THAT ALMOST SOUNDS LIKE A POPPING OR SNAPPING. IT DOES NOT MATTER THE TEMPERATURE OUTSIDE, NOR DOES IT MATTER WHETHER IT IS DRY OR WET. IT ISN'T HAPPENING EVERY TIME EITHER. IT IS FRIGHTENING, THOUGH, BECAUSE I HAD A TIE ROD SNAP ON A CAR ONE TIME AND IT ALWAYS MAKES ME THINK OF THAT. I DID TAKE IT TO A FORD GA… Look up ODI 11312000 at NHTSA ↗ |
|---|
| Engine | 3619.9%ODI 10462207 · 35,000 miTL* THE CONTACT OWNS A 2009 FORD FLEX. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20 MPH, THE ENGINE STALLED WITHOUT THE ILLUMINATION OF WARNING INDICATORS ON THE INSTRUMENT PANEL. THE ENGINE RESTARTED AND THE VEHICLE RESUMED AS NORMAL. THE FAILURE OCCURRED FOUR TIMES WHEN DRIVING AT A LOW SPEED. THE CONTACT WAS IN THE PROCESS OF TAKING THE VEHICLE TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 35,000. Look up ODI 10462207 at NHTSA ↗ | 3021.6%ODI 10458332 · 23,500 miVEHICLE BOGS DOWN DURING ACCELERATION. NO TROUBLE CODES SHOWN. NOT SPEED SPECIFIC. MPG HAS DROPPED SIGNIFICANTLY, FROM 24 HIGHWAY MPG, TO 14 HIGHWAY MPG. JUST HAD TRANSFER CASE REPLACED. FEELS AS IF THE VEHICLE IS FIGHTING ITSELF AGAIN. *JS Look up ODI 10458332 at NHTSA ↗ | 2517.4%ODI 10564768 · 10,000 miOUR 2011 FORD FLEX WE BOUGHT "NEW" IN OCTOBER OF 2010. IT HAS ALL THE BELLS & WHISTLES & HAD A STICKER PRICE OF ALMOST $51,000 DOLLARS! THIS CAR DOESN'T LIKE TO GET WET! IT STALLS IN THE SNOW, RAIN, CAR WASH & EVEN PUDDLES! IT JUST "SHUTS DOWN" IN THE MIDDLE OF AN INTERSECTION.....IT WILL "PUTT PUTT" & ALMOST STALL ON HIGHWAYS. WE CAME SOOO CLOSE TO GETTING KILLED! UGH....WE HAVE TAKEN THIS CAR IN TO (METRO FORD IN RAYNHAM) AT LEAST "4" TIMES. THE LAST TIME WAS JUST A COUPLE OF MONTHS AGO & IT WAS THERE FOR "4 WEEKS"! THEN THIS WAS IT.........… Look up ODI 10564768 at NHTSA ↗ | 1117.2%ODI 10482817 · 5,020 miFIRST INCIDENT HAPPENED WHILE DRIVING ABOUT 40 MILES AN HOUR. IDIOT LIGHTS CAME ON THE DASH AND THE CARS ENGINE TURNED OFF. THANKFULLY I WAS ABLE TO GET CAR OFF TO THE SIDE OF ROAD. CAR CRANKED RIGHT BACK UP. 5 DAYS LATER WHILE SITTING IN A FAST FOOD LINE, SAME THING HAPPENED AND WAS ABLE TO CRANK CAR. CALLED DEALERSHIP IN TOWN, BROUGHT CAR IN AND THEY SAID, "NOTHING IS WRONG WITH YOUR CAR, COME AND GET IT" PICKED UP CAR. 2 DAYS LATER WHILE DRIVING IT DOWN OUR STREET, I STOPPED TO GET MAIL ABOUT 9PM AND THE CAR TOTALLY DIED. NO POWER AT ALL. WA… Look up ODI 10482817 at NHTSA ↗ | 335.7%ODI 10547329 · 2,080 miWHILE TRAVELING AT 55 MPH, ON CRUISE CONTROL, THE ENGINE BEGAN TO KNOCK AND THEN THE CAR LURCHED FORWARD TWICE AND BEGAN TO SHAKE PRETTY BAD. I PULLED OFF THE ROAD AND CALLED THE DEALERSHIP. AFTER HOLDING UP THE CELL PHONE TO THE ENGINE, I WAS TOLD TO "TURN THAT ENGINE OFF NOW!". THE CAR WAS TOWED TO THE DEALERSHIP AND I WAS LATER TOLD THERE WAS A CATASTROPHIC ENGINE FAILURE DUE TO AN CYLINDER WITHIN THE INTERNAL PISTON THAT BROKE FREE AND PUT A WHOLE IN THE ENGINE BLOCK, REQUIRING THE ENGINE TO BE REPLACED. THE SERVICE MANAGER GAVE ME THE MANG… Look up ODI 10547329 at NHTSA ↗ | 228.8%ODI 10669446 · 34,304 miI WAS TRAVELING 70 MPH ON A TOLL WAY IN BUSY MORNING TRAFFIC. WITHOUT ANY WARNING THE VEHICLE LOST ENGINE POWER. PRESSING THE GAS GAVE NO ACCELERATION AND NO POWER TO MOVE THE CAR. THANKFULLY I WAS IN THE LEFT LANE AND HAD ENOUGH MOMENTUM TO GET TO THE LEFT SHOULDER. AT THIS POINT A WRENCH LIGHT CAME ON SAYING CHECK MANUAL. THE CAR WAS UNDER NO POWER OF ITS OWN IN 70 MPH TRAFFIC. VERY DANGEROUS! SAT ON THE LEFT SHOULD OF THE SPEEDING TOLL ROAD UNTIL A TOW TRUCK ARRIVED AND TOOK IT TO THE NEAREST DEALERSHIP. THEY RAN DIAGNOSTICS AND WERE VERY SU… Look up ODI 10669446 at NHTSA ↗ | 1110.0%ODI 10881799 · 12,752 miREGARDING NHTSA COMPLAINT NO. 10876758. HAD THE CAR AT THE DEALERSHIP THIS MORNING AND NOTHING WAS FOUND. THEY THINK IT IS THE THROTTLE BODY BUT CAN'T REPAIR IT WITHOUT AUTHORIZATION FROM FORD MOTOR COMPANY. SERVICE WRITER SAID HE WOULD CALL ME IF AND WHEN HE GOT AUTHORIZATION (NO IDEA WHEN THAT MIGHT BE). NO OFFER WAS MADE TO LEAVE CAR UNTIL REPAIRS WERE MADE AND REPLACE WITH A LOANER. I DROVE THE CAR BACK HOME APPROXIMATELY 25 MILES ONE WAY. THIS AFTERNOON I DROVE IT TO THE GROCERY STORE WITH MY WIFE RIDING ALONG AND UPON RETURNING HOME I WAS… Look up ODI 10881799 at NHTSA ↗ | 88.2%ODI 11154082 · 32,000 mi"TAKATA RECALL" MY ENGINE LIGHT WENT ON 2000 MILES BEFORE MY MANUFACTURES WARRANTY EXPIRED. I HAVE A FORD SHOP HERE, BUT THEY ARE RATED SO LOW AND I HEAR NOTHING BUT BAD STUFF ABOUT THEM, SO I CALLED THE NEXT CLOSEST 95 MILES AWAY IN SPEARFISH, SD. I EXPLAINED TO THE GUY WHAT CODE THE ENGINE THREW, BUT MY LIGHT IS NOW OFF. HE SAID NOT TO COME IN, UNTIL MY ENGINE LIGHT CAME BACK ON. MEANWHILE MY ENGINE STILL HISSES AND THE EXHAUST ODOR IS SO STRONG INSIDE AND OUTSIDE OF THE VEHICLE. I HAVE 36,879 MILES ON MY 2016 AND EITHER HAVE AN EXHAUST LE… Look up ODI 11154082 at NHTSA ↗ | 12.4%ODI 11731995I am submitting this complaint to report a serious and potentially dangerous safety defect involving the internal water pump design in the 3.5L Duratec V6 engine used in my 2017 Ford Flex. The water pump in this engine is mounted internally behind the timing chain cover. When the pump fails, coolant is not externally visible but instead leaks directly into the engine oil. This design prevents early detection and warning, leading to rapid and catastrophic engine failure without adequate notice to the driver. In my case, the water pump failed s… Look up ODI 11731995 at NHTSA ↗ | 11.5%ODI 11740471An antifreeze leak is very hard to locate because Ford’s design placed the water pump INside the engine rather than on the OUTside, which would be more the norm. If antifreeze leaks enough, it gets into the oil and the entire engine stands to be destroyed. Our heater quit blowing warm air recently and after intently searching we discovered that we had an antifreeze leak inside of our engine, and antifreeze was slowly leaking out through a weephole in the engine. The water pump had gone bad and needed replacing. The hours required to replace th… Look up ODI 11740471 at NHTSA ↗ | 52.0%ODI 11657792The water pump and timing cover gaskets are faulty. The water pump is internal and causes major engine malfunction when it breaks. Look up ODI 11657792 at NHTSA ↗ |
|---|
| Back Over Prevention | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 20.3%ODI 11503136 · 85,000 miThe contact owns a 2013 Ford Flex. The contact stated that the rear-view camera image was displayed inverted on the infotainment screen. Upon investigation, the contact discovered that there were recalls on other Ford model vehicles for the same failure; however, the VIN was not included. The contact called the dealer and the manufacturer and was informed that there were no recalls on the VIN regarding the failure. The vehicle was not repaired. The failure mileage was approximately 85,000. Look up ODI 11503136 at NHTSA ↗ | 31.2%ODI 11670878 · 122,000 miThe contact owns a 2014 Ford Flex. The contact stated while driving and attempting to reverse, the rear-view camera image was upside down or occasionally there was a blank screen. There was no warning light illuminated. A dealer was contacted. The vehicle was not taken to a dealer or an independent mechanic to be diagnosed or repaired. The contact related the failure to NHTSA Campaign Number: 25V442000 (BACK OVER PREVENTION); however, the VIN was not included in the recall. The manufacturer was not notified of the failure. The contact was refer… Look up ODI 11670878 at NHTSA ↗ | 2825.5%ODI 11633700 · 40,000 miThe contact owns a 2015 Ford Flex. The contact stated that while the vehicle was shifted into reverse, the back-over prevention camera screen image displayed an unknown service error message, showed an upside-down image, and displayed a blacked-out image occasionally. No warning light was illuminated. The vehicle was taken to a local dealer; however, the vehicle was not diagnosed or repaired due to the costs. Upon further investigation, the contact related the failure to NHTSA Campaign Number: 24V951000 (Back Over Prevention); however, the VIN … Look up ODI 11633700 at NHTSA ↗ | 1818.4%ODI 11617857 · 25,000 miThe contact owns a 2016 Ford Flex. The contact stated that the back-over prevention camera was inoperable. The message that the camera was unavailable was displayed on the screen. There were no warning lights illuminated. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 25,000. Look up ODI 11617857 at NHTSA ↗ | 614.3%ODI 11716950 · 60,000 miThe contact owns a 2017 Ford Flex. The contact stated that months after a routine service appointment with a local dealer, the rear-view camera failed to operate as designed. The contact received notification of NHTSA Campaign Number: 25V695000 (Back Over Prevention). The dealer and the manufacturer were contacted, and the contact was informed that the part for the recall repair was not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The failure mileage was approximately 60,000… Look up ODI 11716950 at NHTSA ↗ | 1116.4%ODI 11675869The contact owns a 2018 Ford Flex. The contact stated that the back-over prevention camera frequently failed to operate as needed. The contact stated that the camera displayed a blank or distorted image while the vehicle was shifted into reverse(R). In addition, the back over prevention camera screen remained displayed while the vehicle was in drive(D). The dealer was notified of the failure and the contact was informed that there were no recalls on the vehicle. The manufacturer was notified of the failure and the contact was provided the same … Look up ODI 11675869 at NHTSA ↗ | 11144.6%ODI 11504724 · 30,000 miThe contact owns a 2019 Ford Flex. The contact stated that the rear-view camera failed to operate as needed. The contact had taken the vehicle to a dealer where she was given an estimate for the repair. The manufacturer was notified of the failure and agreed to cover only half of the cost of a replacement camera. The contact stated that parts for the repair were ordered; however, the parts for the repair remained on backorder. The vehicle was not repaired. The failure mileage was approximately 30,000. Look up ODI 11504724 at NHTSA ↗ |
|---|
| Fuel/Propulsion System | 158.3%ODI 10510850 · 56,260 miCHECK ENGINE LIGHT WENT ON AND WHEN DIAGNOSED IT WAS ONE OF THE OXYGEN SENSORS. IT HAD TO BE REPLACED IN ORDER FOR THE REST OF THE SAFETIES TO OPERATE PROPERLY. IT WAS A DEFECTIVE PART THAT COST OVER $400 TO REPLACE. WARRANTY WAS DECLINED, HOWEVER, THE DESIGN LIFE OF THE PART MUST BE IN EXCESS OF 150000 MILES. IF THIS PART WERE FAILING ALL THE TIME, THERE WOULD BE A RECALL. MY DEFECTIVE PART WAS NOT REPLACED BY FORD AS IT SHOULD HAVE BEEN. THERE ARE NO MOVING PARTS, IT SHOULD NOT WEAR OUT. *TR Look up ODI 10510850 at NHTSA ↗ | 128.6%ODI 10550357 · 66,000 miTL* THE CONTACT OWNS A 2010 FORD FLEX. THE CONTACT ATTEMPTED TO FILL THE FUEL TANK WHEN HE OVERFLOW VALVE FAILED. THE CONTACT ALSO MENTIONED THAT SPORADICALLY, THE VALVE WOULD NOT ALLOW THE FUEL TANK TO BE FILLED TO CAPACITY AND WHEN ATTEMTPING TO FILL THE TANK, IT WOULD OFTEN TAKE APPROXIMATLEY 30 MINUTES TO FILL. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE TECHNICIAN STATED THAT THE FUEL TANK NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 66,000. Look up ODI 10550357 at NHTSA ↗ | 53.5%ODI 10734655 · 89,300 miUPON ACCELERATION, USUALLY FROM A COMPLETE STOP SUCH AS ACCELERATING FROM A STOP SIGN OR ON A GREEN LIGHT, IT FEELS AS THOUGH THE GEARS DO NO CATCH & THE CAR JERKS AND THE RPM'S RAISE BUT THE CAR STOPS ACCELERATING. WILL ALSO HAVE A "STUTTERING" OR "JERKING" WHILE AT A COMPLETE STOP WITH BREAK PEDAL BEING PRESSED DOWN. I HAVE TAKEN THIS ISSUE TO THE DEALERSHIP AS IT IS STILL UNDER EXTENDED WARRANTY AND HAVE BEEN TOLD THAT EVERYTHING CHECKED OUT NORMAL & THE MECHANIC AT THE DEALERSHIP WAS UNABLE TO GET THE VEHICLE TO HAVE SUCH DESCRIBED MALFUN… Look up ODI 10734655 at NHTSA ↗ | 57.8%ODI 10897143 · 42,000 miFUEL GAUGE WILL ONLY REGISTER 1/2 FULL MAX. WHEN TANK IS FULL AND KEY TURNED ON THE GAUGE WILL INITIALLY GO TO FULL, THEN QUICKLY FALL TO 1/2 WITH A CORRESPONDING DISTANCE TO EMPTY READING. Look up ODI 10897143 at NHTSA ↗ | 5910.2%ODI 10531792 · 50 miNEW 2013 FORD FLEX HAS CARBON MONOXIDE LEAKING INTO CAR WHEN YOU ACCELERATE. DEALERSHIP AND FORD KNOW OF THIS. COULD POTENTIALY BE DEADLY. *TR Look up ODI 10531792 at NHTSA ↗ | 4618.5%ODI 10908523 · 14,539 miTL* THE CONTACT OWNS A 2014 FORD FLEX. WHILE ATTEMPTING TO START THE VEHICLE, IT FAILED TO START. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP DRIVER MODULE FAILED. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 14,539. Look up ODI 10908523 at NHTSA ↗ | 1816.4%ODI 10762895 · 2,983 miI WAS ENTERING AT CARPOOL LANES WHEN A DEBRIS HIT THE UNDERBODY OF THE VEHICLE, I JUST HEARD A BIG HIT UNDERBODY AND CONTINUE DRIVING AFTER TWO MILES ANOTHER DRIVER NOTICE FLUIDS WERE DRAINING FROM THE BOTTOM OF THE VEHICLE AND URGE ME TO CHECK WHEN I STOPPED I FIND OUT THE DEBRIS HAD MAKE A HEAVY DAMAGE TO THE GAS TANK AND GASOLINE WAS IN EFECT DRAINING FAST. I STOPPED AND TURN OFF THE ENGINE AND A FRIEND OF MINE HELP ME TAKE THE DAMAGE VEHICLE TO MY HOUSE WHERE THE THE REST OF THE GASOLINE DRAIN OUT. I PUT SAND INTO THE DRAIN GASOLINE AND TRY… Look up ODI 10762895 at NHTSA ↗ | 33.1%ODI 11153753 · 29,000 miGAS SMELL AND ELECTRONIC ISSUES. I BOUGHT MY VEHICLE BRAND NEW. I FIRST NOTICED SMELLING GASOLINE AFTER THE FIRST OIL CHANGE, SO I HAD DRIVEN SEVERAL MONTHS.THE DEALERSHIP BLAMED IT ON MY UNDERCOATING STATING THAT'S WHAT I'M SMELLING.IT'S GAS DEFINITELY.I ASKED THEM TO DRIVE IT A WEEK SINCE THE SMELL COMES AND GOES.THEY REFUSED.IT STILL DOES IT AND I HAVE GIVEN UP TRYING TO GET THE DEALERSHIP TO FIND THE ISSUE.THEY DID STATE THE FLEX IS THE SAME BASE AS THE POLICE VEHICLE THAT HAS THE GAS EMISSION LEAK.2ND PROBLEM IS "NO KEY DETECTED" LIGHT COM… Look up ODI 11153753 at NHTSA ↗ | 00.0%No examples available for this selection. | 23.0%ODI 11111043 · 55,054 miENGINE STOPPED WHILE DRIVING IN WALMART PARKING LOOT. WOULD NOT START. TOWED TO GARAGE WHO TRACED THE CAUSE TO. FUEL PUMP CONTROL MODULE. THERE IS AN EXISTING RECAL FOR THIS PROBLEM FROM 2013 TO 2014 FORD FLEX HOWEVER MY VIN SHOWS AS NOT COVERED. WHATEVER CRITERIA TO LIMIT RECALL APPEARS TO BE INVALID Look up ODI 11111043 at NHTSA ↗ | 00.0%No examples available for this selection. |
|---|
| Structure:Body | 63.3%ODI 10510002OUR FLEX WAS PREVIOUSLY USED, BUT PURCHASED THROUGH A FORD DEALERSHIP. AFTER OWNING IT FOR ABOUT ONE MONTH, THE 2ND ROW GLASS ROOF CRACKED ON BOTH SIDES. WE INFORMED THE DEALERSHIP, AND WE WERE TOLD THE THERE WAS A RECALL ALREADY IN THE WORKS FOR THE FLEXS THAT HAD 2ND AND 3RD ROW GLASS CEILING PANELS. THE GLASS IS NOT CRACKED ON THE INSIDE OR ON THE OUTSIDE.....SO IT APPEARS THAT THERE ARE 3 PANES OF GLASS. AFTER WAITING AND WAITING, WE HAVE NOW NOTICED THAT THE 3RD ROW HAS CRACKED AS WELL. NO ONE HAS SEEN OR HEARD IT HAPPEN, BUT BECAU… Look up ODI 10510002 at NHTSA ↗ | 21.4%ODI 10524016 · 93,818 miWE WERE INVOLVED IN AN ACCIDENT WHERE A JEEP WAS THROWN INTO THE FRONT OF OUR VEHICLE BY A FORD F-150, TOTALING OUR VEHICLE, AND OUR AIRBAGS DID NOT DEPLOY, NONE OF THEM. WE WERE AT A STOP SIGN AND ALL WALKED AWAY FROM THE ACCIDENT, BUT THE POLICE, FIRE DEPARTMENT, AND INSURANCE ADJUSTER ALL SAID SOMETHING WAS WRONG FOR THE METAL IBEAM BEHIND THE BUMPER TO BE CRUSHED INTO THE RADIATOR AND FOR OUR AIRBAGS TO NOT DEPLOY. THE INSURANCE ADJUSTER HAD ALREADY DEEMED OUR FLEX AS A TOTAL LOSS BUT MENTIONED THAT HAD WE REPAIRED THE VEHICLE WE WOULD NE… Look up ODI 10524016 at NHTSA ↗ | 32.1%ODI 10695149 · 52,000 miMY WIFE WAS DRIVING DOWN THE INTERSTATE YESTERDAY, WHEN THE REAR PASSENGER DOOR WINDOW SHATTERED INTO PIECES FOR APPARENTLY NO REASON. THANKFULLY NO ONE WAS INJURED. BASED ON INFORMATION FOUND ON THE INTERNET, THIS HAS HAPPENED WITH OTHER FORD MODELS AND YEARS AS WELL. I HAVE SEEN WHERE NHTSA HAS INVESTIGATED THIS SIMILAR ISSUE WITH 2010-2011 FORD ESCAPE AND MERCURY MARINER, BUT HAVE NOT BEEN ABLE TO FIND THE RESULTS OF THE INVESTIGATION. CARCOMPLAINTS.COM SHOWS 3 COMPLAINTS ABOUT THE SAME ISSUE WITH THE FORD FLEX. *TR Look up ODI 10695149 at NHTSA ↗ | 34.7%ODI 10494420 · 14,000 miTL* THE CONTACT OWNS A 2012 FORD FLEX. THE CONTACT ENTERED THE FRONT PASSENGER'S SIDE DOOR AND HER LEG WAS SEVERELY PUNCTURED BY A SHARP CORNER ON THE SEAT BRACKET. THE CONTACT SUSTAINED A DEEP LACERATION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO COVERED THE POINTED CORNER AREA OF THE SEAT BRACKET. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 14,000. Look up ODI 10494420 at NHTSA ↗ | 5810.0%ODI 10552923 · 36,300 miI WAS TURNING A CORNER AND SOMETHING POPPED AND THE CAR WOULD NOT STEER. THE ONLY THING THAT STOPPED THE CAR WAS THE CURVE, AS I WAS MAKING THE TURN, AND THAT CAUSED A LOT OF DAMAGE. SUTTON FORD LINCOLN IN MATTESON, IL SAID THEY WOULD NOT REPAIR THE DAMAGES CAUSED BY THE LEMON-FORD-FLEX THAT WAS SOLD TO ME BECAUSE THE VEHICLE WAS 300 MILES OUT OF THE WARRANTY. SUTTON FORD LINCOLN IN MATTESON, IL THAN SAID IT WOULD HAVE TO BE REPORTED TO INSURANCE. SO I REPORTED IT TO INSURANCE AND THE REPAIR SHOP, THAT WAS REPAIRING THE DAMAGES, SAID THEY F… Look up ODI 10552923 at NHTSA ↗ | 93.6%ODI 10904977 · 50,000 miOUR 2014 FORD FLEX INDICATES PASSENGER DOOR AJAR (RIGHT FRONT DOOR) ON THE INSTRUMENT PANEL, EVEN THOUGH THE DOOR APPEARS PROPERLY CLOSED. REPEATED ATTEMPTS (UP TO 50 OR MORE) ARE REQUIRED TO GET THE DOOR TO CLOSE WITH THE INDICATOR LIGHT TURNING OFF. ONCE THE DOOR IS CLOSED PROPERLY, WITH THE INDICATOR LIGHT OFF, THE DOOR AJAR LIGHT MAY TURN ON AGAIN WHILE THE CAR IS OFF AND NOT MOVING, CAUSING THE ALARM TO SOUND. IN ADDITION, WHILE DRIVING, THE PASSENGER DOOR AJAR LIGHT MAY SUDDENLY TURN ON, CAUSING THE NEED TO PULL OVER TO INSURE THE DOOR… Look up ODI 10904977 at NHTSA ↗ | 10.9%ODI 11302861 · 102,000 miDOOR LATCH FAILURE. NOTICED PROBLEM WITH DOOR AJAR LIGHT LIT FOR A COUPLE DAYS. SUBSEQUENT BATTERY DRAINING PROBLEMS. SEEMS DUE TO KEEPING LIGHTS ON IN CAR BECAUSE IT THOUGHT DOORS WERE OPEN EVEN THOUGH THEY WERE SECURELY SHUT. WITHIN COUPLE DAYS FRONT DOORS WERE TOTALLY INOPERABLE. COULD NOT OPEN FROM INSIDE OR OUT OF CAR. REQUIRED ENTRY FROM REAR SEAT. THEN UPON DRIVING TO DEALER FOR DIAGNOSIS THE DOOR AJAR LIGHT LIT UP AND RELEASED THE DOOR LATCHES SO THAT BOTH OF THE DOORS ATTEMPTED TO OPEN WHILE DRIVING AT HIGHWAY SPEED. THIS CONDITION HAP… Look up ODI 11302861 at NHTSA ↗ | 66.1%ODI 11391013 · 62,155 miREAR PARK ASSIST CAMERA DOES NOT ACTIVATE WHEN IN REVERSE. READ PASSENGER DOOR LOCK PAWL FRACTURE-NHTSA RECALL. FORD REFUSES TO REPAIR THE RECALL BECAUSE THEY DID NOT ISSUE THE RECALL. THIS DOOR HAS A FRACTURED PAWL LOCK/LATCH ON THE REAR PASSENGER DOOR. CAR DOES NOT DETECT KEY. WE PAID ADDITIONAL FOR FOB ANNUAL REPLACEMENTS, FORD REFUSES TO REPLACE THE FOBS EVEN WHEN ITS FAULTY. I RECORDED THIS CALL...AND EVERY OTHER CALL. Look up ODI 11391013 at NHTSA ↗ | 00.0%No examples available for this selection. | 710.4%ODI 11128307 · 2,500 miWHEN THE VEHICLES FRONT LEFT AND RIGHT TIRES ARE RETRACTED INTO THE WHEEL WELL, FOR EXAMPLE WHEN GOING OVER A SPEED BUMP OR CURB TOO FAST, THERE IS A SHARP PIECE OF METAL THAT STICKS OUT OF THE BODY WHERE THE PLASTIC COWLING AND THE FENDER MEET. I'VE HAD TO REPLACE TWO TIRES SO FAR ON THE FRONT RIGHT WHEEL BECAUSE OF THIS METAL PIECE THAT STICKS OUT. IN BOTH INSTANCES THE VEHICLE WAS DOING ABOUT 5 MILES AN HOUR TURNING INTO A DRIVEWAY. Look up ODI 11128307 at NHTSA ↗ | 166.4%ODI 11577178The keyless entry keypad - driver sides B-Pillar front door’s trim panel came loose while driving on I-95 today (approximately 70 mph). It was not apparently loose before this event. It dislodged and hit the rear passenger window. This is a safety issue because, were the window down, it would have hit a child passenger. Additionally, with the force that was exerted on the window, breaking the glass was definitely a possibility. Lastly, it was very startling to the driver. The dealership did confirm this issue. They provided a TSB - TSB20-24… Look up ODI 11577178 at NHTSA ↗ |
|---|
| Suspension | 84.4%ODI 10560400 · 35,000 miPURCHASED FLEX IN 2009, DAY 1, 5 MILES, STATION WAGON HAS VIBRATION. TO THIS DAY, STILL HAS VIBRATION. 58000 MILES NOW. BBBAUTOLINE SAYS IT'S OUT OF COVERAGE FOR ARBITRATION. FLEX WAS IN SHOP MIN 12X FOR SAME ISSUE. DEALER AND ENGINEERS SAID BAD BRAKES, THE HAVE PUT ON 5 SETS OF PADS AND ROTORS. BAD WHEELS, MINE WERE THE 17" STYLE, NOW I HAVE 19" LIMITED WHEELS, VERY EXPENSIVE TIRES. STILL VIBRATES.... ONE 3 DAY SERVICE STOP AT VARSITY FORD , A@$$$$@ TECH OR MECHANIC DROVE MILES TO THE TUNE OF 750!!!!! AND I WASN'T SUPPOSED TO BE UPSET...… Look up ODI 10560400 at NHTSA ↗ | 53.6%ODI 11404647 · 351,000 miTL* THE CONTACT OWNS A 2010 FORD FLEX. THE CONTACT STATED WHILE DRIVING 35 MPH, THE PASSENGER'S SIDE REAR TIRE WAS DRIFTING TO THE RIGHT INDEPENDENTLY CAUSING THE CONTACT TO LOSE CONTROL OF THE VEHICLE. THE CONTACT REGAINED CONTROL OF THE VEHICLE AND PULLED TO THE SIDE OF THE ROADWAY. THE CONTACT HAD THE VEHICLE TOWED TO BILL KNIGHT FORD (9607 S. MEMORIAL DR, TULSA, OK 74133) WHO INSPECTED THE VEHICLE AND DIAGNOSED THAT THE REAR TOE LINK WAS FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF TH… Look up ODI 11404647 at NHTSA ↗ | 21.4%ODI 11054476 · 73,500 miTL* THE CONTACT OWNS A 2011 FORD FLEX. THE CONTACT STATED THAT THERE WAS UNEVEN TIRE TREAD WEAR TO THE TIRES. THE CONTACT STATED THAT THE SET OF TIRES WERE REPLACED TWICE. THE CONTACT STATED THAT THE FAILURE WAS DUE TO A MECHANICAL DESIGN OF THE VEHICLE'S SUSPENSION SYSTEM, WHICH CAUSED THE UNEVEN WEAR OF THE TIRES. THE CONTACT STATED THAT THE SUSPENSION SYSTEM WAS POORLY DESIGNED THAT IT WAS IMPOSSIBLE FOR THE TIRES TO REMAIN BALANCED OR ALIGNED. THE VEHICLE WAS TAKEN TO TOM HOLZER FORD DEALER LOCATED AT: 39300 W 10 MILE RD, FARMINGTON HILLS, … Look up ODI 11054476 at NHTSA ↗ | 34.7%ODI 11407044 · 102,407 miMY VEHICLE WAS MANUFACTURED JUST A FEW MONTHS SHY OF A RECALL FOR BAD TOE LINKS IN THIS MAKE AND MODEL. I HAVE HAD MY CAR DIAGNOSED WITH HAVING BAD TOE LINKS AND WOULD LIKE TO SEE ABOUT GETTING MY VEHICLE INCLUDED IN THE RECALL SINCE IT WAS MANUFACTURED AROUND THE SAME TIME AS THE VEHICLES INCLUDED IN THE RECALL. Look up ODI 11407044 at NHTSA ↗ | 172.9%ODI 10552923 · 36,300 miI WAS TURNING A CORNER AND SOMETHING POPPED AND THE CAR WOULD NOT STEER. THE ONLY THING THAT STOPPED THE CAR WAS THE CURVE, AS I WAS MAKING THE TURN, AND THAT CAUSED A LOT OF DAMAGE. SUTTON FORD LINCOLN IN MATTESON, IL SAID THEY WOULD NOT REPAIR THE DAMAGES CAUSED BY THE LEMON-FORD-FLEX THAT WAS SOLD TO ME BECAUSE THE VEHICLE WAS 300 MILES OUT OF THE WARRANTY. SUTTON FORD LINCOLN IN MATTESON, IL THAN SAID IT WOULD HAVE TO BE REPORTED TO INSURANCE. SO I REPORTED IT TO INSURANCE AND THE REPAIR SHOP, THAT WAS REPAIRING THE DAMAGES, SAID THEY F… Look up ODI 10552923 at NHTSA ↗ | 2510.0%ODI 10679123 · 22,000 miTL*THE CONTACT OWNS A 2014 FORD FLEX. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 40 MPH, THE VEHICLE IMPACTED THE CURB AND STARTED TO JERK UNCONTROLLABLY. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT THE AXLE FRACTURED AND THE FRONT PASSENGER TIRE DETACHED FROM THE VEHICLE. THE AIRBAGS FAILED TO DEPLOY. THE CONTACT DID NOT SUSTAIN ANY INJURIES AND MEDICAL ATTENTION WAS NOT REQUIRED. A POLICE REPORT WAS FILED. THE VEHICLE WAS NOT DIAGNOSED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE MILEAGE WAS 2… Look up ODI 10679123 at NHTSA ↗ | 76.4%ODI 11288237 · 69,200 miI WAS DRIVING MY 2015 FORD FLEX AND I MADE A RIGHT TURN GOING LESS THAN 5MPH. ONCE I STRAIGHTENED OUT MY STEERING WHEEL, ALL WITHIN 2 SECONDS, I SUDDENLY HEARD A GRINDING NOISE THEN MY REAR TIRE BENT OUTWARD AT AN ANGLE. I WAS TOLD BY THE REPAIR SHOP THAT IF I WAS GOING AT LEAST 25MPH, THE WHOLE TIRE WOULD OF FLOWN OUT AND CAUSED WORSE INJURY. THE REPAIR SHOP INFORMED ME THAT THE REAR LEFT TOE LINK IS GOING BAD AS WELL AND IT LOOKS LIKE THIS IS POSSIBLY BE A DEFECTED PART FORD IS USING. FORD IS REFUSING TO HELP OR CARE ABOUT THIS PROBLEM. THERE… Look up ODI 11288237 at NHTSA ↗ | 1010.2%ODI 11253487 · 47,000 miTL* THE CONTACT OWNS A 2016 FORD FLEX. WHILE DRIVING APPROXIMATELY 60 MPH OVER A BUMP IN THE ROAD, A SQUEAKY NOISE WAS HEARD WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AIRPORT MARINA FORD [phone removed], LOCATED AT 6701 CENTER DR W, STE 925, LOS ANGELES, CA 90045) WHERE IT WAS DIAGNOSED THAT THE STRUT MOUNT FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE PART. ALSO, WHILE BACKING OUT OF A PARKING SPACE AND ATTEMPTING TO TURN THE STEERING WHEEL, IT WAS NOTICED THAT THE WHEEL WAS BENT. THE VEHIC… Look up ODI 11253487 at NHTSA ↗ | 1331.0%ODI 11324447 · 70,000 miTL* THE CONTACT OWNS A 2017 FORD FLEX. THE CONTACT STATED THAT WHILE TRAVELING AT 45 MPH, SHE DEPRESSED THE BRAKE PEDAL AS SHE HEARD APPROACHING POLICE SIRENS. AS THE CONTACT CAME TO A COMPLETE STOP, SHE WAS HIT FROM BEHIND BY ANOTHER VEHICLE AND WAS THRUST INTO THE MIDDLE OF AN INTERSECTION. THE AIR BAGS DID NOT DEPLOY UPON IMPACT. THE CONTACT AND HER DAUGHTER SOUGHT MEDICAL ATTENTION AT THE SCENE. THE NEXT DAY, THE CONTACT WENT TO AN URGENT CARE FACILITY WHERE SHE SOUGHT TREATMENT FOR INJURIES TO HER NECK, HER LEFT ARM AND HER BACK. THE CONTA… Look up ODI 11324447 at NHTSA ↗ | 913.4%ODI 11427935On 7-28-21, the Right Rear Toe Link Broke while I was driving, the wheel was sticking out and could not be driven. I have the old broken part and loose part. On 7-30-21, I had the broken part on right rear replaced and the Left rear part was loose and replaced also. As far as safety goes, it had to be towed to shop to get off the road, and could not drive. On 6-17-21, I took my car to Tom Holzer Ford in Farmington Hills, MI, to be inspected, because I was hearing a clunking noise on the right back side of the vehicle. After the serviceman… Look up ODI 11427935 at NHTSA ↗ | 62.4%ODI 11451582 · 39,150 miThe contact owns a 2019 Ford Flex. The contact stated that while driving approximately 40 MPH, the steering wheel suddenly jerked to the left causing the vehicle to fishtail and cross the median line. After regaining control of the steering, the driver was able to safely park on the side of the road. While inspecting the vehicle, it was discovered that the rear driver’s side wheel was angled outward and out of position. The vehicle was towed to the local dealer was diagnosed that the rear toe link had failed and needed to be replaced. The vehic… Look up ODI 11451582 at NHTSA ↗ |
|---|